枯草芽孢杆菌SN-02发酵液的抑菌谱及稳定性研究

目的:研究枯草芽孢杆菌SN-02发酵液的抑菌谱及稳定性。方法:以28种植物病原菌为供试菌,杯碟法测定SN-02菌发酵液的抑菌谱;以烟草靶斑病菌为指示菌,杯碟法测定发酵液的热稳定性、酸碱稳定性及传代稳定性。结果:SN-02菌发酵液对28种供试菌株的抑菌圈直径在20mm以上。将发酵液于120℃处理2.5h,-20℃处理25d抑菌活性没有明显变化;发酵液在pH 4~9时抑菌活性无明显变化,在pH 1~3和pH 10条件下抑菌活性明显下降;连续培养10代,发酵液抑菌活性没有下降。结论:SN-02菌发酵液抑菌谱较广,耐高温和低温,传代稳定性好,但在强酸和强碱条件下稳定性较差。     

浙贝母内生真菌Nectria sp. JZ6分泌抑菌活性代谢产物的初步研究

Nectria sp.JZ6是从浙贝母新鲜鳞茎中首次分离到的一株内生真菌,其发酵液具有抑菌活性。为建立该真菌稳定分泌抑菌活性成分的发酵体系,本研究利用单因素实验和正交实验确定了发酵培养基的配方并初步优化了发酵条件。结果表明,将活化后的菌种接种于改良查氏培养基(8%葡萄糖,0.5%蛋白胨,0.05%KCl,0.1%K2HPO4,0.15%MgSO4,pH6.5)中,28℃、150r/min振荡培养6d后获得的发酵液抑菌活性比优化前提高了26%。该发酵液经100℃水浴30min不失活,在pH1-5时抑菌活性相对稳定,其后逐渐减弱,并在pH9.0及以上时丧失。Nectriasp.JZ6发酵液的乙酸乙酯浸膏抑菌活性最强,对金黄色葡萄球菌、藤黄八叠球菌、枯草芽孢杆菌、绿脓杆菌和大肠杆菌的最低抑菌浓度(MIC)分别为0.625、0.625、1.25、1.25和1.25mg/mL。     

解淀粉芽胞杆菌PC2产抑菌物质培养基及发酵条件优化

【目的】优化解淀粉芽胞杆菌PC2产抑菌活性物质发酵培养基及发酵条件。【方法】以马铃薯葡萄糖液体培养基为基础,依据发酵液对金黄色葡萄球菌抑菌圈的单因素试验结果,采用Box-Behnken响应面法优化发酵培养基,二次通用旋转组合设计,频率分析法优化发酵条件。【结果】影响发酵液抑菌活性的培养基主要组分为马铃薯、蔗糖和L-谷氨酸钠,最优发酵培养基配方为:马铃薯188.0 g/L,蔗糖22.0 g/L,L-谷氨酸钠1.80 g/L,培养基成本为0.81元/L;最佳发酵条件为:接种量6%、发酵温度30°C、装液量40 mL/250 mL、摇床转速185 r/min、发酵时间24 h、初始pH 7.0。优化后发酵液对金黄色葡萄球菌抑菌圈直径为30.82 mm,较优化前的18.22 mm增加了12.60 mm。【结论】优化后的培养基和发酵条件提高了解淀粉芽胞杆菌PC2发酵液的抑菌活性,为该菌株的工业化生产应用提供了依据。     

解淀粉芽孢杆菌SC1150 的抑菌活性及其液体发酵条件的优化

通过比较解淀粉芽孢杆菌SC1150 菌株发酵液对香蕉枯萎病菌4 号生理小种的抑菌活性, 对解淀粉芽孢杆菌SC1150 菌株液体发酵条件进行了优化研究。结果显示: 在固体培养条件下解淀粉芽孢杆菌SC1150 菌株对测试的8 种作物病原菌均有抑制作用, 其中对香蕉枯萎病菌4 号生理小种的抑制作用特别强烈, 其抑菌圈直径达到23.31 mm。以香蕉枯萎病菌4 号生理小种为指示菌, 对该活性SC1150 菌株的液体发酵条件进行优化, 液体发酵培养基各组分的最佳配比为0.5%可溶性淀粉(碳源)、1.5%蛋白胨+酵母粉(1︰1)的混合氮源、0.1%NaCl; 最佳培养条件: pH 6.5、30 ℃、摇床转速确180 rmin–1。优化后SC1150 菌株对香蕉枯萎病菌4 号生理小种的抑菌圈直径达到 28.33 mm。     

反复冻融对枯草芽孢杆菌St-zn-34抑制链格孢菌活性的影响北大核心CSCD

【目的】以从冬枣分离的内生枯草芽孢杆菌(Bacillus subtilis St-zn-34)为供试菌株,明确反复冻融对菌体形态及其发酵滤液抑制枣缩果病初侵染病菌(Alternaria alternata)活性的变化。【方法】对供试菌株分批发酵后进行反复冻融,采用梯度稀释计数法、滤纸片法分别测定活菌数量和芽孢含量、发酵滤液抑菌活性,对供试菌株的形态变化进行电镜观察。【结果】发酵培养中pH值、活菌量、芽孢量及抑菌活性随发酵时间的增加均呈先上升后下降的趋势,其中发酵60 h发酵滤液抑菌活性最大,对此时的发酵液反复冻融,冻融3次枯草芽孢杆菌活菌量和发酵滤液抑菌活性依次减少,以后再冻融差异不显著(P>0.05),电镜观察发现随冻融次数增加,菌体变小,表面凹陷、扭曲,胶状物流出。抑菌谱检测发现发酵滤液对12种植物病原菌具有抑菌能力。不同温度和蛋白酶处理发酵滤液表明,低于60℃以下,抑菌活性与对照相比差异不显著;80℃以上抑菌活性随温度上升而下降,与对照相比差异显著;蛋白酶K可降低抑菌活性。【结论】反复冻融影响细菌形态并降低发酵滤液的抑菌活性。     

家蝇幼虫血淋巴粗提物抑菌活性初步研究

以4种细菌(大肠杆菌、金黄色葡萄球菌、巨大芽孢杆菌、枯草芽孢杆菌)为供试菌,测定了家蝇幼虫血淋巴粗提物的抑菌活性。结果显示,家蝇幼虫血淋巴各浓度粗提物对4种供试细菌均有一定的抑菌活性,其中对金黄色葡萄球菌的抑菌率最大,其他依次为大肠杆菌>枯草芽胞杆菌>巨大芽孢杆菌,在0.8mg/mL时的抑菌率分别为51.09%、48.66%、43.27%和40.62%;在各浓度下不同菌种之间的抑菌率差异不显著,抑菌活性随着血淋巴粗提物浓度的增加而增强。在0.8mg/mL时对各细菌的抑菌圈直径分别为12.00mm、12.22mm、9.11mm和10.33mm,均显著大于对照,但低于头孢霉素。     

风信子中抗青霉素内生菌的分离、筛选和活性检测

通过用初筛培养基培养,从风信子叶子中分离出一种抗青霉素的内生菌,进行离体培养和抑菌活性检测。结果表明所筛选的菌株的发酵产物对细菌和真菌均有一定的抑菌活性。其中发酵液提取物对枯草芽孢杆菌有一定的抑菌活性,对苹果干腐病原菌和烟草赤星病原菌的抑菌率分别是94.8%和93.8%,而菌体内的活性物对蜡状芽孢杆菌和枯草芽孢杆菌都有较高的活性,对苹果干腐病原菌、烟草赤星病原菌和苹果轮纹病原菌的抑菌率都在80%以上。     

海洋真菌梅花状青霉FS83抗菌抗肿瘤活性研究

采用滤纸片法测定海洋真菌梅花状青霉(Penicillium herquei)FS83的发酵提取物对金黄色葡萄球菌(Staphylococcusaureus)、枯草芽孢杆菌(Bacillus subtilis)、铜绿假单胞菌(Pseudomonas aeruginosa)和大肠杆菌(Escherichia coli)的抑菌活性,采用生长速率法测定提取物对绿色木霉(Trichoderma viride)、黑曲霉(Aspergillus niger)、黄曲霉(Aspergillus flavus)、链格孢(Alterna-ria alternata)和胶孢炭疽菌(Colletotrichum gloeosporioides)的抗真菌活性,并采用连续稀释法测定提取物对所有细菌和真菌的最低抑制浓度(MIC值)。此外,还通过MTT法测试提取物对人肺癌细胞(NCI-H460)、人乳腺癌细胞(MCF-7)和人神经胶质瘤细胞(SF-268)的细胞毒活性。结果表明,菌丝体提取物对金黄色葡萄球菌和枯草芽孢杆菌有明显的抑制活性,抑菌圈分别为18.1 mm、17.3 mm,最低抑制浓度均为1.56 mg/mL,对所有供试真菌也有较好的抑制作用,抑菌率均达50%以上,最低抑制浓度为0.78-3.12mg/mL;发酵液提取物对枯草芽孢杆菌有明显的抑制作用,抑菌圈达16.4 mm,最低抑制浓度均为1.56 mg/mL,对所有供试真菌也有较好的抑制作用,最低抑制浓度为1.56-6.25 mg/mL。菌丝体提取物对3种肿瘤细胞株有较强的细胞毒活性,IC50值为55.9-63.5μg/mL,发酵液提取物对肿瘤细胞株MCF-7有较强的细胞毒活性,在200μg/mL浓度下的抑制率为84.3%。     

一株对稻瘟病菌有抗菌活性的特基拉芽孢杆菌 WRN032的筛选及发酵条件优化

采用牛津杯法抑菌试验,根据多种芽孢杆菌对不同植物病原真菌的生长抑制效果进行筛选,得到特基拉芽孢杆菌WRN032对稻瘟病菌的生长抑制效果最佳。以吸光度和抑菌圈直径为指标,设计进行单因素试验、多因素显著性筛选试验和中心点复合试验对特基拉芽孢杆菌WRN032的发酵条件进行优化,得到该菌株抗菌活性最优的发酵条件为:接种量1%,摇瓶装液量40%,葡萄糖浓度2%,摇床转速220 rpm,初始pH6.5,培养时间48 h,培养温度30℃。在此条件下,特基拉芽孢杆菌WRN032的发酵液吸光度和萃取物的抑菌圈直径与优化前相比分别提高了186.63%和154.10%。     

枯草芽孢杆菌HAINUP40的培养条件及其抑菌物质分析

前期研究表明枯草芽孢杆菌HAINUP40能够有效拮抗罗非鱼无乳链球菌,是潜在的益生菌。为了进一步优化其培养条件,并探索其其抑菌机理,本研究通过普通平板扩散法和单因素变量控制法,探究了培养条件的改变对菌株HAINUP40发酵的影响,同时确定发酵上清液抑菌活性成分及其稳定性。结果表明菌株HAINUP40的最宜培养条件为:普通淡水培养基,pH值为7.0～7.5,温度34℃,培养时长24 h,转速为50～150 r/min。HAINUP40发酵上清液中抑菌活性物质可以被80%(NH_4)_2SO_4溶液析出,对蛋白酶K敏感,不耐高温,pH4或8时失去抑菌活性,可以耐受短时间(180 s)紫外线照射。综上证明枯草芽孢杆菌HAINUP40所分泌的抑菌活性物质为大分子蛋白质,且非小分子抗菌肽。本研究为枯草芽孢杆菌HAINUP40在生物防治方面的大规模应用提供了重要的参考依据。     

Fermentation of methanol in the sheep rumen

Sheep fed a hay-concentrate diet were adapted to pectin administration and ruminal infusion of methanol. Both treatments resulted in a strong increase in the rate of methanogenesis from methanol. Quantitative data show that methanol was exclusively converted into methane. Treatments did not influence ruminal volatile fatty acid percentages.     

葡萄糖酸钙对L-组氨酸发酵的影响及条件优化

目的：提高L-组氨酸的产量并且得出最佳发酵条件。方法：在L-组氨酸的摇瓶发酵实验中,加入20g/L的葡萄糖酸钙,对发酵条件进行优化。结果：L-组氨酸的产量大幅度提高,产酸量由3.00g/L提高到7.50g/L。条件优化后L-组氨酸的产量提高到9.30g/L。结论：发酵培养基中20g/L的葡萄糖酸钙的加入能够诱导葡萄糖酸激酶生成,大幅度提高其比活,增大磷酸戊糖（HMP）途径的通量。有利于L-组氨酸的合成、菌体的生长。     

蔗渣发酵菌剂培养基的筛选及发酵条件的优化

采用单因素和正交试验研究了蔗渣高效发酵菌剂(芽孢杆菌B-A、曲霉菌F-A、链霉菌A-B)的摇瓶发酵最佳工艺条件.结果表明:芽孢杆菌B-A的最佳培养基配方:牛肉膏0.3%、蛋白胨1%、葡萄糖1%、NaCl 0.5%、可溶性淀粉0.5%、3.08%浓度的MnSO4溶液0.1;最适发酵条件为pH7、装液量100 ml(250 ml三角瓶)、36℃培养27 h.曲霉F-A的最佳培养基配方:葡萄糖3%、豆饼粉3%、蛋白胨1.2%、酵母膏0.3%、K2HPO4 0.05%、KH2PO40.05%、CaCl20.08%、MgSO40.04%、MnSO40.04%、ZnSO40.02%;最适发酵条件为pH6、装液量50 ml、30℃培养3 d.链霉菌A-B的最佳培养基配方:可溶性淀粉4.5%、蔗糖1%、豆饼粉3%、NaNO30.2%、ZnSO40.01%、KH2PO40.001%;最适发酵条件为pH7、装液量50 ml、30℃培养3 d.     

Mechanism of Fermentation Conversion from Polyalcohol Fermentation to Ethanol Fermentation by Pichia miso

A possible mechanism of fermentation conversion is described from polyalcohol fermentation to ethanol fermentation by Pichia miso. Little alcohol dehydrogenase activity was found in polyalcohol-producing cells, whereas higher enzyme activity was induced by ethanol-producing cells. The fermentation conversion may be caused by the different levels of alcohol dehydrogenase activity between polyalcohol- and ethanol-producing cells. It was also shown that yeast growth was inhibited and that yeast cells were lysed by ethanol (at 6g/100ml) that accumulated in 24 hr.     

Enzymatic Studies on the Conversion of Erythritol Fermentation to d-Mannitol Fermentation in n-Alkane-grown Yeast Candida zeylanoides

In the polyol fermentation by Candida zeylanoides KY6166, which occurred preferentially by keeping the pH of medium at acidic side (below 4.0), phosphate ion played a precise role in the conversion of erythritol fermentation to d-mannitol fermentation. Enzymatic studies on the conversion mechanism provided the following evidences.

The enzymes involved in pentosephosphate cycle were considerably depressed in polyol production phase in which intracellular pH ranged from 5.5 to 5.7. Particularly transaldolase responsible for the synthesis of erythrose 4-phosphate and fructose 6-phosphate from glyceraldehyde 3-phosphate plus d-sedoheptulose 7-phosphate was significantly depressed at pH 5.5. Besides, transketolase which participated directly in the formation of erythrose 4-phosphate from fructose 6-phosphate was significantly inhibited by phosphate ion. Glucose 6-phosphate dehydrogenase was slightly inhibited by phosphate ion.

The enzymes involved in pentosephosphate cycle were considerably depressed in polyol production phase in which intracellular pH ranged from 5.5 to 5.7. Particularly transaldolase responsible for the synthesis of erythrose 4-phosphate and fructose 6-phosphate from glyceraldehyde 3-phosphate plus d-sedoheptulose 7-phosphate was significantly depressed at pH 5.5. Besides, transketolase which participated directly in the formation of erythrose 4-phosphate from fructose 6-phosphate was significantly inhibited by phosphate ion. Glucose 6-phosphate dehydrogenase was slightly inhibited by phosphateion. From these results, the alteration from erythritol fermentation to mannitol fermentation by phosphate ion was explained as the result of the change in the level of erythrose 4-phosphate and fructose 6-phosphate which was caused by the inhibition of transketolase.     

Fermentation of methanol in the sheep rumen.

Sheep fed a hay-concentrate diet were adapted to pectin administration and ruminal infusion of methanol. Both treatments resulted in a strong increase in the rate of methanogenesis from methanol. Quantitative data show that methanol was exclusively converted into methane. Treatments did not influence ruminal volatile fatty acid percentages.