菊粉酶产生菌的筛选及60Co诱变选育简

目的：从新疆石河子盐碱地菊芋生长根际土壤中分离筛选高产菊粉酶活力菌株。方法：通过稀释平板涂布法分离微生物;利用^60Co诱变选育,96孔板筛选突变菌株;采用3,5-二硝基水杨酸比色法测定菊粉酶酶活。结果：分离到12株具有菊粉酶活力的菌株,复筛得到1株高产菊粉酶活力菌株,将其命名为G-60;以此菌株为出发菌株进行^60Co诱变,利用96孔板对诱变菌株进行筛选,经摇瓶发酵酶活测定,得到1株高产菊粉酶酶活的突变株,酶活达46．62U/mL,是未诱变菌株酶活的2．72倍。结论：经诱变得到1株高产菊粉酶活力的突变菌株。     

一株产几丁质酶菌株的筛选及其产酶条件的研究

采用平板透明圈法从土壤中分离筛选到一株产几丁质酶放线菌株L12,用250mL摇瓶发酵初筛和复筛,酶活力为0.63U/mL。通过产酶条件实验,初步确定了该菌株较适产酶培养基和摇瓶发酵条件。条件优化后,30℃、250mL摇瓶发酵48h,几丁质酶活力达到1.06U/mL。     

多拷贝毕赤酵母重组菌表达GCL摇瓶优化和高密度发酵

目的:构建高效表达白地霉脂肪酶的毕赤酵母重组菌株,并对筛选得到的菌株进行摇瓶发酵条件优化和分批补料高密度发酵工艺研究。方法:将诱导型表达载体pPIC9K-gcl电转化至毕赤酵母GS115。通过橄榄油-罗丹明B平板和摇瓶发酵筛选高脂肪酶活力的重组菌株,运用基于TaqMan探针的实时荧光定量PCR 法确定其拷贝数,并对菌株进行摇瓶发酵条件优化。在此基础上,研究重组菌在3L 发酵罐中的高密度发酵工艺。结果:筛选得到一株具有3 个白地霉脂肪酶基因拷贝的菌株GS115/pPIC9K-gcl 78#,初始酶活力为220 U/ml。当摇瓶发酵条件为甲醇诱导96 h,每24 h甲醇添加量1 %,接种量2 %,培养基初始pH 7.0,500 ml摇瓶装液量50 ml,甲醇诱导温度25℃ 时酶活力达735 U/ml。3L 发酵罐高密度发酵176.5 h,酶活力达到3360 U/ml,总蛋白含量达到4.30 g/L,且发酵过程中细胞活性一直保持在96 % 以上。结论:基因拷贝数与重组菌株的产酶水平呈正相关,摇瓶优化可显著提高重组菌株的产酶能力,为白地霉脂肪酶的工业化生产奠定了技术基础。     

菊粉酶产生菌的筛选及~(60)Co诱变选育

目的:从新疆石河子盐碱地菊芋生长根际土壤中分离筛选高产菊粉酶活力菌株。方法:通过稀释平板涂布法分离微生物;利用60Co诱变选育,96孔板筛选突变菌株;采用3,5-二硝基水杨酸比色法测定菊粉酶酶活。结果:分离到12株具有菊粉酶活力的菌株,复筛得到1株高产菊粉酶活力菌株,将其命名为G-60;以此菌株为出发菌株进行60Co诱变,利用96孔板对诱变菌株进行筛选,经摇瓶发酵酶活测定,得到1株高产菊粉酶酶活的突变株,酶活达46.62 U/mL,是未诱变菌株酶活的2.72倍。结论:经诱变得到1株高产菊粉酶活力的突变菌株。     

葡聚糖酶高产菌株的诱变筛选及其摇瓶发酵条件的初步研究

从土壤中分离出的一株产葡聚糖酶酶活31 U／ml的野生菌株,经UV、^60Co、LiCl诱变筛选后得到了产葡聚糖酶高产菌株SB126,经发酵条件优化试验后检测其酶活达到85U／ml,较野生菌株提高了近两倍。葡聚糖酶摇瓶较适发酵条件为：装量30ml(250m1)、转速180r／min、pH7．0、温度30℃、接种量8％、发酵周期5d。     

ARTP诱变选育葡萄糖氧化酶高产菌株及发酵条件优化

利用常压室温等离子体诱变技术对产葡萄糖氧化酶的黑曲霉菌株进行诱变处理,通过平板筛选以及摇瓶复筛选出8株酶活较高的菌株,其中产酶活力最高的突变株为PCTC-8,酶活达到14.36 U/m L,较初始菌株的酶活提高了117.25%。然后在优化培养基的基础之上通过单因素实验对诱变菌株的发酵条件进行优化,最终确定最优的发酵条件为:接种量10%,装液量30 m L,种龄24 h,发酵时间48 h,转速225 r/min,在此条件下最高酶活可达到93.26 U/m L。     

两株高产纤维素酶细菌的筛选、鉴定及酶学特性

从腐烂枯叶及附近土壤筛选分离得到2株产纤维素酶的菌株。经细菌形态观察、生理生化实验并结合16S rRNA序列分析,将其初步鉴定为地衣芽孢杆菌CT1(Bacillus licheniformis CT1)和枯草芽孢杆菌CM2(Bacillus subtilis CM2)。经摇瓶发酵,测定其CMCase、FPA酶活力,结果表明CT1和CM2在液体摇瓶培养4 d后的CMC酶活最大,分别可达163.3 U/mL和167.17 U/mL;CT1摇瓶培养2 d后,FPA酶活达到了211.17 U/mL,CM2摇瓶培养3 d后,FPA酶活为207.83 U/mL。进行不同碳源对菌株产酶能力影响的试验,并通过SDS-聚丙烯酰胺凝胶电泳、银染后初步分析纤维素酶谱条带,发现菌株对不同来源纤维素的降解能力及产纤维素酶的种类均有所不同。     

1株产菊粉酶菌株的筛选、鉴定及发酵条件优化

筛选分离可以分解菊芋中菊糖的菌株。采用平板稀释法从土样中筛选出能够分解菊芋中菊糖的菌株,并从中得到1株酶活较高的真菌A-15,经菌落观察及采用18S rRNA基因测序鉴定,研究不同因素对菌株菊粉酶活力的影响。通过对分离得到的菌株形态观察及分子鉴定后,确定菌株A-15为黑曲霉(Aspergillus niger)。通过正交试验优化菌株A-15的发酵条件分析结果显示,菌株A-15产菊粉酶最优条件:最佳氮源为酵母膏,氮源量1.0%,氯化钠0.5%,磷酸氢二钾0.3%,菊芋汁定容,初始pH 6,培养温度30℃,摇瓶发酵6 d。结果表明菌株A-15具有很好地降解菊芋中菊糖的性能。     

黑曲霉产菊粉酶的发酵条件优化及诱变育种

对1株黑曲霉产菊粉酶的发酵条件进行了研究,确定了优化的发酵条件为菊粉2%,酵母膏2%,(NH4)H2PO40 5%,Na Cl0 5%,MgSO4·7H2O0 05%,ZnSO4·7H2O0 01%,初始pH6 5,接种量1 6%,装液量30ml,发酵5d,菊粉酶活最高可达26U/ml,I/S为1 15。经Co60诱变筛选出1株突变株C-32,在相同的发酵条件下菊粉酶活提高30%,I/S不变。     

一步法发酵菊芋产乙醇菌种的筛选及产酶条件、酶学性质的研究

从腐烂的菊芋及实验室保存的菌种中,选育到一株发酵菊芋产乙醇的菌株克鲁维酵母Kluyveromyces marxianus Y1。利用正交实验法对克鲁维酵母产菊粉酶的培养基组成及培养条件进行优化,确定培养基组成（g/L）为：菊粉40,酵母粉4,蛋白胨4,尿素1;初始pH5．0,温度30℃,150r／min条件下培养达到最佳产酶效果（57U／mL）。该菌株所产菊粉酶的性质测定结果表明：以菊粉为底物,该菊粉酶最适反应温度为55℃,在60℃以下稳定性很好,高于60℃时酶迅速失活;最适pH为5．0,pH4．6—5．2范围内酶稳定性很好;该酶属于外切型菊粉酶,体积分数为8％的乙醇对酶活力基本没有影响。     

Non-specific β-fructofuranosidase (inulase) from Kluyveromyces fragilis: Batch and continous fermentation,simple recovery method and some industrial properties

The yeast Kluyveromyces fragilis was grown in continuous culture on a complex medium containing sucrose as the carbon source and limiting nutrient. The inulase yield was 7000 μg hexose/min.mg biomass, determined with 4% sucrose at 50°C and pH 5.0. Maximum amount of enzyme was formed at the lowest dilution rate (0.09 h^?1) tested. Any increase in dilution rate caused a severe reduction in activity per unit biomass due to carbon catabolite repression. Inulase yields were constant in the pH range 3.5 to 6.0 and in the dissolved oxygen tension range 2.5 to 40% of saturation. Continuous cultivation on sucrose produced twice as much inulase as the previously used method of batch cultivation on the expensive substrate inulin. A high quality industrial grade inulase was prepared by autolysis of the yeast cells, ultrafiltration of the supernatant and acetone precipitation. Under the assay conditions used the preparation showed an activity ratio toward sucrose and inulin of 10.5 as compared to 1600 for baker's yeast invertase. Further comparison with invertase showed that it is at least as resistant to substrate inhibition, as thermostable and has slightly less transferase activity. These results suggest that K. fragilis inulase may represent an alternative to Saccharomyces cerevisiae invertase presently used in industry.     

深海低温脂肪酶基因工程菌LIP001发酵条件的优化

对从深海沉积物宏基因组文库中获得的产低温脂肪酶基因工程菌LIP001进行了发酵条件优化。通过单因素试验对LIP001产脂肪酶的主要影响条件进行了探讨,确定了培养条件为30℃、pH7.0、接种量5%、装液量50ml。在单因素的基础上通过正交试验优化了影响重组菌LIP001产酶主要因素:橄榄油、酵母粉、磷酸盐、MgSO₄,确定了培养基为橄榄油1%、酵母粉0.5%、蛋白胨1%、硫酸铵0.5%、磷酸盐0.5%、MgSO₄为0.2%、氯霉素12.5μg/ml,优化后的脂肪酶活为1980U/ml,比优化前提高了54.7%,为大规模发酵奠定了基础。采用5升发酵罐方法试验,酶活达到2420U/ml。     

鸟氨酸脱羧酶高活性微生物菌株的筛选

根据鸟氨酸脱羧酶(ODC)催化底物L-鸟氨酸脱羧生成腐胺,从而引起培养基中pH升高的特点,设计了一种高效、经济的筛选方法,并以此作为初筛手段从土壤中快速分离可产生较高ODC活力微生物菌种。研究发现培养后pH的变化与微生物产酶能力存在着明显的正相关性,R2=0.914 2。对从土壤和活性污泥样品中分离得到的343株细菌进行有效初筛以及经过摇瓶发酵测定酶活的复筛试验后,筛选得到6株高酶活的菌株,其中菌株CJW07和CGW27的ODC活性分别达到了121.32 U/mL和109.25 U/mL。     

微生物絮凝剂产生菌的筛选和发酵条件研究

设计了微生物絮凝剂产生菌菌种筛选模型,并从土壤和活性污泥中筛选到５１株絮凝剂产生菌,经复筛获得两株絮凝活性较高的菌株,分别定名为Ｎｏｃａｒｄｉａ,ＪＩＭ－８９和ＪＩＭ－１２７。对两株菌的发酵条件,特别是培养基组成,进行了初步研究。两株菌所产生的絮凝剂,对大肠杆菌悬液２０ｍｉｎ的絮凝活性在１０００ｕ／ｍｌ,最高可达１２４８ｕ／ｍｌ。     

Optimization of cellulase production in batch fermentation byTrichoderma reesei

Maximum cellulase production was sought by comparing the activities of the cellulases produced by differentTrichoderma reesei strains andAspergillus niger. Trichoderma reesei Rut-C30 showed higher cellulase activity than otherTrichoderma reesei strains andAspergillus niger that was isolated from soil. By optimizing the cultivation condition during shake flask culture, higher cellulase production could be achieved. The FP (filter paper) activity of 3.7 U/ml and CMCase (Carboxymethylcellulase) activity of 60 U/ml were obtained from shake flask culture. When it was grown in 2.5L fermentor, where pH and DO levels are controlled, the Enzyme activities were 133.35 U/ml (CMCase) and 11.67 U./ml (FP), respectively. Ammonium sulfate precipitation method was used to recover enzymes from fermentation broth. The dried cellulase powder showed 3074.9 U/g of CMCase activity and 166.7 U/g of FP activity with 83.5% CMCase recovery.     

Novel screening method for extracellular phytase-producing microorganisms

A bioassay was developed to screen extracellular phytase-producing microorganisms. Washed cells of Corynebacterium glutamicum, which cannot use sodium phytate as source of phosphate, were mixed with phytate-minimal agar as indicator strain. By this method, we could easily obtain phytase-producing strains from soil samples and 71 % of the isolates had phytase activities above 0.01 U/ml when they were grown in modified phytase screening medium. © Rapid Science Ltd. 1998     

微孔板与响应面相结合筛选壳聚糖酶高产菌株

利用微孔板与响应面相结合筛选壳聚糖酶高产菌株.经平板透明圈法从土样中筛选出60株产壳聚糖酶菌株,再经96孔板复筛得到1株产壳聚糖酶活力较高的菌株.通过Plackett-Burman设计实验确定蛋白胨、胶体壳聚糖、CaCl2对产酶具有显著影响;最后应用中心组合设计和响应面分析得到以上3个因素的最佳浓度分别为(%,w/v)...     

Utilization of UF-permeate for production of beta-galactosidase by lactic acid bacteria

Four lactobacilli strains (Lactobacillus bulgaricus, Lactobacillus acidophilus, Lactobacilus casei and Lactobacillus reuteri) were grown in MRS broth and three lactococci strains (Streptococcus thermophilus, Lactococcus lactis subsp. Lactis and Lactococcus lactis subsp. lactis biovar. diacetilactis) were grown in M17 broth. L. reuteri and S. thermophilus were chosen on the basis of the best mean beta-galactosidase activity of 10.44 and 10.01 U/ml respectively, for further studies on permeate-based medium. The maximum production of beta-galactosidase by L. reuteri was achieved at lactose concentration of 6%, initial pH 5.0-7.5, ammonium phosphate as nitrogen source at a concentration of 0.66 g N/L and incubation temperature at 30 degrees C/24 hrs to give 6.31 U/ml. While in case of S. thermophilus, maximum beta-galactosidase production was achieved at 10% lactose concentration of permeate medium, supplemented with phosphate buffer ratio of 0.5:0.5 (KH2PO4:K2HPO4, g/L), at initial pH 6.0-6.5, ammonium phosphate (0.66g N/L) as nitrogen source and incubation temperature 35 degrees C for 24 hrs to give 7.85 U/ml.     

Visual detection of β-fructofuranosidase (inulase) —Regulatory mutants ofKluyveromyces fragilis

Summary Inulase constitutive mutant cells of the yeastKluyveromyces fragilis were enumerated in continuous culture cell populations. After cloning and growth on glycerol agar plates, mutant colonies stained red when exposed to a mixture of sucrose and a chromogenic reagent for glucose.Mutants with improved inulase production on glucose were isolated from opaque agar plates containing undissolved inulin. Mutant colonies were surrounded with clearing zones. Attempts to isolate similar mutants by selection for 2-deoxyglucose resistance proved unsuccessful withK. fragilis.     

云南高原湖泊抚仙湖和星云湖的酵母菌胞外酶活性

【背景】高原湖泊因其海拔高、气压低、辐射强、氧气含量低,是一类特殊环境,而其中的微生物是高原湖泊生态系统物质循环与能量流动的重要参与者,其胞外酶活性的表现决定其适应这一特殊环境的方式与能力。【目的】对分离自云南高原湖泊抚仙湖和星云湖湖水的酵母菌进行产胞外酶活性的筛选,以期获得具有潜在应用价值的活性菌株。【方法】在5°C和25°C培养温度下,采用平板筛选法对两个湖泊酵母菌进行产胞外蛋白酶、纤维素酶、淀粉酶、脂肪酶、几丁质酶、木聚糖酶、植酸酶、菊粉酶、漆酶、锰依赖过氧化物酶和木质素过氧化物酶活性的筛选。【结果】抚仙湖和星云湖的所有测试酵母菌菌株至少都能产1种胞外酶,且主要产植酸酶、菊粉酶和淀粉酶;其次为脂肪酶、纤维素酶、木聚糖酶、锰依赖过氧化物酶和木质素过氧化物酶;产几丁质酶、蛋白酶和漆酶的酵母菌很少,星云湖酵母菌都不产漆酶。培养温度为5°C时,抚仙湖和星云湖的酵母菌产5种及5种以上胞外酶的活性菌株数均多于25°C。【结论】抚仙湖和星云湖的酵母菌产胞外酶菌株多样性丰富,胞外酶种类多样,产酶酵母菌可能参与高原湖泊生态系统的物质循环;筛选得到的产胞外酶菌株为开发与利用高原湖泊酶资源提供了良好的种质资源,具有进一步研究的价值。