植酸酶固体发酵条件的研究

黑曲霉Ｇ２．１．１．１．４菌株在产生植酸酶时受无机磷的反馈阻遏,并且植酸酶的产生与淀粉酶的产生存在相互抑制。对植酸菌固体发酵进行调控和通过响应面分析优化发酵条件,提高了植酸酶产量。最适发酵条件下,植酸酶（ＰｈｙｔＡ）的产量可达６２．１ｕ／ｇ．干基。     

产植酸酶菌株的分离筛选研究

研究了产植酸酶菌株分离筛选的方法 ,筛选得到分别适宜液态发酵和固态发酵的酶活力较高的黑曲霉XH和黑曲霉PA两菌株。在液态发酵KH2 PO4 对植酸酶产生有促进作用 ,其最佳用量为 8mg %;在固态发酵KH2 PO4 的添加对植酸酶的产生无明显促进作用。 2菌株所产植酸酶具有相似的酶学性质 ,最适作用温度为 5 5℃ ,当底物 pH为 3～ 5具有较高的酶活力。     

低温植酸酶菌株Y1的发酵条件研究

目的:提高低温植酸酶产量.方法:通过单因素和正交实验研究温度、pH、发酵时间、接种量、装液量对菌株Y1的发酵影响.结果:最适发酵条件为温度15℃,pH 5.0,发酵时间24h,接种量10%,装液量200ml/500ml.其最终酶活力达到了162.39U/mL.结论:经单因素和正交实验研究后其低温植酸酶酶活力比优化前提高了29.43%.     

青霉LQ-7植酸酶产生条件研究

筛选到一株植酸酶高产菌株 ,对其进行诱变并研究了该菌株产植酸酶的最适条件。优化产酶液体培养基组成为 :3%可溶性淀粉 ,0 5 %蛋白胨 ,0 5 %NH4NO3 ,0 0 5 %MgSO4·7H2 O ,0 0 5 %FeSO4·7H2 O ,0 0 0 1%MnSO4·4H2 O ;发酵培养基的起始pH为 6 5 ,接种量 4%的条件下 30℃ ,135r min培养 72h可获得较高的植酸酶产量。少量 (2 5mg)植酸盐的加入对植酸酶有促进作用 ,但过量 (10mg以上 )时则会产生抑制作用。     

通过参数相关性分析对发酵控制策略在植酸酶高密度发酵中的作用探讨

为了优化植酸酶高密度发酵条件,有必要获取在发酵过程中由于控制策略引起有关参数的实时变化及其关联性。本研究利用传感器对植酸酶工程菌高密度发酵过程进行数据在线采集,通过改变转速、接种量与补料甘油,探讨三方面控制因素对高密度发酵产酶过程参数具体影响及各参数变化之间的相关性,建立起与转速-细胞密度-溶氧-乳酸相关的发酵罐内外环境氧控制关系,细胞密度-氧气吸收-二氧化碳释放相关的细胞生长氧控制关系,以及细胞密度-二氧化碳释放-pH变化-蛋白表达的细胞诱导表达的关系。基于参数相关性分析并优化发酵控制条件得到:当搅拌转速递增,植酸酶工程菌接种量为10%时,其生长迟滞期最短(20 h)且发酵末期诱导表达植酸酶酶活可达3037.98 U/mL,相较摇瓶优化发酵的酶活提高了176.18%。本文研究结果可为工业植酸酶高效生产提供参考。     

灵芝深层发酵生产四环三萜酸的研究

从灵芝深层发酵产物中分离得到三种四环三萜酸,命名为灵芝酸Ｍ１,Ｍ２,Ｍ３,在２５Ｌ发酵罐上研究了发酵条件对灵芝酸产量的影响,以及灵芝酸的代谢形成特征。结果表明最适发酵条件是：温度３０℃;通风量１：０．７５ｖ／ｖ／ｍ;搅拌转速１８０ｒ／ｍｉｎ;发酵时间８０ｈ,此时灵芝酸的最高产量是０．３６ｇ／Ｌ发酵液。抑菌实验表明上述灵芝酸能够抑制大肠杆菌,产气杆菌、肠炎杆菌、金黄色葡萄球菌和枯草芽孢杆菌的生长。     

植酸酶产生菌的选育及固态产酶条件研究

植酸酶催化植酸,并将其盐类水解成肌醇和磷酸,因此植酸酶的使用可以提高植酸磷的吸收利用率,降低饲料成本,同时还可保护生态环境.经分离和亚硝基胍诱变选育,得到一株植酸酶高产菌株绿色木霉LH374,并对该菌株固态发酵产植酸酶的条件和扩大生产进行了研究.结果表明,固态发酵的最佳条件:稻草和米糠的比例为8:2,培养基起始pH为6.5,最适温度为30℃,最适培养时间为96 h,含水量为60%,硫酸铵的流加量为2%.绿色木霉LH37在上述最适条件下生产植酸酶平均可达1 580 U·g^-1.     

文摘

产植酸酶的黑曲霉菌株筛选及其植酸酶基因克隆［中］／姚斌…／／农业生物技术学报．－１９９８,６（１）．－１～６从土壤中筛选到产植酸酶的黑曲霉菌株Ａｓｐｅｒｇｉｌｕｓｎｉｇｅｒ９６３,对其所产植酸酶的生理生化性质研究表明具有适合于在饲料中使用的优良性质...     

来源于Escherichia coli的高比活植酸酶基因的高效表达

高效表达高比活植酸酶是进一步提高植酸酶发酵效价、降低植酸酶生产成本的一个有效途径。对源于Escherichiacoli的高比活植酸酶基因appA ,按照毕赤酵母 (Pichiapastoris)密码子的偏爱进行了密码子优化改造。该改造后的基因appA m按正确的阅读框架融合到毕赤酵母表达载体pPIC9上的α 因子信号肽编码序列 3′端 ,通过电击转化得到重组转化子。对重组毕赤酵母的Southernblotting分析证实植酸酶基因已整合到酵母基因组中 ,并确定了整合基因的拷贝数。Northernblotting分析证实植酸酶基因得到了正常转录。SDS PAGE分析和表达产物的研究表明 ,植酸酶得到了高效分泌表达 ,在 5L发酵罐中植酸酶蛋白表达量达到 2 5mg mL发酵液 ,酶活性 (发酵效价 )达到 7 5× 10 6 IU mL发酵液以上 ,大大高于目前报道的各种植酸酶基因工程菌株的发酵效价。     

表面展示表达植酸酶的重组酿酒酵母构建及酒精发酵

以淀粉为原料的同步糖化发酵是目前乙醇生产的主要途径之一。然而原料中含有的植酸不仅影响酒精发酵效率,而且也会导致环境中难以被植物吸收的磷含量的增加,加剧环境污染。将来源于大肠杆菌的植酸酶基因与酵母编码α-凝集素C端编码序列连接并置于α-因子分泌信号肽下游,构建植酸酶表面展示表达重组载体pMGK-AG-phy并转化工业酿酒酵母,成功获得了在细胞表面锚定表达植酸酶的重组菌PHY。重组酵母的植酸酶表达水平达到6.4 U/g(菌体湿重),其最适温度为55℃,最适pH 4.0,在pH 3.5–4.5范围内具有较高的活性。以玉米粉为原料的同步糖化发酵实验表明,重组酵母PHY的生长速度高于出发菌株,同时酒精产量相较于出发菌株提高了3.7%。更为重要的是发酵后酒糟中植酸磷含量与对照相比降低了91%。构建的表面展示表达植酸酶的重组工业酿酒酵母能够有效降低植酸含量,提高了酒糟的利用价值,减少磷排放,对燃料酒精的环境友好生产具有重要的借鉴意义。     

植物植酸酶及其在饲料中的应用前景

植物植酸酶不但能分解内源植酸磷 ,对外源植酸磷同样有明显的降解作用。在饲粮中添加植酸酶活性高的植物性饲料 ,可提高猪和家禽对植酸磷的利用率 ,降低粪便中磷的排泄量 ,提高生产性能。麦类籽实中具有较高的天然植酸酶活性 ,发芽能显著提高种子中植酸酶的活性 ,因而有希望通过发芽提高麦类籽实中的植酸酶活性 ,经提纯浓缩后可达到在实际生产中应用的水平 ,从而减少在饲料中添加无机磷或价格昂贵的微生物植酸酶。     

A marked enhancement in phytase production by a thermophilic mould Sporotrichum thermophile using statistical designs in a cost-effective cane molasses medium

AIMS: Statistical optimization of phytase production by a thermophilic mould Sporotrichum thermophile in a cost-effective cane molasses medium. METHODS AND RESULTS: Sporotrichum thermophile secreted phytase in cane molasses medium at 45 degrees C and 250 rev min(-1) after 5 days. The important factors identified by Plackett-Burman design (magnesium sulfate, Tween 80, ammonium sulfate and incubation period) were further optimized by response surface methodology (RSM). An overall 107% improvement in phytase production was achieved due to optimization. Supplementation of the medium with inorganic phosphate repressed the enzyme synthesis. When inorganic phosphate was reduced from the cane molasses medium by treatment with calcium chloride, the enzyme production increased. The phytase activity was not affected by the enzyme treatment with trypsin and pepsin. CONCLUSIONS: A twofold increase in phytase production was achieved due to optimization using statistical designs in a cost-effective cane molasses medium. SIGNIFICANCE AND IMPACT OF THE STUDY: Phytase production was doubled due to optimization. The enzyme, being resistant to trypsin and pepsin, thermostable and acid stable, can find application in animal feed industry for improving nutritional status of the feed and combating environmental phosphorus pollution.     

Screening of fungi for phytase production

Over 200 fungal strains were screened for phytase production using a two-step procedure. The best strain, an Aspergillus sp., produced phytase almost equally active at both pH 5.0 and 2.5. Synthesis of the enzyme was limited by content of inorganic phosphorus above 20mg/dm.     

Pigs expressing salivary phytase produce low-phosphorus manure

To address the problem of manure-based environmental pollution in the pork industry, we have developed the phytase transgenic pig. The saliva of these pigs contains the enzyme phytase, which allows the pigs to digest the phosphorus in phytate, the most abundant source of phosphorus in the pig diet. Without this enzyme, phytate phosphorus passes undigested into manure to become the single most important manure pollutant of pork production. We show here that salivary phytase provides essentially complete digestion of dietary phytate phosphorus, relieves the requirement for inorganic phosphate supplements, and reduces fecal phosphorus output by up to 75%. These pigs offer a unique biological approach to the management of phosphorus nutrition and environmental pollution in the pork industry.     

Extracellular secretion of Aspergillus phytase from Arabidopsis roots enables plants to obtain phosphorus from phytate

Phosphorus (P) deficiency in soil is a major constraint for agricultural production worldwide. Despite this, most soils contain significant amounts of total soil P that occurs in inorganic and organic fractions and accumulates with phosphorus fertilization. A major component of soil organic phosphorus occurs as phytate. We show that when grown in agar under sterile conditions, Arabidopsis thaliana plants are able to obtain phosphorus from a range of organic phosphorus substrates that would be expected to occur in soil, but have only limited ability to obtain phosphorus directly from phytate. In wild-type plants, phytase constituted less than 0.8% of the total acid phosphomonoesterase activity of root extracts and was not detectable as an extracellular enzyme. By comparison, the growth and phosphorus nutrition of Arabidopsis plants supplied with phytate was improved significantly when the phytase gene (phyA) from Aspergillus niger was introduced. The Aspergillus phytase was only effective when secreted as an extracellular enzyme by inclusion of the signal peptide sequence from the carrot extensin (ex) gene. A 20-fold increase in total root phytase activity in transgenic lines expressing ex::phyA resulted in improved phosphorus nutrition, such that the growth and phosphorus content of the plants was equivalent to control plants supplied with inorganic phosphate. These results show that extracellular phytase activity of plant roots is a significant factor in the utilization of phosphorus from phytate and indicate that opportunity exists for using gene technology to improve the ability of plants to utilize accumulated forms of soil organic phosphorus.     

Phytase production byAspergillus ficuum on semisolid substrate

Summary Phytase production byAspergillus ficuum was studied using solid state cultivation on several cereal grains and legume seeds. The microbial phytase was used to hydrolyze the phytate in soybean meal and cotton seed meal. Wheat bran, soybean meal, cottonseed meal and corn meal supported good fungal growth and yielded a high level of phytase when an adequate amount of moisture was present. The level of phytase production on solid substrate was higher than that obtained by submerged liquid fermentation. Higher levels of phosphorus (more than 10 mg Pi/100 g substrate) in the growth medium (static culture) inhibited phytase synthesis, and the degree of phosphorus inhibition was less apparent in semisolid medium than in liquid medium. A static cultivation on semisolid substrate produced a higher level of phytase (2-20-fold) than that obtained by agitated cultivation. The minimal amount of water required for growth and enzyme production on those substrates was about 15%, while the optimum level for phytase production was between 25 and 35% and that for cell growth was above 50%. Optimum pH for phytase production was between 4 and 6.A ficuum grew well on raw (unheated) substrate containing a minimal amount of water and produced as much phytase as on heated substrate. About half of the phytic acid in soybean meal and cottonseed meal was hydrolyzed by treatment withA. ficuum phytase.     

植酸酶对斑点叉尾鲴生长性能及磷当量的研究

试验旨在研究饲料中添加植酸酶对斑点叉尾 [初始平均体重(1.70±0.04) g]生长性能及植酸磷利用的影响, 确定植酸酶的磷当量。试验采用单因素试验设计, 以 Ca(H2PO4)2提供外源无机磷, 同时添加不同浓度植酸酶, 试验设计为 10 个处理组, 分别为 1 个对照试验组、4 个无机磷试验组(0.3%、0.5%、0.8%、1.2%)和 5 个植酸酶试验组(300、500、1000、1500、2000 U/kg), 每个处理 3 个重复, 每个重复 30 尾鱼。通过折线模型确定植酸酶的最佳添加量; 通过回归分析, 建立响应指标(特定生长率、椎骨磷)与外源磷添加量之间的线性关系, 进而确定植酸酶的磷当量值。结果表明: (1)添加植酸酶的处理组与对照组相比, 增重率、特定生长率、蛋白质效率、肥满度均有显著提高(P<0.05), 饲料系数、肝体比、脏体比均有下降(P<0.05), 成活率各处理组没有显著差别(P>0.05); 鱼体粗蛋白、粗灰分、钙、磷及椎骨粗灰分、钙、磷均有显著提高(P<0.05), 鱼体粗脂肪含量有所下降。(2)无机磷添加水平与响应指标之间线性关系如下: Y1=0.2714X+2.294(X-无机磷, Y1-特定生长率, R2=0.9238), 300、500、1000、1500 和 2000 U/kg 植酸酶分别可替代 1 kg 饲料中 0.13%、0.57%、0.76%、1.46% 和 1.35% 的 磷 酸 二 氢 钙 , 等 效 于 添 加 了 0.03% 、 0.14% 、 0.19% 、 0.36% 和 0.33% 的 有 效 磷 ;Y2=0.8737X+5.1028(X-无机磷, Y2-椎骨磷, R2=0.9638), 300、500、1000、1500 和 2000 U/kg 植酸酶分别可替代1 kg 饲料中 0.47%、1.11%、1.18%、1.38%和 1.41%的磷酸二氢钙, 等效于添加了 0.12%、0.27%、0.29%、0.34%和 0.35%的有效磷。在试验条件下, 添加 1000―2000 U/kg 植酸酶能有效改善斑点叉尾 生长性能, 有利于营养物质在鱼体中的沉积, 促进骨骼矿化。以特定生长率为响应指标, 植酸酶最佳添加量为 1435 U/kg等效于添加了 0.37%的有效磷; 以椎骨磷为响应指标, 植酸酶最佳添加量为 1226 U/kg 等效于添加了 0.33%的有效磷。     

Phytate degradation by micro-organisms in synthetic media and pea flour

AIMS: To screen micro-organisms for the ability to produce phytase enzyme(s) and to use promising strains for the fermentation of pea flour. METHODS AND RESULTS: Two methods using the indirect estimation of phytate degradation were evaluated and both shown to be inadequate. A third method, measuring the inositol phosphate (IP3-IP6) content directly during fermentation, was used instead of the indirect estimations of phytate degradation. In synthetic media, some strains required customized conditions, with no accessible phosphorus sources other than phytate, to express phytase activity. The repression of phytase synthesis by inorganic phosphorus was not detected during fermentation with pea flour as substrate and seemed to be less significant with a higher composition complexity of the substrate. None of the tested lactic acid bacteria strains showed phytase activity. CONCLUSIONS: The methodology for the phytase screening procedure was shown to be critical. Some of the screening methods and media used in previous publications were found to be inadequate. SIGNIFICANCE AND IMPACT OF THE STUDY: This paper highlights the pitfalls and difficulties in the evaluation of phytase production by micro-organisms. The study is of great importance for future studies in this area.     

Phytase production by a thermophilic mould Sporotrichum thermophile in solid state fermentation and its potential applications

Phytase production by a thermophilic mould Sporotrichum thermophile Apinis was investigated in solid state fermentation (SSF) using sesame oil cake as the substrate. Scanning electron microscopy of the fermented sesame oil cake revealed a dense growth of the mould with abundant conidia. Glucose, ammonium sulphate and incubation period were identified as the most significant factors by Plackett-Burman design. The optimum values of the critical components determined by central composite design of response surface methodology for the maximum phytase production were glucose 3%, ammonium sulphate 0.5% and incubation period 120 h. An overall 2.6-fold improvement in phytase production was achieved due to optimization. Highest enzyme production (348.76 U/g DMR) was attained at a substrate bed depth of 1.5 cm in enamel coated metallic trays. The enzyme liberated inorganic phosphate from wheat flour and soymilk with concomitant dephytinization and liberation of soluble inorganic phosphate.