大孔吸附树脂对海边月见草总黄酮的吸附及解吸特性

通过比较3种大孔吸附树脂对海边月见草(O enothera littaralisSchlect.)总黄酮的吸附能力,选择了吸附量较大且易洗脱的树脂AB-8,研究了提取液浓度、pH值对该树脂静态吸附能力的影响,以及洗脱剂种类、乙醇浓度对动态解吸能力的影响。结果表明,AB-8树脂对海边月见草总黄酮有良好的吸附纯化性能,当原液浓度为1.076mg.mL-1时,树脂达饱和吸附量36.11 mg.g-1;提取液pH值对该树脂的吸附能力影响显著,pH值达4.0~4.5时树脂吸附量最大;用60%乙醇为洗脱剂,流速为1 mL.m in-1,总黄酮的动态洗脱率达83.41%,获得的总黄酮纯度为24.13%,得率3.54%;而30%乙醇(6倍柱床体积)和50%乙醇(6倍柱床体积)组合是最佳动态洗脱剂。     

HZ-841吸附树脂精制银杏叶总黄酮

本文研究了用HZ-841吸附树脂精制银杏叶总黄酮的工艺。用10 BV 70％的乙醇分三次提取脱脂银杏叶粉中的银杏叶总黄酮,其收得率为4．8％,纯度为21．7％;用30BV纯净水、微波解冻提取30min,银杏叶总黄酮的收得率及纯度分别是2．63％和13．4％。HZ-841树脂对银杏叶总黄酮的动态吸附容量在pH=7．0时为0．265g／mL,树脂,动态吸附平衡时间为10min。酸度对HZ-841树脂吸附银杏叶总黄酮有显著影响,当pH=5．0时,其静态吸附量可达到0．322g／mL。吸附了银杏叶总黄酮的HZ-841树脂可用乙醇洗脱,当洗脱液pH=9．0、乙醇浓度为90％、洗脱流速3BV／h时,5BV洗脱液的收得率为1．8％。用无水乙醇洗脱的银杏叶总黄酮经过真空浓缩、干燥,获得的浅黄色粉末中银杏叶总黄酮含量为37．3％,产品收得率为2．41％。     

从姜黄中提取姜黄素的研究

本文利用75％乙醇浸提姜黄得到姜黄素粗提物,然后分别采用吸附分离法和沉淀法对粗提物进一步分离提纯得到纯度较高的姜黄素产品。在吸附分离法提取姜黄素实验中,考察了不同洗脱剂组成对洗脱率的影响,实验发现90％乙醇洗脱效果最好;在沉淀法实验中,考察了不同pH值条件下的姜黄素沉淀量,发现pH值为7．0时,姜黄素沉淀量最大。实验结果表明,沉淀法得到的姜黄素产品纯度比吸附分离法得到的高,但沉淀法产品收率比吸附分离法低,吸附分离法比沉淀法更适合工业应用。     

桑椹中黄酮类物质的大孔树脂纯化工艺

以桑椹中黄酮类物质的吸附量和解吸率为指标,对比分析HZ-801、HZ-816、HZ-818等12种大孔吸附树脂对桑椹提取液的分离纯化效果,优选出最佳树脂HZ-801并通过对上样液pH、上样液质量浓度、上样量、吸附流速、洗脱剂质量浓度、洗脱剂用量、洗脱流速等影响因素的考察,确定最优工艺:吸附阶段上样液pH=4,上样液质量浓度0.45mg/mL,上样量420mL,吸附流速120mL/h,动态吸附量(干树脂)25.34mg/g,吸附率84.25%;洗脱阶段的洗脱剂体积分数为60%乙醇,洗脱剂用量270mL,洗脱流速120mL/h。此优化工艺条件下的洗脱率为85.78%,总黄酮纯度从23.64%提高到82.36%。     

AB-8大孔树脂吸附分离红花桑寄生总黄酮的影响因子研究

AB-8大孔吸附树脂对红花桑寄生总黄酮静态吸附和动态洗脱的效果,受提取液质量浓度、pH值及环境温度、振速以及洗脱剂乙醇浓度、流速等因素影响。试验表明,提取液质量浓度和pH值对AB-8树脂的吸附效果有显著影响,其吸附分离总黄酮的工艺条件为:浓度为1.2~2.0 mg/ml、pH 3.0~4.0的红花桑寄生提取液,置于摇床上,于室温条件下振荡(振速160 r/min)吸附2~3 h,然后用5倍于树脂体积(5BV)的50%乙醇以1.5 ml/min流速进行柱上动态解吸。AB-8树脂对红花桑寄生总黄酮的饱和吸附量可达29.0 mg/g,动态洗脱率达95.0%,获得产品中黄酮纯度为46.0%,得率为5.5%。     

AB-8型树脂对无患子皂苷的动态吸附与解吸性能

采用单因素实验法,以树脂的饱和吸附量、产品的得率及纯度为指标,考察各因素对动态吸附与解吸的影响,优化大孔树脂动态吸附分离无患子皂苷的工艺条件。结果表明,当pH为4.5的无患子皂苷水提液以流速1 mL/min通过高径比为5.4∶1的吸附柱时,AB-8树脂对无患子皂苷的饱和吸附量达568 mg/g;采用1.5 BV的95%乙醇以1 mL/min的流速洗脱吸附后的树脂,产品得率为83.48%、纯度达93.00%;树脂重复使用8次后其吸附解吸性能基本不变。该方法可以用于无患子皂苷的工业化分离提纯。     

吸附树脂AB—8对甘草酸的吸附性能及其在提取纯化中的应用

考察了大孔吸附树脂AB-8对甘草酸的吸附性能和原液浓度pH值、流速、洗脱剂的种类对树脂吸附性能的影响。结果表明,AB-8树脂对甘草酸吸附量高,易于洗脱,分离效果较好,回收率较一般方法高,达70％～80％,纯度达90％以上。     

大孔吸附树脂分离富集苜蓿皂甙的研究

本项工作以对苜蓿皂甙的吸附量和解吸率为指标筛选大孔吸附树脂。研究结果表明,X-5吸附树脂具有较好的吸附性能和解吸效果。研究应用正交试验方法进一步对大孔吸附树脂分离纯化苜蓿皂甙的工艺条件进行试验分析,确定苜蓿皂甙分离富集的最佳操作条件为:上样浓度8mg/mL,色谱柱的径高比1∶7,药材-树脂比例1∶3;吸附完全后,先以水洗脱,除去杂质,再以50%乙醇洗脱,可以得到纯度较好的苜蓿皂甙。     

大孔吸附树脂分离纯化番石榴叶总黄酮的研究

考察大孔吸附树脂吸附分离番石榴叶总黄酮的工艺条件.以静态饱和吸附量、静态洗脱率、动态饱和吸附量、动态洗脱率为考察指标,比较了D101、AB-8两种大孔树脂分离纯化番石榴叶总黄酮的优劣.又以总黄酮回收率为指标,对最佳树脂吸附工艺参数进行了研究.在考察的2种树脂中,AB-8型树脂最适于番石榴叶总黄酮的分离纯化,其工艺条件为:4倍树脂体积50%乙醇洗脱,速度2mL/min.树脂可重复使用4次.其平均总黄酮回收率为87.47%.所得总黄酮纯度为74.03%     

AB-8树脂对珍珠菜总黄酮的吸附性能研究

目的：考察AB-8树脂对珍珠菜提取液中总黄酮的吸附、解吸附性能及影响因素。方法：采用紫外分光光度法测定总黄酮的含量,分别考察了样品液浓度、pH值和流速对AB-8树脂吸附珍珠菜总黄酮的影响,以及洗脱剂乙醇浓度和流速对解吸附效果的影响。结果：样品液总黄酮浓度10mg／mL、pH值5．07、流速1．0mL／min时,AB-8树脂对珍珠菜总黄酮的吸附效果较好;洗脱剂为70％乙醇,流速1．5mL／min时,洗脱完全,固体总黄酮含量较高。结论：在上述条件下,AB-8树脂可用于珍珠菜提取液中总黄酮的分离纯化。     

Routine manufacture of recombinant proteins using expanded bed adsorption chromatography

Two different recombinant human proteins were purified directly from Pichia pastoris whole cell fermentation broth, containing 30–44% biomass (wet weight percent), by strong cation exchange expanded bed adsorption chromatography. Expanded bed adsorption chromatography provided clarification, product purification and product concentration in a single unit operation at large scale (2000-l nominal fermentation volume). The efficiency of expanded bed adsorption chromatography resulted in a short process time, high process yield, and limited proteolytic degradation of the target proteins. The separations were operated using a 60-cm (d) column run at 14 l/min. For one protein, expanded bed adsorption chromatography resulted in an average product recovery of 113% (relative to fermentation supernatant) and a purity of 89% (n=10). For the other protein, the average product recovery was 99% (relative to fermentation supernatant) and the purity was 62.1 (n=10). Laboratory experiments showed that biomass reduced product dynamic binding capacity for protein 2.     

扩张柱床吸附层析回收纯化灌流培养生产的单克隆抗体

用扩张柱床吸附层析技术,一步回收纯化连续灌流培养的单克隆抗体。用Streamline SP阳离子交换介质在固定床柱XK16/20上进行条件摸索,扩张床柱Streamline25和50分别用于小规模条件优化和中试规模放大。培养液中的低浓度单抗经此步处理,浓缩10倍以上,纯度提高5～7倍,回收率＞90%,制备周期比固定柱床层析缩短一半以上。 根据培养液中单抗浓度的不同,一次处理量为18～50L,纯化规模由实验室水平（400mg）扩大至中试水平（2g）,生产成本和工艺复杂性大为降低。应用扩张柱床吸附层析技术,建立单克隆抗体回收纯化工艺,具有经济、简便、高效实用和良好的可放大性。     

Purification of the two major proteins from whey concentrate using a cation‐exchange selective adsorption process

The packed‐bed adsorption and elution of aqueous solutions of whey concentrate powders were investigated at pH 3.7 using a 5‐mL SP Sepharose FF column to separate and isolate two major proteins namely, α‐lactalbumin (ALA) and β‐lactoglobulin (BLG) from these solutions. ALA displaced and eluted BLG from the column in a pure form. Pure ALA could then be eluted with good recovery. A novel consecutive two‐stage separation process was developed to separate ALA and BLG from whey concentrate mixtures. Almost all of the BLG in the feed was recovered, with 78% being recovered at 95% purity and a further 20% at 86% purity. In addition, 67% of ALA was recovered, 48% at 54% purity and 19% at 60% purity. © 2009 American Institute of Chemical Engineers Biotechnol. Prog., 2010     

大孔吸附树脂柱层析分离淫羊藿甙的研究

本文通过考察八种大孔吸附树脂对淫羊藿甙的吸附分离性能,筛选出了AB-8树脂作为分离纯化淫羊藿甙的介质。对该树脂的吸附性能研究表明其对浸提物中的淫羊藿甙有良好的吸附选择性,静态饱和吸附容量和动态吸附容量分别为22．97和16．20mg／mL。通过柱层析实验确定了AB-8树脂分离淫羊藿甙的工艺,经一步层析可将淫羊藿甙的纯度从2．78％提高到27％,回收率达97．3％。     

Purification of human IgG by negative chromatography on ω-aminohexyl-agarose

The ω-aminohexyl diamine immobilized as ligand on CNBr- and bisoxirane-activated agarose gel was evaluated for the purification of human immunoglobulin G (IgG) from serum and plasma by negative affinity chromatography. The effects of matrix activation, buffer system, and feedstream on recovery and purity of IgG were studied. A one-step purification process using Hepes buffer at pH 6.8 allowed a similar recovery (69–76%) of the loaded IgG in the nonretained fractions for both matrices, but the purity was higher for epoxy-activated gel (electrophoretically homogeneous protein with a 6.5-fold purification). The IgG and human serum albumin (HSA) adsorption equilibrium studies showed that the adsorption isotherms of IgG and HSA obeyed the Langmuir–Freundlich and Langmuir models, respectively. The binding capacity of HSA was high (210.4 mg mL^?1 of gel) and a positive cooperativity was observed for IgG binding. These results indicate that immobilizing ω-aminohexyl using bisoxirane as coupling agent is a useful strategy for rapid purification of IgG from human serum and plasma.     

Improving the recovery of clarification process of recombinant hepatitis B surface antigen in large-scale by optimizing adsorption-desorption parameters on Aerosil-380

Abstract

In the downstream process of recombinant hepatitis B surface antigen (rHBsAg), nano-colloidal silica adsorbent (Aerosil-380) is one of the possible methods to separate the antigen from other main impurities partially. The current study aimed to maximize the adsorptive capacity of Aerosil-380 as well as rHBsAg recovery for large-scale production of recombinant hepatitis B vaccine. The experimental design methodology was used to optimize the eight critical parameters influencing the efficiency, rHBsAg recovery, of the adsorption-desorption process in the lab-scale. These examined parameters were the adsorption–desorption temperature, pH, contact time, agitation speed, antigen concentration, and desorption buffer. Under optimal condition, the maximum adsorption capacity of Aerosil-380 was equal to 3333?μg.g^?1 (rHBsAg/adsorbent), and we could recover about 95% of rHBsAg with purity of 54% (rHBsAg/total protein) in the lab scale. Using the optimum parameters for rHBsAg clarification process in large-scale by Aerosil-380, we recovered about 78% of rHBsAg with 43% purity. Based on the obtained experimental data, Langmuir adsorption isotherm and pseudo-first-order kinetic model provide the best correlations of experimental data for the adsorbent. Findings of this study significantly increase the recovery of clarification process of rHBsAg in large-scale compared to previous reports.     

Bacillus amyloliquefaciens ES-2发酵产抗菌脂肽消泡剂的筛选及脂肽的提取和纯化

将大豆油、有机硅消泡剂和聚醚类消泡剂3种消泡剂分别用于Bacillus amyloliquefaciens ES-2抗菌脂肽发酵,研究表明大豆油既可以实现消泡,又有利于抗菌脂肽的发酵,使其产量达到了2497.67mg/L。经过提取得到纯度为55.68%的产品,提取率达到88.72%。此外还比较了不同大孔树脂对抗菌脂肽吸附和解吸附效果,发现大孔树脂X-5最适合抗菌脂肽的纯化。纯化的工艺参数为:上样浓度14.4mg/ml、上样速率1ml/min,洗脱速率2ml/min、洗脱剂用量2.5BV,产品的回收率达90.01%,纯度达74.4%。     

Lipase purification by affinity precipitation with a thermo-responsive polymer immobilized Cibacron Blue F3GA ligand

A thermo-responsive polymer (P_NNB) was synthesized with lower critical solution temperature 27.5°C and over 95% recovery. The adsorption of porcine pancreatic lipase on Cibacron Blue F3GA-conjugated P_NNB (P_NNB-CB) closely followed the bi-Langmuir adsorption isotherm. The maximum adsorption capacity was found at pH 5.0, with a ligand density of 18.4 μmol/g polymers. The optimized eluent was a 0.01 M phosphate buffer solution at pH 8.0 containing 20% ethylene glycol. Six adsorptiondesorption recycles indicated excellent reusability of the affinity adsorbent. P_NNB-CB was applied to separate porcine pancreatic lipase from its crude material giving a lipase activity recovery of 81.6% with a 16-fold purification factor. Lipase could be purified to single-band purity, according to gel electrophoresis. The purification strategy is therefore feasible and efficient for purifying proteins of interest.