Pretreatment of municipal waste activated sludge for volatile sulfur compounds control in anaerobic digestion

The effect of combination of mechanical and chemical pretreatment of municipal waste activated sludge (WAS) prior to anaerobic digestion was studied using a laboratory scale system with an objective to decrease volatile sulfur compounds in biogas and digested sludge. Mechanical pretreatment was conducted using depressurization of WAS through a valve from a batch pretreatment reactor pressurized at 75 ± 1 psi, while combined pretreatments were conducted using six different dosages of hydrogen peroxide (H₂O₂) and ferrous chloride (FeCl₂) along with mechanical pretreatment. About 37-46% removal of H₂S in biogas occurred for different combined pretreatment conditions. Sludge solubilization achieved due to the mechanical pretreatment increased total cumulative methane production by 8-10% after 30 days during the biochemical methane potential (BMP) test. The pretreatment also improved dewaterability in terms of time to filter (TTF), and decreased methyl mercaptan generation potential of the digested sludge.     

Anaerobic digestion of microalgal biomass with ultrasonic disintegration

The use of photosynthetic microalgae for nutrient removal and biofuel production has been widely discussed. Anaerobic digestion of waste microalgal biomass to produce biogas is a promising technology for bioenergy production. However, the methane yield from this anaerobic process was limited because of the hard cell wall of Chlorella vulgaris. The use of ultrasound has proven to be successful at improving the disintegration and anaerobic biodegradability of Chlorella vulgaris. Ultrasonic pretreatment in the range of 5–200 J ml⁻¹ was applied to waste microalgal biomass, which was then used for batch digestion. Ultrasound techniques were successful and showed higher soluble COD at higher applied energy. During batch digestion, cell disintegration due to ultrasound increased in terms of specific biogas production and the degradation rate. Compared to the untreated sample, the specific biogas production was increased in the ultrasound-treated sample by 90% at an energy dose of 200 J ml⁻¹. For the disintegrated samples, volatile solids reduction was also increased according to the energy input and degradation. These results indicate that the hydrolysis of microalgal cells is the rate-limiting step in the anaerobic digestion of microalgal biomass.     

Laboratory-scale ultrasound pre-treated digestion of sludge: Heat and energy balance

The objective of this work was to maximize the digestibility of biological sludge to elucidate the feasibility of a new sludge management strategy to recover good quality sludge for agricultural use. The combined effects of organic loading rates (from 0.7 to 2.8 g VS L⁻¹ d⁻¹) and the degree of disintegration by anaerobic digestion of sonicated activated sludge were discussed, and the thermal and energetic balances were evaluated. Despite low sonication inputs, sludge digestion performance improved in terms of solids degradation and biogas production depending on the soluble organic load. The biogas production by sonicated sludge was higher (up to 30%) with respect to the control. Filterability improved during digestion of sonicated sludge at medium OLR due to a significant abatement of the fines. Thermal balances indicated that sonication may be a proper system to guarantee self-sustaining WAS mesophilic digestion. Nevertheless, thickening is a pre-requisite to achieve a positive energy balance.     

Enzyme research and applications in biotechnological intensification of biogas production

Biogas technology provides an alternative source of energy to fossil fuels in many parts of the world. Using local resources such as agricultural crop remains, municipal solid wastes, market wastes and animal waste, energy (biogas), and manure are derived by anaerobic digestion. The hydrolysis process, where the complex insoluble organic materials are hydrolysed by extracellular enzymes, is a rate-limiting step for anaerobic digestion of high-solid organic solid wastes. Biomass pretreatment and hydrolysis are areas in need of drastic improvement for economic production of biogas from complex organic matter such as lignocellulosic material and sewage sludge. Despite development of pretreatment techniques, sugar release from complex biomass still remains an expensive and slow step, perhaps the most critical in the overall process. This paper gives an updated review of the biotechnological advances to improve biogas production by microbial enzymatic hydrolysis of different complex organic matter for converting them into fermentable structures. A number of authors have reported significant improvement in biogas production when crude and commercial enzymes are used in the pretreatment of complex organic matter. There have been studies on the improvement of biogas production from lignocellulolytic materials, one of the largest and renewable sources of energy on earth, after pretreatment with cellulases and cellulase-producing microorganisms. Lipids (characterised as oil, grease, fat, and free long chain fatty acids, LCFA) are a major organic compound in wastewater generated from the food processing industries and have been considered very difficult to convert into biogas. Improved methane yield has been reported in the literature when these lipid-rich wastewaters are pretreated with lipases and lipase-producing microorganisms. The enzymatic treatment of mixed sludge by added enzymes prior to anaerobic digestion has been shown to result in improved degradation of the sludge and an increase in methane production. Strategies for enzyme dosing to enhance anaerobic digestion of the different complex organic rich materials have been investigated. This review also highlights the various challenges and opportunities that exist to improve enzymatic hydrolysis of complex organic matter for biogas production. The arguments in favor of enzymes to pretreat complex biomass are compelling. The high cost of commercial enzyme production, however, still limits application of enzymatic hydrolysis in full-scale biogas production plants, although production of low-cost enzymes and genetic engineering are addressing this issue.     

Enzyme research and applications in biotechnological intensification of biogas production

Biogas technology provides an alternative source of energy to fossil fuels in many parts of the world. Using local resources such as agricultural crop remains, municipal solid wastes, market wastes and animal waste, energy (biogas), and manure are derived by anaerobic digestion. The hydrolysis process, where the complex insoluble organic materials are hydrolysed by extracellular enzymes, is a rate-limiting step for anaerobic digestion of high-solid organic solid wastes. Biomass pretreatment and hydrolysis are areas in need of drastic improvement for economic production of biogas from complex organic matter such as lignocellulosic material and sewage sludge. Despite development of pretreatment techniques, sugar release from complex biomass still remains an expensive and slow step, perhaps the most critical in the overall process. This paper gives an updated review of the biotechnological advances to improve biogas production by microbial enzymatic hydrolysis of different complex organic matter for converting them into fermentable structures. A number of authors have reported significant improvement in biogas production when crude and commercial enzymes are used in the pretreatment of complex organic matter. There have been studies on the improvement of biogas production from lignocellulolytic materials, one of the largest and renewable sources of energy on earth, after pretreatment with cellulases and cellulase-producing microorganisms. Lipids (characterised as oil, grease, fat, and free long chain fatty acids, LCFA) are a major organic compound in wastewater generated from the food processing industries and have been considered very difficult to convert into biogas. Improved methane yield has been reported in the literature when these lipid-rich wastewaters are pretreated with lipases and lipase-producing microorganisms. The enzymatic treatment of mixed sludge by added enzymes prior to anaerobic digestion has been shown to result in improved degradation of the sludge and an increase in methane production. Strategies for enzyme dosing to enhance anaerobic digestion of the different complex organic rich materials have been investigated. This review also highlights the various challenges and opportunities that exist to improve enzymatic hydrolysis of complex organic matter for biogas production. The arguments in favor of enzymes to pretreat complex biomass are compelling. The high cost of commercial enzyme production, however, still limits application of enzymatic hydrolysis in full-scale biogas production plants, although production of low-cost enzymes and genetic engineering are addressing this issue.     

Experiences with the dual digestion of municipal sewage sludge

The dual digestion process was investigated using sludge samples collected at the WWTP of Tomaszow Mazowiecki (Poland). Mixed sludge was treated in a laboratory setup under batch and semi-continuous conditions. Dual digestion with a 1d SRT aerobic thermophilic pretreatment followed by an anaerobic step with 20 d of SRT turned out to be optimal, since a 44-46% VS reduction and a biogas yield of 480 dm(3)/kg VS fed were achieved. In the course of the process, the concentration of nitrogen in supernatant increased over 5 times and its major portion was converted into ammonia. Phosphorus also entered the supernatant, reaching over 200 g/m(3). The dual digestion noticeably deteriorated the sludge dewaterability. Following completion of the process, capillary suction time measurements averaged 64 s for the raw sludge, 400 s for aerobically pretreated sludge and 310-360 for the anaerobically digested sludge. Aerobic pretreatment consistently reduced Enterobacteriaceae content to below detectable limits.     

Developments in pre-treatment methods to improve anaerobic digestion of sewage sludge

During wastewater treatment, most organic matter is transferred to a solid phase commonly known as sludge or biosolids. The high cost of sludge management and the growing interest in alternative energy sources have prompted proposals for different strategies to optimize biogas production during anaerobic sludge treatment. Because of the high solid content and complex structure of sludge-derived organic matter, methane production during digestion is limited at the hydrolysis step. Therefore, large digester volume and long retention times of over 20 days are necessary to achieve adequate stabilization. Pre-treatments can be used to hydrolyze sludge and consequently improve biogas production, solids removal and sludge quality after digestion. This paper reviews the main pre-treatment processes, with emphasis on the most recent developments. An overview of the different technologies is presented, discussing their effects on sludge properties and anaerobic digestion. Future challenges and concerns related to pre-treatment assessment and implementation are also addressed.     

Assessment of the influence of thermal pre-treatment time on the macromolecular composition and anaerobic biodegradability of sewage sludge

Laboratory and pilot-scale experiments were carried out in order to evaluate the influence of thermal pre-treatment time on waste-activated sludge properties and anaerobic biodegradability. Six experimental conditions were analyzed from 0 to 30 min of hydrolysis time. Solubilization of macromolecular compounds, changes in the main sludge properties and anaerobic biodegradability of the sewage sludge were evaluated. A similar carbohydrate solubilization degree was achieved, from 53% to 70% and 59% to 75% for lab- and pilot-scale experiments, respectively. In the case of proteins, the values of solubilization were lower in the pilot-scale experiment than in the laboratory, with 31-45% and 47-70%, respectively. Ammonia and volatile fatty acid did not undergo important changes; however the sludge dewaterability enhanced at increased pre-treatment times. All the pre-treatment conditions had a positive effect with regard to anaerobic biodegradability and by fitting experimental data with a simplified mathematical model, it was concluded that the maximum biogas production rate is more influenced by the pre-treatment time than the total biogas production.     

Sequential anaerobic/aerobic digestion of waste activated sludge: analysis of the process performance and kinetic study

Sequential anaerobic-aerobic digestion was applied to waste activated sludge (WAS) of a full scale wastewater treatment plant. The study was performed with the objective of testing the sequential digestion process on WAS, which is characterized by worse digestibility in comparison with the mixed sludge. Process performance was evaluated in terms of biogas production, volatile solids (VS) and COD reduction, and patterns of biopolymers (proteins and polysaccharides) in the subsequent digestion stages. VS removal efficiency of 40%, in the anaerobic phase, and an additional removal of 26%, in the aerobic one, were observed. For total COD removal efficiencies of 35% and 25% for anaerobic and aerobic stage respectively, were obtained. Kinetics of VS degradation process was analyzed by assuming a first order equation with respect to VS concentration. Evaluated kinetic parameters were 0.44 ± 0.20 d(-1) and 0.25 ± 0.15 d(-1) for the anaerobic stage and aerobic stage, respectively. With regard to biopolymers, in the anaerobic phase the content of proteins and polysaccharides increased to 50% and 69%, respectively, whereas in the subsequent aerobic phase, a decrease of 71% for proteins and 67% for polysaccharides was observed. The average specific biogas production 0.74 m(3)/(kg VS destroyed), was in the range of values reported in the specialized literature for conventional anaerobic mesophilic WAS digestion.     

Low temperature thermo-chemical pretreatment of dairy waste activated sludge for anaerobic digestion process

An investigation into the influence of low temperature thermo-chemical pretreatment on sludge reduction in a semi-continuous anaerobic reactor was performed. Firstly, effect of sludge pretreatment was evaluated by COD solubilization, suspended solids reduction and biogas production. At optimized condition (60 °C with pH 12), COD solubilization, suspended solids, reduction and biogas production was 23%, 22% and 51% higher than the control, respectively. Secondly, semi-continuous process performance was studied in a lab-scale semi-continuous anaerobic reactor (5 L), with 4 L working volume. With three operated SRTs, the SRT of 15 days was found to be most appropriate for economic operation of the reactor. Combining pretreatment with anaerobic digestion led to 80.5%, 117% and 90.4% of TS, SS and VS reduction respectively, with an improvement of 103% in biogas production. Thus, low temperature thermo-chemical can play an important role in reducing sludge production.     

Petroleum coke supplementation for enhanced biogas production and phosphate removal under mesophilic conditions

The use of carbon-based conductive materials has been shown to lead to an increase in biogas and methane yields during anaerobic digestion (AD). The effect of these additives on AD using synthetic substrates has been extensively studied, yet their significance for wastewater sludge digestion has not been adequately investigated. Therefore, the aim of this research was to optimize the concentration of petroleum coke (PC) that is a waste by-product of oil refineries, for the anaerobic digestion of wastewater sludge and investigation of phosphate removal in the AD process in the mesophilic temperature range. According to the results of the experiments, supplementing reactors with PC could significantly improve biogas and methane production. Supplementation of reactors with 1.5 g/L PC led to 23.40 ± 0.26% and 42.55 ± 3.97% increase in biogas production and methane generation, respectively. Moreover, the average volatile solids (VS), phosphate, and chemical oxygen demand (COD) removals were 43.43 ± 0.73, 46.74 ± 0.77%, and 60.40 ± 0.38%, respectively.     

Enhanced Methane Production from Anaerobic Digestion of Disintegrated and Deproteinized Excess Sludge

To improve biogas yield and methane content in anaerobic digestion of excess sludge from the wastewater treatment plant, the sludge was disintegrated by using various methods (sonication, alkaline and thermal treatments). Since disintegrated sludge contains a high concentration of soluble proteins, the resulting metabolite, ammonia, may inhibit methane generation. Therefore, the effects of protein removal from disintegrated sludge on methane production were also studied. As a result, an obvious enhancement of biogas generation was observed by digesting disintegrated sludge (biogas yield increased from 15 to 36 ml/g COD_added·day for the raw excess sludge and the sonicated sludge, respectively). The quality of biogas was also improved by removing proteins from the disintegrated sludge. About 50% (w/w) of soluble proteins were removed from the suspension of disintegrated sludge by salting out using 35 g MgCl₂·6H₂O/l and also by isoelectric point precipitation at pH 3.3. For deproteinized sludge, methane production increased by 19%, and its yield increased from 145 ml/g COD_removed to 325 ml/g COD_removed. Therefore, the yield and quality of biogas produced from digestion of excess sludge can be enhanced by disintegrating the sludge and subsequent protein removal. Revisions requested 14 November 2005; Revisions received 13 January 2006     

Effect of bioaugmentation of activated sludge with white-rot fungi on olive mill wastewater detoxification

AIMS: To test the potential use of Phanerochaete chrysosporium and other white-rot fungi to detoxify olive mill wastewaters (OMW) in the presence of a complex activated sludge. To combine the aerobic with anaerobic treatment to optimize the conversion of OMW in biogas. METHODS AND RESULTS: A 25-l air lift reactor was used to pretreat OMW by white-rot fungi. Detoxification of the OMW was monitored by size exclusion HPLC analysis, chemical oxygen demand (COD)/biological oxygen demand (BOD(5)) ratio evolution, and bioluminescence toxicity test. Anaerobic treatment of OMW was performed in a 12-l anaerobic filter reactor. Efficiency of the treatment was evaluated by organic matter removal, and biogas production. By comparison with the pretreatment by activated sludge only, the bioaugmentation with Phanerochaete chrysosporium or Trametes versicolor led to high removal of organic matter, decreased the COD/BOD(5) ratio and the toxicity. The subsequent anaerobic digestion of the OMW pretreated with activated sludge-white-rot fungi showed higher biomethanization yields than that pretreated with activated sludge only. Higher loading rates (7 g COD l(-1) day(-1)) were reached without any acidification or inhibition of biomethanization. CONCLUSIONS: The use of white-rot fungi, even in the presence of complex biological consortia to detoxify OMW, proved to be possible and made the anaerobic digestion of OMW for methane production feasible. SIGNIFICANCE AND IMPACT OF THE STUDY: The use of fungi for OMW reuse and energy production could be adapted to industrial applications.     

Ultrasonic sludge disintegration for enhanced methane production in anaerobic digestion: effects of sludge hydrolysis efficiency and hydraulic retention time

Hydrolysis of waste activated sludge (WAS) has been regarded as the rate limiting step of anaerobic sludge digestion. Therefore, in this study, the effect of ultrasound and hydraulic residence time during sludge hydrolysis was investigated with the goal of enhancing methane production from anaerobic digestion (AD). WAS was ultrasonically disintegrated for hydrolysis, and it was semi-continuously fed to an anaerobic digesters at various hydraulic retention times (HRTs). The results of these experiments showed that the solids and chemical oxygen demand (COD) removal efficiencies when using ultrasonically disintegrated sludge were higher during AD than the control sludge. The longer the HRT, the higher the removal efficiencies of solids and COD, while methane production increased with lower HRT. Sludge with 30% hydrolysis produced 7 × more methane production than the control sludge. The highest methane yields were 0.350 m(3)/kg volatile solids (VS)(add) and 0.301 m(3)/kg COD(con) for 16 and 30% hydrolyzed sludge, respectively. In addition, we found that excess ultrasound irradiation may inhibit AD since the 50% hydrolyzed sludge produced lower methane yields than 16 and 30% hydrolyzed sludge.     

Autohydrolysis pretreatment of secondary sludge for anaerobic digestion

The increase in the number of wastewater treatment plants and the quality required for the residue produced makes it necessary to improve the efficiency of anaerobic digestion of sludge. Pretreatments of secondary sludge have shown important advantages in the elimination of volatile solids and pathogenic microorganisms from the sludge, and they have also had a positive effect on biogas production. However, such methods are associated with high operating costs. This paper shows the behavior of a autohydrolysis pretreatment, which consists of subjecting the secondary sludge to a temperature of 55 °C for 12–24 h with a limited amount of oxygen under batch operation. The pretreatment results in a high solubilization of organic matter, increasing the fluidity of the sludge and improving the biogas production. This study focuses on the evaluation of the influence of oxygen and the initial sludge concentration on the pretreatment behavior. The main results obtained showed that when autohydrolysis pretreatment was carried out for 12 h, with a high solid concentration and microaerobic conditions, the solubilization of organic matter was increased by 40%, the methane productivity was improved by 23%, and there was an overall improvement in sludge fluidity. Moreover, the energy assessment of the autohydrolysis pretreatment and anaerobic digestion system showed the energetic feasibility of this treatment method, since the increase in energy production compensates for the extra energy required to carry out the pretreatment.     

Inhibition of Biogas Production by Alkyl Benzene Sulfonates (LAS) in a Screening Test for Anaerobic Biodegradability

The effect of the inoculum source on the digestion of linear alkylbenzene sulfonates (LAS) under anaerobic conditions has been investigated. The potential for primary and ultimate LAS biodegradation of anaerobic sludge samples obtained from wastewater treatment plants (WWTPs) of different geographical locations was studied applying a batch test system. It was found that only 4–22% of the LAS added to the batch anaerobic digesters was primarily transformed suggesting a poor primary degradation of the LAS molecule in anaerobic discontinuous systems. Regarding ultimate biodegradation, the addition of LAS to the batch anaerobic digesters caused a reduction on the extent of biogas production. Significant differences in the inhibition extent of the biogas production were observed (4–26%) depending on the sludge used as inoculum. Effect of the surfactant on the anaerobic microorganisms was correlated with its concentration in the aqueous phase. Sorption of LAS on anaerobic sludge affects its toxicity by depletion of the available fraction of the surfactant. LAS content on sludge was related to the total amount of calcium and magnesium extractable ions. The presence of divalent cations promote the association of LAS with anaerobic sludge reducing its bioavailability and the extent of its inhibitory effect on the biogas production.     

Peracetic acid oxidation as an alternative pre-treatment for the anaerobic digestion of waste activated sludge

Anaerobic digestion is generally considered to be an economic and environmentally friendly technology for treating waste activated sludge, but has some limitations, such as the time it takes for the sludge to be digested and also the ineffectiveness of degrading the solids. Various pre-treatment technologies have been suggested to overcome these limitations and to improve the biogas production rate by enhancing the hydrolysis of organic matter. This paper studies the use of peracetic acid for disintegrating sludge as a pre-treatment of anaerobic digestion. It has been proved that this treatment effectively leads to a solubilisation of organic material. A maximum increase in biogas production by 21% is achieved. High dosages of PAA lead to a decrease in biogas production. This is due to the inhibition of the anaerobic micro-organisms by the high VFA-concentrations. The evolution of the various VFAs during digestion is studied and the observed trends support this hypothesis.     

Degradation and characteristic changes of organic matter in sewage sludge using microbial fuel cell with ultrasound pretreatment

Microbial fuel cell (MFC) could be an efficient sludge treatment unit in regard of rates and extents of total chemical oxygen demand (TCOD) removal, particularly when ultrasound was applied to pretreat the sludge. This study characterized the organic matter in sludge before and after MFC treatment, with or without ultrasound as a pretreatment stage. The 5-d MFC tests with electric load significantly enhanced TCOD removal rate from 11.3% to 19.2% for raw sludge and from 25% to 57% for sludge pretreated with >0.6 W ml^?1 ultrasound, using conventional anaerobic digestion test (without electric load) as control. The aromatic proteins, soluble microbial byproduct-like fluorescent compounds and carboxylic components, aliphatic components (C–H related), hydrocarbon and carbohydrate materials were identified to be principally released by ultrasound pretreatment and the fuels in the present MFC study.     

城市污泥中邻苯二甲酸酯(PAEs)的厌氧微生物降解

邻苯二甲酸酯(PAEs)是城市污泥中普遍存在的一类具有内分泌干扰性作用的有机污染物.研究污泥厌氧生物处理过程中PAEs的微生物降解对保障污泥农用的安全性十分必要.本文以污泥中两种主要的PAEs——邻苯二甲酸二丁酯(DBP)和邻苯二甲酸(2-乙基己)酯(DEHP)为研究对象,通过比较PAEs在污泥厌氧消化系统与发酵产氢系统中降解过程的差异及系统污泥特性的变化,分析不同污泥厌氧生物处理系统中影响PAEs降解的可能因素.结果表明: 在污泥厌氧发酵系统中,DBP在6 d内降解率达99.6%, DEHP在整个14 d的培养期间也降解了46.1%;在发酵产氢系统中,在14 d培养过程DBP的降解率仅为19.5%,DEHP则没有明显的降解.与厌氧消化系统相比,PAEs在发酵产氢系统中的降解受到明显抑制,这与发酵产氢过程中微生物量下降、革兰氏阳性菌/革兰氏阴性菌(G⁺/G^-)和真菌/细菌变小及挥发性脂肪酸(包括乙酸、丙酸及丁酸)浓度升高有关.     

Effect of microaerobic conditions on the degradation kinetics of cellulose

Limited oxygen supply to sludge digesters has shown to be an effective method to eliminate hydrogen sulfide from the biogas produced during anaerobic digestion but uneven results have been found in terms of the effect on the degradation of complex organic matter. In this study, the effect that the limited oxygen supply provoked on the “anaerobic” degradation of cellulose was evaluated in batch-tests. The microaerobic assays showed to reach a similar maximum production of methane than the anaerobic ones after 19 d and a similar hydrolytic activity (considering a first order rate constant); however, the microaerobic assays presented a shorter lag-phase time than the anaerobic test resulting in faster production of methane during the first steps of the degradation; specifically, the maximum methane production found in the anaerobic test in 19 d was found in the microaerobic test before the day 15.