葡萄糖酸钙对L-组氨酸发酵的影响及条件优化

目的：提高L-组氨酸的产量并且得出最佳发酵条件。方法：在L-组氨酸的摇瓶发酵实验中,加入20g/L的葡萄糖酸钙,对发酵条件进行优化。结果：L-组氨酸的产量大幅度提高,产酸量由3.00g/L提高到7.50g/L。条件优化后L-组氨酸的产量提高到9.30g/L。结论：发酵培养基中20g/L的葡萄糖酸钙的加入能够诱导葡萄糖酸激酶生成,大幅度提高其比活,增大磷酸戊糖（HMP）途径的通量。有利于L-组氨酸的合成、菌体的生长。     

L-苏氨酸工业生产发酵条件优化研究

发酵法生产L-苏氨酸是目前广泛采用的方法,因此研究工业生产发酵条件优化具有重要意义。试验以高产L-苏氨酸菌作为出发菌株,结合本公司的实际工业生产条件对发酵各条件进行了一系列优化研究,结果表明：添加0.2%的工业级生长促进剂,以复合糖代替葡萄糖为初糖,并控制初糖浓度在60g/L,除生长高峰期外,发酵过程中溶解氧（DO）控制在10%~20%之间;最终发酵放罐湿菌体在45g/L左右,L-苏氨酸含量可达110g/L左右。     

柠檬酸钠对L-组氨酸发酵代谢流分布的影响

目的：建立谷氨酸棒杆菌TL1105生物合成L-组氨酸的代谢网络模型,并进行代谢网络计量分析。方法：通过所构建的L-组氨酸代谢网络模型,利用MATLAB软件计算出添加柠檬酸钠和不添加柠檬酸钠发酵中后期代谢网络的代谢流分布。结果：在L-组氨酸分批发酵过程中,在发酵初期未添加柠檬酸钠的条件下流向戊糖磷酸途径（HMP）的代谢流为9.59,合成组氨酸的代谢流为8.91;在发酵初期添加2g/L柠檬酸钠的条件下流向HMP的代谢流为12.74,合成组氨酸的代谢流为9.61。结论：在发酵初期添加柠檬酸钠能够改变L-组氨酸生物合成途径的关键节点6-磷酸葡萄糖、丙酮酸及乙酰辅酶A的代谢流分布,保持糖酵解途径、三羧酸循环与HMP之间代谢流量平衡,有利于提高L-组氨酸生物合成途径的代谢流量,最终使流向组氨酸的代谢流增加了7.86%。     

新筛选L-精氨酸产生菌发酵培养基的响应面优化

目的:优化谷氨酸棒杆菌YHR-09的发酵培养基以提高L-精氨酸的产量.方法:在研究葡萄糖、硫酸铵、玉米浆和生物素4个单因素实验的基础上,用Design Expert软件的Central Composite Design建立响应曲面模型.结果:YHR-09最佳产酸条件 为:葡萄糖112.95g/L,玉米浆22.61g/L,硫酸铵49.44g/L.在此条件下L-精氨酸的产量为29.36g/L,与预测值(29.57g/L)吻合度较高.结论:通过发酵对比实验可见,菌体浓度的明显提高是L-精氨酸产量上升的重要因素.     

米根霉利用纯糖和不同预处理玉米秸秆酶解糖生产L-乳酸

通过单因素实验设计,优化米根霉摇瓶发酵产L-乳酸。在此基础上,以蒸气爆破和碱处理玉米秸秆酶解液为混合C源,与纯糖对比,研究不同预处理玉米秸秆混合C源对米根霉发酵产L-乳酸的影响。结果显示:在初始葡萄糖质量浓度100g/L、(NH4)2SO4质量浓度2g/L、接种量6%(体积分数)、转速170r/min、发酵12h后添加30g/LCaCO3的条件下,米根霉发酵产L-乳酸质量浓度为69.15g/L。米根霉发酵不同预处理玉米秸秆酶解混合C源,木糖的存在影响了米根霉的C代谢网络,降低L乳酸的产量。     

大肠杆菌产L-苯丙氨酸发酵调控及代谢通量分析

考察了外源添加中间代谢产物、维生素B1和硫酸镁对大肠杆菌发酵产L-苯丙氨酸的影响,结果表明,添加1g/L柠檬酸三钠、1g/Lα-酮戊二酸、150mg/L维生素B1及3g/L硫酸镁均对L-苯丙氨酸的合成有利。根据构建的大肠杆菌合成L-苯丙氨酸的生化反应网络,利用代谢通量分析其原因。结果表明,这些物质的添加均可以调节G6P和PEP节点处的代谢通量分布,为L-苯丙氨酸的合成提供更多的前体物质赤藓糖四磷酸(E4P)、磷酸烯醇式丙酮酸(PEP)和还原力NADPH。通过补料分批发酵实验得出,优化后菌体对总葡萄糖的消耗提高了24.49%,菌体终浓度提高了23.50%,L-苯丙氨酸的终浓度提高了62.87%,L-苯丙氨酸的收率提高了30.88%,乙酸的合成降低了56.51%。     

玉米芯稀酸水解及L-乳酸发酵研究

对玉米芯稀硫酸水解条件及糖化液发酵L-乳酸进行了初步研究。结果表明,玉米芯木聚糖最适水解条件为2%H2SO_4、120℃、30 min、固液比1:10,糖化液还原糖含量可达40.8 g/L,主要成分为木塘。细菌A-19可以利用水解液中的葡萄糖和木糖产酸,最适发酵条件为45℃、pH 6.5,从45℃～51℃、pH 5.5～pH 6.5产量均较高。用未浓缩的水解液发酵24 h,L-乳酸产量为30.6g/L,残糖为1.6 g/L,糖酸转化率为82.6%;用浓缩1倍的水解液发酵48 h,L-乳酸产量为41.4 g/L,残糖4.1g/L,糖酸转化率为68.2%,在发酵48 h后继续补料发酵至72 h(补料液为浓缩3倍的水解液),L-乳酸产量为50.9 g/L,残糖6.3 g/L,糖酸转化率为71.8%。该研究为利用木质纤维素生产L-乳酸奠定了一定基础。     

基因重组大肠杆菌表达HrpNEcc蛋白的发酵条件及诱导条件优化

对已构建好的表达HrpNEcc蛋白的工程菌BL21(DE3)/pET30a(+)hrpN Ecc的摇瓶发酵条件及乳糖诱导进行优化, 通过在7L发酵罐中放大发酵实验,以期提高蛋白产量并降低生产成本。在摇瓶中优化的发酵及诱导条件是：5% 的接种量,TB培养基,菌体培养至对数生长前期,添加3g/L外源诱导剂乳糖时,HrpNEcc蛋白产量可达417.60mg/L,比不添加乳糖时提高了36.73%,比用IPTG诱导时提高了16.85%。7L发酵罐中发酵,获得菌体湿重达到57.24g/L（WCW）,可溶性HrpNEcc蛋白产量占细胞总蛋白的50.2%,为3.29 g/L。     

皮状丝孢酵母B3利用木薯淀粉发酵生产微生物油脂

对皮状丝孢酵母B3以木薯淀粉水解液为碳源发酵生产微生物油脂培养条件进行了优化,并在2 L发酵罐中对菌体生长和油脂积累进行了考察。摇瓶实验表明,木薯淀粉水解液的浓度高于90 g/L时不利于菌体的生长和油脂积累,皮状丝孢酵母B3发酵生产微生物油脂的最适氮源及其浓度、最适C/N比和pH分别为酵母提取物3.0 g/L、116、6.0,在此条件下培养144 h菌体生物量、油脂产量和油脂含量分别达到15.2 g/L、6.22 g/L和40.9％;在2 L发酵罐中分批发酵44 h后菌体生物量、油脂产量和油脂含量分别达28.7 g/L、12.27 g/L和42.8％。以皮状丝孢酵母B3所产油脂制备生物柴油,其主要组成包括棕榈酸甲酯、硬脂酸甲酯、油酸甲酯、亚油酸甲酯等,且理化特性符合相关国家标准,可作为一种有潜力的化石燃料替代品。     

产γ-氨基丁酸乳酸菌的发酵优化

为显著提高γ-氨基丁酸的产量,对发酵培养基的装液量、接种量、碳源、氮源、L-谷氨酸（L-Glu）的添加量进行了单因素优化,在单因素基础上进行响应面优化,利用 Plackett-Burman 得出对产γ-氨基丁酸影响最大的因素分别为：葡萄糖、玉米浆、接种量以及发酵时间,用最陡爬坡试验逼近关键因素的最大响应区域。在此基础上,采用 Box-Behnken 试验设计对培养基组分进行进一步优化,得出4种显著因子葡萄糖、玉米浆、接种量以及发酵时间的最佳结果分别为22．0 g·L－1、15．0 g·L－1、19％和48 h。采用优化培养基后,γ-氨基丁酸的产量可达到12．030 g·L－1,较原始培养基的产量增加了5．602 g·L－1。     

L-谷氨酸补料分批发酵的研究

对谷氨酸棒杆菌(Corynebacteriuin glutamicum)HCJ46产L-谷氨酸的补料分批发酵条件进行研究.结果表明:最适初糖质量浓度和最佳残糖维持质量浓度分别为100和(10～20)g/L;对发酵控温方式进行研究,确定了最佳温度控制策略为0～8h维持32℃,8～16h维持34℃、16～32h维持36℃,同时发现相对溶氧控制在30%左右时产酸最高.在以上的优化条件下,L-谷氨酸产量从72g/L提高到95g/L,提高了31.9%.     

Potential inhibitors from wet oxidation of wheat straw and their effect on ethanol production of Saccharomyces cerevisiae: wet oxidation and fermentation by yeast

Alkaline wet oxidation (WO) (using water, 6.5 g/L sodium carbonate and 12 bar oxygen at 195 degrees C) was used as pretreatment method for wheat straw (60 g/L), resulting in a hydrolysate and a cellulosic solid fraction. The hydrolysate consisted of soluble hemicellulose (8 g/L), low-molecular-weight carboxylic acids (3.9 g/L), phenols (0.27 g/L = 1.7 mM) and 2-furoic acid (0.007 g/L). The wet oxidized wheat straw hydrolysate caused no inhibition of ethanol production by Saccharomyces cerevisiae ATCC 96581. Nine phenols and 2-furoic acid, identified to be present in the hydrolysate, were each tested in concentrations of 50-100 times the concentration found in the hydrolysate for their effect on fermentation by yeast. At these high concentrations (10 mM), 4-hydroxybenzaldehyde, vanillin, 4-hydroxyacetophenone and acetovanillone caused a 53-67% decrease in the volumetric ethanol productivity in S. cerevisiae compared to controls with an ethanol productivity of 3.8 g/L. The phenol acids (4-hydroxy, vanillic and syringic acid), 2-furoic acid, syringaldehyde and acetosyringone were less inhibitory, causing a 5-16% decrease in ethanol productivity. By adding the same aromatic compounds to hydrolysate (10 mM), it was shown that syringaldehyde and acetovanillone interacted negatively with hydrolysate components on the ethanol productivity. Fermentation in WO hydrolysate, that had been concentrated 6 times by freeze-drying, lasted 4 hours longer than in regular hydrolysate; however, the ethanol yield was the same. The longer fermentation time could not be explained by an inhibitory action of phenols alone, but was more likely caused by inhibitory interactions of phenols with carboxylic acids, such as acetic and formic acid.     

发酵产丁二酸过程中废弃细胞的循环利用

对厌氧发酵产丁二酸后的废弃细胞进行破壁处理,考察了以细胞水解液作为有机氮源重新用于丁二酸发酵的可行性。比较了超声破碎、盐溶、酶解3种方法破碎细胞获得的水解液作为氮源发酵产丁二酸的效果,结果表明酶解制得的细胞水解液效果最佳。以总氮含量为1.11g/L的酶解液(相当于10g/L酵母膏)作为氮源发酵,丁二酸产量可达42.0g/L,继续增大酶解液用量对耗糖、产酸能力没有显著提高。将细胞酶解液与5g/L酵母膏联用发酵36h后,丁二酸产量达75.5g/L,且丁二酸生产强度为2.10g/(L·h),比使用10g/L酵母膏时提高了66.7%。因此,厌氧发酵产丁二酸结束后的废弃细胞酶解液可以替代原培养基中50%的酵母膏用于发酵。     

茴香酸产生菌发酵条件的优化

为提高微生物降解反式茴脑获得茴香酸的产量,对假单胞菌Pseudomonas sp.NT2的发酵参数进行优化,以提高降解过程的转化率。利用单因素试验考察碳氮源种类及浓度、反式茴脑添加量、发酵温度、接种量、初始pH以及装液量对茴香酸生成量、反式茴脑降解率的影响,通过Plackett-Burman试验和最陡爬坡试验确定影响茴香酸生成量的显著因素并获取中心点,最后采用Box-Behnken模型进行响应面优化得到最佳发酵条件并验证。结果表明氯化铵浓度、初始pH和装液量是显著影响因素,最佳发酵条件为:柠檬酸钠10 g/L,氯化铵1.26 g/L,反式茴脑添加量1%,发酵温度30℃,接种量4%,初始pH 7.9,装液量42 mL/250 mL。优化后茴香酸生成量为7.24 g/L,为优化前的3.5倍,茴香酸摩尔生成率为80.72%,反式茴脑降解率为89.81%,分别比优化前提高了270.28%和97.78%。综上,假单胞菌NT2是生物转化生产茴香酸的潜力菌株。响应面优化可以显著提高反式茴脑的降解率和茴香酸产量,这为大规模生产茴香酸奠定了基础。     

拜氏梭菌Clostridium beijerinckii NCIMB 8052发酵玉米皮生产丁醇

玉米皮作为玉米淀粉加工的副产物,是一种可用于生产液体燃料的潜在廉价优质的生物质资源。本文以玉米皮为原料,对拜氏梭菌发酵生产丁醇进行了研究。实验结果表明,玉米皮首先在最优的预处理温度140℃下使用0.5%硫酸水溶液以固液比1∶8处理20 min,再添加200 IU/g底物糖化酶、1.0 IU/g底物木聚糖酶进行酶解,可以使原料中的淀粉和半纤维素转化为可发酵糖,此时水解液中的总糖浓度为50.46 g/L。然后使用1.0%的活性炭对水解液进行脱毒处理以去除发酵抑制物,再进行丁醇发酵,丁醇产量为9.72 g/L,总溶剂产量可达14.09 g/L,糖醇转化率为35.1%。上述研究结果证明玉米皮作为一种粮食加工废弃物用于液体燃料丁醇的生产在技术上是完全可行的。     

Microbial production of d‐lactic acid from dried distiller's grains with solubles

d ‐Lactic acid production is gaining increasing attention due to the thermostable properties of its polymer, poly‐d ‐lactic acid . In this study, Lactobacillus coryniformis subsp. torquens, was evaluated for its ability to produce d ‐lactic acid using Dried Distiller's Grains with Solubles (DDGS) hydrolysate as the substrate. DDGS was first subjected to alkaline pretreatment with sodium hydroxide to remove the hemicellulose component and the generated carbohydrate‐rich solids were then subjected to enzymatic hydrolysis using cellulase mixture Accellerase® 1500. When comparing separate hydrolysis and fermentation and simultaneous saccharification and fermentation (SSF) of L. coryniformis on DDGS hydrolysate, the latter method demonstrated higher d ‐lactic acid production (27.9 g/L, 99.9% optical purity of d ‐lactic acid), with a higher glucose to d ‐lactic acid conversion yield (84.5%) compared to the former one (24.1 g/L, 99.9% optical purity of d ‐lactic acid). In addition, the effect of increasing the DDGS concentration in the fermentation system was investigated via a fed‐batch SSF approach, where it was shown that the d ‐lactic acid production increased to 38.1 g/L and the conversion yield decreased to 70%. In conclusion, the SSF approach proved to be an efficient strategy for the production of d ‐lactic acid from DDGS as it reduced the overall processing time and yielded high d ‐lactic acid concentrations.     

Beneficial Effect of Corncob Acid Hydrolysate on the Lipid Production by Oleaginous Yeast Trichosporon dermatis

In this work, corncob acid hydrolysate and its simulated medium whose sugar composition was the same as the corncob acid hydrolysate were used as fermentation substrate for lipid production by oleaginous yeast Trichosporon dermatis. On the corncob acid hydrolysate, after 7 days of fermentation, the biomass, lipid content, lipid yield, and lipid coefficient of T. dermatis were 17.3 g/L, 40.2%, 7.0 g/L, and 16.5%, respectively. Interestingly, during the lipid fermentation on the corncob acid hydrolysate, glucose, xylose, arabinose, and even acetic acid could be well utilized as carbon sources by T. dermatis. Surprisingly, the lipid yield (7.0 g/L) of T. dermatis on the corncob acid hydrolysate was much higher than that (3.8 g/L) on the simulated medium, in spite of the fact that the lipid coefficient (17.4%) on the simulated medium was a little higher. This phenomenon further showed that lignocellulosic acid hydrolysate was a suitable substrate for lipid fermentation by T. dermatis. This work would help the comprehensive utilization of lignocellulosic biomass for lipid production.     

菊糖芽孢乳杆菌DS2-18中试规模的D-乳酸发酵研究

研究了菊糖芽孢乳杆茵DS2的突变株DS2-18在中试规模的D-乳酸发酵.在容积为300L自控发酵罐中,DS2-18茵在合适的发酵条件下,即培养基组成(g/L):葡萄糖120,玉米浆8,蛋白胨6,豆粕水解液100,接种量8%(v/v),发酵温度40℃,以轻质碳酸钙作为中和剂调pH 5～6,发酵期间交替不通气和通气,发酵6...