Patterns and quantities of NH(3), N(2)O and CH(4) emissions during swine manure composting without forced aeration--effect of compost pile scale

To evaluate the NH(3), N(2)O, and CH(4) emissions from composting of livestock waste without forced aeration in turned piles, and to investigate the possible relationship between the scale of the compost pile and gas emission rates, we conducted swine manure composting experiments in parallel on small- and large-scale compost piles. Continuous measurements of gas emissions during composting were carried out using a chamber system, and detailed gas emission patterns were obtained. The total amount of each gas emission was computed from the amount of ventilation and gas concentration. NH(3) emission was observed in the early period of composting when the material was at a high temperature. Sharp peaks in CH(4) emission occurred immediately after swine manure was piled up, although a high emissions level continued after the first turning only in the large-scale pile. N(2)O emissions started around the middle stage of the composting period when NH(3) emissions and the temperature of the compost material began to decline. The emission rates of each gas in the small and large piles were 112.8 and 127.4 g NH(3)-N/kg T-N, 37.2 and 46.5 g N(2)O-N/kg T-N, and 1.0 and 1.9 g CH(4)/kg OM, respectively. It was found that changing the piling scale of the compost material was a major factor in gas emission rates.     

城市污泥强制通风堆肥过程中的生物学和化学变化特征

采用间竭式强制通风堆肥法进行的肥堆体积约4m3,堆肥时间为53d的污泥堆肥试验表明,堆肥的第2天即达高温阶段(≥55℃)并能保持8d,平均最高温度达68℃,局部温度达74℃.粪大肠杆菌由开始时的1.41×105个·g-1降至试验结束时的2.32×101个·g-1.污泥堆肥过程中挥发性固体,总有机C、水溶性有机C、固体有机 C/N比和水溶性有机 C/有机 N比下降明显,而 N、P及重金属含量有所升高.随着堆肥的进程,在前1周堆肥过程中产生的氨氮大幅下降,硝酸盐含量随之升高.相应地,pH在第1周内升高,随后降低.堆肥40d左右,水芹(Lepidiumsativum L.)种子发芽指数即可达 80%.综合堆肥过程中堆温和化学与生物学变化特点,表明污泥堆肥在40d左右基本上接近腐熟,50d后达到完全腐熟.产品外观呈黑褐色,蓬松,无明显异味.     

两种微生物菌剂对西番莲果渣高温堆肥腐熟进程的影响

研究了在西番莲果渣堆肥体系中加入两种微生物菌剂（福贝和榕风）后的温度、C／N、NH4^＋ -N和NO3^- -N的动态变化及对西番莲果渣堆肥产品品质的影响．结果表明,在西番莲果渣中加入微生物菌剂能增加高温分解持续时间,加快物料C／N降低的速率,促进NH4^＋ -N向NO3^- -N转化,加快西番莲果渣堆肥腐熟化进程．添加福贝和榕风菌剂后,堆肥高温持续时间分别比对照（4d）增加7d和8d;腐熟后堆肥的NO3^- -N浓度分别比对照增加58．0％和64．2％．添加菌种显著增加了西番莲果渣堆肥的N、P、K养分含量,降低了堆肥容重,提高了堆肥总孔隙度和持水孔隙度,改善了堆肥产品的品质．两种菌剂间对西番莲果渣高温腐熟进程的影响没有显著差异,但福贝菌剂更有利于改善堆肥品质．     

Thermophilic methane production from cattle waste.

Methane production from waste of cattle fed a finishing diet was investigated, using four 3-liter-working volume anaerobic digestors at 60 degrees C. At 55 degrees C a start-up culture, in which waste was the only source of bacteria, was generated within 8 days and readily adapted to 60 degrees C, where efficiency of methanogenesis was greater. Increasing the temperature from 60 to 65 degrees C tended to drastically lower efficiency. When feed concentrations of volatile solids (VS, organic matter) were increased in steps of 2% after holding for 1 months at a given concentration, the maximum concentrations for efficient fermentation were 8.2, 10.0, 11.6, and 11.6% for the retention times (RT) of 3, 6, 9, and 12 days, respectively. The VS destructions for these and lower feed concentrations were 31 to 37, 36 to 40, 47 to 49 and 51 to 53% for the 3-, 6-, 9-, and 12-day RT digestors, respectively, and the corresponding methane production rates were about 0.16, 0.18, 0.20, and 0.22 liters/day per g of VS in the feed. Gas contained 52 to 57% methane. At the above RT and feed concentrations, alkalinity rose to 5,000 to 7,700 mg of CaCo3 per liter (pH to 7.5 to 7.8), NH3 plus NH4+ to 64 to 90 mM, and total volatile acids to 850 to 2,050 mg/liter as acetate. The 3-day RT digestor was quite stable up to 8.2% feed VS and at this feed concentration produced methane at the very high rate of 4.5 liters/day per liter of digestor. Increasing the percentage of feed VS beyond those values indicated above resulted in greatly decreased organic matter destruction and methane production, variable decrease in pH, and increased alkalinity, ammonia, and total volatile acid concentrations, with propionate being the first to accumulate in large amounts. In a second experiment with another lot of waste, the results were similar. These studies indicate that loading rates can be much higher than those previously thought useful for maximizing methanogenesis from cattle waste.     

Thermophilic methane production from cattle waste

Methane production from waste of cattle fed a finishing diet was investigated, using four 3-liter-working volume anaerobic digestors at 60 degrees C. At 55 degrees C a start-up culture, in which waste was the only source of bacteria, was generated within 8 days and readily adapted to 60 degrees C, where efficiency of methanogenesis was greater. Increasing the temperature from 60 to 65 degrees C tended to drastically lower efficiency. When feed concentrations of volatile solids (VS, organic matter) were increased in steps of 2% after holding for 1 months at a given concentration, the maximum concentrations for efficient fermentation were 8.2, 10.0, 11.6, and 11.6% for the retention times (RT) of 3, 6, 9, and 12 days, respectively. The VS destructions for these and lower feed concentrations were 31 to 37, 36 to 40, 47 to 49 and 51 to 53% for the 3-, 6-, 9-, and 12-day RT digestors, respectively, and the corresponding methane production rates were about 0.16, 0.18, 0.20, and 0.22 liters/day per g of VS in the feed. Gas contained 52 to 57% methane. At the above RT and feed concentrations, alkalinity rose to 5,000 to 7,700 mg of CaCo3 per liter (pH to 7.5 to 7.8), NH3 plus NH4+ to 64 to 90 mM, and total volatile acids to 850 to 2,050 mg/liter as acetate. The 3-day RT digestor was quite stable up to 8.2% feed VS and at this feed concentration produced methane at the very high rate of 4.5 liters/day per liter of digestor. Increasing the percentage of feed VS beyond those values indicated above resulted in greatly decreased organic matter destruction and methane production, variable decrease in pH, and increased alkalinity, ammonia, and total volatile acid concentrations, with propionate being the first to accumulate in large amounts. In a second experiment with another lot of waste, the results were similar. These studies indicate that loading rates can be much higher than those previously thought useful for maximizing methanogenesis from cattle waste.     

Survival of a Shiga toxin-encoding bacteriophage in a compost model

Bacteriophages that carry the Shiga toxin gene (stx) represent an additional hazard in cattle manure-based fertilizers in that their survival could lead to toxigenic conversion of Escherichia coli and other bacteria post-composting. A Stx-phage in which the Shiga toxin (stx(2)) gene was inactivated by insertion of a chloramphenicol resistance gene was used in combination with a rifampicin-resistant E. coli host where RecA is constitutively activated so that all infectious phage particles could be enumerated by plaque assay. PCR-based confirmation methods and the additional application of a host enrichment protocol ensured that very low numbers of surviving bacteriophage could be detected and unequivocally identified. Stx-bacteriophage numbers declined rapidly over the first 48 h and none could be detected after 3 days. The host enrichment method was applied after 6 days and no bacteriophages were recovered. While addition of fresh E. coli cells at intervals after the compost temperature had reduced below 40 degrees C demonstrated that E. coli growth could be supported in the compost, Stx-phages or their lysogens were never detected. Here, we demonstrate that composting animal manure for 40 days during which a temperature of >60 degrees C is maintained for at least 5 days is effective at removing both E. coli and a model infectious Stx-encoding bacteriophage.     

Co-composting of filter cake and bagasse; by-products from a sugar mill

Thailand has nearly 2 million tonnes of filter cake waste containing 1.8% total N from the sugar cane industry to dispose of annually. Compost studies were conducted to determine how rapidly this material can be converted to a stable product that may be useful in crop production, and to characterize the N transformations. Two kinds of sugar mill by-products were composted, filter cake and filter cake mixed with bagasse, at a 2:1 ratio to reduce the C:N ratio in an attempt to reduce N loss during composting. Materials were mixed manually at 3-5 day intervals during the composting process. Both composts were analyzed at least weekly to measure temperature, pH, NH4+, NO3-, total N content, C loss, and germination index. For both mixtures, the thermophilic stage lasted 15-20 days and was higher than ambient for nearly 80 days. The degradation of organic matter (OM) was rapid in both mixtures to approximately 40 days, after which it began to stabilize. Both mixtures achieved maturity at approximately 90 days as indicated by a stable C/N, low NH4+/NO3-, lack of heat production and a germination index higher than 80%. Mixing filter cake with bagasse helped conserve N during composting. Because N was in excess, approximately 12-15% was lost from the composts. Mixing more bagasse with the filter cake may result in further reduction in N losses. Both composts have potential for use in crop production.     

Methods to improve the composting process of the solid fraction of dairy cattle slurry

Cattle slurry solid fraction (SF) with different dry matter (DM) contents was collected from two dairy farms and composted in static and turned piles, with different sizes and cover types, to investigate the effects of pile conditions on the physical and chemical changes in SF during composting and to identify approaches to improve final compost quality. Thermophilic temperatures were attained soon after separation of SF, but the temperature of piles covered with polyethylene did not increase above 60 degrees C. The rate of organic matter (OM) mineralisation increased for turned piles in comparison to static piles, but the maximum amount of mineralisable OM (630-675gkg(-1)) was similar for all pile treatments. The C/N ratio declined from over 36 to a value of 14 towards the end of composting, indicating an advanced degree of OM stabilisation. Mature compost was obtained from raw SF feedstock as indicated by the low compost temperature, low C/N ratio, and low content of NH(4)(+) combined with increased concentrations of NO(3)(-). The efficiency of the composting process was improved and NH(3)-N losses were minimized by increasing DM content of the SF, reducing the frequency of pile turning and managing compost piles without an impermeable cover.     

Compost convective airflow under passive aeration

For composting, passive aeration can save energy costs while being just as efficient as forced or active aeration. Passive aeration requires the proper design of aeration ducts, and thus, the proper prediction of the convective airflow rates created by the temperature differential between the compost and the ambient air. To establish such relationship, the temperature and convective air flow regimes of composts were investigated using three bulking agents (wood shavings, hay and straw), each at three moisture contents (MC-60%, 65% and 70%) spanning the normal values. All bulking agent and aeration treatments were aerated in duplicate under passive and active regimes. Laboratory vessels of 105 L were used for all treatments. Passive aeration treatments produced temperatures above 57 degrees C, as did the treatments actively aerated at 4 mg of air s(-1) kg(-1) of initial dry compost material. Compost MC had an effect only on the peak compost temperature, occurring between day 2 and 6. After 6 days of composting, MC no longer had any effect on temperature regime because of the loss of moisture by each mixture. A relationship was established between the Grasholf number (Gr-ratio of buoyancy to viscous forces) and the convective airflow rates, to size the aeration ducts for passive aeration. In general, convective airflow rates ranged from 1.5 to 0.7 mg of dry air s(-1) kg(-1) of initial compost dry matter, from day 0 to day 20, respectively, and for all compost treatments. This airflow rate sizes the aeration ducts installed under compost piles for passive aeration. As compared to straw where airflow rate dropped over a given level of Gr, wood shavings and hay were found to be more effective as bulking agents, as their airflow rate increased constantly with Gr.     

Bioremediation of leachate from a green waste composting facility using waste-derived filter media

The evaluation of two waste-derived materials used to treat compost leachate by biofiltration is described in this paper. Nine biofilters were constructed using 240 l, high density polyethylene containers. Three containers were filled without compaction with 200l of each of three types of filter media. Waste-derived filter media (compost and oversize) were compared to a mineral control (granite chips). The filters were fed with compost leachate from a typical green waste composting facility at hydraulic loading rates ranging from 0.05 m3/m3/day to 0.5 m3/m3/day over a period of twelve months. The oversize medium emerged as the most effective demonstrating characteristics of consistency of effluent quality and resilience to stress. The oversize medium produced an effluent of <10mg/l ammoniacal nitrogen on >95% of sampling occasions. The organic component of compost leachate was dominated by compounds that proved to be recalcitrant to biodegradation. The solids content of the treated effluent remained too high to be acceptable for direct discharge to a watercourse without further treatment and if discharge to a watercourse is to be considered, a polishing stage (e.g., reed bed) able to remove solids and dampen occasional peaks of ammoniacal nitrogen should be employed.     

Do earthworms affect dynamics of functional response and genetic structure of microbial community in a lab-scale composting system?

Two laboratory-scale systems were set up (i) composting (without earthworms) and (ii) vermicomposting (with earthworms) and were monitored for 60 days after pre-composting. The physico-chemical parameters (pH, C/N, organic matter, NH(4)(+)-N and ash content) showed similar evolution in both systems except a higher NH(4)(+)-N in the initial vermicomposts. However, principle component analysis (PCA) of enzymatic activities and community level physiological profiles revealed differences in the functional response of microbial communities in compost and vermicompost during maturation. Dehydrogenase activity and bacterial counts indicated a steady decrease in biological activity and population during composting, whereas vermicomposting exhibited higher activity on day 30 and a reduction in bacterial counts on day 10. PCA of denatured gradient gel electrophoresis (DGGE) profiles showed divergent dynamics of bacterial communities in two processes. These results indicated differences in the functional response and genetic structure of microbial community in composts and vermicomposts despite similar changes in their physico-chemical parameters.     

Application of PVA-derived porous media to accelerate biodegradation (composting) of organic solid substrates

Poly(vinyl alcohol) (PVA)-derived cubes with fine pores and high water-binding and microbial adhesion capacities, enhanced the biodegradation of organic solid substrates with the temperature of the mixture increasing to over 65°C on the second day and being maintained ~60°C for the following 3 days, averaging at least 15°C higher than the control. The amount of CO₂ evolved also reflected a higher level of biodegradation. The compost made with PVA porous cubes for 2 weeks improved lettuce cultivation and crop losses decreased by at least 10% compared with the control. Thus PVA porous cubes can facilitate the production of mature compost for plants.     

Determining thermal inactivation of Escherichia coli O157:H7 in fresh compost by simulating early phases of the composting process

A three-strain mixture of Escherichia coli O157:H7 was inoculated into fresh dairy compost (ca. 10(7) CFU/g) with 40 or 50% moisture and was placed in an environmental chamber (ca. 70% humidity) that was programmed to ramp from room temperature to selected composting temperatures in 2 and 5 days to simulate the early composting phase. The surviving E. coli O157:H7 population was analyzed by direct plating and enrichment. Optimal and suboptimal compost mixes, with carbon/nitrogen (C/N) ratios of 25:1 and 16:1, respectively, were compared in this study. In the optimal compost mix, E. coli O157:H7 survived for 72, 48, and 24 h in compost with 40% moisture and for 72, 24, and 24 h with 50% moisture at 50, 55, and 60°C, respectively, following 2 days of come-up time (rate of heating up). However, in the suboptimal compost mix, the pathogen survived for 288, 72, and 48 h in compost with 40% moisture and for 240, 72, 24 h in compost with 50% moisture at the same temperatures, respectively. Pathogen survival was longer, with 5 days of come-up time compared with 2 days of come-up. Overall, E. coli O157:H7 was inactivated faster in the compost with 50% moisture than in the compost with 40% at 55 and 60°C. Both moisture and come-up time were significant factors affecting Weibull model parameters. Our results suggest that slow come-up time at the beginning of composting can extend pathogen survival during composting. Additionally, both the C/N ratio and the initial moisture level in the compost mix affect the rate of pathogen inactivation as well.     

The effect of inoculation with Selenophoma donacis at different growth stages on spring barley cultivars

A technique used for 3 yr to produce 15 000–20 000 nematode-free adult Megaselia halterata/v/k is described and its potential for future mass-production of nematode-parasitised flies, for use in biological control, is assessed. Gravid female phorids preferred to oviposit in compost in which mushroom mycelium had grown for 7–12 days. At 20 ± 1 °C flies began to emerge 24 days after adults of the previous generation had been released on the compost. By day28, 88% of the total population had emerged. In laboratory experiments using different densities of parental flies, fly yield per female was highest when 200 flies infested each 1 kg of compost. At higher densities, competition between larvae affected survival of larvae and pupae, and probably resulted in the mean egg content of emerging flies being reduced by as much as 16-4%. Theoretically, 250 kg compost should yield 1 150 000 phorids.     

Composting of olive leaves and pomace from a three-phase olive mill plant

The composting of olive leaves and olive pomace from a three-phase olive mill was tested as a method for solid waste reuse. The process was carried out using a compost windrow and mixing olive leaves and pomace at a ratio of 1:2. Compost was retained in the windrow for 60 days during which thermophilic temperatures developed for the first 40 days. The compost was then placed into a closed area to mature for another 60 days. The final product proved to be high quality amendment with C/N 27.1 and high nutrient concentrations (N, 1.79%; P, 0.17%; K, 4.97%; Na, 2.8%). Mature compost presented the highest germination index (198%) reported to date, as the germination index in the majority of previous studies is under 80%. Furthermore, tests revealed that addition of 31.5 tons of compost per ha, could increase lettuce yield by 145%.     

Accelerated coffee pulp composting

The effect of two abundant, easily available and very low-cost agro-industrial organic residues, i.e., filter cake from the sugar industry and poultry litter, on the composting stabilization time of coffee pulp and on the quality of the produced compost, was evaluated. Piles of one cubic meter were built and monitored within the facilities of a coffee processing plant in the Coatepec region of the State of Veracruz, Mexico. Manual aeration was carried out once a week. A longer thermophilic period (28 days) and a much lower C/N ratio (in the range of 6.9–9.1) were observed in the piles containing the amendments, as compared to the control pile containing only coffee pulp (14 days and a C/N ratio of 14.4, respectively). The maximum assimilation rate of the reducing sugars was 1.6 g kg-1 d-1 (from 7.5 to 5.3%) during the first two weeks when accelerators were present in the proportion of 20% filter cake plus 20% poultry litter, while they accumulated at a rate of 1.2 g kg-1 d-1 (from 7.4 to 9.13%) during the same period in the control pile. The best combination of amendments was 30% filter cake with 20% poultry litter, resulting in a final nitrogen content as high as 4.81%. The second best combination was 20% filter cake with 10% poultry litter, resulting in a compost which also contained a high level of total nitrogen (4.54%). It was concluded that the use of these two residues enhanced the composting process of coffee pulp, promoting a shorter stabilization period and yielding a higher quality of compost.     

Growth of ammonia-oxidizing archaea and bacteria in cattle manure compost under various temperatures and ammonia concentrations

A recent study showed that ammonia-oxidizing bacteria (AOB) and ammonia-oxidizing archaea (AOA) coexist in the process of cattle manure composting. To investigate their physiological characteristics, liquid cultures seeded with fermenting cattle manure compost were incubated at various temperatures (37°C, 46°C, or 60°C) and ammonium concentrations (0.5, 1, 4, or 10?mM NH (4) (+) -N). The growth rates of the AOB and AOA were monitored using real-time polymerase chain reaction analysis targeting the bacterial and archaeal ammonia monooxygenase subunit A genes. AOB grew at 37°C and 4 or 10?mM NH (4) (+) -N, whereas AOA grew at 46°C and 10?mM NH (4) (+) -N. Incubation with allylthiourea indicated that the AOB and AOA grew by oxidizing ammonia. Denaturing gradient gel electrophoresis and subsequent sequencing analyses revealed that a bacterium related to Nitrosomonas halophila and an archaeon related to Candidatus Nitrososphaera gargensis were the predominant AOB and AOA, respectively, in the seed compost and in cultures after incubation. This is the first report to demonstrate that the predominant AOA in cattle manure compost can grow and can probably oxidize ammonia under moderately thermophilic conditions.     

Co-Composting of Soil Heavily Contaminated with Creosote with Cattle Manure and Vegetable Waste for the Bioremediation of Creosote–Contaminated Soil

Mispah form (FAO: Lithosol) soil contaminated with >380 000 mg kg^?1 creosote was co-composted with cattle manure and mixed vegetable waste for 19 months. The soil was mixed with wood chips to improve aeration and then mixed with cattle manure or mixed vegetable waste in a ratio of 4:1. Moisture, temperature, pH, ash content, C:N ratios, and the concentrations of creosote in the compost systems were monitored monthly. The concentrations of selected hydrocarbons in the compost systems were determined at the end of composting. Temperature rose to about 45°C in the cattle manure compost within two months of incubation while temperature in the control and vegetable waste remained below 30°C until the fourth month. Creosote concentration was reduced by 17% in the control and by more than 99% in the cattle manure and vegetable waste compost after composting. The rate of reduction in concentration in the mixed vegetable waste compost was initially lower than in the cattle manure compost. The reduction rate became similar in later months with only small differences towards the end of the composting. The concentrations of selected creosote components were reduced by between 96% and 100% after composting. There was no significant difference in reduction in concentration in both compost systems at p 0.05. Microbial activity correlated with reduction in creosote concentration.     

Phosphorus removal in pilot plant using biofilm filter process from farm wastewater

Various environmental conditions affecting total phosphorus removal from farm wastewater in a biofilm filter, process were investigated using loess balls andChromobacterium LEE-38 at a pilot plant. WhenChromobacterium LEE-38 was used, the removal efficiency of total phosphorous was approximately 10- or 5-fold higher than that ofAcinetobacter CHA-2-14 orAcinetobacter CHA-4-5, respectively. When a loess ball of 11–14 mm manufactured at a 960°C calcining temperature was used, the removal efficiency of total phosphorous was 90.0%. When 70% of the volume fraction was used, the maximum efficiency of total phosphorus removal was 93.1%. Notably, when the initial pH was in the range of 6.0 to 8.0, the maximum removal efficiency of total phosphorus was obtained after 30 days. When the operating temperature was in the range of 30 to 55°C, the maximum removal efficiencies of total phosphorus, 95.6 to 94.6%, were obtained. On the other hand, at operating temperatures below 20°C or above 40°C, the removal efficiency of total phosphorous decreased. Among the various processes, biofilm filter process A gave the highest removal efficiency of 96.4%. Pilot tests of total phosphorus removal using farm wastewater from the biofilm filter process A were carried out for 60 days under optimal condition. WhenAcinetobacters sp. Lee-11 was used, the average removal efficiency in thep-adsorption area was only 32.5%, and the removal efficiencies of chemical oxygen demand (COD) and biological oxygen demand (BOD) were 56.7 and 62.5%, respectively. On the other hand, whenChromobacterium LEE-38 was used, the average removal efficiency was 95.1%, and the removal efficiencies of COD and BOD were 91.3 and 93.2%, respectively. The first two authors contributed equally to this work.     

The effect of iprodione on seed germination and seedling emergence in onion

Iprodione seed treatment at 100 g a.i./kg seed had little effect on final emergence in peat-based compost at 60% moisture content (wet weight basis) but caused up to 1.5 days' delay in the time to 50% of the final emergence (t₅₀). The effect was independent of initial seed viability, the conditions and duration of seed storage after treatment and germination temperature. Raising the compost moisture content to 70% resulted in a 9% reduction in final emergence and a 3 day increase in t₅₀. Iprodione had a greater effect in a filter paper test, reducing final emergence by up to 24% and increasing t₅₀; the effects were again independent of initial seed viability and storage conditions.