好氧发酵生产琥珀酸工程菌株的构建

通过分析大肠杆菌的碳源代谢途径, 利用基因敲除手段, 以Escherichia coli MG1655为出发菌株, 成功构建了琥珀酸好氧发酵生产工程菌E. coli QZ1111 (MG1655?ptsG?poxB?pta?iclR?sdhA)。检测结果表明该菌株能以葡萄糖为碳源, 在好氧发酵且不表达任何异源基因的条件下大量积累琥珀酸。摇瓶试验证明, 琥珀酸发酵产量达到26.4 g/L, 乙酸盐作为唯一检测到的副产物产量为2.3 g/L。二者浓度比达到11.5:1。     

大肠杆菌利用木糖发酵产琥珀酸的研究

目的:研究大肠杆菌以木糖为碳源发酵产琥珀酸。方法:首先比较了实验室保藏的7种野生型大肠杆菌利用木糖发酵产琥珀酸的产量和得率,结果:表明野生型菌株琥珀酸对木糖的得率集中在0.34g/g~0.53g/g之间,得率较低,副产物主要为乳酸、乙酸。然后选取其中2株菌(E.coli MG1655与E.coli C-1)进行基因敲除,构建了ldhA和pflB双基因缺失的MLB和CLB菌株,以减少副产物的积累。两阶段摇瓶发酵结果表明,琥珀酸得率从0.40g/g分别提高到了0.89g/g及0.90g/g,而产量分别从4.92g/L、5.58g/L提高到11.52g/L、11.81g/L。结论:通过基因敲除后,大肠杆菌能够利用木糖发酵产琥珀酸,琥珀酸得率可以达到0.90g/g。     

过量表达烟酸单核苷酸腺苷酰转移酶对大肠杆菌NZN111产丁二酸的影响

大肠杆菌NZN111是敲除了乳酸脱氢酶的编码基因(ldhA)和丙酮酸-甲酸裂解酶的编码基因(pflB)的发酵生产丁二酸的潜力菌株。厌氧条件下NADH不能及时再生为NAD+,引起胞内辅酶NAD(H)的不平衡,最终导致厌氧条件下菌株不能利用葡萄糖生长代谢。nadD为催化NAD(H)合成途径中烟酸单核苷酸(NaMN)生成烟酸腺嘌呤二核苷酸(NaAD)的烟酸单核苷酸腺苷酰转移酶(Nicotinic acid mononucleotide adenylyltransferase,NAMNAT)的编码基因,通过过量表达nadD基因能够提高NAD(H)总量与维持合适的NADH/NAD+比例。文中构建了重组菌E.coli NZN111/pTrc99a-nadD,在厌氧摇瓶发酵过程中通过添加终浓度为1.0 mmol/L的IPTG诱导表达,重组菌E.coli NZN111/pTrc99a-nadD中NAD+和NADH的浓度分别比宿主菌E.coli NZN111提高了3.21倍和1.67倍,NAD(H)总量提高了2.63倍,NADH/NAD+从0.64降低为0.41,使重组菌株恢复了厌氧条件下生长和代谢葡萄糖的能力。重组菌与对照菌相比,72 h内可以消耗14.0 g/L的葡萄糖产6.23 g/L的丁二酸,丁二酸产量增加了19倍。     

乙酸合成途径阻断及NADH氧化酶表达对于谷氨酸棒杆菌生产乙偶姻的影响

【目的】研究乙酸合成途径阻断及NADH氧化酶表达对于谷氨酸棒杆菌生产乙偶姻的影响。【方法】在谷氨酸棒杆菌CGF2中异源表达als SD操纵子构建乙偶姻生产菌株CGT1,考察敲除乙酸生成途径cat和pqo对乙偶姻的影响。然后引入短乳杆菌的NADH氧化酶,在优化的溶氧条件下研究其对乙偶姻产量的影响。【结果】CGT1在摇瓶发酵中可积累6.27 g/L乙偶姻,敲除cat使乙偶姻产量显著提高30.94%,达到8.21 g/L;双敲除cat和pqo没有进一步提高产量。通过优化发酵的溶氧水平,乙偶姻产量达到10.06 g/L。在高溶氧水平下引入NADH氧化酶导致菌株的生长和糖代谢速率提高,但乙偶姻产量略有降低。在分批补料发酵中,重组菌株乙偶姻产量达到40.51 g/L,产率为0.51 g/(L?h)。【结论】在谷氨酸棒杆菌中阻断乙酸合成途径cat能够有效提高乙偶姻产量,NADH氧化酶在高溶氧水平下表达不利于乙偶姻的合成,需要进一步调节表达水平以确定其效果。     

进化代谢选育高渗透压耐受型产琥珀酸大肠杆菌

在以碳酸钠为酸中和剂的大肠杆菌两阶段发酵产琥珀酸的过程中,由于Na+的积累造成发酵体系中渗透压的提高,严重抑制了琥珀酸的产物浓度。为了增强大肠杆菌对渗透压的耐受性,考察了利用进化代谢方法筛选高渗透压耐受型高产琥珀酸大肠杆菌菌株的可行性。进化代谢系统作为一种菌株突变装置,可以使菌体在连续培养条件下以最大的生长速率生长。以NaCl为渗透压调节剂,通过在连续培养装置中逐步提高NaCl浓度使菌体在高渗透压条件下快速生长,最终得到了一株高渗透压耐受型琥珀酸生产菌株Escherichia coli XB4。以碳酸钠为酸中和剂,在7 L发酵罐中利用Escherichia coli XB4进行两阶段发酵,厌氧培养60 h后,琥珀酸产量达到了69.5 g/L,琥珀酸生产速率达到了1.81 g/(L.h),分别比出发菌株提高了18.6%和20%。     

琥珀酸发酵高产菌株的选育

以富马酸钠为唯一碳源的选择性平板,从牛的瘤胃中筛选出一株产琥珀酸的菌株Actinobacillus succinogenes CGMCC1593。以该菌株为出发菌株进行NTG诱变,挑选在含有50~100 mmol/L氟乙酸平板生长较快的菌落,经过初筛和复筛,发现SF-9菌株产琥珀酸能力强且积累的乙酸较少。以50 g/L的葡萄糖为碳源,在培养瓶厌氧发酵条件下其琥珀酸产量(35.09 g/L)比出发菌株(28.91 g/L)提高了21.4%,琥珀酸/乙酸比率(w/w)从3.3∶1提高到7.5∶1。用SF-9菌株在5 L发酵罐上进行分批发酵,发酵36 h时琥珀酸积累量达到40.51 g/L,对葡萄糖的转化率为0.81(w/w),琥珀酸/乙酸比率为9∶1,副产物乙酸量比出发菌株降低了约50%。     

产L-苹果酸重组大肠杆菌的构建

基于产琥珀酸重组大肠杆菌E.coli B0013-1050的琥珀酸合成途径,利用Red同源重组技术结合Xer/dif重组系统敲除富马酸酶基因fumB、fumC,苹果酸酶基因maeB,构建L-苹果酸合成途径,最终得到重组大肠杆菌E.coli2030,该菌株在15 L发酵罐中,产L-苹果酸12.5 g/L,葡萄糖-苹果酸转化率为52.1%,同时对发酵产物中主要杂酸丙酮酸和琥珀酸的生产原因进行了初步的探讨与分析。为进一步提高L-苹果酸的转化率,整合表达来源于黄曲霉的苹果酸脱氢酶基因,构建重组菌E.coli 2040,在15 L发酵罐中产L-苹果酸14 g/L,葡萄糖-苹果酸转化率提高到60.3%。     

产琥珀酸工程菌株的发酵工艺条件优化

对实验室构建的产琥珀酸大肠杆菌工程菌株(E.coliQZ1111)进行发酵工艺条件研究。以AM1低盐培养基为基础,研究不同C、N源及其质量浓度,培养基初始pH和发酵温度等因素对琥珀酸的影响,并在5L发酵罐中进行了补料-分批发酵实验。优化后的发酵条件为葡萄糖20g/L,玉米浆10g/L,pH6.4,发酵温度37℃。在5L发酵罐中培养,琥珀酸产量达到47.9g/L。     

过表达carAB和pyrBI对大肠杆菌发酵胞苷的影响

为了考察氨甲酰磷酸合成酶和天冬氨酸氨甲酰转移酶对大肠杆菌发酵生产胞苷的影响,以E. coli A39 (△cdd)基因组为模板克隆carAB和pyrBI并与载体pSTV28连接构建出重组质粒pSTV28-carAB和pSTV28-pyrBI,将这两个重组质粒分别转入出发菌株A39 (△cdd)后,通过摇瓶发酵研究重组质粒对菌体的生长、胞苷和尿苷产量及副产物乙酸积累的影响。结果显示,工程菌E. coli A39-AB和A39-BI的胞苷产量分别为583.5 mg/L、408.4 mg/L,与出发菌株相比,分别提高了85.3%、29.7%。这说明过表达操纵子基因carAB和pyrBI均可促进胞苷的积累。     

常压室温等离子体诱变高效利用木糖产丁二酸菌株

大肠杆菌Escherichia coli AFP111是E. coli NZN111 (△pflAB△ldhA) 的ptsG自发突变株,其转化1 mol的木糖合成丁二酸的过程中净产生1.67 mol ATP,但是转化1 mol的木糖合成丁二酸的过程中实际需要2.67 mol ATP,因此在厌氧条件下,ATP的供给不足导致E. coli AFP111不能代谢木糖。采用常压室温等离子体射流诱变产丁二酸大肠杆菌菌株,在厌氧条件下,利用以木糖为碳源的M9培养基,筛选得到一株可以代谢木糖并积累丁二酸的突变株DC111。该突变菌株在发酵培养基中,72 h内可以消耗10.52 g/L木糖产6.46 g/L的丁二酸,丁二酸的得率达到了0.78 mol/mol。而且突变株中伴有ATP产生的磷酸烯醇式丙酮酸羧激酶 (PCK) 途径得到加强,PCK的比酶活相对于出发菌株提高了19.33倍,使得其在厌氧条件下能够有足够的ATP供给来代谢木糖发酵产丁二酸。     

代谢工程改造大肠杆菌合成己二酸

己二酸是一种具有重要应用价值的二元羧酸,是合成尼龙-66的关键前体。目前,生物法生产己二酸存在生产周期长、生产效率低的问题。本研究选择一株野生型高产琥珀酸菌株大肠杆菌(Escherichia coli) FMME N-2为底盘细胞,首先通过引入逆己二酸降解途径的关键酶,成功构建了可合成0.34 g/L己二酸的E. coli JL00菌株;接着,对合成路径限速酶进行表达优化,使E. coli JL01菌株在摇瓶发酵条件下产量达到0.87 g/L;随后,通过敲除sucD基因、过表达acs基因和突变lpd基因的组合策略平衡己二酸合成前体的供应,优化菌株E. coli JL12己二酸产量进一步提升至1.51 g/L;最后,在5 L发酵罐上对己二酸发酵工艺进行优化。工程菌株经72 h分批补料发酵,己二酸的产量达到22.3 g/L,转化率为0.25 g/g,生产强度为0.31 g/(L·h),具备了一定的应用潜力。本研究可为包括己二酸在内的多种二元羧酸细胞工厂的构建提供理论依据和技术基础。     

Performance and mechanism analysis of succinate production under different transporters in <Emphasis Type="Italic">Escherichia coli</Emphasis>

Succinic acid is a platform chemical with potential for bio-based synthesis. However, the production of bio-based succinate is limited because of insufficient succinate efflux capacity in the late stage of fermentation. In the present study, three different transporters, which have been reported to be responsible for C₄-dicarboxylates transport, were employed for investigation of the transport capacity of succinate in Escherichia coli. After engineered strains were constructed, the fermentative production of succinic acid was studied in serum bottles and 3 L of fermentor. The results demonstrated that engineered strain showed better efflux capacity than control strain under high concentration of succinate. The highest production of succinate was 68.66 g/L, while the NCgl2130 transporter may be the best candidate for succinate export in E. coli. Further research showed that the expression levels and relative enzyme activities involved in the metabolic pathway all increased markedly, and the maximum activities of PPC, PCK, PYK, and MDH increased by 1.50, 1.38, 1.28, and 1.27-fold in recombinant E. coli AFP111/pTrc99a-NCgl2130, respectively. Moreover, the maximum level of intracellular ATP increased by 23.79% in E. coli AFP111/pTrc99a-NCgl2130. Taken together, these findings indicated that engineered transporters can improve succinate production by increasing key enzyme activities and intracellular ATP levels. To the best of thew authors’ knowledge, this is the first report on a mechanism to improve succinate production by engineered transporters. This strategy set up a foundation for improving the biosynthesis of other C₄-dicarboxylates, such as fumaric acid and malic acid.     

模块化工程改造大肠杆菌生产L-色氨酸

L-色氨酸作为一种必需氨基酸,广泛应用于食品、饲料和医药等领域。目前,微生物法生产L-色氨酸存在转化率低等问题。为此,本研究通过敲除L-色氨酸操纵子阻遏蛋白(L-tryptophan operon repressor protein, trpR)、替换l-色氨酸弱化子(trpL)、引入抗反馈调节的aroG^fbr等,获得可积累11.80 g/L L-色氨酸的底盘菌株大肠杆菌(Escherichia coli)TRP3。在此基础上,将L-色氨酸合成途径分为中心代谢途径模块、莽草酸(shikimic acid, SA)途径至分支酸(chorismic acid, CHA)模块、分支酸至L-色氨酸模块,并借助启动子工程,通过平衡中心代谢途径模块、莽草酸途径至分支酸模块、分支酸至L-色氨酸模块,获得工程菌E.coli TRP9。在5 L发酵罐中,工程菌E.coli TRP9的L-色氨酸产量提升至36.08 g/L,糖酸转化率提升至18.55%,达到理论转化率的81.7%。本研究利用模块工程策略,构建了高产L-色氨酸生产菌株,为l-色氨酸的规模化生产奠定了良好的基础。     

群体感应动态调控促进大肠杆菌合成酪醇

酪醇是一种多酚类天然产物,广泛应用于化工、医药和食品等领域。目前大肠杆菌(Escherichia coli)从头合成酪醇存在发酵菌体密度低和产量低等问题。为此,本研究将前期获得苯丙酮酸脱羧酶突变体ARO10F138L/D218G与不同来源的醇脱氢酶融合表达,最优组合ARO10F138L/D218G-L-YahK酪醇产量达到1.09 g/L。为进一步提高酪醇产量,敲除了4-羟基苯乙酸竞争途径关键基因feaB,使酪醇产量提高了21.15%,达到1.26g/L。针对酪醇发酵菌体密度低的问题,通过群体感应系统动态调控酪醇合成途径,减轻酪醇对底盘细胞的毒性作用,缓解生长抑制,使其产量提高了33.82%,达到1.74 g/L。在2 L发酵罐中,群体感应动态调控工程菌TRFQ5的酪醇产量达到4.22g/L,OD600值达到42.88,分别较静态诱导表达工程菌TRF5提高了38.58%和43.62%。本研究应用基因敲除技术,阻断了酪醇合成竞争途径;同时结合群体感应动态调控策略,减轻了酪醇毒性对底盘细胞的生长抑制,从而有效地提高了酪醇产量。本研究对其他高毒性化学品的生物合成具有良好的借鉴和应用价值。     

Pathway engineering of Escherichia coli for α-ketoglutaric acid production

α-Ketoglutaric acid (α-KG) is a multifunctional dicarboxylic acid in the tricarboxylic acid (TCA) cycle, but microbial engineering for α-KG production is not economically efficient, due to the intrinsic inefficiency of its biosynthetic pathway. In this study, pathway engineering was used to improve pathway efficiency for α-KG production in Escherichia coli. First, the TCA cycle was rewired for α-KG production starting from pyruvate, and the engineered strain E. coli W3110Δ4-PCAI produced 15.66 g/L α-KG. Then, the rewired TCA cycle was optimized by designing various strengths of pyruvate carboxylase and isocitrate dehydrogenase expression cassettes, resulting in a large increase in α-KG production (24.66 g/L). Furthermore, acetyl coenzyme A (acetyl-CoA) availability was improved by overexpressing acetyl-CoA synthetase, leading to α-KG production up to 28.54 g/L. Finally, the engineered strain E. coli W3110Δ4-P_(H)CAI_(H)A was able to produce 32.20 g/L α-KG in a 5-L fed-batch bioreactor. This strategy described here paves the way to the development of an efficient pathway for microbial production of α-KG.     

Metabolic Engineering of Escherichia coli for the Production of Xylonate

Xylonate is a valuable chemical for versatile applications. Although the chemical synthesis route and microbial conversion pathway were established decades ago, no commercial production of xylonate has been obtained so far. In this study, the industrially important microorganism Escherichia coli was engineered to produce xylonate from xylose. Through the coexpression of a xylose dehydrogenase (xdh) and a xylonolactonase (xylC) from Caulobacter crescentus, the recombinant strain could convert 1 g/L xylose to 0.84 g/L xylonate and 0.10 g/L xylonolactone after being induced for 12 h. Furthermore, the competitive pathway for xylose catabolism in E. coli was blocked by disrupting two genes (xylA and xylB) encoding xylose isomerase and xylulose kinase. Under fed-batch conditions, the finally engineered strain produced up to 27.3 g/L xylonate and 1.7 g/L xylonolactone from 30 g/L xylose, about 88% of the theoretical yield. These results suggest that the engineered E. coli strain has a promising perspective for large-scale production of xylonate.     

代谢工程改造大肠杆菌合成丙二酸

丙二酸是一种重要的有机二元羧酸,其应用价值遍及化工、医药、食品等领域。本文以大肠杆菌为底盘细胞,过表达了ppc、aspC、panD、pa0132、yneI和pyc基因,成功构建了丙二酸合成重组菌株大肠杆菌BL21(TPP)。该菌株在摇瓶发酵条件下,丙二酸产量达到0.61 g/L。在5 L发酵罐水平,采用间歇补料的方式丙二酸的积累量达3.32 g/L。本研究应用了融合蛋白技术,将ppc和aspC、pa0132和yneI分别进行融合表达,构建了工程菌BL21(SCR)。在摇瓶发酵水平,该菌株丙二酸的积累量达到了0.83 g/L,较出发菌株BL21(TPP)提高了36%。在5 L发酵罐中,工程菌BL21(SCR)的丙二酸产量最高达5.61 g/L,较出发菌株BL21(TPP)提高了69%。本研究实现了丙二酸在大肠杆菌中的生物合成,为构建丙二酸合成的细胞工厂提供了理论依据和技术基础,同时也对其他二元羧酸的生物合成具有启发和指导意义。     

Production of succinate by a <Emphasis Type="Italic">pfl</Emphasis>B <Emphasis Type="Italic">ldh</Emphasis>A double mutant of <Emphasis Type="Italic">Escherichia coli</Emphasis> overexpressing malate dehydrogenase

The gene encoding malate dehydrogenase (MDH) was overexpressed in a pflB ldhA double mutant of Escherichia coli, NZN111, for succinic acid production. With MDH overexpression, NZN111/pTrc99A-mdh restored the ability to metabolize glucose anaerobically and 0.55 g/L of succinic acid was produced from 3 g/L of glucose in shake flask culture. When supplied with 10 g/L of sodium bicarbonate (NaHCO₃), the succinic acid yield of NZN111/pTrc99A-mdh reached 1.14 mol/mol glucose. Supply of NaHCO₃ also improved succinic acid production by the control strain, NZN111/pTrc99A. Measurement of key enzymes activities revealed that phosphoenolpyruvate (PEP) carboxykinase and PEP carboxylase in addition to MDH played important roles. Two-stage culture of NZN111/pTrc99A-mdh was carried out in a 5-L bioreactor and 12.2 g/L of succinic acid were produced from 15.6 g/L of glucose. Fed-batch culture was also performed, and the succinic acid concentration reached 31.9 g/L with a yield of 1.19 mol/mol glucose.     

Enhanced production of succinic acid by Actinobacillus succinogenes with reductive carbon source

Carbon sources with different oxidation states were used to investigate the possibility increasing the availability of NADH and the NADH/NAD⁺ ratio and to determine the effect of this manipulation on the distribution of metabolites in Actinobacillus succinogenes NJ113. The sugars glucose, sorbitol and gluconate were each used at an initial concentration of 40 g/L.The yield of succinic acid (0.75) and the ratio of succinic acid to acetic acid (5.06) were both higher for sorbitol than the values obtained with glucose (0.66 and 2.68, respectively). In contrast, with gluconate as the carbon source the yield of succinic acid was 0.54 and the ratio of succinic acid to acetic acid was only 1.70. This work showed that different levels of NADH availability and the NADH/NAD⁺ ratio can be achieved by using carbon sources that have different oxidation states.Highly reduced sorbitol was examined as a possible carbon substrate for maximizing the redox potential during the production of succinic acid.     

Engineering Escherichia coli for the synthesis of short- and medium-chain α,β-unsaturated carboxylic acids

Concerns over sustained availability of fossil resources along with environmental impact of their use have stimulated the development of alternative methods for fuel and chemical production from renewable resources. In this work, we present a new approach to produce α,β-unsaturated carboxylic acids (α,β-UCAs) using an engineered reversal of the β-oxidation (r-BOX) cycle. To increase the availability of both acyl-CoAs and enoyl-CoAs for α,β-UCA production, we use an engineered Escherichia coli strain devoid of mixed-acid fermentation pathways and known thioesterases. Core genes for r-BOX such as thiolase, hydroxyacyl-CoA dehydrogenase, enoyl-CoA hydratase, and enoyl-CoA reductase were chromosomally overexpressed under the control of a cumate inducible phage promoter. Native E. coli thioesterase YdiI was used as the cycle-terminating enzyme, as it was found to have not only the ability to convert trans-enoyl-CoAs to the corresponding α,β-UCAs, but also a very low catalytic efficiency on acetyl-CoA, the primer and extender unit for the r-BOX pathway. Coupling of r-BOX with YdiI led to crotonic acid production at titers reaching 1.5 g/L in flask cultures and 3.2 g/L in a controlled bioreactor. The engineered r-BOX pathway was also used to achieve for the first time the production of 2-hexenoic acid, 2-octenoic acid, and 2-decenoic acid at a final titer of 0.2 g/L. The superior nature of the engineered pathway was further validated through the use of in silico metabolic flux analysis, which showed the ability of r-BOX to support growth-coupled production of α,β-UCAs with a higher ATP efficiency than the widely used fatty acid biosynthesis pathway. Taken together, our findings suggest that r-BOX could be an ideal platform to implement the biological production of α,β-UCAs.