Sodium bicarbonate reduces viability and alters aflatoxin distribution of Aspergillus parasiticus in Czapek's agar.

The potential of sodium bicarbonate to inhibit growth of and aflatoxin synthesis by Aspergillus parasiticus was examined in Czapek's agar (CA), a medium in which fluorescence under UV light indicates aflatoxin production. Incorporation of sodium bicarbonate (SB) into CA at 0.011, 0.022, and 0.033 mol% reduced cell viability 63-, 10(3)-, and greater than 10(7)-fold, respectively. Colonies resulting from surviving cells did not fluoresce under UV light, but thin-layer chromatography analysis of culture extracts detected aflatoxins. Potassium bicarbonate (KB) at 0.011 and 0.022 mol% produced inhibitory effects similar to those of SB, but NaCl and silica had no effect. After 7 days, control cultures had the normal aflatoxin distribution (B1 greater than G1 greater than B2 greater than G2), but this distribution shifted to B2 greater than B1 approximately equal to G2 greater than G1 during prolonged incubation. Cultures supplemented with SB and KB contained mostly aflatoxins B1 and G1 after 28 days. Both SB and KB raised the pH of CA to 7.5 to 8.5 at the time of growth. Culture growth on CA adjusted to pH 7.5 to 8.5 with NaOH was not inhibited but exhibited reduced fluorescence and elevated levels of aflatoxins B1 and G1. Thus, while bicarbonate inhibition of growth could not be attributed to pH elevation, the lack of culture fluorescence on CA-SB and CA-KB and the altered aflatoxin distribution were caused by the ability of SB and KB to elevate pH.     

Influence of temperature cycling on the production of aflatoxins B1 and G1 by Aspergillus parasiticus.

The effect of temperature cycling on the relative productions of aflatoxins B1 and G1 by Aspergillus parasiticus NRRL 2999 was studied. The cycling of temperature between 33 and 15 degrees C favored aflatoxin B1 accumulation, whereas cycling between 35 and 15 degrees C favored aflatoxin G1 production. Cultures subjected to temperature cycling between 33 and 25 degrees C at various time intervals changed the relative productions of aflatoxins B1 and G1 drastically. Results obtained with temperature cycling and yeast extract-sucrose medium with ethoxyquin to decrease aflatoxin G1 production suggest that the enzyme system responsible for the conversion of aflatoxin B1 to G1 might be more efficient at 25 degrees C than at 33 degrees C. The possible explanation of the effect of both constant and cycling temperatures on the relative accumulations of aflatoxins B1 and G2 might be through the control of the above enzyme system. The study also showed that greater than 57% of aflatoxin B1, greater than 47% of aflatoxin G1, and greater than 50% of total aflatoxins (B1 plus G1) were in the mycelium by day 10 under both constant and cyclic temperature conditions.     

Effects of various acids and salts on growth and aflatoxin production by Aspergillus flavus NRRL 3145.

The effects of sodium chloride, sodium acetate, benzoic acid, sodium benzoate, malonic acid, and sodium malonate on growth and aflatoxin production by Aspergillus flavus were investigated in synthetic media. Sodium chloride at concentrations equivalent to or greater than 12 g/100 ml inhibited growth and aflatoxin production, while at 8 g or less/100 ml, growth and aflatoxin production were stimulated. At 2 g or less/100 ml, sodium acetate also stimulated growth and aflatoxin production, but reduction occurred with 4 g or more/100 ml. Malonic acid at 10, 20, 40, and 50 mM reduced growth and aflatoxin production (over 50%) while sodium malonate at similar concentrations but different pH values had the opposite effect. Benzoic acid (pH 3.9) and sodium benzoate (pH 5.0) at 0.4 g/100 ml completely inhibited growth and aflatoxin production. Examination of the effect of initial pH indicated that the extent of inhibitory action of malonic acid and sodium acetate was a function of initial pH. The inhibitory action of benzoic acid and sodium benzoate appeared to be a function of undissociated benzoic acid molecules. Aflatoxin reduction was usually accompanied by an unidentified orange pigment, while aflatoxin stimulation was accompanied by unidentified blue and green fluorescent spots but with lower Rf values that aflatoxins B1, G1, B2, and G2 standards.     

Aflatoxin Production in Meats. I. Stored Meats

Aflatoxins were produced on fresh beef (in which bacterial spoilage was delayed with antibiotics), ham, and bacon inoculated with toxinogenic fungi and stored at 15, 20 and 30 C. Meats stored at 10 C were spoiled by bacteria and yeast before detectable levels of aflatoxins were produced. High levels of aflatoxins were formed in meats stored at 20 C; one sample supported the production of 630 mug of aflatoxins per g of meat, the major portion (580 mug) of which was aflatoxin G(1). Meats stored below 30 C developed higher levels of aflatoxin G(1) than B(1), but at 30 C Aspergillus flavus produced equal amounts of B(1) and G(1), whereas A. parasiticus continued to produce more G(1) than B(1).     

Molasses supplementation promotes conidiation but suppresses aflatoxin production by small sclerotial Aspergillus flavus

AIMS: To find a supplemental ingredient that can be added to routinely used growth media to increase conidial production and decrease aflatoxin biosynthesis in small sclerotial (S strain) isolates of Aspergillus flavus. METHODS AND RESULTS: Molasses was added to three commonly used culture media: coconut agar (CAM), potato dextrose agar (PDA), and vegetable juice agar (V8) and production of conidia, sclerotia, and aflatoxins by A. flavus isolate CA43 was determined. The effect of nitrogen sources in molasses medium (MM) on production of conidia, sclerotia and aflatoxins was examined. Water activity and medium pH were also measured. Conidia harvested from agar plates were counted using a haemocytometer. Sclerotia were weighed after drying at 45 degrees C for 5 days. Aflatoxins B(1) and B(2) were quantified by high-performance liquid chromatography. Addition of molasses to the media did not change water activity or the pH significantly. Supplementing CAM and PDA with molasses increased conidial production and decreased aflatoxins. Two-fold increased yield of conidia was found on MM, which, like V8, did not support aflatoxin production. Adding ammonium to MM significantly increased the production of sclerotia and aflatoxins, but slightly decreased conidial production. Adding urea to MM significantly increased the production of conidia, sclerotia and aflatoxins. CONCLUSIONS: Molasses stimulated conidial production and inhibited aflatoxin production. Its effect on sclerotial production was medium-dependent. Water activity and medium pH were not related to changes in conidial, sclerotial or aflatoxin production. Medium containing molasses alone or molasses plus V8 juice were ideal for conidial production by S strain A. flavus. SIGNIFICANCE AND IMPACT OF THE STUDY: Insight into molecular events associated with the utilization of molasses may help to elucidate the mechanism(s) that decreases aflatoxin biosynthesis. Targeting genetic parameters in S strain A. flavus isolates may reduce aflatoxin contamination of crops by reducing the survival and toxigenicity of these strains.     

Identification of O-methylsterigmatocystin as an aflatoxin B1 and G1 precursor in Aspergillus parasiticus.

An isolate of Aspergillus parasiticus CP461 (SRRC 2043) produced no detectable aflatoxins, but accumulated O-methylsterigmatocystin (OMST). When sterigmatocystin (ST) was fed to this isolate in a low-sugar medium, there was an increase in the accumulation of OMST, without aflatoxin synthesis. When radiolabeled [14C]OMST was fed to resting mycelia of a non-aflatoxin-, non-ST-, and non-OMST-producing mutant of A. parasiticus AVN-1 (SRRC 163), 14C-labeled aflatoxins B1 and G1 were produced; 10 nmol of OMST produced 7.8 nmol of B1 and 1.0 nmol of G1, while 10 nmol of ST produced 6.4 nmol of B1 and 0.6 nmol of G1. A time course study of aflatoxin synthesis in ST feeding experiments with AVN-1 revealed that OMST is synthesized by the mold during the onset of aflatoxin synthesis. The total amount of aflatoxins recovered from OMST feeding experiments was higher than from experiments in which ST was fed to the resting mycelia. These results suggest that OMST is a true metabolite in the aflatoxin biosynthetic pathway between sterigmatocystin and aflatoxins B1 and G1 and is not a shunt metabolite, as thought previously.     

Development and validation of a method for the quantitative determination of aflatoxin contaminants in Maytenus ilicifolia by HPLC with fluorescence detection

A method for the quantification of aflatoxins B1, G1, B2 and G2 in the medicinal herb Maytenus ilicifolia was developed and validated. The method used immunoaffinity columns for sample clean-up and HPLC with fluorescence detection without any derivatisation step. The method showed good inter-day accuracy (bias values in the range 4.5-10.7%) and precision (5-16% RSD) when applied to the determination of levels of aflatoxins ranging from 7 to 20 ppb in the plant material. The detection limits for samples of the plant material spiked with aflatoxins were 3.5 ng/g for B1 and G1 and 0.1 ng/g for B2 and G2. The method was successfully applied to commercial samples of Maytenus ilicifolia for the screening of aflatoxin contaminants.     

Biosynthetic relationship among aflatoxins B1, B2, M1, and M2.

Aflatoxins are a family of toxic, acetate-derived decaketides that arise biosynthetically through polyhydroxyanthraquinone intermediates. Most studies have assumed that aflatoxin B1 is the biosynthetic precursor of the other aflatoxins. We used a strain of Aspergillus flavus which accumulates aflatoxin B2 to investigate the later stages of aflatoxin biosynthesis. This strain produced aflatoxins B2 and M2 but no detectable aflatoxin B1 when grown over 12 days in a low-salt, defined growth medium containing asparagine. Addition of dichlorvos to this growth medium inhibited aflatoxin production with concomitant accumulation of versiconal hemiacetal acetate. When mycelial pellets were grown for 24, 48, and 72 h in growth medium and then transferred to a replacement medium, only aflatoxin B2 and M2 were recovered after 96 h of incubation. Addition of sterigmatocystin to the replacement medium led to the recovery of higher levels of aflatoxins B2 and M2 than were detected in control cultures, as well as to the formation of aflatoxins B1 and M1 and O-methylsterigmatocystin. These results support the hypothesis that aflatoxins B1 and B2 can arise independently via a branched pathway.     

Biosynthetic relationship among aflatoxins B1, B2, M1, and M2

Aflatoxins are a family of toxic, acetate-derived decaketides that arise biosynthetically through polyhydroxyanthraquinone intermediates. Most studies have assumed that aflatoxin B1 is the biosynthetic precursor of the other aflatoxins. We used a strain of Aspergillus flavus which accumulates aflatoxin B2 to investigate the later stages of aflatoxin biosynthesis. This strain produced aflatoxins B2 and M2 but no detectable aflatoxin B1 when grown over 12 days in a low-salt, defined growth medium containing asparagine. Addition of dichlorvos to this growth medium inhibited aflatoxin production with concomitant accumulation of versiconal hemiacetal acetate. When mycelial pellets were grown for 24, 48, and 72 h in growth medium and then transferred to a replacement medium, only aflatoxin B2 and M2 were recovered after 96 h of incubation. Addition of sterigmatocystin to the replacement medium led to the recovery of higher levels of aflatoxins B2 and M2 than were detected in control cultures, as well as to the formation of aflatoxins B1 and M1 and O-methylsterigmatocystin. These results support the hypothesis that aflatoxins B1 and B2 can arise independently via a branched pathway.     

Fate of aflatoxins B1 and G1 residues during biscuit processing

Effect of biscuit processing on the destruction of aflatoxins B₁ and G₁ with and/or without some commonly leavening agents used namely sodium bicarbonate, ammonium bicarbonate and sodium bisulfite and sodium chloride. It was found that mixing step reduced the concentration of aflatoxins B₁ and G₁ by 80.7% and 82.7%, while the effect of baking step being 28.9% and 21.5%. The effect of mixing was found to be more pronounced than that baking step. The highest destruction effect on aflatoxin B1 was observed by adding a mixture composed of sodium and ammonium bicarbonate and sodium bisulfite followed by sodium chloride, sodium bisulfite, ammonium bicarbonate and/or sodium bicarbonate alone, where the reduction values of toxin after mixing were 93.4,91.9,91.7, 88.8 and 86.6% respectively, while the baking effect ranged 17.2 to 34.5% in the presence of different leaving agents added. Concerning aflatoxin G1; the highest destructive effect of toxin was adsorbed by adding a mixture of sodium and ammonium bicarbonate and sodium bisulfite followed by sodium bisulfite, sodium chloride, ammonium bicarbonate and/or sodium bicarbonate alone since the destruction values of such toxin after mixing were 96.2%, 92.8%, 92.6%, 89.0% and 87.7% respectively, while the baking effect ranged 20.9 to 34.5% in all leavening agents added.     

Enzyme-linked immunosorbent analysis for aflatoxin B1.

An enzyme-linked immunosorbent analysis (ELISA) permitted the detection of less than 10 pg of aflatoxin B1 per ml. The antitoxin was most specific for aflatoxins B1 and B2alpha, and least specific for aflatoxin G1.     

Enzyme-linked immunosorbent analysis for aflatoxin B1.

An enzyme-linked immunosorbent analysis (ELISA) permitted the detection of less than 10 pg of aflatoxin B1 per ml. The antitoxin was most specific for aflatoxins B1 and B2alpha, and least specific for aflatoxin G1.     

Effect of initial pH on aflatoxin production.

The effect of initial pH on aflatoxin production by Aspergillus parasiticus NRRL 2999 was examined in a semisynthetic medium. Maximal growth, aflatoxin production, and aflatoxin production per unit of growth occurred at initial pH levels of 5.0, 6.0, and 7.0 respectively. Initial pH levels less than pH 6.0 favored production of the B toxins, whereas levels greater than pH 6.0 favored production of the G toxins.     

Bioremediation of aflatoxins by some reference fungal strains.

Aspergillus parasiticus RCMB 002001 (2) producing four types of aflatoxins B1, B2, G1, and G2 was used in this study as an aflatoxin-producer. Penicillium griseofulvum, P. urticae, Paecilomyces lilacinus, Trichoderma viride, Candida utilis, Saccharomyces cerevisiae as well as a non-toxigenic strain of Aspergillus flavus were found to be able to exhibit growth on aflatoxin B1-containing medium up to a concentration of 500 ppb. It was also found that several fungal strains exhibited the growth in co-culture with A. parasiticus, natural aflatoxins producer, and were able to decreased the total aflatoxin concentration, resulting in the highest inhibition percentage of 67.2% by T viride, followed by P. lilacinus, P. griseofulvum, S. cerevisiae, C. utilis, P. urticae, Rhizopus nigricans and Mucor rouxii with total aflatoxin inhibition percentage of 53.9, 52.4, 52, 51.7, 44, 38.2 and 35.4%, respectively. The separation of bioremediation products using GC/MS revealed that the toxins were degraded into furan moieties.     

Reduction of mutagenic activity of aflatoxins after UV-irradiation.

Solutions of aflatoxins B1, B2, G1 and G2 and solid films of aflatoxin B1 were irradiated with UV light of wavelength corresponding to the absorption band of aflatoxins at approximately 365 nm (approximately 27 500 cm-1). The reaction was followed spectrophotometrically. Simultaneously the mutagenicity of samples of aflatoxins was determined using Salmonella typhimurium/mammalian microsome test. UV-irradiation caused a modification in all aflatoxins studied (in aqueous and nonaqueous solutions as well as in a solid film); the final photoproducts lost completely the mutagenic activity.     

Intrafungal distribution of aflatoxins among conidia and sclerotia of Aspergillus flavus and Aspergillus parasiticus

This research examines the distribution of aflatoxins among conidia and sclerotia of toxigenic strains of Aspergillus flavus Link and Aspergillus parasiticus Speare cultured on Czapek agar (21 days, 28 degrees C). Total aflatoxin levels in conidia and sclerotia varied considerably both within (intrafungal) and among strains. Aspergillus flavus NRRL 6554 accumulated the highest levels of aflatoxin (conidia: B1, 84000 ppb; G1, 566000 ppb; sclerotia: B1, 135000 ppb; G1, 968000 ppb). Substantial aflatoxin levels in conidia could place at risk those agricultural workers exposed to dust containing large numbers of A. flavus conidia. Cellular ratios of aflatoxin B1 to aflatoxin G1 were nearly identical in conidia and sclerotia even though levels of total aflatoxins in these propagule types may have differed greatly. Aflatoxin G1 was detected in sclerotia of all A. flavus strains but in the conidia of only one strain. Each of the A. parasiticus strains examined accumulated aflatoxin G1 in both sclerotia and conidia. These results are examined in the context of current evolutionary theory predicting an increase in the chemical defense systems of fungal sclerotia, propagules critical to the survival of these organisms.     

Aflatoxin-selective molecularly-imprinted polymer membranes based on acrylate-polyurethane semi-interpenetrating polymer networks

Synthetic analogs of biological receptors able to group-selective recognition of aflatoxins were obtained using the combination of the technique of molecular imprinting with the method of computer modeling. The synthetic receptors were obtained in a form of thin and porous membranes based on semi-interpenetrating polymer networks. The selection of functional monomers able to noncovalent interactions with aflatoxins B1, B2, and G2 was based on the data of computer modeling. Allylamine, diethylaminoethylmethacrylate, and N,N'-methylenebisacrylamide, providing high binding energies with aflatoxins B1, B2, and G2 were selected as functional monomers for the formation of aflatoxin B1-imprinted polymer membranes. It was shown that aflatoxin-B1-imprinted polymeric membranes synthesized using N,N'-methylenebisacrylamide as a functional monomer were characterized with good physico-mechanical properties as well as good adsorbtion capability towards aflatoxin B1. Neglidgible levels of aflatoxin B1 adsorbtion on the surface of blank membranes were observed. High adsorbtion capability of the MIP membranes towards mycotoxins affiliated to the group of aflatoxins was demonstrated, while negligible adsorbtion of ochratoxin A was observed. Therefore, synthetic analogs of biological receptors able to group-selective recognition of aflatoxins in the range 1-1000 ppb were developed.     

Action of phosphine on production of aflatoxins by various Aspergillus strains isolated from foodstuffs.

Phosphine is a food fumigant, used until now as an insecticide and rodenticide. The present work researches the action of phosphine treatment on growth and aflatoxin production of 23 Aspergillus strains. Production of aflatoxins B1, B2, G1, and G2 decreased in almost all cases by a ratio of 10 to 100. Phosphine treatment therefore seems favorable to prevent growth of various Aspergillus strains, in the context of keeping food safe.     

Action of phosphine on production of aflatoxins by various Aspergillus strains isolated from foodstuffs

Phosphine is a food fumigant, used until now as an insecticide and rodenticide. The present work researches the action of phosphine treatment on growth and aflatoxin production of 23 Aspergillus strains. Production of aflatoxins B1, B2, G1, and G2 decreased in almost all cases by a ratio of 10 to 100. Phosphine treatment therefore seems favorable to prevent growth of various Aspergillus strains, in the context of keeping food safe.