Aspergillus sp. RSD生淀粉糖化酶的分离纯化及酶学性质

【目的】纯化得到一种生淀粉糖化酶,并对其酶学性质进行分析。【方法】从曲霉RSD发酵液中,经过硫酸铵分级盐析,HiPrep DEAE FF16/10弱阴离子交换层析,凝胶过滤层析,Hiprep 16/10 source 30S阳离子交换层析最终纯化出一种电泳纯的生淀粉酶。【结果】粗酶液纯化倍数为12.65倍,活力回收率为9.02%,SDS-PAGE结果显示该酶的相对分子质量约为82 kD。对该酶的酶学性质分析结果表明,该酶最适作用温度为50°C,在50°C以下稳定性很好,对高温较为敏感;最适作用pH为4.5,在pH 3.5-7.0范围内酶活力较为稳定,在40°C、pH 4.6条件下以可溶性淀粉为底物时的Km值和Vmax值分别为7.44 g/L和1.45 g/(L·min);金属离子对酶活性的影响试验表明,Fe2+对该酶具有显著激活效果,EDTA、Cu2+、K+对该酶酶活力有不同程度的抑制作用;底物特异性研究表明该酶对麦芽糊精具有较高酶活力。【结论】与市售糖化酶及生淀粉糖化酶相比,该酶对生淀粉的降解能力更高,在工业应用上有较好的前景。     

生淀粉糖化酶产生菌Cellulosimicrobium sp.SDE的分离鉴定及酶学性质研究

从淀粉制品厂周围土壤中分离到一株高产生淀粉糖化酶的菌株SDE,经形态、生理生化及16S rDNA序列分析将其鉴定为Cellulosimicrobium sp..SDE菌株的最适产酶条件为pH7.0,培养温度为30℃.培养42h粗酶液的酶活达175.3U/mL.该酶以生玉米淀粉为底物时,最适作用pH6.0,最适作用温度40℃,pH6.0-7.0范围内酶活力稳定.在Ca2 存在下,酶的热稳定性很高,80℃保温1 h后,酶活力仍保持50%.Ba2 、Cu2 对酶活有强烈的抑制作用,Ca2 、Zn2 有很强的激活作用.     

低温淀粉酶菌株C2的分离鉴定及其产低温淀粉酶的酶学性质

获得低温淀粉酶高产菌株,确定该菌株所产淀粉酶的酶学性质.从大黑山(大连)污泥中筛选菌株,通过菌株的形态特征、生理生化和16S rDNA序列鉴定确定其种属,对其酶学性质进行初步研究.获得1株低温淀粉酶高产菌株C2,经鉴定其为微小杆菌属,C2所产低温淀粉酶最适反应温度为25℃,酶的热稳定性比较差,最适pH为7.5,Ca2+和Fe2+对该酶有激活作用,Cu2+、Ni2+、Go2+等抑制酶活性.经薄层层析(TLC)鉴定酶解产物为葡萄糖,说明该菌株具有产生低温淀粉糖化酶的能力.菌株C2所产淀粉酶符合低温淀粉酶性质,值得进一步研究.     

麻类脱胶高效菌株果胶裂解酶基因克隆与表达

【目的】克隆麻类脱胶高效菌株Dickeya sp.DCE-01的果胶裂解酶基因并进行原核表达,对表达产物进行纯化和酶学性质研究。【方法】根据该菌株全基因组序列预测的果胶裂解酶基因Q59419设计引物,PCR扩增后将该基因连接到pEASY-E1和pACYCDuet-1载体上,导入E.coli BL21(DE3)进行表达。选择酶活力高的阳性克隆子进行大量诱导表达后,采用超滤和Sephadex G-100凝胶层析两步法纯化出果胶裂解酶,研究其酶学性质。【结果】克隆到果胶裂解酶基因pel(GenBank登录号:JX964997),其序列全长1 128 bp,编码375个氨基酸。pACYCDuet-1-pel-BL表达胞外果胶裂解酶活力最高,发酵液粗酶活达298.8 IU/mL。其最适反应温度为50°C,最适pH为9.0;保温1 h,酶活稳定温度≤45°C,稳定pH为9.0?10.0。酶催化作用依赖于Ca2+,其最适作用浓度为2 mmol/L;Zn2+、Ca2+和NH4+促进酶活力,Fe3+和Pb2+严重抑制酶活力;聚半乳糖醛酸钠为该酶的最适底物。【结论】从麻类脱胶高效菌株中发掘到碱性果胶裂解酶基因,其表达产物在生物质加工过程中具有重要工业化应用前景。     

土壤中高产蛋白酶菌株产酶条件及酶学性质

【背景】微生物蛋白酶已经成为工业用蛋白酶的主要来源,筛选具有特殊环境适应性的微生物成为生物酶资源的开发热点。【目的】通过对青藏高原土壤微生物产蛋白酶菌株的筛选、优化及相关特性研究,寻找新的蛋白酶资源,为高原菌种资源利用提供科学依据。【方法】采用形态学和分子生物学对筛选菌株进行菌种鉴定,利用单因素试验和正交试验对菌株进行发酵条件优化及酶学性质的探究。【结果】筛选出一株高产蛋白酶菌株XC2,经鉴定菌株XC2为枯草芽孢杆菌(Bacillus subtilis)。XC2最优产酶条件:可溶性淀粉4.0%,牛肉膏1.0%,K~+0.6%,培养温度34°C、初始pH 7.0、接种量2.0%的条件下200 r/min振荡培养13 h,所产蛋白酶活力最高为638.5 U/mL。XC2所产蛋白酶最适反应温度60°C,最适pH9.0;40-50°C、pH8.0-10.0条件下酶活稳定性较高;Mn~(2+)对酶活力有明显激活作用,而Zn~(2+)、Cu~(2+)、Fe~(2+)、Fe3+对酶活力有明显抑制作用。【结论】枯草芽孢杆菌XC2有较强的产碱性蛋白酶的能力,具有较好的应用前景。     

产壳聚糖酶菌株的筛选、鉴定及酶学特性分析

【目的】利用筛选培养基,从福建沿海潮间带泥样中分离筛选产壳聚糖酶的菌株,并研究菌株的产酶特性。【方法】通过形态学观察,结合26S rDNA序列进行分类鉴定,采用DNS法测定酶活力。【结果】筛选得到产壳聚糖酶的菌株KQ-1002与草酸青霉(Penicillium oxalicum)的同源性为99%,并初步鉴定为青霉属的一种。发酵培养的最适温度为30°C,最适碳源为1.0%水溶性壳聚糖,最适氮源为1.87%(NH4)2SO4,最适pH为6.0。该菌株液体发酵培养72 h产壳聚糖酶活性最高,经优化后最高产酶量为18 U/mL。纯化后的壳聚糖酶经SDS-PAGE分析其分子量约40 kD。酶促反应最适pH为5.0,最适反应温度为55°C,Km值为1.293 g/L。在离子浓度为1.0×10 3mol/L时,金属离子Cu2+、Hg2+、Ag+对酶的活性均有强烈的抑制作用。壳聚糖酶对不同底物及脱乙酰度的壳聚糖具有不同的降解作用。【结论】筛选获得产壳聚糖酶的真菌菌株KQ-1002的壳聚糖酶活力经优化后提高了约7倍,是一株具有研究和应用潜力的产壳聚糖酶菌株。     

地衣芽孢杆菌TG116胞外蛋白酶产酶条件与酶学性质

【背景】从独角莲中分离得到的地衣芽孢杆菌TG116是一株对植物病原菌具有广谱抗性作用的生防菌株。【目的】优化TG116的产酶条件并探索其酶学性质,进一步了解其抗菌机制。【方法】采用Folin-Phenol显色法与响应曲面法,优化菌株TG116的产酶条件并研究其蛋白酶的酶学性质。【结果】菌株TG116产酶最适条件为:温度40.83°C,p H 8.01,发酵时间53.74 h,增加通气量可以显著提高酶活力。按照优化后的条件培养48 h后,上清液蛋白酶活力从57.46 U/mL达到了254.07 U/mL。酶学性质研究表明:该酶为碱性蛋白酶,最适反应pH为8.5,最适反应温度为50°C,具有良好的温度和pH稳定性,EDTA对酶活具有强烈的抑制作用,金属离子Mg~(2+)、Ca~(2+)、Na~+、Co~(2+)、K~+等对酶活也具有一定的抑制作用。【结论】菌株TG116具有良好的p H与温度稳定性,在实际应用中蛋白酶不易失活,可以分解真菌的细胞壁蛋白成分,破坏细胞壁结构,从而抑制甚至杀死病原菌,达到抗菌作用。     

一株纤维素降解真菌的筛选、鉴定及酶学性质分析

通过对富含枯枝败叶的土壤样品进行富集培养,利用刚果红纤维素培养基初筛和酶活测定复筛得到产纤维素酶的一株真菌,将其命名为GC2-2,并对该菌株进行鉴定及酶学性质研究。结果表明该菌株是一株耐高温、碱性纤维素酶的真菌GC2-2。通过18S rDNA分子克隆测定,该菌为球孢枝孢菌,其滤纸酶的活力优于CMC酶的活力。该菌所产酶的最适反应条件为温度35°C,最适pH值7.5。     

低温生淀粉糖化酶菌株RS01分离及其酶学性质

自渤海湾海泥中分离得到一株产低温生淀粉糖化酶能力较强的菌株RS01,经形态学、生理生化特性及16S rRNA分析将其鉴定为气单胞菌属。对该菌株产的低温生淀粉糖化酶酶学性质进行初步研究,结果表明其最适酶反应温度为30℃,酶的热稳定性比较差,最适pH为5.4,经TLC鉴定酶解产物中有葡萄糖,表明该分离菌株具有产低温生淀粉糖化酶的能力。     

酸性α-淀粉酶的分离纯化与酶学性质研究

纯化了枯草芽胞杆菌xm-1菌株酸性α-淀粉酶,并对其酶学性质进行了研究。通过硫酸铵沉淀和Sephadex G-75凝胶层析将酸性α-淀粉酶粗酶液纯化了32.5倍,活力回收率为10.0%。酶性质测定结果表明,该酸性α-淀粉酶分子量约为60kD,最适反应温度为45℃、最适作用pH5.0,该酶在pH3.4-6.0下稳定,高温耐受性差。Cu2+、Zn2+、EDTA对酶有不同程度的抑制作用,Ca2+和Mn2+对酶具有较强的激活作用。     

生淀粉糖化酶高产菌的选育

从土壤及霉变淀粉质等样品中分离出对生淀粉具有降解作用的菌种约 6 0株 ,其中生淀粉糖化酶最高的一株根霉OR-1 ,其酶活为 90U/mL ,通过一次紫外和亚硝基胍诱变 ,酶活分别达到 200U/mL、325U/mL ,RDA值分别为 70 %、 65%。诱变株是一株产生淀粉糖化酶较高的根霉。     

An extracellular glucoamylase produced by endophytic fungus EF6

A strain of endophytic fungus EF6 isolated from Thai medicinal plants was found to produce higher levels of extracellular glucoamylase. This strain produced glucoamylase of culture filtrate when grown on 1% soluble starch. The enzyme was purified and characterized. Purification steps involved (NH₄)₂SO₄ precipitation, anion exchange, and gel filtration chromatography. Final purification fold was 14.49 and the yield obtained was 9.15%. The enzyme is monomeric with a molecular mass of 62.2 kDa as estimated by SDS-PAGE, and with a molecular mass of 62.031 kDa estimated by MALDI-TOF spectrometry. The temperature for maximum activity was 60°C. After 30 min for incubation, glucoamylase was found to be stable lower than 50°C. The activity decrease rapidly when residual activity was retained about 45% at 55°C. The pH optimum of the enzyme activity was 6.0, and it was stable over a pH range of 4.0–7.0 at 50°C. The activity of glucoamylase was stimulated by Ca²⁺, Co²⁺, Mg²⁺, Mn²⁺, glycerol, DMSO, DTT and EDTA, and strongly inhibited by Hg²⁺. Various types of starch were test, soluble starch proved to be the best substrate for digestion process. The enzyme catalyzes the hydrolysis of soluble starch and maltose as the substrate, the enzyme had K _m values of 2.63, and 1.88 mg/ml and V _max, values of 1.25, and 2.54 U/min/mg protein, and V _max/K _m values of 0.48 and 1.35, respectively. The internal amino acid sequences of endophytic fungus EF6 glucoamylase; RALAN HKQVV DSFRS have similarity to the sequence of the glucoamylase purified form Thermomyces lanuginosus. From all results indicated that this enzyme is a glucoamylase (1,4-α-D-glucan glucanohydrolase).     

Purification and properties of two forms of glucoamylase fromAspergillus niger

A. niger produced α-glucosidase, α-amylase and two forms of glucoamylase when grown in a liquid medium containing raw tapioca starch as the carbon source. The glucoamylases, which formed the dominant components of amylolytic activity manifested by the organism, were purified to homogeneity by ammonium sulfate precipitation, ion-exchange and two cycles of gel filtration chromatography. The purified enzymes, designated GA1 and GA2, a raw starch digesting glucoamylase, were found to have molar masses of 74 and 96 kDa and isoelectric points of 3.8 and 3.95, respectively. The enzymes were found to have pH optimum of 4.2 and 4.5 for GA1 and GA2, respectively, and were both stable in a pH range of 3.5–9.0. Both enzymes were thermophilic in nature with temperature optimum of 60 and 65°C, respectively, and were stable for 1 h at temperatures of up to 60°C. The kinetic parametersK _m andV showed that with both enzymes the branched substrates, starch and amylopectin, were more efficiently hydrolyzed compared to amylose. GA2, the more active of the two glucoamylases produced, was approximately six to thirteen times more active towards raw starches compared to GA1.     

Purification,biochemical characterization and gene sequencing of a thermostable raw starch digesting α-amylase from Geobacillus thermoleovorans subsp. stromboliensis subsp. nov.

This study reports the purification and biochemical characterization of a raw starch-digesting α-amylase from Geobacillus thermoleovorans subsp. stromboliensis subsp. nov. (strain Pizzo^T). The molecular weight was estimated to be 58 kDa by SDS–PAGE. The enzyme was highly active over a wide range of pH from 4.0–10.0. The optimum temperature of the enzyme was 70°C. It showed extreme thermostability in the presence of Ca²⁺, retaining 50% of its initial activity after 90 h at 70°C. The enzyme efficiently hydrolyzed 20% (w/v) of raw starches, concentration normally used in starch industries. The α-amylase showed an high stability in presence of many organic solvents. In particular the residual activity was of 73% in presence of 15% (v/v) ethyl alcohol, which corresponds to ethanol yield in yeast fermentation process. By analyzing its complete amyA gene sequence (1,542 bp), the enzyme was proposed to be a new α-amylase.     

Characterization of glucoannylaserom Asperigillus terreus 4

A strain of Aspergillus terreus 4 was found to show extracellular amylolytic activity and the amylase was identified as glucoamylase enzyme. The optimum temperature for the enzyme activity was 60% and it was stable at this temperature for 1 h. The enzyme was optimally active at pH 5.0 and stable between pH 3.0-8.0. Km values of glucoamylase for soluble starch, amylose and amylopectin were 5.9 mg/ml, 4.8 mg/ml and 2.6 mg/ml respectively.     

Characterization of an organic solvent‐tolerant thermostable glucoamylase from a halophilic isolate,Halolactibacillus sp. SK71 and its application in raw starch hydrolysis for bioethanol production

A halophilic bacterium Halolactibacillus sp. SK71 producing extracellular glucoamylase was isolated from saline soil of Yuncheng Salt Lake, China. Enzyme production was strongly influenced by the salinity of growth medium with maximum in the presence of 5% NaCl. The glucoamylase was purified to homogeneity with a molecular mass of 78.5 kDa. It showed broad substrate specificity and raw starch hydrolyzing activity. Analysis of hydrolysis products from soluble starch by thin‐layer chromatography revealed that glucose was the sole end‐product, indicating the enzyme was a true glucoamylase. Optimal enzyme activity was found to be at 70°C, pH 8.0, and 7.5% NaCl. In addition, it was highly active and stable over broad ranges of temperature (0–100°C), pH (7.0–12.0), and NaCl concentration (0–20%), showing excellent thermostable, alkali stable, and halotolerant properties. Furthermore, it displayed high stability in the presence of hydrophobic organic solvents. The purified glucoamylase was applied for raw corn starch hydrolysis and subsequent bioethanol production using Saccharomyces cerevisiae. The yield in terms of grams of ethanol produced per gram of sugar consumed was 0.365 g/g, with 71.6% of theoretical yield from raw corn starch. This study demonstrated the feasibility of using enzymes from halophiles for further application in bioenergy production. © 2014 American Institute of Chemical Engineers Biotechnol. Prog., 30:1262–1268, 2014     

Production and characterization of a new cyclodextrin glycosyltransferase from Bacillus firmus isolated from Brazilian soil

A new CGTase was obtained from Bacillus firmus, strain 7B, isolated from oat soil culture, using a high alkaline pH medium containing 1% Na₂CO₃. The enzyme was characterized in soluble form, for pH 5–11, temperature from 30 to 85 °C, using a 1% maltodextrin substrate solution and appropriate buffers. It produced mainly β-CD and the cell-free supernatant had a precipitating activity measured by the trichloroethylene method that is a 100-fold greater than that of the enzyme of Bacillus firmus, strain 37, previously studied by our group. The molecular weight of the pure protein was measured as 56,230 Da with SDS-PAGE. The optimum temperature for the enzyme activity was 50 °C and it was most active at pH 6.0. Thermal deactivation was noticeable above 65 °C and the enzyme was highly stable below 60 °C. The influence of substrate or product concentration on the initial rate of CD production was studied and the kinetic parameters were determined. The enzyme showed cyclization activity on different raw and hydrolyzed starches and hydrolyzed cornstarch gave the highest activity.     

Characterization of Betaine Aldehyde Dehydrogenase from Cylindrocarpon didymum M-1

To obtain a lipase which effectively hydrolyzes castor oil, bacteria were isolated from 500 soil samples. The best strain was examined; its microbiological characteristics suggested that it belongs to the genus Pseudomonas. A lipase from this strain was purified by ammonium sulfate fractionation and chromatographies on DEAE-cellulose and DEAE-Toyopearl 650 M. The enzyme was purified about 400-fold with a yield of 13%. The purified enzyme was electrophoretically homogeneous and its molecular weight was 30,000. The optimum pH and temperature for the hydrolysis of olive oil emulsion were 7.0 and 60°C. The enzyme was stable up to 35°C at pH 7.0 for 30min and also stable from pH 9.0 to 10.0 at 4°C for 22 hr. The activity was inhibited by Fe³⁺ , Hg²⁺ , pCMB, and anionic surfactants, and enhanced by nonionic surfactants and bile salts. The enzyme efficiently hydrolyzed castor oil.     

Purification and characterization of an extracellular glucoamylase from the yeastCandida tsukubaensis CBS 6389

The starch-degrading yeastCandida tsukubaensis CBS 6389 secreted amylase at high activity when grown in a medium containing soluble starch. The extracellular α-amylase activity was very low. The major amylase component was purified by DEAE-Sephadex A-50 chromatography and Ultrogel AcA 44 gel filtration and characterized as a glucoamylase. The enzyme proved to be a glycoprotein with a molecular weight of 56000. The glucoamylase had a temperature optimum at 55°C and displayed highest activity in a pH range of 2.4–4.8. Acarbose strongly inhibited the purified glucoamylase. Debranching activity was present as demonstrated by the release of glucose from pullulan.     

嗜热菌来源的生淀粉酶分离纯化及其酶学性质

从嗜热菌库中分离到两株能水解生淀粉的菌株173和174,通过扩增和测定两株菌的16S rDNA序列并进行比对结果表明,所分离两株菌属于Geobacillus属的细菌.液体摇瓶发酵菌株173、174,其产生的生淀粉酶(简称RSDE173、RSDE174)活力分别达14.5 U/mL和12.9 U/mL.通过生淀粉吸附-熟淀粉洗脱系统和TOYOPEARL HW-55F系统进行分离纯化,得到纯化的RSDE173和RSDE174,纯化倍数分别为50和29,活力回收率分别为34%和41%.有关RSDE173和RSDE174酶学性质研究显示.对熟淀粉水解的最适作用温度均为70℃,而对生淀粉水解则分别在50℃～60℃和40℃～60℃下表现出高水解活力;对不同底物的最适作用pH值均为5.0～5.5;它们对大多数试验离子的敏感性较低,但个别离子如Co2 、Cu'2 对RSDE173或u'2 对RSDE174的酶活力有一定的抑制作用.纯化的这两种生淀粉酶对不同来源生淀粉的底物专一性并不相同.RSDE173底物专一性顺序为红薯淀粉>小麦淀粉>玉米淀粉>木薯淀粉>糯米淀粉;而RSDE174的糯米淀粉>小麦淀粉>红薯淀粉>玉米淀粉>木薯淀粉.RSDE173对生红薯淀粉有很好的降解,其水解糊化淀粉与生红薯淀粉的比值为1.48;而RSDE174优先降解生糯米淀粉,其相应比值为1.69.