砂地柏种子油超临界CO2萃取技术研究

砂地柏(Sabina vulgaris Ant．)种子油是该植物主要的杀虫、杀菌活性组分。通过对砂地柏种子油的超临界CO2萃取工艺进行研究,得出较适宜的工艺条件为：采用先静态后动态的萃取方式,静态萃取时间10min;动态萃取条件为,萃取压力7000psi,萃取温度65℃,CO2流量为40mL／g;限流管温度80℃,用石油醚(沸程60-90℃)接受。初步认为SC-CO2萃取砂地柏种子油优于常规提取方法。同时对该技术工业化应用前景和可行性进行了分析探讨。     

茶蜂花粉抗氧化活性与成分

本实验研究了茶蜂花粉的抗氧化活性和功效成分。茶蜂花粉85%乙醇回流提取,经过石油醚、乙酸乙酯、正丁醇依次萃取,得到石油醚萃取物、乙酸乙酯萃取物、正丁醇萃取物以及萃余物4个部分,用D-半乳糖诱导衰老小鼠模型检测茶蜂花粉不同组分的抗氧化活性,采用多种色谱方法分离具有抗氧化活性的成分,利用核磁共振方法鉴定各单体的化学结构。结果表明:茶蜂花粉乙醇提取物、乙酸乙酯萃取物具有明显的抗氧化作用,乙酸乙酯萃取物经MCI柱层析,得到30%、50%、70%三个乙醇洗脱组分,其中30%乙醇洗脱组分具有显著抗氧化活性,从该洗脱部分得到三个单体化合物,经鉴定为:槲皮素、山奈素-3-O-芸香糖苷、山奈酚-3-O-(2″,3″,4″-O-三对羟基桂皮酰基)-β-D-吡喃葡萄糖苷,推测茶蜂花粉具有抗氧化活性的成分主要为黄酮类化合物。     

超临界CO2萃取百合花挥发油的工艺研究

本文介绍了超临界CO2萃取百合花中挥发油的提取分离工艺,重点研究了超临界CO2萃取压力、温度、时间对出油率的影响。正交试验结果表明：影响超临界CO2萃取的主要因素为C3〉A2〉B2（A为萃取压力,B为萃取温度,C为萃取时间）;最佳工艺参数：SC-CO2萃取压力为18MPa,温度为50℃,时间为90min,流量为25L／min,所得百合花挥发油的出油率高达2．92％。     

侧柏乙醇提取物对21种植物病原真菌的抑菌活性

采用菌丝生长速率法测定了侧柏(Platycladus orientalis)叶、小枝、球果和种子4个不同部位乙醇提取物对21种植物病原真菌的抑菌活性。结果显示:(1)在供试浓度为50g/L(相当于干样)时,侧柏各部位乙醇提取物对4种供试植物病原真菌均具有较好抑制作用,其中侧柏叶提取物的抑菌效果最好,对供试葡萄白腐病菌(Conio-thyrium diplodiella)、葡萄黑痘病菌(Elsinoe ampelina)、番茄绵腐病菌(Phytophthora melongenae)和青霉病菌(Penicilliu mexpansum)的EC50分别为:5.424、3.186、8.913和19.000g/L。(2)侧柏叶乙醇提取物的石油醚萃取物和乙酸乙酯萃取物抑菌活性均较好,在供试浓度为0.5g/L时,石油醚萃取物对苹果腐烂病菌(Valsa mali)和葡萄黑痘病菌(E.ampelina)的抑菌率分别为80.35%和60.23%;乙酸乙酯萃取物对以上2种植物病原菌的抑菌率分别为81.88%和64.06%。结果表明:侧柏叶、小枝、球果和种子乙醇提取物均具有一定抑菌活性,叶乙醇提取物的活性最好,活性成分主要集中在石油醚萃取物和乙酸乙酯萃取物中。     

草菇培养物中粗三萜和黄酮含量及抗氧化抗肿瘤活性研究

采用液体摇瓶法培养草菇菌丝体,并用不同有机溶剂对培养液及菌丝体中的代谢成分分别进行分离提取,获得了不同来源的次生代谢提取物。对各提取物的成分分析表明,石油醚相、乙酸乙酯相和乙醇相提取物中均含有粗三萜和黄酮类物质,但菌丝体提取物中粗三萜和黄酮含量明显高于培养液提取物中的含量。石油醚抽提菌丝体获得的提取物中粗三萜含量最高,达17%,而乙酸乙酯抽提菌丝体获得的提取物中黄酮含量最高,达9.31%。抗氧化活性检测结果显示,石油醚相、乙酸乙酯相、乙醇相中的代谢提取物均有较高的抗氧化活性,但乙酸乙酯相提取物的抗氧化活性明显高于石油醚相提取物,具最高抗氧化活性的提取物分别来自乙酸乙酯、乙醇对菌丝体的抽提物。MTT法检测各提取物对胃癌细胞增殖的抑制作用,结果显示各组分均有较高的抗肿瘤活性,且抗肿瘤活性与提取物浓度存在明显的量效关系。     

石上柏乙酸乙酯萃取物对喉癌Hep-2细胞增殖与迁移作用的研究

本文利用三种不同极性溶剂从石上柏中分离出活性成分,观察其对喉癌Hep-2细胞的增殖与迁移作用的影响。干燥的石上柏全草粉碎后经乙醇回流提取浓缩得浸膏,依次采用石油醚、二氯甲烷、乙酸乙酯三种溶剂进行萃取,以获得各极性溶剂萃取部位;MTT法检测石上柏提取物对Hep-2细胞增殖的影响;流式细胞仪检测石上柏提取物对Hep-2细胞周期的影响;细胞划痕实验检测石上柏提取物对Hep-2细胞迁移能力的影响;采用p53报告基因探讨石上柏提取物对喉癌Hep-2细胞的作用机制。结果显示31.2~500.0μg/m L的乙酸乙酯萃取部位能明显抑制Hep-2细胞的生长及划痕区域的迁移;15.0~60.0μg/mL的乙酸乙酯萃取物部位能使喉癌Hep-2细胞阻滞于G1期,并且能激活p53的表达。结果表明石上柏乙酸乙酯萃取部位可明显抑制喉癌Hep-2细胞的生长及迁移,其作用与激活p53通路有关。     

草菇培养物中粗三萜和黄酮含量及抗氧化抗肿瘤活性研究

采用液体摇瓶法培养草菇菌丝体,并用不同有机溶剂对培养液及菌丝体中的代谢成分分别进行分离提取,获得了不同来源的次生代谢提取物。对各提取物的成分分析表明,石油醚相、乙酸乙酯相和乙醇相提取物中均含有粗三萜和黄酮类物质,但菌丝体提取物中粗三萜和黄酮含量明显高于培养液提取物中的含量。石油醚抽提菌丝体获得的提取物中粗三萜含量最高,达17%,而乙酸乙酯抽提菌丝体获得的提取物中黄酮含量最高,达9.31%。抗氧化活性检测结果显示,石油醚相、乙酸乙酯相、乙醇相中的代谢提取物均有较高的抗氧化活性,但乙酸乙酯相提取物的抗氧化活性明显高于石油醚相提取物,具最高抗氧化活性的提取物分别来自乙酸乙酯、乙醇对菌丝体的抽提物。MTT法检测各提取物对胃癌细胞增殖的抑制作用,结果显示各组分均有较高的抗肿瘤活性,且抗肿瘤活性与提取物浓度存在明显的量效关系。     

棘托竹荪菌托抑菌物质提取、分离及活性组分北大核心CSCD

以棘托竹荪(Dictyophora echinovolvata)菌托为研究对象,提纯菌托提取物有效抑菌天然产物,分析其抑菌活性组成。选择最佳提取溶剂及指示菌,采用色谱层析法分离纯化,GC-MS检测分析活性组分。结果表明:乙酸乙酯提取物对金黄色葡萄球菌、枯草芽孢杆菌、大肠杆菌、蜡状芽孢杆菌、标准摩根氏菌、肠炎沙门氏菌均有较好的抑制效果;以金色葡萄球菌为指示菌,乙酸乙酯提取物的抑菌作用对温度、紫外线均有较好的稳定性;对提取物进行分离,获得2个有抑菌活性组分DEVⅠ、DEVⅡ,采用GC-MS分析DEVⅠ、DEVⅡ中的化学组分,DEVⅠ中相对含量1%以上的成分有20个;DEVⅡ中相对含量在1%以上成分6个,其中具有抑菌活性的成分为2-呋喃甲酸和肉桂酸,相对含量分别为25.6%和54.2%,推测可能为棘托竹荪菌托抑菌物质的主要组成成分。     

正交实验法优化超临界二氧化碳萃取桑叶总黄酮

探索采用超临界CO_2法萃取桑叶中总黄酮提取的最佳方案。利用超临界二氧化碳萃取技术,依次用正交实验方法考查萃取压强、萃取温度、萃取时间以及夹带剂流速对于桑叶中总黄酮得率的影响,优选提取桑叶黄酮类化合物提取的最佳工艺条件。结果显示,正交实验的最佳萃取条件为:萃取压强为25 MPa,萃取温度为40℃,萃取时间为3 h,夹带剂无水乙醇流速为2.5 mL/min,该条件下,总黄酮得率为6.19%±0.26%,可重复性良好。采用超临界二氧化碳萃取桑叶中黄酮类物质的总黄酮提取率较高,为进一步开发桑叶实验提供了理论和实验依据。     

侧柏树干的超临界CO_2萃取物组分分析及双条杉天牛的EAG反应

利用超临界CO2萃取法和索氏提取法分别提取侧柏Platycladus orientalis(L.)的韧皮部和木质部挥发物,经GC/MS分析其成分,结果表明:超临界CO2萃取物中检测到的21种组分中以倍半萜烯及其氧化物为主,没有检测到单萜类物质;索氏提取法检测到23种组分,韧皮部中检测到的组分以高沸点的树脂酸和二萜等为主,单萜烯和倍半萜及其氧化物含量较低;木质部中以倍半萜烯及其氧化物为主。将不同提取样品进行双条杉天牛Semanotus bifasciatus(Motschulsky)的触角电位反应,结果表明:2种方法的萃取物均能引起天牛的EAG反应,但以超临界萃取物引起的EAG反应较强,且与索氏提取物的反应值差异显著。罗汉柏烯和雪松醇可能是侧柏植物中引诱双条杉天牛的重要活性组分。     

Supercritical carbon dioxide extraction of griseofulvin from the solid matrix obtained after solid-state fermentation

Globally there is an increasing concern to minimize the use of organic solvents, particularly the chlorinated ones because of their suspected human carcinogenicity. The use of ecofriendly carbon dioxide as an alternative to organic solvents would be appropriate in the perspective of green technology. Supercritical carbon dioxide (SC-CO(2)) extraction is suitable for extraction of nonpolar compound with molecular weights less than 400. Griseofulvin is an antifungal antibiotic having a molecular weight of 353, making it amenable to SC-CO(2) extraction. This work brings out the potential of supercritical carbon dioxide extraction (SCFE) for downstream processing of griseofulvin from the solid matrix obtained after solid-state fermentation (SSF). The optimized conditions for SCFE of griseofulvin from dried media after SSF were a flow rate of 0.4 L/min, temperature of 60 degrees C, and contact time of 90 min (30 min static + 60 min dynamic) at a pressure of 450-455 bar.     

Nanostructured microspheres produced by supercritical fluid extraction of emulsions

The system poly(lactic-co-glycolic) acid/ piroxicam (PLGA/PX) was selected, as a model system, to evaluate the effectiveness of supercritical carbon dioxide (SC-CO(2)) extraction of the oily phase (ethyl acetate) from oil-in-water emulsions used in the production of polymer/drug microspheres for sustained drug release applications. The influence of process parameters like operating pressure and temperature, flow rate and contacting time between the emulsion and SC-CO(2) was studied with respect to the microsphere size, distribution and solvent residue. Different polymer concentrations in the oily phase were also tested in emulsions formulation to monitor their effects on droplets and microspheres size distribution at fixed mixing conditions. Spherical PLGA microspheres loaded with PX (10% w/w) with mean sizes ranging between 1 and 3 microm and very narrow size distributions were obtained due to the short supercritical processing time (30 min) that prevents the aggregation phenomena typically occurring during conventional solvent evaporation process. A solvent residue smaller than 40 ppm was also obtained at optimized operating conditions. DSC and SEM-EDX analyses confirmed that the produced microparticles are formed by a solid solution of PLGA and PX and that the drug is entrapped in an amorphous state into the polymeric matrix with an encapsulation efficiency in the range of 90-95%. Drug release rate studies showed very uniform drug concentration profiles, without any burst effect, confirming a good dispersion of the drug into the polymer particles.     

地鳖虫活性物质的超临界CO_2萃取及其药效

应用超临界流体萃取技术萃取地鳖虫Eupolyphaga sinensisWalker活性物质,采用三因素三水平正交试验方案,考察压力、温度、时间等参数对萃取地鳖虫活性物质萃取量的影响。同时,对萃取产物与水提物进行药效比较。结果表明,在试验设计范围内,萃取压力18 MPa、温度55℃、时间90 min为最佳工艺参数组合,地鳖虫活性物质萃取量最大能达到62.50 mg/g,影响萃取量三因素主次关系为压力>温度>时间。地鳖虫超临界萃取产物对镇痛、消炎和抗凝血有较好的效果,相对于水提物有更好的发展潜力。     

Extraction of cashew (Anacardium occidentale) nut shell liquid using supercritical carbon dioxide

This work investigated the extraction of cashew nut shell liquid (CNSL) using supercritical carbon dioxide (SC-CO(2)). Effects of process parameters such as extraction pressure, temperature and flow rate of SC-CO(2) were investigated. The yield of CNSL increased with increase in pressure, temperature and mass flow rate of SC-CO(2). However, under different operating conditions, the composition of CNSL varied. The study of physical properties and chemical composition of the oil obtained through super critical fluid extraction (SCFE) showed better quality as compared to the CNSL obtained through thermal route. Experimental results were compared with diffusion based mass transfer model. Based on this simple model, extraction time was optimized.     

High anti-inflammatory activity of harpagoside-enriched extracts obtained from solvent-modified super- and subcritical carbon dioxide extractions of the roots of Harpagophytum procumbens

Solvent-modified carbon dioxide extractions of the roots of Harpagophytum procumbens have been investigated with respect to extraction efficiency and content of harpagoside, and compared with a conventional extract. The effects of pressure, temperature, type and concentration of the modifier have been examined. Two extraction steps were necessary in order to achievehigh anti-inflammatory harpagoside-enriched extracts. The first extraction step was carried out in the supercritical state using carbon dioxide modified with n-propanol to remove undesired lipophilic substances. The main extraction was performed either in the supercritical or in the subcritical state with carbon dioxide modified with ethanol. The supercritical fluid extraction resulted in extracts containing up to 30% harpagoside. The subcritical extracts showed a harpagoside content of ca. 20%, but the extraction yield was nearly three times greater compared with supercritical conditions. The total harpagoside recovery resulting from the sum of the extract and the crude drug residue was greater than 99% in all experiments. The conventional extract and two carbon dioxide extracts were tested for in-vitro inhibition of 5-lipoxygenase or cyclooxygenase-2 biosynthesis. Both carbon dioxide extracts showed total inhibition on 5-lipoxygenase biosynthesis at a concentration of 51.8 mg/L. In contrast, the conventional extract failed to show any inhibition of 5-lipoxygenase biosynthesis.     

Recovery of phenolic antioxidants from wine industry by-products

The recovery process of the phenolic compounds contained in the wine industry by-products and their antioxidant activity were examined in this work. To this purpose, a combined process of liquid and supercritical solvent extraction was employed. At first the effect of various process parameters of the liquid solvent extraction--the type of solvent and the pretreatment of the raw material (composition (skins, seeds, stems) and crushing)--on the antioxidant activity of the extract was examined. It was shown that an extract of a higher antioxidant activity was obtained by using ethyl acetate as solvent and raw material free of stems. These extracts were further treated with supercritical carbon dioxide (SC CO(2)) at various extraction pressures, which resulted in their significant enrichment in phenolic compounds and the improvement of their antioxidant and organoleptic properties, especially at pressures higher than 100 bar. The antioxidant activity of the products was determined by using the Rancimat method, as well as a simple and not time-consuming free radical method. It was proved that both the ethyl acetate extracts and those treated with SC CO(2) had antioxidant activity comparable to that of antioxidants commonly used in industry, that is butylhydroxytoluene (BHT), a synthetic antioxidant, and Rosemary extract, a widely known natural one.     

An ecofriendly approach to process rice bran for high quality rice bran oil using supercritical carbon dioxide for nutraceutical applications

An integrated approach to extraction and refining of RBO using supercritical carbon dioxide (SC-CO2) in order to preserve the nutritionally important phytochemicals is reported here. Process variables such as pressure, temperature, time, solvent flow rate and packing material on extraction yield and quality of RBO were investigated using a pilot model SC-CO2 extraction system. Three isobaric (350, 425 and 500 bar), three isothermal temperatures (50, 60 and 70 degrees C), three extraction times (0.5, 1 and 1.5h), at 40/min CO2 flow rate and three packing materials (pebbles, glass beads and structured SS rings) were employed. The RBO yield with SC-CO2 extraction increased with temperature and time under isobaric conditions. At the 60 degrees C isotherm, an increase in the RBO yield was obtained with an increase in the pressure and time. The RBO yield increased significantly with structured SS rings used as packing material. The RBO extracted with SC-CO2 had negligible phosphatides, wax and prooxidant metals (Fe and Cu) and was far superior in color quality when compared with RBO extracted with hexane. At the optimum condition of extraction at 500 bar, 60 degrees C for 1.5h, with structured SS rings used as packing material, the yield of RBO was comparable with that of hexane extraction (22.5%). The phytochemical contents of the RBO under the optimum conditions were in the range of tocols, 1500-1800 ppm; sterols, 15,350-19,120 ppm and oryzanol 5800-11,110 ppm.     

Enzymatic dipeptide synthesis by surfactant-coated alpha-chymotrypsin complexes in supercritical carbon dioxide

Enzymatic dipeptide synthesis by surfactant-coated alpha-chymotrypsin complexes was performed in supercritical CO(2) and liquid CO(2) at 308.2 and 333.2 K at pressures of 6.1 and 10.1 MPa. The enzymatic activity of coated alpha-chymotrypsin complexes for dipeptides synthesis at 10.1 MPa in supercritical CO(2) (SC-CO(2)) was higher than that in a liquid CO(2) and ethyl acetate solution at 6.1 MPa. The behavior of alpha-chymotrypsin in SC-CO(2) was similar to that in liquid ethyl acetate. And increasing the pressure and temperature increased the maximum conversion and the enzymatic reaction rate in SC-CO(2). Furthermore, the control of the water content in the reaction media had a dominant effect on the enzymatic activity. The maximum conversion for the dipeptide synthesis by the surfactant-coated alpha-chymotrypsin was obtained at 4% water content. The alpha-chymotrypsin complexes exhibited a higher enzymatic activity than native alpha-chymotrypsin in SC-CO(2). The nonionic surfactants l-glutamic acid dialkyl ester ribitol amide and sorbitan monostearate were more favored than the anionic surfactant sodium bis(2-ethylhexyl)sulfosuccinate.     

超临界CO2流体对纤维素酶催化反应的影响

超临界二氧化碳流体预处理对纤维素超分子结构及纤维素酶催化反应有重要影响。一定含水量的微晶纤维素用SC-CO2在10MPa,50℃处理30min,其结构发生了有利于进一步被酶解的变化。上述超临界条件单独作用于纤维素酶时,并未造成酶催化活力的降低;但与纤维素共同进行SC—CO2处理时,纤维素酶则失去催化活性,但这种处理却能提高纤维素进一步被酶解的效率。一定范围内处理时的酶用量与酶解效率的增加正相关。纤维素的含水量对SC-CO2处理后的酶解效率有显影响。     

茯神挥发性成分及其生物活性研究

为研究茯神挥发性成分含量、构成及其生物活性,本实验采用二氧化碳超临界的方法提取茯神低极性成分,以提取率作为响应值,在单因素试验的基础上采用响应曲面法考察提取压力、温度、二氧化碳流速对提取效果的影响,优化提取工艺。运用气相色谱-质谱联用仪(GC-MS)对其主要化学成分进行鉴定,并采用生长速率法测定了挥发油对5种真菌的生物活性。得到提取模型极值点,即提取压力27.26MPa、提取温度55.97℃、提取流速10.68L/min时,提取率达到最大,提取率预测值为1.66mg/g。通过NIST14质谱库检索,鉴定了其中17个主要化合物,运用峰面积归一法确定各个组分的含量,占挥发油总量的84.5%。抗菌实验表明茯神挥发油对采绒革盖菌菌株有低浓度促进高浓度抑制的活性。