过量表达烟酸单核苷酸腺苷酰转移酶对大肠杆菌NZN111产丁二酸的影响

大肠杆菌NZN111是敲除了乳酸脱氢酶的编码基因(ldhA)和丙酮酸-甲酸裂解酶的编码基因(pflB)的发酵生产丁二酸的潜力菌株。厌氧条件下NADH不能及时再生为NAD+,引起胞内辅酶NAD(H)的不平衡,最终导致厌氧条件下菌株不能利用葡萄糖生长代谢。nadD为催化NAD(H)合成途径中烟酸单核苷酸(NaMN)生成烟酸腺嘌呤二核苷酸(NaAD)的烟酸单核苷酸腺苷酰转移酶(Nicotinic acid mononucleotide adenylyltransferase,NAMNAT)的编码基因,通过过量表达nadD基因能够提高NAD(H)总量与维持合适的NADH/NAD+比例。文中构建了重组菌E.coli NZN111/pTrc99a-nadD,在厌氧摇瓶发酵过程中通过添加终浓度为1.0 mmol/L的IPTG诱导表达,重组菌E.coli NZN111/pTrc99a-nadD中NAD+和NADH的浓度分别比宿主菌E.coli NZN111提高了3.21倍和1.67倍,NAD(H)总量提高了2.63倍,NADH/NAD+从0.64降低为0.41,使重组菌株恢复了厌氧条件下生长和代谢葡萄糖的能力。重组菌与对照菌相比,72 h内可以消耗14.0 g/L的葡萄糖产6.23 g/L的丁二酸,丁二酸产量增加了19倍。     

过量表达烟酸转磷酸核糖激酶对大肠杆菌NZN111产丁二酸的影响

大肠杆菌NZN111厌氧发酵的主要产物为丁二酸,是发酵生产丁二酸的潜力菌株。但是由于敲除了乳酸脱氢酶的编码基因 (ldhA) 和丙酮酸甲酸裂解酶的编码基因 (pflB),导致辅酶NADH/NAD+不平衡,厌氧条件下不能利用葡萄糖生长代谢。构建烟酸转磷酸核糖激酶的重组菌Escherichia coli NZN111/pTrc99a-pncB,在厌氧摇瓶发酵过程中通过添加0.5 mmol/L的烟酸、0.3 mmol/L的IPTG诱导后重组菌的烟酸转磷酸核糖激酶 (Nicotinic acid phosphor     

共表达烟酸转磷酸核糖激酶和丙酮酸羧化酶对大肠杆菌NZN111产丁二酸的影响

构建了共表达烟酸转磷酸核糖激酶(NAPRTase)和丙酮酸羧化酶(PYC)的重组质粒pTrc99a-pncB-pyc,并考察了重组菌E.coli NZN111/pTrc99a-pncB-pyc生产丁二酸的能力。结果表明:重组菌NZN111/pTrc99a-pncB-pyc的NAPRTase和PYC的比酶活达到最高,分别为20.75和1.04 U/mg,同时,辅酶NADH、NAD+及NAD(H)总量达到最高。厌氧摇瓶发酵结果:48 h能够消耗17.5 g/L的葡萄糖生成14.08 g/L的丁二酸,而丙酮酸的产量大幅度降低,仅为0.11 g/L。本研究为基因工程菌大肠杆菌厌氧条件下发酵生产丁二酸提供了一定的基础。     

烟酸转磷酸核糖激酶和丙酮酸羧化酶共表达对大肠杆菌BA002产丁二酸的影响

大肠杆菌BA002是敲除了乳酸脱氢酶的编码基因 (ldhA) 和丙酮酸-甲酸裂解酶的编码基因 (pflB) 的工程菌。厌氧条件下NADH不能及时再生为NAD+,引起胞内辅酶NAD(H)的不平衡,最终导致厌氧条件下菌株不能利用葡萄糖生长代谢。pncB是烟酸转磷酸核糖激酶 (NAPRTase) 的编码基因,通过过量表达pncB基因能够提高NAD(H)总量与维持合适的NADH/NAD+,从而恢复了厌氧条件下重组菌E. coli BA014 (BA002/pTrc99a-pncB) 的生长和产丁二酸的性能。然而,BA014在厌氧发酵过程中有大量丙酮酸积累,为进一步提高菌株的丁二酸生产能力,减少副产物丙酮酸的生成,共表达NAPRTase和来自于乳酸乳球菌 NZ9000中丙酮酸羧化酶 (PYC) 的编码基因pyc,构建了重组菌E. coli BA016 (BA002/pTrc99a-pncB-pyc)。3 L发酵罐结果表明,BA016发酵112 h后,共消耗了35.00 g/L的葡萄糖。发酵结束时,菌体OD600为4.64,产生了25.09 g/L丁二酸。通过共表达pncB和pyc基因,使BA016的丙酮酸积累进一步降低,丁二酸产量进一步提高。     

土壤假单胞菌亚磷酸盐脱氢酶的基因克隆和原核表达及其酶活分析

亚磷酸盐脱氢酶(PTDH)以NAD+为辅助因子催化亚磷酸盐氧化生成正磷酸盐和NADH,在辅酶再生和基于亚磷酸盐的磷利用等方面有着潜在重大的应用价值。以土壤宏基因组DNA为模板,采用两轮PCR扩增得到全长亚磷酸盐脱氢酶基因PsPtx。通过酶切将它克隆到质粒pET32a(+)中,构建了原核表达载体pET(PsPtx)。序列分析表明,PsPtx基因的完整编码区大小为1 011 bp,其推导蛋白由336个氨基酸组成,理论分子量大小为36.5 kD。保守结构域预测分析表明PsPtx编码蛋白属于亚磷酸盐脱氢酶,含有保守的NAD+结合基序和催化功能残基。系统进化树分析显示PsPtx基因来源于一无法确定种名的土壤假单胞菌。另外,PsPtx基因经IPTG诱导能在大肠杆菌BL21(DE3)中获得高效表达,重组PsPtx蛋白用组氨酸标签亲合层析纯化,其以亚磷酸钠盐为底物的酶比活性为3.75 U/mg。该PsPtx功能基因的获得为其后续应用研究打下了必要的基础。     

荧光假单胞菌短链脱氢酶的克隆、表达及酶学性质分析

为了研究荧光假单胞菌中短链脱氢酶的生理角色和催化特性,从荧光假单胞菌Pseudomonas fluorescens GIM1.49基因组DNA克隆表达了一个短链脱氢酶的编码基因pfd,并分析了该基因产物的酶学性质。基因pfd全长684 bp,编码227个氨基酸,推算分子量为24.2 kDa。将携带短链脱氢酶基因的重组质粒pET28b-pfd转入大肠杆菌BL21(DE3) 进行表达,得到了28 kDa的表达产物。重组荧光假单胞菌短链脱氢酶 (PFD) 能氧化4-氯-3-羟基丁酸乙酯、1-苯乙醇、苯甲醇、仲丁醇和还原4-氯-乙酰乙酸乙酯、2-溴-苯乙酮、4-溴-苯乙酮等底物。以4-氯-3-羟基丁酸乙酯为底物时活力最高,Km值为186.90 mmol/L,Vmax为89.56 U/mg。氧化4-氯-3-羟基丁酸乙酯时,最适反应温度和pH分别为12 ℃和10.5,倾向于利用NAD+作辅酶;而还原4-氯-乙酰乙酸乙酯时,最适温度和pH为24 ℃和8.8,倾向于利用NADPH作辅酶。重组PFD能耐受50％ (V/V) 的甲醇等有机助溶剂,Ca2+ (1 mmol/L) 和EDTA (5 mmol/L) 对其酶活有一定的促进作用。上述结果表明,重组PFD是一个新型的短链脱氢酶,其代谢角色推测与卤代次级醇的氧化降解有关。     

果糖和麦芽糖作为有氧碳源对大肠杆菌NZN111两阶段发酵中厌氧发酵的影响

为了了解磷酸转移酶转运系统 (PTS) 依赖和非PTS依赖代谢的糖类对大肠杆菌生产琥珀酸的影响,进行了两阶段培养,有氧阶段采用PTS依赖型的果糖或非PTS依赖型的麦芽糖作为丙酮酸甲酸裂解酶 (PFL) 和乳酸脱氢酶 (LDH) 双突变株NZN111的碳源,研究其对NZN111厌氧阶段代谢葡萄糖的影响。5 L罐发酵结果表明,以果糖和麦芽糖为碳源有氧培养的细胞恢复了在厌氧条件下快速代谢葡萄糖的能力,琥珀酸和丙酮酸成为主要代谢产物,最终琥珀酸得率分别为0.84和0.75 mol/mol,丙酮酸得率分别达到了0.65和0.83 mol/mol,琥珀酸和丙酮酸终浓度比分别为1.73∶1和1.21∶1。果糖和麦芽糖培养的NZN111与葡萄糖培养的菌体代谢的明显差异推测是cyclic AMP (cAMP) 依赖型和非cAMP依赖型的分解代谢物阻遏调控这两种机制共同作用的结果。     

产丁二酸工程菌的构建及其厌氧发酵

为了考察过量表达苹果酸酶对于E.coli NZN111(ldhA::Kan pfl::Cam)厌氧发酵产丁二酸的影响, 将连接有苹果酸酶基因sfcA的表达载体pTrc99a-sfcA转化进NZN111中, 构建了重组NZN111(pTrc99a-sfcA)。0.5 mmol/L IPTG诱导8 h后, 测定的苹果酸酶比酶活为30.67 u/mg, 比受体菌提高了140倍。采用两阶段发酵模式, 结果表明: 过量表达的苹果酸酶在NZN111体内催化了从丙酮酸到苹果酸的逆向反应, 丁二酸是发酵过程中积累的主要有机酸, 且当加入0.7 mmol/L IPTG诱导, 初始葡萄糖糖浓度为18.5 g/L时, 选择对数生长期后期的菌种以10%的接种量转入厌氧发酵, 发酵结束时发酵液中丁二酸的浓度为12.84 g/L, 对葡萄糖的收率为69.43%, 乙酸为0.58 g/L, 二者浓度比为22:1, 没有检测到甲酸和乳酸。构建的菌种具有高产丁二酸和副产物极少的优点, 在同类菌种中处于先进水平。     

芽胞杆菌(Bacillus sp.)YX-1耐有机溶剂葡萄糖脱氢酶的基因克隆与酶学性质

[目的] 从芽胞杆菌(Bacillus sp.)YX-1基因组中克隆出一种有机溶剂耐受型的葡萄糖脱氢酶基因,实现了该基因在大肠杆菌中的高效表达,研究了重组蛋白的酶学性质.[方法] 依据芽胞杆菌属中葡萄糖脱氢酶氨基酸序列的保守性,设计合理引物,钓取来源于Bacillus sp.YX-1的葡萄糖脱氢酶基因,构建诱导型表达载体pET28a-gdh,于大肠杆菌中进行表达.镍柱亲和层析法纯化重组蛋白,考察了重组蛋白的酶学性质.[结果] 葡萄糖脱氢酶基因全长为786 bp,编码261个氨基酸.酶学研究结果表明:该酶最适反应温度为45℃,最适pH值为8.0;具有良好的有机溶剂耐受性,于50％的辛烷、环己烷、癸烷中室温放置1h后,酶活仍能保持90％以上;具有较宽的底物谱,对多种糖均具有一定的催化活性,其中催化D-葡萄糖的活力最高,产生还原型辅酶因子;对辅酶NADH和NADPH具有相似的依赖性,对NAD+和NADP+的催化比活分别为8.37 U/mg和8.62 U/mg.[结论]利用生物信息学成功地挖掘出Bacillus sp.YX-1一种耐有机溶剂的葡萄糖脱氢酶,为氧化还原酶在有机相反应中的的辅酶再生循环提供了新型的生物催化剂.     

日本血吸虫苹果酸脱氢酶的研究

本文报告了日本血吸虫存在苹果酸脱氢酶与延胡索酸酶。在采用的实验条件下(苹果酸钠,0.02M;细胞色素c,1×10~(-5)M;磷酸盐缓冲液,0.01M,pH 7.4)测定了血吸虫匀浆的酶活力。合抱成虫的酶活力为:氧耗量Q_o(?)=4.5微升氧/毫克氮量/小时;草酰乙酸产生量(以丙酮酸测定值表示)Q_p=O.26微克分子丙酮酸/毫克氮量/小时;延胡索酸产生量Q_F=2.5微克分子延胡索酸/毫克氮量/小时。当雌雄虫分别测定时,在等氮量基础上,雌虫酶活力较雄虫者为高。当苹果酸钠用作底物时,合抱成虫的氧耗量可因加入谷氨酸钠及NAD而增高110%。于此同时,用纸层析法证明血吸虫之苹果酸脱氢酶可与谷-草转氨酶相互联系而产生天门冬氨酸。加入NAD可使合抱成虫的氧耗量增高30%,同时发现有相当量乳酸产生(Q_L=0.44微克分子乳酸/毫克氮量/小时)。以上结果表明在血吸虫匀浆存在苹果酸脱氢酶与乳酸脱氢酶的交互作用。此外,研究了虫苹果酸脱氢酶的可逆作用。借助于虫自身的乳酸脱氢酶使加入的NAD还原为NADH,然后此NADH又可将底物草酰乙酸还原。在以上情况下,用纸层析法鉴定其产物为苹果酸及延胡索酸。二巯基丁二酸锑钠(Sb-58)在最后浓度为10~(-3)M及10~(-4)M时,分别抑制血吸虫苹果酸脱氢酶活力约65%及30%。甲状腺素及中酒石酸对该酶均呈抑制作用。酒石酸锑钾在10~(-3)M时对酶活力无显著影响。     

Increased production of succinic acid in Escherichia coli by overexpression of malate dehydrogenase

Escherichia coli NZN111 is a double mutant with inactivated lactate dehydrogenase and pyruvate formate-lyase. It cannot utilize glucose anaerobically because of its unusually high intracellular NADH/NAD(+) ratio. We have now constructed a recombinant strain, E. coli NZN111/pTrc99a-mdh, which, during anaerobic fermentation, produced 4.3 g succinic acid l(-1) from 13.5 g glucose l(-1). The NADH/NAD(+) ratio decreased from 0.64 to 0.26. Furthermore, dual-phase fermentation (aerobic growth followed by anaerobic phase) resulted in enhanced succinic acid production and reduced byproduct formation. The yield of succinic acid from glucose during the anaerobic phase was 0.72 g g(-1), and the productivity was 1.01 g l(-1) h(-1).     

Regulation of NAD(H) pool and NADH/NAD(+) ratio by overexpression of nicotinic acid phosphoribosyltransferase for succinic acid production in Escherichia coli NZN111

Succinic acid is not the dominant fermentation product from glucose in wild-type Escherichia coli W1485. To reduce byproduct formation and increase succinic acid accumulation, pyruvate formate-lyase and lactate dehydrogenase, encoded by pflB and ldhA genes, were inactivated. However, E. coli NZN111, the ldhA and pflB deletion strain, could not utilize glucose anaerobically due to the block of NAD(+) regeneration. To restore glucose utilization, overexpression of nicotinic acid phosphoribosyltransferase, a rate limiting enzyme of NAD(H) synthesis encoded by the pncB gene, resulted in a significant increase in cell mass and succinic acid production. Furthermore, the results indicated a significant increase in NAD(H) pool size, and decrease in the NADH/NAD(+) ratio from 0.64 to 0.13, in particular, the concentration of NAD(+) increased 6.2-fold during anaerobic fermentation. In other words, the supply of enough NAD(+) for NADH oxidation by regulation of NAD(H) salvage synthesis mechanism could improve the cell growth and glucose utilization anaerobically. In addition, the low NADH/NAD(+) ratio also change the metabolite distribution during the dual-phase fermentation. As a result, there was a significant increase in succinic acid production, and it is provided further evidence that regulation of NAD(H) pool and NADH/NAD(+) ratio was very important for succinic acid production.     

Metabolic flux analysis for succinic acid production by recombinant Escherichia coli with amplified malic enzyme activity

A pfl ldhA double mutant Escherichia coli strain NZN111 was used to produce succinic acid by overexpressing the E. coli malic enzyme. Escherichia coli strain NZN111 harboring pTrcML produced 6 and 8 g/L of succinic acid from 20 g/L of glucose in flask culture at 37 degrees C and 30 degrees C, respectively. When NZN111(pTrcML) was cultured at 30 degrees C with intermittent glucose feeding the final succinic acid concentration obtained was 9.5 g/L and the ratio of succinic acid to acetic acid was 13:1. This system could not be analyzed by conventional metabolic flux analysis techniques, since some pyruvate and succinic acid were accumulated intracellularly. Therefore, a new flux analysis method was proposed by introducing intracellular pyruvate and succinic acid pools. By this new method the concentrations of intracellular metabolites were successfully predicted and the differences between the measured and calculated reaction rates could be considerably reduced.     

重组大肠杆菌利用蔗糖及糖蜜发酵生产丁二酸

富含蔗糖的甘蔗糖蜜可作为制备丁二酸的廉价原料。然而生产丁二酸的潜力菌株大肠杆菌Escherichia coli AFP111不能代谢蔗糖。为了使其具有蔗糖代谢能力,将E.coli W中非PTS蔗糖利用系统蔗糖通透酶的编码基因csc B,果糖激酶的编码基因csc K和蔗糖水解酶的编码基因csc A克隆并表达到AFP111中,获得重组菌株AFP111/p MD19T-csc BKA。经厌氧发酵验证,重组菌株72 h消耗20 g/L蔗糖,丁二酸产量达到12 g/L。在3L发酵罐中采用有氧阶段培养菌体、厌氧阶段发酵的两阶段发酵方式,厌氧发酵30 h,重组菌株以蔗糖和糖蜜为碳源丁二酸产量分别为34 g/L和30 g/L。结果表明,通过外源引入非PTS蔗糖利用系统,重组菌株具有较强的代谢蔗糖生长及合成丁二酸的能力,并且能够利用廉价糖蜜发酵制备丁二酸。     

Improved Succinic Acid Production in the Anaerobic Culture of an Escherichia coli pflB ldhA Double Mutant as a Result of Enhanced Anaplerotic Activities in the Preceding Aerobic Culture

Escherichia coli NZN111 is a pflB ldhA double mutant which loses its ability to ferment glucose anaerobically due to redox imbalance. In this study, two-stage culture of NZN111 was carried out for succinic acid production. It was found that when NZN111 was aerobically cultured on acetate, it regained the ability to ferment glucose with succinic acid as the major product in subsequent anaerobic culture. In two-stage culture carried out in flasks, succinic acid was produced at a level of 11.26 g/liter from 13.4 g/liter of glucose with a succinic acid yield of 1.28 mol/mol glucose and a productivity of 1.13 g/liter·h in the anaerobic stage. Analyses of key enzyme activities revealed that the activities of isocitrate lyase, malate dehydrogenase, malic enzyme, and phosphoenolpyruvate (PEP) carboxykinase were greatly enhanced while those of pyruvate kinase and PEP carboxylase were reduced in the acetate-grown cells. The two-stage culture was also performed in a 5-liter fermentor without separating the acetate-grown NZN111 cells from spent medium. The overall yield and concentration of succinic acid reached 1.13 mol/mol glucose and 28.2 g/liter, respectively, but the productivity of succinic acid in the anaerobic stage dropped to 0.7 g/liter·h due to cell autolysis and reduced anaplerotic activities. The results indicate the great potential to take advantage of cellular regulation mechanisms for improvement of succinic acid production by a metabolically engineered E. coli strain.