Effect of carbohydrates on the survival of Lactobacillus helveticus during vacuum drying

AIMS: To assess four carbohydrates for the protective effect against Lactobacillus helveticus cells inactivation during vacuum drying, and to study the effect of selected carbohydrate on changes of inactivation kinetics. METHODS AND RESULTS: Early stationary phase L. helveticus cells grown in MRS media were recovered from fermentation broth, washed with PBS buffer (pH 7.0), and then mixed with different concentrations of four carbohydrates, namely lactose, sorbitol, inulin, and xanthan gum. Cells were dried in a vacuum drier at 100 mbar, 43 degrees C for 12 h. Only cells with 1% sorbitol addition showed higher survival (18%) over cells without added carbohydrate (8%). Using in situ microbalance technique whereby cell weight during vacuum drying was continuously monitored via precision balances integrated into the vacuum chamber, drying and inactivation kinetics of cells and cells mixed with sorbitol were established. CONCLUSION: Survival of L. helveticus during the vacuum drying could be improved by the addition of optimal concentration of 1% sorbitol. Addition of sorbitol did not cause drastic changes in drying rate, water content and water activity of samples. The protection mechanisms of sorbitol seemed not to be due to a direct physical effect, which could be related to drying rate. SIGNIFICANCE AND IMPACT OF THE STUDY: The increase in survival of cells after vacuum drying by the addition of a protective carbohydrate may provide an alternative mean to preserve starter cultures at a higher level of activity.     

Comparative survival rates of human-derived probiotic Lactobacillus paracasei and L. salivarius strains during heat treatment and spray drying

Spray drying of skim milk was evaluated as a means of preserving Lactobacillus paracasei NFBC 338 and Lactobacillus salivarius UCC 118, which are human-derived strains with probiotic potential. Our initial experiments revealed that NFBC 338 is considerably more heat resistant in 20% (wt/vol) skim milk than UCC 118 is; the comparable decimal reduction times were 11.1 and 1.1 min, respectively, at 59 degrees C. An air outlet temperature of 80 to 85 degrees C was optimal for spray drying; these conditions resulted in powders with moisture contents of 4.1 to 4.2% and viable counts of 3.2 x 10(9) CFU/g for NFBC 338 and 5.2 x 10(7) CFU/g for UCC 118. Thus, L. paracasei NFBC 338 survived better than L. salivarius UCC 118 during spray drying; similar results were obtained when we used confocal scanning laser microscopy and LIVE/DEAD BacLight viability staining. In addition, confocal scanning laser microscopy revealed that the probiotic lactobacilli were located primarily in the powder particles. Although both spray-dried cultures appeared to be stressed, as shown by increased sensitivity to NaCl, bacteriocin production by UCC 118 was not affected by the process, nor was the activity of the bacteriocin peptide. The level of survival of NFBC 338 remained constant at approximately 1 x 10(9) CFU/g during 2 months of powder storage at 4 degrees C, while a decline in the level of survival of approximately 1 log (from 7.2 x 10(7) to 9.5 x 10(6) CFU/g) was observed for UCC 118 stored under the same conditions. However, survival of both Lactobacillus strains during powder storage was inversely related to the storage temperature. Our data demonstrate that spray drying may be a cost-effective way to produce large quantities of some probiotic cultures.     

冻干乙型脑炎减毒活疫苗的冻干工艺优化研究

为了研究优化冻干乙型脑炎减毒活疫苗的冻干工艺,运用正交试验法L934考察不同冻干参数对该疫苗成品质量的影响,以外观、残余水分、病毒滴度以及热稳定性为直观分析指标,并对病毒滴度进行方差分析。结果显示,主干燥时间和主干燥真空压力对病毒滴度的影响有显著统计学意义(P<0.05)。优化的冻干参数为预冻温度-35℃、时间2h;主干燥温度从-35℃升温至-10℃,再由-10℃升温至33℃,总耗时16h,真空压力0.220mbar;二次干燥的温度维持于30℃,真空压力为0.001mbar,终点测试压力无变化时结束。对冻干乙型脑炎减毒活疫苗冻干参数筛选优化后,可得到较佳的冻干曲线,经验证该曲线适用于生产。     

1H NMR investigation on the role of sorbitol for the survival of Lactobacillus paracasei ssp. paracasei in vacuum‐dried preparations

Aims: The aim of this work was to study the effect of sorbitol as protective agent on the survival of the probiotic strain Lactobacillus paracasei ssp. paracasei (F19) after vacuum drying. Methods and Results: The survival was studied after different drying times and for various concentrations of sorbitol by plate count method. Furthermore, time domain ¹H NMR studies on dehydrated suspensions of Lact. paracasei ssp. paracasei were performed to study the proton mobility in the dried samples. From the obtained signal, T2 relaxation times of single components and fractions with different proton mobility were determined. It was found out that the survival is increased by the presence of a minimum amount of sorbitol that is dependent on drying time. Furthermore, it is shown that the protective effect can only be observed below a critical water content of c. 20%. Nuclear magnetic resonance (NMR) results indicate a transition of sorbitol from liquid to solid like behaviour during drying. The onset of the transition coincides with the critical water content found for a protective effect. Conclusions: The data suggest that sorbitol protons are incorporated into the dried cells of Lact. paracasei ssp. paracasei (F19) below the critical water content and therefore leading to an enhanced survival. Significance and Impact of the Study: The results help to better understand the underlying mechanism of protection of Lact. paracasei ssp. paracasei using sorbitol and to establish vacuum drying as potential alternative drying technique to standard freeze drying.     

Protective effect of betaine on survival of Lactobacillus plantarum subjected to drying

Abstract The aim of this study was to investigate the effect of betaine on survival of Lactobacillus plantarum subjected to drying. A defined medium was devised devoid of betaine. Addition of 2 mM betaine to this medium increased the growth rate of cells grown under osmotic stress and also made the organism more tolerant. Cells cultivated under osmotic stress of 0.6 M sodium chloride and in the presence of betaine showed an increased survival after air drying and subsequent vacuum desiccation to a water activity of 0.12.     

Rapid identification of 11 human intestinal Lactobacillus species by multiplex PCR assays using group- and species-specific primers derived from the 16S-23S rRNA intergenic spacer region and its flanking 23S rRNA

Rapid and reliable two-step multiplex polymerase chain reaction (PCR) assays were established to identify human intestinal lactobacilli; a multiplex PCR was used for grouping of lactobacilli with a mixture of group-specific primers followed by four multiplex PCR assays with four sorts of species-specific primer mixtures for identification at the species level. Primers used were designed from nucleotide sequences of the 16S-23S rRNA intergenic spacer region and its flanking 23S rRNA gene of members of the genus Lactobacillus which are commonly isolated from human stool specimens: Lactobacillus acidophilus, Lactobacillus crispatus, Lactobacillus delbrueckii (ssp. bulgaricus and ssp. lactis), Lactobacillus fermentum, Lactobacillus gasseri, Lactobacillus jensenii, Lactobacillus paracasei (ssp. paracasei and ssp. tolerans), Lactobacillus plantarum, Lactobacillus reuteri, Lactobacillus rhamnosus and Lactobacillus salivarius (ssp. salicinius and ssp. salivarius). The established two-step multiplex PCR assays were applied to the identification of 84 Lactobacillus strains isolated from human stool specimens and the PCR results were consistent with the results from the DNA-DNA hybridization assay. These results suggest that the multiplex PCR system established in this study is a simple, rapid and reliable method for the identification of common Lactobacillus isolates from human stool samples.     

Intraspecific differences in the response to drying of Quercus ithaburensis acorns

In this study, we investigated the germination behavior, and the differences in desiccation sensitivity and water uptake (WU), of the acorns of the two subspecies of Quercus ithaburensis, inhabiting different ecological niches. Sensitivity of acorns to drying was assessed by subjecting them to several desiccation treatments. The results showed that acorn water loss due to desiccation follows an almost linear pattern for the subspecies macrolepis, while in the case of subspecies ithaburensis, it follows a negative exponential model. Accordingly, the germination behavior was found highly dependent on water loss for both subspecies. The low acorn water content (15%) achieved after 15 days of drying was crucial for the ssp. macrolepis, while it had no effect on seed viability in ssp ithaburensis, that needed a subtle further water loss to reduce its germinability (i.e. <14.5% mc). Our results suggest that intraspecific differences in seed responses to drying may be due to different adaptation to survive drought after dispersal and contribute to explain the ability of ssp. ithaburensis to grow in the hottest and driest Mediterranean bioclimates. Despite being recalcitrant, the ssp. ithaburensis can be considered as one of the most tolerant oaks to desiccation worldwide.     

红酵母固态发酵类胡萝卜素产物稳定性的研究

探讨了红酵母固态发酵类胡萝卜素产物的干燥及储存方法;比较了真空干燥和鼓风干燥2种方法对固态发酵产物稳定性的影响;考察了光照、空气、储藏温度对固态发酵产物稳定性的影响。结果表明:在相同温度下,真空干燥(5.67±0.58)h比鼓风干燥所需时间短(9.33±0.58)h、类胡萝卜素损失小,效果也较好;光照和空气对其储藏过程中色素稳定性影响很大,30 d后类胡萝卜素损失了53%;培养物烘干后用透明塑料袋真空避光储藏效果显著,6个月后类胡萝卜素只损失19%,不抽真空损失了46%;温度对培养产物中色素稳定性影响不显著;红酵母菌株固态发酵培养产物应选择真空避光室温储藏。     

Effect of growth parameters on the residual activity of Lactobacillus plantarum after drying

In order to select optimal conditions for the production of dry and active starter cultures it is important to determine the influence of growth conditions on the residual activity of dried bacteria. The influence of medium composition, pH during growth, continuous vs batch reactor and growth phase was studied on the residual activity of Lactobacillus plantarum after drying. The effect of high sodium chloride concentrations during growth on the residual activity of Lact. plantarum after drying was measured. The samples were dried by convection and in a fluidized bed. Bacteria with the highest residual activity after drying were produced in batch or chemostat with pH-controlled growth using enriched or diluted MRS medium. The presence of 1 or 1·25 mol l⁻¹ NaCl during growth resulted in a decreased residual activity after drying. Variations in growth conditions (application of stress) generally did not result in higher residual activities after drying.     

Influence of lyophilization, fluidized bed drying, addition of protectants, and storage on the viability of lactic acid bacteria

Aims:  The present study focuses on the impact of two different drying technologies and the influence of protectants on process survival and storage stability of the two lactic acid bacterial strains Enterococcus faecium and Lactobacillus plantarum .
Methods and Results:  After incubation with the protectants glucose, sucrose, trehalose, and maltodextrin the concentrated bacterial suspensions were subjected to fluidized bed drying and lyophilization and subsequently stored at 4, 22, and 35°C for half a year. Lactobacillus plantarum turned out to be more sensitive to both drying methods than Ent. faecium . Without the addition of a protectant cells of both strains suffered higher losses during fluidized bed drying. Elevated storage temperatures correlate with a higher decline of viable bacterial cells.
Conclusions:  Although survival rates varied between the strains, the nonreducing disaccharides revealed overall best protection for both investigated lactic acid bacteria during processing and storage. The addition of protective carbohydrates can prevent the decline in viability during fluidized bed drying.
Significance and Impact of the Study:  The influence of protectants proved to be species specific and therefore needs to be determined on a case-to-case basis. Survival rates, duration, and energy consumption appear to be the crucial parameters to evaluate the economy of production processes for industrial starter cultures.     

The normal Lactobacillus flora of healthy human rectal and oral mucosa

The Lactobacillus flora of the rectal and oral mucosa was sampled from 42 healthy volunteers. Species identification was carried out by numerically comparing API 50CH fermentation patterns with type strains, using an S_J-similarity cut-off level of 79%. For the largest groups, identity was further confirmed by DNA-DNA hybridizations against the type strain of the species. Seventeen lactobacilli clusters were defined, of which most were found both on rectal and oral mucosa. The largest taxa were Lactobacillus plantarum , Lact. rhamnosus and Lact. paracasei ssp. paracasei , which were isolated from 52%, 26% and 17% of the individuals, respectively. Most isolates were tested for their capacity to adhere to the human colonic cell line HT-29 in the absence and presence of methyl-α- D -mannoside. Mannose-sensitive adherence to HT-29 cells was encountered in two-thirds of the Lact. plantarum isolates, but infrequently among isolates of other taxa. The results suggest that Lact. plantarum is a major colonizer of the human gastrointestinal mucosa, and that its capacity to adhere to mannose-containing receptors may be of some ecological importance.     

Influence of drying methods over in vitro antitumoral effects of exopolysaccharides produced by Agaricus blazei LPB 03 on submerged fermentation

Agaricus blazei is a mushroom that belongs to the Brazilian biodiversity and is considered as an important producer of bioactive compounds beneficial to human health. Studies have demonstrated that these compounds present immuno-modulatory, antioxidant and antitumor properties. In order to compare the most used method for fungal polysaccharide drying, lyophilization with other industrial-scale methods, the aim of this work was to submit A. blazei LPB 03 polysaccharide extracts to vaucum, spray and freeze drying, and evaluate the maintenance of its antitumoral effects in vitro. Exopolysaccharides produced by A. blazei LPB 03 on submerged fermentation were extracted with ethanol and submitted to drying processes. The efficiency represents the water content that was removed during the drying process. The resultant dried products showed water content around 3% and water activity less than 0.380, preventing therefore the growth of microorganisms and reactions of chemical degradation. Exopolysaccharide extracts dried by vacuum and spray dryer did not showed any significant cytotoxic effect on cell viability of Wistar mice macrophages. Content of total sugars and protein decrease after drying, nevertheless, 20 mg/ml of exopolysaccharides dried by spray dryer reached 33% of inhibition rate over Ehrlich tumor cells in vitro.     

Lactobacilli isolated from sugary kefir grains capable of polysaccharide production and minicell formation

Homo- and heterofermentative species of Lactobacillus have been isolated from sugary kefir grains. Most of the homofermentative strains fermented tagatose and aldonitol and presented 48-54% of homology with Lactobacillus paracasei ssp. paracasei NCDO 151 (ex Lactobacillus casei). The two variants of a hetero-fermentative species, although fermenting arabinose, were related to Lactobacillus hilgardii NCDO 264 (type strain) with 88% of homology. One of them produced polysaccharide from sucrose at pH 4.8 and 30 degrees C; the best glucose conversion into polysaccharide was obtained from 3% of sucrose (81.8%), and the maximum production occurred about 35 hours after the end of the log phase of growth, in MRS sucrose broth. Polysaccharide formation did not occur above 40 degrees C, a temperature at which no growth was observed. The two variants were forming minicells by abnormal divisions.     

Lactobacilli isolated from sugary kefir grains capable of polysaccharide production and minicell formation

Homo- and heterofermentative species of Lactobacillus have been isolated from sugary kefir grains. Most of the homofermentative strains fermented tagatose and aldonitol and presented 48–54% of homology with Lactobacillus paracasei ssp. paracasei NCDO 151 (ex Lactobacillus casei ). The two variants of a heterofermentative species, although fermenting arabinose, were related to Lactobacillus hilgardii NCDO 264 (type strain) with 88% of homology. One of them produced polysaccharide from sucrose at pH 4–8 and 30°C; the best glucose conversion into polysaccharide was obtained from 3% of sucrose (81–8%), and the maximum production occurred about 35 hours after the end of the log phase of growth, in MRS sucrose broth. Polysaccharide formation did not occur above 40°C, a temperature at which no growth was observed. The two variants were forming minicells by abnormal divisions.     

芝麻香型白酒发酵过程中乳酸菌多样性及其演替规律

【背景】乳酸菌是白酒发酵过程中一类非常重要的微生物,其种类及动态变化对于白酒品质具有重要影响。然而,目前对于芝麻香型白酒发酵过程中乳酸菌群落结构及其演替规律的认识并不全面。【目的】揭示芝麻香型白酒发酵过程中乳酸菌的多样性及菌群的演替规律,为更好地探索白酒酿造机理和控制白酒品质提供生物学依据。【方法】利用高通量测序技术对芝麻香型白酒发酵过程中乳酸菌菌群演替进行跟踪分析,同时采用实时荧光定量PCR对发酵过程中乳酸菌的生物量进行定量分析。【结果】高通量测序结果显示,芝麻香型白酒发酵过程涉及5个属的乳酸菌:魏斯氏菌属(Weissella)、片球菌属(Pediococcus)、乳杆菌属(Lactobacillus)、明串珠菌属(Leuconostoc)和乳球菌属(Lactococcus),共计43种乳酸菌。其中,在发酵过程中平均相对丰度大于0.5%的乳酸菌有10种,分别是类肠膜魏斯氏菌(Weissella paramesenteroides)、食窦魏斯氏菌(Weissella cibaria)、融合魏斯氏菌(Weissella confusa)、戊糖片球菌(Pediococcus pentosaceus)、假肠膜明串珠菌(Leuconostoc pseudomesenteroides)、发酵乳杆菌(Lactobacillus fermentum)、植物乳杆菌(Lactobacillus plantarum)、副干酪乳杆菌(Lactobacillus paracasei)、耐酸乳杆菌(Lactobacillus acetotolerans)和Lactobacillus sp.。在堆积发酵过程中,Weissella属占细菌总量的50%以上,其次是Pediococcus属和Lactobacillus属,而Leuconostoc属和Lactococcus属相对较少。在窖池发酵过程中Lactobacillus属的乳酸菌逐渐成为优势细菌,尤其是Lactobacillus sp.在窖池发酵中后期相对丰度达到80%以上。实时荧光定量PCR结果显示,在堆积发酵和窖池发酵前期乳酸菌总量变化不大;从窖池发酵5 d开始,乳酸菌总量迅速上升,30 d时达到最大值。【结论】对白酒发酵过程中乳酸菌种类及动态变化的研究有助于探究白酒酿造过程中乳酸菌功能,进而解析白酒酿造机理,最终达到控制白酒品质的目的。     

Antagonistic activity of probiotic lactobacilli and bifidobacteria against entero- and uropathogens

AIM: To develop in vitro assays for comparing the antagonistic properties and anti-oxidative activity of probiotic Lactobacillus and Bifidobacterium strains against various entero- and urinary pathogens. METHODS AND RESULTS: The antagonistic activity of five probiotic lactobacilli (Lactobacillus rhamnosus GG, Lactobacillus fermentum ME-3, Lactobacillus acidophilus La5, Lactobacillus plantarum 299v and Lactobacillus paracasei 8700:2) and two bifidobacteria (Bifidobacterium lactis Bb12, Bifidobacterium longum 46) against six target pathogens was estimated using different assays (solid and liquid media, anaerobic and microaerobic cultivation) and ranked (low, intermediate and high). Bacterial fermentation products were determined by gas chromatography, and the total anti-oxidative activity of probiotics was measured using linolenic acid test. Pyelonephritic Escherichia coli was highly suppressed by GG and both bifidobacteria strains. Lactobacilli strains 8700:2, 299v and ME-3 were the most effective against Salmonella enterica ssp. enterica in microaerobic while ME-3 and both bifidobacteria expressed high activity against Shigella sonnei in anaerobic milieu. Lact. paracasei, Lact. rhamnosus and Lact. plantarum strains showed intermediate antagonistic activity against Helicobacter pylori under microaerobic conditions on solid media. The highest anti-oxidative activity was characteristic for Lact. fermentum ME-3 (P < 0.05). No efficient antagonist against Clostridium difficile was found. The positive correlations between the pH, lactic acid production and anti-microbial activity for all tested probiotics were assessed. CONCLUSIONS: Developed experimental assays enable to compare the anti-microbial and -oxidative activity of Lactobacillus and/or Bifidobacterium probiotics, which have been claimed to possess the ability of suppressing the growth of various enteric and urinary pathogens. SIGNIFICANCE AND IMPACT OF THE STUDY: Screening Lactobacillus and Bifidobacterium sp. strains according to their activity in various environmental conditions could precede the clinical efficacy studies for adjunct treatment with probiotics in cure of different gastrointestinal and urinary tract infections.     

Proceedings: A method for preservation of bacteria and bacteriophages by drying in vacuo

An efficient and practical method was established to preserve bacterial strains and bacteriophages. The method is characterized by drying without freezing and by use of a cotton wool plug (nonabsorbent) to prevent contamination. Drying conditions were examined by measuring temperature, vacuum, and residual moisture of the samples. From the measurement, it was found that the cotton wool plug acts as a buffer and a desiccant. Thus, the specimens reached optimal conditions during storage. Another point of advantage is that the temperature of the specimen during the drying procedure was 2–5 °C; therefore, the evaporation of the water is rapid and the time of completion is shorter than that during lyophilization.     

Effect of culture medium and cryoprotectants on the growth and survival of probiotic lactobacilli during freeze drying

Aims:  To investigate the effects of the medium and cryoprotective agents used on the growth and survival of Lactobacillus plantarum and Lactobacillus rhamnosus GG during freeze drying.
Methods and Results:  A complex medium was developed consisting primarily of glucose, yeast extract and vegetable-derived peptone. Trehalose, sucrose and sorbitol were examined for their ability to protect the cells during freeze drying. Using standardized amount of cells and the optimized freeze drying media, the effect of the growth medium on cell survival during freeze drying was investigated. The results showed that glucose and yeast extract were the most important growth factors, while sucrose offered better protection than trehalose and sorbitol during freeze drying. When the cells were grown under carbon limiting conditions, their survival during freeze drying was significantly decreased.
Conclusions:  A clear relationship was observed between cell growth and the ability of the cells to survive during the freeze drying process.
Significance and Impact of the Study:  The survival of probiotic strains during freeze drying was shown to be dependent on the cryoprotectant used and the growth medium.     

Changes in membrane fatty acids of Lactobacillus helveticus during vacuum drying with sorbitol

Aims:  To examine changes in membrane fatty acid profile attributed to the physiological adaptation of Lactobacillus helveticus during vacuum drying.
Methods and Results:  The viability and membrane integrity of the cells after vacuum drying were measured by plate counts and DNA fluorescence dyes. The physiological adaptation of cells dried in the presence of sorbitol was observed by determining changes in membrane fatty acid composition using gas chromatography. Results showed that viability and membrane integrity of Lact. helveticus cells increased when drying in the presence of sorbitol. The occurrence of the very low melting point polyunsaturated fatty acids linoleic and arachidonic acid was observed in cells dried in the presence of sorbitol.
Conclusions:  The physiological adaptation of cells occurred with cell membrane of Lact. helveticus during vacuum drying of cells in the presence of sorbitol.
Significance and Impact of the Study:  The study showed that physiological adaptation with membrane of the cells occurred during the drying process. The insight implies that instead of viability improvement of dried cells by the conventional stress induction during cultivation, the induction may be exercised thereafter without compromising growth of the cells.     

来自詹氏乳杆菌的耐热D-乳酸脱氢酶的酶学性质研究

【目的】D-乳酸脱氢酶是催化丙酮酸合成D-乳酸的关键酶。由于其不耐热,从而限制了D-乳酸高温发酵菌株的构建。本文从詹氏乳杆菌中克隆新型D-乳酸脱氢酶研究其酶学性质,为构建D-乳酸高温发酵菌株,进一步降低D-乳酸生产成本奠定基础。【方法】通过克隆詹氏乳杆菌的D-乳酸脱氢酶,将其进行体外表达,并与来自植物乳杆菌中的D-乳酸脱氢酶的最适温度、最适pH、动力学参数及热稳定性和热失活性相比较,研究詹氏乳杆菌D-乳酸脱氢酶的耐热性。【结果】詹氏乳杆菌的D-乳酸脱氢酶最适温度(45 °C)比植物乳杆菌中的D-乳酸脱氢酶的最适温度(30 °C)高很多,热失活的时间和温度均要比植物乳杆菌中D-乳酸脱氢酶高很多。同时其催化效率(kcat/Km)是植物乳杆菌D-乳酸脱氢酶的3倍左右。【结论】詹氏乳杆菌的D-乳酸脱氢酶具有更好的耐热性和更高的催化活力。