硅藻金色奥杜藻色素的HPLC分析与超临界CO2萃取研究

以硅藻金色奥杜藻(Odontella aurita)为实验材料,利用高效液相色谱法分析了其色素组成与含量,采取超临界CO2萃取技术研究了从干藻粉内提取岩藻黄素的条件。结果表明,该藻主要含有岩藻黄素、硅甲藻黄素、β-胡萝卜素、硅藻黄素等类胡萝卜素以及叶绿素a和叶绿素c1,其中岩藻黄素为该藻含量最高的类胡萝卜素。色素的萃取率与压强、温度、夹带剂含量以及萃取时间呈正相关,夹带剂含量对萃取率影响最大,CO2流速的影响最小;与有机溶剂法相比,超临界CO2萃取岩藻黄素效率略低,而更利于岩藻黄素的选择性萃取及分离提纯;岩藻黄素的SFE-CO2适宜条件为压强400 bar、温度50℃、CO2流速0.2 L/min、夹带剂比例10%、萃取时间2～3 h。     

响应面分析法优化大蒜蒜氨酸提取工艺

以新鲜大蒜为原料,微波灭酶后,通过乙酸乙酯打浆除去大蒜中脂溶性成分,以蒸馏水为提取液,采用响应面法研究料液比、提取温度、提取时间对蒜氨酸提取率的影响。结果表明回归模型能较好的预测各因素与响应值之间的关系,所优化的最佳工艺为:料液比为1∶5,提取温度为32℃,提取时间为70 min。此时蒜氨酸的提取率为92.85±0.63%。     

乙酸乙酯抽提法在ESR检测一氧化氮自由基中的应用

改进了用有机溶剂抽提检测一氧化氮(nitric oxide,NO)自由基的方法,并利用有机溶剂抽提法检测了小鼠心肌中NO的含量.有机溶剂可以把二乙基二硫代氨基甲酸钠(diethyldithiocarbamate, DETC)捕集NO的产物(DETC)₂-Fe²⁺-NO由水相中萃取并富集到酯相中,然后利用电子顺磁共振波谱仪(ESR)在常温下检测大体积样品中的NO.比较了几种不同的有机溶剂：正丁醇、乙酸丁酯、乙酸乙酯、三乙酸甘油酯、乙酸异戊酯等的萃取能力,发现乙酸乙酯是一种理想的提取溶剂.乙酸乙酯提取法可以使NO的量与ESR信号强度在20 μmol/L内有良好的线性,使ESR的检测灵敏度提高到200 nmol/L以下;(DETC)₂-Fe²⁺-NO对光比较敏感,见光易于分解;复合物在乙酸乙酯中避光保存于4℃可稳定十几天而无显著的变化.     

Dynamic changes in size distribution of emulsion droplets during ethyl acetate-based microencapsulation process

This study investigated the dynamic effect of the emulsification process on emulsion droplet size in manufacturing microspheres using ethyl acetate as an organic solvent. A dispersed phase consisting of poly(lactide-co-glycolide) and ethyl acetate was emulsified in a poly(vinyl alcohol) aqueous solution for a predetermined time ranging from 2 to 9, 16, 23, 30, 40, 50, or 60 minutes. Ethyl acetate was then quickly extracted to transform emulsion droplets into solidified microspheres, and their size distribution was determined. This experimental design allowed quantification of the size distribution of emulsion droplets over the course of emulsification. When emulsification time was extended from 2 to 60 minutes, the emulsion droplets decreased in size from 98.1 to 50.3 microm and their surface area increased from 0.07 to 0.29 m2/g. Overall, prolonging emulsification time up to 60 minutes resulted in the progressive evolution of smaller emulsion droplets (1-60 microm) and the simultaneous disappearance of larger ones (> 81 microm). Increases in the total number of microspheres and their surface area were caused mainly by continuous fragmentation of emulsion droplets before ethyl acetate extraction. The increase in the smaller microsphere population might also be due in part to shrinkage of microspheres. These results show that the onset of ethyl acetate extraction influenced the kinetics of the breakup and formation of emulsion droplets, thereby affecting to a great extent the size distribution of microspheres.     

Comparative fermentability of enzymatic and acid hydrolysates of steam-pretreated aspenwood hemicellulose by Pichia stipitis CBS 5776

Summary Enzymatic hydrolysates of hemicellulose from steam-pretreated aspenwood were more fermentable than the acid hydrolysate after rotoevaporation or ethyl acetate extraction treatments to remove acetic acid and sugar- and lignin-degradation products prior to fermentation by Pichia stipitis CBS 5776. Total xylose and xylobiose utilization from 5.0% (w/v) ethyl acetate extracted enzymatic hydrolysate was observed with an ethanol yield of 0.47 g ethanol/g total available substrate and an ethanol production rate of 0.20 g·l^-1 per hour in 72 h batch fermentation.     

泥胡菜等8种草本植物提取物除草活性的生物测定

采用顺序提取法制备了泥胡菜（Hemistepta lyrata Bunge）等8种草本植物全草的石油醚、乙酸乙酯和乙醇提取物,并以高粱（Sorghum vulgare Pers．）、黄瓜（Cucumis sativus L．）、小麦（Triticum aestivum L．）和油菜（Brassica campestris L．）为供试对象,用种子萌发法对提取物的除草活性进行了生物测定。结果表明,所有提取物对4种作物幼苗根和茎的生长均有一定的抑制作用,但抑制率有一定差异。泥胡菜和獯草[Humulus scandens（Lour．）Merr．]的乙酸乙酯提取物对作物幼苗根和茎的抑制作用最强,抑制率随提取物浓度的提高逐渐增高,且对作物幼苗根生长的抑制强度高于茎。在低浓度（12．5g·L^-1）条件下,泥胡菜乙酸乙酯提取物对小麦幼苗根和茎生长的抑制作用最强;蓓草乙酸乙酯提取物对高粱幼苗根的生长及油菜幼苗根和茎的生长抑制作用最强。研究结果显示,泥胡菜及蓰草的乙酸乙酯提取物具有潜在的除草活性。     

铜藻岩藻黄素提取及纯化工艺研究

为了对岩藻黄素的提取、纯化进行系统研究,进而为高纯度岩藻黄素的工业化生产提供研究基础,筛选了适用于提取铜藻（Sargassum horneri）鲜藻中岩藻黄素的有机溶剂,并通过单因素实验和正交实验确定了最佳的提取溶剂浓度、提取温度、提取时间、料液比等工艺参数。随后采用硅胶柱层析法进行纯化,并通过单因素实验确定了最佳的硅胶柱床高度、上样量和洗脱流速。最后采用制备液相法对经层析纯化的岩藻黄素进一步纯化。结果表明,有机溶剂萃取的最佳工艺条件为：甲醇浓度90%,提取温度50 ℃,提取时间1 h,料液比1∶10,此条件下岩藻黄素提取率达到(0.258 9±0.003 6) mg·g-1鲜重（FW）［(1.078 8±0.015 0) mg·g-1干重（DW）］。硅胶柱层析的最佳工艺条件为：硅胶柱床高度10 cm,上样量6 g,洗脱流速10 mL·min-1,此条件下岩藻黄素得率为0.176 5 mg·g-1FW（0.735 3 mg·g-1 DW）,纯度为87.01%±0.88%。经制备液相进一步纯化后,岩藻黄素得率为0.127 1 mg·g-1 FW（0.529 4 mg·g-1 DW）,纯度为99.27%±0.22%。研究所用工艺简单,岩藻黄素得率高,为高纯度岩藻黄素的制备提供了实验基础。     

Biotransformation of ferulic acid to acetovanillone using Rhizopus oryzae

Microbial transformation of ferulic acid to acetovanillone was studied using growing cells of Rhizopus oryzae. Ferulic acid was added to the growing medium (0.5 g L^?1) and incubated for 12 days. The progress of formation of metabolites was monitored by GC and GC-MS after extraction with ethyl acetate. The major metabolite was acetovanillone with minor metabolites formed, such as dihydroferulic acid, coniferyl alcohol and dihydroconiferyl alcohol. Traces of metabolites (≤1–3%), such as vanillin, vanillyl alcohol, vanillic acid and phenyl ethyl alcohol, were also produced. Formation of 4-vinyl guaiacol increased from day 1 (12.4%), reaching a maximum on day 4 (31.7%), and reducing to a minimum on day 12 (3.1%). The formation of acetovanillone increased only from day 2 onward, and reached a maximum (49.2%) on day 12. The optimum concentration of ferulic acid to be added into the medium was found to be only 0.5 g L^?1, as any increase in concentration (0.75 and 1.0 g L^?1) precipitated the precursor, resulting in no further degradation.     

Efficient bioreduction of ethyl 4-chloro-3-oxobutanoate to (S)-4-chloro-3-hydrobutanoate by whole cells ofCandida magnoliae in water/n-butyl acetate two-phase system

The asymmetric biosynthesis of ethyl (S)-4-chloro-3-hydrobutanoate from ethyl 4-chloro-3-oxobutanoate was investigated by using whole cells ofCandida magnoliae JX120-3 without the addition of glucose dehydrogenase or NADP⁺/NADPH. In a one-phase system, the bioconversion yield was seriously affected on the addition of 12.1 g/L ethyl 4-chloro-3-oxobutanoate. In order to reduce this substrate inhibition, a water/n-butyl acetate two-phase system was developed, and the bioreduction conditions optimized with regard to the yield and product enantiometric excess value. The optimal conditions were as following: water ton-butyl acetate volume ratio of 1∶1, 4.0 g DCW/L active cells, 50 g/L glucose and 35°C. By adopting a dropwise substrate feeding strategy, high concentration of ethyl 4-chloro-3-oxobutanoate (60 g/L) could be asymmetrically reduced to ethyl (S)-4-chloro-3-hydrobutanoate with high yield (93.8%) and high enantiometric excess value (92.7%).     

大叶桉叶水浸提液成分分析

为进一步明确大叶桉的化学成分,对大叶桉叶水浸提液分别用不同极性的有机溶剂石油醚、乙酸乙酯和正丁醇进行萃取,对各萃取相进行GC-MS分析。结果表明:大叶桉叶水浸提液共含有37种化合物,其中,石油醚萃取相中含有20种,主成分为草酸丁基异己酯(37.24%);乙酸乙酯萃取相中含有16种,主成分为2,2-二亚甲基双[6-(1,1-二甲基乙基-4-甲基)]-苯酚(50.05%);正丁醇萃取相中含有5种,主成分为丙基-2-甲基丁酸酯(54.57%)。在所有成分中,酯类物质居多,也有少量的烯、酮、醇、苯和烷烃。1-甲基,4-(1-甲基乙基)-1,4环己二烯、2,2-二亚甲基[6-(1,1-二甲基乙基)-4-甲基]苯酚、1-十八烯和二十烷为石油醚和乙酸乙酯的共有成分;1、2-苯二甲酸单(2-乙基己基)酯为乙酸乙酯和正丁醇的共有成分。该研究进一步明确了大叶桉的化学成分,为其在医药、化工和化感方面的应用研究奠定了基础。     

Production of ethyl acetate from dilute ethanol solutions by Candida utilis

The conversion of ethanol to ethyl acetate has an advantage as a method of ethanol recovery since ethyl acetate is amenable to simple solvent extraction. The potential of Candida utilis in this conversion was studied. The kinetics of accumulation of ethanol and ethyl acetate in glucose-grown C. utilis showed that ester formation resulted from ethanol utilization under appropriate aeration and was inhibited by Fe(3+) supplementation. Candida utilis converted ethanol to ethyl acetate optimally at pH 5.0-7.0. The five-hour rate of ester production increased as the ethanol concentration increased to 10 g/L, and rapidly declined to zero at concentrations exceeding 35 g/L. Thus, C. utilis has potential to recover dilute ethanol in the form of ethyl acetate.     

Biotransformation of ferulic acid to acetovanillone using Rhizopus oryzae

Microbial transformation of ferulic acid to acetovanillone was studied using growing cells of Rhizopus oryzae. Ferulic acid was added to the growing medium (0.5 g L^-1) and incubated for 12 days. The progress of formation of metabolites was monitored by GC and GC-MS after extraction with ethyl acetate. The major metabolite was acetovanillone with minor metabolites formed, such as dihydroferulic acid, coniferyl alcohol and dihydroconiferyl alcohol. Traces of metabolites (≤1-3%), such as vanillin, vanillyl alcohol, vanillic acid and phenyl ethyl alcohol, were also produced. Formation of 4-vinyl guaiacol increased from day 1 (12.4%), reaching a maximum on day 4 (31.7%), and reducing to a minimum on day 12 (3.1%). The formation of acetovanillone increased only from day 2 onward, and reached a maximum (49.2%) on day 12. The optimum concentration of ferulic acid to be added into the medium was found to be only 0.5 g L^-1, as any increase in concentration (0.75 and 1.0 g L^-1) precipitated the precursor, resulting in no further degradation.     

Enzymatic hydrolysis of olive wastewater for hydroxytyrosol enrichment

Aspergillus niger broth culture on wheat bran was assessed for olive wastewater (OW) hydrolysis in order to release hydroxytyrosol (HT). The enzyme profiles of this culture broth gave essentially (IU/L): 3000 β-glucosidase and 100 esterase. Hydrolysis activity of A. niger enzyme preparation was evaluated by using three substrates: raw OW, phenolic fraction extracted from OW by ethyl acetate and its corresponding exhausted fraction. Large amounts of free simple phenolics were released from exhausted fraction and raw OW after enzymatic treatment. HPLC analyses show that HT was the main phenolic compound. One step of ethyl acetate extraction of hydrolysed OW allowed the recovery of 0.8 g of HT per litre of OW. The antioxidant activity of extracts from OW and exhausted fraction, measured by DPPH method, was drastically enhanced after hydrolysis treatment. This study demonstrates that hydrolysed OW is a potential source of bioactive phenolic compounds with promising applications in food and pharmaceutical industries.     

发酵液中多拉菌素的提取和萃取条件研究

采用单因素实验,分别研究提取试剂、发酵液放置时间、pH值和温度对发酵液中多拉菌素提取效果的影响;然后以乙酸乙酯为萃取试剂,研究萃取次数及萃取体积对多拉菌素萃取效果的影响。结果显示,甲醇为最佳提取试剂;发酵液在pH为3～11、温度为20～80℃的条件下放置144 h,多拉菌素均能稳定存在,提取得到的多拉菌素的质量浓度没有显著变化;浓缩提取液液经2倍体积乙酸乙酯萃取2次即可。该条件下多拉菌素的质量浓度和萃取率分别为151.78μg/mL和98.00%。     

Enzyme-assisted extraction of fucoxanthin and lipids containing polyunsaturated fatty acids from Undaria pinnatifida using dimethyl ether and ethanol

A novel method for the efficient extraction of fucoxanthin and lipids containing polyunsaturated fatty acids (PUFAs) from the brown seaweed Undaria pinnatifida was developed and demonstrated at a laboratory scale. U. pinnatifida, also known as Wakame, contains a number of biologically active lipophilic compounds, particularly fucoxanthin, which has anti-oxidant, anti-cancer, anti-obesity and anti-inflammatory properties. The yield of fucoxanthin and lipids containing PUFAs was determined by extraction from wet and freeze-dried seaweed using dimethyl ether (DME) and ethanol and from enzyme-pretreated seaweed using the same solvents. The highest yields of fucoxanthin (94%) and lipids (94%) rich in PUFAs were obtained from fresh (wet) U. pinnatifida by enzyme pre-processing, followed by extraction using DME with ethanol as a co-solvent. In comparison, ethanol extraction resulted in lower extraction yields for both fucoxanthin (86%) and lipids (73%) under the conditions described. Enzyme pre-processing using alginate lyase resulted in the hydrolysis of cell wall polysaccharides, resulting in high extraction yields. The hydrolysis time, pH and temperature were found to be the most important parameters for the enzyme pre-processing step and for minimizing fucoxanthin losses due to oxidative degradation. The removal of water-soluble compounds (polysaccharides) following the enzyme pre-treatment prior to DME extractions doubled the throughput and maximized the yield. The residual biomass was colorless or a pale-brown color after the DME extraction, which indicated the highly effective extraction of fucoxanthin. The PUFA content and fucoxanthin levels were not affected by the enzyme or extraction using the described enzyme-assisted DME + ethanol co-solvent process.     

Determination of diclazuril, toltrazuril and its two metabolites in poultry tissues and eggs by gel permeation chromatography-liquid chromatography-tandem mass spectrometry

A new procedure has been described for the extraction of diclazuril (DIZ), toltrazuril (TOZ) and its two main metabolites toltrazuril sulphoxide (TZSO) and toltrazuril sulphone (TZS) from poultry tissues and eggs, using gel permeation chromatography (GPC). The analytes and the deuterated internal standard were extracted from the samples with ethyl acetate. The analytes were measured by LC coupled to an electrospray ionization tandem mass spectrometer operating in the negative ion mode. Excellent linear dynamic range was observed from 1 to 500 μg/L with the correlation coefficients (R(2)) better than 0.99 for all analytes. The method LOQ of the four analytes in real samples was 1.2 μg/kg for DIZ and TOZ, and 1.8 μg/kg for TZSO and TZS. These values are far lower than the maximum residue limits (MRLs) established by several control authorities. The developed method was accurate with overall recoveries in four matrices.     

Determination of aconitine,hypaconitine and mesaconitine in urine using hollow fiber liquid-phase microextraction combined with high-performance liquid chromatography

Hollow fiber liquid-phase microextraction (HF-LPME) coupled with high-performance liquid chromatography was used to simultaneously determine three Aconitum alkaloids, including aconitine (AC), hypaconitine (HA) and mesaconitine (MA) in human urine sample. Analytes were extracted from 5 mL urine sample containing 1.0 mmol/L NaOH into 1-octanol membrane phase impregnated in the pores of hollow fiber wall, and then back extracted into acidified aqueous solution in the lumen of the hollow fiber. After extraction, 10 μL of the acceptor phase was analyzed directly by HPLC. In this method, some important extraction parameters, such as organic solvent, extraction time, stirring rate, pH of donor phase and acceptor phase, temperature, and the volume of acceptor phase were optimized. This method provided 98- to 288-fold enrichment factors within 60 min of extraction and good repeatability with RSDs of 0.99–7.22%. The calibration curves were linear over the ranges of 16.0–128.0 μg/L for AC, 11.0–88.0 μg/L for HA and 8.1–64.8 μg/L for MA in human urine sample, with correlation coefficients of 0.9949, 0.9969 and 0.9904, respectively. Limits of detection were from 0.7 to 1.5 μg/L, and recoveries from spiked urine sample varied from 84.4% to 106.2% for AC, 77.3% to 85.6% for HA and 90.1% to 100.8% for MA.     

Solid-phase microextraction for determining twelve orange flavour compounds in a model beverage emulsion

Solid-phase microextraction (SPME) coupled to gas chromatography has been applied for the headspace analysis (HS) of 12 target flavour compounds in a model orange beverage emulsion. The main volatile flavour compounds studied were: acetaldehyde, ethyl acetate, alpha-pinene, ethyl butyrate, beta-pinene, myrcene, limonene, gamma-terpinene, octanal, decanal, linalool and citral (neral plus geranial). After screening the fibre type, the effect of other HS-SPME variables such as adsorption temperature (25-55 degrees C), extraction time (10-40 min), sample concentration (1-100% w/w), sample amount (5-10 g) and salt amount (0-30% w/w) were determined using a two-level fractional factorial design (2(5-2)) that was expanded further to a central composite design. It was found that an extraction process using a carboxen-polydimethylsiloxane fibre coating at 15 masculineC for 50 min with 5 g of diluted emulsion 1% (w/w) and 30% (w/w) of sodium chloride under stirring mode resulted in the highest HS extraction efficiency. For all volatile flavour compounds, the linearity values were accurate in the concentration ranges studied (r(2) > 0.97). Average recoveries that ranged from 90.3 to 124.8% showed a good accuracy for the optimised method. The relative standard deviation for six replicates of all volatile flavour compounds was found to be less than 15%. For all volatile flavour compounds, the limit of detection ranged from 0.20 to 1.69 mg/L.     

印度块菌提取物抗氧化活性的研究

对印度块菌Tuber indicum子实体的提取物,包括55%乙醇粗提物(ECE)、石油醚提取物(PEF)和乙酸乙酯提取物(EAF)的清除DPPH自由基和羟基自由基能力、铁离子鳌合能力以及各提取物的总酚含量等进行了研究和测定,结果显示,3种提取物的清除自由基能力和铁离子鳌合能力具有显著差异(P0.05);ECE对DPPH自由基的清除活性最高,其EC50值为1.61g/L;EAF对羟基自由基及铁离子表现出较强的清除或螯合的能力,其EC50值分别为3.31g/L和0.70g/L;EAF的总酚含量(2.964mg GAE/g提取物)最高,其次是ECE,总酚含量为(2.618mg GAE/g提取物);PEF的清除自由基和铁离子鳌合能力较差,其总酚含量也最低(1.124mg GAE/g提取物);总酚含量与印度块菌提取物清除自由基以及鳌合铁离子的能力密切相关。     

Hydrogel-Forming Microneedle Arrays Allow Detection of Drugs and Glucose In Vivo: Potential for Use in Diagnosis and Therapeutic Drug Monitoring

We describe, for the first time the use of hydrogel-forming microneedle (MN) arrays for minimally-invasive extraction and quantification of drug substances and glucose from skin in vitro and in vivo. MN prepared from aqueous blends of hydrolysed poly(methyl-vinylether-co-maleic anhydride) (11.1% w/w) and poly(ethyleneglycol) 10,000 daltons (5.6% w/w) and crosslinked by esterification swelled upon skin insertion by uptake of fluid. Post-removal, theophylline and caffeine were extracted from MN and determined using HPLC, with glucose quantified using a proprietary kit. In vitro studies using excised neonatal porcine skin bathed on the underside by physiologically-relevant analyte concentrations showed rapid (5 min) analyte uptake. For example, mean concentrations of 0.16 μg/mL and 0.85 μg/mL, respectively, were detected for the lowest (5 μg/mL) and highest (35 μg/mL) Franz cell concentrations of theophylline after 5 min insertion. A mean concentration of 0.10 μg/mL was obtained by extraction of MN inserted for 5 min into skin bathed with 5 μg/mL caffeine, while the mean concentration obtained by extraction of MN inserted into skin bathed with 15 μg/mL caffeine was 0.33 μg/mL. The mean detected glucose concentration after 5 min insertion into skin bathed with 4 mmol/L was 19.46 nmol/L. The highest theophylline concentration detected following extraction from a hydrogel-forming MN inserted for 1 h into the skin of a rat dosed orally with 10 mg/kg was of 0.363 μg/mL, whilst a maximum concentration of 0.063 μg/mL was detected following extraction from a MN inserted for 1 h into the skin of a rat dosed with 5 mg/kg theophylline. In human volunteers, the highest mean concentration of caffeine detected using MN was 91.31 μg/mL over the period from 1 to 2 h post-consumption of 100 mg Proplus^® tablets. The highest mean blood glucose level was 7.89 nmol/L detected 1 h following ingestion of 75 g of glucose, while the highest mean glucose concentration extracted from MN was 4.29 nmol/L, detected after 3 hours skin insertion in human volunteers. Whilst not directly correlated, concentrations extracted from MN were clearly indicative of trends in blood in both rats and human volunteers. This work strongly illustrates the potential of hydrogel-forming MN in minimally-invasive patient monitoring and diagnosis. Further studies are now ongoing to reduce clinical insertion times and develop mathematical algorithms enabling determination of blood levels directly from MN measurements.