中药非药用部位栽培灵芝的活性成分及药效变化

【目的】以丹参(Salvia miltiorrhiza Bge.)、菊花(Chrysanthemum morifolium Ramat.)、桔梗(Ptatycodongrandiflorum A.DC.)3种中药材的非药用部位作为灵芝袋料栽培的原料,研究灵芝子实体活性成分及药效变化。【方法】试验比较测定了非药用部位配方组与常规组(常规组作为实验对照组,配方由玉米芯、棉籽壳等常规基质组成)的灵芝农艺性状,子实体多糖和三萜含量,并对各组灵芝进行了小鼠急性毒性试验及药效试验。【结果】结果表明,非药用部位栽培灵芝生物转化率接近或者高于常规组,生长周期有所延长;活性成分上,除了丹参组(SM.G)的三萜含量有所降低外,其余各组的活性成分较常规配方组(OF.G)均有提高,菊花组(CM.G)灵芝的多糖和三萜含量最高,分别为2.47%和0.79%。最大耐受量试验表明,非药用部位栽培的灵芝子实体的小鼠最大耐受量均为100 g/kg。溶血素试验和促睡眠试验中菊花组效果优于常规组灵芝;抗疲劳上,只有常规组灵芝表现出一定的抗疲劳功效,而非药用部位栽培的灵芝没有该药效。【结论】中药材非药用部位栽培灵芝是可行的,且子实体活性成分含量和部分药效发生了改变。     

响应面法优化以桑枝为主要基质的灵芝栽培配方

目的利用响应面法对以桑枝为主要成分的灵芝栽培培养基配方进行优化。方法以苯酚-硫酸法测定灵芝子实体中的多糖含量为指标,通过Plackett-Burman(PB)实验筛选出影响栽培灵芝子实体多糖含量的主要因素,然后用最陡爬坡试验、中心组合设计和响应面法对影响灵芝多糖含量的显著因素进行优化,利用以栽培灵芝子实体中多糖含量为响应值建立的二次回归方程模型,确定主要影响因素的最佳浓度,得到可大幅度提高灵芝子实体中多糖含量的最佳发酵培养基配方。结果确定了以桑枝为主要基质的优化后栽培培养基配方:65%桑枝屑,25%中药渣,4%玉米粉,1%蔗糖,1%石膏粉,4%麸皮,0.1%KH_2PO_4,0.1%MgSO_4·7H_2O,0.01%VB1。验证实验表明使用优化后的培养基生产的灵芝子实体中的多糖含量高达8.35%,是基础培养基生产的灵芝子实体多糖含量(3.17%)的2.63倍。结论对灵芝栽培培养基配方采用响应面中心组合设计,可以有效地对栽培培养基进行优化。     

金针菇栽培基质替代原料初步筛选研究

针对近年金针菇栽培主要原料棉籽壳价格大幅度上涨,导致栽培成本不断增加、栽培经济效益不断下滑的现实问题,在以棉籽壳为主要栽培料配方（CK1）的基础上,用新型基质花生壳、木屑、玉米芯、油菜杆、黄豆杆、猕猴桃枝、桑枝屑、高粱壳等资源部分替代棉籽壳,设计了8个金针菇栽培料配方,并以常用配方CK2为辅助对照,进行金针菇（川金3号）栽培试验。结果表明,配方6（花生壳）的产量虽未超过对照CK2,但其产量显著高于对照CK1（高33.11%）,转化率达到对照CK2的水平,其栽培效益超过对照CK1（高629.03%）和CK2（高15.90%）,且子实体品质好,所以在成都平原冬末早春季出菇时,用30%的花生壳替代棉籽壳栽培金针菇,可以显著降低材料成本,增加栽培效益。     

荷叶离褶伞优良菌株筛选

以棉籽壳、木屑、玉米芯等为主料设计了10个栽培配方,研究不同配方下7株荷叶离褶伞的菌丝生长和出菇情况。结果表明,各菌株菌丝颜色以雪白色为主,在玉米芯为主料的配方上菌丝体生长优于以棉籽壳、木屑为主料的配方,但均无子实体形成;以棉籽壳为主料有利于子实体的形成,特别是棉子壳添加少量木屑、树叶、腐殖土、发酵料和小麦更利于子实体形成,菌株3001的出菇周期最短（108d）,产量最高（214.80g/袋）,各菌株出菇的顺序为3001、1035、1004和1013。因此,栽培料组分对荷叶离褶伞菌丝生长及子实体形成影响较大。     

莲子壳主料对代栽灵芝生长及其生产效益的影响

莲子壳作为农业副产物体量较大,可用作食用菌栽培原料。本研究以资源化利用莲子壳和拓展灵芝栽培原料来源、降本增效为目的,以10%、20%、40%、60%和80%的莲子壳替代基础配方(杂木屑45%、玉米芯45%、麦麸5%、玉米粉4%、石膏1%)的木屑和玉米芯,研究各试验配方的灵芝农艺性状、品质及生产效益,从中优选出莲子壳基质高效配方,为探究莲子壳在代料灵芝生产中的应用提供依据。结果表明,培养料添加一定比例莲子壳可促进灵芝菌丝生长,60%处理的菌丝生长速度最快,达4.44mm/d;基料添加莲子壳会减少菌柄长度、菌盖厚度和子实体含水量,对菌盖大小、菌柄直径和单朵鲜重无明显影响。活性成分测定结果表明,随栽培料莲子壳比例的增加,灵芝子实体多糖和蛋白质含量明显增加,80%处理的多糖含量(10.57mg/g)是对照的1.66倍、蛋白质含量(15.14%)显著高于对照(14.12%);而栽培料莲子壳对灵芝子实体三萜酸的影响呈“低比例促进、高比例抑制”趋势。另外,莲子壳配方会显著提高灵芝子实体氨基酸总量,以10%处理最高,氨基酸总量为32.44%,该处理检测到13种氨基酸的含量最高值。生产效益分析表明,栽培...     

不同栽培基质对肺形侧耳营养成分及呈味物质的影响

以3种林木枝条废弃物（金银花、松木、杨木）作为栽培基质,对4株综合性状较优异的肺形侧耳菌株进行栽培,测定不同栽培基质的肺形侧耳子实体中粗蛋白、水解氨基酸、游离氨基酸、总糖及5′-核苷酸组成与含量,研究不同菌株、不同栽培基质下肺形侧耳子实体营养成分及呈味物质的含量,以柞木+棉籽壳传统栽培基质作为对照。结果表明不同菌株之间、不同栽培基质之间肺形侧耳子实体的营养成分及呈味物质都具显著差异,其中以金银花作为栽培基质时,菌株P2、P3、P45子实体粗蛋白和水解氨基酸含量在4种基质中最高;以松木作为栽培基质时其游离氨基酸总量在4种基质中普遍最高;所有样品中的等鲜浓度值（EUC）范围为67.91-146.13g MSG/100g,其中以金银花为基质的菌株P3子实体EUC值最高,而以柞木+棉籽壳为基质的菌株P7子实体EUC值最低。本研究可为基于各地农林废弃物开展肺形侧耳的栽培生产提供一定的理论指导。     

牛蒡木屑栽培赤芝子实体多糖含量的检测及其配方筛选

为充分利用牛蒡和食药真菌资源,以不同体积比的牛蒡木屑为基质进行赤芝Ganoderma lingzhi栽培。测定不同条件下生长的赤芝子实体多糖含量,从而确定赤芝最优栽培条件。试验结果表明:当栽培基质中牛蒡与木屑体积比1∶4、温度28℃、固液比为20∶0时赤芝子实体多糖含量最高。用此栽培基质,在子实体形成期间,光照条件为暗光、p H=5～6、湿度90%～95%、培育45～60 d,子实体长势最好,形态最佳,其多糖含量可达23.26 mg/g。     

猴头菌不同发育阶段产生的多糖结构特征及免疫活性

采收猴头菌Hericium erinaceus 7个不同发育阶段的子实体,经热水浸提后分别采用20%、50%、70%的乙醇终浓度进行分级沉淀,获得21个多糖组分,对它们的结构特征及体外免疫活性进行了研究。结果表明,在猴头菌发育过程中,多糖总得率呈现先增大后减小的趋势,在第5阶段达到最大值0.92%。20%醇沉的多糖含量也呈先增大后减小的趋势,在第5阶段达到最大值42.87%,其大分子量多糖（1 000-5 000kDa）所占比例最高。50%、70%醇沉多糖均为小分子量多糖,约为10-40kDa。获得的猴头菌多糖组分中,单糖组成多以岩藻糖、半乳糖、葡萄糖和甘露糖为主（相对比例存在一定差异）;另外,第1阶段20%、70%醇沉多糖还含有少量的核糖,第7阶段20%醇沉多糖含有一定量的鼠李糖;7个时期50%醇沉多糖均含有一定量的葡萄糖醛酸。所得多糖样品均具有刺激巨噬细胞释放NO的活性,其中20%醇沉多糖的活性优于50% 和70% 醇沉多糖,在50μg/mL时就表现出显著的体外免疫活性。此外,在第5阶段即中菌刺期产生的多糖活性最优,说明在此阶段采摘可以获得最佳的猴头菌多糖原材料。本研究为猴头菌生长发育过程中活性多糖的动态形成研究提供了一定的理论基础。     

梭柄松苞菇多糖组分的部分理化性质及对S-180瘤抑制活性研究

【目的】分离和纯化梭柄松苞菇子实体多糖, 并对其结构和抗肿瘤活性进行研究。【方法】采用热水浸提法提取梭柄松苞菇子实体多糖, 采用DE-52纤维素柱和Sephadex G-100进行多糖的分离纯化, HPGPC测定多糖分子量, HPLC测定单糖组成, 红外光谱进行结构分析, 甲基化实验测定连接方式, 核磁共振测定异头碳构型, 采用S-180荷瘤小鼠模型对梭柄松苞菇子实体多糖抗肿瘤活性进行研究, 并测定了荷瘤小鼠血清细胞因子TNF-α、IL-2和IL-6的含量。【结果】从梭柄松苞菇子实体中分离纯化得到多糖命名为CVP-A, 结果表明, CVP-A平均分子量为10 289, 单糖组成主要为葡萄糖, 还含有少量木糖, 含量比约为15:2, 甲基化实验, 核磁共振以及红外光谱分析结果表明CVP-A主链为(1→4)-α-D-葡聚糖, 侧链连接在主链葡萄糖残基2号碳位置, S-180荷瘤小鼠模型实验表明, CVP-A对实验性S-180实体瘤具有较好的抑制作用, 连续10 d腹腔注射25、50和75 mg/(kg·d) CVP-A的昆明小鼠的肿瘤抑制率分别为31.99%、42.68%和60.18%, 小鼠血清细胞因子测定表明, CVP-A能提高荷瘤小鼠血清TNF-α、IL-2和IL-6的含量。【结论】梭柄松苞菇多糖可能作为一个潜在的抗癌药物而开发利用。     

小刺猴头菌液体深层培养过程中多糖积累及其特征的研究

本文探讨了气升环流反应器培养小刺猴头菌过程中菌体生物量、胞内外真菌多糖的积累规律,与同一菌株复元的子实体多糖的含量、组成分别进行分析对比,得到液体深层培养菌丝体多糖的含量为0．0918g／g（干）,而子实体仅为外0．378g／g（干）,发酵液中多糖含量达0．285g／l,它们的单糖构成比例均相同,即葡萄糖：甘露糖：半乳糖＝20．2：5．2：1,但液体深层培养的菌丝体多糖与人工栽培的子实体多糖的电荷性能不同。     

卵孢小奥德蘑驯化栽培、营养成分及抗氧化活性

卵孢小奥德蘑是一种珍贵的食药用真菌。本研究选用果渣、酒糟与菌糠为部分替代料,采用正交试验优化了野生卵孢小奥德蘑的母种、原种及栽培料配方,并测定了栽培子实体的含水量、蛋白质、总糖、维生素C、多酚含量及醇提物对DPPH、ABTs⁺及羟基自由基的清除能力。结果表明,最佳母种培养基配方为麦麸35 g/L、葡萄糖20 g/L、磷酸氢二钾3.5 g/L、硫酸镁2 g/L和琼脂20 g/L,确定了葡萄糖与磷酸氢二钾是影响菌丝生长的重要因素;最优原种培养基配方为果渣45%、豆秸20%、麦麸15%、石灰3%、石膏1%和刺芹侧耳菌糠16%,在培养基中添加果渣能够显著促进卵孢小奥德蘑原种菌丝的生长;最佳栽培料配方为酒糟35%、棉籽壳30%、麦麸20%、石灰1%、石膏1%和玉米芯13%,酒糟对子实体产量的影响达到了显著水平;卵孢小奥德蘑的营养成分显示其富含蛋白质、糖类、维生素C及多酚,由9种配方栽培出的子实体中最高含量可分别达到42.78 g/100 g、23.54 g/100 g、4.02 mg/100 g及4.19 mg/g,且栽培料的不同组分及用量对其营养物质的含量具有显著差异。此外,卵孢小奥德蘑的醇提物具有较强的抗氧化能力且随着用量的增加抗氧化活性增强,当用量为150、40和250 μL时配方Z1对DPPH和ABTs⁺及配方Z2对羟基自由基的清除能力可分别达到88.64%、99.81%和93.48%,本研究结果为卵孢小奥德蘑的栽培、生理活性、药理研究及进一步的开发利用提供理论依据。     

灵芝栽培培养基筛选试验

以灵芝(Ganoderma lucidum)之赤芝(Ganoderma lucidum Karst)、韩芝(Ganoderma luci- dum H.G)为试验品种,培养基以棉壳98%、石膏1%、蔗糖1%为对照,另外以棉壳、麸皮、木屑、氨基酸不同含量配制4种培养基作比较栽培试验。结果表明:2号培养基出菇产量高、菇形好,对赤芝、韩芝都适宜;赤芝、韩芝对培养基的要求略有差异,韩芝在含麸皮量高的基质上栽培更为适合。     

Comparative study of mycelial growth and basidiomata formation in seven different species of the edible mushroom genus Hericium

The potential of using several agricultural by-products as supplements of sawdust substrate for the production of edible mushroom Hericium was evaluated using seven Hericium species. All the tested supplements (rice bran, wheat bran, barley bran, Chinese cabbage, egg shell, and soybean powder) were found to be suitable for the mycelial growth of all the tested species. In mycelial growth, soybean powder was the best supplement for Hericium americanum, Hericium coralloides, and Hericium erinaceum while barley bran was the best for Hericium alpestre, Hericium laciniatum, and Hericium erinaceus. For Hericium abietis, rice bran and Chinese cabbage was the best. The possibility of mushroom production on oak sawdust substrate with 20% rice bran supplement was demonstrated with H. coralloides, H. americanum, H. erinaceus, and H. erinaceum which showed 26-70% biological efficiency. Our results also showed that strain selection is important to improve biological efficiency and mushroom yield in Hericium cultivation.     

Growth,fruiting and lignocellulolytic enzyme production by the edible mushroom <Emphasis Type="Italic">Grifola frondosa</Emphasis> (maitake)

Cultivation of specialty mushrooms on lignocellulosic wastes represents one of the most economical organic recycling processes. Compared with other cultivated mushrooms, very little is known about the nature of the lignocellulolytic enzymes produced by the edible and medicinal fungus Grifola frondosa, the parameters affecting their production, and enzyme activity profiles during different stages of the developmental cycle. In this work we investigated the enzymes that enable G. frondosa, to colonize and deconstruct two formulations based on industrial lignocellulosic by-products. G. frondosa degraded both substrates (oak-sawdust plus corn bran, and oak/corn bran supplemented with coffee spent-ground) decreasing 67 and 50% of their lignin content, along with 44 and 37% of the polysaccharides (hemicellulose and cellulose) respectively. 35.3% biological efficiency was obtained when using oak sawdust plus corn bran as substrate. Coffee spent-ground addition inhibited mushroom production, decreased growth, xylanase and cellulase activities. However, taking into account that G. frondosa successfully colonized this residue; this substrate formula might be considered for its growth and medicinal polysaccharide production. Although G. frondosa tested positive for Azure B plate degradation, a qualitative assay for lignin-peroxidase, attempts to detect this activity during solid state fermentation were unsuccessful. Enzyme activities peaked during colonization but declined drastically during fruiting body formation. Highest activities achieved were: endoglucanase 12.3, exoglucanase 16.2, β-glucosidase 2.3, endoxylanase 20.3, amylase 0.26, laccase 14.8 and Mn-peroxidase 7.4 U/g dry substrate.     

Tea waste as a supplement for the cultivation of <Emphasis Type="Italic">Ganoderma</Emphasis> <Emphasis Type="Italic">lucidum</Emphasis>

Tea waste (TW) was investigated as a new supplement for substrate mixtures in Ganoderma lucidum cultivation. The effects of sawdust (S) based substrates supplemented with TW at the various levels (75S:25TW, 80S:20TW, 85S:15TW, and 90S:10TW) and Ganoderma lucidum strains on yield, biological efficiency (BE) and the chemical composition of fruiting bodies were determined in solid-state fermentation. Significant differences were found among substrates regarding yield and BE, while yield and BE of the strains were not different. The substrate formulations producing highest yield and BE were 80S:20TW (87.98 g/kg substrate and 34.90%) and 75S:25TW (82.30 g/kg substrate and 31%). Yield and BE of substrates containing TW were generally higher than that of the control (80sawdust:18wheat bran:1sucrose:1 CaCO₃). Nitrogen, potassium, iron, and manganese contents and C:N ratios of substrates were strongly correlated with yield. BE showed positive and significant correlations with potassium, iron and manganese. Moisture content, potassium, magnesium, calcium, iron, and zinc contents of the fruiting bodies were affected by both strain and substrate. It was concluded that TW can be used as a supplement for substrate preparation in G. lucidum cultivation.     

Biological efficiency and nutritional value of Pleurotus ostreatus cultivated on spent beer grain

Unpretreated spent beer grains were successfully used as a basic substrate material for the cultivation of Pleurotus ostreatus. The effects of spent grain types, additives, substrate moisture content, and substrate packing density on the yield and nutrition of fruit bodies were investigated. The cultivation results showed that few fruit bodies were formed on spent grain alone; however, a significantly high biological efficiency (19.1%) was obtained with the addition of wheat bran to (45%). The chemical analysis of fruit bodies indicated that P. ostreatus cultivated on spent grain substrate had a higher nutritional value than those grown on other reported types of substrates. The total amino acid content in the fruit bodies was 347.5 mg/g dry matter, and the crude protein content was as high as 53.3% on a dry weight basis. It was also found that the cultivation of P. ostreatus increased the crude protein content, while it decreased the ratio of lignin to cellulose, of the spent grain substrate.     

混料设计优化黑木耳菌丝生长的农业剩余物配方

【背景】菌林矛盾日益突出,农业剩余物资源丰富,可作为食用菌栽培主要基质。【目的】筛选出适合黑木耳菌丝生长的农业剩余物配方。【方法】以大豆秸秆、油菜秸秆、玉米秸秆、花生秸秆、小麦秸秆和杂木屑等6种基质为原料,运用单纯形格子法进行配方设计,分析不同基质交互作用对黑木耳菌丝生长速率、菌丝生长指数、漆酶酶活、多酚氧化酶酶活和纤维素酶酶活的影响。【结果】在这些农业剩余物基质中,大豆秸秆基质最适合黑木耳菌丝生长,其次是油菜秸秆。3种主料共同作用可以优化出最适合黑木耳菌丝生长的基质配比。【结论】最终优化出一个适合黑木耳菌丝生长的农业剩余物配方：杂木屑49.4%、油菜秸秆16.4%、大豆秸秆12.2%、麦麸20%、蔗糖1%、CaSO₄ 1%。本研究为“以草代木”栽培黑木耳提供了理论基础。     

采自祁连山的冷杉侧耳生物学特性及栽培条件探索

以采自甘肃省祁连山国家级自然保护区菌物保育区的野生侧耳作为试验材料,通过形态学及系统发育分析方法将其鉴定为冷杉侧耳Pleurotus abieticola。对该菌株生物学特性及栽培条件进行初步研究,结果表明：菌丝体最适生长温度为25℃;最适pH为7.0;最适碳源为玉米粉;最适氮源为豆粉;在以棉籽壳、木屑和麸皮为栽培料时,可获得子实体。     

不同培养料和发酵次数栽培巴氏菇比较

分别以玉米秸秆和稻草为培养料栽培巴氏菇,对菌丝生长性状进行对比;同时,在我国传统发酵栽培方法的基础上,将三次发酵法与二次发酵法进行了对比。试验结果表明:利用玉米秸秆栽培的巴氏菇在发菌速度及子实体质量和产量上均优于稻草;培养料经过3次发酵更适宜巴氏菇生长。经过3次发酵的玉米秸秆培养料栽培的巴氏菇产量和生物学效率分别为7.7 kg/m2和27.5%,子实体粗蛋白含量44.89%,可溶性糖含量44.01%,18种氨基酸总量31.70%,明显高于2次发酵的玉米秸秆培养料及2次、3次发酵的稻草培养料。