Characterization of a thermostable D-stereospecific alanine amidase from Brevibacillus borstelensis BCS-1

A gene encoding a new thermostable D-stereospecific alanine amidase from the thermophile Brevibacillus borstelensis BCS-1 was cloned and sequenced. The molecular mass of the purified enzyme was estimated to be 199 kDa after gel filtration chromatography and about 30 kDa on sodium dodecyl sulfate-polyacrylamide gel electrophoresis, indicating that the enzyme could be composed of a hexamer with identical subunits. The purified enzyme exhibited strong amidase activity towards D-amino acid-containing aromatic, aliphatic, and branched amino acid amides yet exhibited no enzyme activity towards L-amino acid amides, D-amino acid-containing peptides, and NH(2)-terminally protected amino acid amides. The optimum temperature and pH for the enzyme activity were 85 degrees C and 9.0, respectively. The enzyme remained stable within a broad pH range from 7.0 to 10.0. The enzyme was inhibited by dithiothreitol, 2-mercaptoethanol, and EDTA yet was strongly activated by Co(2+) and Mn(2+). The k(cat)/K(m) for D-alaninamide was measured as 544.4 +/- 5.5 mM(-1) min(-1) at 50 degrees C with 1 mM Co(2+).     

Purification and characterization of carboxymethyl cellulase from Bacillus sp. isolated from a paddy field

A microorganism hydrolyzing carboxymethyl cellulose was isolated from a paddy field and identified as Bacillus sp. Production of cellulase by this bacterium was found to be optimal at pH 6.5, 37 degrees C and 150 rpm of shaking. This cellulase was purified to homogeneity by the combination of ammonium sulphate precipitation, DEAE cellulose, and sephadex G-75 gel filtration chromatography. The cellulase was purified up to 14.5 fold and had a specific activity of 246 U/mg protein. The enzyme was a monomeric cellulase with a relative molecular mass of 58 kDa, as determined by SDS-PAGE. The enzyme exhibited its optimal activity at 50 degrees C and pH 6.0. The enzyme was stable in the pH range of 5.0 to 7.0 and its stability was maintained for 30 min at 50 degrees C and its activity got inhibited by Hg2+, Cu2+, Zn2+, Mg2+, Na2+, and Ca2+.     

疏绵状嗜热丝孢菌热稳定几丁质酶的纯化及其性质研究

采用硫酸铵沉淀、DEAE SepharoseFastFlow阴离子层析、Phenyl Sepharose疏水层析等步骤获得了凝胶电泳均一的疏绵状嗜热丝孢菌 (Thermomyceslanuginosus)几丁质酶。经SDS PAGE和凝胶过滤层析测得纯酶蛋白的分子量在 4 8～ 4 9 .8kD之间。该酶反应的最适温度和最适pH分别为 5 5℃和 4 5 ,在pH4 5条件下 ,该酶在 5 0℃以下稳定 ;6 5℃的半衰期为 2 5min ;70℃保温 2 0min后 ,仍保留 2 4 %的酶活性。其N 端氨基酸序列为AQGYLSVQYFVNWAI。金属离子对几丁质酶的活性影响较大 ,Ca2 、Na 、K 、Ba2 对酶有激活作用 ;Ag 、Fe2 、Cu2 、Hg2 对酶有显著的抑制作用 ;以胶体几丁质为底物的Km 和Vmax值分别为 9 .5 6mg mL和 2 2 . 12 μmol min。抗菌活性显示 ,该酶对供试病原菌有不同程度的抑制作用。     

Purification and Some Properties of ATP: Nucleotide Pyrophospho-transferase of Streptomyces adephospholyticus

ATP: nucleotide pyrophosphotransferase was purified from culture filtrate of Streptomyces adephospholyticus A–4668 about 13,000 fold by the method including ammonium sulfate fractionation, Amberlite IRC–50 treatment and column chromatography with DEAE-cellulose, DEAE-Sephadex A–25, SP-Sephadex C–25 and Sephadex G–75. The purified enzyme was homogenous on disk gel electrophoresis and ultracentrifugation and the specific activity was 915 units per mg protein, The molecular weight was determined as 28,000 by gel filtration on Sephadex G–75. The enzyme was found to be stable in the pH range of 5.5 to 10.5. More than 80% of the activity was remained after heating at 60°C for 30 min. The enzyme exhibited maximum activity at 50°C.     

Purification and properties of a carboxymethylcellulase from phytopathogenic fungus Macrophomina phaseolina

From the culture filtrate of Macrophomina phaseolina, two forms of carboxymethylcellulase were separated by ion-exchange chromatography and designated as CMCase-I and CMCase-II. CMCase-I was purified following a four-step procedure involving gel filtration on Sephadex G-75, Con-A Sepharose 4B affinity chromatography, fast protein liquid chromatography on mono Q anion-exchanger and on Superose 12 gel filtration. The final preparation was homogeneous by SDS-PAGE, isoelectric focussing in thin layers of polyacrylamide gels and immunoelectrophoresis. The enzyme showed optimum activity at pH 5.5 and 65 degrees C, was stable to heating at 65 degrees C for 10 min, and retained 31% of original activity after heating at 80 degrees C for 10 min. The molecular weight of the enzyme was 3.5 x 10(4) Da. A Km of 0.25 mg/ml was determined using carboxymethyl-cellulose as the substrate.     

Characterization of a cysteine protease from wheat Triticum aestivum (cv. Giza 164)

Enzymes, especially proteases, have become an important and indispensable part of the processes used by the modern food and feed industry to produce a large and diversified range of products for human and animal consumption. A cysteine protease, used extensively in the food industry, was purified from germinated wheat Triticum aestivum (cv. Giza 164) grains through a simple reproducible method consisting of extraction, ion exchange chromatography and gel filtration. The molecular weight of the enzyme was estimated to be 61000+/-1200-62000+/-1500 by SDS-PAGE and gel filtration. The cysteine protease had an isoelectric point and pH optimum at 4.4 and 4.0, respectively. The enzyme exhibited more activity toward azocasein than the other examined substrates with K(m) 2.8+/-0.15 mg azocasein/ml. In addition, it had a temperature optimum of 50 degrees C and based on a heat stability study 55% of its initial activity remained after preincubation of the enzyme at 50 degrees C for 30 min prior to substrate addition. All the examined metal cations inhibited the enzyme except Co(2+), Mg(2+), Mn(2+) and Li(+). The proteolytic activity of the enzyme was inhibited by thiol-specific inhibitors, whereas iodoacetate and p-hydroxymercuribenzoate caused a competitive inhibition with Ki values 6+/-0.3 mM and 21+/-1.2 microM, respectively. Soybean trypsin inhibitor had no effect on the enzyme. The enzyme activity remained almost constant for 150 days of storage at -20 degrees C. The properties of this enzyme, temperature and pH optima, substrate specificity, stability and sensitivity to inhibitors or activators, meet the prerequisites needed for food industries.     

Identification, purification, and characterization of a thermally stable lipase from rice bran. A new member of the (phospho) lipase family.

A thermally stable lipase (EC 3.1.1.3.) was first identified in rice (Oryza sativa) bran, and the enzyme was purified to homogeneity using octyl-Sepharose chromatography. The enzyme was purified to 7.6-fold with the final specific activity of 0.38 micromol min(-1) mg(-1) at 80 degrees C using [9,10-(3)H]triolein as a substrate. The purified enzyme was found to be a glycoprotein of 9.4 kD. Enzyme showed a maximum activity at 80 degrees C and at pH 11.0. The protein was biologically active and retained most of its secondary structure even at 90 degrees C as judged by the enzymatic assays and far-ultraviolet circular dichroism spectroscopy, respectively. Differential scanning calorimetric studies indicated that the transition temperature was 76 degrees C and enthalpy 1.3 x 10(5) Calorie mol(-1) at this temperature. The purified lipase also exhibited phospholipase A(2) activity. Colocalization of both the hydrolytic activities in reverse-phase high-performance liquid chromatography and isoelectric focusing showed that the dual activity was associated with a single protein. Further, a direct interaction between both the substrates and the purified protein was demonstrated by photoaffinity labeling, using chemically synthesized analogs of triolein and phosphatidylcholine (PC). Apparent K(m) for triolein (6.71 mM) was higher than that for PC (1.02 mM). The enzyme preferentially hydrolyzed the sn-2 position of PC, whereas it apparently exhibited no positional specificity toward triacylglycerol. Diisopropyl fluorophosphate inhibited both lipase and phospholipase activities of the purified enzyme. This enzyme is a new member from plants in the family of lipases capable of hydrolyzing phospholipids.     

Characterization of a solvent resistant and thermostable aminopeptidase from the hyperthermophillic bacterium, Aquifex aeolicus

A leucine aminopeptidase gene of Aquifex aeolicus, a hyperthermophilic bacterium, was cloned and expressed in Escherichia coli, and its expression product was purified and characterized. The expressed protein was purified to homogeneity by using heat to denature contaminating proteins followed by ion-exchange chromatography to purify the heat-stable product. The purified enzyme gave a single band on SDS-PAGE with a molecular weight of 54 kDa. Kinetic studies on the purified enzyme confirmed that it was a leucine aminopeptidase. The optimum temperature for its activity was around 80 degrees C and the optimum pH was in the range from 8.0 to 8.5. It was stable at high temperatures and 27% of its activity was retained after heating at 115 degrees C for 30 min. The purified enzyme had a pH stability range between 4.0 and 11.0. This aminopeptidase was highly resistant to organic solvents such as methanol, ethanol, tetrahydrofuran, dimethyl sulfoxide, acetone, acetonitrile, dimethyl formamide, 1-propanol, 2-propanol, and dioxane.     

Cloning, expression, and characterization of a xylanase 10 from Aspergillus terreus (BCC129) in Pichia pastoris

A full-length xylanase gene, encoding 326 amino acids belonging to the fungal glycosyl hydrolase family 10, from Aspergillus terreus BCC129 was cloned and sequenced. Sequence analysis suggested that the first 25 amino acids of this enzyme is the signal peptide. Therefore, only the mature xylanase gene of 906 bp was cloned into a yeast expression vector, pPICZalphaA, for heterologous expression in Pichia pastoris. A band of approximately, 33 kDa was observed on the SDS-PAGE gel after one day of methanol induction. The expressed enzyme was purified by gel filtration chromatography. The purified recombinant xylanase demonstrated optimal activity at 60 degrees C, pH 5.0 and a Km of 4.8 +/- 0.07 mg/ml and a Vmax of 757 +/- 14.54 micromol/min mg, using birchwood xylan as a substrate. Additionally, the purified enzyme demonstrated broad pH stability from 4 to 10 when incubated at 40 degrees C for 4 h. It also showed a moderate thermal stability since it retained 90% of its activity when incubated at 50 degrees C, 30 min, making this enzyme a potential use in the animal feed and paper and pulp industries.     

Purification and characterization of RNA polymerase I from a higher plant.

RNA polymerase I was purified from chromatin isolated from auxin-treated soybean hypocotyl. Purification was achieved by using Agarose A-1.5m gel filtration, DEAE-cellulose, CM-sephadex, and phosphocellulose chromatography, and sucrose density gradient centrifugation. With denatured calf thymus DNA as template, the enzyme has a high specific activity (200-300 nmol/mg/30 min at 28 degrees C) which is comparable to other RNA polymerase I enzymes purified from animals and yeast. While the gel profiles indicate that purification to homogeneity (greater than 90%) may not have been achieved, the enzyme appears to be composed of possibly 7 subunits, several of which are similar to the subunits of yeast RNA polymerase I. The putative subunits and molar ratios are 183 000 (1), 136 000 (1), 50 000 (0.5), 46 000 (0.5), 40 000 (0.5), 33 000 (0.2), and 28 000 (2). The purified enzyme strongly prefers a completely denatured template such as poly(dC).     

Purification and characterization of a new xylanase (APX-II) from the fungus Aureobasidium pullulans Y-2311-1.

Aureobasidium pullulans Y-2311-1 produced four major xylanases (EC 3.2.1.8) with pI values of 4.0, 7.3, 7.9, and 9.4 as revealed by isoelectric focusing and zymogram analysis when grown for 4 days on 1.0% oat spelt xylan. The enzyme with a pI of 9.4 was purified by ammonium sulfate precipitation, chromatography on a DEAE-Sephadex A-50 column, and gel filtration with a Sephadex G-75 column. The enzyme had a mass of about 25 kDa as determined by both sodium dodecyl sulfate-polyacrylamide gel electrophoresis and gel filtration chromatography. The purified enzyme had a Km of 7.6 mg . ml(-1) and Vmax of 2,650 micromol . min(-1) . mg(-1) for birchwood xylan at 28 degrees C and pH 4.5. It lacked activity towards carboxymethylcellulose, cellobiose, starch, mannan, p-nitrophenyl (pNP)-beta-D-xylopyranoside, pNP-beta-D-glucopyranoside, pNP-alpha-D-glucopyranoside, pNP-beta-D-cellobioside, pNP-beta-D-fucopyranoside, or pNP-alpha-D-galactopyranoside. The predominant end products of birchwood xylan or xylohexaose hydrolysis were xylobiose and xylose. The enzyme had the highest activity of pH 4.8 and 54 degrees C. Sixty percent of the activity remained after the enzyme had been incubated at 55 degrees C and pH 4.5 for 30 min. The sequence of the first 68 amino acid residues at the amino terminus showed homology to those of several other xylonases. Immunoblot analysis with antiserum raised against the purified xylanase revealed that two immunologically related polypeptides of 25 and 22 kDa were produced in A. pullulans cultures containing oat spelt xylan or xylose as carbon sources but not in cultures containing glycerol or glucose.     

The purification and characterization of a Bacillus stearothermophilus methionine aminopeptidase (MetAP)

Methionine aminopeptidase (MetAP) catalyzes the removal of an amino-terminal methionine from a newly synthesized polypeptide. The enzyme was purified to homogeneity from Bacillus stearothermophilus (KCTC 1752) by a procedure that involves heat precipitation and four sequential chromatographs (including DEAESepharose ion exchange, hydroxylapatite, Ultrogel AcA 54 gel filtration, and Reactive red 120 dye affinity chromatography). The apparent molecular masses of the enzyme were 81,300 Da and 41,000 Da, as determined by gel filtration chromatography and sodium dodecylsulfate polyacrylamide gel electrophoresis (SDS-PAGE), respectively. This indicates that the enzyme is comprised of two identical subunits. The MetAP specifically hydrolyzed the N-terminal residue of Met-Ala-Ser that was used as a substrate, and exhibited a strong preference for Met-Ala- Ser over Leu-Gly-Gly, Leu-Ser-Phe, and Leu-Leu-Tyr. The enzyme has an optimal pH at 8.0, an optimal temperature at 80 degrees C, and pI at 4.1. The enzyme was heat-stable, as its activity remained unaltered when incubated at 80 degrees C for 45 min. The Km and Vmax values of the enzyme were 3.0 mM and 1.7 mmol/min/mg, respectively. The B. stearothermophilus MetAP was completely inactivated by EDTA and required Co(2+) ion(s) for activation, suggesting the metal dependence of this enzyme     

Purification and characterization of a DNA polymerase from the archaebacterium Thermoplasma acidophilum

A thermophilic DNA polymerase has been purified to near homogeneity from the archaebacterium Thermoplasma acidophilum. Analysis of the purified enzyme by sodium dodecyl sulfate gel electrophoresis revealed a single polypeptide of 88 kDa which co-sediments with the DNA polymerase activity on sucrose gradients. Combination of sedimentation and gel filtration analyses indicates that this DNA polymerase is an 88-kDa monomeric enzyme in its native form. The DNA polymerase is resistant to aphidicolin, slightly sensitive to 2',3'-dideoxyribosylthymine triphosphate and inhibited by N-ethylmaleimide when preincubation with this reagent is performed at 65 degrees C. We find that a 3'----5' exonuclease activity is associated with the purified DNA polymerase; the two activities of the enzyme are optimal at 65 degrees C but the exonuclease activity is active in a broader range of lower temperatures and is more thermostable than the DNA polymerase activity.     

Purification and properties of a novel thermostable galacto-oligosaccharide-producing beta-galactosidase from Sterigmatomyces elviae CBS8119.

A thermostable beta-galactosidase which catalyzed the production of galacto-oligosaccharide from lactose was solubilized from a cell wall preparation of Sterigmatomyces elviae CBS8119. The enzyme was purified to homogeneity by means of chromatography on DEAE-Toyopearl, Butyl-Toyopearl, Chromatofocusing, and p-aminobenzyl 1-thio-beta-D-galactopyranoside agarose columns. The molecular weight of the purified enzyme was estimated to be about 170,000 by gel filtration with a Highload-Superdex 200pg column and 86,000 by sodium dodecyl sulfate-polyacrylamide gel electrophoresis. Its isoelectric point, determined by polyacrylamide gel electrofocusing, was 4.1. The optimal temperature for enzyme activity was 85 degrees C. It was stable at temperatures up to 80 degrees C for 1 h. The optimal pH range for the enzyme was 4.5 to 5.0, it was stable at pH 2.5 to 7.0, and its activity was inhibited by Hg2+. The Km values for o-nitrophenyl-beta-D-galactopyranoside and lactose were 9.5 and 2.4 mM, respectively, and the maximum velocities for these substrates were 96 and 240 mumol/min per mg of protein, respectively. In addition, this enzyme possessed a high level of transgalactosylation activity. Galacto-oligosaccharides, including tri- and tetrasaccharides, were produced with a yield, by weight, of 39% from 200-mg/ml lactose.     

An acidic protease from the grass carp intestine (Ctenopharyngodon idellus)

The acidic Protease was extracted from the intestine of the grass carp (Ctenopharyngodon idellus) by 0.1 M sodium phosphate buffer, pH 7.0 at 4 degrees C after neat intestine was defatted with acetone, and partially purified by ammonium sulfate precipitation, gel filtration chromatography and ionic exchange chromatography. SDS-PAGE electrophoresis showed that the enzyme was homogeneous with a relative molecular mass of 28,500. Substrate-PAGE at pH7.0 showed that the purified acidic protease has only an active component. Specificity and inhibiting assays showed that it should be a cathepsin D. The optimal pH and optimal temperature of the enzyme were pH2.5 and 37 degrees C, respectively. It retained only 20% of its initial activity after incubating at 50 degrees C for 30 min. The enzyme lost 81% of its activity after incubation with pepstatin A at room temperature, but was not inhibited by soybean trypsin inhibitor or phenylmethylsulfonyl fluoride (PMSF). Its V(max) and K(m) values were determined to be 3.57 mg/mL and 0.75 min(-1), respectively.     

Purification and characterization of a thermostable glucoamylase from Chaetomium thermophilum

Thermostable amylolytic enzymes are currently being investigated to improve industrial processes of starch degradation. A thermostable extracellular glucoamylase (exo-1, 4-alpha-D-glucanohydrolase, E.C.3.2.1.3) from the culture supernatant of a thermophilic fungus Chaetomium thermophilum was purified to sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE) homogeneity by using ammonium sulfate fraction, DEAE-Sepharose Fast Flow chromatography, and Phenyl-Sepharose Fast Flow chromatography. SDS-PAGE of the purified enzyme showed a single protein band of molecular weight 64 kDa. The glucoamylase exhibited optimum catalytic activity at pH 4.0 and 65 degrees C. It was thermostable at 50 degrees C and 60 degrees C, and retained 50% activity after 60 min at 65 degrees C. The half-life of the enzyme at 70 degrees C was 20 min. N-terminal amino acid sequencing (15 residues) was AVDSYIERETPIAWN. Different metal ions showed different effects on the glucoamylase activity. Ca2+, Mg2+, Na+, and K+ enhanced the enzyme activity, whereas Fe2+, Ag+, and Hg2+ cause obvious inhibition. These properties make it applicable to other biotechnological purposes.     

嗜热毛壳菌内切β-葡聚糖酶的分离纯化及特性

探讨了液体发酵嗜热毛壳菌（Chaetomium thermophile)产生的内切β－葡聚糖酶的分离纯化及特性。粗酶液经硫酸铵分级沉淀,DEAE－Seplharose Fast Flow阴离子层析,Pheny1-Sepha-rose疏水层析,Sephacry1 S-100分子筛层析等步骤便可获得凝胶电泳均一的内切β－葡聚糖酶,经12．5％SDS－PAGE和凝胶过滤层析法分离纯化酶蛋白的分子量约为67．8kD的69．8kD。该酶反应的最适温度和pH分别为60℃和4．0－4．5在pH5.0条件下,该酶在60℃下稳定：70℃保温1h后,仍保留30％的活性;在80摄氏度的半衰期为25min,金属离子内切β－葡聚糖酶的活性影响较大,其中Na^ 对酶有激活作用;Fe^2 ,Ag^ ,Cu^2 ,Ba^2 ,Zn^2 等对酶有抑制作用。该酶对结晶纤维素有没水解能力。     

Purification and characterization of an extracellular lipase from a thermophilic Rhizopus oryzae strain isolated from palm fruit

We have isolated a lipolytic strain from palm fruit that was identified as a Rhizopus oryzae. Culture conditions were optimized and highest lipase production amounting to 120 U/ml was achieved after 4 days of cultivation. The extracellular lipase was purified 1200-fold by ammonium sulfate precipitation, sulphopropyl-Sepharose chromatography, Sephadex G 75 gel filtration and a second sulphopropyl-Sepharose chromatography. The specific activity of the purified enzyme was 8800 U/mg. The lipolytic enzyme has a molecular mass of 32 kDa by SDS-polyacrylamide gel electrophoresis and gel filtration. The enzyme exhibited a single band in active polyacrylamide gel electrophoresis and its isoelectric point was 7.6. Analysis of Rhizopus oryzae lipase by RP-HPLC confirmed the homogeneity of the enzyme preparation. Determination of the N-terminal sequence over 19 amino acid residues showed a high homology with lipases of the same genus. The optimum pH for enzyme activity was 7.5. Lipase was stable in the pH range from 4.5 to 7.5. The optimum temperature for lipase activity was 35 degrees C and about 65% of its activity was retained after incubation at 45 degrees C for 30 min. The lipolytic enzyme was inhibited by Triton X100, SDS, and metal ions such as Fe(3+), Cu(2+), Hg(2+) and Fe(2+). Lipase activity against triolein was enhanced by sodium cholate or taurocholate. The purified lipase had a preference for the hydrolysis of saturated fatty acid chains (C(8)-C(18)) and a 1, 3-position specificity. It showed a good stability in organic solvents and especially in long chain-fatty alcohol. The enzyme poorly hydrolyzed triacylglycerols containing n-3 polyunsaturated fatty acids, and appeared as a suitable biocatalyst for selective esterification of sardine free fatty acids with hexanol as substrate. About 76% of sardine free fatty acids were esterified after 30 h reaction whereas 90% of docosahexaenoic acid (DHA) was recovered in the unesterified fatty acids.     

Characterization of a thermostable L-arabinose (D-galactose) isomerase from the hyperthermophilic eubacterium Thermotoga maritima

The araA gene encoding L-arabinose isomerase (AI) from the hyperthermophilic bacterium Thermotoga maritima was cloned and overexpressed in Escherichia coli as a fusion protein containing a C-terminal hexahistidine sequence. This gene encodes a 497-amino-acid protein with a calculated molecular weight of 56,658. The recombinant enzyme was purified to homogeneity by heat precipitation followed by Ni(2+) affinity chromatography. The native enzyme was estimated by gel filtration chromatography to be a homotetramer with a molecular mass of 232 kDa. The purified recombinant enzyme had an isoelectric point of 5.7 and exhibited maximal activity at 90 degrees C and pH 7.5 under the assay conditions used. Its apparent K(m) values for L-arabinose and D-galactose were 31 and 60 mM, respectively; the apparent V(max) values (at 90 degrees C) were 41.3 U/mg (L-arabinose) and 8.9 U/mg (D-galactose), and the catalytic efficiencies (k(cat)/K(m)) of the enzyme were 74.8 mM(-1).min(-1) (L-arabinose) and 8.5 mM(-1).min(-1) (D-galactose). Although the T. maritima AI exhibited high levels of amino acid sequence similarity (>70%) to other heat-labile mesophilic AIs, it had greater thermostability and higher catalytic efficiency than its mesophilic counterparts at elevated temperatures. In addition, it was more thermostable in the presence of Mn(2+) and/or Co(2+) than in the absence of these ions. The enzyme carried out the isomerization of D-galactose to D-tagatose with a conversion yield of 56% for 6 h at 80 degrees C.