Improved fermentation processes for NS0 cell lines expressing human antibodies and glutamine synthetase

To meet the increasing requirement for therapeutic antibodies to conduct clinical trials, an enhanced culture medium and fed-batch process was developed for GS-NS0 cell lines. This process was shown to produce high concentrations of monoclonal antibodies for several cell lines expressing different antibodies. Cells were adapted to growth in a glutamine- and serum-free medium containing bovine serum albumin (BSA), cholesterol, and transferrin. A number of amino acids were found to be depleted during cell culture. The concentrations of these amino acids were increased, and further cell culture analyses were performed. This process of cell growth and analysis was repeated over multiple cycles until no depletion was detected. This resulted in an amino acid supplement that was shown to be generic and enhanced antibody productivity up to 5-fold for the three cell lines tested. Transferrin was replaced using tropolone, a lipophilic iron chelator and ferric ammonium citrate. Cell growth was equivalent to that in transferrin-containing medium over the wide ranges tested. A concentrated feed solution, based on the amino acid supplement and the components of the serum- and protein-free supplements, was formulated. Addition of this feed in response to metabolic requirements resulted in a harvest titer a further 2-fold higher than the enhanced culture medium. Harvest antibody titers of up to 600 mg/L were achieved for three cell lines expressing different antibodies, representing an increase of 10-fold over the starting concentrations.     

Antibody production and growth of mouse hybridoma cells in Nutridoma media supplements

Traditionally, cell culturists have relied upon the addition of serum to culture medium for the growth and maintenance of cell lines. However, many aspects of the use of serum in tissue culture are problematic. Cell culture supplements that circumvent the need for serum are readily available and provide a consistent protein composition. This defined environment allows the antibody to be more easily purified from culture supernatants. Nutridoma media supplements were formulated to support the growth of lymphoblastoid cells in a defined culture environment. In this study, Nutridoma media supplements were tested in parallel with serum-containing cultures to determine if Nutridoma supplemented medium is effective in supporting hybridoma cell growth and antibody production in three hybridoma cell lines. Data, based on cell growth and antibody production, show the importance of basal media selection when serum is replaced with Nutridoma media supplements. SDS-PAGE results show that cell supernatants from Nutridoma supplemented cultures contain very few contaminating proteins.     

Evidence of Mucin Secretion in Human Lung Adenocarcinoma Cell Lines NCIH650 and NCIH2077 and Effect of Select Secretagogues on Mucin Secretion

Mucins comprise an important class of tumor-associated antigens. The objectives of the present study were (a) to establish an in vitro model system using human non-small cell lung adenocarcinoma cell lines NCIH650 and NCIH2077 (b) provide evidence that these cell lines secrete mucin in culture conditions and (c) investigate the effects of select secretagogues on mucin secretion. The cell lines were established in ACL-4 medium containing several growth factors and retinoic acid and 5% fetal calf serum. The high molecular weight glycoconjugates secreted in the culture medium were purified by ammonium sulfate precipitation and Superose 6 and Superose 12 FPLC chromatography. The purified high molecular weight glycoconjugate fraction and the carcinoma cells were shown to have mucin by dot blot, Western blot and immunohistochemical analysis, respectively, using specific antibodies to purified major mucin, HTM-1. Also, incorporation experiments with mucin precursor ³H-glucosamine demonstrated that the cells indeed synthesize high molecular weight mucins. The effects of secretagogues such as, 8-bromocyclic AMP, ionomycin, phorbol-12-myristate-13-acetate and neutrophil elastase on mucin secretion were also investigated. Only 8-bromocyclic AMP and neutrophil elastase influenced mucin secretion. These studies provided strong evidence that the lung adenocarcinoma cell lines secrete high molecular weight mucins in culture conditions and only two of the four tested secretagogues significantly increased mucin secretion. Thus, this in vitro model system may be useful in determining alterations in mucin structure, if any, in lung adenocarcinomas as well as in studying the regulation of mucin gene expression.     

Rat monoclonal antitubulin antibodies derived by using a new nonsecreting rat cell line

Hybrid myeloma cell lines secreting monoclonal antibodies to tubulin have been prepared using rat myelomas and spleen cells from rats immunized with yeast tubulin. A comparison between the results obtained with the rat myeloma Y3-Ag 1.2.3., which secretes a light chain, and a new line, YB2/O, which does not, shows that they are both excellent parental lines and that the second produces hybrids with no myeloma chain components. The antitubulin antibodies in the serum of rats bearing two of the hybrid myeloma tumors gave titers of up to 1:10(6) from which large amounts of monoclonal antibodies could be easily purified. They recognized tubulin from yeast as well as from birds and mammals. The two antibodies gave clear immunofluorescent staining of yeast mitotic spindles as well as the interphase microtubule network of tissue culture cells. Some difference in the pattern of immunofluorescence staining of yeast cells and nuclei was observed between the two antibodies. The purified antibodies could be conjugated to colloidal gold particles and used for direct labeling of yeast microtubules for electron microscopy.     

Thymidine secretion by hybridoma and myeloma cells

Secretion of thymidine appeared to be a common property of hybridoma and myeloma cells, but not of other cell types, which were tested. Of three hybridoma cell lines tested, all secreted thymidine in amounts resulting in the accumulation of thymidine to concentrations of 10-20microM in the culture medium. Also three of five myeloma cell lines that were analyzed secrete thymidine, but none of the other cell types that were studied. Thymidine was purified to homogeneity (4mg purified from 3l of culture medium) and identified as such by nuclear magnetic resonance spectroscopy. The cells that secreted thymidine showed high resistance to the growth inhibitory effect of thymidine.     

Purification of an active plasminogen activator inhibitor immunologically related to the endothelial type plasminogen activator inhibitor from the conditioned media of a human melanoma cell line

24 established melanoma cell cultures were screened for their secretion of plasminogen activators and plasminogen activator inhibitors into the culture medium by sodium dodecyl sulfate-polyacrylamide gel electrophoresis followed by conventional and reverse fibrin autography. Among the cell lines investigated, 22 cell lines predominantly secreting tissue type plasminogen activator (t-PA) and four cell lines additionally secreting urokinase were found. The conditioned media of two cell lines (KRFM and MJZJ) were found to contain plasminogen activator inhibitor (PAI) activity at a Mr position of approximately 50,000. The PAI of one of the two melanoma cell (MJZJ)-conditioned media found to contain PAI activity was purified to apparent homogeneity employing concanavalin A-Sepharose chromatography, gel filtration on Sephadex G-150, chromatography on Affi-Gel blue, and affinity chromatography on a Sepharose 4B immobilized monoclonal anti-t-PA IgG column. The purified melanoma PAI was found to be a single chain protein, acid stable, immunologically related to the endothelial derived PAI. In contrast to endothelial PAI, melanoma PAI presented itself in the conditioned media of the melanoma cells and in the purified preparation to an appreciable extent in its active form.     

Activity of immunotoxins constructed with modified Pseudomonas exotoxin A lacking the cell recognition domain

Pseudomonas exotoxin (PE) contains three domains whose functions are cell recognition, membrane translocation, and ADP ribosylation of elongation factor 2. PE40 is a form of PE which is missing the cell recognition domain. To study the properties of PE40, it was expressed in Escherichia coli using a vector which contains a T7 phage promoter, an OmpA signal sequence, and that portion of the PE gene encoding PE40. Upon induction with isopropyl-1-thio-beta-D-galactopyranoside, large amounts of PE40 were secreted, and highly purified PE40 was prepared from the culture medium. PE40 was chemically coupled to different monoclonal antibodies, and protein synthesis inhibition activities of these immunotoxins was assessed on various cell lines. These activities were compared with the activities of the corresponding immunotoxins made with native PE. These data indicate that PE40 may be useful in the construction of certain immunotoxins.     

Inhibition of lymphocyte proliferation by antibodies to prolactin

Recent in vivo studies have shown that treatments that decrease circulating prolactin (PRL) in rodents result in significant immunosuppression. Our attempts to demonstrate corresponding direct stimulatory effects of PRL on cultured lymphocytes were unsuccessful. However, antibodies against pituitary PRL potently inhibited both murine and human lymphocyte proliferation in response to both T and B cell mitogens. Further studies using IL 2 and IL 4 responsive cell lines (CTLL-2 and HT-2) demonstrated that the same anti-PRL antibodies inhibited the proliferative response to these cytokine growth factors. Thus, antibodies to PRL appear to block an event occurring in the G1 to GS phase transition of these cell lines, which constitutively express growth factor receptors. The inhibitory activity of anti-PRL antibodies could be adsorbed by addition of purified human PRL or by immobilized PRL on an affinity column. Antibodies to other pituitary hormones were without inhibitory effect on CTLL-2 cell proliferation. Proliferation of lymphocytes in serum-free medium was also potently inhibited by anti-PRL antibodies, suggesting that antibody effects were not due to neutralization of PRL or other factors contained in culture serum supplements. We suggest from these data that a protein with homology to PRL and recognized by these anti-PRL antibodies is produced by lymphocytes and plays a critical role in their progression through the cell cycle.     

Three-dimensional culture of human tumor cells under standardized medium conditions

The 3-dimensional culture of human tumor spheroids under standardized medium conditions may reveal information on specific biological parameters that could be masked in serum-supplemented media. Spheroids derived from human tumor cells are growth retarded in media free of serum. Ex-Cyte IV is a substance derived from human blood that can be used to improve growth in tissue culture. In this study the growth of spheroids from four different human tumor cell lines was studied when grown in medium free of serum, medium supplemented with varying concentrations Ex-Cyte IV, and medium supplemented with foetal calf serum (FCS). The parameters used for comparisons were growth rate, growth enhancement, clonogenicity and cell cycle distribution.The four cell lines showed different growth rates in serum-free medium, which were increased to different extents when Ex-Cyte IV or FCS were added. The growth enhancing effect induced by Ex-Cyte IV was differently concentration dependent for each cell line. The clonogenicity of cells grown as spheroids in serum-free medium was lower than in spheroids grown in supplemented media. There was no difference in clonogenicity between the differently supplemented media. All four cell lines responded to growth in serum-free medium with a drop in the S-phase and G2M phase.The present study provides a novel approach to the study of human tumor cells in 3-dimensional culture under defined conditions. The human serum derived substance Ex-Cyte IV may provide a method to obtain information on specific biological parameters that could be masked in serum-supplemented media.     

The influence of the type of immunosorbent on rabies antibody EIA; advantages of purified glycoprotein over whole virus

Two types of in vitro assay (enzyme immunoassay and sero-neutralization test) for the titration of rabies antibodies were used to assay sera from mice and humans immunized with cell culture vaccines or neural tissue vaccines. Enzyme immunoassays (EIA) were performed in plates sensitized with whole virus, purified glycoprotein or purified nucleocapsid. Neutralizing antibody titres were determined by the rapid fluorescent focus inhibition test (REFIT) and by an in vitro seroneutralization test including a rapid enzyme immunotitration of intracellular antigens (REITICA). The results obtained with sera of immunized mice and humans showed that (1) cell culture vaccines mainly induced the synthesis of antiglycoprotein neutralizing antibodies; and (2) neural tissue vaccines induced a high synthesis of antinucleocapsid non-neutralizing antibodies and a more or less important synthesis of antiglycoprotein antibodies depending on the origin of the tissue used for their preparation. Consequently, it was emphasized that when using EIA, the antibody titration must be run in glycoprotein-coated plates rather than in whole virus-coated plates to appreciate correctly the immunizing potency of a rabies vaccine, especially neural tissue vaccine.     

Initiation and characterization of five embryonic cell lines from the cotton boll weevil anthonomus grandis in a commercial serum- free medium

Summary Five continuous cell lines were initiated from embryonic tissue of the cotton boll weevilAnthonomus grandis Boheman in a commercially available, serum-free medium (Excell 401) and have undergone in excess of 60 passages. Isoenzyme analysis confirmed that the lines originated from boll weevil tissue. Four of the lines grew as single attached cells of either epithelioid or fibroblastoid morphology. The fifth line, BRL-AG-2, grew primarily as cell aggregates and was found to release ecdysteroids (primarily ecdysone) into the culture medium. Evidence was also obtained suggesting that line BRL-AG-2 synthesizes chitin. Three lines, BRL-AG-1, BRL-AG-3A, and BRL-AG-3C, could be induced to produce an antibacterial factor(s) which was released into the culture medium.     

Free taxanes and the release of bound compounds having taxane antibody reactivity by xylanase in female,haploid-derived cell suspension cultures ofTaxus brevifolia

Summary Haploid cells derived from the female gametophyte ofTaxus brevifolia produce multinucleate egglike cells that have grown as cell suspensions over a 5-yr period. Two new media are formulated, one without nitrates, to select for haploid cell lines and to enhance free taxane production when cell lines are artificially aged by withholding subculture. The cell suspensions produce bound taxanes that are detectable with anti-taxane monoclonal antibodies on cell surfaces and on particles released into the culture medium. Recovery and detection of bound taxanes are based on a competitive inhibition enzyme immunoassay (CIEIA). Tissues extracted exhaustively with methanol then treated with xylanase release CIEIA-detectable taxanes. Approximately 300% more taxanes were detected in the xylanase-treated tissue culture material versus the control. Wood (winter bark) taken fromT. brevifolia and treated in the same way with xylanase release 20% more taxanes than could be detected in the control.     

Monoclonal antibodies to the antigens of human HeLa tumor cells

A panel of 6 hybridomas "XEJIMA" producing monoclonal antibodies specific to HeLa cells is prepared. Monoclonal antibodies do not bind to antigens of human diploid fibroblasts, human continuous B- and T-lymphocytes and animal cell lines. The specificity of monoclonal antibodies to cellular antigens of 5 HeLa-like cell lines and 6 human tumour cells lines, not contaminated with HeLa cells, is determined. Antibody containing ascitic fluid and culture media of hybridomas XEJIMA-3, -12, -13, and -22 significantly decrease the attachment of HeLa cells to the surface of culture flasks. Monoclonal antibodies XEJIMA-11, -12 and -13 block the multiplication of HeLa cells. The effect depends on serum concentration in the nutrient medium.     

Mitochondrial-specific thymidine kinase

Thymidine kinase activity has been demonstrated in purified mitochondria prepared from animal tissue, wild-type tissue culture cells, and BrdU-resistant cell lines. The BrdU-resistant cell lines lack a soluble cytoplasmic thymidine kinase present in wild-type cells, but continue to exhibit the minor mitochondrial activity. This elucidates the mechanism by which mitochondrial DNA is exclusively labeled in BrdU-resistant cells.     

Effect of Tyrosine on the Production of Alkaloids in the High-Yielding Cell Lines of Papaver somniferum Tissue Culture

The high yielding cell lines were isolated from the heterogenous callus culture of Papaver somniferum established on modified Murashige and Skoog’s medium. These cell lines were transferred to liquid medium, and maintained for six months by frequent subculturing. The tissues were supplied with different concentrations (12.5, 25, 50 and 100 mg/100 ml) of tyrosine and analysed quantitatively for their alkaloidal contents. Six major opium alkaloids-morphine, codeine, thebaine, narceine, narcotine and papaverine, were identified. The tissue grown on liquid medium supplemented with 12.5 mg tyrosine/100 ml showed maximum percentage of alkaloids and therefore this concentration is considered as the most favourable condition and can be utilized for the large scale production of alkaloids from the cell lines.     

Reduced lysyl oxidase activity in skin fibroblasts from patients with Menkes'' syndrome.

Lysyl oxidase activity against both collagen and elastin substrates has been examined in the culture medium of skin fibroblasts derived from unrelated patients with Menkes' syndrome and from control subjects. The medium of three Menkes' fibroblast lines showed 3--30% of the activity present in the medium of control fibroblasts, against a purified collagen substrate. Lysyl oxidase activity in the culture medium of two of the Menkes' fibroblast lines was also examined by using a crude aortic-elastin substrate and was similarly decreased in comparison with that in the medium of control fibroblasts. Lysyl oxidase activity in the medium of a fourth fibroblast line, derived from a foetus with Menkes' syndrome, was 42% of that in the medium of control fibroblasts derived from a 1-day-old baby against a collagen substrate, and 26% of that in control fibroblast medium against an elastin substrate. The copper content of the cell layers of the Menkes' fibroblast cultures was elevated in comparison with normal fibroblast cultures, as has previously been reported to be characteristic of such cells. It is suggested that the decrease in lysyl oxidase activity would help to explain the connective tissue defects observed in Menkes' syndrome, and that this reduction, in conjunction with the elevated concentrations of cellular copper, would support the hypothesis that a functional intracellular copper deficiency exists in Menkes' syndrome.     

A Library of Monoclonal Antibodies to Torpedo Cholinergic Synaptosomes

Abstract: A library of monoclonal antibodies was generated to the cholinergic synaptosome. The immunogen was a preparation of highly purified synaptosomes from Torpedo electric organ. One hundred forty-one hybridoma cell lines were generated from the fusion of a single mouse. Tests reveal these cells produce antibodies with a vast range of neuronal specificities. The initial screen for specificity of antibody production was solid phase radioimmune binding to the original, highly purified synaptosome preparation. Subsequent tissue specificity tests have indicated that most antibodies are synaptosome-specific amongst the fish tissues tested: brain, liver, and purified synaptic vesicles. Less than 11% cross-react with liver. Many antibodies cross-react with frog and rat CNS. Localization within the frog and rat nervous tissue has revealed a vast array of antibody staining patterns. Some antibodies stain in a synaptic fashion. A few stain a restricted set of mammalian CNS neurons. Others define a broader set of CNS neurons. These Torpedo antibodies promise to be valuable probes with which to describe the molecular cell biology of the nervous system, of neurons in general, and of cholinergic neurons in particular.     

向日葵Ti T—DNA转化系的原生质体培养和细胞培养

根癌农杆菌离体感染向日葵子叶、下胚轴外植体形成的Ti T-DNA转化组织在激素条件下长期继代培养后,用来进行原生质体培养和细胞培养。适于B6S3转化系和T37转化系原生质体培养的培养基分别为附加不同激素和糖类的C81V和DPD培养基。用液体浅层法培养3～5天时,原生质体开始分裂。10天后形成细胞团。B6S3转化系还可直接从原生质体产生原胚状结构。转化系的细胞克隆均保持着激素自主型生长特性和冠瘿碱合成酶合成特性。     

Monoclonal antibody analysis of Perkinsus marinus extracellular products

The protozoan oyster parasite Perkinsus marinus releases a complex set of extracellular products (ECP) during in vitro culture. These products have been previously implicated in parasite virulence, and their expression can be altered by medium supplementation with oyster tissue homogenate. Little is known regarding ECP function, regulation, or mechanism of storage and release. Perkinsus marinus ECP were purified from a protein-free medium and used to produce a panel of five monoclonal antibodies. Several of the antibodies recognised series of proteins implying that the ECP may originate from comparatively few parental molecules. The ECP are secreted by several pathways, including the release of one product from an external cell layer, and two other products from two morphologically distinct intracellular compartments. Antibodies against separate epitopes on one protein provided information about possible protein structure. A sandwich ELISA format allowed sensitive quantification of that protein and showed significantly reduced protein expression in oyster tissue homogenate supplemented cultures. Immunopurification allowed tandem mass spectroscopic amino acid sequencing of that protein. Another antibody was used to characterise the P. marinus cell wall. This antibody specifically bound to trophozoite and tomont walls, and was used to investigate the morphological and antigenic changes in these walls during Ray's fluid thioglycollate medium-induced formation of hypnospores. It was also used to confirm that oyster tissue homogenate supplementation could induce formation of hypnospores. This antibody labeled P. marinus cells in fixed oyster tissue in a species-specific manner.     

Manipulation of heterogeneous hybridoma cultures for overproduction of monoclonal antibodies.

In searching for ways to manipulate heterogeneous hybridoma cell cultures (ATCC HB124) to obtain increased production of monoclonal antibodies (IgG2a), we have selected for a higher secreting but slower growing subpopulation using the level of fluorescent surface-associated antibodies and a fluorescence-activated cell sorter. Cell surface fluorescence was found to be correlated with specific antibody secretion rate over the short term but not with intracellular antibody content. Also, the specific secretion rate of a heterogeneous population of hybridoma cells grown in batch culture has been shown to be inversely correlated with an increase in either the initial cell concentration or the medium antibody concentration. Several experiments suggest that an upper limit exists for medium antibody concentration, above which antibody is degraded at the same rate at which it is produced. Should other cell lines behave similarly, strategies for overproduction of monoclonal antibodies suggested herein could be profitably used in industry.