gTME构建共发酵木糖和葡萄糖的重组酿酒酵母

利用全转录工程（gTME）方法将全局转录因子spt15随机突变并克隆表达, 构建突变库。将突变基因连接到表达载体 pYX212上, 醋酸锂法转化入不利用木糖的酿酒酵母YPH499中, 经特定的培养基初筛获得高效利用木糖并共发酵木糖和葡萄糖的酿酒酵母重组菌株。对获得的重组菌株进行了初步研究, 该菌株能够很好的利用木糖并共发酵木糖和葡萄糖。在30oC, 200 r/min, 发酵96 h时, 50 g/L木糖和葡萄糖的利用率为94.0%和98.9%, 乙醇产率为32.4%和31.6%, 原始菌株乙醇产率为44.3%; 当木糖和葡萄糖以质量比1:1混合发酵时, 木糖和葡萄糖利用率分别为91.7%和85.9%, 乙醇产率为26%。木糖醇的含量极低。     

spt15突变基因对酿酒酵母木糖利用的影响

利用基因工程手段得到重组菌YPH499-3中的spt15有效突变基因,通过表达载体pYX212转化入酿酒酵母原始菌株YPH499中,重新获得酿酒酵母重组菌株。对其性状进行研究,结果表明该菌株能有效利用木糖并共发酵木糖和葡萄糖。在30oC、200r/min,发酵72h时,50g/L木糖的利用率为82.0%,乙醇产率为28.4%;当木糖和葡萄糖以质量比1:1混合发酵时,木糖和葡萄糖的利用率分别为80.4%和100%,乙醇产率为31.4%;同时发现木糖醇的含量极低。从而验证了有效突变基因spt15-10对酿酒酵母共发酵木糖和葡萄糖产酒精的影响。     

CIT2基因对突变酿酒酵母木糖利用影响的研究

木糖利用困难是秸秆燃料乙醇产业化的制约因素,改造酿酒酵母使其能够代谢木糖生成乙醇是当前研究的热点之一。为了研究CIT2基因对遗传改良酿酒酵母C5D-P-M菌株中葡萄糖与木糖共发酵过程中木糖利用的影响,设计引物并应用重叠PCR技术获得敲除CIT2基因的敲除组件,通过同源重组的方法将C5D-P-M中的CIT2基因敲除得到突变菌株C5D-P-M-CIT2Δ。通过对出发菌株和突变菌株的生长速率、葡萄糖利用率、木糖利用率及乙醇产量进行研究,结果表明突变菌株C5D-P-M-CIT2Δ的上述指标比出发菌株C5D-P-M均有一定程度的提高。因此推测,酿酒酵母中CIT2基因是影响木糖利用的因素之一,CIT2基因的敲除可提高酿酒酵母的木糖利用率。     

混合糖发酵重组酿酒酵母的菌株构建和菊芋秸秆同步糖化发酵研究

【目的】构建可用于纤维素乙醇高效生产的混合糖发酵重组酿酒酵母菌株,并利用菊芋秸秆为原料进行乙醇发酵。【方法】筛选在木糖中生长较好的酿酒酵母YB-2625作为宿主菌,构建木糖共代谢菌株YB-2625 CCX。进一步通过r DNA位点多拷贝整合的方式,以YB-2625 CCX为出发菌株构建木糖脱氢酶过表达菌株,并筛选得到优势菌株YB-73。采用同步糖化发酵策略研究YB-73的菊芋秸秆发酵性能。【结果】YB-73菌株以90 g/L葡萄糖和30 g/L木糖为碳源进行混合糖发酵,乙醇产量比出发菌株YB-2625 CCX提高了13.9%,副产物木糖醇产率由0.89 g/g降低至0.31 g/g,下降了64.6%。利用重组菌YB-73对菊芋秸秆进行同步糖化发酵,48 h最高乙醇浓度达到6.10%(体积比)。【结论】通过转入木糖代谢途径以及r DNA位点多拷贝整合过表达木糖脱氢酶基因可有效提高菌株木糖发酵性能,并用于菊芋秸秆的纤维素乙醇生产。这是首次报道利用重组酿酒酵母进行菊芋秸秆原料的纤维素乙醇发酵。     

一种基因工程改造的NADH高亲和力木糖还原酶突变基因可促进酿酒酵母发酵木糖生成乙醇

在导入表达毕赤酵母(Pichia stipitis)木糖还原酶(xylose reductase,XR)和木糖醇脱氢酶(xylitol dehydrogenase,XDH)基因的重组酿酒酵母中,木糖还原酶活性主要依赖辅酶NADPH,木糖醇脱氢酶活性依赖辅酶 NAD+,两者的辅助因子不同导致细胞内电子氧化还原的不平衡,是造成木糖醇积累,影响木糖代谢和乙醇产量的主要原因之一.将经过基因工程改造获得的NADH高亲和力的木糖还原酶突变基因m1,与毕赤酵母木糖醇脱氢酶(PsXDH)基因xyl2共转染酿酒酵母AH109,以转染毕赤酵母木糖还原酶(PsXR)基因xyl1和xyl2重组质粒的酵母细胞为对照菌株,在SC/-Leu/-Trp营养缺陷型培养基中进行筛选,获得的阳性转化子分别命名为AH-M-XDH和AH-XR-XDH.重组酵母在限制氧通气条件下对木糖和葡萄糖进行共发酵摇瓶培养,HPLC检测发酵底物的消耗和代谢产物的产出情况.结果显示,与对照菌株AH-XR-XDH相比,AH-M-XDH的木糖利用率明显提高,乙醇得率增加了16%,木糖醇产生下降了41.4%.结果证实,通过基因工程改造的木糖代谢关键酶,可用于酿酒酵母发酵木糖生产乙醇,其能通过改善酿酒酵母细胞内氧化还原失衡的问题,提高木糖利用率和乙醇产率.     

灭活原生质体融合选育木糖、葡萄糖共发酵酿酒酵母工程菌

为了选育高效利用木糖、葡萄糖共发酵,并使乙醇产量有所提高的酿酒酵母工程菌株。以酿酒酵母Saccharomyces cerevisiae W5和休哈塔假丝酵母Candida shehatae 20335为亲本株,确定了双亲株原生质体灭活剂量,并进行原生质体融合获得融合子,用高效液相色谱（HPLC）测定融合子以木糖、葡萄糖单碳源及混合碳源发酵时的乙醇得率。结果表明,获得一株发酵性能优良的融合子HDY2-14,其利用木糖和葡萄糖单碳源发酵的乙醇得率分别为0.213g/g和0.257g/g,混合碳源发酵的乙醇得率为0.310g/g,其中混合碳源乙醇得率比亲本株W5和20335的乙醇得率分别提高了20.2%和15.2%。     

木糖异构酶在酿酒酵母表面表达及对木糖代谢影响的初步研究

利用α-型酿酒酵母(Saccharomyces cerevisiae)表面展示系统的载体,将来源于嗜热细菌Thermus thermophilus的木糖异构酶基因xylA,插入到酿酒酵母蔗糖酶信号肽序列与α-凝集素的C端编码序列之间,形成融合表达框,构建重组质粒pSY-xy222,转化酿酒酵母H158。含重组质粒的菌株H158-SXI木糖异构酶活性测定表明,细胞壁上酶活测定值为1.53 U,木糖异构酶在酿酒酵母细胞壁上得到活性表达。木糖葡萄糖共发酵结果显示,重组菌株木糖利用率较出发菌株提高了17.8%。     

可同化阿拉伯糖的木糖还原酿酒酵母菌株构建

[目的] 以秸秆等木质纤维素类生物质为原料生产液体生物燃料乙醇,目前生产成本高,大规模工业化生产尚有较大难度。构建能同化阿拉伯糖进行木糖还原生产木糖醇的重组酿酒酵母菌株,以实现原料中全糖利用、生产高附加值产品,实现产品多元化。[方法] 首先,利用CRISPR/Cas9基因编辑技术依次向出发菌株中导入阿拉伯糖代谢途径和木糖还原酶基因,使菌株获得代谢阿拉伯糖和将木糖转化为木糖醇的能力;其次,通过适应性驯化的进化工程手段,提高重组菌株对阿拉伯糖的利用效率;最后,通过混合糖发酵验证重组菌株利用阿拉伯糖和还原木糖产木糖醇的能力。[结果] 通过导入植物乳杆菌的阿拉伯糖代谢途径,酿酒酵母菌株获得了较好的利用阿拉伯糖生长繁殖的能力;进一步导入假丝酵母的木糖还原酶基因后,重组菌株在葡萄糖作为辅助碳源条件下可高效还原木糖产木糖醇,但阿拉伯糖的利用能力下降。利用以阿拉伯糖为唯一碳源的培养基进行反复批次驯化,阿拉伯糖的利用能力得以恢复和提升,得到表型较好的重组菌株KAX3-2。该菌株在木糖（50 g/L）和阿拉伯糖（20 g/L）混合糖发酵条件下发酵72 h时,对阿拉伯糖和木糖利用率分别达到42.1%和65.9%,木糖醇的收率为64%。[结论] 本研究成功构建了一株能有效利用阿拉伯糖并能将木糖转化为木糖醇的重组酿酒酵母菌株KAX3-2,为后续构建、获得阿拉伯糖代谢能力更强、木糖醇积累效率更高菌株的工作奠定了基础。     

利用SPT3的定向进化提高工业酿酒酵母乙醇耐受性

利用对转录因子的定向进化可对多基因控制的性状进行有效的代谢工程改造。本研究对酿酒酵母负责胁迫相关基因转录的SAGA复合体成分SPT3编码基因进行易错PCR随机突变,并研究了SPT3的定向进化对酿酒酵母乙醇耐性的影响。将SPT3的易错PCR产物连接改造的pYES2.0表达载体并转化酿酒酵母Saccharomyces cerevisiae4126,构建了突变体文库。通过筛选在高浓度乙醇中耐受性提高的突变株,获得了一株在10%(V/V)乙醇中生长较好的突变株M25。该突变株利用125g/L的葡萄糖进行乙醇发酵时,终点乙醇产量比对照菌株提高了11.7%。由此表明,SPT3是对酿酒酵母乙醇耐性进行代谢工程改造的一个重要的转录因子。     

利用木糖-葡萄糖为原料产乙醇酵母的筛选、鉴定及发酵试验

建立筛选利用木糖为碳源产乙醇酵母模型,获得一株适合利用木质纤维素为原料产乙醇的酵母菌株。样品经麦芽汁培养基培养后,以木糖为唯一碳源的筛选培养基初筛,再以重铬酸钾显色法复筛。通过生理生化和26D1/D2区对筛选得到的菌株进行分析和鉴定,该菌初步鉴定为Pichia caribbica。经过筛选得到的菌株Y2-3以木糖（40g/L）为唯一碳源发酵时：生物量为23.5g/L,木糖利用率为94.7 %,乙醇终产量为4.57 g/L;以混合糖（葡萄糖40 g/L,木糖20 g/L）发酵时：生物量为28.6 g/L,木糖利用率为94.2 %,葡萄糖利用率为95.6%,乙醇终产量为20.6 g/L。Pichia caribbica是可以转化木糖及木糖-葡萄糖混合糖为乙醇的酵母菌株,为利用木质纤维素发酵乙醇的进一步研究奠定了基础。     

Alteration of xylose reductase coenzyme preference to improve ethanol production by Saccharomyces cerevisiae from high xylose concentrations

A K270R mutation of xylose reductase (XR) was constructed by site-direct mutagenesis. Fermentation results of the F106X and F106KR strains, which carried wild type XR and K270R respectively, were compared using different substrate concentrations (from 55 to 220 g/L). After 72 h, F106X produced less ethanol than xylitol, while F106KR produced ethanol at a constant yield of 0.36 g/g for all xylose concentrations. The xylose consumption rate and ethanol productivity increased with increasing xylose concentrations in F106KR strain. In particular, F106KR produced 77.6g/L ethanol from 220 g/L xylose and converted 100 g/L glucose and 100g/L xylose into 89.0 g/L ethanol in 72h, but the corresponding values of F106X strain are 7.5 and 65.8 g/L. The ethanol yield of F106KR from glucose and xylose was 0.42 g/g, which was 82.3% of the theoretical yield. These results suggest that the F106KR strain is an excellent producer of ethanol from xylose.     

大肠杆菌工程菌ptsG基因敲除及其缺陷株混合糖同型乙醇发酵

为实现可同时利用木糖和葡萄糖进行生产发酵,以产乙醇的大肠杆菌工程菌SZ470为出发菌株(△pflB,△frdABCD,△ackA,△ldhA),采用同源重组技术,敲除葡萄糖转运基因ptsG,以构建不受葡萄糖抑制效应影响的菌株SZ470P.SZ470P在5％混合糖(2.5％木糖和2.5％葡萄糖)培养基中能同时利用葡萄糖和木糖进行发酵,葡萄糖消耗量是13 g/L,为对照菌株SZ470的一半;木糖消耗量是20 g/L,是SZ470的3.8倍;乙醇的最高产量为15.01 g/L,转化率为89.13％,比SZ470提高了14.32％.结果表明,工程菌SZ470P可同时利用葡萄糖和木糖发酵生产高产量的乙醇.     

Repeated-batch fermentations of xylose and glucose-xylose mixtures using a respiration-deficient Saccharomyces cerevisiae engineered for xylose metabolism

Xylose-fermenting Saccharomyces strains are needed for commercialization of ethanol production from lignocellulosic biomass. Engineered Saccharomyces cerevisiae strains expressing XYL1, XYL2 and XYL3 from Pichia stipitis, however, utilize xylose in an oxidative manner, which results in significantly lower ethanol yields from xylose as compared to glucose. As such, we hypothesized that reconfiguration of xylose metabolism from oxidative into fermentative manner might lead to efficient ethanol production from xylose. To this end, we generated a respiration-deficient (RD) mutant in order to enforce engineered S. cerevisiae to utilize xylose only through fermentative metabolic routes. Three different repeated-batch fermentations were performed to characterize characteristics of the respiration-deficient mutant. When fermenting glucose as a sole carbon source, the RD mutant exhibited near theoretical ethanol yields (0.46 g g(-1)) during repeated-batch fermentations by recycling the cells. As the repeated-batch fermentation progressed, the volumetric ethanol productivity increased (from 7.5 to 8.3 g L(-1)h(-1)) because of the increased biomass from previous cultures. On the contrary, the mutant showed decreasing volumetric ethanol productivities during the repeated-batch fermentations using xylose as sole carbon source (from 0.4 to 0.3 g L(-1)h(-1)). The mutant did not grow on xylose and lost fermenting ability gradually, indicating that the RD mutant cannot maintain a good fermenting ability on xylose as a sole carbon source. However, the RD mutant was capable of fermenting a mixture of glucose and xylose with stable yields (0.35 g g(-1)) and productivities (0.52 g L(-1)h(-1)) during the repeated-batch fermentation. In addition, ethanol yields from xylose during the mixed sugar fermentation (0.30 g g(-1)) were higher than ethanol yields from xylose as a sole carbon source (0.21 g g(-1)). These results suggest that a strategy for increasing ethanol yield through respiration-deficiency can be applied for the fermentation of lignocellulosic hydrolyzates containing glucose and xylose.     

树干毕赤酵母NLP31发酵产乙醇的研究

研究了树干毕赤酵母NLP31在木糖质量浓度为45 g/L的3种发酵培养基Ⅰ、Ⅱ和Ⅲ上发酵3轮的发酵性能以及在45 g/L木糖或混合糖(葡萄糖30 g/L,木糖15 g/L)的发酵培养基Ⅲ上的代谢历程。结果表明:树干毕赤酵母NLP31在发酵培养基Ⅲ上,乙醇浓度和乙醇得率均达到最高,分别为(17.29±0.15)g/L和(84.65±0.58)%。在45 g/L木糖或混合糖(葡萄糖30 g/L,木糖15 g/L)的发酵培养基Ⅲ上的代谢历程表明:混合糖发酵达到最大乙醇得率的时间仅为12 h,要比单一木糖发酵缩短了8 h。树干毕赤酵母NLP31在以廉价的无机N源为发酵培养基上的乙醇发酵性能高,能够降低燃料乙醇的生产成本。     

Kinetics of growth and ethanol production on different carbon substrates using genetically engineered xylose-fermenting yeast

Saccharomyces cerevisiae 424A (LNH-ST) strain was used for fermentation of glucose and xylose. Growth kinetics and ethanol productivity were calculated for batch fermentation on media containing different combinations of glucose and xylose to give a final sugar concentration of 20+/-0.8 g/L. Growth rates obtained in pure xylose-based medium were less than those for media containing pure glucose and glucose-xylose mixtures. A maximum specific growth rate micro(max) of 0.291 h(-1) was obtained in YPD medium containing 20 g/L glucose as compared to 0.206 h(-1) in YPX medium containing 20 g/L xylose. In media containing combinations of glucose and xylose, glucose was exhausted first followed by xylose. Ethanol production on pure xylose entered log phase during the 12-24h period as compared to the 4-10h for pure glucose based medium using 2% inoculum. When glucose was added to fermentation flasks which had been initiated on a pure xylose-based medium, the rate of xylose usage was reduced indicating cosubstrate inhibition of xylose consumption by glucose.     

一株厌氧嗜热杆菌生长及发酵特性的初步研究

论文对筛选并鉴定为Thermoanaerobacterium saccharolyticum菌株的生长、底物利用情况、产物生成以及酒精耐受性进行了研究。结果表明,该菌在以甘露糖、葡萄糖和木糖为碳源时生长较好,同时能够较好的利用木聚糖和木薯淀粉;最适底物浓度为15g/L;不同的葡萄糖:木糖比例对其生长无显著影响;能耐受的培养基最高初始酒精浓度为3%(V/V)。在5g/L的木聚糖、木糖和木薯淀粉培养基中发酵60h后,产物主要有乙醇、乳酸和乙酸,乙醇产量分别为0.824、0.867和0.916g/L。     

Reduction of furan derivatives by overexpressing NADH-dependent Adh1 improves ethanol fermentation using xylose as sole carbon source with Saccharomyces cerevisiae harboring XR–XDH pathway

Several alcohol dehydrogenase (ADH)-related genes have been identified as enzymes for reducing levels of toxic compounds, such as, furfural and/or 5-hydroxymethylfurfural (5-HMF), in hydrolysates of pretreated lignocelluloses. To date, overexpression of these ADH genes in yeast cells have aided ethanol production from glucose or glucose/xylose mixture in the presence of furfural or 5-HMF. However, the effects of these ADH isozymes on ethanol production from xylose as a sole carbon source remain uncertain. We showed that overexpression of mutant NADH-dependent ADH1 derived from TMB3000 strain in the recombinant Saccharomyces cerevisiae, into which xylose reductase (XR) and xylitol dehydrogenase (XDH) pathway of Pichia stipitis has been introduced, improved ethanol production from xylose as a sole carbon source in the presence of 5-HMF. Enhanced furan-reducing activity is able to regenerate NAD⁺ to relieve redox imbalance, resulting in increased ethanol yield arising from decreased xylitol accumulation. In addition, we found that overexpression of wild-type ADH1 prevented the more severe inhibitory effects of furfural in xylose fermentation as well as overexpression of TMB3000-derived mutant. After 120 h of fermentation, the recombinant strains overexpressing wild-type and mutant ADH1 completely consumed 50 g/L xylose in the presence of 40 mM furfural and most efficiently produced ethanol (15.70 g/L and 15.24 g/L) when compared with any other test conditions. This is the first report describing the improvement of ethanol production from xylose as the sole carbon source in the presence of furan derivatives with xylose-utilizing recombinant yeast strains via the overexpression of ADH-related genes.     

Improvement in ethanol productivity of engineered <Emphasis Type="Italic">E. coli</Emphasis> strain SSY13 in defined medium via adaptive evolution

E. coli has the ability to ferment both C5 and C6 sugars and produce mixture of acids along with small amount of ethanol. In our previous study, we reported the construction of an ethanologenic E. coli strain by modulating flux through the endogenous pathways. In the current study, we made further changes in the strain to make the overall process industry friendly; the changes being (1) removal of plasmid, (2) use of low-cost defined medium, and (3) improvement in consumption rate of both C5 and C6 sugars. We first constructed a plasmid-free strain SSY13 and passaged it on AM1–xylose minimal medium plate for 150 days. Further passaging was done for 56 days in liquid AM1 medium containing either glucose or xylose on alternate days. We observed an increase in specific growth rate and carbon utilization rate with increase in passage numbers until 42 days for both glucose and xylose. The 42nd day passaged strain SSK42 fermented 113 g/L xylose in AM1 minimal medium and produced 51.1 g/L ethanol in 72 h at 89% of maximum theoretical yield with ethanol productivity of 1.4 g/L/h during 24–48 h of fermentation. The ethanol titer, yield and productivity were 49, 40 and 36% higher, respectively, for SSK42 as compared to unevolved SSY13 strain.