过量表达烟酸转磷酸核糖激酶对大肠杆菌NZN111产丁二酸的影响

大肠杆菌NZN111厌氧发酵的主要产物为丁二酸,是发酵生产丁二酸的潜力菌株。但是由于敲除了乳酸脱氢酶的编码基因 (ldhA) 和丙酮酸甲酸裂解酶的编码基因 (pflB),导致辅酶NADH/NAD+不平衡,厌氧条件下不能利用葡萄糖生长代谢。构建烟酸转磷酸核糖激酶的重组菌Escherichia coli NZN111/pTrc99a-pncB,在厌氧摇瓶发酵过程中通过添加0.5 mmol/L的烟酸、0.3 mmol/L的IPTG诱导后重组菌的烟酸转磷酸核糖激酶 (Nicotinic acid phosphor     

过量表达烟酸单核苷酸腺苷酰转移酶对大肠杆菌NZN111产丁二酸的影响

大肠杆菌NZN111是敲除了乳酸脱氢酶的编码基因(ldhA)和丙酮酸-甲酸裂解酶的编码基因(pflB)的发酵生产丁二酸的潜力菌株。厌氧条件下NADH不能及时再生为NAD+,引起胞内辅酶NAD(H)的不平衡,最终导致厌氧条件下菌株不能利用葡萄糖生长代谢。nadD为催化NAD(H)合成途径中烟酸单核苷酸(NaMN)生成烟酸腺嘌呤二核苷酸(NaAD)的烟酸单核苷酸腺苷酰转移酶(Nicotinic acid mononucleotide adenylyltransferase,NAMNAT)的编码基因,通过过量表达nadD基因能够提高NAD(H)总量与维持合适的NADH/NAD+比例。文中构建了重组菌E.coli NZN111/pTrc99a-nadD,在厌氧摇瓶发酵过程中通过添加终浓度为1.0 mmol/L的IPTG诱导表达,重组菌E.coli NZN111/pTrc99a-nadD中NAD+和NADH的浓度分别比宿主菌E.coli NZN111提高了3.21倍和1.67倍,NAD(H)总量提高了2.63倍,NADH/NAD+从0.64降低为0.41,使重组菌株恢复了厌氧条件下生长和代谢葡萄糖的能力。重组菌与对照菌相比,72 h内可以消耗14.0 g/L的葡萄糖产6.23 g/L的丁二酸,丁二酸产量增加了19倍。     

共表达烟酸转磷酸核糖激酶和丙酮酸羧化酶对大肠杆菌NZN111产丁二酸的影响

构建了共表达烟酸转磷酸核糖激酶(NAPRTase)和丙酮酸羧化酶(PYC)的重组质粒pTrc99a-pncB-pyc,并考察了重组菌E.coli NZN111/pTrc99a-pncB-pyc生产丁二酸的能力。结果表明:重组菌NZN111/pTrc99a-pncB-pyc的NAPRTase和PYC的比酶活达到最高,分别为20.75和1.04 U/mg,同时,辅酶NADH、NAD+及NAD(H)总量达到最高。厌氧摇瓶发酵结果:48 h能够消耗17.5 g/L的葡萄糖生成14.08 g/L的丁二酸,而丙酮酸的产量大幅度降低,仅为0.11 g/L。本研究为基因工程菌大肠杆菌厌氧条件下发酵生产丁二酸提供了一定的基础。     

基于辅因子调控对大肠杆菌两阶段发酵产丁二酸的影响

考察了E.coli NZN111及其重组菌株E.coli NZN111/pTrc99a-pncB发酵生产丁二酸的性能。E.coli NZN111两阶段发酵丁二酸的同时,会造成丙酮酸的大量积累。研究发现:通过过量表达烟酸转磷酸核糖激酶,两阶段发酵重组菌株E.coli NZN111/pTrc99a-pncB,减少丙酮酸的积累且无副产物乙酸生成,提高丁二酸的产量,丁二酸得率和耗糖速率分别提高了139%和20%。     

过量表达苹果酸酶对E.coli FMJ39厌氧混合酸发酵的影响

为了考察苹果酸酶对厌氧混合酸发酵影响,从E.coli DH5α中PCR扩增苹果酸酶（NAD+-dependent, E.C1.1.1.38）基因sfcA,插入质粒pTrc99a构建了表达质粒pTrc99a-sfcA,有氧和厌氧的条件下,IPTG诱导在E.coli FMJ39（ldh,pfl）中均获得大量表达,从而构建和加强了一条在厌氧混合酸发酵中微弱的代谢途径。厌氧发酵结果表明,过量表达苹果酸酶会影响混合酸发酵中甲酸、乙酸、丁二酸途径。重组FMJ39甲酸和乙酸的量分别比FMJ39提高了17.58%和15.27%,丁二酸的量降低了26.87%,柠檬酸的量变化不大。证实即使pfl基因缺陷,高浓度的L-Thr和L-Ser也会诱导Tdc 操纵元把丙酮酸转化为甲酸和乙酸。实验结果为进一步改造和利用FMJ39奠定了基础。     

过量表达苹果酸脱氢酶对大肠杆菌NZN111产丁二酸的影响

大肠杆菌NZN111是敲除了乳酸脱氢酶的编码基因 (ldhA) 和丙酮酸-甲酸裂解酶的编码基因 (pflB) 的工程菌,厌氧条件下由于辅酶NAD(H) 的不平衡导致其丧失了代谢葡萄糖的能力。构建了苹果酸脱氢酶的重组菌大肠杆菌NZN111/pTrc99a-mdh,在厌氧摇瓶发酵过程中通过0.3 mmol/L的IPTG诱导后重组菌的苹果酸脱氢酶 (Malate dehydrogenase,MDH) 酶活较出发菌株提高了14.8倍,NADH/NAD+的比例从0.64下降到0.26,同时NAD+和NADH浓度分别     

乳糖诱导丙酮酸羧化酶基因在大肠杆菌中的表达及对丁二酸产量的影响

大肠杆菌DC1515是敲除葡萄糖磷酸转移酶(ptsG)、乳酸脱氢酶(ldhA)、丙酮酸甲酸裂解酶(pflA)基因的菌株,具有发酵生产丁二酸的潜力。为进一步提高菌株DC1515的丁二酸生产能力,将枯草芽孢杆菌丙酮酸羧化酶(pyc)基因转入其中。用乳糖代替IPTG诱导pyc表达,确定了最佳乳糖加入时间、乳糖浓度及诱导温度。在此基础上,考察了补加乳糖对丁二酸产量的影响。结果表明:由于ptsG基因缺失,当培养基中葡萄糖浓度达到15g/L时,乳糖诱导作用并不受葡萄糖抑制。优化诱导条件后,pyc过表达菌株的丁二酸产量达15.17g/L,为对照菌株的1.78倍。间歇补加乳糖2次至浓度为1g/L,丁二酸产量可进一步增至17.54g/L。研究结果为以葡萄糖为底物生产丁二酸的过程中乳糖诱导外源基因在大肠杆菌中的表达奠定了基础。乳糖诱导降低了成本,有利于实现丁二酸发酵生产的工业化。     

烟酸转磷酸核糖激酶和丙酮酸羧化酶共表达对大肠杆菌BA002产丁二酸的影响

大肠杆菌BA002是敲除了乳酸脱氢酶的编码基因 (ldhA) 和丙酮酸-甲酸裂解酶的编码基因 (pflB) 的工程菌。厌氧条件下NADH不能及时再生为NAD+,引起胞内辅酶NAD(H)的不平衡,最终导致厌氧条件下菌株不能利用葡萄糖生长代谢。pncB是烟酸转磷酸核糖激酶 (NAPRTase) 的编码基因,通过过量表达pncB基因能够提高NAD(H)总量与维持合适的NADH/NAD+,从而恢复了厌氧条件下重组菌E. coli BA014 (BA002/pTrc99a-pncB) 的生长和产丁二酸的性能。然而,BA014在厌氧发酵过程中有大量丙酮酸积累,为进一步提高菌株的丁二酸生产能力,减少副产物丙酮酸的生成,共表达NAPRTase和来自于乳酸乳球菌 NZ9000中丙酮酸羧化酶 (PYC) 的编码基因pyc,构建了重组菌E. coli BA016 (BA002/pTrc99a-pncB-pyc)。3 L发酵罐结果表明,BA016发酵112 h后,共消耗了35.00 g/L的葡萄糖。发酵结束时,菌体OD600为4.64,产生了25.09 g/L丁二酸。通过共表达pncB和pyc基因,使BA016的丙酮酸积累进一步降低,丁二酸产量进一步提高。     

碳源对重组大肠杆菌两阶段发酵产丁二酸的影响

研究了在好氧培养基中分别添加不同碳源对两阶段发酵菌体生长、酶活及代谢产物分布的影响,结果表明添加4mmol/L葡萄糖和12,54,80mmol/L乙酸钠均可以提高好氧阶段的菌体密度和相关酶活。将不同条件下培养的菌体转接厌氧发酵后,厌氧阶段的酶活和代谢产物分布也发生改变。进一步对酶活及代谢产物分析表明：Escherichia coli NZN111(sfcA)厌氧发酵过程中,磷酸烯醇式丙酮酸羧化激酶(PCK)是产丁二酸的关键酶,丙酮酸激酶(PYK)主要和副产物丙酮酸的积累有关,异柠檬酸裂解酶(ICL)对丁二酸产量也有一定影响。好氧培养基中添加80mmol/L乙酸钠,厌氧发酵结束时丁二酸的质量收率可达89.0%,相比对照提高了16.6%。     

产琥珀酸重组大肠杆菌的发酵性能研究

研究了重组大肠杆菌JM001(△ppc)/pTrc99a-pck发酵产琥珀酸的性能,结果表明厌氧条件下其耗糖能力和产酸能力分别为对照菌株JM001的4.2倍和15.3倍。进一步优化发酵条件表明：采用接入菌泥的发酵方式比按照10%接种量转接厌氧发酵的效果要好,琥珀酸的对葡萄糖的质量收率提高了约10%,且副产物乙酸的量进一步降低。初始葡萄糖浓度高于60g/L时会对菌株的生长和产酸产生抑制,且浓度越高,抑制作用越明显。7L发酵罐放大实验中,整个厌氧发酵阶段葡萄糖的消耗速率为0.42g/(L.h),琥珀酸对葡萄糖的质量收率为67.75%,琥珀酸的生产强度为0.28g/(L.h)。     

Effects of growth mode and pyruvate carboxylase on succinic acid production by metabolically engineered strains of Escherichia coli

Escherichia coli NZN111, which lacks activities for pyruvate-formate lyase and lactate dehydrogenase, and AFP111, a derivative which contains an additional mutation in ptsG (a gene encoding an enzyme of the glucose phophotransferase system), accumulate significant levels of succinic acid (succinate) under anaerobic conditions. Plasmid pTrc99A-pyc, which expresses the Rhizobium etli pyruvate carboxylase enzyme, was introduced into both strains. We compared growth, substrate consumption, product formation, and activities of seven key enzymes (acetate kinase, fumarate reductase, glucokinase, isocitrate dehydrogenase, isocitrate lyase, phosphoenolpyruvate carboxylase, and pyruvate carboxylase) from glucose for NZN111, NZN111/pTrc99A-pyc, AFP111, and AFP111/pTrc99A-pyc under both exclusively anaerobic and dual-phase conditions (an aerobic growth phase followed by an anaerobic production phase). The highest succinate mass yield was attained with AFP111/pTrc99A-pyc under dual-phase conditions with low pyruvate carboxylase activity. Dual-phase conditions led to significant isocitrate lyase activity in both NZN111 and AFP111, while under exclusively anaerobic conditions, an absence of isocitrate lyase activity resulted in significant pyruvate accumulation. Enzyme assays indicated that under dual-phase conditions, carbon flows not only through the reductive arm of the tricarboxylic acid cycle for succinate generation but also through the glyoxylate shunt and thus provides the cells with metabolic flexibility in the formation of succinate. Significant glucokinase activity in AFP111 compared to NZN111 similarly permits increased metabolic flexibility of AFP111. The differences between the strains and the benefit of pyruvate carboxylase under both exclusively anaerobic and dual-phase conditions are discussed in light of the cellular constraint for a redox balance.     

Production of succinate by a <Emphasis Type="Italic">pfl</Emphasis>B <Emphasis Type="Italic">ldh</Emphasis>A double mutant of <Emphasis Type="Italic">Escherichia coli</Emphasis> overexpressing malate dehydrogenase

The gene encoding malate dehydrogenase (MDH) was overexpressed in a pflB ldhA double mutant of Escherichia coli, NZN111, for succinic acid production. With MDH overexpression, NZN111/pTrc99A-mdh restored the ability to metabolize glucose anaerobically and 0.55 g/L of succinic acid was produced from 3 g/L of glucose in shake flask culture. When supplied with 10 g/L of sodium bicarbonate (NaHCO₃), the succinic acid yield of NZN111/pTrc99A-mdh reached 1.14 mol/mol glucose. Supply of NaHCO₃ also improved succinic acid production by the control strain, NZN111/pTrc99A. Measurement of key enzymes activities revealed that phosphoenolpyruvate (PEP) carboxykinase and PEP carboxylase in addition to MDH played important roles. Two-stage culture of NZN111/pTrc99A-mdh was carried out in a 5-L bioreactor and 12.2 g/L of succinic acid were produced from 15.6 g/L of glucose. Fed-batch culture was also performed, and the succinic acid concentration reached 31.9 g/L with a yield of 1.19 mol/mol glucose.     

Effects of Growth Mode and Pyruvate Carboxylase on Succinic Acid Production by Metabolically Engineered Strains of Escherichia coli

Escherichia coli NZN111, which lacks activities for pyruvate-formate lyase and lactate dehydrogenase, and AFP111, a derivative which contains an additional mutation in ptsG (a gene encoding an enzyme of the glucose phophotransferase system), accumulate significant levels of succinic acid (succinate) under anaerobic conditions. Plasmid pTrc99A-pyc, which expresses the Rhizobium etli pyruvate carboxylase enzyme, was introduced into both strains. We compared growth, substrate consumption, product formation, and activities of seven key enzymes (acetate kinase, fumarate reductase, glucokinase, isocitrate dehydrogenase, isocitrate lyase, phosphoenolpyruvate carboxylase, and pyruvate carboxylase) from glucose for NZN111, NZN111/pTrc99A-pyc, AFP111, and AFP111/pTrc99A-pyc under both exclusively anaerobic and dual-phase conditions (an aerobic growth phase followed by an anaerobic production phase). The highest succinate mass yield was attained with AFP111/pTrc99A-pyc under dual-phase conditions with low pyruvate carboxylase activity. Dual-phase conditions led to significant isocitrate lyase activity in both NZN111 and AFP111, while under exclusively anaerobic conditions, an absence of isocitrate lyase activity resulted in significant pyruvate accumulation. Enzyme assays indicated that under dual-phase conditions, carbon flows not only through the reductive arm of the tricarboxylic acid cycle for succinate generation but also through the glyoxylate shunt and thus provides the cells with metabolic flexibility in the formation of succinate. Significant glucokinase activity in AFP111 compared to NZN111 similarly permits increased metabolic flexibility of AFP111. The differences between the strains and the benefit of pyruvate carboxylase under both exclusively anaerobic and dual-phase conditions are discussed in light of the cellular constraint for a redox balance.     

Increased production of succinic acid in Escherichia coli by overexpression of malate dehydrogenase

Escherichia coli NZN111 is a double mutant with inactivated lactate dehydrogenase and pyruvate formate-lyase. It cannot utilize glucose anaerobically because of its unusually high intracellular NADH/NAD(+) ratio. We have now constructed a recombinant strain, E. coli NZN111/pTrc99a-mdh, which, during anaerobic fermentation, produced 4.3 g succinic acid l(-1) from 13.5 g glucose l(-1). The NADH/NAD(+) ratio decreased from 0.64 to 0.26. Furthermore, dual-phase fermentation (aerobic growth followed by anaerobic phase) resulted in enhanced succinic acid production and reduced byproduct formation. The yield of succinic acid from glucose during the anaerobic phase was 0.72 g g(-1), and the productivity was 1.01 g l(-1) h(-1).