脱色细菌的分离和对偶氮染料的脱色研究

从印染废水中分离到8株对多种染料具有较好脱色效果的细菌,在所试验的10种染料中对其中大部分都有较好的脱色作用,尤其对三种酸性黑10B、酸性黑NG、直接湖蓝的脱色率最高;在各菌株最适条件下对这三种染料脱色率都能达到80%以上,其中有些菌株对直接湖蓝的脱色率达到100%。本实验研究了这8个菌株在不同的pH值、温度、需氧量条件下对这三种染料的脱色情况,并对有代表性的菌株脱色前后的化学需氧量(COD)值进行测定来判断染料的降解情况。     

脱色希瓦氏菌S12的铁还原性能研究*

从印染废水中分离得到了一株具有染料脱色功能的希瓦氏菌脱色新种。该菌能在厌氧条件下利用Fe3+作为末端电子受体获得能量,支持细胞生长。在pH8．0,温度30℃,柠檬酸铁800mg／L,乳酸钠2g／L,酵母抽提物0．5g／L的条件下,培养8h的过程中,菌体细胞量的增长完全与Fe3+的还原发展趋向一致。同时考察了碳氮源、乳酸钠、酵母抽提物、pH值和温度等方面对该菌株的生长和铁还原特性的影响。结果表明,菌体生长以LB为最好,以葡萄糖和乳酸钠为碳源时对铁还原有利。在酵母抽提物浓度4g／L范围内,菌体生长量和铁还原率     

一株高效广谱染料降解细菌的分离鉴定及脱色特性研究

通过梯度驯化,从印染废水长期污染土壤中分离筛选出能以4种不同结构类型的染料(刚果红、美蓝、孔雀绿和活性艳蓝KN-R)为唯一碳源的菌株XSMR,根据其形态学特征和生理生化鉴定及16S rDNA序列分析,初步鉴定为无色杆菌属(Achromobacter sp.)的菌株。菌株XSMR对4种染料均具有强的脱色降解能力,且对染料脱色的同时,自身能够生长繁殖,培养24h菌体干重超过不加染料的对照。在振荡培养条件下对该菌株的脱色反应条件进行研究,结果表明,当刚果红、美蓝、孔雀绿及活性艳蓝KN-R的初始浓度分别小于200mg/L、200mg/L、150mg/L及150mg/L时,在pH7.5、温度35℃、接种量4%(V/V)条件下,接种菌株XSMR脱色14h对4种染料的脱色率均可达到98%以上。通过对降解产物的紫外-可见光谱分析,进一步证明了菌株XSMR能彻底降解染料。菌株XSMR对染料脱色的机理包括生物降解和菌株吸附两方面。     

脱色希瓦氏菌S12的铁还原性能研究

从印染废水中分离得到了一株具有染料脱色功能的希瓦氏菌脱色新种。该菌能在厌氧条件下利用Fe^3＋作为末端电子受体获得能量,支持细胞生长。在pH8．0．温度30℃。柠檬酸铁800mg／L,乳酸钠2g／L,酵母抽提物0．5g／L的条件下,培养8h的过程中,菌体细胞量的增长完全与Fe^3＋的还原发展趋向一致。同时考察了碳氮源、乳酸钠、酵母抽提物、pH值和温度等方面对该菌株的生长和铁还原特性的影响。结果表明,菌体生长以LB为最好,以葡萄糖和乳酸钠为碳源时对铁还原有利。在酵母抽提物浓度4g／L范围内,菌体生长量和铁还原率随着酵母抽提物浓度的提高而提高。当乳酸钠为6g／L时,S12菌体生长量和铁还原率达到最佳。柠檬酸铁浓度为800mg／L时菌体生长量和铁还原率最高。在起始pH6-8的范围内,菌株S12的生长随着pH升高而升高,这也是菌株S12进行铁还原的最佳pH范围。菌株S12在温度范围20℃-40℃内均可生长和进行铁还原,而以30℃时最佳。     

脱色希瓦氏菌(Shewanella decolorationis)S12T的脱色特性

从印染废水活性污泥中分离到一株高效染料脱色菌,经鉴定该菌株为希瓦氏菌属的一个新种,命名为脱色希瓦氏菌(Shewanelladecolorationis)S12T。该菌株在偶氮染料浓度为50mg/L的培养基中培养4h后,染料去除率达到96%,对偶氮染料的最高脱色浓度达到2000mg/L。在浓度为500mg/L的偶氮染料平板上生长4d后,可观察到明显的脱色圈。全波长光谱扫描的结果表明希瓦氏菌S12T以生物降解的方式对偶氮染料进行脱色。希瓦氏菌S12T的脱色酶为组成型的胞内酶。     

脱色希瓦氏菌(Shewanella decolorationis)S12T的脱色特性*

从印染废水活性污泥中分离到一株高效染料脱色菌,经鉴定该菌株为希瓦氏菌属的一个新种,命名为脱色希瓦氏菌(Shewanelladecolorationis)S12^T。该菌株在偶氮染料浓度为50mg/L的培养基中培养4h后,染料去除率达到96%,对偶氮染料的最高脱色浓度达到2000mg/L。在浓度为500mg/L的偶氮染料平板上生长4d后,可观察到明显的脱色圈。全波长光谱扫描的结果表明希瓦氏菌S12^T以生物降解的方式对偶氮染料进行脱色。希瓦氏菌S12相似文献   

细菌利用不同碳、氮源共代谢降解脱色偶氮染料研究进展

本文主要综述了细菌利用碳、氮源等不同共代谢基质降解脱色偶氮染料的研究进展。综合文献结果表明,在单一碳源、单一氮源、复合碳氮源等不同共代谢基质条件下,细菌降解脱色偶氮染料的效能存在较大差异。其影响因素主要包括碳源种类、氮源种类、浓度、碳氮源复合比例等,其中碳、氮源种类影响最为显著。针对偶氮染料,只有提供合适的碳、氮源共代谢基质,才能对细菌降解脱色的效果起到明显的促进作用。同时,在不同碳、氮源共代谢基质条件下,细菌菌群群落结构及优势功能菌种差异较大,而不同碳、氮源共代谢基质作为偶氮染料还原脱色的电子供体,产生的脱色效能也有显著不同。最后,对利用碳、氮源共代谢降解脱色偶氮染料的研究方向进行了展望,认为复合合适的碳、氮源在提高细菌菌群降解脱色效率方面具有较大潜力,另一方面,细菌混合菌群利用碳、氮源共代谢降解脱色偶氮染料的微观分子生态学机制,酶学作用机制,功能菌种与功能蛋白之间相互作用机制等还有待深入研究。     

染料脱色菌与芳胺降解菌的筛选及降解染料研究

从印染厂废水处理系统的曝气池中分离到17株对多种染料有较高脱色能力的细菌,其脱色率都在80%以上,但偶氮染料脱色后产生的中间产物多数为无色的芳香胺类化合物,大多数细菌不能将其进一步降解。为此,通过富集培养和梯度驯化又筛选到一株以对硝基苯胺为唯一碳、氮源的菌株J18,该菌株虽对染料脱色能力很弱,却能够降解芳香胺类化合物。将芳香胺降解菌J18与染料脱色菌H两菌株混合培养,在最适条件下,结果使染料的脱色率和芳胺降解率均到达90%和85%以上,从而达到了彻底降解染料的目的。     

三种白腐真菌脱色噻嗪染料亚甲基蓝

本研究通过含亚甲基蓝染料的固体培养基,从19株白腐真菌菌株中分离获得3个脱色能力较强的菌株,其在平板上的脱色圈大小分别为7.5cm、6.8cm和5.5cm。鉴定其为：云芝栓孔菌Trametes versicolor（ZT-197）,绒毛栓孔菌Trametes pubescens（ZT-230）和亚黑管孔菌Bjerkandera fumosa（ZT-307）。其中,ZT-230对染料亚甲基蓝的脱色能力最强,可以将染料浓度为50mg/L的100mL液体培养基在6d之内100%脱色,而ZT-197和ZT-307在接种第10天时的脱色率为98%和80%。同时测定了3株白腐真菌在降解染料过程中的漆酶、锰过氧化物酶和木素过氧化物酶3种酶活力的规律：ZT-197和ZT-230均可分泌Lac和MnP两种酶,ZT-307只分泌LiP。本研究说明绒毛栓孔菌ZT-197在印染废水治理方面具有较好的应用前景。     

白腐真菌染料脱色菌株的筛选及一色齿毛菌脱色条件的研究

以平皿培养方式对采集自中国和芬兰的白腐真菌菌株降解6种不同结构的人工染料的能力进行了筛选研究。在40株菌株中,黑管孔菌Bjerkandera adusta Y5012,一色齿毛菌Cerrena unicolor Y5002,硬毛粗盖孔菌Funalia trogii Y4997,香栓孔菌Trametes suaveolens D8325和云芝栓孔菌Trametes versicolor Y4946对刚果红、橙黄G、茜素红、结晶紫、中性红和亚甲基蓝均显示出较强的脱色能力。对一色齿毛菌Cerrena unicolor Y5002的液体培养脱色条件进行了研究,其最适碳源和氮源分别为蔗糖和麦芽浸粉;在不同橙黄G浓度下均获得较高的脱色率,因此浓度为500mg/L的橙黄G未对该菌的脱色能力产生抑制作用,而浓度为400mg/L茜素红则对其脱色作用产生明显抑制。对菌丝生物量和染料脱色率的研究表明,在不同碳源和氮源条件下,两者之间具有明显的正相关性。     

Decolorization of a dye industry effluent by <Emphasis Type="Italic">Aspergillus fumigatus</Emphasis> XC6

The strain Aspergillus fumigatus XC6 isolated from mildewing rice straw was evaluated for its ability to decolorize a dye industry effluent. The strain was capable of decolorizing dyes effluent over a pH range 3.0–8.0 with the dyes as sole carbon and nitrogen sources. The optimum pH was 3.0; however, supplemented with either appropriate nitrogen sources (0.2% NH₄Cl or (NH₄)₂SO₄ ) or carbon sources (1.0% sucrose or potato starch), the strain decolorized the effluent completely at the original pH of the dyes effluent. Therefore, A. fumigatus XC6 is an efficient strain for the decolorization of reactive textile dyes effluents, and it might be a practical alternative in dyeing wastewater treatment.     

多孔菌Trichaptum abietinum 1302BG自然条件下对合成染料刚果红和酸性品红的高效降解

选用杭州竹林土壤分离并筛选能够降解多种类型染料的真菌。经大量筛选发现一株编号为1302BG的真菌能够在固体培养基上分解所测试的全部9种染料(苯胺蓝、刚果红、橙黄G、甲基红、甲基橙、结晶紫、酸性品红、番红花红、碱性品红、甲基紫)。经形态学和分子生物学方法鉴定, 该菌1302BG为冷杉附毛孔菌(Trichaptum abietinum)。在液体培养基中研究了pH、温度、碳源、氮源、碳氮源组合、碳氮源浓度等参数对该菌脱色效果的影响, 以寻找最适最经济的脱色条件。在液体培养基中研究表明, 冷杉附毛孔菌1302BG既能在酸性又能在碱性条件下有效分解2种测试染料(酸性品红和刚果红)。该真菌能以仅含有0.5 g/L淀粉和0.05 g/L硫酸铵的经济、环境友好的培养基为底物, 能在灭菌和非灭菌(自然)的条件下高效脱色, 在24 h内对2种染料的脱色率均在90%以上。紫外/可见光谱及微核试验分析显示, 该菌脱色主要是以生物降解为主, 2种染料经该菌分解后的毒性也同时大大降低。这些优异特点显示了该菌具有非常广阔的工业染料废水处理应用潜力。     

Characterization of azo reduction activity in a novel ascomycete yeast strain

Several model azo dyes are reductively cleaved by growing cultures of an ascomycete yeast species, Issatchenkia occidentalis. In liquid media containing 0.2 mM dye and 2% glucose in a mineral salts base, more than 80% of the dyes are removed in 15 h, essentially under microaerophilic conditions. Under anoxic conditions, decolorization does not occur, even in the presence of pregrown cells. Kinetic assays of azo reduction activities in quasi-resting cells demonstrated the following: (i) while the optimum pH depends on dye structure, the optimum pH range was observed in the acidic range; (ii) the maximum decolorizing activity occurs in the late exponential phase; and (iii) the temperature profile approaches the typical bell-shaped curve. These results indirectly suggest the involvement of an enzyme activity in azo dye reduction. The decolorizing activity of I. occidentalis is still observed, although at a lower level, when the cells switch to aerobic respiration at the expense of ethanol after glucose exhaustion in the culture medium. Decolorization ceased when all the ethanol was consumed; this observation, along with other lines of evidence, suggests that azo dye reduction depends on cell growth. Anthraquinone-2-sulfonate, a redox mediator, enhances the reduction rates of the N,N-dimethylaniline-based dyes and reduces those of the 2-naphthol-based dyes, an effect which seems to be compatible with a thermodynamic factor. The dye reduction products were tested as carbon and nitrogen sources. 1-Amino-2-naphthol was used as a carbon and nitrogen source, and N,N-dimethyl-p-phenylenediamine was used only as a nitrogen source. Sulfanilic and metanilic acids did not support growth either as a carbon or nitrogen source.     

The use of solid waste of a nylon-6 plant as a nutrient for bacterial decolourisation of dyes

Three caprolactam-degrading bacterial isolates grew in liquid synthetic medium containing solubilised solid waste of a nylon-6 production plant as the sole source of carbon and nitrogen. Typically, the caprolactam content of solid waste was decreased by 95% in 72 h by Alcaligenes faecalis. A. faecalis was the most potent caprolactam-degrading bacterium out of the three isolates. The biomass of the bacteria obtained by growth in the solubilised solid waste medium had the ability to decolourise some synthetic azo and triphenylmethane dyes. Decolourisation of dyes was obtained in static condition, in synthetic medium which contained only the components of the solid waste as the sole sources of carbon and nitrogen and also in nutritionally rich medium. The supplementation of yeast extract to solid waste medium did not increase the efficiency of decolourisation in case of two of the bacterial cultures. Depending on the dye, medium and bacteria used, decolourisation in the range of 35–94% was achieved in 48–96 h. The decolourisation was not due to the adsorption of the dyes by the bacterial biomass except in case of Procion Blue MR and Black B. Based on these observations, the simultaneous biological treatment of the solid waste of nylon-6 plant and the decolourisation of synthetic dyes present in wastewater or solid waste is envisaged.     

Decolorization of textile azo dyes by aerobic bacterial consortium

The decolorization potential of two bacterial consortia developed from a textile wastewater treatment plant showed that among the two mixed bacterial culture SKB-II was the most efficient in decolorizing individual as well as mixture of dyes. At 1.3 g L^?1 starch supplementation in the basal medium by the end of 120 h decolorization of 80–96% of four out of the six individual azo dyes Congo red, Bordeaux, Ranocid Fast Blue and Blue BCC (10 mg L^?1) was noted. The culture exhibited good potential ability in decolorizing 50–60% of all the dyes (Congo red, Bordeaux, Ranocid Fast Blue and Blue BCC) when present as a mixture at 10 mg L^?1. The consortium SKB-II consisted of five different bacterial types identified by 16S rDNA sequence alignment as Bacillus vallismortis, Bacillus pumilus, Bacillus cereus, Bacillus subtilis and Bacillus megaterium which were further tested to decolorize dyes. The efficient ability of this developed consortium SKB-II to decolorize individual dyes and textile effluent using packed bed reactors is being carried out.     

Characterization of Azo Reduction Activity in a Novel Ascomycete Yeast Strain

Several model azo dyes are reductively cleaved by growing cultures of an ascomycete yeast species, Issatchenkia occidentalis. In liquid media containing 0.2 mM dye and 2% glucose in a mineral salts base, more than 80% of the dyes are removed in 15 h, essentially under microaerophilic conditions. Under anoxic conditions, decolorization does not occur, even in the presence of pregrown cells. Kinetic assays of azo reduction activities in quasi-resting cells demonstrated the following: (i) while the optimum pH depends on dye structure, the optimum pH range was observed in the acidic range; (ii) the maximum decolorizing activity occurs in the late exponential phase; and (iii) the temperature profile approaches the typical bell-shaped curve. These results indirectly suggest the involvement of an enzyme activity in azo dye reduction. The decolorizing activity of I. occidentalis is still observed, although at a lower level, when the cells switch to aerobic respiration at the expense of ethanol after glucose exhaustion in the culture medium. Decolorization ceased when all the ethanol was consumed; this observation, along with other lines of evidence, suggests that azo dye reduction depends on cell growth. Anthraquinone-2-sulfonate, a redox mediator, enhances the reduction rates of the N,N-dimethylaniline-based dyes and reduces those of the 2-naphthol-based dyes, an effect which seems to be compatible with a thermodynamic factor. The dye reduction products were tested as carbon and nitrogen sources. 1-Amino-2-naphthol was used as a carbon and nitrogen source, and N,N-dimethyl-p-phenylenediamine was used only as a nitrogen source. Sulfanilic and metanilic acids did not support growth either as a carbon or nitrogen source.     

低温条件下诱变菌株的营养动力学研究及分子鉴定

以实验室保存的经过低温混合诱导的乳酸菌菌株Q1-4-6为研究对象,通过生长及产酸情况,研究其在低温条件下对于各种营养素的需求,以期为工业大规模生产提供数据参考。低温条件下通过研究碳源对菌株生长及产酸的影响发现,麦芽糖和乳糖对于菌株的生长及产酸有非常好的促进作用,菌株在以蔗糖为碳源的培养基中生长缓慢,而在以乳糖为碳源的培养基中生长最好。3种氮源对于菌株生长的差异不显著,以酵母膏为氮源的菌株生长略好于其他2种。不同浓度金属离子对于菌株生长有不同影响,Zn2+的促生长作用略高于Fe2+,Zn2+浓度越低,菌株生长越好,高浓度的Zn2+则对菌株生长有抑制作用。Fe2+浓度为0.5 g/L时,菌株生长最好,Fe2+浓度过高或过低对于菌株的生长都有抑制作用。根据16S rDNA序列分析结果,同时结合形态学特征、生理生化特性,将菌株鉴定为棉籽糖肠球菌(Enterococcus raffinosus)。