Cloning, expression, and characterization of a xylanase 10 from Aspergillus terreus (BCC129) in Pichia pastoris

A full-length xylanase gene, encoding 326 amino acids belonging to the fungal glycosyl hydrolase family 10, from Aspergillus terreus BCC129 was cloned and sequenced. Sequence analysis suggested that the first 25 amino acids of this enzyme is the signal peptide. Therefore, only the mature xylanase gene of 906 bp was cloned into a yeast expression vector, pPICZalphaA, for heterologous expression in Pichia pastoris. A band of approximately, 33 kDa was observed on the SDS-PAGE gel after one day of methanol induction. The expressed enzyme was purified by gel filtration chromatography. The purified recombinant xylanase demonstrated optimal activity at 60 degrees C, pH 5.0 and a Km of 4.8 +/- 0.07 mg/ml and a Vmax of 757 +/- 14.54 micromol/min mg, using birchwood xylan as a substrate. Additionally, the purified enzyme demonstrated broad pH stability from 4 to 10 when incubated at 40 degrees C for 4 h. It also showed a moderate thermal stability since it retained 90% of its activity when incubated at 50 degrees C, 30 min, making this enzyme a potential use in the animal feed and paper and pulp industries.     

Purification and characterization of a new xylanase from Acrophialophora nainiana

A new xylanase activity (XynII) was isolated from liquid state cultures of Acrophialophora nainiana containing birchwood xylan as carbon source. XynII was purified to apparent homogeneity by gel filtration and ion exchange chromatographies. The enzyme was optimally active at 55 degrees C and pH 7.0. XynII had molecular mass of 22630+/-3.0 and 22165 Da, as determined by mass spectrometry and SDS-PAGE, respectively. The purified enzyme was able to act only on xylan as substrate. The apparent K(m) values on soluble and insoluble birchwood xylans were 40.9 and 16.1 mg ml(-1), respectively. The enzyme showed good thermal stability with half lives of 44 h at 55 degrees C and ca. 1 h at 60 degrees C The N-terminal sequence of XynII showed homology with a xylanase grouped in family G/11. The enzyme did not show amino acid composition similarity with xylanases from some fungi and Bacillus amyloliquefaciens.     

Purification and properties of xylanase A from alkali-tolerant Bacillus sp. strain BP-23.

Xylanase A from the recently isolated Bacillus sp. strain BP-23 was purified to homogeneity. The enzyme shows a molecular mass of 32 kDa and an isoelectric point of 9.3. Optimum temperature and pH for xylanase activity were 50 degrees C and 5.5 respectively. Xylanase A was completely inhibited by N-bromosuccinimide. The main products of birchwood xylan hydrolysis were xylotetraose and xylobiose. The enzyme was shown to facilitate chemical bleaching of pulp, generating savings of 38% in terms of chlorine dioxide consumption. The amino-terminal sequence of xylanase A has a conserved sequence of five amino acids found in xylanases from family F.     

Isolation, purification and characterization of xylanasefrom Staphylococcus sp. SG-13 and its application in biobleaching of kraft pulp

A haloalkalophilic Staphylococcus sp. SG-13 produced an alkalistable xylanase in wheat bran medium. A 12-fold purification was achieved by using standard purification techniques. The purified xylanase exhibited a dual pH optima of 7.5 and 9.2. The optimum temperature for enzyme activity was 50 degrees C. The enzyme was stable at 50 degrees C for more than 4 h. The xylanase exhibited Km and Vmax values of 4 mg ml-1, 90 micromol min-1 per mg for birchwood xylan and 7 mg ml-1, 55 micromol min-1 per mg for oatspelt xylan, respectively. The substrate binding affinity of xylanase was more for oatspelt xylan but birchwood xylan was hydrolysed more rapidly. The xylanase activity was stimulated by Fe2+, Ni2+, Cu2+ and dithiothreitol up to 60% and was strongly inhibited in the presence of Co2+, Hg2+, Pb2+, phenyl methane sulphonyl fluoride, ethylenediaminetetraacetic acid, and acetic anhydride up to 100%. The xylanase dose of 1.8 U g-1 moisture free pulp, exhibited bleach boosting of kraft pulps optimally at pH 9.5-10.0 and 50 degrees C after 4 h of reaction time. Pretreatment of pulp with xylanase and its subsequent treatment with 8% hypochlorite, reduced the kappa number by 30%, enhanced the brightness and viscosity by 11% and 1.8%, respectively, and improved the paper properties such as tensile strength and burst factor up to 10% and 17%, respectively.     

Purification, characterization and partial amino acid sequences of a xylanase produced by Penicillium chrysogenum.

An extracellular xylanase (1,4-beta-D-xylan xylanohydrolase, EC 3.2.1.8, endo 1,4-beta-xylanase) was found to be the major protein in the culture filtrate of Penicillium chrysogenum when grown on 1% xylan. In contrast to other microorganism no xylanase multiplicity was found in P. chrysogenum under the conditions used. This enzyme was purified to homogeneity by high performance anion-exchange and size-exclusion chromatography. It had an M(r) of 35,000 as estimated by SDS-PAGE and was shown to be active as a monomer. No glycosylation of the protein could be detected neither by a sensitive glycostain nor by enzymatic deglycosylation studies. The enzyme hydrolyzed oat spelt and birchwood xylan randomly, yielding xylose and xylobiose as major end products. It had no cellulase, CMCase, beta-xylosidase or arabinogalactanase activity but acted on p-nitrophenylcellobioside. The pH and temperature optima for its activity were pH 6.0 and 40 degrees C, respectively. Eight peptides obtained after endoproteinase LysC digestion of xylanase have been sequenced, six of them showed considerable amino acid similarity to glucanases and high M(r)/acidic xylanases from different bacteria, yeasts and fungi.     

Purification and characterization of a new xylanase (APX-II) from the fungus Aureobasidium pullulans Y-2311-1.

Aureobasidium pullulans Y-2311-1 produced four major xylanases (EC 3.2.1.8) with pI values of 4.0, 7.3, 7.9, and 9.4 as revealed by isoelectric focusing and zymogram analysis when grown for 4 days on 1.0% oat spelt xylan. The enzyme with a pI of 9.4 was purified by ammonium sulfate precipitation, chromatography on a DEAE-Sephadex A-50 column, and gel filtration with a Sephadex G-75 column. The enzyme had a mass of about 25 kDa as determined by both sodium dodecyl sulfate-polyacrylamide gel electrophoresis and gel filtration chromatography. The purified enzyme had a Km of 7.6 mg . ml(-1) and Vmax of 2,650 micromol . min(-1) . mg(-1) for birchwood xylan at 28 degrees C and pH 4.5. It lacked activity towards carboxymethylcellulose, cellobiose, starch, mannan, p-nitrophenyl (pNP)-beta-D-xylopyranoside, pNP-beta-D-glucopyranoside, pNP-alpha-D-glucopyranoside, pNP-beta-D-cellobioside, pNP-beta-D-fucopyranoside, or pNP-alpha-D-galactopyranoside. The predominant end products of birchwood xylan or xylohexaose hydrolysis were xylobiose and xylose. The enzyme had the highest activity of pH 4.8 and 54 degrees C. Sixty percent of the activity remained after the enzyme had been incubated at 55 degrees C and pH 4.5 for 30 min. The sequence of the first 68 amino acid residues at the amino terminus showed homology to those of several other xylonases. Immunoblot analysis with antiserum raised against the purified xylanase revealed that two immunologically related polypeptides of 25 and 22 kDa were produced in A. pullulans cultures containing oat spelt xylan or xylose as carbon sources but not in cultures containing glycerol or glucose.     

Purification and some properties of an alkaline xylanase from alkaliphilic Bacillus sp. strain 41M-1.

An alkaliphilic Bacillus sp. strain, 41M-1, isolated from soil produced multiple xylanases extracellularly. One of these xylanases was purified to homogeneity by ammonium sulfate fractionation and anion-exchange chromatography. The moleculr mass of this enzyme (xylanase J) was 36 kDa, and the isoelectric point was pH 5.3. Xylanase J was most active at pH 9.0. The optimum temperature for the activity at pH 9.0 was around 50 degrees C. The enzyme was stable up to 55 degrees C at pH 9.0 for 30 min. Xylanase J was completely inhibited by the Hg2+ion and N-bromosuccinimide. The predominant products of xylan hydrolysate were xylobiose, xylotriose, and higher oligosaccharides, indicating that the enzyme was an endoxylanase. The apparent Km and Vmax values on xylan were 3.3 mg/ml and 1,100 micromol-1 mg-1, respectively. Xylanase J showed high sequence homology with the xylanases from Bacillus pumilus and Clostridium acetobutylicum in the N-terminal region. Xylanase J acted on neither crystalline cellulose nor carboxymethyl cellulose, indicating a possible application of the enzyme in biobleaching processes.     

Thermostable, alkalophilic and cellulase free xylanase production by Thermoactinomyces thalophilus subgroup C

Thermoactinomyces thalophilus produced cellulase free extracellular endo-1,4-beta-xylanase (EC 3.2.1.8) at 50 degrees C and pH 8.5. Maximum xylanase production was achieved in fermentation medium using birchwood xylan as substrate after 96 h of growth at 50 degrees C. Other agricultural substrates such as wheat bran, wheat straw, sugarcane bagasse and cornstover produced less xylanase. The crude enzyme preparation from mutant T. thalophilus P2 grown under optimised fermentation conditions showed no cellulase contamination and maximum xylanase activity of 42 U/ml at 65%deg;C and pH 8.5-9.0. This enzyme with initial xylanase activity of 42 U/ml was found thermostable up to 65 degrees C and retaining 50% of its activity after its incubation for 125 min at 65 degrees C.     

Biochemical characterization,cloning and molecular modeling of a detergent and organic solvent-stable family 11 xylanase from the newly isolated Aspergillus niger US368 strain

New β-1,4-d-xylan xylanohydrolase (XAn11) belonging to the xylanase 11 family was purified to homogeneity from a newly soil-isolated Aspergillus niger US368 strain. The pure xylanase is a glycosylated monomer having a molecular mass of about 26 kDa. The N-terminal sequence of the purified enzyme was determined and compared to some Aspergillus xylanases N-terminal ones. The gene encoding the XAn11 was cloned and sequenced.The maximal xylanase activity was obtained at pH 5.0 and 55 °C. The XAn11 was found to be stable in a wide range of pH (3–9) and in presence of some detergents and organic solvents. A specific activity of about 805.6 U/mg or 334 U/mg was measured using birchwood xylan or oatspelt xylan as substrate, respectively. A structural explanation of the difference between experimental and theoretical molecular mass as well as the stability of the enzyme against acidic pH was proposed by molecular modeling.     

Purification and characterization of xylanases from<Emphasis Type="Italic">Aspergillus giganteus</Emphasis>

A strain of Aspergillus giganteus cultivated in a medium with xylan produced two xylanases (xylanase I and II) which were purified to homogeneity. Their molar mass, estimated by SDS-PAGE, were 21 and 24 kDa, respectively. Both enzymes are glycoproteins with 50 degrees C temperature optimum; optimum pH was 6.0-6.5 for xylanase I and 6.0 for xylanase II. At 50 degrees C xylanase I exhibited higher thermostability than xylanase II. Hg2+, Cu2+ and SDS were strong inhibitors, 1,4-dithiothreitol stimulated the reaction of both enzymes. Both xylanases are xylan-specific; kinetic parameters indicated higher efficiency in the hydrolysis of oat spelts xylan. In hydrolysis of this substrate, xylotriose, xylotetraose and larger xylooligosaccharides were released and hence the enzymes were classified as endoxylanases.     

A Bifunctional Endoglucanase/Endoxylanase from <Emphasis Type="Italic">Cellulomonas flavigena</Emphasis> with Potential Use in Industrial Processes at Different pH

Cellulomonas flavigena CDBB-531 was found to secrete a bifunctional cellulase/xylanase with a molecular mass of 49 kDa and pI 4.3. This enzyme was active on Remazol brilliant blue-carboxymethylcellulose (RBB-CMC) and Remazol brilliant blue-xylan (RBB-X). Based on thin-layer chromatographic analysis of the degradation products, the cellulase activity produced glucose, cellobiose, cellotriose, and cellotetraose from CMC as the substrate. When xylan from birchwood was used, end products were xylose, arabinose, and xylobiose. The bifunctional enzyme showed a pH optimum of 6 for cellulase activity and 9 for xylanase activity, which pointed out that this enzyme had separate sites for each activity. In both cases, the apparent optimum temperature was 50 degrees C. The predicted amino acid sequence of purified protein showed similarity with the catalytic domain of several glycosyl hydrolases of family 10.     

Fusion of family 2b carbohydrate-binding module increases the catalytic activity of a xylanase from Thermotoga maritima to soluble xylan

A family 2b carbohydrate-binding module from Streptomyces thermoviolaceus STX-II was fused at the carboxyl-terminus of XynB, a thermostable and single domain family 10 xylanase from Thermotoga maritima, to create a chimeric xylanase. The chimeric enzyme (XynB-CBM2b) was purified and characterized. It displayed a pH-activity profile similar to that of XynB and was stable up to 90 degrees C. XynB-CBM2b bound to insoluble birchwood and oatspelt xylan. Whereas its hydrolytic activities toward insoluble xylan and p-nitrophenyl-beta-xylopyranoside were similar to those of XynB, its activity toward soluble xylan was moderately higher than that of XynB.     

Purification and characterization of a family G/11 beta-xylanase from Streptomyces olivaceoviridis E-86

A beta-xylanase (GXYN) was purified from the culture filtrate of Streptomyces olivaceoviridis E-86 by successive chromatography on DE-52, CM-Sepharose and Superose 12. The molecular mass of the xylanase was estimated to be 23 kDa, indicating that the enzyme consists of a catalytic domain only. The enzyme displayed an optimum pH of 6, a temperature optimum of 60 degrees C, a pH stability range from 2 to 11 and thermal stability up to 40 degrees C. The N-terminal amino acid sequence of GXYN was A-T-V-I-T-T-N-Q-T-G-T-N-N-G-I-Y-Y-S-F-W-, and sharing a high degree of similarity with the N-terminal sequence of xylanases B and C from Streptomyces lividans, indicating GXYN belongs to family G/11 of glycoside hydrolases. GXYN was inferior to xylanase B from Streptomyces lividans in the hydrolysis of insoluble xylan because of its lack of a xylan binding domain.     

Optimisation of culture medium and conditions for alpha-l-Arabinofuranosidase production by the extreme thermophilic eubacterium Rhodothermus marinus

The culture medium for Rhodothermus marinus was optimised on a shake-flask scale by using statistical factorial designs for enhanced production of a highly thermostable alpha-L-arabinofuranosidase (AFase). The medium containing 3.6 g/l birch wood xylan and 8.2 g/l yeast extract yielded a maximum of 110 nkat/ml AFase activity together with 125 nkat/ml xylanase and 65 nkat/ml beta-xylosidase activity. In addition, low levels of beta-mannanase (30 nkat/ml), alpha-galactosidase (0.2 nkat/ml), beta-galactosidase (0.3 nkat/ml), endoglucanase (5 nkat/ml) and beta-glucosidase (30 nkat/ml) were detected in the culture filtrate. Among the various carbon sources tested, birchwood xylan was most effective for the formation of AFase and xylanase activities, followed by oat spelt and beechwood xylans, and xylan-rich lignocelluoses (e.g., starch-free sugar beet pulp and wheat bran). Constitutive levels of enzyme activities were detected when the bacterium was grown on other polysaccharides and low-molecular-weight carbohydrates. A fermentation in a 5-l fermenter (3-l working volume) using the optimised medium yielded 60 nkat/ml AFase associated with 65 nkat/ml xylanase and 35 nkat/ml beta-xylosidase activities. The crude AFase displayed optimal activity between pH 5.5 and 7 and at 85 degrees C. It had half-lives of 8.3 h at 85 degrees C and 17 min at 90 degrees C. It showed high stability between pH 5 and 9 (24 h at 65 degrees C). The combined use of AFase-rich xylanase and mannanase from R. marinus in the prebleaching of softwood kraft pulp gave a brightness increase of 1.8% ISO. To our knowledge, this is the first report on the production of a high AFase activity by an extreme thermophilic bacterium and this enzyme is the most thermostable AFase reported so far.     

Cloning of <Emphasis Type="Italic">Bacillus licheniformis</Emphasis> Xylanase Gene and Characterization of Recombinant Enzyme

Hemicellulose is a major component of lignocellulose biomass. Complete degradation of this substrate requires several different enzymatic activities, including xylanase. We isolated a strain of Bacillus licheniformis from a hot springs environment that exhibited xylanase activity. A gene encoding a 23-kDa xylanase enzyme, Xyn11, was cloned, and the recombinant protein was expressed in an Escherichia coli host and biochemically characterized. The optimum activity of the enzyme was at pH 5-7 and 40-50 degrees C. The enzyme was stable at temperatures up to 50 degrees C. Against birchwood xylan, the enzyme had an apparent K ( m ) of 6.7 mg/mL and V (max) of 379 mumol/min/mg.     

Thermal stability of beta-xylanases produced by different Thermomyces lanuginosus strains

The thermostability of beta-xylanases produced by nine thermophilic Thermomyces lanuginosus strains in a coarse corn cob medium was assessed. The xylanase produced by T. lanuginosus strain SSBP retained 100% of its activity after 6 h at temperatures up to 65 degrees C. In comparison seven ATCC strains and the DSM 5826 strain of T. lanuginosus only retained 100% xylanase activity at temperatures up to 60 degrees C. Culture filtrates of T. lanuginosus strain SSBP grown on coarse corn cobs, oatspelts xylan, birchwood xylan, wheatbran, locust beangum, and sugar cane bagasse, retained 100% xylanase activity at temperatures up to 60 degrees C. The xylanase produced on corn cobs was the most thermostable and showed an increase of approximately 6% from 70 degrees C to 80 degrees C. The T(1/2) of all strains at 70 degrees C at pH 6.5 varied greatly from 63 min for strain ATCC 28083 to 340 min for strain SSBP. The xylanase of strain SSBP was much less thermostable at pH 5.0 and pH 12.0 with T(1/2) values of 11.5 min and 15 min, respectively at 70 degrees C. At 50 degrees C, the enzyme of T. lanuginosus strain SSBP produced on coarse corn cobs was stable within the pH range of 5.5-10.0. Furthermore, the enzyme retained total activity at 60 degrees C for over 14 days and at 65 degrees C for over 48 h. The xylanase of T. lanuginosus strain SSBP possesses thermo- and pH stability properties that may be attractive to industrial application.     

Purification and characterization of a moderately thermostable xylanase from Bacillus sp. strain SPS-0

A Bacillus spp. strain SPS-0, isolated from a hot spring in Portugal, produced an extracellular xylanase upon growth on wheat bran arabinoxylan. The enzyme was purified to homogeneity by ammonium sulfate precipitation, anion exchange, gel filtration, and affinity chromatography. The optimum temperature and pH for activity was 75 degrees C and 6.0. Xylanase was stable up to 70 degrees C for 4 h at pH 6.0 in the presence of xylane. Xylanase was completely inhibited by the Hg(2+) ions. beta-Mercaptoethanol, dithiothreitol, and Mn(2+) stimulated the xylanase activity. The products of birchwood xylan hydrolysis were xylose, xylobiose, xylotriose, and xylotetraose. Kinetic experiments at 60 degrees C and pH 6.0 gave V(max) and K(m)values of 2420 nkat/mg and 0.7 mg/ml.     

Production, characterization, and partial amino acid sequence of xylanase A from Schizophyllum commune.

Xylanase A, one of several extracellular xylanases produced by Schizophyllum commune strain Delmar when grown in submerged culture with spruce sawdust as carbon source, was purified 43-fold in 25% yield with respect to total xylanase activity. Although some polysaccharide was strongly bound to the purified enzyme, the complex could be dissociated by sodium dodecyl sulfate and appeared homogeneous on sodium dodecyl sulfate-polyacrylamide gel electrophoresis. The molecular weight of the protein, calculated from the electrophoretic mobility, was 33,000. The molecular activity of the purified xylanase A, determined with soluble larch xylan as substrate, was 1.4 X 10(5) min-1, with xylobiose and xylose as the major products. The enzyme had a pH optimum of 5.0 and a temperature optimum of 55 degrees C in 10-min assays. The acid hydrolysate of xylanase A was rich in aspartic acid and aromatic amino acids. The sequence of 27 residues at the amino terminus showed no homology with known sequences of other proteins.     

Production, characterization, and partial amino acid sequence of xylanase A from Schizophyllum commune.

Xylanase A, one of several extracellular xylanases produced by Schizophyllum commune strain Delmar when grown in submerged culture with spruce sawdust as carbon source, was purified 43-fold in 25% yield with respect to total xylanase activity. Although some polysaccharide was strongly bound to the purified enzyme, the complex could be dissociated by sodium dodecyl sulfate and appeared homogeneous on sodium dodecyl sulfate-polyacrylamide gel electrophoresis. The molecular weight of the protein, calculated from the electrophoretic mobility, was 33,000. The molecular activity of the purified xylanase A, determined with soluble larch xylan as substrate, was 1.4 X 10(5) min-1, with xylobiose and xylose as the major products. The enzyme had a pH optimum of 5.0 and a temperature optimum of 55 degrees C in 10-min assays. The acid hydrolysate of xylanase A was rich in aspartic acid and aromatic amino acids. The sequence of 27 residues at the amino terminus showed no homology with known sequences of other proteins.     

Isolation, purification, and characterization of a thermostable xylanase from a novel strain, Paenibacillus campinasensis G1-1

High levels of xylanase activity (143.98 IU/ml) produced by the newly isolated Paenibacillus campinasensis G1-1 were detected when it was cultivated in a synthetic medium. A thermostable xylanase, designated XynG1-1, from P. campinasensis G1-1 was purified to homogeneity by Octyl-Sepharose hydrophobic-interaction chromatography, Sephadex G75 gel-filter chromatography, and Q-Sepharose ion-exchange chromatography, consecutively. By multistep purification, the specific activity of XynG1-1 was up to 1,865.5 IU/mg with a 9.1-fold purification. The molecular mass of purified XynG1-1 was about 41.3 kDa as estimated by sodium dodecyl sulfate polyacrylamide gel electrophoresis (SDS-PAGE). Sequence analysis revealed that XynG1-1 containing 377 amino acids encoded by 1,134 bp genomic sequences of P. campinasensis G1-1 shared 96% homology with XylX from Paenibacillus campinasensis BL11 and 77%~78% homology with xylanases from Bacillus sp. YA- 335 and Bacillus sp. 41M-1, respectively. The activity of XynG1-1 was stimulated by Ca2+, Ba2+, DTT, and beta- mercaptoethanol, but was inhibited by Ni2+, Fe2+, Fe3+, Zn2+, SDS, and EDTA. The purified XynG1-1 displayed a greater affinity for birchwood xylan, with an optimal temperature of 60 degrees C and an optimal pH of 7.5. The fact that XynG1-1 is cellulose-free, thermostable (stability at high temperature of 70 degrees C~80 degrees C), and active over a wide pH range (pH 5.0~9.0) suggests that the enzyme is potentially valuable for various industrial applications, especially for pulp bleaching pretreatment.