堆肥中木质素降解微生物对腐殖质形成的作用

堆肥化是处理有机固体废物的主要方法之一。但传统堆肥法存在历时长、肥效低等问题 ,因此加速腐殖化进程可提高堆肥效率和堆肥质量。综述了堆肥中降解木质素的微生物种类的腐殖质的组成 ,介绍了木质素降解与腐殖质形成的关系 ,最后阐述了堆肥中各木质素降解微生物对腐殖质形成的作用。     

Investigation of the microbial community structure and activity as indicators of compost stability and composting process evolution

In a bid to identify suitable microbial indicators of compost stability, the process evolution during windrow composting of poultry manure (PM), green waste (GW) and biowaste was studied. Treatments were monitored with regard to abiotic factors, respiration activity (determined using the SOUR test) and functional microflora. The composting process went through typical changes in temperature, moisture content and microbial properties, despite the inherent feedstock differences. Nitrobacter and pathogen indicators varied as a monotonous function of processing time. Some microbial groups have shown a potential to serve as fingerprints of the different process stages, but still they should be examined in context with respirometric tests and abiotic parameters. Respiration activity reflected well the process stage, verifying the value of respirometric tests to access compost stability. SOUR values below 1 mg O₂/g VS/h were achieved for the PM and the GW compost.     

Activity and composition of ammonia oxidizing bacterial communities and emission dynamics of NH3 and N2O in a compost reactor treating organic household waste

Aims:  To monitor emissions of NH₃ and N₂O during composting and link these to ammonia oxidation rates and the community structure of ammonia oxidizing bacteria (AOB).
Methods and Results:  A laboratory-scale compost reactor treating organic household waste was run for 2 months. NH₃ emissions peaked when pH started to increase. Small amounts of N₂O and CH₄ were also produced. In total, 16% and less than 1% of the initial N was lost as NH₃-N and N₂O-N respectively. The potential ammonia oxidation rate, determined by a chlorate inhibition assay, increased fourfold during the first 9 days and then remained high. Initially, both Nitrosospira and Nitrosomonas populations were detected using DGGE analysis of AOB specific 16S rRNA fragments. Only Nitrosomonas europaea was detected under thermophilic conditions, but Nitrosospira populations re-established during the cooling phase.
Conclusions:  Thermophilic conditions favoured high potential ammonia oxidation rates, suggesting that ammonia oxidation contributed to reduced NH₃ emissions. Small but significant amounts of N₂O were emitted during the thermophilic phase. The significance of different AOBs detected in the compost for ammonia oxidation is not clear.
Significance and Impact of Study:  This study shows that ammonia oxidation occurs at high temperature composting and therefore most likely reduces NH₃ emissions.     

Characterization of dairy cattle manure/wallboard paper compost mixture

The aim of this research was to evaluate the use of manufacturing wallboard paper scraps as an alternative bulking agent for dairy cattle manure composting. The characteristics of the composting process were studied based on the changes in physico-chemical parameters and final compost quality. Composting of dairy cattle manure with wallboard paper was performed in a 481-L cylindrical reactor with vacuum-type aeration. Rapid degradation of organic matter was observed during the thermophilic stage of composting due to high microbial activity. High temperature and alkaline pH conditions promoted intense ammonia emission during the early stage of composting. The number of mesophilic and thermophilic microorganisms were found to be affected by changes in temperature at different composting stages. The total nitrogen (N), phosphorus (P), potassium (K), and sodium (Na) concentrations of the mixture did not change significantly after 28days of composting. However, the presence of gypsum in the paper scraps increased the calcium content of the final compost. The wallboard paper had no phyto-inhibitory effects as shown by high germination index of final compost (GI=99%).     

Co-composting of sewage sludge:fats mixtures and characteristics of the lipases involved

Co-composting of sewage sludge and animal fat mixtures was studied in order to determine the possibility of using this technology to recycle fat-enriched wastes. A maximum fat content of 30% in fat:sludge mixtures is recommended to achieve the international sanitation requirements on compost quality and to avoid an excessive thermophilic composting time. Under these conditions a fat content reduction of 85% was achieved. Biological activity was highly dependent on the moisture content as shown by the respiratory quotient values. Moisture content is a critical control factor because of the hydrophobic nature of fats and should be maintained above 40% in the composting of fats. Biological indices of the compost obtained after 69 days of process (maturity grade: IV; respiration index: 1.1 mg O₂ g OM⁻¹ h⁻¹) indicated a high stability and maturity degree of the material. Lipases responsible for fat hydrolysis were monitored during the composting process and a sample from the thermophilic period was characterized in terms of stability in front of pH and temperature. Optimal conditions for lipase stability were found at 38.3 °C and pH 7.97, however, the maximum lipolytic activity was observed at thermophilic temperatures. Lipases from the thermophilic period were purified by anion exchange chromatography and visualised by SDS-PAGE. Two major bands were observed at molecular weights of 29 and 62 kDa. These bands could not be identified precisely by N-terminal sequence analysis.     

The potential applications of using compost chars for removing the hydrophobic herbicide atrazine from solution

One commercial compost sample was pyrolyzed to produce chars as a sorbent for removing the herbicide atrazine from solution. The sorption behavior of compost-based char was compared with that of an activated carbon derived from corn stillage. When compost was pyrolyzed, the char yield was greater than 45% when heated under air, and 52% when heated under N₂. In contrast, when the corn stillage was pyrolyzed under N₂, the yield was only 22%. The N₂-BET surface area of corn stillage activated carbon was 439 m²/g, which was much greater than the maximum compost char surface area of 72 m²/g. However, the sorption affinity of the compost char for dissolved atrazine was comparable to that of the corn stillage activated carbon. This similarity could have resulted from the initial organic waste being subjected to a relatively long period of thermal processes during composting, and thus, the compost was more thermally stable when compared with the raw materials. In addition, microorganisms transformed the organic wastes into amorphous humic substances, and thus, it was likely that the microporisity was enhanced. Although this micropore structure could not be detected by the N₂-BET method, it was apparent in the atrazine sorption experiment. Overall, the experimental results suggested that the compost sample in current study was a relatively stable material thermally for producing char, and that it has the potential as a feed stock for making high-quality activated carbon.     

Effects of age, supra-ambient oxygen and repeated assays on acetylene reduction and root respiration in pea

An open flow-through gas system was used to investigate the effect of plant age on nitrogenase activity in relation to root respiration (measured as CO₂ release) and supra-ambient O₂ levels in 24- to 51-day-old, nodulated Pisum sativum L. cv. Bodil. The effect of assaying plants repeatedly was also studied. The respiratory efficiency of nitrogenase [mol CO₂ (mol C₂H₄)⁻¹] and the relative decline in nitrogenase (EC 1.7.99.2) activity in response to introduction of C₂H₂ in the gas stream were unaffected by plant age. In contrast, the nitrogenase-linked respiration as a proportion of total root respiration increased with time. Accordingly, the specific respiration linked-to growth and maintenace of the noduled root system decreased with time. C₂H₂ reduction and root respiration were increased by supra-ambient O₂ levels, but the tolerance to high O₂ concentrations seemed to decrease with plant age. Repeated C₂H₂ assays on the same plants decreased their rate of growth and N accumulation: in addition, nitrogenase activity and root respiration were somewhat negatively affected. The results indicate that results from experiments with plants of different ages cannot always be directly compared, and that repeated C₂H₂ assays on the same plants should be applied with caution in physiological work.     

Novel static composting method for bioremediation of olive mill waste

This paper presents results obtained on the evaluation of static composting process aimed at bioremediation of the hazardous solid olive mill waste (OMW). The static composting process carried out in gas-permeable polyethylene bags followed the fluctuating temperature and oxygen profiles similar to those seen in aerated composting systems. Static composting resulted in apparent increases and decreases in values for total nitrogen and C:N ratios respectively during the process. The amount of nitrogen (>3%) in the composting end product was in agreement with the Italian legislation (Decreto Legislativo 29 aprile 2010, n. 75) specification for nitrogen fertilizer. A gradual decrease in polyphenols during the storage of compost resulted in a non-phytotoxic composted organic matter high in humic substances. Different respirometric tests also stated high biological stability of the end compost product.     

蘑菇渣堆肥对华北落叶松移植容器苗生长和营养积累的影响

为缓解草炭大量使用带来的环境问题,在华北落叶松容器育苗过程中添加蘑菇渣堆肥以替代草炭,添加蘑菇渣堆肥体积比例分别为0%(T₀)、15%(T₁)、18.75%(T₂)、25%(T₃)、37.50%(T₄)、50%(T₅)、56.25%(T₆)、60%(T₇),研究不同配比下基质的理化性质以及对华北落叶松1年生移植容器苗生长和营养积累的影响.结果表明: 当蘑菇渣堆肥替代草炭的比例≤50%时,苗木苗高、地径和生物量与常用草炭处理无显著差异,且处理T₂、T₄、T₅苗木体内养分浓度显著高于对照,基质pH值处于微酸性或中性范围,适宜苗木生长;当蘑菇渣添加比例＞50%时,基质pH值偏碱性,苗木生长受到不利影响,苗木质量下降.当蘑菇渣添加比例为15%时,苗木质量最好,苗高、地径和单株生物量达到最大.因此,蘑菇渣替代草炭培育华北落叶松移植容器苗是完全可行的,替代比例最高可达到50%,当添加比例为15%时,可培育出高质量的苗木.     

工厂化堆肥温室气体排放和氨气同位素特征

畜禽废弃物堆肥处理过程中产生的二氧化碳(CO₂)、氧化亚氮(N₂O)、甲烷(CH₄)和氨气(NH₃)等是重要的温室气体和大气污染物。但目前有关该过程气体排放的研究多基于室内小型模拟的反应器式堆肥,在工厂化堆肥条件下的原位气体排放监测较少。为探究工厂化堆肥产生气体对区域环境的影响,本研究对沈阳某堆肥厂畜禽废弃物堆体的气体排放进行了19 d的监测,并量化了排放氨气的自然丰度¹⁵N(δ¹⁵N)特征。结果表明: 堆置周期内,CO₂、CH₄、N₂O和NH₃的平均排放速率分别为86.8 g CO₂-C·d^-1·m^-2、9.8 g CH₄-C·d^-1·m^-2、3.7 mg N₂O-N·d^-1·m^-2和736.6 mg NH₃-N·d^-1·m^-2。温室气体日增温潜势(GWP)的贡献大小为CH₄>CO₂>NH₃(间接)>N₂O,其中CH₄贡献了65％。堆肥排放NH₃的δ¹⁵N在-21.8‰～-7.2‰,平均-11.6‰±1.2‰。本研究结果可为区域畜禽废弃物堆肥过程中温室气体排放的核算及大气氨溯源提供数据支持。     

Assessing the effect of biodegradable and degradable plastics on the composting of green wastes and compost quality

An assessment of the effect of the composting potential of Mater-Bi biodegradable plastic with green wastes, noted by GBIO, and degradable plastic (PDQ-H additive) with green wastes, noted by GDEG, was carried out in a lagged two-compartment compost reactor. The composting time was determined until constant mass of the composting substrates was reached. The green wastes composting process was used as control (G). After one week of composting, the biodegradable plastics disappeared completely, while 2% of the original degradable plastic still remained after about 8 weeks of composting. A net reduction in volatile solids contents of 61.8%, 56.5% and 53.2% were obtained for G, GBIO and GDEG, respectively. Compost quality was assessed in terms of nitrogen, potassium and phosphorus contents, which were found to be highest for GBIO compost. From the phytotoxicity test, it has been observed that a diluted extract of GBIO compost has produced the longest length of radicle. From the respiration test, no significant difference in the amount of carbon dioxide released by the composting of GDEG and G was observed. This study showed that the quality of the compost is not affected by the presence of the biodegradable and degradable plastics in the raw materials.     

Dynamics of pruning waste and spent horse litter co-composting as determined by chemical parameters

Co-composting of pruning waste and horse manure was monitored by different parameters. A windrow composting pile, having the dimensions 2.5m (height) x 30m (length) was established. The maturation of pruning waste and horse manure compost was accompanied by a decline in NH(4)(+)-N concentration, water soluble C and an increase in NO(3)(-)-N content. Organic matter (OM) content during composting followed a first-order kinetic equation. This result was in agreement with the microbiological activity measured by the CO(2) respiration during the process. The correlation at a high level of probability found between the OM loss and CO(2) evolution showed that both parameters could be used to indicate the degree of OM degradation that is the maturity and stability phases of the compost studied. Humification parameters data from the organic matter fractionation did not show a clear tendency during the composting time, suggesting that these parameters are not suitable for evaluating the dynamics of the process.     

Composting of the solid fraction of olive mill wastewater with olive leaves: organic matter degradation and biological activity

The flocculated solid fraction of olive mill wastewaters, obtained from two different olive oil extraction systems (FOMW1 and FOMW2) was composted, with olive leaves (OL) as bulking agent, by the static pile system (Rutgers). The dynamic of organic matter (OM) degradation during composting and its relationship with the basal respiration and fluorescein diacetate (FDA) hydrolytic activity, as indicators of biological activity, were studied. Two mixtures were prepared: C1, from 65% FOMW1 plus 35% OL; and C2, from 74% FOMW2 plus 25% OL and 1% urea. The biooxidative phase of composting in C1, which had a high initial C/N ratio, was long, leading to a high OM degradation, mainly of the lignocellulosic compounds. The water-soluble organic carbon content, C/N ratio and the urea supplied as a N source for the C2 compost make this mixture more adequate for composting, as it had a shorter composting time than C1, and developed a microbial population with a high metabolic activity. The results for basal respiration in C1 and C2 were correlated at a high probability level with those of FDA hydrolysis, and both parameters can be used for establishing the degree of biological stability of the composting material.     

Respiration profiles in monitoring the composting of by-products from the olive oil agro-industry

The composting of olive press cake (OPC) repeatedly mixed either with olive mill wastewater (OPC+OMW) or with tap water (OPC+W) was studied using the thermogradient respirometer, an apparatus that determines the respiration rates from a substrate over a wide range of different temperatures (respiratory profile). The composting processes took place over a period of five months during which nine moistenings of the OPC were performed with the respective liquids. The composting resulted in detoxification of the materials used in both treatments, as indicated by seed germination tests. However, the repeated applications of OMW resulted in recurring thermophilic phases (following each application) and in greater pH and conductivity increases in the final product, as compared to water applications. Respiration measurements performed at 35 degrees C were good indicators of the mean metabolic potential in the compost piles (the mean respiration derived from the whole respiration profile over a wide range of environmental temperatures). However, respiration measurements at higher temperatures (48.5 degrees C) were better indicators of the respiration activity occurring in situ. Following the initial thermophilic phase, the respiration potential of the composts at high temperatures (42-63 degrees C) increased drastically compared to their respiration potential at lower temperatures (17-42 degrees C) indicating the establishment of a thermophilic microflora. Subsequently, only the periodic new substrate-C applications in the form of OMW resulted in increased ratios of low temperature-to-high temperature respiration potential. These ratios decreased again following the respective thermophilic phase that each new OMW application had induced.     

Monitoring respiration and biological stability during sludge composting with a modified dynamic respirometer

A static electrolytic respirometer was adapted to work under dynamic conditions using an internal airflow recirculation system that passed air through sludge/straw solid mixtures. Airflow reduced oxygen transfer limitations and increased the maximum respiration rate and k_La values, indicating that the observed value may have been close to the actual biodegradation rate. Airflow caused sludge drying, so the sample moisture was controlled by air humidification. To apply the optimised respirometric technique, a pilotscale composting process was developed. Some commonly used respiration indices (RI₂₄, AT₄) were used to measure the final compost stability. RI₂₄ indices without airflow were underestimated during the thermophilic composting stage. Once the easily biodegradable carbon was consumed, the static and dynamic RI₂₄ indices were nearly identical. Because of the dynamic procedure, the respiration rate was likely controlled by the biochemical reaction and not by the mass transfer. The respiration indices indicated that the final compost was unstable.     

Chemical properties and hydrolytic enzyme activities for the characterisation of two-phase olive mill wastes composting

Two-phase olive mill waste (TPOMW) is a semisolid sludge generated during the extraction of olive oil by the two-phase centrifugation system. Among all the available disposal options, composting is gaining interest as a sustainable strategy to recycle TPOMW for agricultural purposes. The quality of compost for agronomical use depends on the degree of organic matter stabilization, but despite several studies on the topic, there is not a single method available which alone can give a certain indication of compost stability. In addition, information on the biological and biochemical properties, including the enzymatic activity (EA) of compost, is rare. The aim of this work was to investigate the suitability of some enzymatic activities (beta-glucosidase, arylsulphatase, acid-phosphatase, alkaline-phosphatase, urease and fluorescein diacetate hydrolysis (FDA)) as parameters to evaluate organic matter stability during the composting of TPOMW. These enzymatic indices were also compared to conventional stability indices. For this purpose two composting piles were prepared by mixing TPOMW with sheep manure and grape stalks in different proportions, with forced aeration and occasional turnings. The composting of TPOMW followed the common pattern reported previously for this kind of material with a reduction of 40-50% of organic matter, a gradual increase in pH, disappearance of phytotoxicity and formation of humic-like C. All EA increased during composting except acid-phosphatase. Significant correlations were found between EA and some important conventional stability indices indicating that EA can be a simple and reliable tool to determine the degree of stability of TPOMW composts.     

Enzyme production-based approach for determining the functions of microorganisms within a community

The functions of specific microorganisms in a microbial community were investigated during the composting process. Cerasibacillus quisquiliarum strain BLx(T) and Bacillus thermoamylovorans strain BTa were isolated and characterized in our previous studies based on their dominance in the composting system. Strain BLx(T) degrades gelatin, while strain BTa degrades starch. We hypothesized that these strains play roles in gelatinase and amylase production, respectively. The relationship between changes in the abundance ratios of each strain and those of each enzyme activity during the composting process was examined to address this hypothesis. The increase in gelatinase activity in the compost followed a dramatic increase in the abundance ratio of strain BLx(T). Zymograph analysis demonstrated that the pattern of active gelatinase bands from strain BLx(T) was similar to that from the compost. Gelatinases from both BLx(T) and compost were partially purified and compared. Homologous N-terminal amino acid sequences were found in one of the gelatinases from strain BLx(T) and that of compost. These results indicate strain BLx(T) produces gelatinases during the composting process. Meanwhile, the increase in the abundance ratio of strain BTa was not concurrent with that of amylase activity in the compost. Moreover, the amylase activity pattern of strain BTa on the zymogram was different from that of the compost sample. These results imply that strain BTa may not produce amylases during the composting process. To our knowledge, this is the first report demonstrating that the function of a specific microorganism is directly linked to a function in the community, as determined by culture-independent and enzyme-level approaches.     

Soils contain two different activities for oxidation of hydrogen

Abstract Hydrogen oxidation rates were measured in a neutral compost soil and an acidic sandy loam at H₂ mixing ratios of 0.01 to 5000 ppmv. The kinetics were biphasic showing two different K _m values for H₂, one at about 10–40 nM dissolved H₂, the other at about 1.2–1.4 μM H₂. The low- K _m activity was less sensitive to chloroform fumigation than the high- K _m activity. If sterile soil was amended with Paracoccus denitrificans or a H₂-oxidizing strain isolated from compost soil, it exhibited only a high- K _m (0.7–0.9 μM) activity. It also failed to utilize H₂ mixing ratios below a threshold of 1.6–3.0 ppmv H₂ (160–300 mPa). A similar result was obtained when fresh soil samples were suspended in water, and H₂ oxidation was determined from the decrease of dissolved H₂. However, H₂ was again utilized to mixing ratios lower than 0.05 ppmv, if the supernatant of the soil suspension or the settled soil particles were dried onto sterile soil or purified quarz sand. Obviously, soils contain two different activities for oxidation of H₂: (1) a high- K _m, high-threshold activity which apparently is due to aerobic H₂-oxidizing bacteria, and (2) a low- K _m, low-threshold activity whose origin is unknown but presumably is due to soil enzymes.     

有机固体废弃物堆肥的物质变化及腐熟度评价

堆肥是资源化处理有机固体废弃物的有效途径之一．有机固体废弃物的种类繁多,物科的性质差异很大,另外,由于堆肥条件的不同,也会引起堆肥的物质变化有很大差异．堆肥的稳定度和腐熟度是衡量堆肥产品质量的尺度,其评价对于安全农用有着重要意义．稳定度则重于堆肥施用对周围环境的影响,而腐熟度则重于堆肥施用对植物生长的影响,它们受堆肥物料,堆肥条件等诸多因素的综合影响,其评价指标因而多种多样．堆肥稳定度主要从堆肥的温度、颜色、CO2是最为简便的稳定度评价指标,当其趋于环境温度时,表明堆肥达到稳定．堆肥腐熟度的评价指标很多,包括化学指标、生物活性指标以及植物毒性指标3类,其中种子发芽系数作为植物毒性指标被认为是最可靠的评价指标之一。     

Chemical and biological changes during composting of different organic wastes and assessment of compost maturity

Changes in organic C, total N, C:N ratio, activities of cellulase, xylanase and protease, and microbial population were determined during composting of different organic wastes such as mixture of sugarcane trash and cattle dung, press mud, poultry waste and water hyacinth biomass. There were losses of N in poultry waste and water hyacinth with the effect an initial increase in C:N ratio was observed which decreased later on due to decomposition. The activities of cellulase, xylanase and protease were maximum between 30 and 60 days of composting in various wastes. Similar trend was observed with respect to mesophilic bacterial and fungal population. Various quality parameters like C:N ratio, water soluble C (WSC), CO(2) evolution and level of humic substances were compared after 90 day composting. There was statistically significant correlation between C:N ratio and CO(2) evolution, WSC and humic substances. Significant correlation between CO(2) evolved and level of humic substances was also observed. The study shows that no single parameter can be taken as an index of compost maturity. However, C:N ratio and CO(2) evolved from finished compost can be taken as the most reliable indices of compost maturity.