锁掷酵母预处理油脂原料膨化大豆

通过3株红酵母对膨化大豆进行固态发酵预处理,油脂和豆粕中类胡萝卜素的含量都显著增加,且油脂中脂肪酸组成没有显著变化.其中,锁掷酵母发酵膨化大豆所提取的油脂中类胡萝卜素含量最高,为15.010 μg/g,比未发酵样品提高了5.526倍.进一步对锁掷酵母固态发酵进行工艺优化,培养时间、培养基含水量、接种量和发酵温度均显著影...     

溶氧对L-苏氨酸发酵的影响

探索溶氧对L-苏氨酸发酵过程的影响及其控制方法。通过摇瓶装液量试验、不同溶氧控制方式考察发酵过程中溶氧对L-苏氨酸合成的影响。采用补料分批发酵工艺发酵L-苏氨酸,利用氨基酸分析仪测定发酵液中L-苏氨酸的产量,通过10L罐补料分批发酵36h,产酸可达118.9g/L,糖酸转化率为47.6%。可以得出溶氧对L-苏氨酸生物合成有重要影响,并建立了最佳溶氧控制条件。     

氮源对L-苏氨酸发酵的影响

以L-苏氨酸生产菌TRFC为供试菌株,研究了氮源对L-苏氨酸发酵的产量和糖酸转化率的影响。首先通过摇瓶实验确定发酵的最佳无机氮源和有机氮源分别为硫酸铵和酵母粉,进一步利用10L罐补料分批发酵确定硫酸铵和酵母粉的最佳用量,继续优化培养条件,采用发酵中后期流加硫酸铵和糖氨混合补料等措施,L-苏氨酸产量得到进一步的提高。在最优发酵条件下,通过10L罐补料分批发酵36h,产酸可达118.9g/L,糖酸转化率为47.6%。     

一株法夫酵母虾青素高产菌株的生产性能

为了评价虾青素高产菌株-法夫酵母JMU-MVP14的生产性能及建立虾青素高产发酵技术,通过测定糖、生物量、虾青素产量、总类胡萝卜素产量等发酵参数,用摇瓶试验对比了法夫酵母JMU-MVP14和出发菌株的差异,用7 L罐试验对比了pH值调控方式及补料培养基成分对发酵的影响,用1 m3罐试验评估了法夫酵母JMU-MVP14高密度发酵虾青素的产量水平。摇瓶发酵结果表明,法夫酵母JMU-MVP14虾青素及总类胡萝卜素的细胞产率分别达到6.01 mg/g及10.38 mg/g;7 L罐分批发酵试验结果表明,自动流加调     

锁掷酵母油中营养成分的分离和鉴定

【目的】研究一种新来源的微生物油脂的主要组成。【方法】对锁掷酵母(Sporidiobolus pararoseus)油中的主要功能性成分用两次硅胶柱层析进行分离纯化,得到9种物质。对这9种物质用薄板层析法、液相色谱洗脱和质谱法进行定量和定性分析。【结果】这9种物质为角鲨烯、β-胡萝卜素、γ-胡萝卜素、麦角固醇酯、红酵母烯、三甘酯、游离脂肪酸、麦角固醇和红酵母红素。其中麦角固醇的总浓度为3.2 g/kg油,16.7%的麦角固醇以麦角固醇酯的形式存在,角鲨烯的含量为1.25 g/kg油,类胡萝卜素含量为0.4 g/kg油。分析了麦角固醇酯和三甘酯中的脂肪酸组成,锁掷酵母油含有约73%的油酸,它可以作为良好的单不饱和脂肪酸来源。【结论】锁掷酵母油可能成为功能性油脂的来源。     

红酵母COS—5产胡萝卜素条件的研究

研究碳源、氮源和添加剂对红酵母（Rhodotorulasp．）COS－5产胡萝卜素的影响,并通过正交试验优化其产胡萝卜素的培养基组成。结果表明,COS－5产胡萝卜素的适宜培养基：蔗糖50g、蛋白胨5g、酵母膏5g、桔子皮15g、盐酸硫胺素0．002g、定容1L,pH6．0.250mL三角瓶装培养基30mL。在上述条件下28℃振荡培养96h,细胞生物量为27．5mg干重／mL发酵液,胡萝卜素含量达492．7μg／g干重细胞。COS－5胡萝卜素在474．4nm、338．6nm和310．2nm处有     

红酵母类胡萝卜素高产菌株的筛选及其发酵生理学条件研究

从数株红酵母中选出了1株产类胡萝卜素能力较强的红酵母RY－98（生物量,类胡萝卜素含量和产量分别为19．9g/L,334.8ug/g和6．7mg/L);研究了该菌株产类胡萝卜素的最适营养与环境条件,获得了最佳的发酵生理学条件;葡萄糖40g/L,(NH4)2SO4 10g/L,酵母膏3g/L,蕃茄汁2mL/L,花生油0.5mL/L,接种量30mLL初始pH6.0和通气量（培养基装置040ml/250mL:,在此初步优化的培养条件下,红酵母RY－98经72小时摇瓶发酵其生物量,类胡萝卜素含量和产量分别可达26．8g/L,386.9ug/g和10．4mg/L,依次比初筛中提高了34．7％,15．6％,和55．2％。     

羊肚菌液态发酵的研究

通过摇瓶正交试验研究了圆锥羊肚菌液体发酵的条件,选出最佳培养基配方、接种量、培养温度、pH、通气量,培养时间等参数。在此基础上,应用VIRTIS公司生产的2L－自控发酵罐进行了分批发酵,摸索到了羊肚菌液态深层发酵的基本规律,然后分别以淀粉和玉米粉为碳源进行了补料分批发酵,获得其干细胞产量为25．4g／L和27．4g／L,生长速率为0．45g／（L·h）和0．51g／（L·h）,以碳源为基准的产量得率系数（yx／s）为0.72（g／g）和0.75（g／g）等数据。实验结果表明,羊肚菌的液态深层发酵已达到了真菌菌丝液态发酵的正常水平。     

羊肚菌液态发酵的研究*

通过摇瓶正交试验研究了圆锥羊肚菌液体发酵的条件,选出最佳培养基配方、接种量、培养温度、pH、通气量,培养时间等参数。在此基础上,应用VIRTIS公司生产的2L－自控发酵罐进行了分批发酵,摸索到了羊肚菌液态深层发酵的基本规律,然后分别以淀粉和玉米粉为碳源进行了补料分批发酵,获得其干细胞产量为25．4g／L和27．4g／L,生长速率为0．45g／（L·h）和0．51g／（L·h）,以碳源为基准的产量得率系数（yx／s）为0.72（g／g）和0.75（g／g）等数据。实验结果表明,羊肚菌的液态深层发酵已达到了真菌菌丝液态发酵的正常水平。     

粘红酵母发酵生产类胡萝卜素培养条件的优化

目的是通过测定不同条件下类胡萝卜素的产量找出粘红酵母发酵生产类胡萝卜素的最优条件。探讨了不同碳源、氮源对粘红酵母菌体生长和色素形成的影响,并通过正交实验确定了最佳条件组合。实验结果表明,最适发酵培养条件为：蔗糖40g/L、酵母粉20g/L、转速150r/min、装液量30mL/500mL、发酵时间84h。在此条件下,粘红酵母摇瓶发酵的生物量、类胡萝卜素含量及产量分别达15.17g/L、718.6μg/g、10.9mg/L,依次比初始发酵提高了1倍、7.4倍和15.8倍。发酵过程动态分析表明,84h色素产量达最高峰。     

Carotenoids production in different culture conditions by Sporidiobolus pararoseus

Carotenoids produced by Sporidiobolus pararoseus were studied. It was found that biomass was connected with carbon source, temperature, and pH, but carotenoids proportion was seriously influenced by dissolved oxygen and nitrogen source. Different carotenoids could be obtained by using selected optimum conditions. In the end we established the strategies to produce β-carotene or torulene. Fed-batch fermentation in fermentor was used to prove the authenticity of our conclusions. The cell biomass, β-carotene content, and β-carotene proportion could reach 56.32?g/L, 18.92?mg/L and 60.43%, respectively, by using corn steep liquor at 0-5% of dissolved oxygen saturation. β-Carotene content was 271% higher than before this addition. The cell biomass, torulene content, and torulene proportion could reach 62.47?g/L, 31.74?mg/L, and 70.41%, respectively, by using yeast extract at 30-35% of dissolved oxygen saturation. Torulene content was 152% higher than before this addition. The strategy for enhancing specific carotenoid production by selected fermentation conditions may provide an alternative approach to enhance carotenoid production with other strains.     

CAROTENOIDS PRODUCTION IN DIFFERENT CULTURE CONDITIONS BY Sporidiobolus pararoseus

Carotenoids produced by Sporidiobolus pararoseus were studied. It was found that biomass was connected with carbon source, temperature, and pH, but carotenoids proportion was seriously influenced by dissolved oxygen and nitrogen source. Different carotenoids could be obtained by using selected optimum conditions. In the end we established the strategies to produce β-carotene or torulene. Fed-batch fermentation in fermentor was used to prove the authenticity of our conclusions. The cell biomass, β-carotene content, and β-carotene proportion could reach 56.32 g/L, 18.92 mg/L and 60.43%, respectively, by using corn steep liquor at 0–5% of dissolved oxygen saturation. β-Carotene content was 271% higher than before this addition. The cell biomass, torulene content, and torulene proportion could reach 62.47 g/L, 31.74 mg/L, and 70.41%, respectively, by using yeast extract at 30–35% of dissolved oxygen saturation. Torulene content was 152% higher than before this addition. The strategy for enhancing specific carotenoid production by selected fermentation conditions may provide an alternative approach to enhance carotenoid production with other strains.     

Effects of nitrogen on the lipid and carotenoid accumulation of oleaginous yeast <Emphasis Type="Italic">Sporidiobolus pararoseus</Emphasis>

Nitrogen limited but carbon excess condition was used to obtain high cellular lipid content and production. The maximum lipid production was 51 g/L, the lipid content in the dry cell was 60 %, and the lipid productivity was 0.53 g/L/h. In the fermentation, the content of lipid was raised from 20 % of dry cell weight to 60 %, and the proportion of oleic acid was raised from 66.8 to 72.5 %. Meanwhile, the metabolism of carotenoids switched to torulene, and its proportion was raised from 30 to 58 %. This was according to torulene had the better antioxidant ability than β-carotene to protect the strain from oxidative damage proved by their ABTS* radical scavenging activity and lipid peroxidation inhibition ability. Sporidiobolus pararoseus lipid was a good source of lipid not only because of its high oleic acid composition, but also the antioxidant ability of carotenoids in the lipid.     

beta-Carotene production in sugarcane molasses by a Rhodotorula glutinis mutant

Several wild strains and mutants of Rhodotorula spp. were screened for growth, carotenoid production and the proportion of -carotene produced in sugarcane molasses. A better producer, Rhodotorula glutinis mutant 32, was optimized for carotenoid production with respect to total reducing sugar (TRS) concentration and pH. In shake flasks, when molasses was used as the sole nutrient medium with 40 g l⁻¹ TRS, at pH 6, the carotenoid yield was 14 mg l⁻¹ and -carotene accounted for 70% of the total carotenoids. In a 14-l stirred tank fermenter, a 20% increase in torulene content was observed in plain molasses medium. However, by addition of yeast extract, this effect was reversed and a 31% increase in -carotene content was observed. Dissolved oxygen (DO) stat fed-batch cultivation of mutant 32 in plain molasses medium yielded 71 and 185 mg l⁻¹ total carotenoids in double- and triple-strength medium, respectively. When supplemented with yeast extract, the yields were 97 and 183 mg l⁻¹ total carotenoid with a 30% increase in -carotene and a simultaneous 40% decrease in torulene proportion. Higher cell mass was also achieved by double- and triple-strength fed-batch fermentation. Journal of Industrial Microbiology & Biotechnology (2001) 26, 327–332. Received 18 September 2000/ Accepted in revised form 02 March 2001     

Production of carotenoids and lipids by <Emphasis Type="Italic">Rhodococcus opacus</Emphasis> PD630 in batch and fed-batch culture

Production of carotenoids by Rhodococcus opacus PD630 is reported. A modified mineral salt medium formulated with glycerol as an inexpensive carbon source was used for the fermentation. Ammonium acetate was the nitrogen source. A dry cell mass concentration of nearly 5.4 g/L could be produced in shake flasks with a carotenoid concentration of 0.54 mg/L. In batch culture in a 5 L bioreactor, without pH control, the maximum dry biomass concentration was ~30 % lower than in shake flasks and the carotenoids concentration was 0.09 mg/L. Both the biomass concentration and the carotenoids concentration could be raised using a fed-batch operation with a feed mixture of ammonium acetate and acetic acid. With this strategy, the final biomass concentration was 8.2 g/L and the carotenoids concentration was 0.20 mg/L in a 10-day fermentation. A control of pH proved to be unnecessary for maximizing the production of carotenoids in this fermentation.     

Enhancement of carotenoids and lipids production by oleaginous red yeast Sporidiobolus pararoseus KM281507

Bioconversion of biodiesel-derived crude glycerol into carotenoids and lipids was investigated by a microbial conversion of an oleaginous red yeast Sporidiobolus pararoseus KM281507. The methanol content in crude glycerol (0.5%, w/v) did not show a significant effect on biomass production by strain KM281507. However, demethanolized crude glycerol significantly supported the production of biomass (8.64?±?0.13?g/L), lipids (2.92?±?0.03?g/L), β-carotene (15.76?±?0.85?mg/L), and total carotenoids (33.67?±?1.28?mg/L). The optimal conditions suggested by central composite design were crude glycerol concentration (55.04?g/L), initial pH of medium (pH 5.63) and cultivation temperature (24.01°C). Under these conditions, the production of biomass, lipids, β-carotene, and total carotenoids were elevated up to 8.83?±?0.05, 4.00?±?0.06?g/L, 27.41?±?0.20, and 53.70?±?0.48?mg/L, respectively. Moreover, an addition of olive oil (0.5???2.0%) dramatically increased the production of biomass (14.47?±?0.15?g/L), lipids (6.40?±?0.09?g/L), β-carotene (54.43?±?0.95?mg/L), and total carotenoids (70.92?±?0.51?mg/L). The oleic acid content in lipids was also increased to 75.1% (w/w) of total fatty acids, indicating a good potential to be an alternative biodiesel feedstock. Meanwhile, the β-carotene content in total carotenoids was increased to 76.7% (w/w). Hence, strain KM281507 could be a good potential source of renewable biodiesel feedstock and natural carotenoids.     

以糙米为原料流加L-蛋氨酸的S-腺苷蛋氨酸发酵优化

研究了S-腺苷甲硫氨酸(SAM)高产菌啤酒酵母S-W55的廉价培养基及分批补料发酵过程优化.对啤酒酵母S-W55生长和SAM产量影响最为重要的糙米水解糖和酵母粉进行了响应面优化,得到了最优化的配方为糙米水解糖51.4g/L、酵母粉4.74g/L,此条件下啤酒酵母S-W55的SAM产量达2.61 g/L.不同分批补料发酵...     

Production of carotenoids by strains of Rhodotorula glutinis cultured in raw materials of agro-industrial origin

The production of carotenoids by strains of Rhodotorula glutinis on different raw materials of agro-industrial origin (grape must, glucose syrup, beet molasses, soybean flour extract, maize flour extract) was investigated. Maximum yield (5.95 mg/l of total carotenoids culture fluid, 630 μg/g dry cell weight) was obtained with a particular strain of Rhodotorula glutinis after a batch culture of 120 h in a substrate containing concentrated rectified grape must as the sole carbohydrate source. In all experiments, the major pigments forming carotenoids (β-carotene, torulene, torularhodin) were quantified.     

Agro-food wastes utilization by Blakeslea trispora for carotenoids production

The all-trans-β-carotene is a natural pigment used in various industrial fields (food, cosmetics, pharmaceuticals, etc) and possesses the higher provitamin A activity, in respect to other carotenoids. All-trans-β-carotene is produced industrially by chemical and biotechnological means. For β-carotene biotechnological production in industrial scale mated cultures of Blakeslea trispora, a heterothallic fungus, are mainly used. Despite the intense research for β-carotene production by B. trispora, natural substrate utilization has not been extensively studied. Solid agro-food wastes such as cabbage, watermelon husk and peach peels from northern Greece as main carbon source into submerged B. trispora cultures for carotenoids production, was examined. The media containing only the agro-food waste (2-4) gave a biomass accumulation 7.77 ± 0.4 g/L, while a reference medium 1 with glucose (10 g/L) gave 4.65 ± 0.21 g/L. In another experiments series agro-food wastes were used with corn steep liquor and thiamine (media 6-8), giving a biomass accumulation and total carotenoid volumetric production 10.2 ± 2.41 g/L and 230.49 ± 22.97 mg/L, respectively. These are the higher values reported for solid wastes so far in respect to those obtained from a synthetic medium, with higher glucose concentration of 50 g/L where the correspondent values were 9.41 ± 1.18 g/L and 45.63 mg/L respectively. The results support that B. trispora is able to utilize, almost equivalently, different origin agro-food wastes for carotenoids production. Furthermore, β-carotene percentage in all examined cases was over 76%, as it was estimated by HPLC analysis, suggesting that these agro food wastes may be used for high purity, large scale β carotene production.     

Carotenoids of hemipteran insects,from the perspective of chemo-systematic and chemical ecological studies

Carotenoids of 47 species of insects belonging to Hemiptera, including 16 species of Sternorrhyncha (aphids and a whitefly), 11 species of Auchenorrhyncha (planthoppers, leafhoppers, and cicadas), and 20 species of Heteroptera (stink bugs, assassin bugs, water striders, water scorpions, water bugs, and backswimmers), were investigated from the viewpoints of chemo-systematic and chemical ecology. In aphids, carotenoids belonging to the torulene biosynthetic pathway such as β-zeacarotene, β,ψ-carotene, and torulene, and carotenoids with a γ-end group such as β,γ-carotene and γ,γ-carotene were identified. Carotenoids belonging the torulene biosynthetic pathway and with a γ-end group were also present in water striders. On the other hand, β-carotene, β-cryptoxanthin, and lutein, which originated from dietary plants, were present in both stink bugs and leafhoppers. Assassin bugs also accumulated carotenoids from dietary insects. Trace amounts of carotenoids were detected in cicadas. Carotenoids of insects belonging to Hemiptera well-reflect their ecological life histories.