Physiological studies of beta-galactosidase induction in Kluyveromyces lactis

We examined the kinetics of beta-galactosidase (EC 3.2.1.23) induction in the yeast Kluyveromyces lactis. Enzyme activity began to increase 10 to 15 min, about 1/10 of a cell generation, after the addition of inducer and continued to increase linearly for from 7 to 9 cell generations before reaching a maximum, some 125- to 150-fold above the basal level of uninduced cells. Thereafter, as long as logarithmic growth was maintained, enzyme levels remained high, but enzyme levels dropped to a value only 5- to 10-fold above the basal level if cells entered stationary phase. Enzyme induction required the constant presence of inducer, since removal of inducer caused a reduction in enzyme level. Three nongratuitous inducers of beta-galactosidase activity, lactose, galactose, and lactobionic acid, were identified. Several inducers of the lac operon of Escherichia coli, including methyl-, isopropyl- and phenyl-1-thio-beta-d-galactoside, and thioallolactose did not induce beta-galactosidase in K. lactis even though they entered the cell. The maximum rate of enzyme induction was only achieved with lactose concentrations of greater than 1 to 2 mM. The initial differential rate of beta-galactosidase appearance after induction was reduced in medium containing glucose, indicating transient carbon catabolite repression. However, glucose did not exclude lactose from K. lactis, it did not cause permanent carbon catabolite repression of beta-galactosidase synthesis, and it did not prevent lactose utilization. These three results are in direct contrast to those observed for lactose utilization in E. coli. Furthermore, these results, along with our observation that K. lactis grew slightly faster on lactose than on glucose, indicate that this organism has evolved an efficient system for utilizing lactose.     

Activation and regeneration of whole cell biocatalysts: initial and periodic induction behavior in starved Escherichia coli after immobilization in thin synthetic films

Activation and regeneration of whole cell biocatalytic activity via initial and subsequent induction of the lacZ gene was investigated in starved Escherichia coli using a novel synthetic biofilm. Stationary-phase bacteria were entrapped in 10-80 mum thick multi-layer films, where a copolymer of acrylic and vinyl acetate was the immobilization matrix. The E. coli were placed in a defined starvation medium containing essentially no nitrogen or carbon source and induced initially using lactose or isopropylthiogalactoside (IPTG). Subsequent inductions were performed with IPTG. Comparison studies with suspended bacteria showed that when IPTG was the initial inducing agent, induction kinetics are linear for both immobilized and suspended cells. After induction with lactose, however, a lag time is noted for suspended cells, but not for E. coli in the biofilm. Biocatalytic activity was successfully regenerated by re-inducing starved suspended cells 1-3 days after an initial induction with lactose. This regeneration was demonstrated in the synthesis of additional active beta-galactosidase. However, immobilized cells could be re-induced for at least 17 days after the initial induction, and viability in the synthetic biofilms remained greater than 90%, demonstrating that periodic induction is a valuable method for extending the life of whole cell biocatalysts. (c) 1996 John Wiley & Sons, Inc.     

乳糖诱导木聚糖酶基因在大肠杆菌中的可溶性表达

以构建好的大肠杆菌工程菌BL21(DE3)/xylanase为研究对象,研究了以IPTG和乳糖作为诱导剂时重组蛋白的表达规律。在摇瓶发酵条件下研究了诱导剂浓度、诱导时机、诱导培养时间和诱导培养温度对目标蛋白表达的影响。实验结果表明,乳糖作为诱导剂时,重组菌产酶活力33.9 U/mg略高于IPTG作为诱导剂时重组菌产酶活力28.10 U/mg,这为乳糖作为诱导剂应用于重组大肠杆菌生产木聚糖酶提供了参考依据。     

分散泛菌蔗糖异构酶在大肠杆菌中的表达及发酵优化

为了提高分散泛菌Pantoea dispersa UQ68J来源的蔗糖异构酶产量,研究了不同信号肽及发酵条件对蔗糖异构酶在大肠杆菌中重组表达的影响。将携带天然信号肽的蔗糖异构酶基因优化后,转入大肠杆菌Escherichia coli BL21(DE3)构建重组表达菌株——ORI菌株,摇瓶发酵总酶活和胞外酶活分别为85 U/m L、65 U/m L。从天然信号肽开始第22位氨基酸作为成熟蛋白的起始,连接Pel B或Omp A信号肽构建P22和O22菌株,其中P22菌株发酵总酶活提高至138 U/m L,是ORI菌株总酶活的1.6倍;而O22菌株发酵总酶活和ORI菌株无明显差别。采用3.0 g/L的乳糖诱导,P22菌株的蔗糖异构酶总酶活提高至168 U/m L。在3 L发酵罐中,研究甘氨酸浓度和诱导时间对蔗糖异构酶分泌的影响,当补加0.5%甘氨酸,DCW为18 g/L(OD_(600)=30)开始诱导,P22菌株的蔗糖异构酶胞外酶活最高达1 981 U/m L,同时蔗糖异构酶总酶活达到2 640 U/m L,是已报道大肠杆菌重组表达蔗糖异构酶的最高水平。     

复合与合成培养基对大肠杆菌胞外生产α-环糊精葡萄糖基转移酶的影响

为实现来源于Paenibacillus macerans JFB05-01的α-环糊精葡萄糖基转移酶（α-CGT酶）的高效胞外表达,以含分泌型信号肽OmpA的大肠杆菌E.coli BL21（DE3）{pET-20b（+）/α-cgt}为研究对象,比较了其在不同诱导条件下复合与合成培养基中生长产酶的规律。结果表明在添加甘氨酸的条件下采用合成培养基,以0.8 g/L/h的乳糖进行流加诱导所得的胞外酶活和生产强度最高。在该条件下发酵30小时后胞外α-CGT酶的环化活性达113.0U/ml（水解活性为79 100.0IU/ml）,是复合培养基胞外产酶的2.3倍,完全满足工业化生产的需求。     

A new fermentation process allows large-scale production of human milk oligosaccharides by metabolically engineered bacteria

When fed to a beta-galactosidase-negative (lacZ(-)) Escherichia coli strain that was grown on an alternative carbon source (such as glycerol), lactose accumulated intracellularly on induction of the lactose permease. We showed that intracellular lactose was efficiently glycosylated when genes of glycosyltransferase that use lactose as acceptor were expressed. High-cell-density cultivation of lacZ(-) strains that overexpressed the beta 1,3 N acetyl glucosaminyltransferase lgtA gene of Neisseria meningitidis resulted in the synthesis of 6 g x L(-1) of the expected trisaccharide (GlcNAc beta 1-3Gal beta 1-4Glc). When the beta 1,4 galactosyltransferase lgtB gene of N. meningitidis was coexpressed with lgtA, the trisaccharide was further converted to lacto-N-neotetraose (Gal beta 1-4GlcNAc beta 1-3Gal beta 1-4Glc) and lacto-N-neoheaxose with a yield higher than 5 g x L(-1). In a similar way, the nanA(-) E. coli strain that was devoid of NeuAc aldolase activity accumulated NeuAc on induction of the NanT permease and the lacZ(-) nanA(-) strain that overexpressed the N. meningitidis genes of the alpha2,3 sialyltransferase and of the CMP-NeuAc synthase efficiently produced sialyllactose (NeuAc alpha 2-3Gal beta 1-4Glc) from exogenous NeuAc and lactose.     

Cooperative binding of the sugar substrates and allosteric regulatory protein (enzyme IIIGlc of the phosphotransferase system) to the lactose and melibiose permeases in Escherichia coli and Salmonella typhimurium

An Escherichia coli strain which overproduces the lactose permease was used to investigate the mechanism of allosteric regulation of this permease and those specific for melibiose, glycerol, and maltose by the phosphoenolpyruvate-sugar phosphotransferase system (PTS). Thio-beta-digalactoside, a high affinity substrate of the lactose permease, released the glycerol and maltose permeases from inhibition by methyl-alpha-d-glucoside. Resumption of glycerol uptake occurred immediately upon addition of the galactoside. The effect was not observed in a strain which lacked or contained normal levels of the lactose permease, but growth of wild-type E. coli in the presence of isopropyl-beta-thiogalactoside plus cyclic AMP resulted in enhanced synthesis of the lactose permease so that galactosides relieved inhibition of glycerol uptake. Thiodigalactoside also relieved the inhibition of glycerol uptake caused by the presence of other PTS substrates such as fructose, mannitol, glucose, 2-deoxyglucose, and 5-thioglucose. Inhibition of adenylate cyclase activity by methyl-alpha-glucoside was also relieved by thiodigalactoside in E. coli T52RT provided that the lactose permease protein was induced to high levels. Cooperative binding of sugar and enzyme III(Glc) to the melibiose permease in Salmonella typhimurium was demonstrated, but no cooperativity was noted with the glycerol and maltose permeases. These results are consistent with a mechanism of PTS-mediated regulation of the lactose and melibiose permeases involving a fixed number of allosteric regulatory proteins (enzyme III(Glc)) which may be titrated by the increased number of substrate-activated permease proteins. This work suggests that the cooperativity in the binding of sugar substrate and enzyme III(Glc) to the permease, demonstrated previously in in vitro experiments, has mechanistic significance in vivo. It substantiates the conclusion that PTS-mediated regulation of non-PTS permease activities involves direct allosteric interaction between the permeases and enzyme III(Glc), the postulated regulatory protein of the PTS.     

Purification and properties of an inducible beta-galactosidase isolated from the yeast Kluyveromyces lactis.

beta-Galactosidase (EC 3.2.1.32) was purified 80-fold from the yeast Kluyveromyces lactis induced for this enzyme by growth on lactose. When the purified enzyme was subjected to electrophoresis on an acrylamide gel in the presence of sodium dodecyl sulfate, one protein with an apparent molecular weight of 135,000 was observed. The enzyme has a sedimentation coefficient of 9.6S. This beta-galactosidase and the one from Escherichia coli are not antigenically related. Maximal enzyme activity requires Na+ and Mn2+ and a reducing agent. beta-Galactosidase has Km values of 12 to 17 and 1.6 mM for lactose and o-nitrophenyl-beta-D-galactoside, respectively. The hydrolase and transgalactosylase activities of the enzyme are similar to those of E. coli beta-galactosidase.     

乳糖诱导的重组人血管内皮抑素(rhEndostatin)蛋白的表达

研究用乳糖替代IPTG作为诱导剂进行重组蛋白的表达,观察乳糖对乳糖操纵子调控的基因工程菌发酵及重组血管内皮抑素表达的影响,从而选取最佳诱导表达条件。以重组人血管内皮抑素表达工程菌pETrhEN/BL21(DE3)作为研究对象,分别用IPTG和乳糖作为诱导剂,在摇瓶中进行表达实验。并对重组蛋白质表达量进行分析。然后在5 L发酵罐中进行验证。在摇瓶培养条件下,乳糖浓度大于0.5 g/L即可以诱导目的蛋白的表达。乳糖浓度1 g/L时诱导目的蛋白表达量与1 mmol/L的IPTG相当,当乳糖浓度为10 g/L,目的蛋白表达量达到最大。在发酵罐培养条件下,补料4 h后葡萄糖浓度基本耗尽,此时开始加入乳糖。诱导后1 h,即有重组蛋白表达,在诱导后4 h达到高峰(占菌体可溶性蛋白的56%),与此同时,诱导后5 h菌体浓度也达到最高值。在以乳糖操纵子为调控手段的工程菌表达系统中,可以使用乳糖作为诱导剂,诱导应在葡萄糖消耗完后进行。     

Induction of the lactose transport system in a lipid-synthesis-defective mutant of Escherichia coli

In order to relate the biogenesis of the lactose transport system to lipid synthesis, a glycerol-requiring mutant of Escherichia coli K-12 with a specific defect in l-glycerol-3-phosphate synthesis was isolated and characterized. The defective enzyme is the biosynthetic l-glycerol-3-phosphate dehydrogenase [l-glycerol-3-phosphate: NAD (P) oxidoreductase, EC 1.1.1.8] which functions as a dihydroxyacetone phosphate reductase to provide l-glycerol-3-phosphate for lipid synthesis. In this mutant, removal of glycerol from the growth medium results in inhibition of the synthesis of protein, deoxyribonucleic acid, and phospholipid. Inhibition of phospholipid synthesis immediately follows glycerol removal, whereas the inhibition of deoxyribonucleic acid and protein synthesis is preceded by a short lag period. Glycerol starvation does not change the turnover pattern of previously synthesized phospholipids. The blocking of lipid synthesis by glycerol starvation causes a drastic decrease in inducibility of beta-galactoside transport activity relative to beta-galactosidase, indicating that induction of lactose transport requires de novo lipid synthesis.     

Properties of immobilized β-d-galactosidase from Bacillus circulans

Partially purified β-d-galactosidase (β-d-galactoside galactohydrolase, EC 3.2.1.23) from Bacillus circulans showed high activity towards both pure lactose and lactose in skim milk, and a better thermal stability than the enzyme from yeast or Escherichia coli. During the course of hydrolysis of lactose catalysed by the enzyme, considerable amounts of oligosaccharides were produced. β-d-Galactosidase from B. circulans was immobilized onto Duolite ES-762, Dowex MWA-1 and sintered alumina by adsorption with glutaraldehyde treatment. The highest activity for hydrolysis of lactose was obtained with immobilization onto Duolite ES-762. During a continuous hydrolysis of lactose, the immobilized enzyme was reversibly inactivated, probably due to oligosaccharides accumulating in the gel. The inactivation was reduced when a continuous reaction was operated at a high percent conversion of lactose in a continuous stirred tank reactor (CSTR). The half-life of the immobilized enzyme was estimated to be 50 and 15 days at 50 and 55°C, respectively, when the reaction was carried out in a CSTR with a percent conversion of lactose >70%.     

Co-induction of beta-galactosidase and the lactose-P-enolpyruvate phosphotransferase system in Streptococcus salivarius and Streptococcus mutans.

The addition of lactose, galactose, or isopropyl-beta-D-thiogalactoside (IPTG) to glucose-grown cells of Streptococcus salivarius 25975 resulted in the co-induction of both the lactose-P-enolpyruvate phosphotransferase system (lactose-PTS) and beta-galactosidase, with the latter the predominant metabolic system. With various strains of Streptococcus mutans and Streptococcus sanguis 10556, on the other hand, the lactose-PTS was the major metabolic pathway with beta-galactosidase induced either to low or negligible levels. In all cases, induction of the lactose-PTS resulted in the concomitant induction of 6-P-beta-galactosidase. The induction by lactose of both the lactose-PTS and beta-galactosidase in all strains was repressed by glucose and other catabolites, notably, fructose. Induction of beta-galactosidase in S. salivarius 25975 by IPTG was, however, relatively resistant to glucose repression. Induction experiments with IPTG and lactose suggested that a cellular metabolite of lactose metabolism was a repressor of enzyme activity. Exogenous cAMP was shown to reverse the transient repression by glucose of beta-galactosidase induction in cells of S. salivarius 25975 receiving lactose, provided the cells were grown with small amounts of toluene to overcome the permeability barrier to this nucleotide, cAMP, was however, unable to overcome the permanent repression of beta-galactosidase activity to a significant extent under these conditions.     

Regulation of Newly Evolved Enzymes. III Evolution of the ebg Repressor during Selection for Enhanced Lactase Activity

The evolution of lactose utilization by lacZ deletion strains of E. coli occurs via mutations in the ebg genes. We show that one kind of mutation in the regulatory gene ebgR results in a repressor which retains the ability to repress synthesis of ebg enzymes, but which permits 4.5-fold more ebg enzyme synthesis during lactose induction than does the wild-type repressor. A comparison between the growth rate of various ebg+ strains on lactose and the amount of ebg enzyme synthesized by these strains shows that the rate of enzyme synthesis permitted by the wild-type repressor is insufficient for growth on lactose as a sole carbon source by a cell with the most active ebg lactase yet isolated. We conclude, therefore, that the evolution of lactose utilization requires both a structural and a regulatory mutation.     

Effect of lacY expression on homogeneity of induction from the P(tac) and P(trc) promoters by natural and synthetic inducers

The role of the Escherichia coli lactose permease (LacY) in the homogeneous induction of the lactose-inducible promoters P(tac) and P(trc) by the natural inducer lactose and the synthetic inducer isopropyl-beta-D-thiogalactopyranoside (IPTG) was investigated. Lactose requires active transport by LacY, whereas IPTG can freely penetrate the cell wall. In E. coli strains lacking a functional LacY, IPTG is required for induction of P(tac) and P(trc). In E. coli strains carrying a functional LacY, induction of P(trc) and P(tac) with intermediate concentrations of lactose gave rise to two subpopulations, one fully induced and one uninduced, whereas a single, fully induced population resulted when high inducer concentrations were used. In contrast, induction with IPTG gave rise to a single population of cells at all inducer concentrations in both lacY and lacY(+) strains.     

Overexpression and functional analysis of cold-active beta-galactosidase from Arthrobacter psychrolactophilus strain F2

Cold-active beta-galactosidase from Arthrobacter psychrolactophilus strain F2 was overexpressed in Escherichia coli using the Cold expression system and the recombinant enzyme, rBglAp, was characterized. The purified rBglAp exhibited similar enzymatic properties to the native enzyme, e.g., (i) it had high activity at 0 degrees C, (ii) its optimum temperature and pH were 10 degrees C and 8.0, respectively, and (iii) it was possible to rapidly inactivate the rBglAp at 50 degrees C in 5 min. Moreover, rBglAp was able to hydrolyze both ONPG and lactose with K(m) values of 2.7 and 42.1mM, respectively, at 10 degrees C. One U of rBglAp could hydrolyze about 70% of the lactose in 1 ml of milk in 24h, and the enzyme produced trisaccharide from lactose. We conclude that rBglAp is a cold-active enzyme that is extremely heat labile and has significant potential application to the food industry.