1, 3-丙二醇发酵过程中盐浓度的胁迫作用

通过对克雷伯氏菌(Klebsiella pneumoniae)甘油发酵生产1, 3-丙二醇(1, 3-PD)过程的研究发现, 盐浓度对 1, 3-PD发酵有胁迫作用。盐浓度较低时, 菌体生长和产物生成均维持较高速率; 盐浓度较高时会导致菌体生长减慢, 1, 3-PD最终浓度, 甘油到1, 3-丙二醇的转化率降低, 同时1, 3-丙二醇氧化还原酶受到抑制。在5 m3罐中控制合适的盐浓度可以提高1, 3-PD的发酵水平, 使1, 3-PD的最终浓度达到64 g/L, 转化率61%, 生产强度2.1 g/(L·h)。     

利用克雷伯肺炎杆菌限制性底物发酵生产1，3-丙二醇

研究了克雷伯肺炎杆菌（Klebsiella pneumoniae）批式流加发酵生产1,3-丙二醇的发酵工艺,根据1,3-丙二醇的生产和菌体生长相关的特点,采用营养基质限制性流加的发酵工艺,通过控制氮源氯化铵以保持细胞稳定生长。结果表明：过低的氮源浓度,细胞生长受到限制,影响产物1,3-PD的合成;过高的氮源浓度,细胞比生长速率增加,但1,3-PD关于消耗甘油的得率降低,用于生长和维持代谢所消耗的甘油量增加。以0.41 g/(L·h)的氮源流加速率,残余氯化铵浓度在0.1 g/L时,转化率和生产强度最高。发酵25 h～28 h后,1,3-丙二醇最终浓度达到52.03 g/L,生产强度为2.04 g/(L·h),相对于甘油的摩尔转化率为0.66,分别比氮源限制前提高了28.0 ％、35.1 ％及29.4 ％。通过限制性流加氯化铵,控制细胞的比生长速率,使底物甘油有效转变为发酵的目标产物1,3-PD,有效实现产物1,3-PD的高生产强度以及对甘油的高转化率。     

克雷伯氏菌产1,3-丙二醇ldhA基因缺失菌株的构建

克雷伯氏菌(Klebsiella pneumonia)甘油歧化发酵生产1,3-丙二醇(1,3-PD)的过程中,乳酸是氧化途径最主要的副产物,乳酸的产生和积累,不仅限制了菌体本身的生长,而且严重影响了1,3-丙二醇的转化率。利用λRed重组技术对Klebsiella pneumonia中的酶乳酸脱氢酶基因(ldhA)进行改造。在λRed重组系统作用下,将带有300 bp的线性同源片段ldhA1-Cm-ldh A2与基因组DNA的同源重组,经过抗性筛选和PCR鉴定最终获得了ldhA基因缺失菌株K.pneumonia2-1ΔldhA。经过24 h发酵可知,乳酸最大产出浓度由原来的10.16 g/L降为0.49 g/L,1,3-PD由原来的78.83 g/L增长为85.76 g/L,甘油转化率由60.64%增长到65.97%,提高了5.33%。     

补料分批发酵过程中两阶段发酵生产1,3-丙二醇

在补料分批发酵过程中提高比生长速率不仅减少乙醇、甲酸的生成,而且提高1,3-丙二醇的得率和比生产速率.发酵后期甘油的浓度在15～26 g/L时有利于提高1,3-丙二醇的生产.采取在发酵前期控制菌体较高比生长速率和发酵后期控制适宜甘油浓度相结合的策略,有效地提高了1,3-丙二醇的生产,降低副产物乳酸和乙醇的生成.     

一株1,3-丙二醇生产菌的分离鉴定及其发酵特性

从活性污泥中分离筛选得到一株能代谢甘油生产1,3-丙二醇(1,3-PD)的菌株2-1,通过形态学鉴定、生理生化试验、16S rRNA序列分析对菌株分类学地位进行鉴定,用MEGA 4.1软件构建的系统发育树显示菌株2-1与Klebsiella pneumoniae(CP001891)的亲缘关系最近。16S rDNA序列同源性比较发现,菌株2-1与模式菌株同源率为95.4%,疑似为新种。对菌株2-1在5 L发酵罐中进行发酵特性研究,分批补料发酵时得到较高的1,3-PD终浓度,达到63.5 g/L,此时生产强度为2.19 g/(L.h),底物转化率0.64 mol/mol。     

利用甘油发酵耦联生产3-羟基丙酸及1,3-丙二醇重组菌的构建及筛选

在肺炎克雷伯杆菌(Klebsiella pneumoniae)代谢甘油生产1,3-丙二醇(1,3-PD)的过程中,为了减少有毒中间产物3-羟基丙醛(3-HPA)的积累,可将其转化为3-羟基丙酸(3-HP),从而实现1,3-丙二醇和3-羟基丙酸的联产。克隆来自于酿酒酵母的NAD+依赖型的乙醛脱氢酶(ALDH)的基因aldh4,构建了表达载体pKP-aldh,转化K.pneumoniae,得到了有效表达乙醛脱氢酶的重组肺炎克雷伯杆菌(K.pneumoniae A+)。在此基础上,使用紫外诱变联合菌种驯化的方法对K.pneumoniae A+进行筛选,获得了可耐受较高3-HP浓度(≥35 g/L)的重组肺炎克雷伯杆菌K.pneumoniae A+5-3。发酵实验结果表明,K.pneumoniae A+5-3可将3-HPA转化为3-HP,能够同时利用甘油耦联生产3-HP和1,3-PD,产量分别达到5.0 g/L和74.5 g/L。     

混合菌发酵1,3-丙二醇的初步研究

将表达酿酒酵母3-磷酸甘油脱氢酶基因(GPD1)和3-磷酸甘油酯酶基因(HOR2)的质粒PSE-gpd1-hor2转化到甘油激酶基因(glpK)和甘油脱氢酶基因(gldA)双缺失的大肠杆菌JM109C中,构建产甘油的工程菌JM109C/PSE-gpd1-hor2.接种JM109C/pSE-gpd1-hor2和Klebsiella在含1%葡萄糖的摇瓶发酵培养基中37℃发酵56 h,1,3-丙二醇的最高产量为1.28 g/L,葡萄糖摩尔转化率为37.5%;在30 L发酵罐中发酵68 h,1,3-丙二醇的最高产量为24.09 g/L,葡萄糖摩尔转化率为38.0%;5 g/L的乙酸、乳酸,10 g/L的乙醇分别使1,3-丙二醇的产量降低了91.41%、54.68%和51.56%.     

克雷伯氏肺炎杆菌LDH526产1,3-丙二醇的甘油自动流加策略

1,3-丙二醇是一种重要的化工原料,主要作为平台化合物用于合成聚酯,如聚对苯二甲酸丙二醇酯。经基因工程改造的克雷伯氏肺炎杆菌LDH526能以甘油作为唯一碳源合成1,3-丙二醇,最终发酵浓度超过90 g/L。甘油浓度是影响1,3-丙二醇合成的关键因素。为了实现对甘油浓度的精确控制,设计并优化了基于发酵动力学的甘油自动流加策略。通过将底物流加速率与易观察变量p H和发酵时间偶联,实现了发酵过程中甘油流加的自启动和甘油浓度的动态控制。发酵72 h,1,3-丙二醇的浓度可稳定超过95 g/L。自动控制甘油流加的发酵过程具有可重复性、连续性以及人工工作量少的特点,有望从实验室规模扩大到生产规模。     

丙酮酸对肺炎克雷伯氏菌微氧发酵甘油产1,3-丙二醇的影响

微氧条件下,考察肺炎克雷伯氏菌发酵生产1,3-丙二醇过程中柠檬酸和丙酮酸对发酵过程的影响。摇瓶实验结果表明:添加柠檬酸能抑制菌体生长和1,3-丙二醇合成;丙酮酸对菌体生长和1,3-丙二醇合成有一定的促进作用。5 L发酵罐批式发酵表明:补料培养基中加入8 g/L丙酮酸,1,3-丙二醇的产量提高了约10.8%,转化率提高了约4.4%,比生长速率提高了约10.8%。上述结果初步表明,强化能量的产生能够有效促进1,3-丙二醇的合成,可以利用分子生物学手段强化丙酮酸的产生以促进1,3-丙二醇的合成。     

一步法产1,3-丙二醇酿酒酵母基因工程菌的构建

1,3-丙二醇(1,3-PD)是一种重要的化工原料,发酵法生产1,3-PD是一条新颖且具有潜在竞争力的生产途径。本研究在前期工作的基础上,将分别来源于大肠杆菌和肺炎克雷伯氏菌的基因片段yqhD和dhaB串联表达,构建重组表达载体pYX212-zeocin-pGAP-yqhD-pGAP-dhaB;并得到重组酿酒酵母(Saccharomyces cerevisiae)W303-1A/pYX212-zeocin-pGAP-yqhD-pGAP-dhaB。该重组菌和对照S.cerevisiae分别以葡萄糖为底物摇瓶发酵72h后,重组酿酒酵母发酵液中1,3-PD含量约为1.5g/L;而对照菌株不产1,3-PD。以上结果表明本研究在国内首次成功构建了直接以葡萄糖为底物发酵生产1,3-PD的酿酒酵母基因工程菌。为进一步将dhaB、yqhD基因导入其他以葡萄糖为底物高产甘油的酵母宿主中表达,获得以葡萄糖为底物一步法发酵高产1,3-丙二醇工程菌打下了坚实的基础。     

Improved 1,3-propanediol production with hemicellulosic hydrolysates (corn straw) as cosubstrate: Impact of degradation products on Klebsiella pneumoniae growth and 1,3-propanediol fermentation

To improve 1,3-propanediol (1,3-PD) production by an economic and efficient approach, hemicellulosic hydrolysates (HH) used as cosubstrate resulted in more biomass and higher reducing power for 1,3-PD production. The effects of primary degradation products such as individual sugars (xylose, glucose, mannose, arabinose and galactose) and major inhibitors (furfural, acetate and formate) on the Klebsiella pneumoiae growth and 1,3-PD production were investigated in this study. Xylose and mannose could efficiently promote the 1,3-PD production and cell growth. Furfural (0.28 g/l) and sodium acetate (1.46 g/l) in low concentration were not inhibitory to Klebsiella pneumoniae, rather they have stimulatory effect on the growth and 1,3-PD biosynthesis, especially the acetate. In fed-batch fermentation with HH as cosubstrate, the final 1,3-PD production, conversion from glycerol and productivity were 71.58 g/l, 0.65 mol/mol and 1.93 g/l/h, respectively, which were 17.8%, 25.0% and 17.7% higher than that from glycerol alone.     

High production of 1,3-propanediol from industrial glycerol by a newly isolated Clostridium butyricum strain

Batch and continuous cultures of a newly isolated Clostridium butyricum strain were carried out on industrial glycerol, the major by-product of the bio-diesel production process. For both types of cultures, the conversion yield obtained was around 0.55 g of 1,3-propanediol formed per 1 g of glycerol consumed whereas the highest 1,3-propanediol concentration, achieved during the single-stage continuous cultures was 35-48 g l-1. Moreover, the strain presented a strong tolerance at the inhibitory effect of the 1,3-propanediol, even at high concentrations of this substance at the chemostat (e.g. 80 g l-1). 1,3-Propanediol was associated with cell growth whereas acetate and butyrate seemed non growth-associated products. At low and medium dilution rates (until 0.1 h-1), butyrate production was favoured, whereas at higher rates acetate production increased. The maximum 1,3-propanediol volumetric productivity obtained was 5.5 g l-1 h-1. A two-stage continuous fermentation was also carried out. The first stage presented high 1,3-propanediol volumetric productivity, whereas the second stage (with a lower dilution rate) served to further increase the final product concentration. High 1,3-propanediol concentrations were achieved (41-46 g l-1), with a maximum volumetric productivity of 3.4 g l-1 h-1. A cell concentration decrease was reported between the second and the first fermentor.     

Microbial fed-batch production of 1,3-propanediol by Klebsiella pneumoniae under micro-aerobic conditions

The microbial production of 1,3-propanediol (1,3-PD) by Klebsiella pneumoniae under micro-aerobic conditions was investigated in this study. The experimental results of batch fermentation showed that the final concentration and yield of 1,3-PD on glycerol under micro-aerobic conditions approached values achieved under anaerobic conditions. However, less ethanol was produced under microaerobic than anaerobic conditions at the end of fermentation. The batch micro-aerobic fermentation time was markedly shorter than that of anaerobic fermentation. This led to an increment of productivity of 1,3-PD. For instance, the concentration, molar yield, and productivity of 1,3-PD of batch micro-aerobic fermentation by K. pneumoniae DSM 2026 were 17.65 g/l, 56.13%, and 2.94 g l^–1 h^–1, respectively, with a fermentation time of 6 h and an initial glycerol concentration of 40 g/l. Compared with DSM 2026, the microbial growth of K. pneumoniae AS 1.1736 was slow and the concentration of 1,3-PD was low under the same conditions. Furthermore, the microbial growth in fed-batch fermentation by K. pneumoniae DSM 2026 was faster under micro-aerobic than anaerobic conditions. The concentration, molar yield, and productivity of 1,3-PD in fed-batch fermentation under micro-aerobic conditions were 59.50 g/l, 51.75%, and 1.57 g l^–1 h^–1, respectively. The volumetric productivity of 1,3-PD under microaerobic conditions was almost twice that of anaerobic fed-batch fermentation, at 1.57 and 0.80 g l^–1 h^–1, respectively.     

产1,3-丙二醇菌株的诱变和筛选

为提高克雷伯氏肺炎杆菌产1,3-丙二醇的能力,以离子束、紫外线和氯化锂为复合诱变法,建立了产酸圈和产物耐受相结合的平板筛选方法,获得可耐受高浓度1,3-丙二醇并且副产物中乙醇含量较少的优良突变菌株2株。与出发菌株相比,两株高产突变菌株Klebsiella pneumoniae LM 03和Klebsiella pneumoniae LM05的1,3-丙二醇产量分别提高了33% 和30% ,达到66.74 g/L和65.12 g/L;乙醇产量分别降低了38% 和24% ,降低为6.59 g/L和8.05 g/L。同时测定了诱变前后还原途径中甘油脱水酶（GDHt）和1,3-丙二醇氧化还原酶（PDOR）的酶活变化,研究表明诱变对GDHt有明显的促进作用,而对PDOR的影响不明显。该诱变和筛选方法目标明确、易操作、效率高,在1,3-PD工业规模的生物法生产中将具有良好的应用价值,而且对于其他具有工业应用价值的菌株筛选工作也具有一定的借鉴意义。     

3-Hydroxypropionaldehyde guided glycerol feeding strategy in aerobic 1,3-propanediol production by <Emphasis Type="Italic">Klebsiella pneumoniae</Emphasis>

3-Hydroxypropionaldehyde (3-HPA) is a toxic intermediary metabolite in the biological route of 1,3-propanediol biosynthesis from glycerol. 3-HPA accumulated in culture medium would arouse an irreversible cessation of the fermentation process. The role of substrate (glycerol) on 3-HPA accumulation in aerobic fermentation was investigated in this paper. 1,3-Propanediol oxidoreductase and glycerol dehydratase, two key enzyme catalyzing reactions of 3-HPA formation and consumption, were sensitive to high concentration of 3-HPA. When the concentration of 3-HPA increased to a higher level in medium (ac 10 mmol/L), the activity of 1,3-propanediol oxidoreductase in cell decreased correspondingly, which led to decrease of the 3-HPA conversion rate, then the 3-HPA concentration increasing was accelerated furthermore. 3-HPA accumulation in culture medium was triggered by this positive feedback mechanism. In the cell exponential growth phase, the reaction catalyzed by 1,3-propanediol oxidoreductase was the rate limiting step in 1,3-propanediol production. The level of 3-HPA in culture medium could be controlled by the substrate (glycerol) concentration, and lower level of glycerol could avoid 3-HPA accumulating to a high, lethal concentration. In fed batch fermentation, under the condition of initial glycerol concentration 30 g/L, and keeping glycerol concentration lower than 7–8 g/L in cell exponential growth phase, 3-HPA accumulation could not be incurred. Based on this result, a glycerol feeding strategy was set up in fed batch fermentation. Under the optimized condition, 50.1 g/L of 1,3-propanediol was produced in 24 h, and 73.1 g/L of final 1,3-propanediol concentration was obtained in 54 h.     

High-level production of 1,3-propanediol from crude glycerol by <Emphasis Type="Italic">Clostridium butyricum</Emphasis> AKR102a

The aim of this study was to optimize a biotechnological process for the production of 1,3-propanediol (1,3-PD) based on low-quality crude glycerol derived from biodiesel production. Clostridium butyricum AKR102a was used in fed-batch fermentations in 1-L and 200-L scale. The newly discovered strain is characterized by rapid growth, high product tolerance, and the ability to use crude glycerol at the lowest purity directly gained from a biodiesel plant side stream. Using pure glycerol, the strain AKR102 reached 93.7 g/L 1,3-PD with an overall productivity of 3.3 g/(L*h). With crude glycerol under the same conditions, 76.2 g/L 1,3-PD was produced with a productivity of 2.3 g/(L*h). These are among the best results published so far for natural producers. The scale up to 200 L was possible. Due to the simpler process design, only 61.5 g/L 1,3-PD could be reached with a productivity of 2.1 g/(L*h).     

Production of 1,3-propanediol from Glycerol by Recombinant <Emphasis Type="Italic">E. coli</Emphasis> Using Incompatible Plasmids System

1,3-Propanediol (1,3-PD) has numerous applications in polymers, cosmetics, foods, lubricants, and medicines as a bifunctional organic compound. The genes for the production of 1,3-PD in Klebsiella pneumoniae, dhaB, which encodes glycerol dehydratase, and dhaT, which encodes 1,3-PD oxidoreductase, and gdrAB, which encodes glycerol dehydratase reactivating factor, are naturally under the control of different promoters and are transcribed in different directions. These genes were coexpressed in E. coli using two incompatible plasmids (pET28a and pET22b) in the presence of selective pressure. The recombinant E. coli coexpressed the glycerol dehydratase, 1,3-propanediol oxidoreductase and reactivating factor for the glycerol dehydratase at high levels. In a fed-batch fermentation of glycerol and glucose, the recombinant E. coli containing these two incompatible plasmids consumed 14.3 g/l glycerol and produced 8.6 g/l 1,3-propanediol. In the substitution case of yqhD (encoding alcohol dehydrogenase from E. coli) for dhaT, the final 1,3-propanediol concentration of the recombinant E. coli could reach 13.2 g/l.