休哈塔假丝酵母HDYXHT-01利用木糖生产乙醇的发酵工艺优化

采用Plackett-Burman (PB) 方法和中心组合设计 (Ccentral composit design,CCD) 对休哈塔假丝酵母Candida shehataeHDYXHT-01利用木糖发酵生产乙醇的工艺进行优化。PB试验设计与分析结果表明：硫酸铵、磷酸二氢钾、酵母粉和接种量是影响木糖乙醇发酵的4个关键因素,以乙醇产量为响应目标,采用CCD和响应面分析法 (Response surface methodology,RSM),确定了木糖乙醇发酵的最佳工艺为：硫酸铵1.73 g/L、磷酸二氢钾3.56 g/L、酵母粉2.62 g/L和接种量5.66％,其他发酵条件为：木糖80 g/L,MgSO4·7H2O 0.1 g/L,pH 5.0,培养温度30 ℃,装液量100 mL/250 mL,摇床转速140 r/min,发酵时间48 h,在该条件下发酵液中乙醇产量可以达到26.18 g/L,比未优化前提高了1.15倍。     

内切中性纤维素酶EGⅡ的发酵条件优化

对毕赤酵母基因工程菌EIM-50-eg2产内切中性纤维素酶的主要影响因子进行研究,考察氮源、pH、温度、微量元素PTM1和甲醇浓度等对工程菌产酶的影响。单因素实验和正交实验结果表明,优化后的培养基组成及培养条件:磷酸氢二铵40 g/L,甲醇15 mL/L,硫酸镁10 g/L,磷酸二氢钾9 g/L,初始pH 6.0,培养温度28℃,PTM1添加量0.02%,甲醇诱导浓度1.5%。优化后内切葡聚糖酶活力可达4 158 U/(mL.min)是优化前1 449 U/(mL.min)的2.86倍。     

阿拉伯胶酶产生菌株的筛选及其发酵培养基的优化

从土壤中筛选产阿拉伯胶酶的微生物菌株,并通过紫外诱变选育后得到高产突变菌株ZHB05F,依据菌落和孢子形态特征初步鉴定为镰刀茵(Fusarium sp.).通过单因素试验,优化了产酶培养基的主要组分的浓度和pH值,得到最佳的产酶发酵培养基组成为:阿拉伯胶30 g/L,(NH4)2SO4 8 g/L,K2HPO4 1g/...     

Influence of nutritional and environmental factors on ethanol and endopolygalacturonase co-production by Kluyveromyces marxianus CCEBI 2011

Ethanol and endopolygalacturonase (endoPG) are simultaneously produced by the yeast Kluyveromyces marxianus CCEBI 2011. The aim of this study was to determine the optimal combination of seven environmental and nutritional variables, as well as the influence of each one, with respect to the fermentation process in yeast cultures in which sugarcane juice was the substrate. Simplex sequential optimization showed that after 15 runs the optimal conditions were: pH, 4.6; temperature, 31 oC; total reducing sugars (TRS), 125 g/l; (NH(4))(2)SO(4), 2.48 g/l; (NH(4))(2)HPO(4), 2.73 g/l; CaCl(2), 0.33 g/l and MgSO(4)·7H(2)O, 0.54 g/l. Under these conditions, the ethanol concentration was 47.6 g/l and endoPG concentration was 9.8 U/ml, which represented increases of 22% and 10%, respectively, over the concentrations obtained under suboptimal conditions. Temperature and (NH(4))(2)SO(4) supplementation were the most significant factors influencing the co-production process.     

重组谷氨酸棒杆菌发酵L-苯丙氨酸培养基的优化

【目的】提高重组谷氨酸棒杆菌发酵L-苯丙氨酸(L-phenylalanine,L-Phe)的产量。【方法】使用正交试验设计以及响应面优化法分别对种子培养基及发酵培养基进行优化,确定了重组谷氨酸棒杆菌发酵L-Phe的最佳种子培养基及最佳发酵培养基。【结果】重组谷氨酸棒杆菌发酵L-Phe最佳种子培养基(g/L):葡萄糖25.0,玉米浆25.0,硫酸铵15.0,硫酸镁1.0,磷酸二氢钾2.0,尿素2.0,p H 6.8-7.0;最佳发酵培养基(g/L):葡萄糖110.0,玉米浆7.0,硫酸铵25.0,硫酸镁1.0,磷酸二氢钾1.0,柠檬酸钠2.0,谷氨酸1.0,碳酸钙25.0,p H 6.8-7.0;在最佳培养基条件下L-Phe产量最高达到9.14 g/L,较优化前的7.46 g/L提高了22.5%。【结论】通过正交试验和响应面分析对重组谷氨酸棒杆菌发酵L-Phe培养基进行优化,明显提高了L-Phe的产量,并确定了葡萄糖、玉米浆和硫酸铵为发酵培养基中影响L-Phe产量的3个关键因子。研究结果为L-Phe的发酵放大提供了依据。     

产脂肪酶菌株C7828-5的筛选、鉴定以及产酶条件的优化

以花生油为唯一碳源,从海口市各地被油脂污染土样中分离筛选出1株中温碱性脂肪酶菌株C7828-5。形态学、生理生化特征和分子生物学鉴定结果表明,该菌株为铜绿假单胞菌(Pseudomonas aeruginosa)。该菌所产脂肪酶的最适温度为37℃,最适pH为8.0。优化了菌株的产酶条件,最适产酶培养基(g/L)为:蔗糖5、牛肉膏20、(NH_4)_2SO_41、MgSO_4·7H_2O 0.5、CaCl_20.5,聚乙烯醇花生油乳化液120 mL,发酵72 h,获得高达8.08 U/mL的脂肪酶表达量。     

黑曲霉固态发酵生产单宁酶的条件优化

研究采用响应面法优化黑曲霉固态发酵生产单宁酶的培养条件。应用Plackett—Burman试验筛选出重要影响因子：五倍子粉含量、（NH4）2SO4浓度以及接种孢子量,最陡爬坡试验逼近最大响应区域。应用Box．Behnken响应面试验对重要影响因子进一步优化。得到最佳培养条件：每250mL三角瓶中装入1．0g五倍子粉、4．4g稻壳和0．5g麸皮、液固比（mL／g）2：1且营养盐溶液组成为（NH4）2s0421g/L、MgSO4·7H2O1g／L、NaCl1g／L,培养基pH自然,接种5．7×10^7个孢子后在30℃温度下培养4d。在此条件下,单宁酶产量从40U／g提高到114U／g,3次重复验证性试验平均值为115U／g,验证了模型的可靠性。     

翅鳞伞深层发酵胞外多糖优化研究

采用PlackettBurman设计(PlackettBurman Design, PB)对影响翅鳞伞［ Pholiota squarrosa (Pers. Ex Fr.) Quel.］ AS 5245菌株发酵产糖的内在和外在相关因素进行了筛选,所选取的20个相关因素为葡萄糖、果糖、麦芽糖、酵母膏、胰蛋白胨、KH₂PO₄、K₂HPO₄、(NH₄)₂SO₄、NaNO₃、FeSO₄、MgSO₄、MnCl₂、ZnCl₂、FeCl₃、CuSO₄·5H₂O、维生素B1、起始pH、发酵温度、时间和装液量。在此基础上,再采用响应曲面法(Response Surface Methodology,RSM)对影响发酵产糖的内在关键影响因素酵母膏、果糖、MgSO₄、麦芽糖、ZnCl₂和发酵基质起始pH值的最佳水平范围作了进一步的研究与探讨,通过对二次多项回归方程求解得知,在上述自变量分别为6.0g/L、11.5g/L、0.5g/L、9.6g/L、38.6mg/L和5.3时,胞外多糖最大预测值为876.32μg/mL发酵醪,此预测可信度不仅被统计分析所验证,也实践所证实。     

侧孢短芽胞杆菌产生线虫侵染性蛋白酶的优化

采用单因素试验确定侧孢短芽胞杆菌G4产线虫侵染性蛋白酶的最佳碳氮源,通过Placket-Burman设计筛选影响蛋白酶活力的主效因子,最陡坡试验和Box-Behnken设计获得主效因子的最佳水平,建立线虫侵染性蛋白酶的最佳生产体系:葡萄糖9.78 g/L、牛肉膏16.65 g/L、磷酸氢二钾0.75 g/L、可溶性淀粉12.5 g/L、氯化钠0.75 g/L、硫酸镁0.5 g/L、初始pH值自然、装液量50 mL,37℃摇瓶培养32 h,蛋白酶活力可达12 379.41 U/mL,较优化前的2 476.3 U/mL提高了4倍。     

鞘胺醇杆菌肝素酶的产生

肝素类分子是一类结构异常复杂的高度硫酸化的糖胺聚糖,是临床上的一种主要的抗凝剂。除了抗凝血及其相关的抗栓活性以外,肝素还具有多种其他生物学功能,如抗平滑肌细胞及肾小球系膜细胞的增殖^[1]、抗炎症^[2]和阻止肿瘤生长及转移的作用^[3]等。因而肝素可用于防治球囊扩充血管成型术后的血管再狭窄、肾小球系膜细胞增生性肾炎、病理性炎症及肿瘤。但由于完整肝素的抗凝血活性,会引起出血及血小板减少综合症等负作用,限制了肝素在这些方面的临床应用。研究表明,肝素的抗凝血活性依赖于一种独特的肝素五糖序列,约占完整肝素链的1／3,除了五糖序列以外,还需要附近的至少13糖残基,因而不含五糖序列或含五糖序列小于18糖的肝素其抗凝活性大大降低^[4]。而六糖以上的肝素片段就具有抗平滑肌细胞增生、抗炎症及抗肿瘤的活性,并且这些活性与抗凝活性无关。因此,可利用特异性的肝素酶降解肝素长链,产生一系列不同结构及大小的肝素片段,并从中筛选出具有不同生物活性的片段。     

产低温脂肪酶菌株CZW001发酵培养基优化研究

【目的】研究产低温脂肪酶菌株CZW001发酵培养基。【方法】在单因素试验的基础上, 采用Plackett-Burman (P-B)设计, Box-Behnken (B-B)设计和响应面试验设计(RSM), 在20 °C、pH 8.0、160?r/min发酵2 d条件下, 对发酵培养基进行优化。【结果】该菌株最适产酶培养基为(g/L): 葡萄糖7.68, 橄榄油21.93, 硫酸铵2.0, 磷酸二氢钾1.0, 硫酸镁0.27, 氯化钙0.3, 氯化钠20.0, 吐温-80 1.0。其最高酶活为62.8 U/mL, 比优化前提高了3.14倍。【结论】通过对产低温脂肪酶菌株CZW001发酵培养基优化研究, 明显提高低温脂肪酶活力。     

红曲菌利用生物柴油废液生产红曲色素

对生物柴油废液作简单处理,利用红曲茵发酵生物柴油废液中副产物甘油生产红曲色素。通过响应面方法确定最佳发酵培养基为：甘油48．49g/L,蛋白胨3．12g／L,K2HPO4·3H202．01g/L,MgSO4 0．48g／L,ZnSO4·7H2O 0．04g／L,MnSO4·H2O 0．03g／L,玉米浆13mL／L,植物油10mL／L,起始pH为6。发酵结果表明：在接种量6％（v／v）,转速140r／min,35℃的条件下发酵培养6d,红曲色素最高产量到达204U／mL。说明用生物柴油废液中的粗甘油为原料生产红曲色素是基本可行的。可望为生物柴油废液的资源化提供一条环境友好型的途径。     

培养条件对头孢霉菌丝体脂肪酸组分的影响

研究了头孢霉(Cephalosporium sp.)菌丝体最大生产力和多不饱和脂肪酸形成积累的条件。菌丝体最适培养条件为：麦芽糖60g/L\,KNO33g/L、起始pH为60、500mL三角瓶装100mL培养基、接种25%、25℃培养10d则菌丝体达到最大干重。多不饱和脂肪酸形成积累的最适条件为：葡萄糖10～20g/L、(NH4)2SO4或NH4Cl 3g/L、培养基起始pH为40、500mL三角瓶装100mL培养基、接种10%～20%、10℃下照光培养。〖JP2〗因此,在整个生产流程中可采用不同条件分段掌握的技术原则。同时提出在多不饱和脂肪酸的形成和积累途径中油酸(18∶1)向亚油酸(18∶2)的转化是关键,为进一步探索最适培养条件和关键酶的调节提供依据。     

A glycerol-inducible thermostable lipase from Bacillus sp.: medium optimization by a Plackett-Burman design and by response surface methodology

The production of a neutral lipase from a Bacillus sp. was improved tremendously (193-fold) following media optimization involving both the "one-at-a-time" and the statistical designing approaches. The present lipase was poorly induced by oils, instead its production was induced in the presence of sugars and sugar alcohols, mainly galactose, lactose, glycerol, and mannitol. A high inoculum density of 15% v/v (A550 = 0.8) led to maximum lipase production. Interestingly, the enzyme induction was growth independent, a property very different from most of the lipases investigated to date. The optimal composition of the growth medium to achieve maximum lipase production was determined to be as follows: NH4Cl, 35 g x L(-1); glycerol, 10 mL x L(-1); K2HPO4, 3 g x L(-1); KH2PO4, 1 g x L(-1); MgSO4.7H2O, 0.1 g x L(-1); glucose, 2 g x L(-1); MgCl2, 0.6 mmol x L(-1), with 15% inoculum density and an incubation period of 24 h. About 62 U x mL(-1) of enzyme production was achieved in the optimized medium.     

Optimization of fermentation conditions for preparation of polygalacturonic acid transeliminase by Erwinia carotovora IFO3830

This paper is concerned with optimization of the fermentation conditions for preparation of alkaline pectin lyase (poly-galacturonic acid trans-eliminase, PATE) by Erwinia carotovora IFO3830 (E.C.IFO3830). The orthogonal matrix method was adopted as the experimental design method for media. The effects of media composition on the growth rate of E.C.IFO3830 are in the order of pectin > KH(2)PO(4)/Na(2)HPO(4) > MgSO(4) > (NH(4))(2)SO(4) > glucose > L-glutamate sodium, and those on PATE activity are in the order of glucose > pectin > L-glutamate sodium > KH(2)PO(4)/Na(2)HPO(4) > MgSO(4) > (NH(4))(2)SO(4). The strain of E.C.IFO3830 grows quickly and easily near an initial pH of 7.0, and especially at the alkaline range of pH 7.0-8.0. The growth rate profiles indicate that E.C.IFO3830 grows very quickly; its generation time t(1/2) is about 0.2 h. The appropriate fermentation period is about 10-20 h for a high level productivity of biomass and 25-35 h for high productivity of PATE enzyme.     

圆红冬孢酵母菌发酵产油脂培养基及发酵条件的优化研究

采用均匀设计和单因子试验法,系统考察了圆红冬孢酵母菌(Rhodosporidiumtoruloides)在不同碳氮比条件下产油发酵情况以及添加无机盐对产油发酵的影响,通过均匀设计软件对二次多项回归方程求解及单因素分析得知在培养基组成分别为葡萄糖70g/L,硫酸铵0.1g/L,酵母粉0.75g/L,磷酸二氢钾0.4g/L,七水硫酸镁1.5g/L,初始pH6.0,在灭菌(121℃15min)后添加ZnSO41.91×10-6mmol/L、CaCl21.50mmol/L、MnCl21.22×10-4mmol/L、CuSO41.00×10-4mmol/L。发酵摇瓶装液量为250mL三角瓶装培养基50mL,接种量为10%(种龄28h)。在上述条件下,30℃振荡(200r/min)培养120h,所得菌体油脂含量高达76.1%,脂肪得率系数可达22.7。     

Optimization of medium compositions favoring butanol and 1,3-propanediol production from glycerol by Clostridium pasteurianum

Medium compositions favoring butanol and 1,3-propanediol (1,3-PDO) production from glycerol by Clostridium pasteurianum DSM525 were investigated using statistical experimental designs. Medium components affecting butanol and 1,3-PDO production were screened using a fractional factorial experimental design. Among the six tested variables (phosphate buffer, MnSO4·H2O, MgSO4·7H2O, FeSO4·7H2O, (NH4)2SO4, and yeast extract), FeSO4·7H2O, (NH4)2SO4, and yeast extract were found to be significant variables for further optimization of medium using a Box-Behnken design. Optimal butanol (0.98 g/L/h) and 1,3-PDO (1.19 g/L/h) productivities were predicted by the corresponding quadratic model for each product and the models were validated experimentally under optimized conditions. The optimal medium composition for butanol production was significantly different from that for 1,3-PDO production (0.06 vs. 0 g/L for FeSO4·7H2O, 7.35 vs. 0 g/L for (NH4)2SO4, and 5.08 vs. 8.0 g/L for yeast extract), suggesting that the product formation from glycerol by C. pasteurianum DSM525 can be controlled by changing medium compositions.     

产γ-谷氨基甲酰胺合成酶菌株的筛选及产酶条件研究

以假单胞菌(Pseudomonas sp.)为出发菌株,通过紫外诱变筛选得到一株γ-谷氨基甲酰胺合成酶高产菌株UV-19,其酶活提高32.54%。以突变株UV-19为供试菌株,对γ-谷氨基甲酰胺合成酶的发酵条件进行优化。首先利用Plackett-Burman设计筛选出影响较大的4个因素:葡萄糖、蛋白胨、起始pH值、装液量。在此基础上再利用CCD响应面分析法进行优化,得到最佳产酶培养条件为(g/L):葡萄糖15、蛋白胨12、NaCl 5.0、MgSO4.7H2O 0.2、K2HPO4.3H2O 0.5、甲胺盐酸盐1.0g/L、起始pH值6.5、装液量72mL/250mL。该优化条件下进行产酶培养,假单胞菌发酵产γ-谷氨基甲酰胺合成酶酶活力可达32.68U/mL。     

Enhanced antibiotic activity of Xenorhabdus nematophila by medium optimization

Nutrition had highly influence on the antibiotic production by Xenorhabdus nematophila YL001. Glucose and peptone were identified as the best carbon and nitrogen sources that significantly affected antibiotic production using one-factor-at-a-time approach. Response surface methodology was applied to optimize the medium constituents (Glucose, peptone and minerals) for antibiotic production by X. nematophila YL001. Higher antibiotic activity (328.9 U/ml) was obtained after optimizing medium components. The optimal levels of medium components were (g/l): glucose 6.13, peptone 21.29, MgSO(4).7H(2)O 1.50, (NH(4))(2)SO(4) 2.46, KH(2)PO(4) 0.86, K(2)HPO(4) 1.11 and Na(2)SO(4) 1.72. An overall 16% and 35% increase in antibiotic activity were obtained as compared with mean observed response (283.7U/ml) at zero level of all variables and YSG medium.     

低温脂肪酶产生菌的筛选、产酶发酵及粗酶性质研究

利用含有Tween 80的琼脂平板和摇瓶发酵法,从若尔盖高原土壤中筛选产脂肪酶菌株.通过菌落形态和菌体特征观察初步对菌种进行鉴定,得到一株产低温脂肪酶的适冷菌Pseudomonassp.DL-B,并设计正交试验对该菌株的产酶发酵培养条件进行了优化.摇瓶实验表明,该菌株最适产酶发酵培养基为:蔗糖10 g/L,蛋白胨20 ...