极地适冷菌Pseudoalteromonas sp. QI-1产适冷蛋白酶发酵条件的优化

对极地适冷菌Pseudoalteromonas sp. QI-1产适冷蛋白酶的发酵条件进行优化。结果表明:菌株QI-1的最适生长和产酶温度均为5℃;最佳接种量为1%;发酵培养基的最适初始pH和最佳装样量分别为5和10%;盐度为2%时对菌株的生长和产酶最为有利;麸皮和醋酸钠分别为最佳N源和C源;添加0.75%酪蛋白时菌株QI-1胞外蛋白酶的活性最高;10 mmol/L Mg2+和0.5%Tween-80有利于产酶。正交试验结果表明:菌株Pseudoalteromonassp. QI-1产蛋白酶较佳培养基配方(g/L)为麸皮5,酵母粉2.5,酪蛋白3,MgCl2.6H2O 3,KCl 1.5;发酵液比酶活为166.20 U/mL,较优化前提高了约56%。     

产低温碱性蛋白酶海洋适冷菌SY的筛选

从连云港海域、港口、远洋捕捞船及鱼市等地采集的海水和各类海鱼、贝类等样品中分离到217株产蛋白酶的细菌,并从中得到1株产低温碱性蛋白酶的海洋适冷细菌—SY。研究表明,该菌株最适生长温度和最适产酶温度均在15℃左右,0℃下仍可生长;具有一定的耐盐性和嗜盐性,无盐条件不能生长,在3%的NaCl盐浓度时,生长达到最高峰;最适生长和最适产酶pH均为8.0;SY菌所产的蛋白酶可能为一种丝氨酸蛋白酶,酶最适作用温度为50℃,最适作用pH为9.0;酶的热稳定性差,50℃保温20min,酶活下降40%。     

耐冷菌Bacillus cereus SYP-A3-2低温蛋白酶的发酵条件

研究了营养因子及环境条件对中国冰川1号耐冷菌Bacillus cereus SYP-A3-2产低温蛋白酶的影响。结果表明对该菌产酶影响较大的因素分别是温度、酪蛋白浓度和pH,在酪蛋白浓度0．8％、pH7、15℃下摇瓶发酵48h产酶水平可达3,800U／mL。     

氧化铁鞘细菌铁氧化酶最适产酶条件及其酶学特性的研究

对氧化铁鞘细菌FC990 1菌株的铁氧化酶最适产酶条件及酶学特性进行了研究。菌株最适产酶培养基为 (g/L) :柠檬酸铁胺 10g ,NaNO3 1.2g,MgSO4·7H2 O 0 .5g ,K2 HPO4·7H2 O 0 .5g ,CaCl2 0 .0 15g ,ZnSO4·7H2 O 0 .0 0 0 5g。最适产酶条件为 :温度 30℃ ,起始pH7.0 ,接种量 2 % ,15 0mL三角瓶装 5 0mL ,15 0r/min振荡培养 72h。铁氧化酶最适pH为7.5 ,最适温度为 30℃。金属离子Ca2 、Mg2 、Zn2 对酶有激活和稳定作用 ;Cu2 、Hg2 、Al3 则抑制酶的活性 ;Fe2 、K 、Na 对酶活性影响不明显。     

四株冰川雪细菌产酶能力的初步研究

目的:从青藏高原冰川雪中筛选出一菌多酶的菌株.方法:对恢复出的4个细菌,通过平板透明法研究其产淀粉酶、脂肪酶和蛋白酶的特性.结果:LHG-C-9为惟一可以产淀粉酶的菌株,所产脂肪酶活性最高.4个菌株均不产蛋白酶.结论:LHG-C-9最适生长温度为15℃,属于耐冷菌.对该菌所产淀粉酶和脂肪酶的性质进行了初步研究,其随产淀粉酶的最适作用温度为50℃;最佳产酶pH值为7.0,该pH值所产酶活为83.9U/mL;在60℃的高温下温浴10min后酶活为0%.该菌株所产脂肪酶的最适作用温度为20℃;最佳产酶pH值为7.0,该pH值所产酶活为9.2U/mL;50℃温浴1h后酶活力不足34%.     

耐冷菌Bacillus cereus SYP-A3-2低温蛋白酶的发酵条件*

研究了营养因子及环境条件对中国冰川1号耐冷菌BacilluscereusSYP-A3-2产低温蛋白酶的影响。结果表明对该菌产酶影响较大的因素分别是温度、酪蛋白浓度和pH,在酪蛋白浓度0·8%、pH7、15℃下摇瓶发酵48h产酶水平可达3,800U/mL。     

极端微生物产碱性蛋白酶菌株的筛选及发酵条件研究*

从深海的 3 8份水样和泥样中筛选到一株产蛋白酶的菌株DY A ,其最适生长温度为1 0℃ ,能适应较大范围的pH值和盐度。此菌株只在酵母膏存在的情况下产酶 ,不利用单一氮源 ,最适产酶条件为 :pH1 0 0 ,1 0℃ ,接种量 0 5 % ,2 0 0r/min摇床培养 48～ 72h。粗酶液的最适作用温度为 40℃ ,最适pH值为 1 0 ,在pH9～ 1 2内稳定 ,是一碱性蛋白酶。     

一株产环糊精葡萄糖基转移酶的地衣芽孢杆菌的选育、产酶条件及酶学特性

从土壤分离物中筛选到一株环糊精葡萄糖基转移酶 (CGTase)产生菌 4 0 3,96h发酵酶活为 0 95U mL。经紫外辐射和硫酸二乙酯复合诱变而获得突变株CLS4 0 3,96h发酵酶活达 1 36U mL ,提高 4 3%。该突变菌株被鉴定为地衣芽孢杆菌 (Bacilluslicheniformis) ,产CGTase的最佳碳源为可溶性淀粉 ,最佳氮源为硝酸铵 ,最适初始pH为 6 5 ,最适培养温度为 35℃ ,发酵期间CGTase的产生高峰 (第 96h)滞后于菌体生物量高峰 (第 4 8h) 2d。菌株所产CGTase的最适反应pH为 6 0 ,最适温度为 5 5℃ ,在pH 6 0～ 7 5间和 5 0℃下保持 1h后的剩余酶活均达 90 %以上 ;酶液中适量添加Ca2 能大幅提高CGTase在 5 5℃下的稳定性。经高效液相色谱分析 ,CGTase作用于淀粉后的产物以α 环糊精为主 ,β 环糊精为次 ,二者比例为 2 4 7∶1,环糊精总产率达 2 9 8% ,但产物中不含γ 环糊精     

链霉菌产木聚糖酶条件和酶学性质以及重离子诱变对产酶的影响研究

以一株由青藏高原牦牛粪中分离出的链霉菌为出发菌株,对其培养特性、产酶条件和酶学性质进行初步研究.通过重离子诱变,筛选出遗传稳定的高产菌株.结果表明,该菌以玉米芯和麸皮(1∶1)为碳源能高效地诱导木聚糖酶的胞外分泌,其最适培养基和培养条件氮源为酵母膏、初始pH7、培养温度为25℃,在此条件下,第4天酶活力达到峰值3480.25 U/mL.说明该酶能够利用农业废弃物高效生产木聚糖酶.该菌株所产木聚糖酶的最适反应温度为15℃、pH4,属低温酸性木聚糖酶.经重离子诱变后,筛选出一株高产菌株SZ10-7,其酶活力可达5 338.42 U/mL.     

一株耐冷玫红假裸囊菌HD1031的鉴定及其所产纤维素酶的研究

[目的]以纤维素为唯一碳源,从四川省阿坝自治州黄龙沟的高山低温环境中分离筛选产纤维素酶的耐冷菌,并研究菌株的产酶特征.[方法]根据菌株的ITS序列分析及形态特征,对菌株进行鉴定.利用DNS法测定纤维素酶酶活性.[结果]从四川省阿坝自治州黄龙沟的高山腐殖土中筛选出一株产纤维素酶的耐冷菌HD1031,经鉴定该菌为玫红假裸囊菌(Pseudogymnoascus roseus).该菌可在4℃-25℃生长,最适生长温度为16℃-17℃.该菌在以微晶纤维素和玉米芯粉为碳源、硫酸铵和Tryptone为氮源的培养基中,17℃、160 r/min摇瓶发酵8d后产生纤维素酶,其中内切葡聚糖酶酶活为366.67 U/mL,滤纸酶酶活87.6 U/mL,β-葡萄糖苷酶酶活90.8 U/mL,酶最适反应pH为6.0,最适反应温度为50℃.[结论]筛选获得一株产纤维素酶的耐冷菌HD1031,此菌株所产纤维素酶在20℃-40℃下活性较高,对热敏感,具有低温纤维素酶的特点.     

低温脂肪酶产生菌的筛选、产酶发酵及粗酶性质研究

利用含有Tween 80的琼脂平板和摇瓶发酵法,从若尔盖高原土壤中筛选产脂肪酶菌株.通过菌落形态和菌体特征观察初步对菌种进行鉴定,得到一株产低温脂肪酶的适冷菌Pseudomonassp.DL-B,并设计正交试验对该菌株的产酶发酵培养条件进行了优化.摇瓶实验表明,该菌株最适产酶发酵培养基为:蔗糖10 g/L,蛋白胨20 ...     

土壤中高产蛋白酶菌株产酶条件及酶学性质

【背景】微生物蛋白酶已经成为工业用蛋白酶的主要来源,筛选具有特殊环境适应性的微生物成为生物酶资源的开发热点。【目的】通过对青藏高原土壤微生物产蛋白酶菌株的筛选、优化及相关特性研究,寻找新的蛋白酶资源,为高原菌种资源利用提供科学依据。【方法】采用形态学和分子生物学对筛选菌株进行菌种鉴定,利用单因素试验和正交试验对菌株进行发酵条件优化及酶学性质的探究。【结果】筛选出一株高产蛋白酶菌株XC2,经鉴定菌株XC2为枯草芽孢杆菌(Bacillus subtilis)。XC2最优产酶条件:可溶性淀粉4.0%,牛肉膏1.0%,K~+0.6%,培养温度34°C、初始pH 7.0、接种量2.0%的条件下200 r/min振荡培养13 h,所产蛋白酶活力最高为638.5 U/mL。XC2所产蛋白酶最适反应温度60°C,最适pH9.0;40-50°C、pH8.0-10.0条件下酶活稳定性较高;Mn~(2+)对酶活力有明显激活作用,而Zn~(2+)、Cu~(2+)、Fe~(2+)、Fe3+对酶活力有明显抑制作用。【结论】枯草芽孢杆菌XC2有较强的产碱性蛋白酶的能力,具有较好的应用前景。     

铜绿假单胞菌产蛋白酶的发酵条件优化

【目的】鉴定一株来源于酱油曲能够分泌蛋白酶的铜绿假单胞菌CAU342A,优化其产蛋白酶的发酵条件。【方法】采用形态学观察、16S r RNA基因序列比对和生理生化方法鉴定菌株CAU342A;通过碳源、氮源、初始pH、温度、表面活性剂及发酵时间的单因素优化和正交试验获得最适发酵条件。【结果】菌株CAU342A被鉴定为铜绿假单胞菌(Pseudomonas aeruginosa),其最适发酵产酶条件为(质量体积比):3%酒糟,1.5%酵母浸提物,0.05%吐温-80,0.5%NaCl,0.7%K_2HPO_4,0.3%KH_2PO_4,0.04%MnSO_4,培养基初始pH 7.5,30°C培养72 h。在最适发酵条件下,该菌株最大产酶水平达到2 653.5 U/m L。蛋白酶酶谱分析表明该菌株能够产生至少4种具有蛋白酶活性的同工酶,其中两个主要酶谱带对应分子量分别为32 k D和50 k D。【结论】铜绿假单胞菌CAU342A高产蛋白酶,具有很大的工业应用潜力。     

Pestalotiopsis mangiferae isolated from cocoa leaves and concomitant tannase and gallic acid production

The enzyme tannase is of great industrial and biotechnological importance for the hydrolysis of vegetable tannins, reducing their undesirable effects and generating products for a wide range of processes. Thus, the search for new microorganisms that permit more stable tannase production is of considerable importance. A strain of P. mangiferae isolated from cocoa leaves was selected and investigated for its capacity to produce tannase enzymes and gallic acid through submerged fermentation. The assessment of the variables affecting tannase production by P. mangiferae showed that tannic acid, ammonium nitrate and temperature were the most significant (8.4 U/mL). The variables were analyzed using Response Surface Methodology - RSM (Box-Behnken design), with the best conditions for tannase production being: 1.9% carbon source, 1% nitrogen source and temperature of 23 °C. Tannase activity doubled (16.9 U/mL) after the optimization process when compared to the initial fermentation. A pH of 7.0 was optimal for the tannase and it presented stability above 80% with pH between 4.0 and 7.0 after 2h of incubation. The optimal temperature was 30 °C and activity remained at above 80% at 40–60 °C after 1 h. Production of gallic acid was achieved with 1% tannic acid (0.9 mg/mL) and P. mangiferae had not used up the gallic acid produced by tannic acid hydrolysis after 144 h of fermentation. A 5% tannic acid concentration was the best for gallic acid production (1.6 mg/mL). These results demonstrate P. mangiferae’s potential for tannase and gallic acid production for biotechnological applications.     

南极交替单胞菌R11-5产卡拉胶酶的发酵条件优化

【背景】极地寒冷环境中发现了大量具有潜在应用前景的冷适应酶,同时也存在种类繁多的海藻多糖降解菌,因此极端环境微生物是筛选获得新颖、高效多糖降解酶的重要新源泉。由于筛选培养基通常并非野生菌发酵产酶的最优条件,为了使野生菌的产酶效率达到最高,需要对其培养条件进行优化,从而为其深入研究及开发利用提供依据。【目的】对一株产卡拉胶酶的南极菌株进行种属鉴定,并采用响应面法对该菌的发酵产酶条件进行优化。【方法】通过16SrRNA基因对产卡拉胶酶的南极菌株进行种属鉴定,采用响应面法优化南极菌株产酶发酵条件。【结果】该南极菌属于交替单胞菌属(Alteromonas),命名为交替单胞菌R11-5。发酵条件优化结果显示,7个环境因子影响交替单胞菌R11-5的产酶量。利用Design-Expert软件中的Plackett-Burman设计实验,筛选出影响交替单胞菌R11-5产酶量的4个主要因素分别为培养温度、牛肉膏浓度、卡拉胶浓度和Ca~(2+)浓度。通过Box-Behnken设计和响应面分析得到交替单胞菌R11-5最佳产酶发酵条件为:温度15.0°C,牛肉膏浓度11.0 g/L,卡拉胶浓度3.0 g/L,Ca~(2+)浓度5.0 mmol/L。优化后发酵上清液酶产量达到87.193 U/mL,与优化前相比提高了1.8倍。【结论】响应面法提高了南极交替单胞菌R11-5卡拉胶酶的产量,为其开发应用提供了科学依据。     

Optimization of fermentation medium and conditions for mycelial growth and water-soluble exo-polysaccharides production by Isaria farinosa B05

The optimal fermentation medium and conditions for mycelial growth and water-soluble exo-polysaccharides production by Isaria farinosa B05 were investigated. The medium components and fermentation conditions were optimized according to the one at a time method, while the concentration of medium components was determined by the orthogonal matrix method. The results showed that the optimal fermentation medium was as follows: sucrose 3.5% (w/v), peptone 0.5%, yeast extract 0.2%, K(2)HPO(4) 0.1%, and MgSO(4) 0.05%. The suitable fermentation conditions were as follows: initial pH 7.0, temperature 25 degrees C, medium volume 75 mL/250 mL, inoculum volume 5% (v/v), time 5d. In such optimal nutrition and environmental conditions, the maximal mycelial yield was 2.124 g/100 mL after 4 day's fermentation, while maximal water-soluble exo-polysaccharides production reached 2.144 g/L after 5 day's fermentation.     

Fermentation of starch for enhanced alkaline protease production by constructing an alkalophilic Bacillus pumilus strain

A new engineering strain, Bacillus pumilus c172-14 (pBX 96), was obtained by introducing the pBX 96 plasmid, which carries the alpha-amylase amy gene, into the host strain of alkalophilic Bacillus pumilus c172 via transformation. The newly constructed strain was found to express the amy gene and could use starch instead of glucose or starch hydrolysate as carbon source for its fermentation of alkaline protease. The pBX 96 plasmid in the new host was found to be segregationally and structurally stable. The expression of amy gene did not affect the host strain's resistance to bacteriophages. Moreover, the level of alkaline protease was improved significantly compared with the parent strain. The constructed strain gave a maximum alkaline protease activity of 14,014 U/ml in shaking flask after 48 h cultivation when growing in a medium containing 6% corn meal, 4% soybean flour, 0.4% Na2HPO4, 0.03% KH2PO4, 0.02% MgCl2, 0.3% CaCl2, 0.25% Na2CO3, 0.1% glucose, and 20 microg/ml kanamycin (pH 7.0). The optimal pH value and temperature of the alkaline protease were 11.0 and 40 degrees C, respectively. This enzyme was stable over a pH range of 8-11. Its residual activity remained at 100% when treated under a temperature of less than 45 degrees C for 30 min. The corresponding residual activity reduced to 65% of its optimal value at 60 degrees C for 30 min. The alkaline protease was a kind of serine protease, which was demonstrated by the complete inactivation by PMSF (1 mM). This newly constructed strain will be useful in the alkaline protease industry.     

Enhanced production of Penicillium expansum PED-03 lipase through control of culture conditions and application of the crude enzyme in kinetic resolution of racemic Allethrolone

Alkaline lipase production was performed in submerged fermentation by Penicillium expansum PED-03. It was found that the suitable carbon source and nitrogen source for lipase production were 0.5% starch and 4.0% soybean meal, respectively. The maximal lipase activity (850 U/mL) of production was achieved at initial pH 5.5-6.0, 26 degrees C, 72 h. Tween-80 was an effective enhancer for lipase production. Agitation speed of the fermentor played an important role, and the suitable agitation speed for lipase production was 500 r/min. The lipase was stable within the range of pH 7.0-10.0 and 20-40 degrees C, and the optimum conditions for the enzymatic reaction were 35 degrees C and pH 9.5. The enzymatic resolution of racemic allethrolone (4-hydroxy-3-methyl-2-(2-propenyl)-2- cyclopenten-1-one) was carried out by the lipase from P. expansum PED-03, and the conversion reached 48% with excellent enantioselectivity (E > 100), which showed a good application potential in the production of optically pure allethrolone.     

纤维素降解菌Aspergillus sp. YN1的产酶条件及酶学特性

从牛羊粪堆肥中筛选出一株纤维素降解菌Aspergillus sp.YN1,主要研究了液体发酵培养基中碳源、氮源、培养温度、起始pH、通气量以及接种菌龄对菌株YN1的羧甲基纤维素酶活(CMC酶活)及滤纸酶活的影响。研究结果表明,在优化条件下,该菌的CMC酶活、滤纸酶活在培养第3天分别达到0.53U/mL和0.15U/mL。在酶学特性研究中,菌株YN1的CMC酶的最适反应温度为70°C,最适反应pH4.0(酶促反应为30min)。用不同温度处理1h或不同pH处理2h,YN1的CMC酶在30°C?50°C或pH3.0?4.0之间仍可保持80%以上的酶活性,对热及酸表现出较高的稳定性。     

纳豆激酶液态发酵条件的研究

考察纳豆杆菌在7.5 L发酵罐中分批发酵产纳豆激酶的条件,纳豆激酶酶活采用四肽底物测定。结果表明:纳豆杆菌生长和产酶的适宜条件不一致。发酵过程中发酵罐搅拌转速控制为500 r/min不变,0～12 h时控制pH为8.0、温度为37℃;12～36 h调整pH为7.0、温度为30℃;16 h时补加外源C源,连续发酵36 h。该过程中发酵液中比酶活最高达到3 232 U/mL,与摇瓶发酵相比,比酶活提高了58%。