氮源对L-苏氨酸发酵的影响

以L-苏氨酸生产菌TRFC为供试菌株,研究了氮源对L-苏氨酸发酵的产量和糖酸转化率的影响。首先通过摇瓶实验确定发酵的最佳无机氮源和有机氮源分别为硫酸铵和酵母粉,进一步利用10L罐补料分批发酵确定硫酸铵和酵母粉的最佳用量,继续优化培养条件,采用发酵中后期流加硫酸铵和糖氨混合补料等措施,L-苏氨酸产量得到进一步的提高。在最优发酵条件下,通过10L罐补料分批发酵36h,产酸可达118.9g/L,糖酸转化率为47.6%。     

柞树林下菌根真菌对碳、氮营养的利用

研究了柞树林下菌根真菌对Ｃ、Ｎ营养的利用状况．结果表明,供试菌种对Ｃ源的利用较为广泛,葡萄糖、果糖为其最适碳源,平均生长量比对照高出４．４倍;供试菌种对有机氮的利用优于无机氮,平均生长量比无机氮源高出１．６倍,硝态无机氮源中平均生长量为对照的２．５倍,对铵态氮的利用较差,平均生长量仅为对照的２．２倍     

樟芝对氮素营养源利用的研究

采用 5种不同的氮素营养源 ,配制合成液体培养基 ,测定各种氮源对樟芝菌丝液体深层培养的影响。结果表明 ,樟芝对 5种氮源的利用表现明显的差异性 ,对有机氮利用较好 ,尤其是酵母膏 ,无论是菌球数量还是菌体收率均高于蛋白胨。酵母膏的菌球数量达 1 2 5 8个 /dL,比蛋白胨多出 63 8个 ;菌体干重为 7 2 1 6g/dL比蛋白胨高出 1 45 0g/dL。樟芝对无机氮的利用不如有机氮 ,其中对硫酸铵能够利用 ,而对硝酸铵的利用较差 ,对碳酸铵基本不能利用。樟芝菌丝在液体深层培养过程中 ,pH值变化幅度不大 ,基本处于平缓状态。有机氮处理的发酵液起始pH值与终止pH值呈上升趋势 ,而无机氮处理的发酵液pH值呈下降趋势 ,但下降的幅度不大 ,尤其是碳酸铵 ,pH值一直处于偏碱性状态 ,不适合樟芝菌丝的生长。樟芝在马铃薯基础培养基中 ,不同氮源的各个处理 ,菌球生长都比较均匀 ,表面光滑 ,没有分枝 ,圆形或肾形 ,且发酵液有浓郁的果香味。     

铁尾矿区油松根际溶磷泛菌D2的筛选鉴定及溶磷特性

从河北省迁安市马兰庄镇铁尾矿植被恢复区油松根际分离出2株溶磷细菌,经过平板初筛和摇瓶复筛得到1株溶磷能力较强的菌株D2.通过菌落形态、生理生化特性及16S rDNA序列分析,确定此菌株D2属于泛菌属.利用液体发酵试验测定不同碳源、氮源对菌株D2溶磷能力的影响,通过高效液相色谱测定D2在不同氮源条件下产生有机酸的种类和浓度.结果表明:菌株D2对磷酸三钙有较强的溶磷能力,培养液有效磷含量最高为392.13 mg·L^-1,菌株D2的溶磷能力在碳源为葡萄糖、氮源为硫酸铵时效果最好;高效液相色谱测定发现,不同氮源条件下,D2分泌有机酸的种类和浓度存在差异,以硫酸铵、氯化铵、硝酸钾、硝酸钠、硝酸铵为氮源,均产生草酸、甲酸、乙酸和柠檬酸,以硫酸铵、氯化铵、硝酸铵为氮源还产生苹果酸.相关性分析表明,乙酸含量与有效磷含量间呈显著正相关(r=0.886,P<0.05),表明溶磷泛菌D2分泌的乙酸对无机磷的溶解有明显的促进作用,这也很可能是该菌株的重要溶磷机制之一.     

营养要素对原油降解菌生长的影响

目的:研究营养要素对原油降解菌生长的影响.方法:通过紫外分光光度计于600nm处测量菌体OD值检测6种碳源、5种氮源、无机离子含量和氯化钠含量对原油降解菌K5生长的影响.通过正交实验确定了原油降解菌K5生长的最佳营养条件.结果:当蔗糖含量0.6%、硫酸铵含量0.2%、氯化钠含量0.6%、微量元素含量0.1%时,原油降解菌生长得最好.结论:确定了原油降解菌K5生长的最佳营养条件,并且发现了培养基中的氮源和碳源对菌体生长量的影响最大以及不同微量元素对菌体生长量有不同程度的促进或抑制作用.     

氮源对灵芝菌丝体液态深层发酵合成灵芝三萜的影响

以沪农灵芝1号为供试菌株,葡萄糖作为碳源,用硫酸铵、氯化铵、鱼粉蛋白胨、胰蛋白胨和酵母粉作为氮源,研究不同种类氮源对灵芝菌丝体液态深层发酵过程的影响。首先,确定了N-10酵母自溶粉作为发酵的氮源,降低了发酵的复杂性和不确定性;其次,考察N-10酵母自溶粉不同浓度对灵芝菌丝体发酵合成灵芝三萜过程中菌丝体的生物量、葡萄糖消耗、灵芝三萜产量等方面的影响,确定了N-10酵母自溶粉的适宜添加浓度。在此基础上,采用响应面中心组合设计,对4因素最佳水平范围进行研究,结果表明,葡萄糖、N-10酵母自溶粉、磷酸二氢钾和七水硫酸镁的含量分别为31.06g/L、2.76g/L、1.77g/L和1.99g/L时,灵芝三萜的理论产量为21.166g/kg干菌丝体,实际发酵产量提高到21.153g/kg干菌丝体。与原工艺相比,新工艺的灵芝三萜产量提高了6.22%。     

碳源和氮源对黑盖木层孔菌菌丝生长的影响

研究了四种碳源(蔗糖、乳糖、葡萄糖、可溶性淀粉)和九种氮源(玉米面、麸皮、马铃薯、大豆粉、酵母粉、蛋白胨、硝酸钾、硝酸铵、尿素)对黑盖木层孔菌菌丝生长的影响。从不同代数的菌丝体中提取多糖,并测定多糖含量、分子量分布范围及单糖组成。结果表明:黑盖木层孔菌菌丝生长的最佳碳源为可溶性淀粉,最佳氮源为玉米面,最优碳氮组合为蔗糖和玉米面的组合。不同代数的菌丝体多糖性状基本稳定。     

鸭跖草生防菌叶点霉F-3菌株生物学特性的研究

主要研究影响鸭跖草生防菌叶点霉菌株菌丝生长和孢子萌发的条件。研究表明,PDA培养基和鸭跖草培养基是该菌生长的适宜培养基,该菌生长的温度范围为20~35℃,最适温度为25℃,分生孢子萌发的温度范围为25~35℃,最适温度为30℃;pH为6时生长最快,偏酸偏碱有利于孢子的萌发,在pH为10时萌发最好。F-3菌株在供试的6种碳源中生长速度相差不大,在不同氮源中差异显著,以硝酸铵为氮源生长最好。     

基质氮素对大球盖菇生长及亚硝酸盐含量的影响

目的探索氮源对大球盖菇生长及亚硝酸盐、硝酸盐含量的影响。方法在培养基中添加不同含氮化合物,培养菌丝,定时测定生长量,并采用重氮偶合分光光度法测定其亚硝酸盐、硝酸盐含量。结果添加亚硝酸盐的基质,菌丝生长速度比对照慢。尿素、硫酸铵、硝酸铵和硝酸钾四处理之间差异无显著性,其生长速度最快。各处理间亚硝酸盐、硝酸盐含量差异均存在非常显著性。亚硝酸钾处理,亚硝酸盐含量高达402.03 mg/kg,不宜食用。硝酸钾处理,亚硝酸盐含量为30.87 mg/kg,食用100 g,就会超出亚硝酸盐日限量;硝酸铵处理,硝酸盐含量远远超过日常蔬菜,也不宜食用。结论在栽培大球盖菇时氮源不宜使用亚硝酸盐、硝酸盐,应使用尿素或硫酸铵,有机氮源也可以。     

解磷菌发酵及溶磷条件的研究

从新疆盐碱土中分离纯化得到一株高效解磷菌PS-3,为改善盐碱地磷素供应提供菌种资源。采用单因素和正交试验,对菌株PS-3的发酵条件和溶磷能力进行分析。结果表明,菌株PS-3较适发酵条件为温度35℃、pH 7和盐浓度1%,其对碳、氮源的利用顺序依次为葡萄糖>麦芽糖>果糖>蔗糖>乳糖,硝酸铵>硝酸钠>氯化铵>硫酸铵>尿素,菌株PS-3最适溶磷条件为2%葡萄糖、0.01%硝酸铵、温度35℃、初始pH 7.5、盐浓度2 g/L、接种量4%,在此条件下,其对磷酸三钙的溶解量可达100 2.95mg/L。该菌株具有一定耐盐性和良好的溶磷能力,在生物溶磷方面具有较好的应用潜力。     

Inorganic nitrogen source for autotrophic growth of Euglena mutabilis Schmitz

The effect of inorganic nitrogen source on population growth of Euglena mutabilis, an acidophillic benthic protozoa colonizing on the sediment of acid mine drainage, was investigated. Sodium nitrate, ammonium chloride, and ammonium sulfate were tested as nitrogen sources. The population density of E. mutabilis at equilibrium density cultivated in ammonium chloride‐ and ammonium sulfate‐containing media was 9–11 times higher than that in sodium nitrate‐containing medium at the optimal salt medium concentration. The population growth of E. mutabilis in ammonium sulfate‐containing medium was rapid and reached half of the equilibrium density after ca. 228 h, which was ca. 77 h earlier than that in ammonium chloride‐containing medium. Culture medium with ammonium sulfate as the nitrogen source achieved the highest maximum population density and the fastest growth rate among the three nitrogen salts used as nitrogen sources.     

Effect of nitrogen sources on cellulase biosynthesis by a mutant strain of Trichoderma viride 44

The effect of various nitrogen sources on cellulase biosynthesis by the mutant strain Trichoderma viride 44 was examined. This strain may utilized nitrogen in the nitrate, ammonium of organic form. When cultivating this strain, it appears advantageous to add to the nutrient medium yeast and yeast lyzates as well as their mixture with ammonium sulfate. Cellulase reached its maximum activity of 20.2, 21.5 and 23.2 mu/ml when grown on the medium containing ammonium phosphate, peptone and brewing yeast plus ammonium sulfate, respectively. It is useful to apply nitrogen in its organic forms in small quantities and in combination with mineral forms. The nitrogen presence in the medium is necessary only at the exponential stage of fungal growth. The lack of nitrogen in the stationary stage characterized by the maximum cellulase formation does not inhibit an increase in the enzyme activity.     

Condition stabilization for <Emphasis Type="Italic">Aspergillus niger</Emphasis> FCBP-198 and its hyperactive mutants to yield high titres of α-amylase

A number of substrates were tested for the cultivation of microorganisms to produce a host of enzymes. The effect of different substrates (wheat and rice straw, sugar cane waste, wood waste), incubation temperatures (20–40°C), initial pH levels (3.5–9.0), incubation periods (0–72 hours) and nitrogen sources (ammonium sulfate, urea, peptone, yeast extract, sodium nitrate) on growth and α-amylase activity was studied for the native and mutant strains. Maximum enzyme activity was observed at 1.5% wheat straw for Aspergillus niger FCBP-198 and An-Ch-4.7 and at 2% wheat straw for An-UV-5.6, with sodium nitrate as a principle nitrogen source. The optimum temperature for maximum enzyme activity was 30°C for the parental strain, while An-UV-5.6 and An-Ch-4.7 thrived well at 32.5°C. The best conditions of pH and incubation duration were 4.5 and 48 hours, respectively, for all the strains. Mass production under preoptimized growth conditions demonstrated the suitability of wheat straw for swift mycelial colonization and viability.     

戊糖乳杆菌发酵培养基氮源条件的优化

对戊糖乳杆菌发酵培养基的氮源条件进行了优化。通过单因素实验及响应面分析优化利用木糖高产乳酸的戊糖乳杆菌发酵培养基的不同氮源组合。优化得到的牛肉膏与柠檬酸氢二铵复合的最佳组成为牛肉膏17.72 g/L,柠檬酸氢二铵1.91 g/L,得到乳酸实际最大产量42.37 g/L。添加玉米浆与酵母粉和无机氮源复合的最佳组成为玉米浆46.54 g/L,酵母粉21.95 g/L,柠檬酸氢二铵9.95 g/L,可得到乳酸最大产量41.06 g/L。通过响应面优化减少了有机氮源的种类。牛肉膏与柠檬酸氢二铵的复合得到了更高的乳酸产量,且减少了有机氮源用量,节约了成本。玉米浆与酵母粉的复合解决了单一玉米浆造成的木糖利用速率过低的问题,同样得到较高浓度的乳酸。     

The effect of different nitrogen sources on pigment production and sporulation of Monascus species in submerged, shaken culture.

Thirty-nine strains from the genus Monascus were cultivated aerobically to study the relation between nitrogen nutrition and sporulation and pigment production. The effects of yeast extract, nitrate, ammonium, and ammonium nitrate have been compared. During cultivation the pHs of the different media are not the same, resulting in the formation of different coloured pigments. When the source of nitrogen is yeast extract or nitrate the pH is around 6.5 and red pigments are formed, whereas with ammonium or ammonium nitrate the pH is around 2.5 and the pigments are orange. It is proposed that only the orange pigments, monascorubrin and rubropunctatin, are produced biosynthetically and that the other pigments are formed from these by chemical transformations depending on the cultural conditions. The presence of organic nitrogen is optimal for growth and unfavourable for pigment production. Reduced growth and best pigment formation occurs with the three other nitrogen sources. Nitrate stimulates conidiation and sexual reproduction, while ammonium is inhibitory. Pigment production is better when conidiation is reduced. A mechanism is proposed for the control of sporulation and pigment production.     

Effects of fertilizer-based culture media on the production of exocellular polysaccharides and cellular superoxide dismutase by <Emphasis Type="Italic">Phaeodactylum tricornutum</Emphasis> (Bohlin)

Microalgae cultures are receiving attention because of increasing biotechnological and biomedical production of active biomolecules. We evaluated various fertilizer-based culture media to scale up production of the marine microalga Phaeodactylum tricornutum for production of exocellular polysaccharides (EPS), soluble proteins, and cellular superoxide dismutase (SOD). The standard source of sodium nitrate was the same as that used in the synthetic f/2 culture medium and ammonium nitrate, urea, ammonium sulfate, and calcium nitrate as alternative sources of nitrogen. The maximum production of EPS was achieved in microalgae cells grown in the culture media containing 63 and 23% nitrogen from ammonium sulfate, and also in microalgae cells grown in the culture media containing 3% nitrogen from ammonium nitrate. The maximum production of cellular SOD was achieved in microalgae cells grown in the culture media containing 35 and 26% nitrogen from ammonium sulfate, and in the culture media containing 17% nitrogen from urea. The results suggest that it is possible to use a source of nitrogen, other than sodium nitrate, to scale up growth of P. tricornutum for production of EPS and SOD at reduced costs.     

Effect of nitrogen source on biosynthesis of rapamycin by Streptomyces hygroscopicus

Six non-amino acid nitrogen compounds were examined as nitrogen source for growth of Streptomyces hygroscopicus and biosynthesis of rapamycin. Of the nitrogen sources studied, ammonium sulfate was the best with respect to formation of rapamycin, and supported cell growth comparable to the organic nitrogen sources used in the control chemically defined medium, ie, aspartate, arginine plus histidine. In the new chemically defined medium, which is buffered with 200 mM 2-(N-morpholino)ethanesulfonic acid to prevent decline of pH during fermentation, an ammonium sulfate concentration of 40 mM was optimal for biosynthesis of rapamycin. Rapamycin production increased by more than 30% on both volumetric and specific bases as compared to the previous medium containing the three amino acids as nitrogen source. Received 08 November 1996/ Accepted in revised form 07 April 1997     

冬小麦等4种作物对铵,硝态氮的吸收能力

采用水培试验探讨了冬小麦、大豆、油菜和莴笋４种作物对硝、铵态氮的相对吸收能力以及这两种氮源对它们生长发育的影响。试验表明：（１）不同氮源对供试作物的生长发育影响极大。供给硝态氮,这些作物生长发育良好,供给等量的ＮＯ＾－３和ＮＨ＾－４（１：１）时,蔬菜作物莴笋生长量下降幅度最大;供给铵态氨,莴笋和大豆极为敏感,供给ＮＯ＾－３时莴笋吸氮量显著高于供给等氮量ＮＯ＾－３和ＮＨ＾＋４,莴上麦供给等量ＮＯ＾－