里氏木霉FS10-C固体发酵基质筛选及发酵条件初探

筛选适宜里氏木霉FS10-C菌株固体发酵的基质,并优化其发酵基本条件,以期为将该菌株应用于土壤重金属污染修复中奠定基础。采用单因素试验对固体发酵基质进行筛选,在筛选结果的基础上,再运用正交试验设计初步确定适宜的发酵条件,并在50 L固体发酵罐中进行放大试验。结果表明,桔皮麦麸混合物为木霉FS10-C的最佳发酵基质,优化后的平皿固体发酵条件为:桔皮、麦麸按1∶1比例配伍,固水比为1∶1.2,接种量为5%,发酵温度为28℃,发酵14 d后产孢量可高达2.43×1010 CFU/g,且应用于固体发酵罐中发酵效果良好,产孢量达到1.44×1010 CFU/g。通过对固体发酵基质的筛选和发酵条件的优化,可实现木霉FS10-C的高密度培养,降低制剂成本,具有规模化生产的潜力。     

影响蜡蚧轮枝菌发酵产孢量和孢子活力的基本因素分析

不同接种浓度、发酵时间、菌株和基质对蜡蚧轮枝菌固体发酵的产孢量都有显著影响,而对孢子活力的影响不明显,萌发率均在90%以上.在5至7天内,随发酵时间的延长产孢量有明显增长;7至10天则变化不大;15天时产孢量和孢子活力均显著降低.随接种孢子浓度每增加1倍,菌株(VLFNL95-01)发酵的产孢量平均提高15.6%,浓度加大至32倍则提高71.9%.3个菌株比较,VLFNL95-01产孢量明显高得多.不同固体基质发酵的结果有显著差异,产孢量最高的(正交3号配方)比其次的(黄豆饼粉+玉米碎粒+磷酸盐)就提高了95.1%.     

白僵菌固态发酵试验研究

以产孢量为指标,筛选出白僵菌固态发酵的培养基为：90％麦麸＋5％玉米粉＋5％黄豆粉,原孢粉的产孢量可达244．7亿／g。在25m^3发酵罐内进行浅盘固态发酵,培养基的最适起始含水率为60％～65％;最佳通气条件为：前12h不通气,12～48h通气量为1：2,48～144h的通气量为1：1;而温度只需在12～48＋8h内进行控制。常温干燥能最大限度地维持白僵菌的活孢率。     

链霉菌Men-myco-93-63固体发酵的初步研究

试验对链霉菌Men-myco-93-63固体发酵的培养基和培养条件进行了研究.以产孢量为指标,通过单一固体基质筛选、组合固体基质筛选及正交试验得到适宜链霉菌Men-myco-93-63产孢的固体培养基是大米:高粱:米糠:稻壳为2:2:3:3(W/W/W/W),试验中产孢量最高达到2.52×109 CFU/g.在此培养基的基础上研究了装料量、初始水料比、接种量和培养温度对其产孢的影响.结果表明,链霉菌Men-myco-93-63产孢的适宜条件为:装料量为15 g/500 mL三角瓶,初始水料比为1.7:1.0(V/W,不计稻壳质量),液体接种量为7 mL,培养温度为28℃.     

对蜱致病性球孢白僵菌培养条件的优化

对前期筛选得到的具有生防潜力的杀蜱真菌Beauveria bassiana AT17菌株进行相关生物学性状的研究,建立一套规范的实验室培养的技术和方法,同时对其液固双相发酵技术进行优化,在于提供优质高效的生防材料,为其真菌制剂的规模化生产提供实践和理论基础。通过采用单因素筛选方案对其最适基础培养基、温度、pH值、碳源、氮源、微量元素及液固双相发酵配方进行研究,发现该菌株在PDA、PPDA、PDAY、SDAY、SMAY 5种培养基上均能较好生长,在PDA上生长最快,在PDAY上产孢量最大。温度对菌丝的生长和产孢影响显著,25°C菌丝生长最快,且产孢量最大。B.bassiana AT17菌株在pH 4-10范围内均可生长,在偏碱性环境内生长最快,在pH 5-6的偏酸性环境内产孢量最大。综合评价真菌各项指标后,葡萄糖和酵母粉为菌丝生长和产孢的最佳碳源和氮源,固体物料麦麸+玉米粉+米粉与基础培养液3/4 SDAY按2:1均匀混合后,添加0.05%K+可作为菌株固体发酵的最佳物料配方组合。     

短小芽孢杆菌HR10产孢培养基及发酵条件优化

短小芽孢杆菌(Bacillus pumilus)HR10是一株具有促生抗逆作用的优良菌株。探究菌株HR10产孢的最佳发酵培养条件,对于在更大规模上进行生产发酵具有重要的指导意义。以稀释涂布平板法计数活菌数和芽孢数并计算芽孢率;对菌株HR10产孢培养基的碳源、氮源和无机盐进行单因素分析及正交试验,并采用摇瓶发酵法对影响菌株HR10产孢的几种发酵因子进行单因素优化。结果显示,菌株HR10的产孢培养基最佳组成成分为葡萄糖1%、糖蜜1%、豆饼粉2%、KCl 0.3%、 MnSO_4 0.4%。最佳发酵条件为温度37℃、pH 7、250 mL三角瓶装液量50%、接种量5%、转速220r/min、培养时间52 h。芽孢数达到2.37×10~(10) cfu/mL,芽孢率达94.46%。相比初始培养基芽孢数提高了60.77倍,为其工业化生产提供参考。     

白僵菌固态发酵试验研究*

以产孢量为指标,筛选出白僵菌固态发酵的培养基为:90%麦麸+5%玉米粉+5%黄豆粉,原孢粉的产孢量可达244.7亿/g。在25m³发酵罐内进行浅盘固态发酵,培养基的最适起始含水率为60%~65%;最佳通气条件为:前12h不通气,12~48h通气量为1:2,48~144h的通气量为1:1;而温度只需在12~48±8h内进行控制。常温干燥能最大限度地维持白僵菌的活孢率。     

防治稻水象甲优效球孢白僵菌YS03菌株产孢培养基优化

采用单因素试验和响应面分析对球孢白僵菌YS03菌株进行产孢培养基的配方改良。单因素试验筛选出对产孢量影响较大的3种原料为花生、麦麸和玉米粉,进而根据Box-Behnken的中心组合原理进行三因素三水平的实验设计,最终得出使产孢量最大的配方为花生∶麦麸∶玉米粉=2.6∶3.5∶3.9。经验证,预测值与验证试验平均值接近,且新配方的产孢量是PDA培养基产孢量的1.92倍。     

二步发酵丢糟生产微生物油脂的研究

目的:探索以黄曲霉和皮状丝孢酵母为菌种二步发酵大曲丢糟生产微生物油脂的最佳工艺条件.方法:利用黄曲霉对丢糟进行一步发酵,再以一步丢糟发酵物为基质,设定皮状丝孢酵母的接种量、培养温度、培养时间为三个因素,进行L9(33)正交试验.结果:黄曲霉一步发酵丢糟的最佳条件为接种量12％,在28℃下发酵5d,获得的一步丢糟发酵物还原糖含量为2.4051％;皮状丝孢酵母二步发酵丢糟生产微生物油脂的最佳条件为皮状丝孢酵母接种量12％,在30℃下培养4d,每1 000g发酵物中可得油脂19.32g.结论:利用黄曲霉的产纤维素酶的性能和皮状丝孢酵母积累油脂的性能进行二步发酵丢糟生产微生物油脂,具有一定的可行性.     

尖孢镰刀菌生产蒽醌色素的液体发酵条件研究

优化了尖孢镰刀菌液体发酵生产蒽醌类红色素的发酵条件。通过单因素实验和正交优化实验,确定最佳产色素发酵培养基为：可溶性淀粉30％,(NH4)2SO4 3％,MgSO4 0.3％,KH2PO4 4％,pH 6.0。产色素最适培养条件为：初始pH6.0,装液量20％,接种量10％,吐温-80添加量1％,温度28℃,摇床转速200r/min,发酵周期120h。此条件下,色素效价即可达到8.184U/ml,比优化前提高了1.8倍。国内首次对尖孢镰刀菌所产蒽醌色素进行研究,为其进一步应用奠定基础。     

Effects of nutrient supplements on biological efficiency, quality and crop cycle time of maitake (Grifola frondosa)

The effects of various combinations of wheat bran, rye and millet (at 20% and 30% of total dry substrate wt) on crop cycle time, biological efficiency (BE) and mushroom quality were evaluated for a commercially used isolate of Grifola frondosa (maitake). Supplements were combined with a basal ingredient of mixed oak (primarily red oak) sawdust, and the resulting mixture was pasteurized, cooled, inoculated and bagged with an autoclaving mixer. Times to mushroom primordial formation and mushroom harvest were recorded, and mushroom quality was rated on a scale of 1-4, where 1 was the highest quality and 4 was the lowest quality. The combinations of 10% wheat bran, 10% millet and 10% rye (BE 47.1%, quality 1.8 and crop cycle 12 weeks) and 10% wheat bran plus 20% rye (BE 44%, quality 1.7 and crop cycle 10 weeks) gave the most consistent yields and best basidiome quality over time.     

Production of alpha amylase by Bacillus licheniformis using an economical medium

The present study is concerned with the selection of new medium for the production of alpha amylase by Bacillus licheniformis. Different agricultural by-products such as wheat bran, sunflower meal, cotton seed meal, soybean meal, rice husk or rice bran were tested for the production of alpha amylase. Among different agricultural by-products evaluated, wheat bran was found to be the best basal and standardized medium for optimal production of alpha amylase. The production was increased 2-folds when soluble starch was replaced with pearl millet starch at 1% level and nutrient broth concentrations was reduced from 1% level to 0.5%. The newly selected fermentation medium containing (% w/v) wheat bran 1.25, nutrient broth 0.5, pearl millet starch 1.0, lactose 0.5, NaCl 0.5, CaCl2 0.2 in 100 ml of phosphate buffer. The kinetic values of Y(p/x), Y(p/s), and Q(p) indicated that the production of enzyme was greater in newly selected medium than the conventional more expensive medium.     

绿色木霉在啤酒糟基质上产纤维素酶条件的优化

对绿色木霉接种到啤酒糟固态发酵产纤维素酶的培养基和培养条件进行优化,考察发酵物料起始含水量、发酵时间、起始pH值等发酵条件,以及啤酒糟培养基中添加麸皮、氮源种类对产酶的影响。结果表明,以啤酒糟为发酵基质接种绿色木霉生产纤维素酶是可行的。经单因素和正交试验获得最适固态发酵的培养条件为:起始pH 5~6,培养温度28~30℃,发酵4 d;最佳发酵培养基组合为:麸皮比例30%,培养基起始含水量50%,(NH₄)₂SO₄添加量为2.0%~2.5%。     

用生料制备功能性双歧醋生产工艺的实验室研究

目的将双歧杆菌、醋酸菌、酵母菌和粉碎的制醋原料及麸曲共同发酵,通过生料制醋的方法来制备功能性双歧醋。方法将粉碎的玉米与麸曲、酵母液、麸皮和水搅拌均匀,使其经过液态糖化和酒精发酵后,接入醋酸菌和双歧杆菌(二者比例为1∶1),同时加入辅料,进行醋酸发酵,当检测到醋酸酸度为5.0%~7.5%时,加入食盐终止发酵,经过过滤,除菌澄清得到功能性双歧醋。结果双歧醋的最终醋酸度为3.2%,外观红棕色,光泽度好,清澈透明,无沉淀和悬浮物。总菌数:醋酸菌为3.3×1011/m l,双歧杆菌为1.9×107/m l;活菌数:醋酸菌为1.7×1011/m l,双歧杆菌为6.8×106/m l;大肠菌群数3个/100 m l;致病菌:不得检出。结论双歧杆菌及其代谢物可以在双歧醋中存活,生料固态发酵制备双歧醋的方法可行。     

人工饲料成分对甜菜夜蛾核多角体 病毒产量的影响

通过采取单因素和正交组合设计的方法,研究了甜菜夜蛾Spodoptera exigua人工饲料中黄豆粉、酵母粉和麦麸3种主要营养成分对甜菜夜蛾核多角体病毒产量的影响,同时获得甜菜夜蛾核多角体病毒高产优化组合方案：酵母粉7 g、黄豆粉14 g和麦麸6 g。此外,还研究了4种无机盐和1种非蛋白氮对甜菜夜蛾核多角体病毒产量的影响。     

The effects of culture media, solid substrates, and relative humidity on growth, sporulation and conidial discharge of Valdensinia heterodoxa

Valdensinia heterodoxa (Sclerotiniacae) is a potential fungal bioherbicide for control of salal (Gaultheria shallon). The effect of culture media, substrates and relative humidity (RH) on growth, sporulation and conidial discharge of V. heterodoxa was determined for two isolates PFC2761 and PFC3027 in vitro. Culture media significantly affected the growth, sporulation, and conidial discharge of V. heterodoxa. Of eight agar media used, colony radial growth was optimal on salal oatmeal agar and salal potato dextrose agar for isolates PFC2761 and PFC3027, respectively; whereas sporulation was at an optimum on salal oatmeal agar for both isolates. Of the eight liquid media tested, mycelial production was highest on wheat bran–salal–potato dextrose broth. Growth on solid substrates greatly stimulated sporulation and conidial discharge of V. heterodoxa. Of the 12 solid substrates used, the greatest numbers of discharged conidia were observed from wheat bran and wheat bran–salal within 14 d of sporulation. Sporulation on solid substrates continued for 42 d. RH significantly affected the sporulation and conidial discharge for both isolates across all solid substrates tested. No conidia were produced or discharged below 93 % RH on wheat bran–salal and millet. With an increase of the RH from 93 to 97 %, sporulation and the number of discharged conidia increased significantly for both isolates on wheat bran–salal, but not on millet.     

Influence of inocula and grains on sclerotia biomass and carotenoid yield of<Emphasis Type="Italic"> Penicillium</Emphasis> sp. PT95 during solid-state fermentation

Various inocula and grains were evaluated for carotenoid production by solid-state fermentation using Penicillium sp. PT95. Millet medium was more effective in both sclerotia growth and carotenoid production than other grain media. An inoculum in the form of sclerotia yielded higher sclerotia biomass compared to either a spore inoculum or a mycelial pellet inoculum. Adding wheat bran to grain medium favored the formation of sclerotia. However, neither the inoculum type nor addition of wheat bran resulted in a significant change in the carotenoid content of sclerotia. Among grain media supplemented with wheat bran (wheat bran:grain =1:4 w/w, dry basis), a medium consisting of rice and wheat bran gave the highest sclerotia biomass (15.10 g/100 g grain), a medium consisting of buckwheat and wheat bran gave the highest content of carotenoid in sclerotia (0.826 mg/g dry sclerotia), and a medium consisting of millet and wheat bran gave the highest carotenoid yield (11.457 mg/100 g grain).     

Production of cellulases by Thermomucor indicae-seudaticae: characterization of a thermophilic β-glucosidase

Abstract

The current study evaluated the production and characterization of β-glucosidase by the thermophilic fungus Thermomucor indicae-seudaticae in solid-state fermentation of wheat bran. Isolated fungi have significant amounts of β-glucosidase, an enzyme that may be applied to different industrial processes, such as the production of fuels, food, and other chemical compounds. Maximal enzyme activity occurred in pH 3.5–4.5 and at 70?°C. The enzyme exhibited high thermostability, for 1?h, up to 60?°C, and good tolerance to glucose (10?mM) and ethanol (10%). The optimization of fermentative parameters on the production of β-glucosidase was carried out by evaluating the best supplementary nutrient source, pH of nutrient solution, initial substrate moisture and fermentation temperature. The optimization of the above fermentation parameters increased enzyme activity by 120.0%. The highest enzymatic activity (164.0?U/g) occurred with wheat bran containing 70% initial moisture, supplemented with 1.0% (NH₄)₂SO₄ solution at pH 5.5–6.0 and fungus incubated at 40?°C. A more detailed study of β-glucosidase suggested that Sulfur is an important component of the main amino acid present in this enzyme. The enhancer of the enzyme activity occurred when the fungus was grown on wheat bran supplemented with a sulfur-containing solution. In fact, increasing the concentration of sulfur in the solution increased its activity.     

Production of cellulase-free endoxylanase from novel alkalophilic thermotolerent Bacillus pumilus by solid-state fermentation and its application in wastepaper recycling

The present study aimed at optimization of culture condition for the enhanced production of extra cellular thermostable cellulase-free xylanase from Bacillus pumilus by solid-state fermentation. Batch studies were carried out to evaluate various agro-industrial residues such as rice bran, rice husk, rice straw, sawdust, coconut pith, sugarcane bagasse and wheat bran for enzyme production by the bacterial culture. The endoxylanase production was highest on wheat bran media (5582 U/gds), which was enhanced 3.8-fold (21,431 U/gds) by optimization of cultivation conditions. The enzymatic extracts was used in mixed wastepaper recycling, which resulted in a considerable improvement of the paper strength with high drainage and easy drying up. The results of enzyme application with recycled paper clearly indicated that the effective use of enzymes in fiber separation could reduce the cost of carton paper production.