A hybrid anaerobic solid-liquid bioreactor for food waste digestion

A hybrid anaerobic solid-liquid (HASL) bioreactor is an enhanced two-phase anaerobic system, that consists of a solid waste reactor as the acidification reactor and a wastewater reactor, i.e. an upflow anaerobic sludge blanket (UASB) reactor as the methanogenic reactor. Food waste digestion in HASL bioreactors with pre-acidification and HASL operation stages was investigated in two separate runs. After 8 days of pre-acidification in Run A and 4 days in Run B, total volatile fatty acid (TVFA) and chemical oxygen demand (COD) concentrations in the leachates of both acidification reactors were similar. During HASL operation stage, TVFA and COD removal in the methanogenic phase were 77–100% and 75–95%, respectively. Some 99% of the total methane generated was from the methanogenic phase with a content of 68–70% methane. At the end of operation, about 59–60% of the added volatile solids (VS) were removed with a methane yield of 0.25 l g^–1 VS.     

Formation of metabolites during biodegradation of linear alkylbenzene sulfonate in an upflow anaerobic sludge bed reactor under thermophilic conditions.

Biodegradation of linear alkylbenzene sulfonate (LAS) was shown in an upflow anaerobic sludge blanket reactor under thermophilic conditions. The reactor was inoculated with granular biomass and fed with a synthetic medium and 3 micromol/L of a mixture of LAS with alkylchain length of 10 to 13 carbon atoms. The reactor was operated with a hydraulic retention time of 12 h with effluent recirculation in an effluent to influent ratio of 5 to 1. A sterile reactor operated in parallel revealed that sorption to sludge particles initially accounted for a major LAS removal. After 8 days of reactor operation, the removal of LAS in the reactor inoculated with active granular biomass exceeded the removal in the sterile reactor inoculated with sterile granular biomass. The effect of sorption ceased after 185 to 555 h depending on the LAS homologs. 40% of the LAS was biodegraded, and the removal rate was 0.5 x 10(-6) mol/h/mL granular biomass. Acidified effluent from the reactor was subjected to dichloromethane extraction followed by gas chromatography/mass spectrometry. Benzenesulfonic acid and benzaldehyde were detected in the reactor effluent from the reactor with active granular biomass but not in the sterile and unamended reactor effluent. Benzenesulfonic acid and benzaldehyde are the first identified degradation products in the anaerobic degradation of LAS.     

Granulation in thermophilic upflow anaerobic sludge blanket (UASB) reactors

The state of the art for thermophilic UASB reactors is discussed focusing on the start-up of UASB reactors, the influence of the waste water composition and temperature on the development and maintenance of thermophilic granules, and the microbial composition and structure of thermophilic granules.     

Biodegradation by activated sludge and toxicity of tetracycline into a semi-industrial membrane bioreactor

Much attention has been devoted recently to the fate of pharmaceutically active compounds such as tetracycline antibiotics in soil and water. Tetracycline (TC) biodegradability by activated sludge derived from membrane bioreactor (MBR) treating swine wastewater via CO₂-evolution was evaluated by means of modified Sturm test, which was also used to evaluate its toxicity on carbon degradation. The impact of tetracycline on a semi-industrial MBR process was also examined and confronted to lab-scale experiments. After tetracycline injection in the pilot, no disturbance was detected on the elimination of organic matters and ammonium (nitrification), reaching after injection 88% and 99% respectively; only denitrification was slightly affected. Confirming the ruggedness and the superiority of membrane bioreactors over conventional bioreactors, no toxicity was observed at the considered level of TC in the pilot (20 mg TOC L⁻¹), while at lab-scale sodium benzoate biodegradation was completely inhibited from 10 mg TOC L⁻¹ TC. The origin of the activated sludge showed a significant impact on the performances, since the ultimate biodegradation was in the range −50% to −53% for TC concentrations in the range 10–20 mg TOC L⁻¹ with conventional bioreactor sludge and increased to 18% for 40 mg TOC L⁻¹ of TC with activated sludge derived from the MBR pilot. This confirmed the higher resistance of activated sludge arising from membrane bioreactor.     

Biomineralization of 2,3,4,6-Tetrachlorophenol by Bacillus sp. and Staphylococcus sp. Isolated from Secondary Sludge of Pulp and Paper Mill

Three 2,3,4,6-tetrachlorophenol (2,3,4,6-TeCP)-mineralizing bacteria were isolated from the secondary sludge of a pulp and paper industry. The isolates used 2,3,4,6-TeCP as a source of carbon and energy and were capable of degrading this compound, as indicated by stoichiometric release of chloride and biomass formation. Based on 16S rRNA gene sequence analysis, the bacteria were identified as Bacillus megaterium (CL3), Staphylococcus suciri (CL10), and Bacillus thuringensis (CL11). High-performance liquid chromatography (HPLC) analysis revealed that these isolates were able to degrade 2,3,4,6-TeCP at higher concentrations (600 mg/L or 2.5 mM). A consortia of the isolates completely removed 2,3,4,6-TeCP from the sludge obtained from a pulp and paper mill within 2 weeks when supplemented at a rate of 100 mg/L or 0.43 mM. A bacterial consortium also significantly reduced absorbable organic halogen (AOX) and extractable organic halogen (EOX) by 63% and 68%, respectively, from the sludge. These isolates have a high potential to remove 2,3,4,6-TeCP and may be used for remediation of pulp paper mill waste containing 2,3,4,6-TeCP.     

Membrane fouling control and sludge solubilization using high voltage impulse (HVI) electric fields

The effectiveness of a high voltage impulse (HVI) technique in mitigating the membrane fouling occurring in membrane bioreactors was examined. After the activated sludge was membrane filtered, the cake layer was removed by either water-washing cleaning (experimental control) or HVI cleaning. The flux recoveries after HVI induction were always higher than those of the control. The effect of HVI induction on the sludge properties was also examined. The mixed liquor suspended solids (MLSS) concentration decreased with increasing HVI contact time, while the concentrations of soluble-chemical oxygen demand (SCOD), -total nitrogen (TN), -total phosphorus (TP), -polysaccharide, and -protein in the bulk solution increased, indicating that the flocs and cells were damaged by the HVI induction. These results suggest that the HVI induction led to sludge solubilization, which loosened the tightly deposited cake layer on the membrane surface, hence allowing it to be easily dislodged from the membrane surface.     

Proteogenomic Refinement of the Neomegalonema perideroedesT Genome Annotation

Neomegalonema perideroedes (formerly Meganema perideroedes) str. G1 is the type strain and only described isolate of the genus Neomegalonema (formerly Meganema) which belongs to the Alphaproteobacteria. N. perideroedes is distinguished by the ability to accumulate high amounts of polyhydroxyalkanoates and has been associated with bulking problems in wastewater treatment plants due to its filamentous morphology. In 2013, its genome was sequenced as part of the Genomic Encyclopedia of Bacteria and Archaea (GEBA), which aims to improve the sequencing coverage of the poorly represented regions of the bacterial and archaeal branches of the tree of life. As N. perideroedes str. G1 is relatively distantly related to well described species—being the only sequenced member of its proposed family—the in silico prediction of genes by nucleotide homology to reference genes might be less reliable. Here, a proteomic dataset for the refinement of the N. perideroedes genome annotations is generated which clearly indicates the shortcomings of high‐throughput in silico genome annotation.     

Effect of tannery sludge amendments on the activity of soil enzymes and phytoremediation potential of two economically important cultivars of geranium (Pelargonium graveolens)

A field experiment was conducted to observe the effect of TS amendments on soil enzymes and phytoremediation potential of two economically important cultivars of geranium. Different doses of TS were applied in soil to examine threshold limit of HMs where geranium cultivars can be grown successfully in contaminated sites. Treatment variation significantly affected pH, EC, OC, N, P, K and HM content in soil after 50 days of incubation. After harvest, both cultivars were examined to assess the impact of various treatments on their fresh herb, dry matter, essential oil yield and HM accumulation. C/G ratio close to 1 was observed at 50 tha^?1 sludge treatment in both cultivars. Urease and β-glucosidase activities in soil were maximum at 50 tha^?1 whereas dehydrogenase and phosphatase activities were maximum at 100 tha^?1 in both cultivars. β-glucosidase, acid and alkaline phosphatase, urease and dehydrogenase activities were relatively high after 85 days over 45 days in both cultivars. Maximum metal uptake was found in roots of cv. Bourbon followed by leaves. Geranium was observed to be a good candidate for phytoremediation as it mitigates metal toxicity by root absorption and cv. Bourbon is better candidate for the same.     

利用皇竹草处理城市污泥生产植物产品

利用大生物量植物——皇竹草(Pennisetum hydridum),处理城市污泥高效生产有用的植物产品。通过小型田间试验,采用根兜分株移栽和直接扦插方式种植皇竹草,比较土壤、新鲜污泥、土壤+新鲜污泥等体积混合、植物处理后的污泥4种介质的适应性,测定了皇竹草的成活率和生长状况,以及污泥自身性质的变化;通过盆栽试验及田间试验进一步探讨育苗后移栽在新鲜污泥上的可行性。结果表明,新鲜污泥上直接扦插的皇竹草无一存活,即使是根兜分株移栽其成活率也仅为16.67%,生长较差。而对于土壤+污泥混合物或植物处理后的污泥,采用直接扦插方式,皇竹草的成活率也分别达58.33%、75.00%,两个月干草产量达22.20、19.80 t/hm2,为土壤上的5.11、4.55倍。皇竹草吸收K较明显,3个有污泥的处理皇竹草K含量接近40 g/kg干重,N、P2O5、K2O的总含量大于70 g/kg,可作为有机K肥原料;皇竹草重金属Cu、Zn、Pb、Cd含量均符合国家饲料卫生标准(GB 13078—2001),作为饲料是安全的。盆栽试验及田间试验表明,采用育苗后移栽的方式,皇竹草在新鲜污泥上的成活率达66.67%以上。因此,城市污泥直接种植皇竹草可以实现资源化利用。