玉米秸秆酸解副产物对重组酿酒酵母6508-127发酵的影响

将木质纤维素类生物质如玉米秸秆等用稀酸水解预处理,在半纤维素水解为单糖的同时,水解液中还会产生一些可能对后续发酵有影响的副产物。本实验分别考查了在玉米秸秆稀酸水解液中检测出的乙酸、甲酸、香草醛、糠醛和羟甲基糠醛对重组木糖发酵菌株S. cerevisiae 6508-127生长和发酵的影响。结果表明,甲酸和乙酸对菌体生长的抑制强于乙醇生成,且甲酸的抑制程度远大于乙酸;2g/L香草醛可使菌体生长延滞期明显延长,而在较低浓度（≤1.2g/L）此现象不明显。糠醛在0.5-1.5g/L范围内对菌体生长有抑制作用,但使乙醇得率提高;羟甲基糠醛在0.2g/L浓度存在就使乙醇得率有明显降低,但使生物量得率提高;研究中还发现,糠醛、羟甲基糠醛和香草醛可被S. cerevisiae 6508-127代谢。     

发酵抑制物对絮凝酵母戊糖发酵的影响

将絮凝剂加入酵母溶液中,使酵母絮凝成颗粒以此作为固定化酵母进行戊糖发酵。研究了常见发酵抑制物(甲酸、乙酸、糠醛和乳酸等)对絮凝酵母发酵木糖的影响。结果表明:在60.0g/L木糖发酵液中,经过24h发酵,木糖利用率达94.6%,当分别添加抑制物甲酸、乙酸、糠醛、乙醇和乳酸时,聚氧乙烯絮凝酵母分别对其的耐受浓度为0.5、0.5、1.0、30.0和8.0g/L。当抑制物添加量超过各自的耐受浓度后,对絮凝酵母发酵会产生明显的抑制作用。     

木质纤维素酸解副产物对D-乳酸生产菌Sporolactobacillus sp.Y2-8生长及发酵的影响

选择乙酸根、糠醛、5-羟甲基糠醛、苯酚、香草酸和丁香醛等6种典型木质纤维素酸解副产物,考察它们对D-乳酸生产菌Sporolactobacillus sp.Y2-8生长及发酵的影响。实验结果表明:酚类物质抑制作用最强烈,0.25 g/L丁香醛已经完全抑制了菌体的生长和D-乳酸的发酵;苯酚和香草酸在低浓度(≤1.0 g/L)时抑制作用较小,但质量浓度达到3 g/L时对D-乳酸产量的抑制率分别为99%和70%;3 g/L糠醛和5-羟甲基糠醛对产物的抑制率分别为60%与20%,抑制作用小于酚类;乙酸根的影响最小,10 g/L的乙酸钠对菌体的生长和发酵几乎无抑制作用;当抑制物混合时,存在着相互促进作用,抑制作用更强烈。     

Kluyveromyces marxianus发酵己糖和戊糖生产乙醇

对利用底物广泛的乙醇发酵菌株马克斯克鲁维(Kluyveromyces marxianus)DL1菌株与工业用乙醇发酵菌株酿酒酵母(Saccharomyces cerevisiae)6525利用己糖(葡萄糖、甘露糖、半乳糖)和戊糖(木糖、阿拉伯糖)的情况进行对比研究。结果发现:以己糖为底物时,K.marxianus DL1均表现出细胞生长快、乙醇得率高的特点;在不通气、糖20 g/L条件下,K.marxianus DL1的最大乙醇质量浓度均比S.cerevisiae 6525高出10%左右,细胞量及乙醇生产强度分别是S.cerevisiae 6525的近2和1.7倍。当以戊糖为底物时,K.marxianus DL1可以利用木糖和阿拉伯糖;在不通气、糖20g/L条件下,K.marxianus DL1利用木糖产木糖醇和乙醇,乙醇终质量浓度可达7.68 g/L,木糖醇质量浓度为9.12 g/L;以阿拉伯糖为发酵底物时,阿拉伯糖醇的产量可达6 g/L左右;而S.cerevisiae 6525不能利用戊糖。马克斯克鲁维酵母比酿酒酵母更适合纤维乙醇生产。     

休哈塔假丝酵母乙醇发酵性能的研究

木糖的高效发酵是制约纤维素燃料乙醇生产的技术瓶颈之一,高性能发酵菌种的开发是本领域研究的重点。以木糖发酵的典型菌株休哈塔假丝酵母为材料,研究氮源配比、葡萄糖和木糖初始浓度、葡萄糖添加及典型抑制物等因素对其木糖利用和乙醇发酵性能的影响规律。结果表明,硫酸铵更适宜于木糖和葡萄糖发酵产乙醇。在摇瓶振荡发酵条件下,该酵母可发酵164.0 g/L葡萄糖生成61.9 g/L乙醇,糖利用率和乙醇得率分别为99.8%和74.0%;受酵母细胞膜上转运体系的限制,对木糖的最高发酵浓度为120.0 g/L,可生成45.7 g/L乙醇,糖利用率和乙醇得率分别达到94.8%和87.0%。休哈塔假丝酵母发酵木糖的主要产物为乙醇,仅生成微量的木糖醇;添加葡萄糖可促进木糖的利用;休哈塔假丝酵母在葡萄糖发酵时的乙酸和甲酸的耐受浓度分别为8.32和2.55 g/L,木糖发酵时的乙酸和甲酸的耐受浓度分别为6.28和1.15 g/L。     

木质纤维素水解液副产物对东方伊萨酵母乙醇发酵的影响

为了客观评判耐高温东方伊萨酵母HN-1利用木质纤维素水解液生产燃料乙醇的潜力,本文采用单因素试验和响应面中心组合试验研究了木质纤维素水解液有毒副产物甲酸钠(1.0-5.0 g/L)、乙酸钠(2.5-8.0 g/L)、糠醛(0.2-2.0 g/L)、5-羟甲基糠醛(0.1-1.0 g/L)和香草醛(0.5-2.0 g/L)对其乙醇发酵的影响。结果表明,木质纤维素水解液有毒副产物对东方伊萨酵母HN-1乙醇发酵的影响较小,除添加2 g/L香草醛或添加1 g/L 5-羟甲基糠醛可使乙醇产量分别降低20.38%和11.2%外,其他抑制物的添加对乙醇的生成未有显著影响。但是,当副产物浓度较高时,可以显著抑制菌体生长,添加1-5 g/L甲酸钠、2.5-8.0 g/L乙酸钠、0.4-2 g/L糠醛或0.5-2 g/L香草醛,发酵36 h时菌体细胞干重分别较对照下降了25.04%-37.02%、28.83%-43.82%、20.06%-37.60%和26.39%-52.64%。中心组合试验结果表明各抑制物交互作用对乙醇的生成影响不显著。该研究表明木质纤维素水解液副产物对东方伊萨酵母HN-1乙醇发酵的影响较小,适合用于纤维乙醇发酵。     

乙酸、糠醛和5-羟甲基糠醛对产酸克雷伯氏菌发酵生产2,3-丁二醇的影响

为了解产酸克雷伯氏菌对木质纤维素水解液中主要抑制物的耐受和代谢,考察了产酸克雷伯氏菌发酵生产2,3-丁二醇(2,3-butanediol,2,3-BDO)过程中对3种发酵抑制物乙酸、糠醛和5-羟甲基糠醛(5-hydroxymethylfurfural HMF)的耐受以及抑制物浓度的变化,检测了糠醛和HMF的代谢产物.结果表明:产酸克雷伯氏菌对乙酸、糠醛和HMF的耐受浓度分别为30 g/L、4 g/L和5 g/L.并且部分乙酸可作为生产2,3-丁二醇的底物,在0～30 g/L浓度范围内可提高2,3-丁二醇的产量.发酵过程中产酸克雷伯氏菌可将HMF和糠醛全部转化,其中约70％HMF被转化为2,5-呋喃二甲醇,30％HMF和全部糠醛被菌体代谢.研究表明在木质纤维素水解液生产2,3-丁二醇的脱毒过程中可优先考虑脱除糠醛,一定浓度的乙酸可以不用脱除.     

紫外诱变驯化提高酿酒酵母木糖发酵的抑制物耐受性

利用驯化和紫外处理结合驯化的手段对一株木糖发酵工业菌株的抑制物耐受性进行提升。在反复批次培养过程中不断提高含9种抑制物的混合抑制物浓度,使细胞的生长和发酵逐渐适应高浓度抑制物环境,分离突变菌株并进行评价。紫外处理结合驯化比直接驯化能更有效的提升细胞对高浓度抑制物的耐受能力;通过突变菌株分离和筛选,获得3株抑制物耐受能力高于出发菌株的突变菌株,它们在抑制物浓度100%MI(甲酸1 g/L,乙酸3.5 g/L,乙酰丙酸1.5 g/L,糠醛1.5 g/L,5-羟甲基糠醛1.5g/L,丁香醛0.1 g/L,香草醛0.1 g/L,松柏醛0.025 g/L,肉桂酸0.025 g/L)条件下的木糖消耗率比出发菌株高出11.3%-23.2%。紫外诱变处理结合驯化过程可以有效提高酿酒酵母对混合抑制物的耐受性。     

糠醛和5-羟甲基糠醛对大肠杆菌产丁二酸的影响

利用可再生生物质特别是木质纤维素水解液来生产平台化合物丁二酸,是目前研究的热点。虽然许多研究者相继报道了木质纤维素水解液对菌株生长和丁二酸生产存在一定抑制作用,但并没有水解液中各种抑制物对菌株影响的相关动力学研究及机理研究。我们选择了两种代表性木质纤维素水解液抑制物,即糠醛和5-羟甲基糠醛,系统研究了它们对大肠杆菌的生长和丁二酸生产的影响。结果表明：糠醛和5-羟甲基糠醛的初始抑制浓度均为0.8 g/L。当糠醛浓度大于6.4 g/L,5-羟甲基糠醛浓度大于12.8 g/L时,菌株生长完全受到抑制。在最高耐受浓度下,糠醛的存在使菌株生物量比对照菌株下降77.8%,丁二酸产量下降36.1%。5-羟甲基糠醛的存在使菌株生物量比对照菌株降低13.6%,丁二酸产量降低18.3%。糠醛和5-羟甲基糠醛具有明显的协同作用。体外酶活测定表明丁二酸生产途径中关键酶磷酸烯醇式丙酮酸羧化酶、苹果酸脱氢酶、富马酸还原酶均受糠醛和5-羟甲基糠醛抑制。研究结果对丁二酸生产用纤维素水解液的预处理和脱毒工艺开发具有指导作用,有利于实现丁二酸发酵生产的工业化。     

选育耐受复合抑制剂酿酒酵母提高乙醇产量

能够耐受纤维素预处理中抑制剂的酿酒酵母对高效、经济生产纤维素乙醇至关重要。利用诱变结合驯化工程选育了一株可耐受复合抑制剂(1.3g/L糠醛、5.3g/L乙酸及1.0g/L苯酚)的工业酿酒酵母YYJ003。在pH 4.0的含有抑制剂的培养基中,耐受菌株乙醇产率是原始菌株的7.8倍,糠醛转化速率提高了5倍。在pH 5.5的复合抑制剂条件下,YYJ003发酵时间(16h)比野生菌株发酵时间(22h)缩短6h。在pH 4.0的未脱毒的玉米秸秆水热法预处理水解液中YYJ003的乙醇产率达到0.50g/g(乙醇/葡萄糖),乙醇产速达到4.16g/(L·h),而对照菌株无乙醇产出。     

Comparison of glucose/xylose cofermentation of poplar hydrolysates processed by different pretreatment technologies

The inhibitory effects of furfural and acetic acid on the fermentation of xylose and glucose to ethanol in YEPDX medium by a recombinant Saccharomyces cerevisiae strain (LNH‐ST 424A) were investigated. Initial furfural concentrations below 5 g/L caused negligible inhibition to glucose and xylose consumption rates in batch fermentations with high inoculum (4.5–6.0 g/L). At higher initial furfural concentrations (10–15 g/L) the inhibition became significant with xylose consumption rates especially affected. Interactive inhibition between acetic acid and pH were observed and quantified, and the results suggested the importance of conditioning the pH of hydrolysates for optimal fermentation performance. Poplar biomass pretreated by various CAFI processes (dilute acid, AFEX, ARP, SO₂‐catalyzed steam explosion, and controlled‐pH) under respective optimal conditions was enzymatically hydrolyzed, and the mixed sugar streams in the hydrolysates were fermented. The 5‐hydroxymethyl furfural (HMF) and furfural concentrations were low in all hydrolysates and did not pose negative effects on fermentation. Maximum ethanol productivity showed that 0–6.2 g/L initial acetic acid does not substantially affect the ethanol fermentation with proper pH adjustment, confirming the results from rich media fermentations with reagent grade sugars. © 2009 American Institute of Chemical Engineers Biotechnol. Prog., 2009     

Detoxification of corn stover prehydrolyzate by trialkylamine extraction to improve the ethanol production with Pichia stipitis CBS 5776

In order to realize the separated ethanol fermentation of glucose and xylose, prehydrolysis of corn stover with sulfuric acid at moderate temperature was applied, while inhibitors were produced inevitably. A complex extraction was adopted to detoxify the prehydrolyzate before fermentation to ethanol with Pichia stipitis CBS 5776. The best proportion of mixed extractant was 30% trialkylamine-50% n-octanol -20% kerosene. Detoxification results indicated that 73.3% of acetic acid, 45.7% of 5-hydroxymethylfurfural and 100% of furfural could be removed. Compared with the undetoxified prehydrolyzate, the fermentability of the detoxified prehydrolyzate was significantly improved. After 48 h fermentation of the detoxified prehydrolyzate containing 7.80 g/l of glucose and 52.8 g/l of xylose, the sugar utilization ratio was 93.2%; the ethanol concentration reached its peak value of 21.8 g/l, which was corresponding to 82.3% of the theoretical value.     

The effect of sugar decomposed on the ethanol fermentation and decomposition reactions of sugars

A batch reactor was used to investigate the dilute acid hydrolysis reaction of alpha-cellulose and sugar decomposition reactions. Varying the sulfuric acid concentration from 0.07 to 5.0% for reaction temperatures between 180 and 220°C significantly affected glucose yields, which ranged from about 70% to below 10%. Increasing the reaction temperature enhanced this effect. Similar experimental results were obtained for the decomposition of xylose. For sugar decomposition reactions, less than 0.3 g/L of furfural and 5-hydroxymethylfurfural (5-HMF) were produced from glucose and xylose in the absence of sulfuric acid at 190°C and 15 min of reaction time, but adding a small amount of sulfuric acid (0.5%) dramatically increased the decomposition rate and led to the formation of four undesireable products: formic acid, 5-HMF, acetic acid, and furfural. In both hydrolysis and fermentation reactions formic acid, acetic acid, and 5-HMF severely inhibited ethanol fermentation, while furfural had less of an inhibition effect.     

Novel endophytic yeast Rhodotorula mucilaginosa strain PTD3 II: production of xylitol and ethanol in the presence of inhibitors

A systematic study was conducted characterizing the effect of furfural, 5-hydroxymethylfurfural (5-HMF), and acetic acid concentration on the production of xylitol and ethanol by a novel endophytic yeast, Rhodotorula mucilaginosa strain PTD3. The influence of different inhibitor concentrations on the growth and fermentation abilities of PTD3 cultivated in synthetic nutrient media containing 30?g/l xylose or glucose were measured during liquid batch cultures. Concentrations of up to 5?g/l of furfural stimulated production of xylitol to 77?% of theoretical yield (10?% higher compared to the control) by PTD3. Xylitol yields produced by this yeast were not affected in the presence of 5-HMF at concentrations of up to 3?g/l. At higher concentrations of furfural and 5-HMF, xylitol and ethanol yields were negatively affected. The higher the concentration of acetic acid present in a media, the higher the ethanol yield approaching 99?% of theoretical yield (15?% higher compared to the control) was produced by the yeast. At all concentrations of acetic acid tested, xylitol yield was lowered. PTD3 was capable of metabolizing concentrations of 5, 15, and 5?g/l of furfural, 5-HMF, and acetic acid, respectively. This yeast would be a potent candidate for the bioconversion of lignocellulosic sugars to biochemicals given that in the presence of low concentrations of inhibitors, its xylitol and ethanol yields are stimulated, and it is capable of metabolizing pretreatment degradation products.     

Production of ethanol from corn stover hemicellulose hydrolyzate using <Emphasis Type="Italic">Pichia stipitis</Emphasis>

Hemicellulose liquid hydrolyzate from dilute acid pretreated corn stover was fermented to ethanol using Pichia stipitis CBS 6054. The fermentation rate increased with aeration but the pH also increased due to consumption of acetic acid by Pichia stipitis. Hemicellulose hydrolyzate containing 34 g/L xylose, 8 g/L glucose, 8 g/L Acetic acid, 0.73 g/L furfural, and 1 g/L hydroxymethyl furfural was fermented to 15 g/L ethanol in 72 h. The yield in all the hemicellulose hydrolyzates was 0.37–0.44 g ethanol/g (glucose + xylose). Nondetoxified hemicellulose hydrolyzate from dilute acid pretreated corn stover was fermented to ethanol with high yields, and this has the potential to improve the economics of the biomass to ethanol process.     

Repression of xylose-specific enzymes by ethanol in Scheffersomyces (Pichia) stipitis and utility of repitching xylose-grown populations to eliminate diauxic lag

During the fermentation of lignocellulosic hydrolyzates to ethanol by native pentose-fermenting yeasts such as Scheffersomyces (Pichia) stipitis NRRL Y-7124 (CBS 5773) and Pachysolen tannophilus NRRL Y-2460, the switch from glucose to xylose uptake results in a diauxic lag unless process strategies to prevent this are applied. When yeast were grown on glucose and resuspended in mixed sugars, the length of this lag was observed to be a function of the glucose concentration consumed (and consequently, the ethanol concentration accumulated) prior to the switch from glucose to xylose fermentation. At glucose concentrations of 95 g/L, the switch to xylose utilization was severely stalled such that efficient xylose fermentation could not occur. Further investigation focused on the impact of ethanol on cellular xylose transport and the induction and maintenance of xylose reductase and xylitol dehydrogenase activities when large cell populations of S. stipitis NRRL Y-7124 were pre-grown on glucose or xylose and then presented mixtures of glucose and xylose for fermentation. Ethanol concentrations around 50 g/L fully repressed enzyme induction although xylose transport into the cells was observed to be occurring. Increasing degrees of repression were documented between 15 and 45 g/L ethanol. Repitched cell populations grown on xylose resulted in faster fermentation rates, particularly on xylose but also on glucose, and eliminated diauxic lag and stalling during mixed sugar conversion by P. tannophilus or S. stipitis, despite ethanol accumulations in the 60 or 70 g/L range, respectively. The process strategy of priming cells on xylose was key to the successful utilization of high mixed sugar concentrations because specific enzymes for xylose utilization could be induced before ethanol concentration accumulated to an inhibitory level.     

Effect of various factors on ethanol yields from lignocellulosic biomass by Thermoanaerobacterium AK₁₇

The ethanol production capacity from sugars and lignocellulosic biomass hydrolysates (HL) by Thermoanaerobacterium strain AK(17) was studied in batch cultures. The strain converts various carbohydrates to, acetate, ethanol, hydrogen, and carbon dioxide. Ethanol yields on glucose and xylose were 1.5 and 1.1 mol/mol sugars, respectively. Increased initial glucose concentration inhibited glucose degradation and end product formation leveled off at 30 mM concentrations. Ethanol production from 5 g L(-1) of complex biomass HL (grass, hemp, wheat straw, newspaper, and cellulose) (Whatman paper) pretreated with acid (0.50% H(2) SO(4)), base (0.50% NaOH), and without acid/base (control) and the enzymes Celluclast and Novozyme 188 (0.1 mL g(-1) dw; 70 and 25 U g(-1) of Celluclast and Novozyme 188, respectively) was investigated. Highest ethanol yields (43.0 mM) were obtained on cellulose but lowest on hemp leafs (3.6 mM). Chemical pretreatment increased ethanol yields substantially from lignocellulosic biomass but not from cellulose. The influence of various factors (HL, enzyme, and acid/alkaline concentrations) on end-product formation from 5 g L(-1) of grass and cellulose was further studied to optimize ethanol production. Highest ethanol yields (5.5 and 8.6 mM ethanol g(-1) grass and cellulose, respectively) were obtained at very low HL concentrations (2.5 g L(-1)); with 0.25% acid/alkali (v/v) and 0.1 mL g(-1) enzyme concentrations. Inhibitory effects of furfural and hydroxymethylfurfural during glucose fermentation, revealed a total inhibition in end product formation from glucose at 4 and 6 g L(-1), respectively.