Enantioselective hydration of 2-arylpropionitriles by a nitrile hydratase from Agrobacterium tumefaciens strain d3

The enantioselective nitrile hydratase from the bacterium Agrobacterium tumefaciens d3 was purified and completely separated from the amidase activity that is also present in cell extracts prepared from this strain. The nitrile hydratase had an activity optimum at pH 7.0 and a temperature optimum of 40 °C. The holoenzyme had a molecular mass of 69 kDa, the subunits a molecular mass of 27 kDa. The enzyme hydrated various 2-arylpropionitriles and other aromatic and heterocyclic nitriles. With racemic 2-phenylpropionitrile, 2-phenylbutyronitrile, 2-(4-chlorophenyl)propionitrile, 2-(4-methoxy)propionitrile or ketoprofen nitrile the corresponding (S)-amides were formed enantioselectively. The highest enantiomeric excesses (ee >90% until about 30% of the respective substrates were converted) were found for the amides formed from 2-phenylpropionitrile, 2-phenylbutyronitrile and ketoprofen nitrile. For the reaction of the purified nitrile hydratase, higher ee values were found than when whole cells were used in the presence of an inhibitor of the amidase activity. The enantioselectivity of the whole-cell reaction was enhanced by increasing the reaction temperature. Received: 20 June 1997 / Received revision: 28 August 1997 / Accepted: 29 August 1997     

Purification and characterization of the intracellular β-glucosidase from Aureobasidium sp ATCC 20524

β-Glucosidase hydrolyzing cellobiose was extracted from Aureobasidium sp ATCC 20524 and purified to homogeneity. The molecular mass was estimated to be about 331 kDa. The enzyme contained 26.5% (w/w) carbohydrate. The optimum pH and temperature for the enzyme reaction were pH 4 and 80°C, respectively. The enzyme was stable at a wide range of pH, 2.2–9.8, after 3 h and at 75°C for 15 min. The kinetic parameters were determined. The enzyme was relatively stable against typical organic enzyme inhibitors. The enzyme also hydrolyzed gentiobiose, p-nitrophenyl-β-glucoside and salicin. Received 05 November 1998/ Accepted in revised form 14 February 1999     

Cloning and characterization of a thermostable xylitol dehydrogenase from Rhizobium etli CFN42

An NAD⁺-dependent xylitol dehydrogenase from Rhizobium etli CFN42 (ReXDH) was cloned and overexpressed in Escherichia coli. The DNA sequence analysis revealed an open reading frame of 1,044 bp, capable of encoding a polypeptide of 347 amino acid residues with a calculated molecular mass of 35,858 Da. The ReXDH protein was purified as an active soluble form using GST affinity chromatography. The molecular mass of the purified enzyme was estimated to be ∼34 kDa by sodium dodecyl sulfate–polyacrylamide gel and ∼135 kDa with gel filtration chromatography, suggesting that the enzyme is a homotetramer. Among various polyols, xylitol was the preferred substrate of ReXDH with a K _m = 17.9 mM and k_cat /K _m = 0.5 mM⁻¹ s⁻¹ for xylitol. The enzyme had an optimal pH and temperature of 9.5 and 70 °C, respectively. Heat inactivation studies revealed a half life of the ReXDH at 40 °C of 120 min and a half denaturation temperature (T _1/2) of 53.1 °C. ReXDH showed the highest optimum temperature and thermal stability among the known XDHs. Homology modeling and sequence analysis of ReXDH shed light on the factors contributing to the high thermostability of ReXDH. Although XDHs have been characterized from several other sources, ReXDH is distinguished from other XDHs by its high thermostability.     

A highly thermostable endo-(1,4)-β-mannanase from the marine bacterium Rhodothermus marinus

Rhodothermus marinus ATCC 43812, a thermophilic bacterium isolated from marine hot springs, possesses hydrolytic activities for depolymerising substrates such as carob-galactomannan. Screening of expression libraries identified mannanase-positive clones. Subsequently, the corresponding DNA sequences were determined, eventually identifying a coding sequence specifying a 997 amino acid residue protein of 113 kDa. Analyses revealed an N-terminal domain of unknown function and a C-terminal mannanase domain of 550 amino acid residues with homology to known mannanases of glycosidase family 26. Action pattern analysis categorised the R. marinus mannanase as an endo-acting enzyme with a requirement for at least five sugar moieties for effective catalytic activity. When expressed in Escherichia coli, purified gene product with catalytic activity was mainly found as two protein fragments of 45 kDa and 50 kDa. The full-length protein of 113 kDa was only detected in crude extracts of R. marinus, while truncated protein-containing fractions of the original source resulted in a major active protein of 60 kDa. Biochemical analysis of the mannanase revealed a temperature and pH optimum of 85 °C and pH 5.4, respectively. Purified, E. coli-produced protein fragments showed high heat stability, retaining more than 70% and 25% of the initial activity after 1 h incubation at 70 °C and 90 °C, respectively. In contrast, R. marinus-derived protein retained 87% activity after 1 h at 90 °C. The enzyme hydrolysed carob-galactomannan (locust bean gum) effectively and to a smaller extent guar gum, but not yeast mannan. Received: 5 November 1999 / Received revision: 19 January 2000 / Accepted: 23 January 2000     

Characterisation of a starch-hydrolysing enzyme of Aspergillus niger

A UV-induced mutant strain of Aspergillus niger (CFTRI-1105-U9) overproduced a starch-hydrolysing enzyme with properties characteristically different from the known amylases of the fungus. The purified enzyme of 4.0 pI had an apparent molecular mass of 125 kDa and it dextrinised starch and then saccharified the dextrins. Patterns of the enzyme activity on starch, resulting in glucose at 60 °C and glucose, maltose and maltodextrins at 70 °C as primary products, suggested significant applications for the enzyme in starch-processing industries. Received: 29 October 1998 / Received revision: 11 January 1999 / Accepted: 19 January 1999     

Cloning and functional expression of a nitrile hydratase (NHase) from Rhodococcus equi TG328-2 in Escherichia coli, its purification and biochemical characterisation

The nitrile hydratase (NHase, EC 4.2.1.84) genes (α and β subunit) and the corresponding activator gene from Rhodococcus equi TG328-2 were cloned and sequenced. This Fe-type NHase consists of 209 amino acids (α subunit, M_r 23 kDa) and 218 amino acids (β subunit, M_r 24 kDa) and the NHase activator of 413 amino acids (M_r 46 kDa). Various combinations of promoter, NHase and activator genes were constructed to produce active NHase enzyme recombinantly in E. coli. The maximum enzyme activity (844 U/mg crude cell extract towards methacrylonitrile) was achieved when the NHase activator gene was separately co-expressed with the NHase subunit genes in E. coli BL21 (DE3). The overproduced enzyme was purified with 61% yield after French press, His-tag affinity chromatography, ultrafiltration and lyophilization and showed typical Fe-type NHase characteristics: besides aromatic and heterocyclic nitriles, aliphatic ones were hydrated preferentially. The purified enzyme had a specific activity of 6,290 U/mg towards methacrylonitrile. Enantioselectivity was observed for aromatic compounds only with E values ranging 5–17. The enzyme displayed a broad pH optimum from 6 to 8.5, was most active at 30°C and showed the highest stability at 4°C in thermal inactivation studies between 4°C and 50°C.     

Production, purification, and characterization of a highly enantioselective (S )-N-acetyl-1-phenylethylamine amidohydrolase from Rhodococcus equi Ac6

Rhodococcus equi Ac6 was found to express an inducible (S )-specific N-acetyl-1-phenylethylamine amidohydrolase. Optimal bacterial growth and amidohydrolase expression were both observed around pH 6.5. Purification of the enzyme to a single band in a Coomassie-blue-stained sodium dodecyl sulfate/polyacrylamide gel (SDS-PAGE) was achieved by ammonium sulfate precipitation of R. equi Ac6 crude extract and column chromatographies on Fractogel TSK Butyl-650(S) and Superose 12HR. At pH 7.0 and 30 °C the amidohydrolase had a half-life of around 350 days; at 44 °C it was only 10 min. Except for Ni²⁺ and, to some extent, Zn²⁺ and Co²⁺, the enzyme was neither strongly influenced by metal cations nor by chelating agents, but was inhibited by 95% at 0.1 mM phenylmethylsulfonyl fluoride. The molecular mass of the native enzyme was estimated to be 94 kDa by gel filtration and 50 kDa by SDS-PAGE, suggesting a dimeric structure. Specificity experiments revealed a spectrum of related N-acetylated compounds being hydrolyzed with variable enantiomeric selectivities. Received: 20 September 1996 / Received revision: 23 December 1996 / Accepted: 30 December 1996     

Microbial production, purification, and characterization of (S)-specific N-acetyl-2-amino-1-phenyl-4-pentene amidohydrolase from Rhodococcus globerulus K1/1

Rhodococcus globerulus K1/1 was found to express an inducible (S)-specific N-acetyl-2-amino-1-phenyl-4-pentene amidohydrolase. Optimal bacterial growth and amidohydrolase expression were both observed at about pH 6.5. Purification of the enzyme to a single band in a Coomassie blue-stained SDS-PAGE gel was achieved by nucleic acid and ammonium sulfate precipitation of Rhodococcus globerulus K1/1 crude extract and column chromatography on TSK Butyl-650(S) Fractogel and Superose 12HR. The amidohydrolase was purified to a homogeneity leading to a tenfold increase of the specific activity with a recovery rate of 65%. At pH 7.0 and 23 °C the enzyme showed no loss of activity after 30 days incubation. The amidohydrolase was stable up to 55 °C. The enzyme was inhibited strongly only by 10 mM Zn²⁺ among the tested metal cations and was inhibited 100% by 0.01 mM phenylmethanesulfonyl fluoride. The molecular weight of the native enzyme was estimated to be 92 kDa by gel filtration and 55 kDa by SDS-PAGE, suggesting a homodimeric structure. Received: 8 February 1999 / Received revision: 3 May 1999 / Accepted: 7 May 1999     

Isolation and characterization of highly (R)-specific N-acetyl-1-phenylethylamine amidohydrolase, a new enzyme from Arthrobacter aurescens AcR5b

A new amidohydrolase deacetylating several N-acetyl-1-phenylethylamine derivatives (R)-specifically was found in Arthrobacter aurescens AcR5b. The strain was isolated from a wet haystack by enrichment culture with (R)-N-acetyl-1-phenylethylamine as the sole carbon source. (R) and (S )-N-acetyl-1-phenylethylamine do not serve as inducers for acylase formation. By improving the growth conditions the enzyme production was increased 47-fold. The amidohydrolase was purified to homogeneity leading to a 5.2-fold increase of the specific activity with a recovery of 67%. A molecular mass of 220 kDa was estimated by gel filtration. Sodium dodecyl sulfate/polyacrylamide gel electrophorosis shows two subunits with molecular masses of 16 kDa and 89 kDa. The optimum pH and temperature were pH 8 and 50 °C, respectively. The enzyme was stable in the range of pH 7–9 and at temperatures up to 30 °C. The enzyme activity was inhibited by Cu²⁺, Co²⁺, Ni²⁺, and Zn²⁺, and this inhibition was reversed by EDTA.M Received: 20 September 1996 / Received version: 23 December 1996 / Accepted: 30 December 1996     

Isolation and characterization of photoactive complexes of NADPH:protochlorophyllide oxidoreductase from wheat

A photoactive substrate-enzyme complex of the NADPH:protochlorophyllide oxidoreductase (POR; EC 1. 3. 1. 33) was purified from etiolated Triticum aestivum L. by gel chromatography after solubilization of prolamellar bodies by dodecyl-maltoside. Irradiation by a 1-ms flash induced the phototransformation of protocholorophyllide a (Pchlide) with −196 °C absorbance and emission maxima at 640 and 643 nm, respectively. The apparent molecular weight of this complex was 112 ± 24 kDa, which indicates aggregation of enzyme subunits. By lowering the detergent concentration in the elution buffer, a 1080 ± 250-kDa particle was obtained which displayed the spectral properties of the predominant form of photoactive Pchlide in vivo (−196 °C absorbance and fluorescence maxima at 650 and 653 nm). In this complex, POR was the dominant polypeptide. Gel chromatography in the same conditions of an irradiated sample of solubilized prolamellar bodies indicated rapid disaggregation of the complex after Pchlide phototransformation. High performance liquid chromatographic analysis of the POR complexes obtained using two detergent concentrations indicates a possible association of zeaxanthin and violaxanthin with the photoactive complex. Received: 25 February 1998 / Accepted: 8 June 1998     

Production of β-galactosidase from thermophilic fungus Rhizomucor sp

A thermostable β-galactosidase was produced extracellularly by a thermophilic Rhizomucor sp, with maximum enzyme activity (0.21 U mg⁻¹) after 4 days under submerged fermentation condition (SmF). Solid state fermentation (SSF) resulted in a nine-fold increase in enzyme activity (2.04 U mg⁻¹). The temperature range for production of the enzyme was 38–55°C with maximum activity at 45°C. The optimum pH and temperature for the partially purified enzyme was 4.5 and 60°C, respectively. The enzyme retained its original activity on incubation at 60°C up to 1 h. Divalent cations like Co²⁺, Mn²⁺, Fe²⁺ and Zn²⁺ had strong inhibitory effects on the enzyme activity. The K _m and V _max for p-nitrophenyl-β- _D-galactopyranoside and o-nitrophenyl-β - _D-galactopyranoside were 0.39 mM, 0.785 mM and 232.1 mmol min⁻¹ mg⁻¹ respectively. The K _m and V _max for the natural substrate lactose were 66.66 μM and 0.20 μ mol min⁻¹ mg⁻¹. Received 10 March 1997/ Accepted in revised form 17 July 1997     

Purification and properties of a thermoactive and thermostable pullulanase from Thermococcushydrothermalis, a hyperthermophilic archaeon isolated from a deep-sea hydrothermal vent

The extremely thermophilic archaeon Thermococcus hydrothermalis, isolated from a deep-sea hydrothermal vent in the East Pacific Rise at 21°N, produced an extracellular pullulanase. This enzyme was purified 97-fold to homogeneity from cell-free culture supernatant. The purified pullulanase was composed of a single polypeptide chain having an estimated molecular mass of 110 kDa (gel filtration) or 128 kDa (sodium dodecyl sulfate/polyacryl amide gel electrophoresis). The enzyme showed optimum activity at pH 5.5 and 95 °C. The thermostability and the thermoactivity were considerably increased in the presence of Ca²⁺. The enzyme was activated by 2-mercaptoethanol and dithiothreitol, whereas N-bromosuccinimide and α-cyclodextrin were inhibitors. This enzyme was able to hydrolyze, in addition to the α-1,6-glucosidic linkages in pullulan, α-1,4-glucosidic linkages in amylose and soluble starch, and can therefore be classified as a type II pullulanase or an amylopullulanase. The purified enzyme displayed Michaelis constant (K _m) values of 0.95 mg/ml for pullulan and 3.55 mg/ml for soluble starch without calcium and, in the presence of Ca²⁺, 0.25 mg/ml for pullulan and 1.45 mg/ml for soluble starch. Received: 19 November 1997 / Received revision: 9 March 1998 / Accepted: 14 March 1998     

Enzymes from Sulfolobus shibatae for the production of trehalose and glucose from starch

Enzymes that convert starch and dextrins to α,α-trehalose and glucose were found in cell homogenates of the hyperthermophilic acidophilic archaeon Sulfolobus shibatae DMS 5389. Three enzymes were purified and characterized. The first, the S. shibatae trehalosyl dextrin-forming enzyme (SsTDFE), transformed starch and dextrins to the corresponding trehalosyl derivatives with an intramolecular transglycosylation process that converted the glucosidic linkage at the reducing end from α-1,4 to α-1,1. The second, the S. shibatae trehalose-forming enzyme (SsTFE), hydrolyzed the α-1,4 linkage adjacent to the α-1,1 bond of trehalosyl dextrins, forming trehalose and lower molecular weight dextrins. These two enzymes had molecular masses of 80 kDa and 65 kDa, respectively, and showed the highest activities at pH 4.5. The apparent optimal temperature for activity was 70°C for SsTDFE and 85°C for SsTFE. The third enzyme identified was an α-glycosidase (SsαGly), which catalyzed the hydrolysis of the α-1,4 glucosidic linkages in starch and dextrins, releasing glucose in a stepwise manner from the nonreducing end of the polysaccharide chain. The enzyme had a molecular mass of 313 kDa and showed the highest activity at pH 5.5 and at 85°C. Received: October 29, 1997 / Accepted: April 29, 1998     

Keratinase of Doratomyces microsporus

 The fungus Doratomyces microsporus produced an extracellular keratinase during submerged aerobic cultivation in a medium containing a protein inducer for enzyme synthesis. The keratinase was purified to homogeneity using hydrophobic interaction chromatography followed by gel chromatography. The molecular weight was estimated to be 33 kDa (from SDS-PAGE analysis) or 30 kDa (by gel chromatography), suggesting a monomeric structure. The isoelectric point of the enzyme was determined to be around 9. The optimal pH and temperature for keratinolytic activity were pH 8–9 and 50 °C, respectively. The serine protease inhibitor PMSF totally inhibited the keratinase. The enzyme was not glycosylated. It was capable of hydrolysing different keratinous materials as well as some non-keratinous proteins. Hydrolysis of some synthetic substrates, specific for known proteinases, suggested that the keratinase of D. microsporus is close to proteinase K. Received: 9 July 1999 / Received revision: 13 September 1999 / Accepted: 17 September 1999     

Purification, characterization and immobilization of an NADPH-dependent enzyme involved in the chiral specific reduction of the keto ester M, an intermediate in the synthesis of an anti-asthma drug, Montelukast, from Microbacterium campoquemadoensis (MB5614)

(S)(E)-2-{3-[3-[2-(7-chloro-2-quinolinyl)ethenyl]-phenyl]-3-hydroxypropyl} benzoic acid methyl ester,␣a key intermediate in the synthesis of the anti-asthma drug, Montelukast, was prepared from the corresponding ketone (keto ester M) by microbial transformation. The biotransforming organism, Microbacterium campoquemadoensis (MB5614), was discovered as a result of an extensive screening program and was used for the isolation and purification of the responsible enzyme. The enzyme is a soluble cytoplasmic protein which was purified as a complex with a low-molecular-mass molecule that had a visible-light absorption maximum at 460 nm. The purified enzyme has an apparent molecular mass of 60 kDa, when denatured, and is isolated in the native state as an oligomer. The isolated enzyme requires NADPH for its activity and reduces the keto ester M to the desired (S)-hydroxy ester with an enantiomeric excess greater than 95% at the optimum temperature of 30 °C and pH 8. The enzyme was immobilized on oxirane-activated acrylamide beads with some loss of activity, but it was fully active in a two-phase (water/hexane 25:75) solvent system, both as a free solution and in an immobilized form. Received: 31 October 1997 / Received revision: 8 January 1998 / Accepted: 24 January 1998     

Cloning, sequencing and overexpression of a Rhodothermus marinus gene encoding a thermostable cellulase of glycosyl hydrolase family 12

A gene library from the thermophilic eubacterium Rhodothermus marinus, strain ITI 378, was constructed in pUC18 and transformed into Escherichia coli. Of 5400 transformants, 3 were active on carboxymethylcellulose. Three plasmids conferring cellulase activity were purified and were all found to contain the same cellulase gene, celA. The open reading frame for the celA gene is 780 base pairs and encodes a protein of 260 amino acids with a calculated molecular mass of 28.8 kDa. The amino acid sequence shows homology with cellulases in glycosyl hydrolase family 12. The celA gene was overexpressed in E. coli when the pET23, T7 phage RNA polymerase system was used. The enzyme showed activity on carboxymethylcellulose and lichenan, but not on birch xylan or laminarin. The expressed enzyme had six terminal histidine residues and was purified by using a nickel nitrilotriacetate column. The enzyme had a pH optimum of 6–7 and its highest measured initial activity at 100 °C. The heat stability of the enzyme was increased by removal of the histidine residues. It then retained 75% of its activity after 8 h at 90 °C. Received: 5 August 1997 / Received revision: 6 November 1997 / Accepted: 7 November 1997     

Sequence analysis of glutamate dehydrogenase (GDH) from the hyperthermophilic archaeon Pyrococcus sp. KOD1 and comparison of the enzymatic characteristics of native and recombinant GDHs

The gdhA gene encoding glutamate dehydrogenase (GDH) from the hyperthermophilic archaeon Pyrococcus sp. KOD1 was cloned and sequenced. Phylogenetic analysis was performed on an alignment of 25 GDH sequences including KOD1-GDH, and two protein families were distinguished, as previously reported. KOD1-GDH was classified as new member of the hexameric GDH Family II. The gdhA gene was expressed in Escherichia coli, and recombinant KOD1-GDH was purified. Its enzymatic characteristics were compared with those of the native KOD1-GDH. Both enzymes had a molecular mass of 47 300 Da and were shown to be functional in a hexameric form (284 kDa). The N-terminal amino acid sequences of native KOD1-GDH and the recombinant GDH were VEIDPFEMAV and MVEIDPFEMA, respectively, indicating that native KOD1-GDH does not retain the initial methionine at the N-terminus. The recombinant GDH displayed enzyme characteristics similar to those of the native GDH, except for a lower level of thermostability, with a half-life of 2 h at 100° C, compared to 4 h for the native enzyme purified from KOD1. Kinetic studies suggested that the reaction is biased towards glutamate production. KOD1-GDH utilized both coenzymes NADH and NADPH, as do most eukaryal GDHs. Received: 6 May 1997 / Accepted: 23 September 1997     

Molecular cloning,purification and characterization of two endo-1,4-β-glucanases from Aspergillus oryzae KBN616

Two endo-1,4-β-glucanase genes, designated celA and celB, from a shoyu koji mold Aspergillus oryzae KBN616, were cloned and characterized. The celA gene comprised 877 bp with two introns. The CelA protein consisted of 239 amino acids and was assigned to the cellulase family H. The celB gene comprised 1248 bp with no introns. The CelB protein consisted of 416 amino acids and was assigned to the cellulase family C. Both genes were overexpressed under the promoter of the A. oryzae taka-amylase A gene for purification and enzymatic characterization of CelA and CelB. CelA had a molecular mass of 31 kDa, a pH optimum of 5.0 and temperature optimum of 55 °C, whereas CelB had a molecular mass of 53 kDa, a pH optimum of 4.0 and temperature optimum of 45 °C. Received: 3 July 1996 / Accepted: 15 July 1996     

Purification and properties of a novel raw starch degrading cyclomaltodextrin glucanotransferase from Bacillus firmus

A novel raw starch degrading cyclomaltodextrin glucanotransferase (CGTase; E.C. 2.4.1.19), produced by Bacillus firmus, was purified to homogeneity by ultrafiltration, affinity and gel filtration chromatography. The molecular weight of the pure protein was estimated to be 78 000 and 82 000 Da, by SDS-PAGE and gel filtration, respectively. The pure enzyme had a pH optimum in the range 5.5–8.5. It was stable over the pH range 7–11 at 10 °C, and at pH 7.0 at 60 °C. The optimum temperature for enzyme activity was 65 °C. In the absence of substrate, the enzyme rapidly lost its activity above 30 °C. K _m and k _cat for the pure enzyme were 1.21 mg/ml and 145.17 μM/mg per minute respectively, with soluble starch as the substrate. For cyclodextrin production, tapioca starch was the best substrate used when gelatinized, while wheat starch was the best substrate used when raw. This CGTase could degrade raw wheat starch very efficiently; up to 50% conversion to cyclodextrins was obtained from 150 g/l starch without using any additives. The enzyme produced α-, β- and γ-cyclodextrins in the ratio of 0.2:9.2:0.6 and 0.2:8.6:1.2 from gelatinized tapioca starch and raw wheat starch with 150 g/l concentration respectively, after 18 h incubation. Received: 25 September 1998 / Received revision: 15 December 1998 / Accepted: 21 December 1998     

Characterization of novel thermostable dextranase from Thermotoga lettingae TMO

Biochemical properties of a putative thermostable dextranase gene from Thermotoga lettingae TMO were determined in a recombinant protein (TLDex) expressed in Escherichia coli and purified to sevenfold apparent homogeneity. The 64-kDa protein displayed maximum activity at pH 4.3, and enzyme activity was stable from pH 4.3–10. The optimal temperature was 55–60°C during 15 min incubation, and the half-life of the enzyme was 1.5 h at 65°C. The enzyme showed higher activity against α-(1 → 6) glucan and released isomaltose and isomaltotriose as main products from dextran T2000. An unusual kinetic feature of TLDex was the negative cooperative behavior on the reaction of dextran T2000 cleavage. Enzyme activity was not significantly affected by the presence of metal ions, except for the strong inhibited by 1 mM Fe²⁺ and Ag²⁺. TLDex may prove useful as an enzyme for high temperature sugar milling processes.