翅鳞伞深层发酵胞外多糖优化研究

采用PlackettBurman设计(PlackettBurman Design, PB)对影响翅鳞伞［ Pholiota squarrosa (Pers. Ex Fr.) Quel.］ AS 5245菌株发酵产糖的内在和外在相关因素进行了筛选,所选取的20个相关因素为葡萄糖、果糖、麦芽糖、酵母膏、胰蛋白胨、KH₂PO₄、K₂HPO₄、(NH₄)₂SO₄、NaNO₃、FeSO₄、MgSO₄、MnCl₂、ZnCl₂、FeCl₃、CuSO₄·5H₂O、维生素B1、起始pH、发酵温度、时间和装液量。在此基础上,再采用响应曲面法(Response Surface Methodology,RSM)对影响发酵产糖的内在关键影响因素酵母膏、果糖、MgSO₄、麦芽糖、ZnCl₂和发酵基质起始pH值的最佳水平范围作了进一步的研究与探讨,通过对二次多项回归方程求解得知,在上述自变量分别为6.0g/L、11.5g/L、0.5g/L、9.6g/L、38.6mg/L和5.3时,胞外多糖最大预测值为876.32μg/mL发酵醪,此预测可信度不仅被统计分析所验证,也实践所证实。     

Optimization of submerged culture condition for the production of mycelial biomass and exopolysaccharides by Agrocybe cylindracea

The optimization of submerged culture conditions and nutritional requirements was studied for the production of exopolysaccharide (EPS) from Agrocybe cylindracea ASI-9002 using the statistically based experimental design in a shake flask culture. Both maximum mycelial biomass and EPS were observed at 25 degrees C. The optimal initial pH for the production of mycelial biomass and EPS were found to be pH 4.0 and pH 6.0, respectively. Subsequently, optimum concentration of each medium component was determined using the orthogonal matrix method. The optimal combination of the media constituents for mycelial growth was as follows: maltose 80 g/l, Martone A-1 6 g/l, MgSO4 x 7H2O 1.4 g/l, and CaCl2 1.1 g/l; for EPS production: maltose 60 g/l, Martone A-1 6 g/l, MgSO4 x 7H2O 0.9 g/l, and CaCl2 1.1 g/l. Under the optimal culture condition, the maximum EPS concentration achieved in a 5-l stirred-tank bioreactor indicated 3.0 g/l, which is about three times higher than that at the basal medium.     

桑木层孔菌液体培养条件的研究

对桑木层孔菌(Phellinus mori)液体发酵条件进行了研究,以生物量和胞外多糖为指标,通过L16(45)和L9(34)正交表进行了两次正交试验,筛选出桑木层孔菌最适液体培养条件为:麦芽糖30 g/L,酵母浸粉和蛋白胨15 g/L(质量比2 1),KH2PO4和CaCl25.5 g/L(质量比1 1),初始pH6.0;通过单因素试验筛选出最适装液量为120 mL/250 mL,最适接种量为10%。在此条件下液体发酵培养7 d后,桑木层孔菌生物量达到23.375 g/L,胞外多糖产量达到3.993 g/L。     

Exopolysaccharide production and mycelial growth in an air-lift bioreactor using Fomitopsis pinicola

For effective exopolysaccharide production and mycelial growth by a liquid culture of Fomitopsis pinicola in an air-lift bioreactor, the culture temperature, pH, carbon source, nitrogen source, and mineral source were initially investigated in a flask. The optimal temperature and pH for mycelial growth and exopolysaccharide production were 25degrees C and 6.0, respectively. Among the various carbon sources tested, glucose was found to be the most suitable carbon source. In particular, the maximum mycelial growth and exopolysaccharide production were achieved in 4% glucose. The best nitrogen sources were yeast extract and malt extract. The optimal concentrations of yeast extract and malt extract were 0.5 and 0.1%, respectively. K2HPO4 and MgSO4 x 7H2O were found to be the best mineral sources for mycelial growth and exopolysaccharide production. In order to investigate the effect of aeration on mycelial growth and exopolysaccharide production in an air-lift bioreactor, various aerations were tested for 8 days. The maximum mycelial growth and exopolysaccharide production were 7.9 g/l and 2.6 g/l, respectively, at 1.5 vvm of aeration. In addition, a batch culture in an air-lift bioreactor was carried out for 11 days under the optimal conditions. The maximum mycelial growth was 10.4 g/l, which was approximately 1.7-fold higher than that of basal medium. The exopolysaccharide production was increased with increased culture time. The maximum concentration of exopolysaccharide was 4.4 g/l, which was about 3.3-fold higher than that of basal medium. These results indicate that exopolysaccharide production increased in parallel with the growth of mycelium, and also show that product formation is associated with mycelial growth. The developed model in an air-lift bioreactor showed good agreement with experimental data and simulated results on mycelial growth and exopolysaccharide production in the culture of F pinicola.     

雅致放射毛霉液体培养工艺及其多糖的免疫调节作用研究

对雅致放射毛霉液体培养研究表明,其适宜碳源为饴糖和可溶性淀粉,适宜氮源为黄豆粉和酵母膏,最适培养基含黄豆粉3%、饴糖0.5%、磷酸二氢钾0.2%、硫酸镁0.2%、酵母膏0.1%。适宜液体培养条件是温度28℃,接种量5%,发酵前期通风量1∶0.8,之后将风量调至1∶1.5~1∶2.0,全程不搅拌培养至18h~20h,生物量为每100mL发酵液中菌丝鲜重达30g以上。菌丝体氨基酸含量为46.1mg/100mL。免疫调节作用检验表明,雅致放射毛霉多糖具有一定的增强免疫力作用。     

Factors affecting mycelial biomass and exopolysaccharide production in submerged cultivation of Antrodia cinnamomea using complex media

Submerged cultures were used to identify growth-limiting nutrients by Antrodia cinnamomea strains. The mycelial biomass and EPS production by A. cinnamomea BCRC 35396 were markedly higher than other A. cinnamomea strains. A relatively high C/N ratio was favorable for both the mycelial growth (5.41 g/l) and EPS production (0.55 g/l); the optimum ratio was 40. The glucose was available utilized preferentially for mycelial growth, rather than for EPS production. Flushing the culture medium with nitrogen had a stimulating effect on both mycelial growth and EPS production. In addition, peptone, yeast extract and malt extract appeared to be important and significant component for EPS production. Phosphate ion, magnesium ion and thiamine were probably not essential for mycelial growth. By optimizing the effects of additional nutrition, the results showed that 5% (w/v) glucose, 0.8% (w/v) peptone, 0.8% (w/v) yeast extract, 0.8% (w/v) malt extract, 0.03% (w/v) KH2PO4, 0.1% (w/v) MgSO4 .7H2O and 0.1% (w/v) thiamine could lead to the maximum production of EPS (1.36 g/l).     

营养物质对桑黄菌丝生物量及胞外多糖产量的影响

研究了不同碳源、氮源和无机盐对桑黄深层培养菌丝生物量和胞外多糖产量的影响,结果表明：在培养温度为26℃、摇床转速为160r／min、发酵时间为10d的条件下,以桑黄菌丝生物量为指标,最适碳源、氮源和无机盐分别是果糖或葡萄糖、酵母粉或酵母膏、KH2P04或MgSO4·7H2O;菌丝生物量分别达到1．51、1．31、1．69、1．52、1．52、1．36g／100mL;以胞外多糖为指标,最适碳源、氮源和无机盐分别是葡萄糖、酵母膏、ZnSO4·7H2O,胞外多糖产量分别达到0．49、0．45、0．22g／100mL。     

Medium optimization for the production of thermal stable beta-glucanase by Bacillus subtilis ZJF-1A5 using response surface methodology

Polysaccharides, such as barley flour, dextrin and soluble starch, were better carbon sources than monosaccharides and disaccharides, such as glucose and maltose, for cell growth of Bacillus subtilis ZJF-1A5 and beta-glucanase production. beta-Glucanase produced by B. subtilis ZJF-1A5 was associated partially with cell growth and increased significantly when cells entered stationary phase; yeast extract was the best nitrogen source, followed by soybean flour. All inorganic nitrogen sources chosen in the experiments were not favorable for cell growth and enzyme production. A fractional factorial design (2(6-2)) was applied to elucidate medium components that significantly affect beta-glucanase production. The concentration of barley flour, corn flour and soybean flour in medium were significant factors. The steepest ascent method was used to locate the optimal domain and a central composite design was used to estimate the quadratic response surface from which the factor levels for maximum production of beta-glucanase were determined. The composition of fermentation medium optimized with response surface methodology was (g/l): barley flour, 63.5; corn flour, 44.8; KH2PO4, 1.0; MgSO4 x 7H2O, 0.1; CaCl2, 0.1. beta-Glucanase activity was 251 U/ml at 48 h using optimized medium, 1.4 times higher than that in original medium.     

被孢霉菌发酵产生花生四烯酸的研究

研究了温度、培养基初始pH、碳源、氮源对被孢霉(Mortierella sp.)产生花生四烯酸的影响。正交试验结果表明,Mortierella sp.M10最佳培养基组成为(g/L):葡萄糖100,酵母膏10,KNO_3 4.0,KH_2PO_4 2.0,CaCl_2·2H_2O 0.1,MgSO_4·7H_2O 0.5,FeCl_3·6H_2O0.015,ZnSO_4·7H_2O 0.0075,CuSO_4·5H_2O 0.0005。采用最佳培养基及发酵条件,细胞干重和花生四烯酸产量分别为33.51g/L和0.827g/L。同时对摇瓶发酵过程进行了分析。     

人胰高血糖素样肽-1突变体融合蛋白在大肠杆菌中的自诱导表达优化

考察了在大肠杆菌中自诱导表达人胰高血糖素样肽-1突变体融合蛋白的可行性,并对自诱导培养条件及培养基成分进行优化,以提高蛋白产量。实验结果表明,最优培养基成分为蛋白胨19.17g/L,酵母膏9.59g/L,Na2HPO45.72g/L,KH2PO45.48g/L,(NH4)2SO42.66g/L,NaCl3.33g/L,甘油2%(V/V),葡萄糖0.68g/L,乳糖6.33g/L,MgSO40.24g/L。在温度33°C、接种量1%、pH7、装瓶量20mL/100mL培养条件下,用该最优培养基自诱导表达人胰高血糖素样肽-1突变体融合蛋白的产量可达348.6mg/L。     

Optimisation of submerged culture conditions for the production of mycelial biomass and exopolysaccharide byPleurotus nebrodensis

The optimisation of submerged culture conditions and nutritional requirements was studied for the production of exopolysaccharide (EPS) fromPleurotus nebrodensis. The optimal temperature and initial pH for both mycelial growth and EPS production in shake flask cultures were 25 °C and 8.0, respectively. Maltose was found the most suitable carbon source for both mycelial biomass and EPS production. Yeast extract was favourable nitrogen source for both mycelial biomass and EPS production. Optimum concentration of each medium component was determined using the orthogonal matrix method. The optimal combination of the media constituents for mycelial growth and EPS production was as follows: 200 g l^?1 bran, 25 g l^?1 maltose, 3 g l^?1 yeast extract, 1 g l^?1 KH₂PO₄, 1 g l^?1 MgSO₄ 7H₂O. Under the optimal conditions, the mycelial biomass (4.13 g l^?1) and EPS content (2.40 g l^?1) ofPleurotus nebrodensis was 2.3 and 3.6 times compared to the control with basal medium respectively.     

Production of exopolysaccharides by submerged mycelial culture of a mushroom Tremella fuciformis

The optimization of submerged culture conditions for mycelial growth and exopolysaccharide (EPS) production in an edible mushroom Tremella fuciformis was studied in shake flasks and bioreactors. The temperature of 28 degrees C and pH 8 in the beginning of fermentation in agitated flasks was the most efficient condition to obtain maximum mycelial biomass and EPS. The optimal medium constituents were as follows (gL(-1)): glucose 20, tryptone 2, KH(2)PO(4) 0.46, K(2)HPO(4) 1 and MgSO(4).7H(2)O 0.5. The fungus was cultivated under various agitation and aeration conditions in a 5L stirred-tank bioreactor. The maximum cell mass and EPS production were obtained at a relatively high agitation speed of 200 rpm and at an aeration rate of 2 vvm. The flow behavior of the fermentation broth was Newtonian and the maximum apparent viscosity (35 cP) was observed at a highly aerated condition (2 vvm). The EPS productivity in an airlift reactor was higher than that in the stirred-tank reactor. The morphological study revealed that the fungus grows in mainly three different yeast-like forms: ovoid, elongated, and double yeast forms. The high population of the elongated yeast has a very close relationship to high EPS production. The EPS were protein-bound polysaccharides consisted of mainly mannose, xylose, and fucose. The molecular weights of EPS were determined to be (1.3-1.5)x10(6).     

Influence of nutritional conditions on exopolysaccharide production by submerged cultivation of the medicinal fungus <Emphasis Type="Italic">Shiraia bambusicola</Emphasis>

Maltose and yeast extract were the most favourable carbon and nitrogen sources for exopolysaccharide production by submerged culture of Shiraia bambusicola WZ-003, and initial maltose and yeast extract concentrations were at 30 and 3 g l⁻¹, respectively. Plant oils could increase the mycelial growth and exopolysaccharide production in tested concentration. K⁺ and Mg²⁺ could enhance the mycelial growth and exopolysaccharide biosynthesis. The optimal cultivation temperature and initial pH were found to be 26°C and 6.0, respectively. Exopolysaccharide concentration reached 0.53 g l⁻¹ in 15-l fermenter under optimal nutritional conditions.     

Optimization of a cultural medium for bacteriocin production by Lactococcus lactis using response surface methodology.

The medium composition for bacteriocin production by Lactococcus lactis ATCC 11454 was optimized using response surface methodology. The selected six factors based on CM medium were sucrose, soybean peptone, yeast extract, KH(2)PO(4), NaCl, and MgSO(4).7H(2)O. Fractional factorial designs (FFD) and the path of steepest ascent were effective in searching for the main factors and approaching the optimum region of the response. By a 2(6-2) FFD, sucrose, soybean peptone, yeast extract, KH(2)PO(4) were found to be significant factors and had positive effects on cell growth, however, only soybean peptone and KH(2)PO(4) were shown to be the two significant factors for bacteriocin production and had negative and positive effects, respectively. The effects of the two main factors on bacteriocin production were further investigated by a central composite design and the optimum composition was found to be 1% sucrose, 0.45% soybean peptone, 1% yeast extract, 2.84% KH(2)PO(4), 0.2% NaCl, and 0.02% MgSO(4) x 7H(2)O. The optimal medium allowed bacteriocin yield to be doubled compared to CM medium.     

Effect of medium components on bacteriocin production by Lactobacillus plantarum strains ST23LD and ST341LD, isolated from spoiled olive brine

Bacteriocin ST23LD levels of 2930AU/OD were recorded in MRS broth (pH of 6.5) and in the presence of tryptone and yeast extract as sole nitrogen sources. Growth in MRS broth at an initial pH of 6.0 yielded only 1460AU/OD bacteriocin ST23LD. Activities of 5861AU/OD were recorded with maltose (20, 30 and 40 g/l) as sole carbon source and 9036AU/OD with the addition of 2.0-10.0 g/l KH2PO4. Bacteriocin ST341LD levels of 2850 and 2841AU/OD were recorded in MRS broth at an initial pH of 6.0 or 5.5, respectively. Only 709AU/OD was recorded in the same medium with an initial pH of 6.5. Bacteriocin ST341LD production was stimulated by the presence of tryptone. However, glucose at 10 and 40 g/l, or the presence of 5.0 or 10.0 g/l K2HPO4, resulted in a 50% reduction of bacteriocin activity. Glycerol in the growth medium repressed bacteriocin production. No increased bacteriocin production was recorded in medium supplemented with vitamins.     

休哈塔假丝酵母HDYXHT-01利用木糖生产乙醇的发酵工艺优化

采用Plackett-Burman (PB) 方法和中心组合设计 (Ccentral composit design,CCD) 对休哈塔假丝酵母Candida shehataeHDYXHT-01利用木糖发酵生产乙醇的工艺进行优化。PB试验设计与分析结果表明：硫酸铵、磷酸二氢钾、酵母粉和接种量是影响木糖乙醇发酵的4个关键因素,以乙醇产量为响应目标,采用CCD和响应面分析法 (Response surface methodology,RSM),确定了木糖乙醇发酵的最佳工艺为：硫酸铵1.73 g/L、磷酸二氢钾3.56 g/L、酵母粉2.62 g/L和接种量5.66％,其他发酵条件为：木糖80 g/L,MgSO4·7H2O 0.1 g/L,pH 5.0,培养温度30 ℃,装液量100 mL/250 mL,摇床转速140 r/min,发酵时间48 h,在该条件下发酵液中乙醇产量可以达到26.18 g/L,比未优化前提高了1.15倍。     

Effect of the physiological conditions on alpha-amylase and glucoamylase formation by a selected strain of Aspergillus oryzae

The production of alpha-amylase and glucoamylase by a selected strain of Aspergillus oryzae was investigated using different carbon and nitrogen sources. The best and most economic fermentation medium for the production of the both amylases in submerged cultures had the following composition (in %): defatted rice brain, 8; corn steep liquor, 3; MgSO4 X 7H2O, 0.1; KH2PO4, 0.1; CaCl2, 0.1. The optimum pH was 5.0. The optimal conditions for biosynthesis of the amylases were as follows: cultivation at 28 degrees C for 96 h using the 0.5% mycelial suspension as an inoculum.     

圆红冬孢酵母菌发酵产油脂培养基及发酵条件的优化研究

采用均匀设计和单因子试验法,系统考察了圆红冬孢酵母菌(Rhodosporidiumtoruloides)在不同碳氮比条件下产油发酵情况以及添加无机盐对产油发酵的影响,通过均匀设计软件对二次多项回归方程求解及单因素分析得知在培养基组成分别为葡萄糖70g/L,硫酸铵0.1g/L,酵母粉0.75g/L,磷酸二氢钾0.4g/L,七水硫酸镁1.5g/L,初始pH6.0,在灭菌(121℃15min)后添加ZnSO41.91×10-6mmol/L、CaCl21.50mmol/L、MnCl21.22×10-4mmol/L、CuSO41.00×10-4mmol/L。发酵摇瓶装液量为250mL三角瓶装培养基50mL,接种量为10%(种龄28h)。在上述条件下,30℃振荡(200r/min)培养120h,所得菌体油脂含量高达76.1%,脂肪得率系数可达22.7。     

Optimization of culture media for enhanced chitinase production from a novel strain of Stenotrophomonas maltophilia using response surface methodology

Chitinase is one of the most important mycolytic enzymes with industrial significance. This enzyme is produced by a number of organisms including bacteria. In this study we describe optimization of media components with increased production of chitinase for selected bacteria Stenotrophomonas maltophilia isolated from the soil. Different components of the defined media responsible for influencing chitinase secretion by the bacterial isolate were screened using Plackett-Burman experimental design and were further optimized by Box-Behnken factorial design of response surface methodology (RSM) in liquid culture. Maximum chitinase production was predicted in medium containing chitin 4.94 g/l, maltose 5.56 g/l, yeast extract 0.62 g/l, KH2PO4 1.33 g/l and MgSO4.7H2O 0.65 g/l using Response surface plots and point prediction tool of DESIGN EXPERT 7.1.6 (Statease, USA) software.     

假丝酵母E-2产生物表面活性剂摇瓶发酵条件的优化

从扬子石化的废水淤泥中筛选到1株能发酵液体石蜡产脂肽类生物表面活性剂的假丝酵母Candida E-2.通过单因子实验和正交试验,得到了最佳发酵培养基组成(g/L):牛肉膏3.0,蔗糖2.0,酵母膏0.25,KH2PO4 12.5,MgSO4 0.3,NaCl 1.5,CaCl,0.05,尿素0.5 5;液体石蜡10％(体积分数).最佳培养条件:初始pH7.0,接种量0.12g/L,装液量为200mL三角瓶30mL,培养时间为5 d.最终产量提高了2.7倍,达1.582g/L.