皮状丝孢酵母同步利用葡萄糖/木糖的糖转运动力学

皮状丝孢酵母(Trichosporon cutaneum)能够同步利用葡萄糖和木糖生产油脂。以2-脱氧葡萄糖(2-DOG)为底物,考察皮状丝孢酵母糖跨膜运输的转运动力学。结果表明:2-DOG转运符合米氏方程,表观米氏常数K m为0.19 mmol/L,最大转运速率V max为14.1 nmol/(min·mg)。葡萄糖和木糖均竞争性抑制2-DOG转运,葡萄糖表观抑制常数K i远低于木糖,表明存在一个共用转运体系,且该转运体系对葡萄糖亲和力更高。大量木糖与2-DOG同时转运到胞内,进一步说明木糖与葡萄糖共运输。代谢抑制剂和pH对糖转运有明显影响,说明质子/底物同向运输系统是该酵母的主要糖转运系统。     

休哈塔假丝酵母乙醇发酵性能的研究

木糖的高效发酵是制约纤维素燃料乙醇生产的技术瓶颈之一,高性能发酵菌种的开发是本领域研究的重点。以木糖发酵的典型菌株休哈塔假丝酵母为材料,研究氮源配比、葡萄糖和木糖初始浓度、葡萄糖添加及典型抑制物等因素对其木糖利用和乙醇发酵性能的影响规律。结果表明,硫酸铵更适宜于木糖和葡萄糖发酵产乙醇。在摇瓶振荡发酵条件下,该酵母可发酵164.0 g/L葡萄糖生成61.9 g/L乙醇,糖利用率和乙醇得率分别为99.8%和74.0%;受酵母细胞膜上转运体系的限制,对木糖的最高发酵浓度为120.0 g/L,可生成45.7 g/L乙醇,糖利用率和乙醇得率分别达到94.8%和87.0%。休哈塔假丝酵母发酵木糖的主要产物为乙醇,仅生成微量的木糖醇;添加葡萄糖可促进木糖的利用;休哈塔假丝酵母在葡萄糖发酵时的乙酸和甲酸的耐受浓度分别为8.32和2.55 g/L,木糖发酵时的乙酸和甲酸的耐受浓度分别为6.28和1.15 g/L。     

二步发酵丢糟生产微生物油脂的研究

目的:探索以黄曲霉和皮状丝孢酵母为菌种二步发酵大曲丢糟生产微生物油脂的最佳工艺条件.方法:利用黄曲霉对丢糟进行一步发酵,再以一步丢糟发酵物为基质,设定皮状丝孢酵母的接种量、培养温度、培养时间为三个因素,进行L9(33)正交试验.结果:黄曲霉一步发酵丢糟的最佳条件为接种量12％,在28℃下发酵5d,获得的一步丢糟发酵物还原糖含量为2.4051％;皮状丝孢酵母二步发酵丢糟生产微生物油脂的最佳条件为皮状丝孢酵母接种量12％,在30℃下培养4d,每1 000g发酵物中可得油脂19.32g.结论:利用黄曲霉的产纤维素酶的性能和皮状丝孢酵母积累油脂的性能进行二步发酵丢糟生产微生物油脂,具有一定的可行性.     

全基因组水平扫描鉴定粗糙脉孢菌糖转运蛋白及其在酿酒酵母己糖发酵中的评价

木质纤维素降解真菌粗糙脉孢菌天然具有吸收利用多种单糖和寡糖的能力,但是目前基因组中注释的预测糖转运蛋白仍然有过半功能未知。本研究从全基因组水平系统分析了粗糙脉孢菌预测糖转运蛋白的转运底物。研究发现两个转运蛋白(NCU01868和NCU08152)具有转运多种己糖底物的功能,因此分别命名为NcHXT-1和NcHXT-2。利用荧光共振能量转移技术(FRET)确认了NcHXT-1/-2具有葡萄糖转运功能。在己糖转运蛋白全缺酿酒酵母EBY.VW4000中分别过表达NcHXT-1/-2,能恢复其在葡萄糖、半乳糖或甘露糖的液体培养基中生长并生成乙醇的能力。NcHXT-1/-2在很多纤维素降解真菌中均具有保守的同源蛋白。本研究通过全基因组扫描鉴定,发现了两个保守的丝状真菌己糖转运蛋白,为真菌降解利用木质纤维素及酵母利用单糖发酵提供了新的改造靶点。     

马克斯克鲁维酵母GX-UN120糖转运蛋白基因的克隆及表征

【背景】马克斯克鲁维酵母(Kluyveromyces marxianus)具有完整的木糖代谢途径,可以高效利用木质纤维素中的木糖,因此对其糖转运蛋白基因的研究或可有效解决酵母木糖转运的相关问题。【目的】根据马克斯克鲁维酵母DMKU3-1042中KLMA＿70145和KLMA＿80101基因位点的功能预测,获得马克斯克鲁维酵母GX-UN120相应的糖转运蛋白基因序列并探究其功能。【方法】将转运蛋白基因分别克隆表达至酿酒酵母EBY.VW4000中考察重组菌株生长特性,以此间接评价对应转运蛋白的转运能力。【结果】Km＿SUT2基因编码的糖转运蛋白可有效提高宿主细胞转运木糖、阿拉伯糖、山梨糖、核糖、乳糖和葡萄糖的能力,但却不能转运甘露糖、果糖、蔗糖和半乳糖。类似地,Km＿SUT3基因编码的糖转运蛋白可提高细胞转运木糖、阿拉伯糖、山梨糖、半乳糖、核糖、乳糖和葡萄糖的能力,但却不能转运甘露糖和果糖。然而在葡萄糖存在的条件下,重组菌株对各种碳源的利用均受抑制,但Km＿SUT3转运木糖和核糖过程中受葡萄糖的抑制作用较小。【结论】马克斯克鲁维酵母GX-UN120中转运蛋白Km＿SUT2和Km＿SUT3可...     

利用木糖-葡萄糖为原料产乙醇酵母的筛选、鉴定及发酵试验

建立筛选利用木糖为碳源产乙醇酵母模型,获得一株适合利用木质纤维素为原料产乙醇的酵母菌株。样品经麦芽汁培养基培养后,以木糖为唯一碳源的筛选培养基初筛,再以重铬酸钾显色法复筛。通过生理生化和26D1/D2区对筛选得到的菌株进行分析和鉴定,该菌初步鉴定为Pichia caribbica。经过筛选得到的菌株Y2-3以木糖（40g/L）为唯一碳源发酵时：生物量为23.5g/L,木糖利用率为94.7 %,乙醇终产量为4.57 g/L;以混合糖（葡萄糖40 g/L,木糖20 g/L）发酵时：生物量为28.6 g/L,木糖利用率为94.2 %,葡萄糖利用率为95.6%,乙醇终产量为20.6 g/L。Pichia caribbica是可以转化木糖及木糖-葡萄糖混合糖为乙醇的酵母菌株,为利用木质纤维素发酵乙醇的进一步研究奠定了基础。     

麦芽糖假丝酵母菌混合糖代谢的发酵特性

葡萄糖和木糖的混合糖共代谢是木质纤维素资源高效转化利用的关键环节。利用本实验室保藏的天然木糖利用酵母菌,麦芽糖假丝酵母(Candida maltosa)Xu316,本研究对该菌代谢利用不同比例的葡萄糖、木糖发酵特性进行了系统测试,总结了麦芽糖假丝酵母混合糖代谢的一般规律。研究结果表明麦芽糖假丝酵母菌具有较高的葡萄糖利用率和木糖醇积累能力。在糖浓度低于20%时,该菌可以共同利用葡萄糖和木糖,最大乙醇产量和木糖醇产量分别为0.43g·g-1和0.58g·g-1,具有工业应用生产生物基产品的潜力。     

纤维素酶水解稻草生产单细胞蛋白（SCP）：Ⅱ.稻草酶解液生产SCP的研究

从18株酵母和2株白地霉中选得两株酵母它们能较好地利用稻草酶解液生产单细胞蛋白,其菌名和编号为皮状丝孢酵母(Trichosporon cutaneum)AS 1.374,假丝酵母(Candida sp.)Y002对这两株菌的生长条件进行了研究,在pH5.0、30—32℃、糖浓度1.5—2.0％、培养36h的条件下,SCP对糖的产率可达66.6％。     

微生物酶不对称水解合成S（＋）—布洛芬的研究：Ⅱ.反应条件和产物提取

皮状丝孢酵母具有较强不对称水解底物专一性。在试验的五种布洛芬消旋酯中,水解甲酯和异丙酯生成Ｓ（＋）－布洛芬ｅｅ可达９７％,乙酯为９３％以上;而水解活性以乙酯最强。转化率高于３０５。不对称水解最适ｐＨ６．５－７．０;温度在２８－３７℃范围内拆分能力无明显差别。该酵母的水解酶为胞内酶,将酵母细胞制成丙酮干粉进行水解可提高立体专一性。产物Ｓ（＋）－布洛芬可借助于酸碱反应和有机溶剂提取得到,同时回收未水解     

皮状丝孢酵母B3利用木薯淀粉发酵生产微生物油脂

对皮状丝孢酵母B3以木薯淀粉水解液为碳源发酵生产微生物油脂培养条件进行了优化,并在2 L发酵罐中对菌体生长和油脂积累进行了考察。摇瓶实验表明,木薯淀粉水解液的浓度高于90 g/L时不利于菌体的生长和油脂积累,皮状丝孢酵母B3发酵生产微生物油脂的最适氮源及其浓度、最适C/N比和pH分别为酵母提取物3.0 g/L、116、6.0,在此条件下培养144 h菌体生物量、油脂产量和油脂含量分别达到15.2 g/L、6.22 g/L和40.9％;在2 L发酵罐中分批发酵44 h后菌体生物量、油脂产量和油脂含量分别达28.7 g/L、12.27 g/L和42.8％。以皮状丝孢酵母B3所产油脂制备生物柴油,其主要组成包括棕榈酸甲酯、硬脂酸甲酯、油酸甲酯、亚油酸甲酯等,且理化特性符合相关国家标准,可作为一种有潜力的化石燃料替代品。     

Regulation and butanol inhibition of D-xylose and D-glucose uptake in Clostridium acetobutylicum.

Clostridium acetobutylicum exhibited diauxie growth in the presence of mixtures of glucose and xylose. Both glucose- and xylose-grown cells had a glucose uptake activity. On the other hand, growth on xylose was associated with the induction of a xylose permease activity, which was repressed by glucose in xylose-induced cells. The rate of sugar uptake with increasing sugar concentrations showed saturation kinetics with an apparent Km of 1.25 X 10(-5) M for glucose and 5 X 10(-3) M for xylose. Concomitant with the production of solvents, the activities of the glucose and xylose transport systems decreased. Among the main products of fermentation, butanol was shown to be a potent inhibitor of the growth of the organism and of the rate of sugar uptake as well as of sugar incorporation into cell materials. These inhibitory effects of butanol were more pronounced in xylose-grown cells than in glucose-grown cells. Butanol completely inhibited growth at a concentration of 14 g/liter for cultures growing on glucose and 8 g/liter for cultures growing on xylose. Concentrations of 7 and 10.5 g/liter of butanol caused a 50% inhibition of the xylose and glucose incorporations into cell materials. These inhibitory levels of butanol were found in typical glucose or xylose fermentation.     

Regulation and butanol inhibition of D-xylose and D-glucose uptake in Clostridium acetobutylicum

Clostridium acetobutylicum exhibited diauxie growth in the presence of mixtures of glucose and xylose. Both glucose- and xylose-grown cells had a glucose uptake activity. On the other hand, growth on xylose was associated with the induction of a xylose permease activity, which was repressed by glucose in xylose-induced cells. The rate of sugar uptake with increasing sugar concentrations showed saturation kinetics with an apparent Km of 1.25 X 10(-5) M for glucose and 5 X 10(-3) M for xylose. Concomitant with the production of solvents, the activities of the glucose and xylose transport systems decreased. Among the main products of fermentation, butanol was shown to be a potent inhibitor of the growth of the organism and of the rate of sugar uptake as well as of sugar incorporation into cell materials. These inhibitory effects of butanol were more pronounced in xylose-grown cells than in glucose-grown cells. Butanol completely inhibited growth at a concentration of 14 g/liter for cultures growing on glucose and 8 g/liter for cultures growing on xylose. Concentrations of 7 and 10.5 g/liter of butanol caused a 50% inhibition of the xylose and glucose incorporations into cell materials. These inhibitory levels of butanol were found in typical glucose or xylose fermentation.     

Glucose Transport in Brucella abortus

Brucella abortus British strain 19 transported glucose with an apparent K(m) of 0.16 mM and an apparent V(max) of 250 nmol per min per mg of N. The only common glucose analogue transported was 2-deoxyglucose (2-DOG), with an apparent K(i) of 0.73 mM. Alpha- or beta-methyl glucosides and 3-O-methylglucose were not transported. Transport was linear for 70 to 90 s, depending on the concentration of substrate used. 2-Deoxyglucose was transported as the free sugar and was not further metabolized once inside the cell. There was no glucose phosphoenolpyruvate phosphotransferase system (PEP-PTS) present, and there were no inhibitors present in Brucella cell-free extract that inhibited the Escherichia coli glucose PEP-PTS. N-Ethylmaleimide (NEM) and p-chloromercuribenzoate (pCMB) completely inhibited transport of glucose and 2-DOG. Glutathione, dithiothreitol, and beta-mercaptoethanol reversed the effects of pCMB but not of NEM. A pH optimum of 7.2 and a temperature optimum of 37 to 45 C were observed for both K(m) and V(max). The glucose transport system appeared to be constitutive for glucose transport in cells grown on fructose, galactose, erythritol, or glucose. The electron transfer inhibitors carbonyl cyanide, m-chlorophenylhydrazone, NaN(3), 2,4-dinitrophenol, and KCN inhibited 2-DOG transport to a greater extent than did the metabolic energy inhibitors NaAsO(4), iodoacetate, KF, and 2-heptyl-4-hydroxyquinoline-N-oxide. Dicyclohexylcarbodiimide, an inhibitor of membrane-bound adenosine triphosphatases, inhibited transport by 100%.     

The amino‐terminal tail of Hxt11 confers membrane stability to the Hxt2 sugar transporter and improves xylose fermentation in the presence of acetic acid

Hxt2 is a glucose repressed, high affinity glucose transporter of the yeast Saccharomyces cerevisiae and is subjected to high glucose induced degradation. Hxt11 is a sugar transporter that is stably expressed at the membrane irrespective the sugar concentration. To transfer this property to Hxt2, the N‐terminal tail of Hxt2 was replaced by the corresponding region of Hxt11 yielding a chimeric Hxt11/2 transporter. This resulted in the stable expression of Hxt2 at the membrane and improved the growth on 8% d ‐glucose and 4% d ‐xylose. Mutation of N361 of Hxt11/2 into threonine reversed the specificity for d ‐xylose over d ‐glucose with high d ‐xylose transport rates. This mutant supported efficient sugar fermentation of both d ‐glucose and d ‐xylose at industrially relevant sugar concentrations even in the presence of the inhibitor acetic acid which is normally present in lignocellulosic hydrolysates. Biotechnol. Bioeng. 2017;114: 1937–1945. © 2017 The Authors. Biotechnology and Bioengineering Published by Wiley Periodicals, Inc.     

How hexoses and inhibitors influence the malate transport system in Zygosaccharomyces bailii

When grown in fructose or glucose the cells of Zygosaccharomyces bailii were physiologically different. Only the glucose grown cells (glucose cells) possessed an additional transport system for glucose and malate. Experiments with transport mutants had lead to the assumption that malate and glucose were transported by one carrier, but further experiments proved the existence of two separate carrier systems. Glucose was taken up by carriers with high and low affinity. Malate was only transported by an uptake system and it was not liberated by starved malate-loaded cells, probably due to the low affinity of the intracellular anion to the carrier. The uptake of malate was inhibited by fructose, glucose, mannose, and 2-DOG but not by non metabolisable analogues of glucose. The interference of malate transport by glucose, mannose or 2-DOG was prevented by 2,4-dinitrophenol, probably by inhibiting the sugar phosphorylation by hexokinase. Preincubation of glucose-cells with metabolisable hexoses promoted the subsequent malate transport in a sugar free environment. Preincubation of glucose-cells with 2-DOG, but not with 2-DOG/2,4-DNP, decreased the subsequent malate transport. The existence of two separate transport systems for glucose and malate was demonstrated with specific inhibitors: malate transport was inhibited by sodium fluoride and glucose transport by uranylnitrate. A model has been discussed that might explain the interference of hexoses with malate uptake in Z. bailii.Abbreviations 2,4-DNP 2,4-dinitrophenol - 2-DOG 2-deoxyglucose - 6-DOG 6-deoxyglucose - pCMB para-hydroxymercuribenzoate     

Enabling glucose/xylose co-transport in yeast through the directed evolution of a sugar transporter

The capacity to co-transport glucose and xylose into yeast has remained a technical challenge in the field. While significant efforts have been made in transporter engineering to increase xylose transport rates, glucose-based inhibition still limit most of these transporters. To address this issue, we further engineer sugar transporter proteins to remove glucose inhibition and enable glucose/xylose co-transport. Specifically, we start with our previously derived CiGXS1 FIM mutant strain and subjugate it to several rounds of mutagenesis and selection in a hexose metabolism null strain. Through this effort, we identify several mutations including N326H, a truncation in the C-terminal tail, I171F, and M40V as additionally dominant for reducing glucose inhibition. The resulting transporter shows substantially improved xylose transport rates in the presence of high quantities of glucose including up to 70 g/L glucose. Moreover, the resulting transporter enables co-utilization of glucose and xylose with glucose rates on par with a wild-type transporter and xylose rates exceeding that of glucose. These results demonstrate that major facilitator superfamily hexose transporters can be rewired into glucose-xylose co-transporters without functional inhibition by either substrate. These results enhance the potential of using lignocellulosic biomass as a feedstock for yeast.     

The glucose transport system of the hyperthermophilic anaerobic bacterium Thermotoga neapolitana

The glucose transport system of the extremely thermophilic anaerobic bacterium Thermotoga neapolitana was studied with the nonmetabolizable glucose analog 2-deoxy-D-glucose (2-DOG). T. neapolitana accumulated 2-DOG against a concentration gradient in an intracellular free sugar pool that was exchangeable with external source of energy, such as pyruvate, and was inhibited by arsenate and gramicidin D. There was no phosphoenolpyruvate-dependent phosphorylation of glucose, 2-DOG, or fructose by cell extracts or toluene-treated cells, indicating the absence of a phosphoenolpyruvate:sugar phosphotransferase system. These data indicate that D-glucose is taken up by T. neapolitana via an active transport system that is energized by an ion gradient generated by ATP, derived from substrate-level phosphorylation.     

Is glucose transport enhanced in virus-transformed mammalian cells? A dissenting view

Much of the literature on the uptake of glucose by untransformed and transformed animal cells is based on experiments carried out with 2-deoxy-D-glucose (2-DOG). Results obtained with this analog can be ambiguous, since 2-DOG can be phosphorylated by hexokinases of animal cells. An intracellular trapping mechanism is thus provided. Therefore, the total flux of 2-DOG into the cell is a resultant of both transport and hexokinase action, and the measurement of total 2-DOG incorporation is a valid measurement of transport only if 2-DOG is phosphorylated as rapidly as it enters the cell. Evidence is presented here that this is not necessarily the case, significant levels of free intracellular 2-DOG approaching external concentrations were found in untransformed and transformed mouse 3T3 cells even at early times during uptake. Differences in total intracellular 2-DOG between untransformed and transformed cells were accounted for entirely by 2-deoxyglucose phosphate. Thus, it appears the apparent increase of 2-DOG uptake accompanying transformation in these cell lines is not due to an effect on the transport process, but on enhanced phosphorylation, which is a reflection of an alteration in the regulation of glycolysis. The ambiguity introduced by phosphorylation can be oviated by the use of an analog that cannot be phosphorylated, such as 3-O-methyl-D-glucose. The rate of transport and efflux of this sugar was not found to be different in untransformed versus transformed 3T3 cells. Moreover, deficiencies of this analog as a substrate for the glucose transport system are pointed out.     

Kinetic studies on glucose and xylose transport in Saccharomyces cerevisiae

Zero trans-influx assays of glucose and xylose were performed using Saccharomyces cerevisiae to investigate transport characteristics under high and low glucose conditions. Under high glucose conditions, most glucose was transported by the low-affinity transporter. The high-affinity transporter was expressed under low glucose conditions, transporting over 50% glucose. Inhibition kinetics revealed that xylose was transported by both high- and low-affinity glucose transporters. Affinities of both glucose transporters for xylose were very low under high glucose condition but increased to a similar level to glucose under low glucose condition. The maximum rate of xylose transport increased by 85%, while an overall maximum glucose transport rate decreased by 42% under low glucose condition, indicating the presence of other transport system for sugars except for glucose. It was suggested that expression of the high-affinity transporter and increased affinity of glucose transporters for xylose under low glucose condition would provide a fermentation strategy for enhancing the productivity of xylitol by recombinant S. cerevisiae harboring the xylose reductase gene.