DN2菌降解烟碱的动力学及其应用研究

研究了菌株DN2降解烟碱的特性和对烟草废弃物中烟碱的降解情况。结果表明,该菌降解烟碱的最适条件为接种量为5 %,温度30 ℃,初始pH值为6.5。在该条件下,对初始烟碱浓度为500 mg/L的降解过程进行考察。结果表明,未经烟碱诱导的降解曲线呈倒S曲线,半衰期为17.43 h;经烟碱诱导的降解曲线符合Eckenfelder动力学模型,半衰期为4.10 h。添加0.1 %(质量分数)葡萄糖,可提高菌株DN2的烟碱耐受浓度,达5000 mg/L。菌株DN2能够降解烟草废弃物水提液中的烟碱（烟碱含量约为2220 mg/L）,60 h时烟碱的降解率为95.22 %,表明该菌在治理烟碱污染环境方面具有应用价值。     

链霉菌对烟草中烟碱与绿原酸的降解作用研究

为了研究对烟草中烟碱与绿原酸的快速生物降解,筛选了能有效降解烟草中烟碱与绿原酸的链霉菌Z6菌株与Z8菌株,考察了Z6和Z8菌株在不同培养基上的培养特征,探讨了所选菌株对烟碱与绿原酸的降解特性。实验结果表明,Z8链霉菌在烟草固体培养基中培养48h后,对培养基中烟碱的降解率达到83.9%;培养72h后,对烟碱的降解率可达到93.7%,此时烟草中的烟碱含量降低到0.38mg/g,达到了欧盟条例的无害化标准。Z6菌对绿原酸的降解程度较高,培养48h后,对绿原酸的降解率为57.1%;培养72h后,降解率可达到67.5%.     

烟碱降解细菌的分离、鉴定及其降解性能的初步研究

从福建三明地区的土壤中分离得到一株能够高效降解烟碱的菌株 ,编号为DN2。该菌经常规的形态、生理生化分析以及 16SrDNA序列同源性分析 ,鉴定为Ochrobactrumintermedium ,属于α_变形杆细菌纲。该菌在 30℃～4 0℃和pH 6 . 0～ 9. 0范围内具有较高的降解活性 ,其最适值分别为 30℃和 6 5 ,烟碱的耐受浓度在无机盐培养基中可达到 4 0 0 0mg L。该菌能够以烟碱为唯一碳源生长 ,对于 5 0 0mg L烟碱的降解速率为 15mg L·h ,36h烟碱降解率为97. 6 5 %。该菌在烟草工业和环境保护上可能具有应用前景。     

两株芽胞菌对烟草废料烟碱与绿原酸降解的研究

为综合利用烟草废料,筛选得到能有效降解烟碱与绿原酸的两株芽胞菌,考察了所选菌株对烟碱与绿原酸的降解特性。实验结果表明,菌株Bacillus sp．X6表现出较高降解烟碱能力,培养36h可将含烟碱6．04mg／g烟草物料中的烟碱降解60．3％,72h降解率可达87．6％;对绿原酸降解效果最好的是菌株Bacillus sp．Xy,培养48h将含绿原酸10．57mg／g烟草物料中的绿原酸降解了50．5％,72h可将绿原酸降解62．2％,     

1株兼有烟碱降解活性解磷菌的分离鉴定

从烟草(Nicotiana tabacum L.)根际土壤中分离到1株兼有烟碱降解活性的解磷菌株,编号为YF24;菌株YF24经过48 h发酵后,培养基上清液中游离态磷含量达到141.6μg/m L,烟碱降解率达到77%,确定YF24具有解磷和烟碱降解的双重活性;对菌株YF24生长特性的研究表明,其最适生长温度是30~35℃,最适p H值范围是5.5~7.0,耐盐性差。通过形态特征观察、生理生化特性测定和16S r DNA序列分析,确定菌株YF24隶属于不动杆菌属Acinetobacter,暂命名为Acinetobacter sp.YF24。菌株YF24可作为烟草专用菌肥开发、诱变育种的良好出发菌株。     

一株高浓度烟碱降解菌的筛选、分离和初步鉴定

采用以烟碱为唯一碳源氮源的选择培养基,从烟草和植烟土壤中分离筛选出15株高浓度烟碱降解的菌株,其中菌株D9烟碱降解能力最强,其烟碱降解率为82%,耐受烟碱的最高浓度为8 g/L。经常规形态特征、16S rDNA同源序列以及系统进化树分析,初步鉴定该菌株为类似氧化微杆菌,命名为Microbacterium sp. GYC29。本研究为微生物降解烟碱的研究及应用提供了菌种资源。     

烟碱降解菌以烷烃为碳源产生物表面活性剂的研究

通过测定发酵过程中菌体浓度和发酵上清液的表面张力,研究了烷烃碳源和发酵条件对烟碱降解菌(Ochrobactrum sp.)产生物表面活性剂的影响。结果表明,菌株Ochrobactrum sp.以十三烷和十六烷为碳源生长较好,而利用液体石蜡可产生较多生物表面活性剂。以2%液体石蜡为碳源,装液量为40%(250 m L三角瓶),于30℃,120 r/min培养4 d时,发酵液表面张力能降低至42.1m N/m。     

蚯触圈源啶虫脒降解菌D35的分离鉴定及其降解条件优化

【背景】啶虫脒等新烟碱类杀虫剂的残留易对非靶标生物造成伤害,投加高效降解细菌进行生物强化,可促进其快速降解。【目的】从蚯触圈中分离筛选啶虫脒降解菌并优化其降解条件,提高降解效率。【方法】制备蚯触圈基质富集筛选降解菌;通过生理生化特征和16S rRNA基因序列分析对其进行鉴定;利用单因素筛选、Plackett-Burman试验、最陡爬坡试验及Box-Behnken design试验优化菌株降解条件。【结果】分离得到1株啶虫脒降解菌D35,可在72 h内降解55.46%初始浓度为50 mg/L的啶虫脒,将其鉴定为一株假单胞菌(Pseudomonas sp.)。优化得到菌株降解啶虫脒的最佳环境条件为：胰蛋白胨10.19 g/L、温度为30℃、接种量为5.24%,pH 7.0、初始农药浓度50 mg/L,在此条件下72 h内菌株降解率为80.21%,较未优化前提高了24.75%。【结论】本研究对分离筛选新烟碱类杀虫剂降解菌的方法进行了探索,获得的菌株D35可高效降解啶虫脒,为快速消除环境中啶虫脒污染提供了新的微生物资源。     

一株降烟碱细菌的筛选、鉴定及其降解特性研究

以烟碱为唯一碳源,从湖南张家界烟草种植地的土壤中分离得到一株降解烟碱能力较好的菌株。经常规形态观察和生理生化实验结果表明,该菌为放射形土壤杆菌或根癌土壤杆菌(Agrobacterium radiobacter／tumefaciens)。研究表明,该菌的降解烟碱最适pH和温度分别为7.0和30℃。该菌能够利用烟碱为唯一碳源,在含烟碱的培养基中发酵液呈淡黄色-绿色-墨绿色-深综色变化,培养48h后,烟碱的降解率可达71%,具有较好的烟草工业应用前景。     

烟碱降解菌的选育及改善上部烟叶品质研究

从烟叶叶面和植烟土壤中分离到降解烟碱的微生物18株,经初筛和复筛得到降解烟碱活性较高的微生物菌Nic22。对该菌株产酶培养条件进行优化研究,实验表明:Nic22降解烟碱效果受到多种因素的影响,添加适量的精制淀粉和(NH4)2SO4作为外加碳氮源可明显促进烟碱的降解,适宜的摇瓶培养温度、pH和时间分别为30℃、6.0~7.0和9h。采用Nic22菌株所产酶液对上部烟叶进行处理试验,卷烟评吸结果表明:上部烟叶经酶液处理可明显减轻杂气和刺激性,抽吸品质得到显著提高。     

Biodegradation of nicotine from tobacco waste extract by <Emphasis Type="Italic">Ochrobactrum intermedium</Emphasis> DN2

Ochrobactrum intermedium DN2 was used to degrade nicotine in tobacco waste extracts. The optimal temperature and pH of nicotine degradation by strain DN2 was 30–37 °C and 7.0, respectively. Under these optimal conditions, the average degradation rate of nicotine in a 30L fed-batch culture was 140.5 mg l⁻¹ h⁻¹. The results of this study indicate that strain DN2 may be useful for reducing the nicotine content of reconstituted tobacco.     

Optimization of a medium for enhancing nicotine biodegradation by Ochrobactrum intermedium DN2

AIMS: To optimize a medium for nicotine degradation by Ochrobactrum intermedium DN2 in presence of yeast extract, glucose and Tween 80 using response surface methodology (RSM). METHODS AND RESULTS: In this study, the effects of yeast extract, glucose and Tween 80 on nicotine degradation were investigated in flasks using a novel nicotine-degrading bacterium, O. intermedium DN2. A full factorial central composite design was applied in the design of experiments and in the analysis of the experimental data. The results showed that the most significant variable influencing nicotine degradation was yeast extract, followed by glucose, and then Tween 80. Moreover these three factors interacted with each other and combined to produce positive effects on nicotine degradation. The experimental data also allowed the development of an empirical model (P < 0.0001) describing the inter-relationship between independent and dependent variables. By solving the regression equation, the optimal values of the variables were determined as: yeast extracts 0.094%, glucose 0.101% and Tween 80 0.080%. Using the medium obtained, about 1,220 mg l(-1) of nicotine was degraded (95.55%) within 10 h at the specific biodegradation of 116.59 mg l(-1) h(-1) in 30-l bioreactor containing 25-l tobacco extract. CONCLUSIONS: An optimal medium of nicotine degradation by the strain DN2 was obtained. SIGNIFICANCE AND IMPACT OF THE STUDY: RSM proved to be reliable in developing the model, optimizing factors and analysing interaction effects. The results provide better understanding on the interactions between yeast extract, glucose and Tween 80 for nicotine biodegradation.     

废烟叶提取液源尼古丁降解菌分离鉴定和特性

【目的】目前造纸法再造烟叶工艺已经成为我国重要的废烟叶处理和利用方式,该工艺中尼古丁的调控是很重要的待解决问题。从废烟叶提取液(Tobacco waste extract,TWE)中筛选高耐受高活性降解尼古丁微生物用来直接处理烟梗或烟末提取液中的尼古丁,可实现对尼古丁指标的调控。【方法】以尼古丁为唯一碳氮源的基本培养基为筛选平板,从废烟叶提取液中筛选降解尼古丁菌株;对分离获得的菌株进行形态、生理生化和16S r RNA基因序列分析比对,鉴定其种属;获得的菌株分别在基本培养基和废烟叶提取液中考察其生长和尼古丁降解效果。【结果】从废烟叶提取液中获得了一株尼古丁降解活性和耐受力较好的降解菌株Pseudomonas sp.JY-Q,且在TWE中也有较强的降解能力。【结论】Pseudomonas sp.JY-Q可用于水体和TWE环境尼古丁的降解,但共存的葡萄糖对其有抑制作用,有待深入研究。     

Nicotine degradation enhancement by <Emphasis Type="Italic">Pseudomonas stutzeri</Emphasis> ZCJ during aging process of tobacco leaves

Nicotine is a key harmful component of tobacco and cigarettes, and the development of low-nicotine cigarettes is of increasing importance in the market. The objectives of this study are to isolate native nicotine-degrading strains and evaluate their feasibility for nicotine reduction during the aging (or fermentation) of tobacco leaves. A novel nicotine-degrading strain was isolated and identified as Pseudomonas stutzeri ZCJ based on its 16S rDNA sequence and morphological-biochemical characteristics. In submerged cultures, P. stutzeri ZCJ could tolerate 4.5 g/L nicotine and completely degrade 1.5 g/L nicotine within 24 h at 37°C and pH 7.4. The addition of glucose (1 g/L) could improve nicotine degradation by P. stutzeri ZCJ in submerged cultures. After submerged culturing, the cell suspension of P. stutzeri ZCJ could be utilized to improve nicotine reduction in tobacco leaves during solid-state fermentation. The nicotine content of tobacco leaves decreased by as much as 32.24% after 7 days of solid-state fermentation by P. stutzeri ZCJ, suggesting the industrial application potential of the native strain to enhance nicotine degradation during the aging of tobacco leaves.     

尼古丁降解菌SCUEC1菌株的分离及其降解基因

【目的】分离并鉴定1株具有尼古丁降解能力的细菌,研究其尼古丁降解特性并对其降解基因进行分析,为尼古丁微生物降解提供基础。【方法】从烟草种植地土壤中分离1株具有尼古丁降解能力的细菌,通过16S r RNA基因和生理生化特性对该菌株进行鉴定,检测该菌株尼古丁降解率与生长量的关系,并进一步对该菌株进行尼古丁浓度耐受性测定,采用高通量测序技术对菌株进行全基因组测序,BLAST比对分析尼古丁降解相关基因。【结果】筛选到1株具有尼古丁降解能力的细菌,经鉴定命名为根癌土壤杆菌(Agrobacterium tumerficience)SCUEC1菌株,根癌土壤杆菌SCUEC1菌株尼古丁降解率可达到94.81%,该菌株在尼古丁浓度为0.50–5.00 g/L范围内生长良好且有较高的尼古丁降解能力。对根癌土壤杆菌SCUEC1菌株全基因组序列进行BLAST比对分析,推测该菌株的尼古丁降解代谢途径与中间苍白杆菌SYJ1菌株的尼古丁降解途径相似。【结论】本研究揭示了Agrobacterium tumerficienceSCUEC1菌株具备尼古丁降解特性,初步推测出尼古丁降解相关基因和降解代谢途径,为尼古丁微生物降解提供基础。