嗜碱芽孢杆菌NTT33产碱性β-甘露聚糖酶发酵条件的研究及高产菌株选育

研究了嗜碱芽孢杆菌（ａｌｋａｌｏｐｈｉｌｉｃＢａｃｌｕｓｓｐ．）ＮＴＴ３３发酵产生胞外碱性β－甘露聚糖酶的条件,其最佳碳源为１％槐豆角,最佳氮源为１％蛋白胨＋０．２％酵母膏,发酵培养３６ｈ产酶量最高（达６１．３υ／ｍＬ）。甘油,葡萄糖,甘露糖等对产酶有强的阻遏作用。该菌株经紫外诱变处理后,采用透明圈法初步筛选出在含葡萄糖和不含葡萄糖的槐豆胶培养基上同时产生透明圈的菌株,进一步测定其产酶进程曲线,最后筛选到一株（ＮＴＴ３３－ｒ６）部分消除葡萄糖代谢阻遏高产β－甘露聚糖酶的菌株,其酶活力比出发菌株提高５０％,,达到９６．３Ｕ／ｍｌ;。     

Characterization of an outer membrane mannanase from Bacteroides ovatus

Bacteroides ovatus utilizes guar gum, a high-molecular-weight branched galactomannanan, as a sole source of carbohydrate. No extracellular activity was detectable. Approximately 30% of the total cell-associated mannanase activity partitioned with cell membranes. When inner and outer membranes of B. ovatus were separated on sucrose gradients, the mannanase activity was associated mainly with fractions containing outer membranes. Enzyme activity was solubilized by 3-[(3-cholamidopropyl)dimethylammonio]-1-propanesulfonate (CHAPS) or by Triton X-100 at a detergent-to-protein ratio of 1:1. The enzyme was stable for only 4 h at 37 degrees C and for 50 to 60 h at 4 degrees C. Analysis of the products of the CHAPS-solubilized mannanase on Bio-Gel A-5M and Bio-Gel P-10 gel filtration columns indicated that the enzyme breaks guar gum into high-molecular-weight fragments. The CHAPS-solubilized mannanase was partially purified by chromatography on a FPLC Mono Q column. The partially purified mannanase preparation contained three major polypeptides (Mr 94,500, 61,000, and 43,000) and several minor ones. High mannanase activity was seen only when B. ovatus was grown on guar gum. Cross-absorbed antiserum detected two other guar gum-associated outer membrane proteins: a CHAPS-extractable 49,000-dalton polypeptide and a 120,000-dalton polypeptide that was not solubilized by CHAPS. Neither of these polypeptides was detectable in the partially purified mannanase preparation. These results indicate that there are at least two guar gum-associated outer membrane polypeptides other than the mannanase.     

植酸酶和甘露聚糖酶双功能毕赤酵母工程菌的构建和产酶分析

根据已发表的植酸酶基因和甘露聚糖酶基因序列设计并合成引物,应用PCR技术,分别以土曲霉总DNA和质粒pHBM1201为模板,扩增出均不含假定信号肽序列的植酸酶基因phyA和甘露聚糖酶基因man,将它们各自克隆到毕赤酵母表达载体pHBM907C上,分别得到重组质粒pHBM907C-phyA和pHBM907C-man。将质粒pHBM907C-phyA上由乙醇氧化酶(AOX1)启动子和终止子引导表达、酿酒酵母α信号肽序列引导分泌的phyA表达盒式结构插入到质粒pHBM907C-man中,构成双基因表达分泌质粒pHBM907C-phyA-man。pHBM907C-phyA-man经SalⅠ酶切线性后转化毕赤酵母(Pichiapastoris)GS115,获得了同时分泌表达植酸酶和甘露聚糖酶的双功能酵母工程菌。研究了该酵母工程菌所分泌表达的重组植酸酶和甘露聚糖酶的相关酶学性质,并进行了双功能酵母工程菌的稳定性测试。     

Characterization of the Bacillus subtilis WL-3 mannanase from a recombinant Escherichia coli

A mannanase was purified from a cell-free extract of the recombinant Escherichia coli carrying a Bacillus subtilis WL-3 mannanase gene. The molecular mass of the purified mannanase was 38 kDa as estimated by SDS-PAGE. Optimal conditions for the purified enzyme occurred at pH 6.0 and 60 degrees C. The specific activity of the purified mannanase was 5,900 U/mg on locust bean gum (LBG) galactomannan at pH 6.0 and 50 degrees C. The activity of the enzyme was slightly inhibited by Mg(2+), Ca(2+), EDTA and SDS, and noticeably enhanced by Fe(2+). When the enzyme was incubated at 4 degrees C for one day in the presence of 3 mM Fe(2+), no residual activity of the mannanase was observed. The enzyme showed higher activity on LBG and konjac glucomannan than on guar gum galactomannan. Furthermore, it could hydrolyze xylans such as arabinoxylan, birchwood xylan and oat spelt xylan, while it did not exhibit any activities towards carboxymethylcellulose and para-nitrophenyl-beta-mannopyranoside. The predominant products resulting from the mannanase hydrolysis were mannose, mannobiose and mannotriose for LBG or mannooligosaccharides including mannotriose, mannotetraose, mannopentaose and mannohexaose. The enzyme could hydrolyze mannooligosaccharides larger than mannobiose.     

Xylanase and Mannanase enzymes from Streptomyces galbus NR and their use in biobleaching of softwood kraft pulp

Enzymatic pretreatment of softwood kraft pulp was investigated using xylanase and mannanase, singly or in combination, either sequentially or simultaneously. Enzymes were obtained from Streptomyces galbus NR that had been cultivated in a medium, containing either xylan of sugar cane bagasse or galactomannan of palm-seeds, when they were used as sole carbon sources from local wastes in fermentation media. No cellulase activity was detected. Incubation period, temperature, initial pH values and nature of nutritive constituents were investigated. Optimum production of both enzymes was achieved after 5 days incubation on a rotary shaker (200 rpm) at 35 degrees C and initial pH 7.0. Partial purification of xylanase and mannanase in the cultures supernatant were achieved by salting out at 40-60 and 60-80% ammonium sulphate saturation with a purification of 9.63- and 8.71-fold and 68.80 and 62.79% recovery, respectively. The xylanase and mannanase from S. galbus NR have optimal activity at 50 and 40 degrees C, respectively. Both enzymes were stable at a temperature up to 50 degrees C. Xylanase and mannanase showed highest activity at pH 6.5 and were stable from 5.0 to 8.0 and from 5.5 to 7.5, respectively. The partial purified enzymes preparations of xylanase and mannanase enzymes showed high bleaching activity, which is an important consideration for industry. Xylanase was found to be more effective for paper-bleaching than mannanase. When xylanase and mannanase were dosed together (simultaneously), both enzymes were able to enhance the liberation of reducing sugars and improve pulp bleachability, possibly as a result of nearly additive interactions. The simultaneous addition of both enzymes was more effective in pulp treatment than their sequential addition.     

芽孢杆菌M50产生β—甘露聚糖酶的条件研究

从土壤中分离到９株产生β－甘露聚糖酶的芽孢杆菌（Ｂａｃｉｌｌｕｓ ｓｐ．）。Ｂａｃｉｌｌｕｓ ｓｐ．Ｍ５０２５０ｍＬ三角瓶摇瓶培养试验,以４％的魔芋粉为碳源,１．０％（ＮＨ４）２ＳＯ４为氮源,０．３５％Ｎａ２ＣＯ３,３０～３４℃培养６０ｈ产酶达到高峰。酶活力为１８０～２２０ｕ／ｍＬ。１００Ｌ罐发酵,在３０～３２℃,１：０．７５ｖｖｍ通气量,２００ｒ／ｍｉｎ条件下,发酵液酶活力高达３３０ｕ／ｍＬ。     

Hemicellulases of Bacillus species: preliminary comparative studies on production and properties of mannanases and galactanases

A range of Bacillus subtilis strains and other Bacillus species were screened for mannanase, β-mannosidase and galactanase activities. Maximum mannanase activity, 106.2 units/ml, was produced by B. subtilis NRRL 356. β-Mannosidase and galactanase activities from all strains were relatively low. The effect of carbon and nitrogen source on mannanase and galactanase production by B. brevis ATCC 8186, B. licheniformis ATCC 27811, B. polymyxa NRRL 842 and B. subtilis NRRL 356 was investigated. Highest mannanase production was observed in the four strains tested when the mannan substrate, locust bean gum, was used as carbon source. Induction was most dramatic in the case of B. subtilis NRRL 356 where only basal enzyme levels were produced in the presence of other carbon sources. β-Mannosidase was induced in the four Bacillus cultures by locust bean gum. Results indicated that galactose acted as an inducer for production of galactanase. Organic and inorganic nitrogen sources resulted in induction of high mannanase titres in B. subtilis. Highest galactanase activity was produced by each organism in media containing sodium nitrate as nitrogen source. Mannanases from B. brevis, B. licheniformis, B. polymyxa and B. subtilis retained 100% residual activity after a 3 h incubation at 65°C, 65°C, 60°C and 55°C respectively. Galactanases retained more than 95% activity at 55°C after 3 h. The pH optima of mannanases ranged from 6.5–6.8 whereas galactanases ranged from 5.1 in the case of B. brevis to 7.0 for B. polymyxa.     

NADP+ production using thermostable NAD+ kinase of corynebacterium flaccumfaciens AHU-1622

A sonicate of Corynebacterium flaccumfaciens AHU-1622 had the highest NAD+ kinase activity (1.22 mU/mL culture broth) of the strains of bacteria we investigated. This enzyme was thermostable, with activity maintained at 50 degrees C for 1 h. This treatment inactivated phosphatase activity. Resting cells of the bacterium also had NAD+ kinase activity when treated at 60 degrees C for 30 min with 0.2% Triton X-100. NADP+ production was achieved using 8 mumol NAD+, 8 mumol ATP, 16 mumol MgCl2, 1.6 mumol NaN3, and 12 mU NAD+ kinase (0.1 g of permeabilized wet cells) in 2 mL of 0.1 M phosphate buffer, pH 7.5. The conversion ratio of NADP+ from NAD+ was 75% after 10 h of incubation at 50 degrees C, and the amount of accumulated NADP+ was 3 mumol/mL of reaction mixture. The NAD+ kinase activity of the permeabilized cells was stable and did not decrease after repeated use.     

A beta-mannanase from Bacillus subtilis B36: purification, properties, sequencing, gene cloning and expression in Escherichia coli

MANB36, a secrete endo-beta-1,4-D-mannanase produced by Bacillus subtilis B36, was purified to homogeneity from a culture supernatant and characterized. The optimum pH value for the mannanase activity of MANB36 is 6.4 and the optimum temperature is 50 degrees C. The enzyme activity of MANB36 is remarkably thermostable at 60 degrees C and the specific activity of MANB36 is 927.84 U/mg. Metal cations (except Hg2+ and Ag+), EDTA and 2-mercaptoethanol (2-ME) have no effects on enzyme activity. This enzyme exhibits high specificity with the substituted galactomannan locust bean gum (LBG). The gene encoding for MANB36, manB36, was cloned by PCR and sequenced. manB36 contains a single open reading frame (ORF) consisting of 1104 bp that encodes a protein of 367 amino acids. The predicted molecular weight of 38.13 kDa, calculated by the deduced protein of the gene manB36 without signal peptide, coincides with the apparent molecular weight of 38.0 kDa of the purified MANB36 estimated by SDS-PAGE. The mature protein of MANB36 has been expressed in Escherichia coli BL21 and the expressed mannanase has normal bioactivity.     

Purification and biochemical properties of a galactooligosaccharide producing β-galactosidase from Bullera singularis

A beta-galactosidase, catalyzing lactose hydrolysis and galactooligosaccharide (GalOS) synthesis from lactose, was extracted from the yeast, Bullera singularis KCTC 7534. The crude enzyme had a high transgalactosylation activity resulting in the oligosaccharide conversion of over 34% using pure lactose and cheese whey permeate as substrates. The enzyme was purified by two chromatographic steps giving 96-fold purification with a yield of 16%. The molecular weight of the purified enzyme (specific activity of 56 U mg(-1)) was approx. 53 000 Da. The hydrolytic activity was the highest at pH 5 and 50 degrees C, and was stable to 45 degrees C for 2 h. Enzyme activity was inhibited by 10 mM Ag3+ and 10 mM SDS. The Km for lactose hydrolysis was 0.58 M and the maximum reaction velocity (V(max)) was 4 mM min(-1). GalOS, including tri- and tetra-saccharides were produced with a conversion yield of 50%, corresponding to 90 g GalOS l(-1) from 180 g lactose l(-1) by the purified enzyme.     

Cold-adapted yeasts as producers of cold-active polygalacturonases

Eight cold-adapted, polygalacturonase-producing yeasts belonging to four species were isolated from frozen environmental samples in Iceland. They were identified as Cystofilobasidium lari-marini, Cystofilobasidium capitatum, Cryptococcus macerans and Cryptococcus aquaticus species by sequence analysis of rDNA regions. Growth behavior of the isolates was investigated. All strains could grow at 2 degrees C. Addition of glucose to pectin-containing culture medium had a repressive effect on enzyme production except for C. aquaticus, which showed increased polygalacturonase activity. Optimal temperature for enzyme production for the Cystofilobasidium strains was 14 degrees C, while that for the Cryptococcus strains was lower. Among the isolates, C. lari-marini S3B produced highest levels of enzyme activity at pH 3.2. Preliminary characterization of the polygalacturonases in the culture supernatant showed the enzyme from Cystofilobasidium strains to be optimally active at 40 degrees C and pH 5, and that from the Cryptococcus strains at 50 degrees C and pH 4. The polygalacturonase from C. macerans started to lose activity after 1 h of incubation at 40 degrees C, while that from the other strains had already lost activity at 30 degrees C. All the strains except C. aquaticus produced isoenzymes of polyglacturonase. In addition to polygalacturonase, the Cystofilobasidium strains produced pectin lyase, C. aquaticus pectin esterase, and C. macerans pectin lyase, pectate lyase and pectin esterase.     

Production and characterization of a thermostable alpha-amylase from Nocardiopsis sp. endophyte of yam bean

Thermostable amylolytic enzymes have been currently investigated to improve industrial processes of starch degradation. Studies on production of alpha-amylase by Nocardiopsis sp., an endophytic actinomycete isolated from yam bean (Pachyrhizus erosus L. Urban), showed that higher enzyme levels were obtained at the end of the logarithmic growth phase after incubation for 72 h at pH 8.6. Maximum activity of alpha-amylase was obtained at pH 5.0 and 70 degrees C. The isolated enzyme exhibited thermostable properties as indicated by retention of 100% of residual activity at 70 degrees C, and 50% of residual activity at 90 degrees C for 10 min. Extracellular enzyme from Nocardiopsis sp. was purified by fractional precipitation with ammonium sulphate. After 60% saturation produced 1130 U mg-1 protein and yield was 28% with purification 2.7-fold. The enzyme produced by Nocardiopsis sp. has potential for industrial applications.     

里氏木霉内切-β-甘露聚糖酶基因在毕赤酵母中的表达

采用PCR方法从里氏木霉(Trichoderma reesei)基因组中获得含有两个内含子的内切-β-甘露聚糖酶全长基因,末端重叠延伸PCR去除内含子后,将其插入到巴斯德毕赤酵母(Picher pastoris)表达载体pPIC9K中,位于α-因子信号肽序列的下游,并与之同框,获得重组质粒pM242。重组质粒线性化后用电击法转化毕赤酵母菌株GS115。经大量筛选,获得高效分泌表达内切甘露聚糖酶的毕赤酵母工程菌株Gpmf25。摇瓶发酵结果表明,培养基中甘露聚糖酶的活力可达12.5IU/mL。重组酶最适pH和最适反应温度分别为5.0和80℃,在pH5.0～6.0时酶活稳定,在pH5.4时70℃保温30min酶活维持50％以上。     

Purification and characterization of cellulases produced by two Bacillus strains

Cellulases produced by two Bacillus strains, CH43 and HR68, isolated from hot springs in Zimbabwe, were purified to homogeneity from culture supernatants. Both enzymes had molecular mass of 40 kDa and isoelectric point of 5.4. The enzymes also resembled each other in N-terminal amino acid sequence which was Ala-Gly-Thr-Lys-Thr-Pro-Val-Ala-Lys-Asn-Gly-Gln, showing 100% homology with that of endoglucanases from Bacillus subtilis belonging to glycoside hydrolase family five. The cellulases were optimally active in the pH range of 5-6.5. The optimum temperature was 65 and 70 degrees C for the endoglucanase of CH43 and HR68, respectively. The CH43 enzyme was stable at 50 degrees C in a pH range of 6-10, and HR68 at pH 6-8. Both the enzymes retained complete activity for at least 24 h at 50 degrees C. The enzymes showed highest activity with beta-glucan as substrate followed by carboxymethylcellulose. Significant activity was also observed with crystalline forms of cellulose such as filter paper and Avicel, particularly for HR68 cellulase. For carboxymethycellulose, the CH43 and HR68 cellulases had a Km of 1.5 and 1.7 mg ml(-1), respectively, and Vmax of 0.93 and 1.70 mmol glucose min(-1) mg protein(-1) respectively. The activity of the enzymes was not influenced by most metal ions at 1 mM concentration, but was increased by about 38% by Co2+. The inhibition by Hg2+ and Mn2+ was higher for CH43 than for HR68 enzyme. Ag+ inhibited the CH43 activity but stimulated the HR68 activity. The CH43 cellulase was inhibited by N-bromosuccinimide and iodoacetamide while HR68 was unaffected.     

Production and characterization of a thermostable glucoamylase from Streptosporangium sp. endophyte of maize leaves

Thermostable amylolytic enzymes are currently investigated to improve industrial processes of starch degradation. Streptosporangium sp. an endophytic actinomycete isolated from leaves of maize (Zea mays L.) showed glucoamylase production, using starch-Czapek medium, and the highest rate was obtained in the initial growth phase, after incubation for 24 h at pH 8.0. Maximum glucoamylase activity (158 U mg(-1) protein) was obtained at pH 4.5 and 70 degrees C. The isolated enzyme exhibited thermostable properties as indicated by retention of 100% of residual activity at 70 degrees C for 30 min with total inhibition at 100 degrees C. Extracellular enzyme from Streptosporangium sp. was purified by fractionated precipitation with ammonium sulphate. After 60% saturation produced 421 U mg(-1) protein, and yield was 74% with purification 2.7 fold. The enzyme produced by Streptosporangium sp. has potential for industrial applications.     

耐碱性甘露聚糖酶基因的克隆及其在毕赤酵母中的表达

通过功能平板从土壤中筛选得到含甘露聚糖酶基因的耐碱菌株。构建其基因组文库,从中筛选到甘露聚糖酶基因TM1并测序分析,用BLAST分析表明,TM1的氨基酸序列与其他在GenBank发表的甘露聚糖酶的氨基酸序列的同源性均低于60%,故确定其为一个新的甘露聚糖酶基因(GenBank登录号为AY623903)。将此基因去除信号肽后的编码序列克隆到表达载体pHBM905C上,得到重组质粒pHBM1201。经SalⅠ酶切后分别转化毕赤酵母(Pichiapastoris)KM71、GS115、SMD1168,得到分泌表达的重组毕赤酵母。挑选相对表达量最高的重组毕赤酵母SMD1168-3在摇瓶中诱导产酶,对该酶的粗酶进行酶学性质分析表明,其最适反应温度为55℃,最适PH值为7.5,以魔芋粉为底物所测得的最高酶活为41.8U,半衰期为1h,在80℃保温5min其酶活由最初酶活的77%下降到11%,温度下降到55℃后活性可恢复到最初酶活的60%以上。     

Immobilization of cycloisomaltooligosaccharide glucanotransferase for the production of cycloisomaltooligosaccharides from dextran

Immobilization of cycloisomaltooligosaccharide glucanotransferase (CITase) and its application in the production of cycloisomaltooligosaccharides (CIs) from dextran were studied. Among various carrier materials examined, the enzyme adsorbed physically on Chitopearl BCW-3505 showed the highest activity (1.75 U/ml carrier). The activity remaining was 35%. The maximum CI yield in batch reactions at 0.2, 2 and 10% dextran was 28, 24 and 12%, respectively. The maximum CI yield at 2% dextran (24%) was slightly less than that with the free enzyme under the same conditions (26%). The concentration of linear oligosaccharides, the byproducts in the reaction mixture, was greater with the immobilized CITase than the free enzyme. The immobilized CITase was less thermostable than the free enzyme by about 10 degrees C. The pattern of influence of Ca(2+) concentration on the thermostability differed between the free and immobilized CITase. A Ca(2+) concentration of 50-100 mM was optimum for the thermostability of the immobilized CITase, 10-50 mM for the free enzyme. CIs were produced continuously by a column system packed with the immobilized enzyme at 40 degrees C with a space velocity (SV) of 6 h(-1). The three quarters life time was 4 weeks. We think that relatively long life time at fast SV was accomplished and CI production cost by this method should be lower than the batch reaction. This is the first report on immobilization of CITase.     

枯草芽孢杆菌中性β—甘露聚糖酶的产生及性质

由土壤中分离出一株产中性β甘露聚糖酶的枯草芽孢杆菌（Ｂａｃｉｌｕｓｓｕｂｔｉｌｉｓ）,编号ＢＭ９６０２。该菌在液体培养条件下,产生中性β甘露聚糖酶。多糖能作为碳源,而单糖不能作为碳源;有机氮源优于无机氮源。产酶最适培养基组成：魔芋粉４％,牛肉蛋白胨和酵母膏各１％。产酶最适培养条件：培养基起始ｐＨ８５,３５℃,振荡培养３６ｈ。以槐豆胶为底物,培养滤液中性β甘露聚糖酶活力为９６ＩＵ／ｍＬ。酶在ｐＨ５０～１００和５０℃下稳定;作用最适条件为ｐＨ６０和５０℃;水解魔芋粉和槐豆胶均产生寡聚糖。     

Production, purification, and characterization of lipase from thermophilic and alkaliphilic Bacillus coagulans BTS-3

A thermophilic isolate Bacillus coagulans BTS-3 produced an extracellular alkaline lipase, the production of which was substantially enhanced when the type of carbon source, nitrogen source, and the initial pH of culture medium were consecutively optimized. Lipase activity 1.16 U/ml of culture medium was obtained in 48 h at 55 degrees C and pH 8.5 with refined mustard oil as carbon source and a combination of peptone and yeast extract (1:1) as nitrogen sources. The enzyme was purified 40-fold to homogeneity by ammonium sulfate precipitation and DEAE-Sepharose column chromatography. Its molecular weight was 31 kDa on SDS-PAGE. The enzyme showed maximum activity at 55 degrees C and pH 8.5, and was stable between pH 8.0 and 10.5 and at temperatures up to 70 degrees C. The enzyme was found to be inhibited by Al3+, Co2+, Mn2+, and Zn2+ ions while K+, Fe3+, Hg2+, and Mg2+ ions enhanced the enzyme activity; Na+ ions have no effect on enzyme activity. The purified lipase showed a variable specificity/hydrolytic activity towards various 4-nitrophenyl esters.     

Candida albicans cell wall lytic enzyme produced by Streptomyces thermodiastaticus

The production of lytic enzyme by Streptomyces thermodiastaticus was found to be affected by some growth conditions and nutritional factors. The highest enzyme production was obtained after 18 h of incubation at pH 5.5 and at 50 degrees C. The carbon source influenced the lytic enzyme production. A higher enzyme yield was obtained when Candida albicans cell wall (1 g/100 ml) was used as the sole carbon source. NaNO3 at 0.1 g/100 ml was the best nitrogen source for enzyme production. From all phosphorous sources, microelements, and growth factors tested, KH2PO4 (1 g/l), ZnSO4 (1 mg/I) and Tween 80 (0.1%), respectively, were found to favour the highest production of lytic enzymes by S. thermodiastaticus. The lytic enzymes mainly produced chitinolytic and proteolytic activities.