利用嗜盐菌Salinivibrio YS生产2,3-丁二醇和琥珀酸

以从新疆艾丁湖采集的土样中分离出的中度嗜盐菌Salinivibrio YS为研究对象,利用该菌在厌氧条件下生产2,3-丁二醇和琥珀酸,在单因素摇瓶实验基础上,确定影响产物积累的各因素及其相应条件,再利用正交试验确定这些参数的最佳水平,即温度33℃,起始pH为8.0,发酵过程pH为7.0,乙酸添加量为3 g/L,NaCl浓度为l0 g/L.利用优化条件进行3L体系的发酵放大实验,经过108 h的无氧发酵,2,3-丁二醇的产量可达35.05 g/L,而琥珀酸的含量则高达22.46 g/L,且其糖的总转化率高达约50％.首次利用嗜盐菌在厌氧条件下生产2,3-丁二醇和琥珀酸,拓展了嗜盐菌的应用,同时也为生产2,3-丁二醇和琥珀酸提供了新的思路.     

Enhancement of succinic acid production by osmotic-tolerant mutant strain of Actinobacillus succinogenes

Fermentation and succinic acid production by Actinobacillus succinogenes YZ0819 was inhibited by high NaCl. To enhance the resistance of this strain to osmotic stress, an NaCl-tolerant mutant strain of A. succinogenes (CH050) was screened and selected through a continuous culture using survival in 0.7 M NaCl as the selection criterion. Using Na₂CO₃ as the pH regulator and glucose as the carbon source in batch fermentation, the isolated osmo-resistant stain, A. succinogenes CH050, produced up to 66 g/l succinic acid with a yield of 73.37% (w/w). The concentration of succinic acid and mass yield were increased by 37.5 and 4.37%, respectively, compared to the parent strain. The dry cell weight reached 10.1 g/l, which is 37% higher than that of the parent strain. The high tolerance of A. succinogenes CH050 to osmotic stress increased improved the succinic acid production from batch fermentation.     

Production of succinic acid and lactic acid by Corynebacterium crenatum under anaerobic conditions

A new succinic acid and lactic acid production bioprocess by Corynebacterium crenatum was investigated in mineral medium under anaerobic conditions. Corynebacterium crenatum cells with sustained acid production ability and high acid volumetric productivity harvested from the glutamic acid fermentation broth were used to produce succinic acid and lactic acid. Compared with the first cycle, succinic acid production in the third cycle increased 120% and reached 43.4 g/L in 10 h during cell-recycling repeated fermentations. The volumetric productivities of succinic acid and lactic acid could maintain above 4.2 g/(L·h) and 3.1 g/(L·h), respectively, for at least 100 h. Moreover, wheat bran hydrolysates could be used for succinic acid and lactic acid production by the recycled C. crenatum cells. The final succinic acid concentration reached 43.6 g/L with a volumetric productivity of 4.36 g/(L·h); at the same time, 32 g/L lactic acid was produced.     

Succinic acid production from corn stalk hydrolysate in an E. coli mutant generated by atmospheric and room-temperature plasmas and metabolic evolution strategies

AFP111 is a spontaneous mutant of Escherichia coli with mutations in the glucose-specific phosphotransferase system, pyruvate formate lyase system, and fermentative lactate dehydrogenase system, created to reduce byproduct formation and increase succinic acid accumulation. In AFP111, conversion of xylose to succinic acid only generates 1.67 ATP per xylose, but requires 2.67 ATP for xylose metabolism. Therefore, the ATP produced is not adequate to accomplish the conversion of xylose to succinic acid in chemically defined medium. An E. coli mutant was obtained by atmospheric and room-temperature plasmas and metabolic evolution strategies, which had the ability to use xylose and improve the capacity of cell growth. The concentration of ATP in the mutant was 1.33-fold higher than that in AFP111 during xylose fermentation. In addition, under anaerobic fermentation with almost 80 % xylose from corn stalk hydrolysate, a succinic acid concentration of 21.1 g l^?1 was obtained, with a corresponding yield of 76 %.     

A complete industrial system for economical succinic acid production by Actinobacillus succinogenes

An industrial fermentation system using lignocellulosic hydrolysate, waste yeast hydrolysate, and mixed alkali to achieve high-yield, economical succinic acid production by Actinobacillus succinogenes was developed. Lignocellulosic hydrolysate and waste yeast hydrolysate were used efficiently as carbon sources and nitrogen source instead of the expensive glucose and yeast extract. Moreover, as a novel method for regulating pH mixed alkalis (Mg(OH)₂ and NaOH) were first used to replace the expensive MgCO₃ for succinic acid production. Using the three aforementioned substitutions, the total fermentation cost decreased by 55.9%, and 56.4 g/L succinic acid with yield of 0.73 g/g was obtained, which are almost the same production level as fermentation with glucose, yeast extract and MgCO₃. Therefore, the cheap carbon and nitrogen sources, as well as the mixed alkaline neutralize could be efficiently used instead of expensive composition for industrial succinic acid production.     

Performance analyses of a neutralizing agent combination strategy for the production of succinic acid by <Emphasis Type="Italic">Actinobacillus succinogenes</Emphasis> ATCC 55618

A neutralizing agent combination strategy was developed to enhance the succinic acid production by Actinobacillus succinogenes ATCC 55618. First, a maximal succinic acid production of 48.2 g/L was obtained at a culture pH of 7.5. Second, NaOH and KOH were screened to identify the optimal neutralizing agent for pH control. However, the production of succinic acid did not increase, and severe cell flocculation was observed due to a high concentration of metal ions when only one neutralizing agent was used to control pH. Finally, a neutralizing agent combination strategy was developed with a supply of neutralizing agents with OH⁻ and carbonate. The cell flocculation was eliminated, and a maximum succinic acid production of 59.2 g/L was obtained with 5 M NaOH and 40 g/L of MgCO₃; this production was 27.9% higher than that obtained with NaOH alone. The results obtained in this study may be useful for the large-scale industrial production of succinic acid.     

调控大肠杆菌胞内ATP和NADH水平促进琥珀酸生产

琥珀酸作为一种重要的C4平台化合物,广泛应用于食品、化学、医药等领域。利用大肠杆菌(Escherichia coli)发酵生产琥珀酸受胞内辅因子不平衡的影响,存在产率低、生产强度低、副产物多等问题。为此,对不同氧气条件下琥珀酸产量和化学计量学分析发现,微厌氧条件下E.coli FMME-N-26高效积累琥珀酸需要借助三羧酸循环(tricarboxylic acid cycle,TCA)为还原性三羧酸途径(reductive tricarboxylic acid pathway,r-TCA)提供足够的ATP和NADH。通过减少ATP消耗、强化ATP合成、阻断NADH竞争途径和构建NADH回补路径等代谢工程策略,组合调控胞内ATP与NADH含量,获得工程菌株E.coli FW-17。通过发酵条件优化,菌株E.coli FW-17在5 L发酵罐能积累139.52 g/L琥珀酸,比出发菌株提高了17.81%,乙酸浓度为1.40 g/L,降低了67.59%。进一步在1000 L发酵罐中进行放大实验,琥珀酸产量和乙酸浓度分别为140.2 g/L和1.38 g/L。     

Effect of redox potential regulation on succinic acid production by Actinobacillus succinogenes

The effects of redox potential used as a control parameter on the process of succinic acid production in batch cultures of Actinobacillus succinogenes NJ113 have been investigated. In batch fermentation, cell growth and metabolite distribution were changed with redox potential levels in the range of ?100 to ?450 mV. From the results, the ORP level of ?350 mV was preferable, which resulted in high succinic acid yield (1.28 mol mol^?1), high succinic acid productivity (1.18 g L^?1 h^?1) and high mole ratio of succinic acid to acetic acid (2.02). The mechanism of redox potential regulation was discussed by metabolic flux analysis and the ratio of NADH/NAD⁺. We expected that redox potential can be used as a valuable parameter to monitor and control much more anaerobic fermentation production.     

过量表达苹果酸脱氢酶对大肠杆菌NZN111产丁二酸的影响

大肠杆菌NZN111是敲除了乳酸脱氢酶的编码基因 (ldhA) 和丙酮酸-甲酸裂解酶的编码基因 (pflB) 的工程菌,厌氧条件下由于辅酶NAD(H) 的不平衡导致其丧失了代谢葡萄糖的能力。构建了苹果酸脱氢酶的重组菌大肠杆菌NZN111/pTrc99a-mdh,在厌氧摇瓶发酵过程中通过0.3 mmol/L的IPTG诱导后重组菌的苹果酸脱氢酶 (Malate dehydrogenase,MDH) 酶活较出发菌株提高了14.8倍,NADH/NAD+的比例从0.64下降到0.26,同时NAD+和NADH浓度分别     

Process development of succinic acid production by Escherichia coli NZN111 using acetate as an aerobic carbon source

Escherichia coli strain NZN111 could convert glucose to succinic acid efficiently in anaerobic conditions after the induction of gluconeogenic carbon sources in aerobic conditions. Acetate shows a strong effect on both yield and productivity of succinic acid. In this study, the fed-batch process of succinic acid production by NZN111 using acetate in a chemically defined medium in the aerobic stage was investigated and developed. Increasing cell density could increase succinic acid with a productivity of 3.97 g/(L h) in the first 8 h of the anaerobic phase with an overall yield of 1.42 mol/mol glucose in a 5 L fermentor. However, there was strong repression from succinic acid in the later anaerobic stage. When succinic acid exceeded 30 g/L, the glucose consumption rate began to drop sharply along with the succinic acid production rate. Supplementation with glucose from 30 to 70 g/L in the anaerobic stage showed little effect on succinic acid production. Acetic acid and pyruvic acid accumulated had no effect on succinic acid formation because of their low concentration. With acetate as the sole carbon source for aerobic cultivation in the following scale-up, 60.09 g/L of succinic acid was produced with a yield of 1.37 mol/mol in a 50 L bioreactor.     

Fermentative production of succinic acid from straw hydrolysate by Actinobacillus succinogenes

In this work, straw hydrolysates were used to produce succinic acid by Actinobacillus succinogenes CGMCC1593 for the first time. Results indicated that both glucose and xylose in the straw hydrolysates were utilized in succinic acid production, and the hydrolysates of corn straw was better than that of rice or wheat straw in anaerobic fermentation of succinic acid. However, cell growth and succinic acid production were inhibited when the initial concentration of sugar, which was from corn straw hydrolysate (CSH), was higher than 60 g l^?1. In batch fermentation, 45.5 g l^?1 succinic acid concentration and 80.7% yield were attained after 48 h incubation with 58 g l^?1 of initial sugar from corn straw hydrolysate in a 5-l stirred bioreactor. While in fed-batch fermentation, concentration of succinic acid achieved 53.2 g l^?1 at a rate of 1.21 g l^?1 h^?1 after 44 h of fermentation. Our work suggested that corn straw could be utilized for the economical production of succinic acid by A. succinogenes.     

进化代谢选育高渗透压耐受型产琥珀酸大肠杆菌

在以碳酸钠为酸中和剂的大肠杆菌两阶段发酵产琥珀酸的过程中,由于Na+的积累造成发酵体系中渗透压的提高,严重抑制了琥珀酸的产物浓度。为了增强大肠杆菌对渗透压的耐受性,考察了利用进化代谢方法筛选高渗透压耐受型高产琥珀酸大肠杆菌菌株的可行性。进化代谢系统作为一种菌株突变装置,可以使菌体在连续培养条件下以最大的生长速率生长。以NaCl为渗透压调节剂,通过在连续培养装置中逐步提高NaCl浓度使菌体在高渗透压条件下快速生长,最终得到了一株高渗透压耐受型琥珀酸生产菌株Escherichia coli XB4。以碳酸钠为酸中和剂,在7 L发酵罐中利用Escherichia coli XB4进行两阶段发酵,厌氧培养60 h后,琥珀酸产量达到了69.5 g/L,琥珀酸生产速率达到了1.81 g/(L.h),分别比出发菌株提高了18.6%和20%。     

S-Adenosylmethionine,cyclopropane fatty acid synthase,and the production of lactobacillic acid in Lactobacillus plantarum

S-Adenosylmethionine (AdoMet) levels in Lactobacillus plantarum were found to increase concomitantly with the production of membrane cyclopropane fatty acids under normal growth conditions. This increase in AdoMet did not occur when the pH of the culture medium (initially pH 6.5) was not allowed to fall (pH 4 or lower) during growth. When the culture medium was maintained at pH 6.5, cyclopropane fatty acid synthesis also remained low. While the activity of cyclopropane fatty acid synthase is increased as the pH decreases, the activity of AdoMet synthetase is largely unaffected by the variation of pH of the culture medium. The production of cyclopropane fatty acids is also dependent upon continued protein synthesis; in the presence of chloramphenicol cyclopropane fatty acid synthase activity is decreased, resulting in a lowered production of cyclopropane fatty acids. A dramatic increase in AdoMet levels occurs in the presence of chloramphenicol. It is proposed that AdoMet levels, in conjunction with cyclopropane fatty acid synthase activities, regulate cyclopropane fatty acid synthesis in L. plantarum.     

Anaerobic reduction of ferulic acid to dihydroferulic acid by Wolinella succinogenes from cow rumen

Summary Ferulic acid(FA)-modifying microflora from the rumen of cows were acclimated in an FA-containing medium, in which aromatic compounds (dihydroferulic acid, homovanillic acid, carboxymethylphenol and vanillic acid) and volatile fatty acids (acetic, butyric and isobutyric) were detected by gas chromatography and mass spectrometry. An anaerobic curved bacterium was isolated from the rumen microflora. This bacterium was characterized and identified as Wolinella succinogenes according to the method of Holdeman et al. (1977). It could only reduce FA to dihydroferulic acid in the absence of hydrogen acceptors such as nitrate or fumarate and under strictly anaerobic conditions. FA-reducing ability of the bacterium was inhibited to some extent at FA concentrations greater than 5 mM. The FA was reduced more effectively at pH values of 7.0–7.2 than at 6.8 and the reduction was enhanced by the addition of an Ruminococcus albus' culture supernatant.     

谷氨酸棒状杆菌厌氧产丁二酸的发酵条件

考察谷氨酸棒状杆菌ATCC13032Δldh厌氧产丁二酸的发酵条件。结果发现:补加NaHCO3的效果最好,并且考察了NaHCO3浓度对葡萄糖转化速率及丁二酸生成速率的影响。运用代谢流分析方法分析了乳酸脱氢酶基因敲除对谷氨酸棒状杆菌厌氧代谢的影响,发现乳酸脱氢酶基因敲除导致磷酸烯醇式丙酮酸生成丁二酸的流量提高了214.3%,流向乳酸的流量变为0;分批厌氧转化36 h生成41.2 g/L丁二酸,产率45.0%。     

Enhanced production of succinic acid by Actinobacillus succinogenes with reductive carbon source

Carbon sources with different oxidation states were used to investigate the possibility increasing the availability of NADH and the NADH/NAD⁺ ratio and to determine the effect of this manipulation on the distribution of metabolites in Actinobacillus succinogenes NJ113. The sugars glucose, sorbitol and gluconate were each used at an initial concentration of 40 g/L.The yield of succinic acid (0.75) and the ratio of succinic acid to acetic acid (5.06) were both higher for sorbitol than the values obtained with glucose (0.66 and 2.68, respectively). In contrast, with gluconate as the carbon source the yield of succinic acid was 0.54 and the ratio of succinic acid to acetic acid was only 1.70. This work showed that different levels of NADH availability and the NADH/NAD⁺ ratio can be achieved by using carbon sources that have different oxidation states.Highly reduced sorbitol was examined as a possible carbon substrate for maximizing the redox potential during the production of succinic acid.     

Metabolic engineering of Mannheimia succiniciproducens for malic acid production using dimethylsulfoxide as an electron acceptor

Microbial production of various TCA intermediates and related chemicals through the reductive TCA cycle has been of great interest. However, rumen bacteria that naturally possess strong reductive TCA cycle have been rarely studied to produce these chemicals, except for succinic acid, due to their dependence on fumarate reduction to transport electrons for ATP synthesis. In this study, malic acid (MA), a dicarboxylic acid of industrial importance, was selected as a target chemical for mass production using Mannheimia succiniciproducens, a rumen bacterium possessing a strong reductive branch of the TCA cycle. The metabolic pathway was reconstructed by eliminating fumarase to prevent MA conversion to fumarate. The respiration system of M. succiniciproducens was reconstructed by introducing the Actinobacillus succinogenes dimethylsulfoxide (DMSO) reductase to improve cell growth using DMSO as an electron acceptor. Also, the cell membrane was engineered by employing Pseudomonas aeruginosa cis-trans isomerase to enhance MA tolerance. High inoculum fed-batch fermentation of the final engineered strain produced 61 g/L of MA with an overall productivity of 2.27 g/L/h, which is the highest MA productivity reported to date. The systems metabolic engineering strategies reported in this study will be useful for developing anaerobic bioprocesses for the production of various industrially important chemicals.     

Biosynthesis of 1,3-propanediol from recombinant E. coli by optimization process using pure and crude glycerol as a sole carbon source under two-phase fermentation system

The environmental and nutritional condition for 1,3-propanediol (1,3-PD) production by the novel recombinant E. coli BP41Y3 expressing fusion protein were first optimized using conventional approach. The optimum environmental conditions were: initial pH at 8.0, incubation at 37 °C without shaking and agitation. Among ten nutrient variables, fumarate, (NH₄)₂HPO₄ and peptone were selected to study on their interaction effect using the response surface methodology. The optimum medium contained modified Riesenberg medium (containing pure glycerol as a sole carbon source) supplemented with 63.65 mM fumarate, 3.80 g/L (NH₄)₂HPO₄ and 1.12 g/L peptone, giving the maximum 1,3-PD production of 2.43 g/L. This was 3.5-fold higher than the original medium (0.7 g/L). Two-phase cultivation system was conducted and the effect of pH control (at 6.5, 7.0 and 8.0) was investigated under anaerobic condition by comparing with the no pH control condition. The cultivation system without pH control (initial pH of 8.0) gave the maximum values of 1.65 g/L 1,3-PD, the 1,3-PD production rate of 0.13 g/L h and the yield of 0.31 mol 1,3-PD/mol crude glycerol. Hence, using crude glycerol as a sole carbon source resulted in 32 % lower 1,3-PD production from this recombinant strain that may be due to the presence of various impurities in the crude glycerol of biodiesel plant. In addition, succinic acid was found to be a major product during fermentation by giving the maximum concentration of 11.92 g/L after 24 h anaerobic cultivation.     

耐铵型产琥珀酸放线杆菌的选育

以Actinobacillus succinogenes NJ113为出发菌株,经硫酸二乙酯(DES)诱变,在含8～20 g/L硫酸铵平板中筛选到一株耐铵型突变株YZ25,该菌株在含8 g/L硫酸铵培养基中厌氧发酵,琥珀酸产量达32.68 g/L,比出发菌提高了180.5%,对葡萄糖收率达65.4%,副产物乙酸、甲酸产量分别下降3.5%、28.7%,琥珀酸/乙酸比值由0.63提高到2.5。在7.5 L发酵罐中,用氨水调节pH分批实验,发酵34 h琥珀酸产量达27.13 g/L,较出发菌株提高了85.3%。     

Substrate and product inhibition kinetics in succinic acid production by Actinobacillus succinogenes

The inhibition of substrate and products on the growth of Actinobacillus succinogenes in fermentation using glucose as the major carbon source was studied. A. succinogenes tolerated up to 143 g/L glucose and cell growth was completely inhibited with glucose concentration over 158 g/L. Significant decrease in succinic acid yield and prolonged lag phase were observed with glucose concentration above 100 g/L. Among the end-products investigated, formate was found to have the most inhibitory effect on succinic acid fermentation. The critical concentrations of acetate, ethanol, formate, pyruvate and succinate were 46, 42, 16, 74, 104 g/L, respectively. A growth kinetic model considering both substrate and product inhibition is proposed, which adequately simulates batch fermentation kinetics using both semi-defined and wheat-derived media. The model accurately describes the inhibitory kinetics caused by both externally added chemicals and the same chemicals produced during fermentation. This paper provides key insights into the improvement of succinic acid production and the modelling of inhibition kinetics.