高产菊粉酶酵母筛选、发酵和酶学性质研究

筛选到1株菊粉酶高产克鲁维酵母菌株,采用酵母高密度细胞发酵方法,最高菊粉酶产量达到288.78u/mL,比80～90年代国际上报道的克鲁维酵母菊粉酶最高产量高6.8倍。该酶的菊粉酶/转化酶活性比为1/24.72;菊糖m=13.3mmol/L,蔗糖Km=62.6mmol/L;最适反应pH值为4.4,但在pH3.8～5.6的范围内均保持了较高的活性,相当于最适pH值下活性的90%;最适反应温度为55℃,在50～575℃范围内能够保持较高活性,50℃下酶的半衰期约为16h;外加Mg2+提高酶活性11.28%。     

克鲁维酵母Y-85合成菊粉酶最适条件的研究

采用响应面方法对克鲁维酵母Ｙ－８５产菊粉酶培养基成份进行了优选,和正交试验相比,该法选出的最适培养基的酶发酵水平提高２８％。用１５Ｌ自控发酵罐进行产酶条件控制试验,并在１０００Ｌ罐上进行了５批次酶发酵中试,平均菊粉酶活性达６８．９ｕ／ｍｌ。     

鹰嘴豆孢克鲁维酵母利用菊芋原料同步糖化与发酵生产乙醇

菊芋含有大量的菊粉多糖,且种植简单、产量高,是极具开发价值的替代玉米等粮食作物生产燃料乙醇的原料。文中研究了鹰嘴豆孢克鲁维酵母Y179利用菊芋原料同步糖化与发酵生产乙醇。鹰嘴豆孢克鲁维酵母Y179具有高效分泌菊粉酶的能力,摇瓶试验显示Y179酵母能够利用完全由菊芋原料配制而成的培养基良好生长并发酵产生乙醇。通气及温度对乙醇产量影响明显,相对厌氧环境对Y179酵母发酵产乙醇具有促进作用,30℃发酵温度相对37℃和42℃更有利于乙醇产量提高。种子液培养时间及接种量对乙醇产量影响较小。在5 L发酵罐中以10%(V/V)量接入预培养36 h的Y179种子液,发酵液完全由菊芋干粉配制而成,总糖含量22%(W/V),30℃不通气,300 r/min搅拌,发酵144 h时,乙醇浓度达到12.3%(V/V),糖醇转化效率86.9%,糖利用率大于93.6%。初步研究结果显示鹰嘴豆孢克鲁维酵母Y179在利用菊芋原料生产乙醇方面具有良好应用前景。     

克鲁维酵母Y-85合成菊粉酶最适条件的研究

采用响应面方法（ResponseSurfaceMethod,RSM）对克鲁维酵母（Kluyveromycessp．）Y－85产菊粉酶培养基成份进行了优选,和正交试验相比,该法选出的最适培养基的酶发酵水平提高28％。用15L自控发酵罐进行产酶条件控制试验,并在1000L罐上进行5批次酶发酵中试,平均菊粉酶活性达68.9u／ml。     

产低温脂肪酶非极端细菌的筛选、产酶发酵及粗酶性质研究

目的：筛选产低温脂肪酶非极端细菌菌株,扩大脂肪酶的应用范围。方法：利用维多利亚蓝B平板显色法和摇瓶发酵法,从土壤中筛选产脂肪酶菌株,通过菌落形态和菌体特征观察初步对菌种进行鉴定,并对该菌株的产酶发酵培养基进行了优化。结果：得到一株产低温脂肪酶非极端细菌菌株sybc—li一1,该菌株适宜产酶培养基（％）为淀粉1、牛肉浸膏1、NaNO3 0．08、CaCl2 0．04、MgSO4 0．04、橄榄油2和OP1;初始DH8、30℃、200r／min培养72h,脂肪酶活力可高达到30．2U／mL;所产脂肪酶粗酶最适作用温度20℃,最适pH9．5,0℃时仍能保持70％的酶活性,属于低温酶;该酶与目前报道的低温脂肪酶相比,有较好的热稳定性,粗酶在pH8．5、70℃条件下保温60mla,酶活力损失30％。结论：该菌株为自然环境中筛选的非极端细菌,所产脂肪酶为低温脂肪酶,在开发应用上有良好的前景。     

CN—92植酸酶产生菌的诱变选育及产酶条件的研究

以无花果曲霉IFFI2227为出发菌株,通过NTGT和Co60复合诱变处理,获得5株产植酸酶活力比出发菌株高2．1～2．5倍的高产菌株。其中1株CN－92菌产酶性能稳定,研究了该菌株的最适产酶条件：培养温度30℃,培养基起始pH6．0培养时间72h。适宜于该菌株产植酸酶的优良固体培养基组成为：麸皮、豆饼粉、硫酸铵及少量无机磷,培养基含水率51％。葡萄糖、乳糖和MH4Cl、NH4NO3等不同程度地抑制植酸酶的合成,微量元素如Mn,Zn,Cu等对产酶无促进作用。     

脂肪酶产生菌Geofrichum sp. AS 2.1135产酶条件及酶一般性质的研究

在92株能同化油的地霉属菌株中,Geotrichum sp. AS2．1135菌株产脂肪酶活力为50—60u／ml,对其产酶条件的研究表明,不饱和长链脂肪酸和油类有利于酶的形成。在4％豆饼粉作为有机氮源的培养基中,加入0．2％尿素,酶活力显著增加,酶活达150u／ml。用聚乙二醇橄榄油乳化系统测定酶的作用最适pH为8．0,最适温度为4O一42℃。在pH4一9时5℃下存放24小时,或在pH 5和8时45℃保持15分钟,酶活力不变。     

酿酒酵母和克鲁维酵母发酵菊芋生产燃料乙醇

为获得菌株发酵菊芋生产燃料乙醇的最佳方案,首先选取实验室保存的重组菌株R32对其产酶条件进行优化,其最高产菊粉酶活性为298.8 U· mL-1,此时的最佳培养基配方为:YPG培养基为酵母粉1％ (w/v),蛋白胨2％ (w/v),甘油0.5％ (v/v);YPM培养基为酵母粉1％ (w/v),蛋白胨2％ (w/v),甲醇1％(v/v);培养基pH为自然初始pH.然后选取酿酒酵母S.c和克鲁维酵母Klu,比较是否在添加重组菌株R32粗酶液条件下,两株酵母菌分别进行单独发酵和混合发酵时的产乙醇能力,以获得最佳的发酵组合.结果表明,酿酒酵母S.c和克鲁维酵母Klu在未添加重组菌株R32粗酶液时,混合一步发酵获得的乙醇含量较高,发酵84 h时乙醇含量为11.37％.添加重组菌株R32粗酶液进行两步发酵时,2株酵母菌混合发酵72 h时,乙醇含量为11.43％.2种发酵组合的最高乙醇含量以及各个发酵参数基本相同,虽然一步法发酵时间延长,但节省成本,操作简单,更适宜工业生产应用.最后对其进行正交试验优化,培养条件为菊粉浓度225 g· L-1,脲素浓度40 g·L-1,接种量15％,pH为5时,酿酒酵母菌S.c和克鲁维酵母Klu混合一步发酵法的最高乙醇体积比达11.82％.     

1株产菊粉酶菌株的筛选、鉴定及发酵条件优化

筛选分离可以分解菊芋中菊糖的菌株。采用平板稀释法从土样中筛选出能够分解菊芋中菊糖的菌株,并从中得到1株酶活较高的真菌A-15,经菌落观察及采用18S rRNA基因测序鉴定,研究不同因素对菌株菊粉酶活力的影响。通过对分离得到的菌株形态观察及分子鉴定后,确定菌株A-15为黑曲霉(Aspergillus niger)。通过正交试验优化菌株A-15的发酵条件分析结果显示,菌株A-15产菊粉酶最优条件:最佳氮源为酵母膏,氮源量1.0%,氯化钠0.5%,磷酸氢二钾0.3%,菊芋汁定容,初始pH 6,培养温度30℃,摇瓶发酵6 d。结果表明菌株A-15具有很好地降解菊芋中菊糖的性能。     

链霉菌产木聚糖酶条件和酶学性质以及重离子诱变对产酶的影响研究

以一株由青藏高原牦牛粪中分离出的链霉菌为出发菌株,对其培养特性、产酶条件和酶学性质进行初步研究.通过重离子诱变,筛选出遗传稳定的高产菌株.结果表明,该菌以玉米芯和麸皮(1∶1)为碳源能高效地诱导木聚糖酶的胞外分泌,其最适培养基和培养条件氮源为酵母膏、初始pH7、培养温度为25℃,在此条件下,第4天酶活力达到峰值3480.25 U/mL.说明该酶能够利用农业废弃物高效生产木聚糖酶.该菌株所产木聚糖酶的最适反应温度为15℃、pH4,属低温酸性木聚糖酶.经重离子诱变后,筛选出一株高产菌株SZ10-7,其酶活力可达5 338.42 U/mL.     

Thermotolerant Kluyveromyces marxianus and Saccharomyces cerevisiae strains representing potentials for bioethanol production from Jerusalem artichoke by consolidated bioprocessing

Thermotolerant inulin-utilizing yeast strains are desirable for ethanol production from Jerusalem artichoke tubers by consolidated bioprocessing (CBP). To obtain such strains, 21 naturally occurring yeast strains isolated by using an enrichment method and 65 previously isolated Saccharomyces cerevisiae strains were investigated in inulin utilization, extracellular inulinase activity, and ethanol fermentation from inulin and Jerusalem artichoke tuber flour at 40?°C. The strains Kluyveromyces marxianus PT-1 (CGMCC AS2.4515) and S. cerevisiae JZ1C (CGMCC AS2.3878) presented the highest extracellular inulinase activity and ethanol yield in this study. The highest ethanol concentration in Jerusalem artichoke tuber flour fermentation (200?g?L(-1)) at 40?°C achieved by K. marxianus PT-1 and S. cerevisiae JZ1C was 73.6 and 65.2?g?L(-1), which corresponded to the theoretical ethanol yield of 90.0 and 79.7?%, respectively. In the range of 30 to 40?°C, temperature did not have a significant effect on ethanol production for both strains. This study displayed the distinctive superiority of K. marxianus PT-1 and S. cerevisiae JZ1C in the thermotolerance and utilization of inulin-type oligosaccharides reserved in Jerusalem artichoke tubers. It is proposed that both K. marxianus and S. cerevisiae have considerable potential in ethanol production from Jerusalem artichoke tubers by a high temperature CBP.     

一步法发酵菊芋生产乙醇

利用马克斯克鲁维酵母(Kluyveromyces marxianus)YX01具有菊粉酶生产能力且乙醇发酵性能良好的特点,直接发酵菊粉生成乙醇.在摇瓶中考察了该菌株最适发酵温度,进而在2.5L发酵罐中考察了通气量和底物浓度的影响.实验结果表明:该菌株最适发酵温度为35℃;在通气量为50 mL/min和100 mL/min时菌体生长加快,发酵时间缩短,但在不通气条件下糖醇转化率明显提高;在菊粉浓度235 g/L时,发酵终点乙醇浓度达到92.2 g/L,乙醇对糖的得率为0.436,为理论值的85.5%.在此基础上,使用近海滩涂种植海水灌溉收获的菊芋为底物,以批式补料方式直接发酵菊芋干粉浓度为280 g/L的底物,发酵终点乙醇浓度为84.0 g/L,乙醇对糖的得率为0.405,为理论值的80.0%.这些研究工作,为以菊芋为原料的燃料乙醇技术开发奠定了基础.     

Partial purification and characterization of exoinulinase from Kluyveromyces marxianus YS-1 for preparation of high-fructose syrup

An extracellular exoinulinase (2,1-beta-D fructan fructanohydrolase, EC 3.2.1.7), which catalyzes the hydrolysis of inulin into fructose and glucose, was purified 23.5-fold by ethanol precipitation, followed by Sephadex G-100 gel permeation from a cell-free extract of Kluyveromyces marxianus YS-1. The partially purified enzyme exhibited considerable activity between pH 5 to 6, with an optimum pH of 5.5, while it remained stable (100%) for 3 h at the optimum temperature of 50 degrees C. Mn2+ and Ca2+ produced a 2.4-fold and 1.2-fold enhancement in enzyme activity, whereas Hg2+ and Ag2+ completely inhibited the inulinase. A preparation of the partially purified enzyme effectively hydrolyzed inulin, sucrose, and raffinose, yet no activity was found with starch, lactose, and maltose. The enzyme preparation was then successfully used to hydrolyze pure inulin and raw inulin from Asparagus racemosus for the preparation of a high-fructose syrup. In a batch system, the exoinulinase hydrolyzed 84.8% of the pure inulin and 86.7% of the raw Asparagus racemosus inulin, where fructose represented 43.6 mg/ml and 41.3 mg/ml, respectively.     

Consolidated bioprocessing strategy for ethanol production from Jerusalem artichoke tubers by Kluyveromyces marxianus under high gravity conditions

Aims: Developing an innovative process for ethanol fermentation from Jerusalem artichoke tubers under very high gravity (VHG) conditions. Methods and Results: A consolidated bioprocessing (CBP) strategy that integrated inulinase production, saccharification of inulin contained in Jerusalem artichoke tubers and ethanol production from sugars released from inulin by the enzyme was developed with the inulinase‐producing yeast Kluyveromyces marxianus Y179 and fed‐batch operation. The impact of inoculum age, aeration, the supplementation of pectinase and nutrients on the ethanol fermentation performance of the CBP system was studied. Although inulinase activities increased with the extension of the seed incubation time, its contribution to ethanol production was negligible because vigorously growing yeast cells harvested earlier carried out ethanol fermentation more efficiently. Thus, the overnight incubation that has been practised in ethanol production from starch‐based feedstocks is recommended. Aeration facilitated the fermentation process, but compromised ethanol yield because of the negative Crabtree effect of the species, and increases the risk of contamination under industrial conditions. Therefore, nonaeration conditions are preferred for the CBP system. Pectinase supplementation reduced viscosity of the fermentation broth and improved ethanol production performance, particularly under high gravity conditions, but the enzyme cost should be carefully balanced. Medium optimization was performed, and ethanol concentration as high as 94·2 g l^?1 was achieved when 0·15 g l^?1 K₂HPO₄ was supplemented, which presents a significant progress in ethanol production from Jerusalem artichoke tubers. Conclusions: A CBP system using K. marxianus is suitable for efficient ethanol production from Jerusalem artichoke tubers under VHG conditions. Significance and Impact of the Study: Jerusalem artichoke tubers are an alternative to grain‐based feedstocks for ethanol production. The high ethanol concentration achieved using K. marxianus with the CBP system not only saves energy consumption for ethanol distillation, but also significantly reduces the amount of waste distillage discharged from the distillation system.     

Optimization of medium and process parameters for the production of inulinase from a newly isolated Kluyveromyces marxianus YS-1

A newly isolated strain of Kluyveromyces marxianus YS-1 was used for the production of extra cellular inulinase in a medium containing inulin, meat extract, CaCl2 and sodium dodecyl sulphate (SDS). Fermentation medium pH 6.5, cultivation temperature 30 degrees C and 5% (v/v) inoculum of 12 h-old culture were optimal for enzyme production (30.8 IU/ml) with a fermentation time of 72 h at shake flask level. Raw inulin (2%, w/v) extracted from dahlia tubers by processing at 15 kg/cm2 for 10 min was optimum for bioreactor studies. Maximum enzyme production (55.4 IU/ml) was obtained at an agitation rate of 200 rpm and aeration of 0.75 vvm in a stirred tank reactor with a fermentation time of 60 h.     

Improved ethanol production in Jerusalem artichoke tubers by overexpression of inulinase gene in Kluyveromyces marxianus

Ethanol production from Jerusalem artichoke tubers through a consolidated bioprocessing (CBP) strategy using the inulinase-producing yeast Kluyveromyces marxianus is an economical and competitive than that from a grainbased feedstock. However, poor inulinase production under ethanol fermentation conditions significantly prolongs the fermentation time and compromises ethanol productivity. Improvement of inulinase activity appears to be promising for increasing ethanol production from Jerusalem artichoke tubers by CBP. In the present study, expression of the inulinase gene INU with its own promoter in K. marxianus (K/INU2) was explored using the integrative cassette. Overexpression of INU was explored using chromosome integration via the HO locus of the yeast. Inulinase activity and ethanol were determined from inulin and Jerusalem artichoke tubers under fed-batch operation. Inulinase activity was 114.9 U/mL under aerobic conditions for K/INU2, compared with 52.3 U/mL produced by the wild type strain. Importantly, inulinase production was enhanced in K/INU2 under ethanol fermentation conditions. When using 230 g/L inulin and 220 g/L Jerusalem artichoke tubers as substrates, inulinase activities of 3.7 and 6.8 U/mL, respectively, were measured using K/INU2, comparing favorably with 2.4 and 3.1 U/mL, respectively, using the wide type strain. Ethanol concentration and productivity for inulin were improved by the recombinant yeast to 96.2 g/L and 1.34 g/L/h, respectively, vs 93.7 g/L and 1.12 g/L/h, respectively, by the wild type strain. Ethanol concentration and productivity improvements for Jerusalem artichoke tubers were 69 g/L and 1.44 g/L/h, respectively, from the recombinant strain vs 62 g/L and 1.29 g/L/h, respectively, from the wild type strain.     

Localization of inulinase and invertase in Kluyveromyces species

In vivo hydrolysis of inulin and sucrose was examined in selected yeasts of the genus Kluyveromyces. Cells, grown in sucrose-limited chemostat cultures, were subjected to treatments for the removal of inulinase, the enzyme responsible for the hydrolysis of both inulin and sucrose. The effects of these treatments were studied by measurement of inulin-dependent and sucrose-dependent oxygen consumption by cell suspensions. In Kluyveromyces marxianus var. marxianus, inulinase was partially secreted into the culture fluid. Removal of culture fluid inulinase by washing had no effect on sucrose-dependent oxygen consumption by this yeast. However, this treatment drastically reduced inulin-dependent oxygen consumption. Treatment of washed cells with sulfhydryls removed part of the cell wall-retained inulinase and reduced inulin-dependent oxygen consumption by another 80%. Sucrose-dependent oxygen consumption was less affected, decreasing by 40%. Cell suspensions of K. marxianus var. drosophilarum, K. marxianus var. vanudenii, and Saccharomyces kluyveri rapidly utilized sucrose but not inulin. This is in accordance with the classification of these yeasts as inulin negative. Supernatants of cultures grown at pH 5.5 did not catalyze the hydrolysis of inulin and sucrose. This suggested that these yeasts contained a strictly cell-bound invertase, an enzyme not capable of inulin hydrolysis. However, upon washing, cells became able to utilize inulin. The inulin-dependent oxygen consumption further increased after treatment of the cells with sulfhydryls. These treatments did not affect the sucrose-dependent oxygen consumption of the cells. Apparently, these treatments removed a permeability barrier for inulin that does not exist for sucrose.(ABSTRACT TRUNCATED AT 250 WORDS)     

菊粉酶基因在酿酒酵母中的表达及乙醇发酵

以乙醇耐受力较强的酿酒酵母为受体菌,构建了能够分泌菊粉酶的基因工程菌并进行了菊芋粉的生料发酵。首先,以马克斯克鲁维酵母Kluyveromyces marxianus中的基因组DNA为模板,PCR扩增菊粉酶编码基因inu,分别使用菊粉酶自身启动子和酵母磷酸甘油激酶 (Phosphoglycerate kinase,pgk) 启动子,构建重组表达质粒HO/p-inu和HO/pgk-inu。经NotⅠ线性化后,采用电击法转化酿酒酵母工业菌株Saccharomyces cerevisiae 6525,分别得到含菊