Removal of Viruses from Human Intravenous Immune Globulin by 35 nm Nanofiltration

Viral safety is an important prerequisite for clinical immunoglobulin preparations. A common manufacturing practice is to utilize several virus removal/inactivation process steps to ensure the safety of human intravenous immunoglobulin (IVIg). In this regard, we examined the use of Planova 35 nm filters to reduce potential loads of both non-enveloped and enveloped viruses prior to end-stage solvent detergent treatment. The nanofiltration process was validated for removal of a variety of enveloped and non-enveloped viruses ranging in size from 70 nm to 18 nm including: Sindbis virus, Simian Virus 40 (SV40), Bovine Viral Diarrhoea virus (BVDV), Feline Calicivirus, Encephalomyocarditis virus (EMC), Hepatitis A virus (HAV), Bovine Parvovirus (BPV) and Porcine Parvovirus (PPV). The filtration procedure was carried out by first spiking a 7% solution of IVIg with < 10(8) virus. The spiked IVIg solution was then filtered through a 75 nm Planova filter followed by two Planova 35 nm filters in series (75/35/35). The 75 nm prefilter is incorporated into this process to increase the capacity of the 35 nm viral removal filters. As a result of the inclusion of the 75 nm pre-filtration step it was possible to assess the removal of virus by the 35 nm filters independent of possible aggregation of the initial viral spiking material. Samples were collected at each step and immediately titred by viral plaque assay. A process control sample of the spiked load solution was held at the same conditions for the duration of the filtration process and then titred to determine the extent to which antibody neutralization may have contributed to overall viral reduction. Control assays of spiked IVIg were performed to establish the degree of toxicity of the IVIg solution to the indicator cell lines and the extent to which the IVIg interfered with plaque formation in the assay system. This combined data was used to establish assay sensitivity for the calculation of log removal by the filtration process. It was noted that toxicity/interference effects could have a significant effect upon apparent log reductions, and these effects could vary greatly, even within viruses of the same family. The results of these studies indicate that 35 nm filtration is very effective for removing substantial quantities of both non-enveloped and enveloped viruses from IVIg. Complete clearance (to the limits of detection of the assay) was obtained for all viruses larger than 35 nm. Interestingly, viruses reported to have mean diameters of less than 35 nm (EMC and HAV) were at least partially removed by the filtration (4.3 and > 4.7 logs removal, respectively). Even small viruses such as PPV were to some extent removed from the IVIg solution by the filters (2.6 logs removal). Reduction of BPV would not be assessed due to extensive neutralization and interference with plaque formation by the IVIg. Sindbis and SV40 also were subject to neutralization and assay interference due to the IVIg, though to a lesser extent. We conclude from these studies that the 35 nm mean pore size is functionally efficient in removal of smaller size viruses from spiked IVIg concentrates.     

Assessment of viral inactivation during pH 3.3 pepsin digestion and caprylic acid treatment of antivenoms

Antivenoms are manufactured by the fractionation of animal plasma which may possibly be contaminated by infectious agents pathogenic to humans. This study was carried out to determine whether pre-existing antivenom production steps, as carried out by EgyVac in Egypt, may reduce viral risks. Two typical manufacturing steps were studied by performing down-scaled viral inactivation experiments: (a) a pH 3.3 pepsin digestion of diluted plasma at 30 degrees C for 1h, and (b) a caprylic acid treatment of a purified F(ab')2 fragment fraction at 18 degrees C for 1h. Three lipid-enveloped (LE) viruses [bovine viral diarrhoea virus (BVDV), pseudorabies virus (PRV), and vesicular stomatitis virus (VSV)] and one non-lipid-enveloped (NLE) virus [encephalomyocarditis virus (EMC)] were used as models. Kinetics of inactivation was determined by taking samples at 3 time-points during the treatments. The pH 3.3 pepsin digestion resulted in complete clearance of PRV (>7.0 log(10)) and in almost complete reduction of VSV (>4.5 but < or =6.4 log(10)), and in a limited inactivation of BVDV (1.7 log(10)). EMC inactivation was > or =2.5 but < or =5.7 log(10). The caprylic acid treatment resulted in complete inactivation of the 3 LE viruses tested: BVDV (>6.6 log(10)), PRV (>6.6 log(10)), and VSV (>7.0 log(10)). For EMC no significant reduction was obtained (0.7 log(10)). Cumulative reduction was >13.6, >11.5, >8.3 and > or =2.5 for PRV, VSV, BVDV and EMC, respectively. Therefore the current manufacturing processes of at least some animal antisera already include production steps that can ensure robust viral inactivation of LE viruses and moderate inactivation of a NLE virus.     

Improvement of virus safety of an antihemophilc factor IX by virus filtration process

Viral safety is an important prerequisite for clinical preparations of plasma-derived pharmaceuticals. One potential way to increase the safety of therapeutic biological products is the use of a virus-retentive filter. In order to increase the viral safety of human antihemophilic factor IX, particularly in regard to non-enveloped viruses, virus removal process using a polyvinylidene fluoride membrane filter (Viresolve NFP) has been optimized. The most critical factor affecting the filtration efficiency was operating pH and the optimum pH was 6 or 7. Flow rate increased with increasing operating pressure and temperature. Recovery yield in the optimized productionscale process was 96%. No substantial changes were observed in the physical and biochemical characteristics of the filtered factor IX in comparison with those before filtration. A 47-mm disk membrane filter was used to simulate the process performance of the production-scale cartridges and to test if it could remove several experimental model viruses for human pathogenic viruses, including human hepatitis A virus (HAV), porcine parvovirus (PPV), murine encephalomyocarditis virus (EMCV), human immunodeficiency virus type 1 (HIV), bovine viral diarrhea virus (BVDV), and bovine herpes virus (BHV). Nonenveloped viruses (HAV, PPV, and EMCV) as well as enveloped viruses (HIV, BVDV, and BHV) were completely removed during filtration. The log reduction factors achieved were (i)v.12 for HAV, (i)t.28 for PPV, (i)u.33 for EMCV, (i)u.51 for HIV, (i)u.17 for BVDV, and (i)u.75 for BHV. These results indicate that the virus filtration process successfully improved the viral safety of factor IX.     

Evaluation of viral clearance in the production of HPV-16 L1 virus-like particles purified from insect cell cultures

Biopharmaceutical products produced from cell cultures have a potential for viral contamination from cell sources or from adventitious introduction during production. The objective of this study was to assess viral clearance in the production of insect cell-derived recombinant human papillomavirus (HPV)-16 type L1 virus-like particles (VLPs). We selected Japanese encephalitis virus (JEV), bovine viral diarrhea virus (BVDV), and minute virus of mice (MVM) as relevant viruses to achieve the aim of this study. A downstream process for the production of purified HPV-16 L1 VLPs consisted of detergent lysis of harvested cells, sonication, sucrose cushion centrifugation, and cesium chloride (CsCl) equilibrium density centrifugation. The capacity of each purification/treatment step to clear viruses was expressed as reduction factor by measuring the difference in log virus infectivity of sample pools before and after each process. As a result, detergent treatment (0.5% v/v, Nonidet P-40/phosphate-buffered saline) was effective for inactivating enveloped viruses such as JEV and BVDV, but no significant reduction (< 1.0 log(10)) was observed in the non-enveloped MVM. The CsCl equilibrium density centrifugation was fairly effective for separating all three relevant adventitious viruses with different CsCl buoyant density from that of HPV-16 L1 VLPs (JEV, BVDV, and MVM = 4.30, 3.10, > or = 4.40 log(10) reductions). Given the study conditions we used, overall cumulative reduction factors for clearance of JEV, BVDV, and MVM were > or = 10.50, > or = 9.20, and > or = 6.40 log(10) in 150 ml of starting cell cultures, respectively.     

Enveloped virus inactivation by caprylate: a robust alternative to solvent-detergent treatment in plasma derived intermediates.

Solvent-detergent treatment, although used routinely in plasma product processing to inactivate enveloped viruses, substantially reduces product yield from the human plasma resource. To improve yields in plasma product manufacturing, a new viral reduction process has been developed using the fatty acid caprylate. As licensure of plasma products warrants thorough evaluation of pathogen reduction capabilities, the present study examined susceptibility of enveloped viruses to inactivation by caprylate in protein solutions with varied pH and temperature. In the immunoglobin-rich solutions from Cohn Fraction II+III, human immunodeficiency virus, Type-1, bovine viral diarrhea virus (BVDV), and pseudorabies virus were inactivated by caprylate concentrations of >/=9 mM, >/=12 mM, and >/=9 mM, respectively. Compared to solvent-detergent treatment, BVDV inactivation in Fraction II+III solution was significantly faster (20-60 fold) using 16 mM caprylate. Caprylate-mediated inactivation of BVDV was not noticeably affected by temperature within the range chosen manufacturing the immunoglobulin product. In Fraction II+III solutions, IgG solubility was unaffected by 相似文献   

Dry-heat treatment process for enhancing viral safety of an antihemophilic factor VIII concentrate prepared from human plasma

Viral safety is a prerequisite for manufacturing clinical antihemophilic factor VIII concentrates from human plasma. With particular regard to the hepatitis A virus (HAV), a terminal dry-heat treatment (100 degrees for 30 min) process, following lyophilization, was developed to improve the virus safety of a solvent/detergent-treated antihemophilic factor VIII concentrate. The loss of factor VIII activity during dry-heat treatment was of about 5%. No substantial changes were observed in the physical and biochemical characteristics of the dry-heat-treated factor VIII compared with those of the factor VIII before dry-heat treatment. The dry-heat-treated factor VIII was stable for up to 24 months at 4oC. The dry-heat treatment after lyophilization was an effective process for inactivating viruses. The HAV, murine encephalomyocarditis virus (EMCV), and human immunodeficiency virus (HIV) were completely inactivated to below detectable levels within 10 min of the dry-heat treatment. Bovine herpes virus (BHV) and bovine viral diarrhea virus (BVDV) were potentially sensitive to the treatment. However porcine parvovirus (PPV) was slightly resistant to the treatment. The log reduction factors achieved during lyophilization and dry-heat treatment were > or =5.55 for HAV, > or =5.87 for EMCV, > or =5.15 for HIV, 6.13 for BHV, 4.46 for BVDV, and 1.90 for PPV. These results indicate that dry-heat treatment improves the virus safety of factor VIII concentrates, without destroying the activity. Moreover, the treatment represents an effective measure for the inactivation of non-lipid-enveloped viruses, in particular HAV, which is resistant to solvent/detergent treatment.     

Viral clearance during the manufacture of urokinase from human urine

The purpose of the present study was to evaluate the efficacies and mechanisms of the PAB (para-amino benzamidine) affinity column chromatography, virus filtration, pasteurization (60°C heat treatment for 10 h), and lyophilization steps employed in the manufacture of urokinase from human urine with regard to the removal and/or inactivation of human immunodeficiency virus (HIV), bovine viral diarrhoea virus (BVDV), bovine herpes virus (BHV), and murine encephalomyocarditis virus (EMCV). Samples from relevant stages of the production process were spiked with each virus and subjected to scale-down processes mimicking the manufacture of urokinase. Samples were collected at each step, immediately titrated using a 50% tissue culture infectious dose (TCID₅₀), and the virus reduction factors evaluated. PAB chromatography was found to be an effective step for removing BVDV, BHV, and EMCV with log reduction factors of 2.79, 6.50, and 5.96, respectively. HIV, BVDV, BHV, and EMCV were completely removed during the Viresolve NFP filtration step with log reduction factors of ≥6.06, ≥4.60, ≥5.44, and ≥6.87, respectively. Pasteurization was also found to be a robust and effective step in inactivating all the viruses tested, since there were no residual viruses detected after the pasteurization process. The log reduction factors achieved by pasteurization were ≥5.73 for HIV, ≥3.86 for BVDV, ≥6.75 for BHV, and ≥5.92 for EMCV. Lyophilization showed significant efficacy for inactivating BVDV, BHV, and EMCV with log reduction factors of 2.69, 1.37, and 4.70, respectively. These results indicate that the production process for urokinase exhibited a sufficient viral reducing capacity to achieve a high margin of virus safety.     

Inactivation and clearance of viruses during the manufacture of high purity factor IX.

Haemophilia is a bleeding disorder characterised by a deficiency in Factor IX. Replacement therapy in the form of a Factor IX concentrate is a widely accepted practice. In this paper we describe a double virus inactivated chromatographic process for producing a high purity Factor IX product, MonoFIX((R))-VF. The process involves separation of the prothrombin complex by cryoprecipitation, fraction I precipitation and DEAE-cellulose adsorption, further ion-exchange chromatography of crude Factor IX, followed by solvent/detergent treatment. Heparin affinity chromatography is then used to further purify Factor IX. Final nanofiltration is sequential through 35 nm then 15 nm membrane filters. The principal virus inactivation/removal steps are solvent/detergent treatment and nanofiltration and the partitioning of relevant and model viruses provides further reduction in virus load through the production process.Solvent/detergent treatment was shown to achieve log reduction factors of 4.5 for HIV-1, 5.1 for Sindbis virus, 6.1 for vesicular stomatitis virus (VSV), 5.1 for bovine viral diarrhoea virus (BVDV) and 5.3 for pseudorabies virus (PRV). BVDV is a model for hepatitis C virus (HCV), and pseudorabies virus (PRV), like hepatitis B virus (HBV) is an enveloped DNA virus. Using scaled down models of the production process, we have also demonstrated the neutralization/partitioning of at least 6 logs of hepatitis A virus (HAV) during cryoprecipitation, Fraction I precipitation, and the DEAE adsorption and elution step, and a further 1.6 log reduction in HAV load as a result of heparin affinity chromatography. The log reduction factors for HAV as a result of the second ion-exchange chromatography step and as a result of enhanced neutralisation associated with solvent/detergent treatment were not significant. Nanofiltration was shown to contribute a further log reduction factor of 6.7 for HAV and 5.8 for BVDV indicating that log reduction factors of this order would be obtained with other viruses of a similar or larger size, such as HIV, HBV and HCV.Overall, these studies indicate that MonoFIX-VF is a product with an extremely high level of viral safety.     

Partitioning and inactivation of viruses by the caprylic acid precipitation followed by a terminal pasteurization in the manufacturing process of horse immunoglobulins

Caprylic acid (octanoic acid), has been used for over 50 years as a stabilizer of human albumin during pasteurization. In addition caprylic acid is of great interest, by providing the advantage of purifying mammalian immunoglobulins and clearing viruses infectivity in a single step. Exploiting these two properties, we sequentially used the caprylic acid precipitation and the pasteurization to purify horse hyperimmune globulins used in the manufacturing of Sérocytol. To evaluate the effectiveness of the process for the removal/inactivation of viruses, spiking studies were carried out for each dedicated step. Bovine viral diarrhoea virus (BVDV), pseudorabies virus (PRV), encephalomyocarditis virus (EMCV) and minute virus of mice (MVM) were used for the virological validation. Our data show that the treatment with caprylic acid 5% (v/v) can effectively be used as well to purify or to ensure viral safety of immunoglobulins. Caprylic acid precipitation was very efficient in removing and/or inactivating enveloped viruses (PRV, BVDV) and moderately efficient against non-enveloped viruses (MVM, ECMV). However the combination with the pasteurization ensured an efficient protection against both enveloped and non-enveloped viruses. So that viruses surviving to the caprylic acid precipitation will be neutralized by pasteurization. Significant log reduction were achieved > or =9 log(10) for enveloped viruses and 4 log(10) for non-enveloped viruses, providing the evidence of a margin of viral safety achieved by our manufacturing process. Its a simple and non-expensive manufacturing process of immunoglobulins easily validated that we have adapted to a large production scale with a programmable operating system.     

Removal and inactivation of viruses during the manufacture of a high-purity antihemophilic factor IX from human plasma

The purpose of this study was to evaluate the efficacy and mechanisms of the solvent/detergent (S/D) treatment, DEAE-toyopearl 650M anion-exchange column chromatography, heparin-sepharose 6FF affinity column chromatography, and Viresolve NFP filtration steps employed in the manufacture of high-purity antihemophilic factor IX (Green-Nine VF) from human plasma, with regard to removal and/or inactivation of blood-borne viruses. A variety of experimental model viruses for human pathogenic viruses, including human immunodeficiency virus (HIV), bovine herpes virus (BHV), bovine viral diarrhoea virus (BVDV), hepatitis A virus (HAV), murine encephalomyocarditis virus (EMCV), and porcine parvovirus (PPV), were all selected for this study. Samples from relevant stages of the production process were spiked with each virus and subjected to scale-down processes mimicking the manufacture of high-purity factor IX. Samples were collected at each step, immediately titrated using a 50% tissue culture infectious dose (TCID₅₀), and virus reduction factors were evaluated. S/D treatment using the organic solvent, tri (n-butyl) phosphate (TNBP), and the detergent, Tween 80, was a robust and effective step in inactivation of enveloped viruses. Titers of HIV, BHV, and BVDV were reduced from the initial titer of 6.06, 7.72, and 6.92 log₁₀ TCID₅₀, respectively, reaching undetectable levels within 1 min of S/D treatment. DEAE-toyopearl 650M anion-exchange column chromatography was found to be a moderately effective step in the removal of HAV, EMCV, and PPV with log reduction factors of 1.12, 2.67, and 1.38, respectively. Heparin-sepharose 6FF affinity column chromatography was also moderately effective for partitioning BHV, BVDV, HAV, EMCV, and PPV with log reduction factors of 1.55, 1.35, 1.08, 1.19, and 1.61, respectively. The Viresolve NFP filtration step was a robust and effective step in removing all viruses tested, since HIV, BHV, BVDV, HAV, EMCV, and PPV were completely removed during the filtration step with log reduction factors of ≥ 5.51, ≥ 5.76, ≥ 5.18, ≥ 5.34, ≥ 6.13, and ≥ 4.28, respectively. Cumulative log reduction factors of HIV, BHV, BVDV, HAV, EMCV, and PPV were ≥ 10.52, ≥ 12.07, ≥ 10.49, ≥ 7.54, ≥ 9.99, and ≥ 7.24, respectively. These results indicate that the production process for GreenNine VF has a sufficient virus reduction capacity for achievement of a high margin of virus safety.     

Inactivation of caliciviruses

The viruses most commonly associated with food- and waterborne outbreaks of gastroenteritis are the noroviruses. The lack of a culture method for noroviruses warrants the use of cultivable model viruses to gain more insight on their transmission routes and inactivation methods. We studied the inactivation of the reported enteric canine calicivirus no. 48 (CaCV) and the respiratory feline calicivirus F9 (FeCV) and correlated inactivation to reduction in PCR units of FeCV, CaCV, and a norovirus. Inactivation of suspended viruses was temperature and time dependent in the range from 0 to 100 degrees C. UV-B radiation from 0 to 150 mJ/cm(2) caused dose-dependent inactivation, with a 3 D (D = 1 log(10)) reduction in infectivity at 34 mJ/cm(2) for both viruses. Inactivation by 70% ethanol was inefficient, with only 3 D reduction after 30 min. Sodium hypochlorite solutions were only effective at >300 ppm. FeCV showed a higher stability at pH <3 and pH >7 than CaCV. For all treatments, detection of viral RNA underestimated the reduction in viral infectivity. Norovirus was never more sensitive than the animal caliciviruses and profoundly more resistant to low and high pH. Overall, both animal viruses showed similar inactivation profiles when exposed to heat or UV-B radiation or when incubated in ethanol or hypochlorite. The low stability of CaCV at low pH suggests that this is not a typical enteric (calici-) virus. The incomplete inactivation by ethanol and the high hypochlorite concentration needed for sufficient virus inactivation point to a concern for decontamination of fomites and surfaces contaminated with noroviruses and virus-safe water.     

S/D处理结合低pH放孵灭活静注人免疫球蛋白

在低ｐＨ静脉注射用人免疫球蛋白（ＩＶＩＧ）的制备中,采用有机溶剂／表面活性剂处理和低ｐＨ放孵（２３°Ｃ～２５°Ｃ,２１天）进行病毒灭活,以提高ＩＶＩＧ的安全性,两法累积灭活效果为：＞８ｌｏｇＨＩＶ－Ⅰ;＞１１．３ＬｏｇＶＳＶ和＞１０．８ＬｏｇＳｉｎｄｂｉｓ。     

Virus removal capacity at varying ionic strength during nanofiltration of AlphaNine® SD

Nanofiltration is incorporated into the manufacturing processes of many protein biopharmaceuticals to enhance safety by providing the capacity to retain pathogens while allowing protein drugs to pass through the filter. Retention is mainly a function of size; however, the shape of the pathogen may also influence retention. The ability of the Viresolve^® Pro nanofilter to remove different sized viruses during the manufacture of a Coagulation Factor IX (Alphanine^® SD) was studied at varying ionic strength, a process condition with the potential to affect virus shape and, hence, virus retention. Eight viruses were tested in a scale-down of the nanofiltration process. Five of the viruses (EMCV, Reo, BVDV, HIV, PRV) were nanofiltered at normal sodium processing conditions and three (PPV, HAV and WNV) were nanofiltered at higher and lower sodium. Representative Reduction Factors for all viruses were ≥4.50 logs and removal was consistent over a wide range of ionic strength.     

Generic/matrix evaluation of SV40 clearance by anion exchange chromatography in flow-through mode

The potential of viral contamination is a regulatory concern for continuous cell line-derived pharmaceutical proteins. Complementary and redundant safety steps, including an evaluation of the viral clearance capacity of unit operations in the purification process, are performed prior to registration and marketing of biotechnology pharmaceuticals. Because process refinement is frequently beneficial, CBER/FDA has published guidance facilitating process improvement by delineating specific instances where the bracketing and generic approaches are appropriate for virus removal validation. In this study, a generic/matrix study was performed using Q-Sepharose Fast Flow (QSFF) chromatography to determine if bracketing and generic validation can be applied to anion exchange chromatography. Key operational parameters were varied to upper and lower extreme values and the impact on viral clearance was assessed using simian virus 40 (SV40) as the model virus. Operational ranges for key chromatography parameters were identified where an SV40 log(10) reduction value (LRV) of >or=4.7 log(10) is consistently achieved. On the basis of the apparent robustness of SV40 removal by Q-anion exchange chromatography, we propose that the concept of "bracketed generic" validation can be applied to this and potentially other chromatography unit operations.     

Effect of gamma irradiation on human cortical bone transplants contaminated with enveloped and non-enveloped viruses.

In the production of bone grafts intended for transplantation, basic safety measures to avoid the transmission of pathogens are selection and serological screening of donors for markers of virus infections. As an additional safety tool we investigated the effect of gamma irradiation on the sterility of human bone diaphysis transplants and evaluated its impact on the virus safety of transplants. Model viruses were included in the study to determine the dose necessary to achieve a reduction factor for the infectivity titres of at least 4 log(10) at a temperature of -30+/-5 degrees C. The following viruses were used: human immunodeficiency virus type 2 (HIV-2), hepatitis A virus (HAV), and poliovirus (PV-1), and the following model viruses: pseudorabies virus (PRV) as a model for human herpesviruses, bovine viral diarrhoea virus (BVDV) for HCV, and bovine parvovirus (BPV) for parvovirus B19. A first approach was to determine the D(10) values (kGy) for the different viruses (virus inactivation kinetics: BPV 7.3; PV-1 7.1; HIV-2 7.1; HAV 5.3; PRV 5.3; BVDV <3.0 kGy). Based on these results, inactivation of these viruses was studied in experimentally contaminated human bone transplants (femoral diaphyses). For BPV, the most resistant one of the viruses studied, a dose of approximately 34 kGy was necessary to achieve a reduction of infectivity titres of 4 log(10). We therefore recommend a dose of 34 kGy for the sterilisation of frozen bone transplants.     

Comparison of Two Human Papovaviruses with Simian Virus 40 by Structural Protein and Antigenic Analysis

The proteins of simian virus 40 (SV40) and two human papovaviruses, the hemagglutinating BK virus and the non-hemagglutinating DAR virus, were analyzed and compared by sodium dodecyl sulfate polyacrylamide gel electrophoresis. The virions of SV40 and DAR contain seven proteins. By molecular weight analysis the constituent proteins of SV40 and DAR are identical. Approximately 84% of the viral protein has a molceular weight of 45,000. The major protein of BK virus is 3,000 to 5,000 daltons lighter than the major proteins of SV40 and DAR viruses. The five most rapidly migrating proteins of BK virus are indistinguishable by molecular weight analysis from the corresponding proteins of SV40 and DAR viruses. Radial immunodiffusion and immunoelectrophoresis of whole virus gave lines of identity between SV40 and DAR when reacted with SV40 antibody. SV40 antiserum tested against BK virus and BK antiserum tested against SV40 virus showed no reactivity by complement fixation, immunodiffusion, or immunoelectrophoresis.     

Viral safety of C1-inhibitor NF

We studied the efficacy of virus reduction by three process steps (polyethylene glycol 4000 (PEG) precipitation, pasteurization, and 15 nm virus filtration) in the manufacturing of C1-inhibitor NF. The potential prion removing capacity in this process was estimated based on data from the literature. Virus studies were performed using hepatitis A virus (HAV) and human immunodeficiency virus (HIV) as relevant viruses and bovine viral diarrhea virus (BVDV), canine parvovirus (CPV) and pseudorabies virus (PRV) as model viruses, respectively. In the PEG precipitation step, an average reduction in infectious titer of 4.5 log₁₀ was obtained for all five viruses tested. Pasteurization resulted in reduction of infectious virus of >6 log₁₀ for BVDV, HIV, and PRV; for HAV the reduction factor was limited to 2.8 log₁₀ and for CPV it was zero. Virus filtration (15 nm) reduced the infectious titer of all viruses by more than 4.5 log₁₀. The overall virus reducing capacity was >16 log₁₀ for the LE viruses. For the NLE viruses CPV and HAV, the overall virus reducing capacities were >8.7 and >10.5 log₁₀, respectively. Based on literature and theoretical assumptions, the prion reducing capacity of the C1-inhibitor NF process was estimated to be >9 log₁₀.     

Characterizing clearance of helper adenovirus by a clinical rAAV1 manufacturing process.

Recombinant adeno-associated viral vectors (rAAV) are being developed as gene therapy delivery vehicles and as genetic vaccines, and some of the most scaleable manufacturing methods for rAAV use live adenovirus to induce production. One aspect of establishing safety of rAAV products is therefore demonstrating adequate and reliable clearance of this helper virus by the vector purification process. The ICH Q5A regulatory guidance on viral safety provides recommendations for process design and characterization of viral clearance for recombinant proteins, and these principles were adapted to a rAAV serotype 1 purification process for clinical vectors. Specific objectives were to achieve overall adenovirus clearance factors significantly greater than input levels by using orthogonal separation and inactivation methods, and to segregate adenovirus from downstream operations by positioning a robust clearance step early in the process. Analytical tools for process development and characterization addressed problematic in-process samples, and a viral clearance validation study was performed using adenovirus and two non-specific model viruses. Overall clearance factors determined were >23 LRV for adenovirus, 11 LRV for BVDV, and >23 LRV for AMuLV.     

High-fidelity PCR amplification of infectious copies of the complete simian virus 40 genome from plasmids and virus-infected cell lysates

We describe here a long-polymerase chain reaction (PCR) method that can be used to amplify complete simian virus 40 (SV40) DNA with high fidelity, and we show that authentic, viable virus can be produced from molecular clones of the PCR-amplified viral DNAs. A commercial long-PCR kit that employed a combination of Taq and GB-D polymerases was used, together with a pair of overlapping primers that recognized a unique EcoRI site in the SV40 genome. Efficient amplification required linearization of the circular SV40 genomic DNAs with EcoRI. Entire SV40 genomes were successfully PCR-amplified from an SV40 plasmid and from two different SV40-infected cell lysates and were cloned into pUC-19. Three separate segments of the cloned viral genomes were DNA sequenced, and no nucleotide changes relative to the parental virus were detected, suggesting that the viral DNAs had been amplified with high fidelity. Each PCR clone was infectious, and no differences were detected in the growth characteristics of viruses derived from these clones as compared to the original viral strain. The procedure we utilized shortens and simplifies the molecular cloning of small double-stranded DNA viruses and will be useful for viral diagnostic tests and for recovery of virus from clinical samples. The results of these experiments have broad implications, as the methodology is applicable to many systems.     

DNA-damage response pathways triggered by viral replication

Many viruses, with distinct replication strategies, activate DNA-damage response pathways, including the lentivirus human immunodeficiency virus (HIV) and the DNA viruses Epstein-Barr virus (EBV), herpes simplex virus 1, adenovirus and SV40. DNA-damage response pathways involving DNA-dependent protein kinase, ataxia-telengiectasia mutated (ATM) and 'ataxia-telengiectasia and Rad3-related' (ATR) have all been implicated. This review focuses on the effects of HIV and EBV replication on DNA repair pathways. It has been suggested that activation of cellular DNA repair and recombination enzymes is beneficial for viral replication, as illustrated by the ability of suppressors of the ATM and ATR family to inhibit HIV replication. However, activation of DNA-damage response pathways can also promote apoptosis. Viruses can tailor the cellular response by suppressing downstream signalling from DNA-damage sensors, as exemplified by EBV. New small-molecule inhibitors of the DNA-damage response pathways could therefore be of value to treat viral infections.