Purification and partial characterization of α-<Emphasis Type="SmallCaps">l</Emphasis>-arabinofuranosidase produced by<Emphasis Type="Italic">Thermomonospora fusca</Emphasis>

Thermomonospora fusca produced a relatively high level of alpha-L-arabinofuranosidase when growing on oat spelt xylan as the main carbon and energy source. The enzyme exhibited maximum relative activity (0.136 U/g protein) at pH 9.0 with 54 and 55% activity remaining at pH of 4.5 and 11.0, respectively. The apparent Km value for the crude alpha-L-arabinofuranosidase preparation was 180 mumol/L 4-nitrophenyl alpha-L-arabinofuranoside; the upsilon lim value was the release of 40 mumol/L 4-nitrophenol per min. Enzyme activity was eluted as a single peak (HPLC gel filtration chromatography) corresponding to molar mass of approximately 92 kDa. Native electrophoresis of crude cell lysate confirmed the presence of a single active intracellular alpha-L-arabinofuranosidase component. SDS-PAGE of this enzyme, developed as zymogram, did not demonstrate any activity; denaturing gel was stained and a protein band of relative molar mass of 46 kDa was revealed. Isoelectric focusing of a purified alpha-L-arabinofuranosidase yielded a single protein band for the corresponding activity zone with pI 7.9. The enzyme was purified approximately 21-fold the mean overall yield was about 16%.     

Effect of Carbon Source on Production of α-L-Arabinofuranosidase by Aureobasidium pullulans

A color-variant strain of Aureobasidium pullulans (NRRL Y-12974) produced α-L-arabinofuranosidase (α-L-AFase) when grown in liquid culture on sugar beet arabinan, wheat arabinoxylan, L-arabinose, L-arabitol, xylose, xylitol, oat spelt xylan, corn fiber, or arabinogalactan. L-Arabinose was most effective for production of both whole-broth and extracellular α-L-AFase activity, followed by L-arabitol. Oat spelt xylan, sugar beet arabinan, xylose, xylitol, and wheat arabinoxylan were intermediate in their ability to support α-L-AFase production. Lower amounts of enzyme activity were detected in corn fiber- and arabinogalactan-grown cultures. Received: 16 April 1998 / Accepted: 17 June 1998     

Stimulatory effect of ferulic acid on the production of extracellular xylanolytic enzymes by Aspergillus kawachii

Production of extracellular beta-1,4-xylanase, alpha-L-arabinofuranosidase, feruloyl esterase, and acetyl xylan esterase from Aspergillus kawachii was higher in a culture supplemented with ferulic acid than in a counterpart. Culture supernatant grown on oat spelt xylan supplemented with ferulic acid exhibited an increase in ferulic acid-releasing activity from insoluble arabinoxylan relative as compared to that from the ferulic acid-free culture.     

A High-Molecular-Weight, Cell-Associated Xylanase Isolated from Exponentially Growing Thermoanaerobacterium sp. Strain JW/SL-YS485

An unusual cell-associated (beta)-1,4-xylanase was purified to gel electrophoretic homogeneity from a cell extract of the bacterium Thermoanaerobacterium sp. strain JW/SL-YS485 harvested at the late exponential growth phase. The molecular mass of the xylanase was 350 kDa as determined by gel filtration and 234 kDa as determined by native gradient gel electrophoresis. The enzyme contained 6% carbohydrates. Heterosubunits of 180 and 24 kDa were observed for the xylanase on sodium dodecyl sulfate-polyacrylamide gradient gel electrophoresis gels. The xylanase had a pI of 4.37 and a half-life of 1 h at 70(deg)C. Using a 5-min assay, we observed the highest level of activity at pH 6.2 and 80(deg)C. The K(infm) and k(infcat) values when oat spelt xylan was used were 3 mg/ml and 26,680 U/(mu)mol, respectively. The Arrhenius energy was 41.8 kJ/mol. The purified enzyme differed in size, subunit structure, and location from other xylanases that have been described. The cell-associated enzyme activity appeared in the S-layer fraction.     

Purification and characterization of an extracellular endo-1,4-β-xylanase from Fusarium oxysporum f. sp. melonis

Abstract Fusarium oxysporum f. sp. melonis produces extracellular endo-1,4-β-xylanase and β-xylosidase when grown in shaken culture at 26°C in a mineral salts medium containing oat spelt xylan and glucose as carbon sources. Endo-1,4-β-xylanase was purified 251 times from 5-day-old culture filtrates, by Sephacryl S-200, ion exchange and gel filtration HPLC. The purified sample yielded a single band in SDS polyacrylamide gels with a molecular mass of 80 kDa on electrophoretic mobility and 83 kDa by gel filtration behavior. High activity of the endo-1,4-β-xylanase against xylan was observed between 5 and 8 pH, and between 40 and 60°C, the optimum pH and temperature being 5.0 and 50°C, respectively. Kinetic properties of the enzyme are similar to those of other fungal xylanases, showing high affinity towards oat spelt xylan with a K _m of 1 mM expressed as xylose equivalent.     

Characterization of the Bacillus subtilis WL-3 mannanase from a recombinant Escherichia coli

A mannanase was purified from a cell-free extract of the recombinant Escherichia coli carrying a Bacillus subtilis WL-3 mannanase gene. The molecular mass of the purified mannanase was 38 kDa as estimated by SDS-PAGE. Optimal conditions for the purified enzyme occurred at pH 6.0 and 60 degrees C. The specific activity of the purified mannanase was 5,900 U/mg on locust bean gum (LBG) galactomannan at pH 6.0 and 50 degrees C. The activity of the enzyme was slightly inhibited by Mg(2+), Ca(2+), EDTA and SDS, and noticeably enhanced by Fe(2+). When the enzyme was incubated at 4 degrees C for one day in the presence of 3 mM Fe(2+), no residual activity of the mannanase was observed. The enzyme showed higher activity on LBG and konjac glucomannan than on guar gum galactomannan. Furthermore, it could hydrolyze xylans such as arabinoxylan, birchwood xylan and oat spelt xylan, while it did not exhibit any activities towards carboxymethylcellulose and para-nitrophenyl-beta-mannopyranoside. The predominant products resulting from the mannanase hydrolysis were mannose, mannobiose and mannotriose for LBG or mannooligosaccharides including mannotriose, mannotetraose, mannopentaose and mannohexaose. The enzyme could hydrolyze mannooligosaccharides larger than mannobiose.     

Purification and characterization of a new xylanase (APX-II) from the fungus Aureobasidium pullulans Y-2311-1.

Aureobasidium pullulans Y-2311-1 produced four major xylanases (EC 3.2.1.8) with pI values of 4.0, 7.3, 7.9, and 9.4 as revealed by isoelectric focusing and zymogram analysis when grown for 4 days on 1.0% oat spelt xylan. The enzyme with a pI of 9.4 was purified by ammonium sulfate precipitation, chromatography on a DEAE-Sephadex A-50 column, and gel filtration with a Sephadex G-75 column. The enzyme had a mass of about 25 kDa as determined by both sodium dodecyl sulfate-polyacrylamide gel electrophoresis and gel filtration chromatography. The purified enzyme had a Km of 7.6 mg . ml(-1) and Vmax of 2,650 micromol . min(-1) . mg(-1) for birchwood xylan at 28 degrees C and pH 4.5. It lacked activity towards carboxymethylcellulose, cellobiose, starch, mannan, p-nitrophenyl (pNP)-beta-D-xylopyranoside, pNP-beta-D-glucopyranoside, pNP-alpha-D-glucopyranoside, pNP-beta-D-cellobioside, pNP-beta-D-fucopyranoside, or pNP-alpha-D-galactopyranoside. The predominant end products of birchwood xylan or xylohexaose hydrolysis were xylobiose and xylose. The enzyme had the highest activity of pH 4.8 and 54 degrees C. Sixty percent of the activity remained after the enzyme had been incubated at 55 degrees C and pH 4.5 for 30 min. The sequence of the first 68 amino acid residues at the amino terminus showed homology to those of several other xylonases. Immunoblot analysis with antiserum raised against the purified xylanase revealed that two immunologically related polypeptides of 25 and 22 kDa were produced in A. pullulans cultures containing oat spelt xylan or xylose as carbon sources but not in cultures containing glycerol or glucose.     

Purification and characterization of a neutral endoxylanase from Aspergillus nidulans

Abstract A neutral endoxylanase from a culture filtrate of Aspergillus nidulans grown on oat spelt xylan was purified to apparent homogeneity. The purified enzyme showed a single band on SDS-PAGE with a molecular mass of 22,000 and had an isoelectric point of 6.4. The enzyme was a non-debranching endoxylanase highly specific for xylans and completely free from cellulolytic activity. The xylanase showed an optimum activity at pH 5.5 and 62°C and had a K m of 4.2 mg oat spelt xylan per ml and a V max of 710 μmol min⁻¹ (mg protein)⁻¹.     

Bacillus pumilus WL-11木聚糖酶A的纯化、鉴定及其底物降解方式

对一株BacilluspumilusWL_11木聚糖酶的纯化、酶学性质及其底物降解模式进行了研究。经过硫酸铵盐析、CM_Sephadex及SephadexG_75层析分离纯化,获得一种纯化的WL_11木聚糖酶A ,其分子量为2 6 0kD ,pI值9 5 ,以燕麦木聚糖为底物时的表观Km 值为16 6mg mL ,Vmax值为12 6 3μmol (min·mg)。木聚糖酶A的pH稳定范围为6 0至10 4 ,最适作用pH范围则在7 2至8 0之间,是耐碱性木聚糖酶;最适作用温度为4 5℃～5 5℃,在37℃、4 5℃以下时该酶热稳定性均较好;5 0℃保温时,该酶活力的半衰期大约为2h ,在超过5 0℃的环境下,该酶的热稳定较差,5 5℃和6 0℃时的酶活半衰期分别为35min和15min。WL_11木聚糖酶A对来源于燕麦、桦木和榉木的可溶性木聚糖的酶解结果发现,木聚糖酶A对几种不同来源的木聚糖的降解过程并不一致。采用HPLC法分析上述底物的降解产物生成过程发现木聚糖酶A为内切型木聚糖酶,不同底物的降解产物中都无单糖的积累,且三糖的积累量都较高;与禾本科的燕麦木聚糖底物降解不同的是,木聚糖酶A对硬木木聚糖降解形成的五糖的继续降解能力较强。采用TLC法分析了WL_11粗木聚糖酶降解燕麦木聚糖的过程,结果表明燕麦木聚糖能够被WL_11粗木聚糖酶降解生成系列木寡糖,未检出木糖,这说明WL_11主要合成内切型木聚     

Production, purification and properties of endoglucanase from a newly isolated strain of Mucor circinelloides

A newly isolated strain of the fungus, Mucor circinelloides (NRRL 26519), when grown on lactose, cellobiose, or Sigmacell 50 produces complete cellulase (endoglucanase, cellobiohydrolase, and β-glucosidase) system. The extracellular endoglucanase (EG) was purified to homogeneity from the culture supernatant by ethanol precipitation (75%, v/v), CM Bio-Gel A column chromatography, and Bio-Gel A-0.5 m gel filtration. The purified EG (specific activity 43.33 U/mg protein) was a monomeric protein with a molecular weight of 27 000. The optimum temperature and pH for the action of the enzyme were at 55 °C and 4.0–6.0, respectively. The purified enzyme was fully stable at pH 4.0–7.0 and temperature up to 60 °C. It hydrolysed carboxymethyl cellulose and insoluble cellulose substrates (Avicel, Solka-floc, and Sigmacell 50) to soluble cellodextrins. No glucose, cellobiose, and short chain cellooligosaccarides were formed from these substrates. The purified EG could not degrade oat spelt xylan and larch wood xylan. It bound to Avicell, Solka-floc, and Sigmacell 50 at pH 5.0 and the bound enzyme was released by changing the pH to 8.0. The enzyme activity was enhanced by 27±5 and 44±14% by the addition of 5 mM MgCl₂ and 0.5 mM CoCl₂, respectively, to the reaction mixture. Comparative properties of this enzyme with other fungal EGs are presented.     

Physicochemical properties of a novel alpha-L-arabinofuranosidase from Rhizomucor pusillus HHT-1

The zygomycete fungus Rhizomucor pusillus HHT-1, cultured on L(+)arabinose as a sole carbon source, produced extracellular alpha-L-arabinofuranosidase. The enzyme was purified by (NH4)2SO4 fractionation, gel filtration, and ion exchange chromatography. The molecular mass of this monomeric enzyme was 88 kDa. The native enzyme had a pI of 4.2 and displayed a pH optimum and stability of 4.0 and 7.0-10.0, respectively. The temperature optimum was 65 degrees C, and it was stable up to 70 degrees C. The Km and Vmax for p-nitrophenyl alpha-L-arabinofuranoside were 0.59 mM and 387 micromol x min(-1) x mg(-1) protein, respectively. Activity was not stimulated by metal cofactors. The N-terminal amino acid sequence did not show any similarity to other arabinofuranosidases. Higher hydrolytic activity was recorded with pnitrophenyl alpha-L-arabinofuranoside, arabinotriose, and sugar beet arabinan; lower hydrolytic activity was recorded with oat-spelt xylan and arabinogalactan, indicating specificity for the low molecular mass L(+)-arabinose containing oligosaccharides with furanoside configuration.     

A thermostable alpha-arabinofuranosidase from xylanolytic Bacillus pumilus: purification and characterisation

Bacillus pumilus PS213 secretes an alpha-L-arabinofuranosidase (AF) when grown in the presence of arabinogalactan or oat meal. The enzyme has been purified to homogeneity and characterised. Its molecular mass, as determined by gel filtration, is 220 kDa, while sodium dodecyl sulphate-polyacrylamide gel electrophoresis (SDS-PAGE) showed a single band of approximately 60 kDa. According to the result of the mass spectrometry analysis showing a molecular mass of 56 kDa, the enzyme should be a homotetramer. The isoelectric point was found to be 5.2, the enzyme activity was optimal at 55 degrees C and pH 7.0. The enzyme retained 80% of its activity after 2 h at 65 degrees C and lost 50% of activity at 75 degrees C after 135 min. The Michaelis constant K(m) and V(max) for p-nitrophenylarabinofuranoside at 37 degrees C were 1.7 mM and 52.9 U mg(-1), respectively. N-terminal sequence analysis and internal peptide fragments showed homology with glycosyl hydrolases of family 51.     

Cloning and expression of an alpha-L-arabinofuranosidase gene (stxIV) from Streptomyces thermoviolaceus OPC-520, and characterization of the enzyme

The gene encoding alpha-L-arabinofuranosidase (STX-IV), located upstream of the previously reported stxI gene, was cloned and sequenced. The gene is divergently transcribed from the stxI gene, and the two genes are separated by 661 nucleotides. The stxIV gene consists of a 1,092-bp open reading frame encoding 363 amino acids. The deduced amino acid sequence of the gene showed that STX-IV was an enzyme consisting of only a catalytic domain, and that the enzyme had significant similarity with alpha-L-arabinofuranosidases belonging to family 62 of glycosyl hydrolases. The stxIV gene was expressed in Escherichia coli, and the recombinant protein was purified to homogeneity. Arabinoxylan and oat spelt xylan were good substrates for STX-IV, however, the enzyme showed a low activity with p-nitrophenyl alpha-L-arabinofuranoside. The optimum pH and temperature were 5.0 and 60 degrees C, respectively.     

A new thermostable α-l-arabinofuranosidase from a novel thermophilic bacterium

An alpha-L-arabinofuranosidase gene was identified in a sequenced genome of a novel thermophilic bacterium, which belongs to the recently described phylum of Thermomicrobia. Amino acid sequence comparison of the enzyme (designated AraF) revealed similarity to glycoside hydrolases of family 51. The gene was cloned into Escherichia coli and its recombinant product expressed and purified. The enzyme appeared to be a hexamer. AraF was optimally active at 70 degrees C (over 10 min) and pH 6 having 92% residual activity after 1 h at 70 degrees C. AraF had a Km) value of 0.6 mM and V(max) value of 122 U mg(-1) on p-nitrophenyl-alpha-L-arabinofuranoside. AraF was almost equally active on branched arabinan and debranched arabinan, properties not previously found in alpha-L-arabinofuranosidases in GH family 51.     

Purification and functional characterization of a novel alpha-L-arabinofuranosidase from Bifidobacterium longum B667

The gene encoding a novel alpha-L-arabinofuranosidase from Bifidobacterium longum B667, abfB, was cloned and sequenced. The deduced protein had a molecular mass of about 61 kDa, and analysis of its amino acid sequence revealed significant homology and conservation of different catalytic residues with alpha-L-arabinofuranosidases belonging to family 51 of the glycoside hydrolases. Regions flanking the gene comprised two divergently transcribed open reading frames coding for hypothetical proteins involved in sugar metabolism. A histidine tag was introduced at the C terminus of AbfB, and the recombinant protein was overexpressed in Lactococcus lactis under control of the tightly regulated, nisin-inducible nisA promoter. The enzyme was purified by nickel affinity chromatography. The molecular mass of the native protein, as determined by gel filtration, was about 260 kDa, suggesting a homotetrameric structure. AbfB was active at a broad pH range (pH 4.5 to 7.5) and at a broad temperature range (20 to 70 degrees C), and it had an optimum pH of 6.0 and an optimum temperature of 45 degrees C. The enzyme seemed to be less thermostable than most previously described arabinofuranosidases and had a half-life of about 3 h at 55 degrees C. Chelating and reducing agents did not have any effect on its activity, but the presence of Cu(2+), Hg(2+), and Zn(2+) markedly reduced enzymatic activity. The protein exhibited a high level of activity with p-nitrophenyl alpha-L-arabinofuranoside, with apparent K(m) and V(max) values of 0.295 mM and 417 U/mg, respectively. AbfB released L-arabinose from arabinan, arabinoxylan, arabinobiose, arabinotriose, arabinotetraose, and arabinopentaose. No endoarabinanase activity was detected. These findings suggest that AbfB is an exo-acting enzyme and may play a role, together with other glycosidases, in the degradation of L-arabinose-containing polysaccharides.     

An alpha-L-arabinofuranosidase from Penicillium purpurogenum: production, purification and properties

Penicillium purpurogenum secretes arabinofuranosidase to the growth medium. Highest levels of enzyme (1.0 U ml(-1)) are obtained when L-arabitol is used as carbon source, while 0.85 and 0.7 U ml(-1) are produced with sugar beet pulp and oat spelts xylan, respectively. By means of a zymogram, three bands with arabinofuranosidase activity have been detected in the supernatant of a culture grown in oat spelts xylan. One of the enzymes was purified to homogeneity from this supernatant using gel filtration (BioGel P-100), cation exchange chromatography (CM-Sephadex C-50), hydrophobic interaction chromatography (phenyl agarose) and a second BioGel P-100 column. The enzyme is a monomer of 58 kDa with a pI of 6.5. Optimum pH is 4.0 and optimal temperature 50 degrees C. The arabinofuranosidase is highly specific for alpha-L-arabinofuranosides and liberates arabinose from arabinoxylan. The enzyme shows hyperbolic kinetics towards p-nitrophenyl-alpha-L-arabinofuranoside with a K(M) of 1.23 mM. A 36-residue N-terminal sequence is over 70% identical to that of fungal arabinofuranosidases belonging to family 54 of the glycosyl hydrolases. Based on the sequence similarity and other biochemical properties it is proposed that the purified enzyme from P. purpurogenum belongs to family 54.     

Purification and properties of an extracellular beta-xylosidase from a newly isolated Fusarium proliferatum

An extracellular beta-xylosidase from a newly isolated Fusarium proliferatum (NRRL 26517) capable of utilizing corn fiber xylan as growth substrate was purified to homogeneity from the culture supernatant by DEAE-Sepharose CL-6B batch adsorption chromatography, CM Bio-Gel A column chromatography, Bio-Gel A-0.5 m gel filtration and Bio-Gel HTP Hydroxyapatite column chromatography. The purified beta-xylosidase (specific activity, 53 U/mg protein) had a molecular weight of 91,200 as estimated by SDS-PAGE. The optimum temperature and pH for the action of the enzyme were 60 degrees C and 4.5, respectively. The purified enzyme hydrolyzed xylobiose and higher xylooligosaccharides but was inactive against xylan substrates. It had a Km value of 0.77 mM (p-nitrophenol-beta-D-xyloside, pH 4.5, 50 degrees C) and was competitively inhibited by xylose with a Ki value of 5 mM. The enzyme did not require any metal ion for activity and stability. Comparative properties of this enzyme with other fungal beta-xylosidases are presented.     

Gene cloning, sequencing, and biochemical characterization of endoxylanase from Thermoanaerobacterium saccharolyticum B6A-RI.

The gene encoding endoxylanase (xynA) from Thermoanaerobacterium saccharolyticum B6A-RI was cloned and expressed in Escherichia coli. A putative 33-amino-acid signal peptide, which corresponded to the N-terminal amino acids, was encoded by xynA. An open reading frame of 3,471 bp, corresponding to 1,157 amino acid residues, was found, giving the xynA gene product a molecular mass of 130 kDa. xynA from T. saccharolyticum B6A-RI had strong similarity to genes from family F beta-glycanases. The temperature and pH optimum for the activity of the cloned endoxylanase were 70 degrees C and 5.5, respectively. The cloned endoxylanase A was stable at 75 degrees C for 60 min and displayed a specific activity of 227.4 U/mg of protein on oat spelt xylan. The cloned xylanase was an endo-acting enzyme.     

Purification and characterization of a high-thermostable β-xylanase from newly isolated Thermomyces lanuginosus THKU-49

Highly thermostable β-xylanase produced by newly isolated Thermomyces lanuginosus THKU-49 strain was purified in a four-step procedure involving ammonium sulfate precipitation and subsequent separation on a DEAE-Sepharose fast flow column, hydroxylapatite column, and Sephadex G-100 column, respectively. The enzyme purified to homogeneity had a specific activity of 552 U/mg protein and a molecular weight of 24.9 kDa. The optimal temperature of the purified xylanase was 70°C, and it was stable at temperatures up to 60°C at pH 6.0; the optimal pH was 5.0–7.0, and it was stable in the pH range 3.5–8.0 at 4°C. Xylanase activity was inhibited by Mn²⁺, Sn²⁺, and ethylenediaminetetraacetic acid. The xylanase showed a high activity towards soluble oat spelt xylan, but it exhibited low activity towards insoluble oat spelt xylan; no activity was found to carboxymethylcellulose, avicel, filter paper, locust bean gum, cassava starch, and p-nitrophenyl β-d-xylopyranoside. The apparent K _m value of the xylanase on soluble oat spelt xylan and insoluble oat spelt xylan was 7.3 ± 0.236 and 60.2 ± 6.788 mg/ml, respectively. Thin-layer chromatography analysis showed that the xylanase hydrolyzed oat spelt xylan to yield mainly xylobiose and xylose as end products, but that it could not release xylose from the substrate xylobiose, suggesting that it is an endo-xylanase.     

Xylanase production by Aspergillus awamori. Development of a medium and optimization of the fermentation parameters for the production of extracellular xylanase and beta-xylosidase while maintaining low protease production

A growth medium was developed for maximal production in batch culture of extracellular xylanase and beta-xylosidase by Aspergillus awamori CMI 142717 and a mutant (AANTG 43) derived from the wild-type strain. The optimum pH for the production of xylanase and beta-xylosidase was 4.0. The best temperature of xylanase production was 30 degrees C; 35 degrees C was optimal for beta-xylosidase. Protease production was never completely suppressed under any of the conditions tested. However, protease titre was 3.5-fold less than the control in medium in which proteose peptone and yeast extract were omitted: the level of xylanase was not affected (8.6 U mL(-1)) but beta-xylosidase titre was increased 4.7-fold to 1.5 U mL(-1). When corn steep liquor was used as the sole nitrogen source, xylanse and beta-xylosidase titres were further increased by 1.5- and 1.9-fold, respectively. Of the carbon sources investigated, ball-milled oat straw or oat spelt xylan produced the highest titres of xylanse and beta-xylosidase. None of the soluble carbon sources investigated produced the high titres of xylanase or beta-xylosidase induced by either oat straw for xylanse and beta-xylosidase was 2% and the optimum spore inoculum was between 10(6) and 10(7) spores/mL(-1) final concentration. The level of xylanse activity obtained in the culture filtrates of the mutant was a remarkable 820 U mL(-1) when the reducing sugar released was measured by the dinitrosalicylic acid method. This enzyme titre would appear to be the highest reported so far. The xylanases system contained the correct balance of enzymes to effect extensive hydrolysis of oat spelt xylan. The protease titre was very low.