糠醛对粘红酵母生长与油脂积累的影响

为了探究纤维素水解液中常见的发酵抑制物糠醛对粘红酵母Rhodotorula glutinis生长与油脂积累的影响,对比了不同的糠醛浓度(0.1、0.4、0.6、1.5 g/L)下粘红酵母的生物量和油脂积累情况,并探究了1.0 g/L的糠醛对粘红酵母不同碳源(葡萄糖和木糖)利用的影响。研究表明,当糠醛浓度达1.5 g/L时,粘红酵母的延迟期延长至96 h,残糖高达17.7 g/L,生物量最高6.6 g/L,仅为正常积累量的47%,油脂含量也减少了约50%;以木糖为碳源时,糠醛对粘红酵母的抑制程度小于葡萄糖为碳源时的情况;在糠醛存在的逆境中,粘红酵母倾向于生成更多的18碳脂肪酸或18碳不饱和脂肪酸。     

发酵性丝孢酵母HWZ004利用水稻秸秆水解液发酵产油脂

为高效利用水稻秸秆中的纤维素和半纤维素产油脂,采用稀酸预处理和酶水解两步法对水稻秸秆进行水解,然后以水解液为碳源,培养发酵性丝孢酵母Trichosporon fermentans HWZ004产微生物油脂。结果表明,经简单overliming法脱毒后水稻秸秆水解液中乙酸、糠醛和5-羟甲基糠醛的浓度分别为0.4 g/L、0.1 g/L和0.05 g/L。只需添加少量氮源和微量CuSO4?5H2O,该水解液即可满足T. fermentans HWZ004发酵产油脂的要求。发酵最适接种量、初始pH和温度分别是5.0％、7.0和25 ℃。T. fermentans HWZ004在优化条件下培养7 d的生物量、油脂含量和油脂产量分别是26.4 g/L,52.2％和13.8 g/L;油脂得率系数为17.0,大大高于驯化前菌株T. fermentans CICC 1368在脱毒水稻秸秆半纤维素水解液中的对应值 (11.9)。所产油脂的脂肪酸组成与植物油相似,不饱和脂肪酸含量达70％以上,宜作为生物柴油的生产原料。     

云南程海湖冬季酵母菌多样性及胞外酶活性研究

采用过滤涂皿的方法对云南程海湖冬季湖水样品中的酵母菌进行分离,通过26S r DNA D1/D2区域序列分析并结合形态观察和生理生化测试对分离获得的菌株进行鉴定,同时采用胞外酶定性筛选培养基进行产酶活性筛选,分析冬季程海湖酵母菌的多样性及胞外酶活性。结果从程海湖中分离获得171株酵母菌,鉴定为14个属22个种和2个潜在的新分类单元;优势属是红冬孢酵母属Rhodosporidium、红酵母属Rhodotorula和隐球酵母属Cryptococcus;优势种是红冬孢酵母Rhodosporidium kratochvilovae和斯鲁菲亚红酵母Rhodotorula slooffiae;湖北半部的样点CH2的多样性指数(H′=1.5945)和丰富度指数(R=2.7576)均最高,均匀度指数较高的是湖北部的样点CH1(J=0.8531);样点之间种群差异大,相似性低。大多数酵母菌株具有产1种以上的胞外酶。     

云南抚仙湖产类胡萝卜素酵母菌的资源调查

【目的】对分离自云南抚仙湖湖水的379株酵母菌进行产类胡萝卜素的筛选,以期获得具有开发应用价值的产类胡萝卜素酵母菌。【方法】采用酸热法提取类胡萝卜素,紫外分光光度计测定类胡萝卜素含量,SPSS软件分析产类胡萝卜素酵母的分布特征。【结果】318株酵母菌(占供试菌株的83.91%)具有产类胡萝卜素的能力,大多数菌株类胡萝卜素产量在10-300μg/g之间,最高达590.83μg/g。产类胡萝卜素酵母集中分布于红冬孢酵母属(Rhodosporidium)和红酵母属(Rhodotorula);担子菌酵母产类胡萝卜素的能力高于子囊菌酵母;筛选到9株产类胡萝卜素活性较强的菌株:双倒卵形红冬孢酵母(Rhodosporidium diobovatum)3株、沼泽生红冬孢酵母(Rhodosporidium paludigenum)2株、粘红酵母(Rhodotorula glutinis)、禾本红酵母(Rhodotorula graminis)、瑞纳锁掷孢酵母(Sporidiobolus ruineniae)及Cystofilobasidium macerans各1株。【结论】高原湖泊抚仙湖生存着大量产类胡萝卜素的酵母菌,"红色酵母"(Red yeasts)具有较强的产类胡萝卜素的能力,红冬孢酵母属(Rhodosporidium)和红酵母属(Rhodotorula)是抚仙湖产类胡萝卜素酵母菌的主要类群。     

红酵母的抗氧化机制与高产类胡萝卜素菌株的筛选*

通过聚丙烯酰胺凝胶电泳(PAGE)和超氧化物歧化酶(SOD)的鉴别性定位染色分析,表明红酵母Rhodotorula sp.仅存在线粒体中的Mn-SOD。在类胡萝卜素含量较高的时期(培养5d),红酵母SOD活力下降, 过氧化氢酶(CAT)活力升高,而此时它对外界O2-. 和H2O2的抗性均明显高于类胡萝卜素含量较低的时期(培养2d)。以上结果表明红酵母胞质中的抗氧化作用已主要由类胡萝卜素来承担,类胡萝卜素含量越高,红酵母抗氧化能力越强。由此,利用产生的O2-. 试剂TBO处理红酵母,可筛选出稳定高产的类胡萝卜素菌株,其中以培养2d的红酵母作为筛选对象更佳,所筛菌落类胡萝卜素含量可高达1740.9~2039.2g/g干重,比未处理的对照增加了28.2%~50.1%。     

低能离子修饰多不饱和脂肪酸产生菌株的研究北大核心CSCD

为得到多不饱和脂肪酸高产菌株,通过氮离子注入产油粘红酵母(Rhodotorula glutinis),对其进行辐照诱变,发现当注入能量为10 keV时,注入剂量80×2.6×1013ion/cm2为最佳诱变参数。然后,采用含有脂肪酸合成酶抑制剂cerulenin的培养基对高产油脂粘红酵母进行初筛,并研究了cerulenin对粘红酵母细胞的抑制作用,结果表明,当cerulenin的浓度达到11.20×10-6mol/L时,抑制率为90%,可以作为筛选浓度,利用酸热耦合超生波法和索氏抽提法验证了cerulenin筛选菌株的准确性。最终筛选出一株油脂产量比出发菌株提高32%的高产菌株D30,经多次传代实验表明,该菌株遗传稳定性较好。气相色谱分析其油脂组成,结果表明多不饱和脂肪酸含量为28.07%。     

尼罗红染色法筛选产油酵母及定量检测胞内油脂含量的研究

【目的】建立产油酵母筛选以及胞内油脂含量测定的简便方法。【方法】利用尼罗红与胞内油脂成分结合后在紫外光照射下发出荧光且荧光强弱与油脂含量相关的原理。通过在添加尼罗红的培养基中培养酵母,并观察菌落荧光的方法对385株深海酵母进行产油脂菌株筛选,利用26S rDNA D1/D2区序列分析方法对筛选获得的产油酵母菌株进行鉴定,并以其中的一株高产油脂酵母(2A00015)为试验菌株,建立了一套尼罗红染色快速测定油脂含量的方法。【结果】获得22株产油酵母,其中油脂含量最高可达62.9%,经分子鉴定后显示这22株酵母分别属于(Candida viswanathii)、近平滑假丝酵母(Candidaparapsilosis)、粘质红酵母(Rhodotorula mucilaginosa)、汉逊德巴利酵母(Debaryomyceshansenii)、季也蒙毕赤酵母(Pichia guilliermondii)以及Rhodosporidium paludigenum酵母。尼罗红染色快速测定油脂含量方法的最佳检测条件为:菌悬液OD600小于1.2,尼罗红浓度0.5 mg/L,染色时间5 min,激发波长488 nm,发射波长570 nm。该测定方法得到相对荧光强度与称重法得到油脂含量呈正相关性,R2=0.9637。     

不对称还原苯乙酮的酵母菌株筛选与分子鉴定

利用苯乙酮作为模式底物,对145株菌株进行初筛和复筛,获得一株具有高效立体选择性的酵母菌株YS6-2,能够不对称还原苯乙酮生成(S)-1-苯基乙醇.在苯乙酮浓度为70mmol/L时,底物的初始转化率达26.8%,产物(S)-1-苯基乙醇的对映体过量值为98.8%.基于形态学、生理生化特征、18S rDNA和26S rDNA D1/D2区域的分析表明,YS6-2为胶红酵母(Rhodotorula muci-laginosa).     

拜氏梭菌13-2发酵甘蔗渣水解液生产丁醇的研究

目的:蔗渣是一种重要的可再生生物质资源,蔗渣原料生产丁醇将大大降低丁醇的成本.方法:实验利用0.25 ～3.0%不同浓度稀H2SO4对蔗渣进行121℃的高温作用1h,以水解液为碳源,进行丁醇的发酵实验.结果:相对于8052菌株,13 -2菌株对甘蔗渣水解液具有更高的发酵效率,在0.5%硫酸用量条件下,13 -2菌株的丁醇发酵量最高,达到4.5g/L.而8052只有2.3g/L的丁醇发酵量.结论:在同等条件下,拜氏梭菌菌株13 -2比模式菌株8052具有更高的溶剂产量和抑制物耐受能力,最佳的蔗渣水解条件为1.5%硫酸用量,丁醇发酵量和总溶剂分别为4.57g/L和5.41 g/L.     

圆红冬孢酵母基因编辑及天然产物合成的研究进展

圆红冬孢酵母(Rhodotorula toruloides)是一种能够天然合成多种类胡萝卜素和油脂的非模式酵母。该菌能够利用各种廉价原料,耐受甚至同化利用多种有毒木质纤维素水解副产物。目前,该酵母被广泛用于微生物油脂、萜烯类化合物、各种高价值酶、糖醇和聚酮化合物的生产研究。鉴于其广阔的工业应用前景,研究人员对其开展了多维度的理论和技术的探索,包括基因组、转录组、蛋白组、遗传操作平台等。本文着重阐述近年来圆红冬孢酵母的代谢工程和天然产物合成的研究进展,并展望其细胞工厂构建中面临的挑战和可能的应对决策。     

Pyrolysis of olive residue and sugar cane bagasse: non-isothermal thermogravimetric kinetic analysis

Thermal degradation and kinetics for olive residue and sugar cane bagasse have been evaluated under dynamic conditions in the presence of nitrogen atmosphere, using a non-isothermal thermogravimetric method (TGA). The effect of heating rate was evaluated in the range of 2-50 K min(-1) providing significant parameters for the fingerprinting of the biomass. The DTG plot for the olive residue and sugar cane bagasse clearly shows that the bagasse begins to degrade at 473 K and exhibits two major peaks. The initial mass-loss was associated with hemicellulose pyrolysis and responsible for the first peak (538-543 K) whereas cellulose pyrolysis was initiated at higher temperatures and responsible for the second peak (600-607 K). The two biomass mainly devolatilized around 473-673 K, with total volatile yield of about 70-75%. The char in final residue was about 19-26%. Mass loss and mass loss rates were strongly affected by heating rate. It was found that an increase in heating rate resulted in a shift of thermograms to higher temperatures. Ozawa-Flynn-Wall and Vyazovkin methods were applied to determine apparent activation energy to the olive residue and sugar cane bagasse. Two different steps were detected with apparent activation energies in the 10-40% conversion range have a value of 153-162 kJ mol(-1) and 168-180 kJ mol(-1) for the hemicellulose degradation of olive residue and sugar cane bagasse, respectively. In the 50-80% conversion range, this value is 204-215 kJ mol(-1) and 231-240 kJ mol(-1) for the cellulose degradation of olive residue and sugar cane bagasse, respectively.     

Evaluation of holocellulase production by plant-degrading fungi grown on agro-industrial residues

Agaricus brasiliensis CS1, Pleurotus ostreatus H1 and Aspergillus flavus produced holocellulases when grown in solid and submerged liquid cultures containing agro-industrial residues, including sugar cane bagasse and dirty cotton residue, as substrates. These isolates proved to be efficient producers of holocellulases under the conditions used in this screening. Bromatological analysis of agro-industrial residues showed differences in protein, fiber, hemicellulose, cellulose and lignin content. Maximal holocellulase activity (hemicellulase, cellulase and pectinase) was obtained using solid-state cultivation with 10% substrate concentration. In this case, remarkably high levels of xylanase and polygalacturonase activity (4,008 and 4,548 IU/l, respectively) were produced by A. flavus when grown in media containing corn residue, followed by P. ostreatus H1 with IU/l values of 1,900 and 3,965 when cultivated on 5% and 10% sugar cane bagasse, respectively. A. brasiliensis CS1 showed the highest reducing sugar yield (11.640 mg/ml) when grown on medium containing sugar cane bagasse. A. brasiliensis was also the most efficient producer of protein, except when cultivated on dirty cotton residue, which induced maximal production in A. flavus. Comparison of enzymatic hydrolysis of sugar cane bagasse and dirty cotton residue by crude extracts of A. brasiliensis CS1, P. ostreatus H1 and A. flavus showed that the best reducing sugar yield was achieved using sugar cane bagasse as a substrate.     

酵母发酵蔗渣半纤维素水解物生产木糖酶

采用二次正交旋转组合设计研究了蔗渣半纤维素水解过程中硫酸浓度与液 固比对木糖收率的影响。回归分析表明 ,这两个因素与木糖的收率之间存在显著的回归关系。通过回归方程优化水解条件 ,当硫酸浓度 2 .4g L ,液 固 =6 .2 ,在蒸汽压力 2 .5× 10 4Pa的条件下水解 2 .5h ,10 0g蔗渣可水解生成木糖约 2 4g。大孔树脂吸附层析处理蔗渣半纤维素水解物 ,能有效地减少其中的酵母生长抑制物含量 ,显著改善水解物的发酵性能。用大孔树脂在pH 2条件下处理过的蔗渣半纤维素水解物作基质 ,含木糖 2 0 0g L ,产木糖醇酵母菌株CandidatropicalisAS2 .1776发酵 110h耗完基质中的木糖 ,生成木糖醇 12 7g L ,产物转化率 0 .6 4(木糖醇g 木糖g) ,产物生成速率 1.15g L·h .     

Radiation and fermentation treatment of cellulosic wastes

The effect of radiation pasteurization of sugar cane bagasse and rice straw and fermentation using various strains of fungi were studied for upgrading of cellulosic wastes. The initial contamination by fungi and aerobic bacteria both in bagasse and straw was high. The doses of 30 kGy for sterilization and 8 kGy for elimination of fungi were required. Irradiation effect showed that rice straw contained comparatively radioresistant microorganisms. It was observed that all the fungi (Hericium erinacium, Pleurotus djamor, Ganoderma lucidum, Auricularia auricula, Lentinus sajor-caju, Coriolus versicolor, Polyporus arcularius, Coprinus cinereus) grow extending over the entire substrates during one month after inoculation in irradiated bagasse and rice straw with 3% rice bran and 65% moisture content incubated at 30°C. Initially, sugar cane bagasse and rice straw substrates contained 39.4% and 25.9% of cellulose, 22.9% and 26.9% of hemicellulose, and 19.6% and 13.9% of lignin + cutin, respectively. Neutral detergent fibre (NDF) values decreased significantly in sugar cane bagasse fermented byG. lucidum, A. auricula andP. arcularius, and in rice straw fermented by all the 8 strains of fungi. Acid detergent fibre (ADF) values also decreased in bagasse and rice straw fermented by all the fungi.P. arcularius, H. erinacium, G. lucidum andC. cinereus were found to be the most effective strains for delignification of sugar cane bagasse.     

Effects of Ca(OH)(2) treatments ("overliming") on the composition and toxicity of bagasse hemicellulose hydrolysates

Hemicellulose syrups from dilute sulfuric acid hydrolysates of hemicellulose contain inhibitors that prevent efficient fermentation by yeast or bacteria. It is well known that the toxicity of these hydrolysate syrups can be ameliorated by optimized "overliming" with Ca(OH)(2). We have investigated the optimization of overliming treatments for sugar cane bagasse hydrolysates (primarily pentose sugars) using recombinant Escherichia coli LY01 as the biocatalyst. A comparison of composition before and after optimal overliming revealed a substantial reduction in furfural, hydroxymethylfurfural, and three unidentified high-performance liquid chromatography (HPLC) peaks. Organic acids (acetic, formic, levulinic) were not affected. Similar changes have been reported after overliming of spruce hemicellulose hydrolysates (Larsson et al., 1999). Our studies further demonstrated that the extent of furan reduction correlated with increasing fermentability. However, furan reduction was not the sole cause for reduced toxicity. After optimal overliming, bagasse hydrolysate was rapidly and efficiently fermented (>90% yield) by LY01. During these studies, titration, and conductivity were found to be in excellent agreement as methods to estimate sulfuric acid content. Titration was also found to provide an estimate of total organic acids in hydrolysate, which agreed well with the sum of acetic, levulinic, and formic acids obtained by HPLC. Titration of acids, measurement of pH before and after treatment, and furan analyses are proposed as relatively simple methods to monitor the reproducibility of hydrolysate preparations and the effectiveness of overliming treatments.     

Enthalpy content as a function of lipid accumulation in Rhodotorula glutinis

Microcalorimetry has been demonstrated to be a suitable on-line method for monitoring the lipid production phase of oleaginous yeasts. The choice of lipid extraction method for the oil accumulated by oleaginous yeasts is highly important both for accuracy when quantifying the lipid level and determining the fatty acid composition. The energy content of Rhodotorula glutinis increased from 23.0 kJ/g to 30.6 kJ/g dry biomass during the lipid-accumulating phase and was directly correlated to the analysed level of lipids, when an alkaline hydrolysis extraction method was used. Consequently, bomb-calorimetric measurements of the energy content were shown to be an indirect method of quantifying the lipid content in oleaginous yeasts. The fatty acid composition remained rather constant during the batch growth of Rh. glutinis with approximately 70% unsaturated C18 fatty acids. The high energy content as well as the fatty acid composition of Rh. glutinis makes this yeast a better candidate for use as aquaculture feed compared with the commonly used Saccharomyces cerevisiae.     

Mixed culture of oleaginous yeast Rhodotorula glutinis and microalga Chlorella vulgaris for lipid production from industrial wastes and its use as biodiesel feedstock

A mixed culture of oleaginous yeast Rhodotorula glutinis and microalga Chlorella vulgaris was performed to enhance lipid production from industrial wastes. These included effluent from seafood processing plant and molasses from sugar cane plant. In the mixed culture, the yeast grew faster and the lipid production was higher than that in the pure cultures. This could be because microalga acted as an oxygen generator for yeast, while yeast provided CO(2) to microalga and both carried out the production of lipids. The optimal conditions for lipid production by the mixed culture were as follows: ratio of yeast to microalga at 1:1; initial pH at 5.0; molasses concentration at 1%; shaking speed at 200 rpm; and light intensity at 5.0 klux under 16:8 hours light and dark cycles. Under these conditions, the highest biomass of 4.63±0.15 g/L and lipid production of 2.88±0.16 g/L were obtained after five days of cultivation. In addition, the plant oil-like fatty acid composition of yeast and microalgal lipids suggested their high potential for use as biodiesel feedstock.     

Monitoring on-line desalted lignocellulosic hydrolysates by microdialysis sampling micro-high performance anion exchange chromatography with integrated pulsed electrochemical detection/mass spectrometry

An on-line system based on microdialysis sampling (MD), micro-high performance anion exchange chromatography (micro-HPAEC), integrated pulsed electrochemical detection (IPED), and electrospray ionization mass spectrometry (MS) for the monitoring of on-line desalted enzymatic hydrolysates is presented. Continuous monitoring of the enzymatic degradation of dissolving pulp from Eucalyptus grandis as well as degradation of sugar cane bagasse in a 5-mL reaction vessel was achieved up to 24 h without any additional sample handling steps. Combining MD with micro-HPAEC-IPED/MS and on-line desalting of hydrolysates enabled injection (5 microL) of at least 23 samples in a study of the sequential action of hydrolytic enzymes in an unmodified environment where the enzymes and substrate were not depleted due to the perm-selectivity of the MD membrane (30 kDa cut-off). Xylanase, phenolic acid esterase and a combination of endoglucanase (EG II) with cellobiohydrolase (CBH I) resulted in the production of DP 1 after the addition of esterase, DP 2 and DP 3 after the addition of EG II and CBH I, from the dissolving pulp substrate. Similar sequential enzyme addition to sugar cane bagasse resulted in DP 1 production after the addition of esterase and DP 1, DP 2 and DP 3 production after the addition of the EG II and CBH I mixture. Combining MS on-line with micro-HPAEC-IPED proved to be a versatile and necessary tool for such a study compared to conventional methods. The mass selectivity of MS revealed complementary information, including the co-elution of saccharides as well as the presence of more than one type of DP 2 in the case of dissolving pulp and several types of DP 2 and DP 3 for sugar cane bagasse. This study demonstrates the limitation of the use of retention time alone for confirmation of the identity of saccharides especially when dealing with complex enzymatic hydrolysates. In situ sampling and sample clean-up combined with on-line desalting of the chromatographic effluent, provides a generic approach to achieve real time monitoring of enzymatic hydrolysates when they are detected by a combination of IPED and MS.     

Composition of sugar cane,energy cane,and sweet sorghum suitable for ethanol production at Louisiana sugar mills

A challenge facing the biofuel industry is to develop an economically viable and sustainable biorefinery. The existing potential biorefineries in Louisiana, raw sugar mills, operate only 3 months of the year. For year-round operation, they must adopt other feedstocks, besides sugar cane, as supplemental feedstocks. Energy cane and sweet sorghum have different harvest times, but can be processed for bio-ethanol using the same equipment. Juice of energy cane contains 9.8% fermentable sugars and that of sweet sorghum, 11.8%. Chemical composition of sugar cane bagasse was determined to be 42% cellulose, 25% hemicellulose, and 20% lignin, and that of energy cane was 43% cellulose, 24% hemicellulose, and 22% lignin. Sweet sorghum was 45% cellulose, 27% hemicellulose, and 21% lignin. Theoretical ethanol yields would be 3,609 kg per ha from sugar cane, 12,938 kg per ha from energy cane, and 5,804 kg per ha from sweet sorghum.     

Fermentation of sugar cane bagasse hemicellulose hydrolysate to l(+)-lactic acid by a thermotolerant acidophilic Bacillus sp.**

Sugar cane bagasse hemicellulose, hydrolyzed by dilute H2SO4, supplemented with mineral salts and 0.5% corn steep liquor, was fermented to L(+)-lactic acid using a newly isolated strain of Bacillus sp. In batch fermentations at 50 degrees C and pH 5, over 5.5% (w/v) L(+)-lactic acid was produced (89% theoretical yield; 0.9 g lactate per g sugar) with an optical purity of 99.5%.