海藻糖微生物酶法合成机制的研究*

来源于嗜酸热古菌芝田硫化叶菌 (Sulfolobusshibatae)B1 2的麦芽寡糖基海藻糖合酶(MTSase)和麦芽寡糖基海藻糖海藻糖水解酶 (MTHase)基因在大肠杆菌中获得表达。将获得纯化的两个酶 ,分别以麦芽寡糖和淀粉为转化底物 ,在pH5 5 ,6 0℃条件下合成海藻糖。从反应产物分析结果可知 ,两个酶合成海藻糖时能利用的最小底物是麦芽四糖 ,海藻糖产率与麦芽寡糖链长正相关。同时还发现两个酶都具有轻微的α 1 ,4 葡萄糖苷酶活性 ,能在麦芽寡糖还原末端水解α 1 ,4糖苷键     

海藻糖生产过程中产酶发酵条件的研究

研究了产酶的培养基组分和比例以及最佳培养条件对微球菌生产麦芽寡糖基海藻糖合成酶(MTSase)和麦芽寡糖基海藻糖海藻糖水解酶(MTHase)的影响,得到最优培养基组成为：葡萄糖2．0％,酵母膏2．0％,蛋白胨1．0％,磷酸氢二钾0．1％,硫酸镁0．05％;优化后的培养条件为：以15％的接种量接种至250mL的锥形瓶中,装液量为50mL,初始pH值7．5～8．5,培养温度为30℃,摇床培养4d。经优化后菌体干重由原来的1．938g／L增加到18．5g／L,生物量几乎增长了10倍;而酶活也由原来的30．64U／g增加到206．11U／g,酶活提高了接近7倍。     

海藻糖微生物酶法合成机制的研究

来源于嗜酸热古菌芝田硫化叶菌(Sulfolobus shibatae)B12的麦芽寡糖基海藻糖合酶(MTSase)和麦芽寡糖基海藻糖海藻糖水解酶(MTHase)基因在大肠杆菌中获得表达。将获得纯化的两个酶,分别以麦芽寡糖和淀粉为转化底物,在pH5.5,60℃条件下合成海藻糖。从反应产物分析结果可知,两个酶合成海藻糖时能利用的最小底物是麦芽四糖,海藻糖产率与麦芽寡糖链长正相关。同时还发现两个酶都具有轻微的α-1,4-葡萄糖苷酶活性,能在麦芽寡糖还原末端水解α-1,4糖苷键,生成葡萄糖分子,其反应最小底物分别是麦芽三糖和四糖。推测海藻糖合成酶可能有两个不同的催化活性中心。     

定向进化提高来源于Arthrobacter ramosus的MTHase的热稳定性

麦芽寡糖基海藻糖水解酶(maltosyltrehalose hydrolase,MTHase)是以淀粉或麦芽糊精为底物制备海藻糖的关键酶之一。来源于Arthrobacter ramosus的MTHase,表达量好,比活高,但热稳定性差,限制了其工业化应用。采用定向进化技术,筛选得到L137M和A216T两个突变体,在60℃下,野生型和两个突变体的半衰期(t1/2)分别为15.5、20.5和23.3 min,L137M和A216T的t1/2分别比野生型提高1.3和1.5倍。进一步考察了L137M、A216T和野生型酶在60℃分别和同样来源于Arthrobacter ramosus的麦芽寡糖基海藻糖合成酶(maltosyltrehalose synthase,MTSase)复配制备海藻糖,在相同的加酶量下,野生型、L137M和A216T的海藻糖转化率分别为51.3%,52.6%和55.7%,两个突变体的转化率都比野生型提高,说明突变体提高的热稳定性有利于海藻糖的转化率。     

藤黄微球菌海藻糖生物合成基因的克隆与鉴定

首次从一株能利用淀粉产生海藻糖的藤黄微球菌中克隆了海藻糖生物合成基因。采用PCR方法结合非随机鸟枪法得到藤黄微球菌中低聚麦芽糖苷基海藻糖合成酶(MTSase)基因(MtreY)的全序列及低聚麦芽糖苷基海藻糖水解酶(MTHase)基因(MtreZ)的部分序列,其中MtreY共有2,370个碱基,编码789个氨基酸,表达产物分子量为86·7kD。同源性分析表明,与已报道的MTSase和α-淀粉酶家族成员具有相同的保守模体。将MtreY基因在大肠杆菌JM83中表达,证明表达产物具有预期的酶活性。     

嗜酸热硫化叶菌麦芽寡糖基海藻糖合酶基因的克隆和表达

麦芽寡糖基海藻糖合酶( Maltodigosyltrehalose synthase;MTSase)是近年来在一些微生物中发现的新型分子内糖苷转移酶,能将淀粉或淀粉部分水解物(大于3个葡糖基)的糖链还原末端的α-1,4糖苷键转化为α-1,1糖苷键,生成具海藻糖末端结构的产物[1],如下所示: Gn为聚合度n(n＞3)的麦芽寡糖,Gn-2-T为麦芽寡糖基海藻糖,-T为海藻糖基.     

多酶复配合成海藻糖及其分离提取的研究

以大米淀粉为原料,多酶复配制备海藻糖。确定了实验室条件下多酶复配生产海藻糖的最佳条件:以15%(m/V)大米淀粉为底物,催化温度45℃、pH 6. 0、DE值16、α/β-CGTase加量为1. 4U/ml、催化28h后糖化处理12h,海藻糖转化率由双酶法催化的50%提高至73%。在底物浓度为25%(m/V)时,海藻糖产量最高达到182. 5g/L,随后对高浓度海藻糖进行分离提取,分别考察了活性炭脱色、离交分离、浓缩结晶等对海藻糖提取效率的响。     

来源于玫瑰微球菌的麦芽寡糖基海藻糖水解酶基因在大肠杆菌中的融合表达

设计引物克隆玫瑰微球菌QS412中麦芽寡糖基海藻糖水解酶(MTHase)的基因treZ,通过与pET-28a( )载体相连,转化入宿主菌E.coli BL21,进行发酵诱导。通过SDS-PAGE检测到外源基因在大肠杆菌中有很高的MTHase表达量,但大部分都以不溶性包含体形式存在。对菌体超声破碎全菌液检测酶活,结果显示了水解酶酶活。这是来源于微球菌属的麦芽寡糖基海藻糖水解酶首次获得基因克隆和活性表达,为进一步提高酶活、增大海藻糖产量奠定了基础。     

海藻糖合成酶活性受固定化处理过程影响的研究*

在麦芽糖苷基海藻糖合成酶(MTSase)和麦芽糖苷基海藻糖水解酶(MTHase)双酶的作用下,淀粉可转化为海藻糖,但是其转化率较低。中采用多种固定化载体进行酶固定化研究,发现通过经戊二醛与壳聚糖交联后的载体与酶液作用,可吸附与海藻糖合成无关的杂酶和杂质,从而提高海藻糖合成酶的活性。通过比较固定化过程中与反应条件中多个因素的影响,得到了如下最佳作用条件：将酶液与经3％戊二醛交联18h后的滤纸作用18h,再与10％的淀粉溶液反应9h,与未经固定化作用比较,海藻糖的产率提高10倍,达到27．22g／L转化率从5．33％提升到54．43％。     

腾冲嗜热杆菌热稳定海藻糖磷酸化酶的基因表达与酶的分子生物学性质研究

分离克隆了腾冲嗜热杆菌(Thermoanaerobacter tengcongensis)海藻糖磷酸化酶(TreP)的编码基因(treP), 该酶可催化以葡萄糖和α-1-磷酸葡萄糖为底物的海藻糖合成反应及其逆向的分解反应. 反向mRNA点杂交实验表明, 腾冲嗜热杆菌中treP基因在高盐胁迫条件下表达量增加, 而在海藻糖诱导条件下表达量降低. 将该基因导入不含TreP的大肠杆菌中进行诱导表达, SDS-PAGE表明, 异源表达的TreP分子量约为90 kD, 与预期值相同. 通过葡萄糖氧化酶法测定分解产物葡萄糖的产率表明: TreP催化海藻糖分解反应的最适温度是70℃, 最适pH值为7.0; 通过HPLC检测合成产物海藻糖的产率表明: TreP催化合成反应的最适温度为70℃, 最适pH值为6.0. 在最适反应条件下, 50 μg的TreP粗酶可催化25 mmol/L α-1-磷酸葡萄糖与葡萄糖在30 min合成11.6 mmol/L海藻糖; 而同量的酶在同样时间内仅能将250 mmol/L海藻糖分解生成1.5 mmol/L葡萄糖. 以上体内胁迫和诱导表达分析及体外酶学性质分析均证明该酶的主要功能是催化海藻糖的合成反应. 热稳定性实验表明, 该酶性质比较稳定, 在50℃下温育7 h还能保持77%以上的活性, 是一个有潜在工业用途的新的热稳定海藻糖合成酶.     

Characterization of the maltooligosyl trehalose synthase from the thermophilic archaeon Sulfolobus acidocaldarius

We report the molecular characterization and the detailed study of the recombinant maltooligosyl trehalose synthase mechanism from the thermoacidophilic archaeon Sulfolobus acidocaldarius. The mts gene encoding a maltooligosyl trehalose synthase was overexpressed in Escherichia coli using the T7-expression system. The purified recombinant enzyme exhibited optimum activity at 75 degrees C and pH 5 with citrate-phosphate buffer and retained 60% of residual activity after 72 h of incubation at 80 degrees C. The recombinant enzyme was active on maltooligosaccharides such as maltotriose, maltotetraose, maltopentaose and maltoheptaose. Investigation of the enzyme action on maltooligosaccharides has brought much insight into the reaction mechanism. Results obtained from thin-layer chromatography suggested a possible mechanism of action for maltooligosyl trehalose synthase: the enzyme, after converting the alpha-1,4-glucosidic linkage to an alpha-1,1-glucosidic linkage at the reducing end of maltooligosaccharide glc(n) is able to release glucose and maltooligosaccharide glc(n-1) residues. And then, the intramolecular transglycosylation and the hydrolytic reaction continue, with the maltooligosaccharide glc(n-1) until the initial maltooligosaccharide is reduced to maltose. An hypothetical mechanism of maltooligosyl trehalose synthase acting on maltooligosaccharide is proposed.     

嗜热古菌Sulfolobus tokodaii strain 7中麦芽寡糖基海藻糖合酶的酶学性质

【目的】克隆表达嗜热古菌Sulfolobus tokodaii strain 7中的ST0929基因,并测定其酶活性。【方法】根据ST0929基因设计引物进行PCR扩增,将这段基因克隆到p ET-15b质粒上,重组质粒导入大肠杆菌BL21细胞中表达。亲和层析纯化酶蛋白,并测定其酶活性。【结果】SDS-PAGE分析表明其分子量大约为83 k D。酶学性质研究表明该酶的最适温度为75°C,最适p H为5.0,具有很强的热稳定性和p H稳定性。该酶还能对多种金属离子和有机溶剂具有一定的耐受性。底物特异性研究发现该酶能够利用麦芽糊精作底物,而不能利用壳寡糖、麦芽糖等。【结论】通过以上酶学性质的研究,说明这种来源于超嗜热古菌的麦芽寡糖基海藻糖合酶在工业生产海藻糖领域具有一定的应用前景。     

芝田硫化叶菌麦芽寡糖基海藻糖合酶基因在大肠杆菌中的克隆和表达

用ＰＣＲ 方法从芝田硫化叶菌中扩增了编码一种新酶,即麦芽寡糖基海藻糖合酶（ ＭＴＳａｓｅ） 的基因,扩增的２－２ｋｂ ＤＮＡ 插入到原核表达载体ｐＢＶ２２０ 中,构建成重组质粒ｐＳＢＧＴ１ 。ｐＳＢＧＴ１ 中ＭＴＳａｓｅ 基因在大肠杆菌中得到表达。ＳＤＳＰＡＧＥ 分析表达产物ＭＴＳａｓｅ蛋白的分子量约为７４ｋＤａ ,同核苷酸序列测定所推导的值相符。表达产物占细胞总蛋白约４－４ ％ 。ｐＳＢＧＴ１ 产生的重组酶作用于淀粉部分水解物,使ＤＥ 值降低,得到非还原糖或低还原糖。     

红色亚栖热菌TPS/TPP海藻糖合成途径中相关基因的克隆、表达及功能鉴定

通过构建红色亚栖热菌(Meiothermus ruberCBS-01)的基因组DNA文库,克隆得到该嗜热菌海藻糖合成途径中的磷酸海藻糖合成酶(TPS)和磷酸海藻糖磷酸酯酶(TPP)基因。以pET21a为表达载体,将磷酸海藻糖合成酶和磷酸海藻糖磷酸酯酶在大肠杆菌中进行表达并纯化,利用薄层层析的方法验证了这两个酶的活性。同时,本研究检测了红色亚栖热菌在各种环境压力下细胞内含物成分的变化情况,发现在高渗环境压力的诱导下,该菌会在胞内积累大量的6-磷酸海藻糖,而并非海藻糖,这为进一步研究TPS/TPP和TreS途径在细胞体内的作用奠定了基础。     

Isolation and Identification of a Thermophilic Strain Producing Trehalose Synthase from Geothermal Water in China

A slightly thermophilic strain, CBS-01, producing trehalose synthase (TreS), was isolated from geothermal water in this study. According to the phenotypic characteristics and phylogenetic analysis of the 16s rRNA gene sequence, it was identified as Meiothermus ruber. The trehalose synthase gene of Meiothermus ruber CBS-01 was cloned by polymerase chain reaction and sequenced. The TreS gene consisted of 2,895 nucleotides, which specified a 964-amino-acid protein. This novel TreS catalyzed reversible interconversion of maltose and trehalose.     

Cloning, expression and identification of a new trehalose synthase gene from Thermobifida fusca genome

Trehalose is a disaccharide with two glucose mole-cules linked in an α,α-1,1-glycosidic linkage. The onlyreducing group in each of its glucose molecules has beenused up for the formation of α,α-1,1-glycosidic linkage,therefore trehalose is a nonreducing disaccharide withhigh stability against the disruption caused by such factorsas temperature and extreme pH of environment [1]. Ithas been well established that many organisms will copewith external stress conditions by increasing the levelo…     

Purification and Crystallization of d-Arabinose (l-Fucose) Isomerase from Aerobacter aerogenes by Polyethylene Glycol

d-Arabinose(l-fucose) isomerase (d-arabinose ketol-isomerase, EC 5.3.1.3) was purified from the extracts of d-arabinose-grown cells of Aerobacter aerogenes, strain M-7 by the procedure of repeated fractional precipitation with polyethylene glycol 6000 and isolating the crystalline state. The crystalline enzyme was homogeneous in ultracentrifugal analysis and polyacrylamide gel electrophoresis. Sedimentation constant obtained was 15.4s and the molecular weight was estimated as being approximately 2.5 × 10⁵ by gel filtration on Sephadex G-200.

Optimum pH for isomerization of d-arabinose and of l-fucose was identical at pH 9.3, and the Michaelis constants were 51 mm for l-fucose and 160 mm for d-arabinose. Both of these activities decreased at the same rate with thermal inactivation at 45 and 50°C. All four pentitols inhibited two pentose isomerase activities competitively with same Ki values: 1.3–1.5 mm for d-arabitol, 2.2–2.7 mm for ribitol, 2.9–3.2 mm for l-arabitol, and 10–10.5 mm for xylitol. It is confirmed that the single enzyme is responsible for the isomerization of d-arabinose and l-fucose.     

Continuous production of α,α-trehalose by immobilised fungal trehalose phosphorylase

Immobilisation of trehalose phosphorylase from Schizophyllum commune by adsorption onto anion-exchange materials stabilised the enzyme activity at 30°C by approx. 35-fold. Immobilised and free enzymes showed similar pH-dependence of activity but different inactivation behavior above 30°C. A fixed-bed enzyme reactor produced ,-trehalose at a stable substrate conversion of 80% with a productivity of 2.6 g l–1 h–1 for 72 h. Inhibition of trehalose phosphorylase by phosphate limited the productivity of a direct conversion of starch into ,-trehalose.