New isolate of Streptomyces sp. with novel thermoalkalotolerant cellulases

A Streptomyces sp. was isolated that produced novel thermoalkalotolerant cellulase activity after growth on crystalline cellulose at 50°C. Three major components of the cellulases (CMCase, Avicelase and cellobiase) were produced with maximal activities (11.8, 7.8 and 3.9 IU/ml) and maximum specific activities 357, 276 and 118 IU/mg protein, respectively, after 120 h growth. Maximum CMCase activity was between 50 and 60°C measured over 3 h. The enzyme also retained 88% of its maximum activity at 70°C and pH 5, and 80% of the activity at pH 10 and 50°C when assayed after 1 h. After incubation at 40°C for 1 h with commercial detergent (Tide) at pH 11, 95% activity was retained. The enzyme mixture produced glucose from crystalline cellulose.     

Production and Purification of Thermostable Cellulases from Humicola insolens YH-8

Humicola insolens YH-8, a thermophilic fungus isolated from manure and compost heaps, produced a significant amount of thermostable cellulases in cultures on wheat bran medium (50°C, 4 days). The mold bran extract hydrolyzed Avicel, CMC and newsprint at 90%, 45% and 35%, respectively, to glucose. Then, Avicelase and CMCase were purified from the culture extract by adsorption onto Avicel, heat and acid treatment and consecutive column chromatographies to a homogeneous state on polyacrylamide gel disc electrophoresis. The purified cellulases, especially CMCase, was found highly thermostable. The optimal temperature of both enzymes was 50°C. Avicelase was stable after heating at 65°C for 5 mm and CMCase retained 45% of the original activity after heating at 95°C for 5 min.     

纤维素降解菌Aspergillus sp. YN1的产酶条件及酶学特性

从牛羊粪堆肥中筛选出一株纤维素降解菌Aspergillus sp.YN1,主要研究了液体发酵培养基中碳源、氮源、培养温度、起始pH、通气量以及接种菌龄对菌株YN1的羧甲基纤维素酶活(CMC酶活)及滤纸酶活的影响。研究结果表明,在优化条件下,该菌的CMC酶活、滤纸酶活在培养第3天分别达到0.53U/mL和0.15U/mL。在酶学特性研究中,菌株YN1的CMC酶的最适反应温度为70°C,最适反应pH4.0(酶促反应为30min)。用不同温度处理1h或不同pH处理2h,YN1的CMC酶在30°C?50°C或pH3.0?4.0之间仍可保持80%以上的酶活性,对热及酸表现出较高的稳定性。     

Isolation and characterization of a thermostable cellulase-producing <Emphasis Type="Italic">Fusarium chlamydosporum</Emphasis>

A thermostable cellulase-producing fungus, HML 0278, was identified as Fusarium chlamydosporum by morphological characteristics and ITS rDNA sequence analysis. HML 0278 produced extracellular cellulases in solid-state fermentation using sugar cane bassage as the carbon source. Native-PAGE analysis demonstrated that this fungus strain was capable of producing the three major components of cellulases and xylanase, with a yield of 281.8 IU/g for CMCase, 182.4 IU/g for cellobiohydrolase, 135.2 IU/g for β-glucosidase, 95.2 IU/g for filter paper activity, and 4,720 IU/g for xylanase. More importantly, the CMCase and β-glucosidase produced by HML 0278 showed stable enzymatic activities within pH 4–9 and pH 4–10, and at temperatures below 70 and 60°C, respectively.     

Study of cellulases from a newly isolated thermophilic and cellulolytic <Emphasis Type="Italic">Brevibacillus</Emphasis> sp. strain JXL

A potentially novel aerobic, thermophilic, and cellulolytic bacterium designated as Brevibacillus sp. strain JXL was isolated from swine waste. Strain JXL can utilize a broad range of carbohydrates including: cellulose, carboxymethylcellulose (CMC), xylan, cellobiose, glucose, and xylose. In two different media supplemented with crystalline cellulose and CMC at 57°C under aeration, strain JXL produced a basal level of cellulases as FPU of 0.02 IU/ml in the crude culture supernatant. When glucose or cellobiose was used besides cellulose, cellulase activities were enhanced ten times during the first 24 h, but with no significant difference between these two simple sugars. After that time, however, culture with glucose demonstrated higher cellulase activities compared with that from cellobiose. Similar trend and effect on cellulase activities were also obtained when glucose or cellobiose served as a single substrate. The optimal doses of cellobiose and glucose for cellulase induction were 0.5 and 1%. These inducing effects were further confirmed by scanning electron microscopy (SEM) images, which indicated the presence of extracellular protuberant structures. These cellulosome-resembling structures were most abundant in culture with glucose, followed by cellobiose and without sugar addition. With respect to cellulase activity assay, crude cellulases had an optimal temperature of 50°C and a broad optimal pH range of 6–8. These cellulases also had high thermotolerance as evidenced by retaining more than 50% activity at 100°C after 1 h. In summary, this is the first study to show that the genus Brevibacillus may have strains that can degrade cellulose.     

Production of cellulases and xylanase by Aspergillus fumigatus SK1 using untreated oil palm trunk through solid state fermentation

Direct utilization of untreated oil palm trunk (OPT) for cellulases and xylanase production by Aspergillus fumigatus SK1 was conducted under solid-state fermentation (SSF). The highest activities of extracellular cellulases and xylanases were produced at 80% moisture level, initial pH 5.0, 1 × 10⁸ spore/g (inoculum) with 125 μm of OPT as sole carbon source. The cellulases and xylanase activities obtained were 54.27, 3.36, 4.54 and 418.70 U/g substrates for endoglucanase (CMCase), exoglucanase (FPase), β-glucosidase and xylanase respectively. The crude cellulases and xylanase required acidic condition to retain their optimum activities (pH 4.0). Crude cellulases and xylanase were more stable at 40 °C compared to their optimum activities conditions (60 °C for FPase and 70 °C for CMCase, β-glucosidase and xylanase). SDS-PAGE and zymogram analysis showed that Aspergillus fumigatus SK1 could secrete cellulases (endoglucanase, exoglucanase and β-glucosidase), xylanase and protease. Enzymatic degradation of alkaline treated OPT with concentrated crude cellulases and xylanases resulted in producing polyoses.     

Purification and biochemical characterization of glucose–cellobiose-tolerant cellulases from Scytalidium thermophilum

Two cellulases from Scytalidium thermophilum were purified and characterized, exhibiting tolerance to glucose and cellobiose. Characterization of purified cellulases I and II by mass spectrometry revealed primary structure similarities with an exoglucanase and an endoglucanase, respectively. Molecular masses were 51.2 and 45.6 kDa for cellulases I and II, respectively, as determined by sodium dodecyl sulfate polyacrylamide gel electrophoresis. Cellulases I and II exhibited isoelectric points of 6.2 and 6.9 and saccharide contents of 11 and 93 %, respectively. Optima of temperature and pH were 60–65 °C and 4.0 for purified cellulase I and 65 °C and 6.5 for purified cellulase II. Both cellulases maintained total CMCase activity after 60 min at 60 °C. Cysteine, Mn²⁺, dithiotreitol and ß-mercaptoethanol-stimulated cellulases I and II. The tolerance to cellulose hydrolysis products and the high thermal stabilities of Scytalidium cellulases suggest good potential for industrial applications.     

Statistical optimization of cellulases production by <Emphasis Type="Italic">Penicillium</Emphasis><Emphasis Type="Italic">chrysogenum</Emphasis> QML-2 under solid-state fermentation and primary application to chitosan hydrolysis

Solid-state fermentation conditions for cellulases production by a newly isolated Penicillium chrysogenum QML-2 were investigated using statistical methods. At first, significant variables for cellulases production including (NH₄)₂SO₄, initial pH and inoculum size were screened by using Plackett-Burman Design. Then the optimal regions of the significant variables were investigated by using the method of steepest ascent. Finally, central composite design and response surface analysis were adopted to determine the optimal values of the significant variables and investigate the combined effects of each variable’s pair on cellulases production. The results showed that the optimal ranges of (NH₄)₂SO₄ concentration, initial pH and inoculum size for three types of cellulases activities were 1.97–2.15 g, pH 4.32–4.41 and 13.3–13.7% (v/w), respectively. Using the mixture of corn stover powder and wheat bran (CSP/WB, 1/1) as carbon source, the optimization resulted in 370.15, 101.76 and 321.56 U/g for maximal endoglucanase activity, filter paper activity and β-glucosidase activity, respectively. Compared with maximum values of cellulases activities (endoglucanase activity 85.21 U/g, filter paper activity 16.62 U/g and β-glucosidase activity 67.68 U/g) obtained under unoptimized conditions, the optimization resulted in 3.34, 5.12 and 3.75 folds improvement for endoglucanase activity, filter paper activity and β-glucosidase activity, respectively. For chitosan hydrolysis, the crude cellulases had the optimal temperature of 55°C, pH of 4.4 and exhibited Michaelis constant (K _m) value of 8.34 mg/ml and maximum velocity (V _max) of 2.21 μmol glucosamine/min by 1 ml of the crude cellulases.     

Simultaneous production and induction of cellulolytic and xylanolytic enzymes in aStreptomyces sp.

Extracellular cellulolytic and xylanolytic enzymes ofStreptomyces sp. EC22 were produced during submerged fermentation. The cell-free culture supernatant of the streptomycete grown on microcrystalline cellulose contained enzymes able to depolymerize both crystalline and soluble celluloses and xylans. Higher cellulase and xylanase activities were found in the cell-free culture supernatant of the strain when grown on microcrystalline cellulose than when grown on xylan. Total cellulase and endoglucanase [carboxymethyl-cellulase (CMCase)] activities reached maxima after 72 h and xylanase activity was maximal after 60h. Temperature and pH optima were 55°C and 5.0 for CMCase activity and 60°C and 5.5 for total crystalline cellulase and xylanase activities. At 80°C, approximate half-lives of the enzymes were 37, 81 and 51 min for CMCase, crystalline cellulose depolymerization and xylanase, respectively.     

Utilization of oil palm decanter cake for cellulase and polyoses production

The abundance of oil palm decanter cake (OPDC) is a problem in oil palm mills. However, this lignocellulosic biomass can be utilized for cellulase and polyoses production. The effectiveness of chemical and physical pretreatment in reducing the lignin content was studied by saccharification using a Celluclast 1.5 L and scanning electron microscope. Physicochemical pretreatment of OPDC with 1% (w/v) NaOH and autoclaving at 121°C for 20 min increased potential polyoses produced to 52.5% and removed 28.7% of the lignin content. The optimized conditions for cellulase production by a locally isolated fungus were a time of 120 h, a substrate of untreated OPDC, a spore concentration of 1 × 10⁷ spore/mL, a temperature of 30°C, and a pH between 7.0 and 7.5. Trichoderma asperellum UPM1 produced carboxymethylcellulase (CMCase), ??-glucosidase and filter paper activity (FPase) in the following concentrations: 17.35, 0.53, and 0.28 U/mL, respectively. Aspergillus fumigatus UPM2 produced the CMCase, ??-glucosidase and FPase in the following amounts: 10.93, 0.76, and 0.24 U/mL. The cellulases from T. asperellum UPM1 produced 2.33 g/L of polyoses and the cellulases from A. fumigatus UPM2 produced 4.37 g/L of polyoses.     

Enhanced Soluble Expression of a Thermostable Cellulase from <Emphasis Type="Italic">Clostridium thermocellum</Emphasis> in <Emphasis Type="Italic">Escherichia coli</Emphasis>

In this study, the cellulase gene celD from Clostridium thermocellum was cloned into expression vectors pET-20b(+) and pHsh. While high expression can be achieved by means of both these expression systems, only the pHsh expression system gives soluble proteins. By weakening the mRNA secondary structure and replacing the rare codons for the N-terminal amino acids of the target protein, the expression level of CelD was increased from 4.1 ± 0.3 to 6.4 ± 0.4 U ml⁻¹ in LB medium. Recombinant CelD was purified by heat treatment followed by Ni–NTA affinity. The purified CelD exhibited the highest activity at pH 5.4 and 60°C, and retained more than 50% activity after incubation at 70°C for 1 h. The cellulase activity of CelD was significantly enhanced by Ca²⁺ but inhibited by EDTA. The favorable properties of CelD offer the potential for genetic modification of strains for biomass degradation. Presently, one of the major bottlenecks for industrial cellulase users is the high cost of enzyme production. The high level expression of soluble enzymes from the pHsh expression system offers a novel approach for the production of cellulases to be used in various agro-industrial processes such as chemical, food and textile.     

Streptomyces thermocerradoensis I3 secretes a novel bifunctional xylanase/endoglucanase under solid-state fermentation

Lignocellulosic wastes can be potentially converted into several bioproducts such as glucose, xylo-oligosaccharides, and bioethanol. Certain processes, such as enzymatic hydrolysis, are generally needed to convert biomass into bioproducts. The present study investigated the production of xylanases and cellulases by Streptomyces thermocerradoensis I3 under solid-state fermentation (SSF), using wheat bran as a low-cost medium. The activities of xylanase and carboxymethyl cellulase (CMCase) were evaluated until 96 hr of incubation. The highest enzyme activity was observed after 72 hr of incubation. The crude enzyme extract was sequentially filtered, first using a 50 kDa filter, followed by a 30 kDa filter. Fraction 3 (F3) exhibited activities of both xylanase and CMCase. Xylanase and CMCase showed optimum activity at 70°C and pH 6.0 and 55°C and pH 6.0, respectively. The zymogram analysis showed a single activity band with a molecular mass of approximately 17 kDa. These findings provide strong evidence that the enzyme is a bifunctional xylanase/endoglucanase. This enzyme improved the saccharification of sugarcane bagasse by 1.76 times that of commercial cellulase. This enzyme has potential applications in various biotechnological procedures.     

Cloning and expression of a novel thermostable cellulase from newly isolated <Emphasis Type="Italic">Bacillus subtilis</Emphasis> strain I15

A novel bacterial strain with high cellulase activity (2.82 U/ml) was isolated, and then identified by its morphological character and 16S rRNA sequence, and named Bacillus subtilis strain I15. The extracellular thermostable cellulase exhibited the maximum activity at 60°C and pH 6.0. It was very stable since more than 90% of original CMCase activity was maintained at 65°C after incubation for 2 h. The cellulase gene, celI15, was cloned and extracellularly expressed by Escherichia coli BL21 (DE3), which encoded the extracellular protein of about 52 kDa. The extracellular activity of CelI15 from E. coli BL21 was up to about 6.78 U/ml, and all the other properties were almost the same as that from the wild-type strain.     

Optimization of cellulase production in batch fermentation byTrichoderma reesei

Maximum cellulase production was sought by comparing the activities of the cellulases produced by differentTrichoderma reesei strains andAspergillus niger. Trichoderma reesei Rut-C30 showed higher cellulase activity than otherTrichoderma reesei strains andAspergillus niger that was isolated from soil. By optimizing the cultivation condition during shake flask culture, higher cellulase production could be achieved. The FP (filter paper) activity of 3.7 U/ml and CMCase (Carboxymethylcellulase) activity of 60 U/ml were obtained from shake flask culture. When it was grown in 2.5L fermentor, where pH and DO levels are controlled, the Enzyme activities were 133.35 U/ml (CMCase) and 11.67 U./ml (FP), respectively. Ammonium sulfate precipitation method was used to recover enzymes from fermentation broth. The dried cellulase powder showed 3074.9 U/g of CMCase activity and 166.7 U/g of FP activity with 83.5% CMCase recovery.     

Comprehensive studies on optimization of cellulase and xylanase production by a local indigenous fungus strain via solid state fermentation using oil palm frond as substrate

The high cost of cellulases remains the most significant barrier to the economical production of bio-ethanol from lignocellulosic biomass. The goal of this study was to optimize cellulases and xylanase production by a local indigenous fungus strain (Aspergillus niger DWA8) using agricultural waste (oil palm frond [OPF]) as substrate. The enzyme production profile before optimization indicated that the highest carboxymethyl cellulose (CMCase), filter paper (FPase), and xylanase activities of 1.06 U/g, 2.55 U/g, and 2.93 U/g were obtained on day 5, day 4, and day 5 of fermentation, respectively. Response surface methodology was used to study the effects of several key process parameters in order to optimize cellulase production. Of the five physical and two chemical factors tested, only moisture content of 75% (w/w) and substrate amount of 2.5 g had statistically significant effect on enzymes production. Under optimized conditions of 2.5 g of substrate, 75% (w/w) moisture content, initial medium of pH 4.5, 1 × 10⁶ spores/mL of inoculum, and incubation at ambient temperature (±30°C) without additional carbon and nitrogen, the highest CMCase, FPase, and xylanase activities obtained were 2.38 U/g, 2.47 U/g, and 5.23 U/g, respectively. Thus, the optimization process increased CMCase and xylanase production by 124.5 and 78.5%, respectively. Moreover, A. niger DWA8 produced reasonably good cellulase and xylanase titers using OPF as the substrate when compared with previous researcher finding. The enzymes produced by this process could be further use to hydrolyze biomass to generate reducing sugars, which are the feedstock for bioethanol production.     

Purification and characterization of cellulase fromBacillus thermoalcaliphilus isolated from a termite mound

An extracellular carboxymethyl cellulase (CMCase) was purified to homogeneity fromBacillus thermoalcaliphilus sp. nov. The cellulase was composed of a single subunit with molar mass of 46 kDa. The apparentK _m was at 3.5 mg cellulose per mL. Its optimum pH was 8.5, it was most stable at pH 8.5–9.5 but 50% of enzyme activity was present after 30 min at pH 11.0. The activity was highest at 70°C.     

Domestic wastewater as substrate for cellulase production by Trichoderma harzianum

Cellulase production using residues as substrate has been well described, as it is an interesting method of reducing the costs of processes, one of the main bottlenecks for the production of enzymes. This research describes for the first time the use of raw domestic wastewater, which is largely and continuously generated, as a culture base medium for cellulase production. The strain Trichoderma harzianum HBA03 was selected according to the highest activity produced for FPase (5.4 U/mL) and CMCase (8.2 U/mL). Peptone was selected as a nitrogen source and microcrystalline cellulose as the inducer for cellulase production, resulting in FPase activities of 5.6 and 5.0 U/mL and CMCase activities of 12.0 and 14.4 U/mL. The use of domestic wastewater as the culture medium led to an increase of 1.41 and 1.14 fold of FPase and CMCase production, respectively, compared to the synthetic medium. Production was also carried out in a bubble column reactor in which the maximum productivities achieved 10.2 U/L.h (FPase) and 64.6 U/L.h (CMCase). The presented results demonstrate the feasibility of the use of domestic wastewater for cellulases production, thereby contributing to the development of a sustainable process for reusing wastewater with a significant reduction in environmental impact.     

Isolation and characterization of cellulose-degrading bacteria from the deep subsurface of the Homestake gold mine,Lead, South Dakota,USA

The present study investigated the cultivable mesophilic (37°C) and thermophilic (60°C) cellulose-degrading bacterial diversity in a weathered soil-like sample collected from the deep subsurface (1.5 km depth) of the Homestake gold mine in Lead, South Dakota, USA. Chemical characterization of the sample by X-ray fluorescence spectroscopy revealed a high amount of toxic heavy metals such as Cu, Cr, Pb, Ni, and Zn. Molecular community structures were determined by phylogenetic analysis of 16S rRNA gene sequences retrieved from enrichment cultures growing in presence of microcrystalline cellulose as the sole source of carbon. All phylotypes retrieved from enrichment cultures were affiliated to Firmicutes. Cellulose-degrading mesophilic and thermophilic pure cultures belonging to the genera Brevibacillus, Paenibacillus, Bacillus, and Geobacillus were isolated from enrichment cultures, and selected cultures were studied for enzyme activities. For a mesophilic isolate (DUSELG12), the optimum pH and temperature for carboxymethyl cellulase (CMCase) were 5.5 and 55°C, while for a thermophilic isolate (DUSELR7) they were 5.0 and 75°C, respectively. Furthermore, DUSELG12 retained about 40% CMCase activity after incubation at 60°C for 8 h. Most remarkably, thermophilic isolate, DUSELR7 retained 26% CMCase activity at 60°C up to a period of 300 h. Overall, the present work revealed the presence of different cellulose-degrading bacterial lineages in the unique deep subsurface environment of the mine. The results also have strong implications for biological conversion of cellulosic agricultural and forestry wastes to commodity chemicals including sugars.     

Saccharification of cellolulose by the cellulolytic enzyme system of Thermonospora sp. I. Stability of cellulolytic activities with respect to time,temperature, and pH

The stabilities and optima with respect to temperature and pH of the β-glucosidase, Avicelase, and carboxymethylcellulase (CMCase) activity of Thermomonospora sp., in the culture filtrate, culture whole broth, and filtrate after sonication of culture solids, are reported. The β-glucosidase is cell associated and has an optimal activity at about pH 6.5 and 55°C. In the whole culture broth, it has a half-life of about 8 hr at 55°C and less than 1 hr at 60°C, while the half-life of the activity in the sonicated, cell-free filtrate is less than 1 hr at 55°C. The Avicelase and CMCase activities occur in the extracellular culture fluid and have optima at about pH 7.0 and 5.9, and 65 and 70°C, respectively. The CMCase activity is stable over 24 hr at 60°C, but declines by 50% in the same period at 65°C. The Avicelase activity declines by 15% over 24 hr at 55°C, and by 50% at 60°C. The highest pH studied (pH 7.3) was the most destabilizing for all three activities. The thermostable characteristics of the cellulases from Themomonospora appear to make them suitable for commercial saccharification processes operating at elevated temperatures.