Optimization of a reconstituted skim milk based medium for enhanced CLA production by bifidobacteria

Aims:  To determine the effect of a range of supplements on the bioconversion of linoleic acid to conjugated linoleic acid (CLA) by Bifidobacterium breve NCIMB 702258 in reconstituted skim milk (RSM).
Results:  Seven supplements (yeast extract, casein hydrolysate, tryptone, l -cysteine hydrochloride, sodium acetate, sodium butyrate and sodium propionate) were identified as increasing the bioconversion of linoleic acid to c9 , t 11 CLA. Using these supplements, the percentage bioconversion of linoleic acid (0·35 mg ml^−l) to the c9 , t 11 CLA isomer was elevated from 15·5 ± 1·1% in 20% RSM (w/v) to 48·1 ± 2·2% in the supplemented RSM. Through additional supplementation of 20 mg m1⁻¹ inulin and optimization of inoculum and linoleic acid concentration, the percentage bioconversion to c9 , t 11 CLA was increased to 55·0 + 3·2%.
Conclusions:  Through supplementation, the concentration of CLA produced by bifidobacteria in RSM can be increased to levels comparable to those observed in the synthetic medium cys-MRS.
Significance and Impact of the Study:  The impact of 22 supplements on the production of the c9 , t 11 CLA isomer by the strain B. breve NCIMB 702258 in milk has been determined. The results provide an understanding of the factors, which influence CLA production by bifidobacteria in RSM.     

Inhibitory effects of sucrose fatty acid esters on survival of Yersinia enterocolitica on eggshell surface and use of blue lake as indicator of bacterial penetration into eggs

Aims:  To determine the effectiveness of sucrose monolaurate (SML) and sucrose monocaprate (SMC), alone and in combination with ethylenediaminetetraacetic acid (EDTA), propionic acid (PA) or citric acid (CA) in reducing mesophilic aerobic bacteria (MAB) and Yersinia enterocolitica O:9 populations on eggshells and their damage potential on the microstructure of shell cuticle.
Methods and Results:  Uninoculated eggs and eggs submerged in a solution of Y. enterocolitica were immersed in solutions of the various treatments. MAB and Y. enterocolitica counts on the surface of the eggs were carried out before and after treatment. MAB counts decreased less than 2 logs on uninoculated eggshells irrespective of treatment and reductions of 3·2 and 3·0 logs of Y. enterocolitica were obtained with 1000 μg ml⁻¹ SML plus 0·1% CA or 1000 μg ml⁻¹ SML plus 600 μg ml⁻¹ EDTA solutions, respectively. Y. enterocolitica 2/O:9 was recovered from natural microflora. Use of blue lake staining revealed minimal damage to the shells from the washing treatments.
Conclusions:  SML and SMC at 1000 μg ml⁻¹ combined with CA or EDTA could be effective in reducing Y. enterocolitica on eggshells with a minimal risk of later bacterial recontamination.
Significance and Impact of the Study:  Eggs are a recognized vehicle for transmission of Y enterocolitica although a prevalence of only 2·7% was detected in this study. Washing eggs in solutions containing SML or SMC could eliminate Y. enterocolitica contamination of egg shells.     

9 cis,11 trans conjugated linoleic acid (CLA) is synthesised and desaturated into conjugated 18:3 in bovine adipose tissues

Although endogenous synthesis of conjugated linoleic acid (CLA) in the mammary gland of lactating cows has been already well documented, no study has determined so far as to which tissue and/or organ is involved in CLA synthesis in the growing ruminant except one study showing that CLA synthesis does not occur in ruminant liver. In this context, adipose tissue appears to be a good candidate for endogenous synthesis of CLA in the growing ruminant. The aim of this study was to compare the respective metabolisms of 11trans 18:1 (vaccenic acid, VA) and 9cis,11trans 18:2 (rumenic acid) to that of stearic acid (the preferential substrate of Δ9 desaturase) in adipose tissues (subcutaneous, SC and intermuscular, IM) of six Charolais steers by using the in vitromethod of incubated tissue slices. Samples of SC and IM adipose tissues were incubated at 37°C for 16 h under an atmosphere of 95% O2/5% CO2 in a medium supplemented with 0.75 mM of fatty acid (FA) mixture (representative of circulating non-esterified FA) and 186 μM [1-14C]-18:0 or 58.6 μM [1-14C]-VA or 56 μM [1-14C]-9cis,11trans CLA. Viability of explants was verified by measuring metabolic functions (glucose uptake and glucose-6-phosphate dehydrogenase activity). After 16 h of incubation, FA uptake was similar for all FA (18:0, VA and 9cis,11trans 18:2) in both SC and IM adipose tissues (around 40%). Once in adipose tissue, all FA were preferentially esterified (>80% of cell FA) favouring neutral lipid synthesis (around 90% of esterified FA). Stearic acid was highly (27%) desaturated into oleic acid in SC adipose tissue whereas this desaturation was much lower (6.8%) in IM adipose tissue (P < 0.0001). VA was desaturated into 9cis,11trans CLA at a low extent of about 2.5% to 4.4% in both adipose tissues probably because of a limited affinity of Δ9 desaturase for VA. 9cis,11trans CLA was itself converted by desaturation into 6cis, 9cis,11trans 18:3 at the intensity of 10.8% and 14.5% of cell 9cis,11trans CLA in SC and IM adipose tissues, respectively. In conclusion, bovine adipose tissues of the growing ruminant were especially involved in the endogenous synthesis of CLA from VA and in its desaturation into conjugated derivative, mainly 6cis, 9cis,11trans 18:3, of which biological properties need to be elucidated.     

Legionella pollution in cooling tower water of air-conditioning systems in Shanghai, China

Aims:  To determine Legionella pollution prevalence, describe the amount of Legionellae with respect to temperature in Shanghai cooling tower water (CTWs) in various types of public sites.
Methods and Results:  Six urban districts were selected as the study fields, adopting multiple-phase sampling methods. Routine culture was used to identify Legionellae. Of the samples, 58·9% (189/321) were observed to be positive, 19·9% were isolated over 100 CFU ml⁻¹. Legionella pneumophila serogroup 1 was the most frequently isolated species (155/189, 82·0%), followed by Leg. micdadei that was at the second place (44/189, 23·3%). The mean CFU ml⁻¹ of Legionellae in CTWs reached its peak from July to September. Over all 15·4% of the samples exceeding 100 CFU ml⁻¹ were observed in a hospital setting.
Conclusions:  The prevalence of Legionella pollution in CTWs, especially in CTWs of subway stations and hospitals, is worrying, and the positive rate and CFU ml⁻¹ of Legionellae in CTWs have a close relationship with air temperature.
Significance and Impact of the Study:  The study demonstrates pollution prevalence rates in different types of sites and various seasons, and provides a proportion of different serogroups of Legionellae . It illuminates an urgent need for dealing with the potential risk of legionellosis in Shanghai, through improved control and prevention strategies.     

The effect of conjugated linoleic acid on arachidonic acid metabolism and eicosanoid production in human saphenous vein endothelial cells

The effects of a conjugated linoleic acid (CLA) mixture of single isomers (50:50, w/w, cis9,trans11:trans10,cis12) and the individual isomers on (a) the production of resting and calcium ionophore stimulated (14)C-eicosanoids and (b) the incorporation of (14)C-arachidonic acid (AA) into membrane phospholipids of human saphenous vein endothelial cells were investigated. The CLA mixture and the individual isomers were found to inhibit resting production of (14)C-prostaglandin F(2a) by 50, 43 and 40%, respectively. A dose dependent inhibition of stimulated (14)C-prostaglandins was observed with the CLA mixture (IC(50) 100 microM). The cis9,trans11 and trans10,cis12 (50 microM) isomers individually inhibited the overall production of stimulated (14)C-prostaglandins (between 35 and 55% and 23 and 42%, respectively). When tested at a high concentration (100 microM), cis9,trans11 was found to inhibit eicosanoid production in contrast to trans10,cis12 that caused stimulation. The overall degree of (14)C-AA incorporation into membrane phospholipids of the CLA (mixture and individual isomers) treated cells was found to be lower than that of control cells and the cis9,trans11 isomer was found to increase the incorporation of (14)C-AA into phosphatidylcholine. Docosahexaenoic acid, eicosapentaenoic acid and linoleic acid did not alter the overall degree of incorporation of (14)C-AA. The results of this study suggest that both isomers inhibit eicosanoid production, and although trans10,cis12 exhibits pro-inflammatory activity at high concentrations, the CLA mixture maintains its beneficial anti-inflammatory action that contributes to its anti-carcinogenic and anti-atherogenic properties.     

Isomer-specific effects of conjugated linoleic acid on mineralized bone nodule formation from human osteoblast-like cells

Mixed isomers of conjugated linoleic acid (CLA) have been shown to have variable effects on bone formation and resorption in animals. The variable effects of CLA on bone physiology may be due to the different isomers present in common commercial preparations of CLA, and the effects of the predominant individual isomers (9cis,11trans and 10trans,12cis CLA) are not clear. The objective of this study was to determine the effects of individual and mixed isomers of CLA on mineralized bone nodule formation and alkaline phosphatase (ALP) activity in vitro using long-term cultures of SaOS-2 cells. Mineralized bone nodules were stained using the von Kossa method, and ALP activity in cell lysates was measured as a marker of early osteoblast differentiation. The 9cis,11trans isomer increased the number (~4- to 11-fold) and size (~2- to 5-fold) of mineralized bone nodules from 25 to 100 microM, but the 10trans,12cis isomer did not. The increase in mineralized bone nodule formation by 9cis,11trans CLA was accompanied by a variable increase in ALP activity. These results show that the 9cis,11trans isomer of CLA increases the formation of mineralized bone nodules using bone cells of human origin, and provide evidence for isomer-specific effects of CLA on bone health.     

Stimulation of biomethanation by Clostridium sp. PXYL1 in coculture with a Methanosarcina strain PMET1 at psychrophilic temperatures

Aim:  Bioaugumentation of low temperature biogas production was attempted by addition of cold-adapted Clostridium and a methanogen.
Methods and Results:  A psychrotrophic xylanolytic acetogenic strain Clostridium sp. PXYL1 growing optimally at 20°C and pH 5·3 and a Methanosarcina strain, PMET1, growing optimally on acetate and producing methane at 15°C were isolated from a cattle manure digester. Anaerobic conversion of xylose at 15°C with the coculture of the two strains was performed, and batch culture methane production characteristics indicated that methanogenesis occurred via acetate through 'acetoclastic' pathway. Stimulation studies were also undertaken to evaluate the effect of exogenous addition of the coculture on biogas yields at 15°C. Addition of 3 ml of PXYL1 at the rate of 12 × 10² CFU ml⁻¹ increased the biogas 1·7-fold (33 l per kg cowdung) when compared to control (19·3 l per kg cowdung) as well as increased the volatile fatty acid (VFA) levels to 3210 mg l⁻¹ when compared to 1140 mg l⁻¹ in controls. Exogenous of addition of 10 ml PMET1 inoculum at the rate of 6·8 ± 10² CFU ml⁻¹ in addition to PXYL1 served to further improve the biogas yields to 46 l kg⁻¹ as well as significantly brought down the VFA levels to 1350 mg l⁻¹.
Conclusions:  Our results suggest that the rate-limiting methanogenic step at low temperatures could be overcome and that biogas yields improved by manipulating the population of the acetoclastic methanogens.
Significance and Impact of the Study:  Stimulation of biomethanation at low temperature by coculture.     

共轭亚油酸生理功能及微生物合成调控研究进展

共轭亚油酸(conjugated linoleic acid,CLA)是一种新型功能性油脂,顺9,反11-十八碳二烯酸(c9,t11-CLA)和反10,顺12-十八碳二烯酸(t10,c12-CLA)由于具有比其他异构体更强的生理功能得到广泛关注和研究.微生物合成CLA具有安全性高、选择特异性强等特点,研究CLA产量提高...     

Effects of the high pressure of homogenization on some spoiling micro-organisms, representative of fruit juice microflora, inoculated in saline solution

Aims:  This study was aimed to investigate the effects of a high-pressure homogenization (HPH) treatment on some micro-organisms, involved in the spoilage of fruit juices.
Methods and Results:  Lactobacillus plantarum , Lactobacillus brevis , Bacillus coagulans cells, Saccharomyces bayanus , Pichia membranaefaciens and Rhodotorula bacarum were separately inoculated in a saline solution (0·9% NaCl); the initial inoculum was ca. 5 log CFU ml⁻¹. Then, the samples were processed through a homogenizer at 10–150 MPa for 1, 2 or 3 times. Yeasts were completely inactivated at 50–110 MPa with a single pass treatment, while lactic acid bacteria counts were reduced to approximately 1 log CFU ml⁻¹ after a three-steps HPH processing.
Conclusions:  Yeasts were the most sensitive micro-organisms, followed by B. coagulans . On the other hand, lactic acid bacteria appeared resistant to HPH.
Significance and Impact of the Study:  The results of this study provided some useful information on the susceptibility of microflora of juices to homogenization; moreover, they suggested that HPH could be used successfully to inactivate yeasts.     

Antibacterial activity of sphagnum acid and other phenolic compounds found in Sphagnum papillosum against food-borne bacteria

Aims:  To identify the phenolic compounds in the leaves of Sphagnum papillosum and examine their antibacterial activity at pH appropriate for the undissociated forms.
Methods and Results:  Bacterial counts of overnight cultures showed that whilst growth of Staphylococcus aureus 50084 was impaired in the presence of milled leaves, the phenol-free fraction of holocellulose of S. papillosum had no bacteriostatic effect. Liquid chromatography–mass spectrometry analysis of an acetone–methanol extract of the leaves detected eight phenolic compounds. Antibacterial activity of the four dominating phenols specific to Sphagnum leaves, when assessed in vitro as minimal inhibitory concentrations (MICs), were generally >2·5 mg ml⁻¹. MIC values of the Sphagnum- specific compound 'sphagnum acid' [ p -hydroxy-β-(carboxymethyl)-cinnamic acid] were >5 mg ml⁻¹. No synergistic or antagonistic effects of the four dominating phenols were detected in plate assays.
Conclusions:  Sphagnum -derived phenolics exhibit antibacterial activity in vitro only at concentrations far in excess of those found in the leaves.
Significance and Impact of the Study:  We have both identified the phenolic compounds in S. papillosum and assessed their antibacterial activity. Our data indicate that phenolic compounds in isolation are not potent antibacterial agents and we question their potency against food-borne pathogens.     

Effect of alternative treatments on seed-borne Didymella lycopersici in tomato

Aims:  To quantify the phytotoxicity and effect of alternative seed treatments based on acidified nitrite and elicitors of plant resistance (Tillekur and Chitosan) against seed-borne inocula of Didymella lycopersici .
Methods and Results:  Treatments tested were: nitrite [sodium nitrite in citric acid buffer (pH 2)] at 30, 100 and 300 mmol l⁻¹ and three exposure times (10, 20 and 30 min); Tillekur (in water) at 12·5, 25, 50, 100 and 200 mg ml⁻¹; Chitosan (in 0·05% acetic acid) at 2·5, 5, 10 and 50 mg ml⁻¹. Efficacy of treatments was determined in growth chamber experiments. Nitrite at 300 mmol l⁻¹ was completely effective, as was the fungicide, at controlling disease when applied for less than 20 min. Tillekur was as effective as the fungicide postemergence, but proved to be phytotoxic pre-emergence. Chitosan was significantly less effective than the other treatments.
Conclusions:  The high efficacy and low cost of acidified nitrite indicates that it is a suitable alternative to fungicides.
Significance and Impact of the Study:  There is currently a lack of effective seed treatments that can be used in organic and low-input crops. Treatments identified in this study can be considered as an effective alternative to chemical control against seed-borne fungal pathogens.     

Synbiotics growth optimization of Bifidobacterium pseudocatenulatum G4 with prebiotics using a statistical methodology

Aims:  This study demonstrated the optimum growth of Bifidobacterium pseudocatenulatum G4 with prebiotics via statistical model.
Methods and Results:  Commercial prebiotics [inulin and fructooligosaccharide (FOS)], together with sorbitol, arabinan and inoculum rate, were tested by fractional factorial design to determine their impact on growth of Bif. pseudocatenulatum G4 in skim milk. At 48 h incubation, bacterial growth was mainly influenced by FOS and inoculum rate. Growth reduction was observed in all samples incubated for 72 h. Central composite design (CCD) was adopted using FOS and inoculum rate at 48 h incubation to develop the statistical model for optimization. The model predicted that 2·461 log CFU ml⁻¹ produced the optimum growth increase of Bif. pseudocatenulatum G4. The combination that produced the optimum point was 2·86% FOS (g/v) and 0·67% inoculum rate (v/v).
Conclusion:  At optimum combination of inoculum rate and FOS, validation experiments recorded 2·40 ± 10·02 log CFU ml⁻¹. The application in 1-l bioreactor for 24 h showed higher growth increase of 2·95 log CFU ml⁻¹.
Significant and Impact of the Study:  Response surface methodology approach is useful to develop optimum synbiotics combination for strain G4 with FOS.     

Statistical optimization of medium components for extracellular protease production by an extreme haloarchaeon, Halobacterium sp. SP1(1)

Aims:  Optimization of medium components for extracellular protease production by Halobacterium sp. SP1(1) using statistical approach.
Methods and Results:  The significant factors influencing the protease production as screened by Plackett–Burman method were identified as soybean flour and FeCl₃. Response surface methodology such as central composite design was applied for further optimization studies. The concentrations of medium components for higher protease production as optimized using this approach were (g l⁻¹): NaCl, 250; KCl, 2; MgSO₄, 10; tri-Na-citrate, 1·5; soybean flour, 10 and FeCl₃, 0·16. This statistical optimization approach led to production of 69·44 ± 0·811 U ml⁻¹ of protease.
Conclusions:  Soybean flour and FeCl₃ were identified as important factors controlling the production of extracellular protease by Halobacterium sp. SP1(1). The statistical approach was found to be very effective in optimizing the medium components in manageable number of experimental runs with overall 3·9-fold increase in extracellular protease production.
Significance and Impact of the Study:  The present study is the first report on statistical optimization of medium components for production of haloarchaeal protease. The study also explored the possibility of using extracellular protease produced by Halobacterium sp. SP1(1) for various applications like antifouling coatings and fish sauce preparation using cheaper raw material.     

Real-time quantification of Pseudomonas fluorescens cell removal from glass surfaces due to bacteriophage varphiS1 application

Aims:  To study the efficacy of the lytic phage φS1 in eliminating Pseudomonas fluorescens in the early stage of biofilm formation, using an in situ and real time methodology for cell quantification.
Methods and Results:  Cell adhesion and phage infection studies were carried out in a parallel plate flow chamber under laminar conditions. Cells were allowed to adhere until reaching 1·7–1·8 × 10⁶ cells cm⁻² and phage infection was performed with two different phage concentrations (2 × 10⁹ PFU ml⁻¹ and 1 × 10¹⁰ PFU ml⁻¹). Phage concentration clearly affects the speed of infection. The less concentrated phage solution promoted a three times slower rate of cell removal but did not affect the overall percentage of cell removal. In fact, after a longer infection period the less concentrated phage solution reached the same 93% cell removal value.
Conclusions:  Phages are efficient in the eradication of bacterial cells at the early stage of biofilm formation and their presence at the surface did not allow bacterial recolonization of the surface.
Significance and Impact of the Study:  To date, no published studies have been made concerning in situ and real time quantification of cell removal from surfaces due to phage action.     

Response surface methodology to optimize the nutritional parameters for enhanced production of jasmonic acid by Lasiodiplodia theobromae

Aims:  To find out the cumulative effect of the nutritional parameters and to enhance the production of jasmonic acid (JA) in static fermentation by Lasiodiplodia theobromae using response surface methodology (RSM).
Method and Results:  Malt extract, sucrose, NaNO₃ and MgSO₄.7H₂O were analysed by a 30-trial central composite design using RSM for optimizing their concentrations in the medium and the effect of their mutual interaction on JA production. Sucrose and NaNO₃ were found highly significant in influencing the JA production. Malt extract and MgSO₄.7H₂O showed an effect on the JA production in interaction with other variables. When the optimum values of the parameters obtained through RSM (19·95 g l⁻¹ malt extract, 50 g l⁻¹ sucrose, 7·5 g l⁻¹ NaNO₃ and 3·51 g l⁻¹ MgSO₄.7H₂O) were applied, 32% increase in JA production (299 mg l⁻¹) was observed in comparison with 225 mg l⁻¹ of JA produced with same media components not analysed by RSM and subsequently validated the statistical model.
Conclusions:  Increase in JA production was achieved by optimizing the nutritional parameters.
Significance and Impact of the Study:  This is the first report of using RSM for optimizing a medium for JA production. It resulted in an increase in JA production without augmentation of costly additives.     

The combined effects of high pressure and nisin on germination and inactivation of Bacillus spores in milk

Aims:  The aim of this work was to investigate the germination and inactivation of spores of Bacillus species in buffer and milk subjected to high pressure (HP) and nisin.
Methods and Results:  Spores of Bacillus subtilis and Bacillus cereus suspended in milk or buffer were treated at 100 or 500 MPa at 40°C with or without 500 IU ml⁻¹ of nisin. Treatment at 500 MPa resulted in high levels of germination (4 log units) of B. subtilis spores in both milk and buffer; this increased to >6 logs by applying a second cycle of pressure. Viability of B. subtilis spores in milk and buffer was reduced by 2·5 logs by cycled HP, while the addition of nisin (500 IU ml⁻¹) prior to HP treatment resulted in log reductions of 5·7 and 5·9 in phosphate buffered saline and milk, respectively. Physical damage of spores of B. subtilis following HP was apparent using scanning electron microscopy. Treating four strains of B. cereus at 500 MPa for 5 min twice at 40°C in the presence of 500 IU ml⁻¹ nisin proved less effective at inactivating the spores of these isolates compared with B. subtilis and some strain-to-strain variability was observed.
Conclusions:  Although high levels of germination of Bacillus spores could be achieved by combining HP and nisin, complete inactivation was not achieved using the aforementioned treatments.
Significance and Impact of the Study:  Combinations of HP treatment and nisin may be an appealing alternative to heat pasteurization of milk.     

A potent anti-oxidant property: fluorescent recombinant α-phycocyanin of Spirulina

Aims:  To express and product a fluorescent antioxidant holo-α-phycocyanin (PC) of Spirulina platensis ( Sp ) with His-tag (rHHPC; recombinant holo-α-phycocyaninof Spirulina platensis with His-tag) in 5-l bench scale.
Methods and Results:  A vector harbouring two cassettes was constructed: cpcA along with cpcE - cpcF in one cassette; ho1 - pcyA in the other cassette. Lyases CpcE/F of Synechocystis sp. PCC6803 ( S6 ) could catalyse the 82 site Cys in apo-α-PC of Sp linking with bilin chromophores, and rHHPC was biosynthesized in Escherichia coli BL21. The constant feeding mode was adopted, and transformant reached the biomass of rHHPC up to 0·55 g l⁻¹ broth in 5-litre bench scale. rHHPC was purified by Ni²⁺ affinity column conveniently. The absorbance and the fluorescence emission spectra of rHHPC had λ_max at 621 and 650 nm, respectively. The IC₅₀ values of rHHPC were 277·5 ± 25·8 μ g ml⁻¹ against hydroxyl radicals and 20·8 ± 2·2  μ g ml⁻¹ against peroxyl radicals.
Conclusions:  Combinational biosynthesis of rHHPC was feasible, and the constant feeding mode was adopted to produce good yields of rHHPC. Fluorescent rHHPC with several unique qualitative and quantitative features was effective on scavenging hydroxyl and peroxyl radicals.
Significance and impact of the study:  A potent antioxidant rHHPC was co-expressed, produced and characterized for nutritional and pharmacological values, which would help to develop phycobiliproteins' applications in their fluorescent and biological activities.     

Production and partial characterization of lipases from a newly isolated Penicillium sp. using experimental design

Aims:  The objective of this work was to investigate the lipase production by a newly isolated Penicillium sp . , using experimental design technique, in submerged fermentation using a medium based on peptone, yeast extract, NaCl and olive oil, as well as to characterize the crude enzymatic extracts obtained.
Methods and Results:  Lipase activity values of 9·5 U ml⁻¹ in 96 h of fermentation was obtained at the maximized operational conditions of peptone, yeast extract, NaCl and olive oil concentrations (g l⁻¹) of 20·0, 5·0, 5·0 and of 10·0 respectively. The partial characterization of crude enzymatic extract obtained by submerged fermentation showed optimum activity at pH range from 4·9 to 5·5 and temperature from 37°C to 42°C. The crude extract maintained its initial activity at freezing temperatures up to 100 days.
Conclusions:  A newly isolated strain of Penicillium sp . used in this work yielded good lipase activities compared to the literature.
Significance and Impact of the Study:  The growing interest in lipase production is related to the potential biotechnological applications that these enzymes present. New lipase producers are relevant to finding enzymes with different catalytic properties of commercial interest could be obtained, without using genetically modified organisms (GMO).     

Fungal endophytes from Acer ginnala Maxim: isolation, identification and their yield of gallic acid

Aims:  The aim of the study was to isolate the endophytic fungi from Acer ginnala and screen isolates rich in gallic acid.
Methods and Results:  After epiphytic sterilization, 145 fungal endophytes were isolated from the stem, annual twig and seed of Acer ginnala . The endophytes were grouped into ten different taxa, Phomopsis sp., Neurospora sp., Phoma sp., Epicoccum sp., Penicillium sp., Alternaria sp., Fusarium sp., Trichoderma sp., Cladosporium sp. and a species of Pleosporales Incertae Sedis , by their morphological traits and ITS-rDNA sequence analysis. The content and yield of gallic acid of 141 isolates were determined by HPLC. On average, the species of Pleosporales Incertae Sedis had the highest content and yield of gallic acid (13·28 mg g⁻¹ DW; 119·62 mg l⁻¹), while Alternaria sp. had the lowest.
Conclusions:  Of 141 fungal endophytes from A. ginnala , Phomopsis sp. isolate SX10 showed both the highest content and the highest yield of gallic acid (29·25 mg g⁻¹ DW; 200·47 mg l⁻¹).
Significance and Impact of the Study:  Endophytic fungi isolated from A. ginnala may be used as potential producers of gallic acid and other compounds with biological activities, or functioned as elicitors to produce natural compounds.     

Optimization of medium constituents for improved chitinase production by Paenibacillus sp. D1 using statistical approach

Aims:  Statistical optimization of medium components for improved chitinase production by Paenibacillus sp. D1.
Methods and Results:  Urea, K₂HPO₄, chitin and yeast extract were identified as significant components influencing chitinase production by Paenibacillus sp. D1 using Plackett–Burman method. Response surface methodology (central composite design) was applied for further optimization. The concentrations of medium components for improved chitinase production were as follows (g l⁻¹): urea, 0·33; K₂HPO₄, 1·17; MgSO₄, 0·3; yeast extract, 0·65 and chitin, 3·75. This statistical optimization approach led to the production of 93·2 ± 0·58 U ml⁻¹ of chitinase.
Conclusions:  The important factors controlling the production of chitinase by Paenibacillus sp. D1 were identified as urea, K₂HPO₄, chitin and yeast extract. Statistical approach was found to be very effective in optimizing the medium components in manageable number of experimental runs with overall 2·56-fold increase in chitinase production.
Significance and Impact of the Study:  The present investigation provides a report on statistical optimization of medium components for improved chitinase production by Paenibacillus sp. D1. Paenibacillus species are gram-positive, spore-forming bacteria with several PGPR and biocontrol potentials. However, only few reports concerning mycolytic enzyme production especially chitinases are available. Chitinase produced by Paenibacillus sp. D1 represents new source for biotechnological and agricultural use.