Denitrification with endogenous carbon source at low C/N and its effect on P(3HB) accumulation

The objective of the work reported here was to determine whether the ratio of COD/Nox has an impact on poly-beta-hydroxybutyrate (PHB) metabolism in activated sludge. Furthermore, it was tested if the ratio influenced the percentage use of organic compounds present in wastewater, for endogenous respiration, oxidation, accumulation and denitrification. Gas flow rate in SBR reactor was controlled by thermal mass flow controller (TMFC). Constant amount of air entering sequencing batch reactor was automatically adjusted to stable set-point 2mg O2 L(-1). It means that DO concentration in the reactor could change with oxygen uptake. During the filling period and part of the reaction time DO was nearly zero. Feast period of the external substrate availability and famine period of little amount or no external carbon availability were determined. At 23 h of the reaction time, and COD/Nox ratio 8, denitrification took place only during feast period. What was interesting, poly-beta-hydroxybutyrate degradation was observed in the feast period as well. However, at 11h of the reaction time and COD/Nox ratio 37, denitrification occurred in feast and famine period. In the feast period PHB was accumulated and in the famine period was used as the endogenous carbon source. COD consumption to reduce 1mg N-nitrate was ranging from 1.15 to 6.26 depending on carbon source and increased when exogenous and endogenous carbon were used by activated sludge. The increase in PHB content from 0.25 to 0.43 Cmol/Cmol resulted in a double increase in the amount of nitrogen removed due to denitrification was observed.     

The effect of dissolved oxygen on PHB accumulation in activated sludge cultures

Nitrogen removal from wastewater is often limited by the availability of reducing power to perform denitrification, especially when treating wastewaters with a low carbon:nitrogen ratio. In the increasingly popular sequencing batch reactor (SBR), bacteria have the opportunity to preserve reducing power from incoming chemical oxygen demand (COD) as poly-beta-hydroxybutyrate (PHB). The current study uses laboratory experiments and mathematical modeling in an attempt to generate a better understanding of the effect of oxygen on microbial conversion of COD into PHB. Results from a laboratory SBR with acetate as the organic carbon source showed that the aerobic acetate uptake process was oxygen-dependent, producing higher uptake rates at higher dissolved oxygen (DO) supply rates. However, at the lower DO supply rates (k(L)a 6 to 16 h(-1), 0 mg L(-1) DO), a higher proportion of the substrate was preserved as PHB than at higher DO supply rates (k(L)a 30, 51 h(-1), DO >0.9 mg L(-1)). Up to 77% of the reducing equivalents available from acetate were converted to PHB under oxygen limitation (Y(PHB/Ac) 0.68 Cmol/Cmol), as opposed to only 54% under oxygen-excess conditions (Y(PHB/Ac) 0.48 Cmol/Cmol), where a higher fraction of acetate was used for biomass growth. It was calculated that, by oxygen management during the feast phase, the amount of PHB preserved (1.4 Cmmol L(-1) PHB) accounted for an additional denitrification potential of up to 18 mg L(-1) nitrate-nitrogen. The trends of the effect of oxygen (and hence ATP availability) on PHB accumulation could be reproduced by the simulation model, which was based on biochemical stoichiometry and maximum rates obtained from experiments. Simulated data showed that, at low DO concentrations, the limited availability of adenosine triphosphate (ATP) prevented significant biomass growth and most ATP was used for acetate transport into the cell. In contrast, high DO supply rates provided surplus ATP and hence higher growth rates, resulting in decreased PHB yields. The results suggest that oxygen management is crucial to conserving reducing power during the feast phase of SBR operation, as excessive aeration rates decrease the PHB yield and allow higher biomass growth.     

Effect of low dissolved oxygen on simultaneous nitrification and denitrification in a membrane bioreactor treating black water

Effect of low dissolved oxygen on simultaneous nitrification and denitrification was evaluated in a membrane bioreactor treating black water. A fully aerobic membrane bioreactor was operated at a sludge age of 60 days under three low dissolved oxygen (DO) levels below 0.5mg/L. It sustained effective simultaneous nitrification/denitrification for the entire observation period. Nitrification was incomplete due to adverse effects of a number of factors such as low DO level, SMPs inhibition, alkalinity limitation, etc. DO impact was more significant on denitrification: Nitrate was fully removed at low DO level but the removal was gradually reduced as DO was increased to 0.5mg/L. Nitrogen removal remained optimal within the DO range of 0.15-0.35 mg/L. Experimental results were calibrated and simulated by model evaluation with the same model coefficients. The model defined improved mass transfer with lower affinity coefficients for oxygen and nitrate as compared to conventional activated sludge.     

N-removal in a granular sludge sequencing batch airlift reactor

The removal of N-compounds in the sequencing batch airlift reactor (SBAR) containing granular sludge was studied under conditions of decreased dissolved oxygen (DO). A simulation model was developed to describe and evaluate the effects of several process conditions in the SBAR on N-removal performance. The model described the experimental data reasonable well. It has been shown that nitrification, denitrification, and removal of chemical oxygen demand (COD) can occur simultaneously in a granular sludge SBR. It has also been shown that the exact location of the autotrophic biomass influences the net N-removal. The distribution of the autotrophic biomass is influenced by the DO in the reactor. The optimal DO value is expected to be around 40% air saturation. It was shown that storage and subsequent degradation of poly-beta-hydroxybutyrate (PHB) benefit the denitrification. In particular, PHB is stored in bacteria situated in deeper layers of the granules below where the autotrophic activity occurs, serves as a C-source for denitrification.     

Effect of oxygen concentration on nitrification and denitrification in single activated sludge flocs

Simultaneous nitrification and denitrification (SND) was investigated in the single aeration tank of a municipal wastewater treatment plant. Microelectrode measurements and batch experiments were performed to test for the presence of SND. Microelectrodes recorded the presence of O(2) concentration gradients in individual activated sludge flocs. When the O(2) concentration in the bulk liquid was <45 microM, anoxic zones were detected within flocs with a larger diameter (approximately 3000 microm). The O(2) penetration depth in the floc was found to be dependent on the O(2) concentration in the bulk liquid. Nitrification was restricted to the oxic zones, whereas denitrification occurred mainly in the anoxic zones. The nitrification rate of the activated sludge increased with increasing O(2) concentration in the bulk liquid, up to 40 microM, and remained constant thereafter. SND was observed in the aerated activated sludge when O(2) concentration was in the range of 10 to 35 microM.     

Modeling of simultaneous denitrification--anaerobic digestion--organic matter aerobic oxidation and nitrification in an anoxic-anaerobic-aerobic compact filter reactor

A mathematical model was developed for a compact anoxic-anaerobic-aerobic filter reactor with liquid recirculation for the treatment of fishing effluents. The model includes denitrification, anaerobic digestion, aerobic carbon oxidation and nitrification steps, as well as an evaluation of the liquid gas mass transfer and pH. The model was calibrated using one experimental condition at a recycling ratio (R)=10, and was validated with R equal to 2 and 0, with an organic concentration of 554±24 mg TOCL(-1), salinity of 24 g L(-1) and hydraulic retention time (HRT) of 2 d. Carbon total removal is higher than 98%, while maximum nitrogen removal is 62% using total nitrification in the aerobic zone, due to a higher quantity of NO(x) produced which were recirculated to the anoxic zone. In the aerobic zone, simultaneous nitrification and denitrification processes occur, because the diffusion limitations cause a low oxygen penetration in the biofilm. In the anoxic-anaerobic zone, denitrification or methanogenesis inhibition by DO (caused by the recycled oxygen) is not observed.     

Simultaneous nitrification,denitrification, and phosphorus removal in a lab-scale sequencing batch reactor

Simultaneous nitrification and denitrification (SND) via the nitrite pathway and anaerobic-anoxic-enhanced biological phosphorus removal (EBPR) are two processes that can significantly reduce the energy and COD demand for nitrogen and phosphorus removal. The combination of these two processes has the potential of achieving simultaneous nitrogen and phosphorus removal with a minimal requirement for COD. A lab-scale sequencing batch reactor (SBR) was operated in alternating anaerobic-aerobic mode with a low dissolved oxygen (DO) concentration (0.5 mg/L) during the aerobic period, and was demonstrated to accomplish nitrification, denitrification, and phosphorus removal. Under anaerobic conditions, COD was taken up and converted to polyhydroxyalkanoates (PHAs), accompanied by phosphorus release. In the subsequent aerobic stage, PHA was oxidized and phosphorus was taken up to <0.5 mg/L by the end of the cycle. Ammonia was also oxidized during the aerobic period, but without accumulation of nitrite or nitrate in the system, indicating the occurrence of simultaneous nitrification and denitrification. However, off-gas analysis showed that the final denitrification product was mainly nitrous oxide (N(2)O), not N(2). Further experimental results demonstrated that nitrogen removal was via nitrite, not nitrate. These experiments also showed that denitrifying glycogen-accumulating organisms (DGAOs), rather than denitrifying polyphosphate-accumulating organisms (DPAOs), were responsible for the denitrification activity.     

Long-term effect of dissolved oxygen on partial nitrification performance and microbial community structure

In this study, the performance of partial nitrification via nitrite and microbial community structure were investigated and compared in two sequencing batch reactors (SBR) with different dissolved oxygen (DO) levels. Both reactors achieved stable partial nitrification with nitrite accumulation ratio of above 95% by using real-time aeration duration control. Compared with high DO (above 3 mg/l on average) SBR, simultaneous nitrification and denitrification (SND) via nitrite was carried out in low DO (0.4–0.8 mg/l) SBR. The average efficiencies of SND in high DO and low DO reactor were 7.7% and 44.9%, and the specific SND rates were 0.20 and 0.83 mg N/(mg MLSS h), respectively. Low DO did not produce sludge with poorer settling properties but attained lower turbidities of the effluent than high DO. Fluorescence in situ hybridization (FISH) analysis in both the reactors showed that ammonia-oxidizing bacteria (AOB) were the dominant nitrifying bacteria and nitrite-oxidizing bacteria (NOB) did not be recovered in spite of exposing nitrifying sludge to high DO. The morphology of the sludge from both two reactors according to scanning electron microscope indicated that small rod-shaped and spherical clusters were dominant, although filamentous bacteria and few long rod-shaped coexisted in the low DO reactor. By selecting properly DO level and adopting process control method is not only of benefit to the achievement of novel biological nitrogen removal technology, but also favorable to sludge population optimization.     

Simultaneous nitrification-denitrification achieved by an innovative internal-loop airlift MBR: comparative study

This study assessed the performance of different single-stage continuous aerated submerged membrane bioreactors (MBR) for nitrogen removal. Almost complete nitrification was achieved in each MBR irrespective of operating mode and biomass system. Denitrification was found to be the rate-limiting step for total nitrogen (T-N) removal. The MBR with internal-loop airlift reactor (ALR) configuration performed better as regards T-N removal compared with continuous stirred-tank reactor (CSTR). It was demonstrated that simultaneous nitrification and denitrification (SND) is the mechanism leading to nitrogen removal and the contribution of microenvironment on SND is more remarkable for the MBRs with hybrid biomass. Macroenvironment analyses showed that gradient distribution of dissolved oxygen (DO) level in airlift MBRs imposed a significant effect on SND. Higher mixed liquor suspended solid (MLSS) concentration led to the improvement in T-N removal by enhancing anoxic microenvironment. Apparent nitrite accumulation coupled with higher nitrogen reduction was accomplished at MLSS concentration exceeded 12.6 g/L.     

Biofilm stratification during simultaneous nitrification and denitrification (SND) at a biocathode

The aeration of the cathode compartment of bioelectrochemical systems (BESs) was recently shown to promote simultaneous nitrification and denitrification (SND). This study investigates the cathodic metabolism under different operating conditions as well as the structural organization of the cathodic biofilm during SND. Results show that a maximal nitrogen removal efficiency of 86.9 ± 0.5%, and a removal rate of 3.39 ± 0.08 mg N L⁻¹ h⁻¹ could be achieved at a dissolved oxygen (DO) level of 5.73 ± 0.03 mg L⁻¹ in the catholyte. The DO levels used in this study are higher than the thresholds previously reported as detrimental for denitrification. Analysis of the cathodic half-cell potential during batch tests suggested the existence of an oxygen gradient within the biofilm while performing SND. FISH analysis corroborated this finding revealing that the structure of the biofilm included an outer layer occupied by putative nitrifying organisms, and an inner layer where putative denitrifying organisms were most dominant. To our best knowledge this is the first time that nitrifying and denitrifying microorganisms are simultaneously observed in a cathodic biofilm.     

Study of operational conditions of simultaneous nitrification and denitrification in a Carrousel oxidation ditch for domestic wastewater treatment

The study on the operational conditions of simultaneous nitrification and denitrification (SND) in the channel of oxidation ditch (OD) without the need for a special anoxic tank was carried out based on lab-scale and pilot-scale experiments using real domestic wastewater. The influence of sludge loading and component proportion in influent, temperature, hydraulic retention time (HRT), dissolved oxygen (DO) and operational mode on SND was investigated. The result indicated that the optimal DO (ODO) of SND occurrence was confirmed majorly by the sludge loading of influent and temperature, the high TCOD/NH₃–N and short HRT can enhance the occurrence of SND. A new operational mode was proposed that achieved a higher removal efficiency of 60–70% for total nitrogen by SND with HRT of 4–6 h, and the concentrations of NH₃–N and TN in effluent are less than 5 and 15 mg/L, respectively.     

Stoichiometry and kinetics of poly-beta-hydroxybutyrate metabolism in aerobic, slow growing, activated sludge cultures

This paper discusses the poly-beta-hydroxybutyrate (PHB) metabolism in aerobic, slow growing, activated sludge cultures, based on experimental data and on a metabolic model. The dynamic conditions which occur in activated sludge processes were simulated in a 2-L sequencing batch reactor (SBR) by subjecting a mixed microbial population to successive periods of external substrate availability (feast period) and no external substrate availability (famine period). Under these conditions intracellular storage and consumption of PHB was observed. It appeared that in the feast period, 66% to almost 100% of the substrate consumed is used for storage of PHB, the remainder is used for growth and maintenance processes. Furthermore, it appeared that at high sludge retention time (SRT) the growth rate in the feast and famine periods was the same. With decreasing SRT the growth rate in the feast period increased relative to the growth rate in the famine period. Acetate consumption and PHB production in the feast period both proceeded with a zero-order rate in acetate and PHB concentration respectively. PHB consumption in the famine period could best be described kinetically with a nth-order degradation equation in PHB concentration. The obtained results are discussed in the context of the general activated sludge models.     

Air-lift internal loop biofilm reactor for realized simultaneous nitrification and denitrification

Simultaneous nitrification and denitrification (SND) was realized by means of a novel air-lift internal loop biofilm reactor, in which aeration was set in middle of the reactor. During operation, the aeration was adjusted to get appropriate dissolve oxygen (DO) in bulk solution and let aerobic and anoxic zone coexist in one reactor. When aeration was at 0.6 and 0.2 L/min, corresponding to DO of 5.8 and 2.5 mg/L in bulk solution, ammonia nitrogen removal percentage reached about 80 and 90 %, but total nitrogen removal percentage was lower than 25 %. While the aeration was reduced to 0.1 L/min, aerobic and anoxic zones existed simultaneously in one reactor to get 75 % of ammonia nitrogen and 50 % of total nitrogen removal percentage. Biofilms were, respectively, taken from aerobic and anoxic zone to verify their function of nitrification and denitrification in two flasks, in which ammonia nitrogen was transferred into nitrate completely by aerobic biofilm, and nitrate was removed more than 80 % by anoxic biofilm. Microelectrode was used to measure the DO distribution inside biofilms in anoxic zone corresponding to different aerations. When aeration was at 0.6 and 0.2 L/min, DO inside biofilm was more than 1.5 mg/L, but the DO inside biofilm decreased to anoxic status with depth of biofilm increasing corresponding to aeration of 0.1 L/min. The experimental results indicated that SND could be realized because of simultaneous existence of aerobic and anoxic biofilms in one reactor.     

Short-cut nitrification of domestic wastewater in a pilot-scale A/O nitrogen removal plant

The feasibility of nitrite accumulation in a pilot-scale A/O (anoxic/oxic) nitrogen removal plant treating domestic wastewater was investigated at various dissolved oxygen (DO) concentrations and pH levels. The results showed that the pH was not a useful operational parameter to realize nitrite accumulation. Significant nitrite accumulation was observed at the low DO concentration range of 0.3–0.8 mg/l and the maximum nitrite accumulation ratio of about 90% occurred at a DO concentration of 0.6 mg/l. This suggests a reduction of 22% in the oxygen consumption, and therefore a considerable saving in aeration. However, the nitrite accumulation was destroyed at the high DO concentration and the resumption was very slow. In addition, the average ammonia removal efficiency reached as high as 93% at the low DO level. Moreover, experimental results indicated that nitrogen could be removed by simultaneous nitrification and denitrification (SND) via nitrite in the aerobic zones at the low DO concentration, with the efficiency of 6–12%.     

Heterotrophic nitrification and aerobic denitrification inAlcaligenes faecalis strain TUD

Heterotrophic nitrification and aerobic and anaerobic denitrification byAlcaligenes faecalis strain TUD were studied in continuous cultures under various environmental conditions. Both nitrification and denitrification activities increased with the dilution rate. At dissolved oxygen concentrations above 46% air saturation, hydroxylamine, nitrite and nitrate accumulated, indicating that both the nitrification and denitrification were less efficient. The overall nitrification activity was, however, essentially unaffected by the oxygen concentration. The nitrification rate increased with increasing ammonia concentration, but was lower in the presence of nitrate or nitrite. When present, hydroxylamine, was nitrified preferentially. Relatively low concentrations of acetate caused substrate inhibition (K_I=109 M acetate). Denitrifying or assimilatory nitrate reductases were not detected, and the copper nitrite reductase, rather than cytochrome cd, was present. Thiosulphate (a potential inhibitor of heterotrophic nitrification) was oxidized byA. faecalis strain TUD, with a maximum oxygen uptake rate of 140–170nmol O₂·min^-1·mg prot^-1. Comparison of the behaviour ofA. faecalis TUD with that of other bacteria capable of heterotrophic nitrification and aerobic denitrification established that the response of these organisms to environmental parameters is not uniform. Similarities were found in their responses to dissolved oxygen concentrations, growth rate and ammonia concentration. However, they differed in their responses to externally supplied nitrite and nitrate.     

Effect of oxic and anoxic conditions on nitrous oxide emissions from nitrification and denitrification processes

A lab-scale sequencing batch reactor fed with real municipal wastewater was used to study nitrous oxide (N(2)O) emissions from simulated wastewater treatment processes. The experiments were performed under four different controlled conditions as follows: (1) fully aerobic, (2) anoxic-aerobic with high dissolved oxygen (DO) concentration, (3) anoxic-aerobic with low DO concentration, and 4) intermittent aeration. The results indicated that N(2)O production can occur from both incomplete nitrification and incomplete denitrification. N(2)O production from denitrification was observed in both aerobic and anoxic phases. However, N(2)O production from aerobic conditions occurred only when both low DO concentrations and high nitrite concentration existed simultaneously. The magnitude of N(2) O produced via anoxic denitrification was lower than via oxic denitrification and required the presence of nitrite. Changes in DO, ammonium, and nitrite concentrations influenced the magnitude of N(2)O production through denitrification. The results also suggested that N(2)O can be produced from incomplete denitrification and then released to the atmosphere during aeration phase due to air stripping. Therefore, biological nitrogen removal systems should be optimized to promote complete nitrification and denitrification to minimize N(2)O emissions.     

Determination of growth and coupled nitrification/denitrification by immobilized Thiosphaera pantotropha using measurement and modeling of oxygen profiles

An oxygen microsensor in combination with mathematical modeling was used to determine the behavior of immobilized Thiosphaera pantotropha. This organism can convert ammonia completely to nitrogen gas under aerobic conditions (coupled nitrification/denitrification) and denitrifies nitrate at highest rates under anaerobic conditions. Immobilization of T. pantotropha can result in aerobic and anaerobic zones inside the biocatalyst particle which will be advantageous for the conversion of ammonia and nitrate from wastewater. However, information of the effects of immobilization on the physiology of T. pantotropha is necessary for the development of such a system. This article gives the extension of a model developed to describe the behavior of chemostat cultures of T. pantotropha so that it can be used for immobilized cells. The original model was based on metabolic reaction equations. Kinetic and diffusion equations have now been added. Experimental verification was carried out using a stirred tank reactor and a Kluyver flask. After immobilization in agarose, the cells were grown in the particles under continuous culture conditions for 3 days. After 24 h the oxygen penetration depth showed a constant value of 100 mu, indicating that a steady state was reached. Scanning electron micrographs showed that large colonies of cells were present in this 100-mum aerobic layer.From the dynamics of the start-up phase, several parameters were determined from measurements of the oxygen concentration profiles made every few hours. The profiles simulated by the model were fitted to the measured data. The average value for the maximum specific growth rate was 0.52 h(-1), and the maximum oxygen conversion rate was 1.0 mol Cmol(-1) h(-1). The maximum specific acetate uptake rate was 2.0 mol Cmol(-1) h(-1), and the Monod constant for acetate was 2.9 x 10(-2) mol m(-3). The maximum specific nitrification rate was 0.58 x 10(-1) mol Cmol(-1) h(-1), and the amount of oxygen necessary for nitrification was 11% of the total oxygen uptake rate. Most of the kinetic parameters determined for the immobilized cells were in good agreement with those for the suspended cells. Only the maximum specific growth rate was significantly higher, and the maximum specific nitrification rate was some what lower than for suspended cells. The experimental results clearly show that an oxygen microsensor, in combination with mathematical modeling, can successfully be used to elucidate the kinetic behavior of immobilized, oxygen-consuming, cells.     

Simultaneous nitrification and denitrification using an autotrophic membrane-immobilized biofilm reactor

AIMS: To develop a laboratory-scale autotrophic membrane-immobilized biofilm reactor to remove nitrogen from drinking water. METHODS AND RESULTS: A polyvinyl alcohol (PVA) immobilized biofilm, attached to the surface of a silicone tube, was used as the basis of a bioreactor for simultaneous nitrification and denitrification of water. The bioreactor was aerated with air to supply oxygen for nitrification. Pure hydrogen was supplied to the silicone tube and diffused through the membrane wall to feed the biofilm for autotrophic denitrification. The bioreactor was effective for the simultaneous nitrification and denitrification of water after a short period of acclimation, while the biofilm exhibited good resistance to the inhibition of denitrification by dissolved oxygen; the denitrification rate decreased by only 8% as the dissolved oxygen increased from 2 mg l(-1) to saturation. CONCLUSIONS: By using PVA crosslinked with sodium nitrate to entrap nitrifying and denitrifying sludge on the surface of a silicone tube, a novel bioreactor for simultaneous nitrification and denitrification was developed. In addition to performing as an immobilizing agent to strengthen the biofilm, PVA protected the denitrifying microorganisms to reduce the inhibition by dissolved oxygen under aerobic condition. Therefore, nitrification and denitrification occurred simultaneously within the biofilm. Furthermore, the immobilization technique shortened the acclimation period of the bioreactor. SIGNIFICANCE AND IMPACT OF THE STUDY: The described space saving and simple to operate bioreactor for nitrogen removal performed autotrophic denitrification to solve the problem of residual carbon in heterotrophic denitrification, and thus is suitable for removing nitrogen from drinking water.     

以纸为碳源去除地下水硝酸盐的研究

研究了以纸为碳源和反应介质的生物反应器对水中硝酸盐的去除。结果表明,以纸为碳源的反应器启动快．反硝化反应受温度及水力停留时间影响大。25℃的反硝化速率是14℃的1．7倍。在室温25±1℃,进水硝酸盐氮浓度为45．2mg·L^-1、水力停留时间8．6h时,反应器对硝酸盐氮的去除率在99．6％以上,当水力停留时间为7．2h,氮去除率只有50％。反硝化反应受pH值和溶解氧的影响小,反应进行过程中,纸表面形成了生物膜,纸也被消耗了．采用反应器出水再经活性炭吸附的工艺流程处理高硝酸盐氮地下水,<33．9mg·L^-1的硝酸盐氮完全去除,没有出现NC2-N,最终出水水质DOC<11mg·L^-1。