Stability of the lipase immobilized on DEAE-Sephadex for continuous lipid hydrolysis in organic solvent

Summary Continuous hydrolysis reaction was carried out in glass-column by using lipase fromCandida rugosa immobilized on DEAE-Sephadex A50. Substrate olive oil dissolved in hydrophobic organic solvent (isooctane) was supplied into the reactor with a concurrent stream of aqueous buffer. Stability of the immobilized enzyme was greatly increased in higher substrate concentration. Glyccrol added in the aqueous stream showed stabilizing effect against the organic solvent; half life was extended from 220 hrs to 450 hrs by 15% glycerol supplemented at 30°C.     

Characteristics of immobilized lipase-catalyzed hydrolysis of olive oil of high concentration in reverse phase system

Candida rugosa lipase immobilized by adsorption on swollen Sephadex LH-20 could almost completely hydrolyze 60% (v/v) olive oil in isooctane. Kinetic analysis of the lipase-catalyzed hydrolysis reaction was found to be possible in this system. Amount of fatty acids produced was linearly proportional to the enzyme concentration of 720 mug/g wet gel. The specific enzyme activity was 217 units/mg protein at 60% (v/v) olive oil concentration. When the initial rate is plotted versus concentration of olive oil, this system did not follow Michaelis-Menten kinetics. Maximum activity was obtained at pH 7, but optimum temperature shifted towards higher one with the increase of olive oil concentration. Among the various chemical compounds tested, Hg(2+) and Fe(2+) inhibited the lipase seriously. As the concentration of olive oil increased, the rate of the hydrolysis also increased, but degree of the hydrolysis was observed to decrease. The supply of water from the inside of the gel to the surface of the gel was the main factor for the control of the rate of hydrolysis in batch hydrolysis. The immobilized lipase was used to hydrolyze olive oil two times. Achievement of chemical equilibrium took a longer time with the addition of water and the degree of hydrolysis decreased in the second consecutive trial. After the second hydrolysis trial, the gels were regenerated in a packed column first by eluting out both residual fatty acids around the gel particles and the accumulated glycerol with ethanol and then with 0.05M phosphate buffer, pH 7. The immobilized lipase on the regenerated gel showed the same hydrolysis activity as the original one.     

Continuous glycerolysis of olive oil by Chromobacterium viscosum lipase immobilized in liposome in reversed micelles

Chromobacterium viscosum lipase which has adsorbed on liposome and solubilized in microemulsion droplets of glycerol containing a little amount of water could catalyze the glycerolysis of olive oil. Studies on the continuous glycerolysis of olive oil by the immobilized enzyme was done at 37 degrees C in continuous stirred vessel bioreactor with polysulfone membrane. The effect of the flow rate of substrate (olive oil) in isooctane on the conversion and composition of the outlet was investigated using high-performance liquid chromatography (HPLC). The conversion increased with decrease in the flow rate. And we studied the effect of water content in the glycerol-water-lipase solution on the glycerolysis reaction. The conversion to desirable products, mono- and di-olein, was improved without a substantial production of oleic acid at lower water concentrations, i.e., below 8.0% (w/v) which corresponds to a w(o) value of 0.97. At water concentration higher than 8.0% (w/v), the amount of free fatty acid was dramatically increased. Higher operational stability of the enzyme reactor, and the half-line of the enzyme continuous reaction was about 7 weeks.     

Hydrolysis of rice bran oil using an immobilized lipase from Candida rugosa in isooctane

The kinetics of enzymatic hydrolysis of rice bran oil in isooctane by immobilized Candida rugosa lipase in a batch reactor showed competitive inhibition by isooctane with a dissociation constant, K1, of 0.92 M. Continuous hydrolysis of rice bran oil was performed in recycling, packed bed reactor with 4352 U of immobilized lipase; the optimum recycle ratio was 9 and the operational half-life was 360 h without isooctane but 288 h with 25% (v/v) isooctane in rice bran oil.     

Kinetics of olive oil hydrolysis in an enzyme membrane reactor. Bond graph network model of reactor performance (part 1)

Hydrolyses of olive oil were performed in a reactor with lipase immobilized on a laboratory ultrafiltration poliamide-6 membrane. The reactor consisted of two circulating phases of olive oil and buffer solution. For the characterization of the reactor performance, a model of the hydrolysis process was developed. It was created by means of thermodynamic network representation of both the chemical processes and the transport of the reactants. According to an estimated bond graph network, the model is represented quantatively by a set of thirty-three differential equations representing the time derivatives of the particular species concentration. The parameters of the model were estimated based on experimental data and/or literature notations. Close agreement of numerical estimations of the product concentrations with experimental data was gained. The model enabled an extended analysis of the influence of different reaction parameters, enzyme inhibition and concentration of the reactants on reactor performance.     

Immobilization of penicillin G acylase on aminoalkylated polyacrylic supports

A procedure is described for the immobilization of penicillin G acylase (PA) on Amberlite XAD7 modified by transamidation with 1,2-ethylenediamine and activated with glutaraldehyde. Reduction with sodium borohydride of the Schiff's bases formed between the amino groups of the protein and glutaraldehyde results in a dramatic improvement of the operational stability of the immobilized enzyme without affecting the catalytic activity. The enzyme kept in presence of the substrate, penicillin G, displays an increased stability with respect to that stored in pure phosphate buffer solution. The inactivation kinetics of the immobilized preparations of PA, determined in a continuous fixed bed reactor, as well as a discontinuous batch reactor, are reported.     

Enantioselective synthesis of (S)‐naproxen using immobilized lipase on chitosan beads

S‐naproxen by enantioselective hydrolysis of racemic naproxen methyl ester was produced using immobilized lipase. The lipase enzyme was immobilized on chitosan beads, activated chitosan beads by glutaraldehyde, and Amberlite XAD7. In order to find an appropriate support for the hydrolysis reaction of racemic naproxen methyl ester, the conversion and enantioselectivity for all carriers were compared. In addition, effects of the volumetric ratio of two phases in different organic solvents, addition of cosolvent and surfactant, optimum pH and temperature, reusability, and inhibitory effect of methanol were investigated. The optimum volumetric ratio of two phases was defined as 3:2 of aqueous phase to organic phase. Various water miscible and water immiscible solvents were examined. Finally, isooctane was chosen as an organic solvent, while 2‐ethoxyethanol was added as a cosolvent in the organic phase of the reaction mixture. The optimum reaction conditions were determined to be 35 °C, pH 7, and 24 h. Addition of Tween‐80 in the organic phase increased the accessibility of immobilized enzyme to the reactant. The optimum organic phase compositions using a volumetric ratio of 2‐ethoxyethanol, isooctane and Tween‐80 were 3:7 and 0.1% (v /v/v), respectively. The best conversion and enantioselectivity of immobilized enzyme using chitosan beads activated by glutaraldehyde were 0.45 and 185, respectively.     

Repeated batch and continuous operations for phosphatidylglycerol synthesis from phosphatidylcholine with immobilized phospholipase D

Summary The repeated batch and continuous operations for transphosphatidylation reaction were carried out for phosphatidylglycerol (PG) synthesis from phosphatidylcholine (PC) with the help of immobilized cabbage phospholipase D (PLD) in the presence of glycerol. The biphasic reaction system was used which included the aqueous phase containing immobilized PLD along with high concentrations of glycerol (30%–50%) and buffer, whereas the main part of substrate (PC) and products (mainly PG) formed were in the organic phase (diethyl ether).Octyl-Sepharose CL-4B having a hydrophobic octyl group was chosen for the PLD immobilization. Both immobilization yield and activity yield of immobilized enzyme were 100%. The effects of solvents, temperature and glycerol concentrations on the immobilized PLD were examined. Repeated batch conversion of PC (15 g/l) to PG was examined with the immobilized PLD in 30% glycerol. In all five batch cycles examined, 100% selectivity was obtained and there was no significant decrease in the fractional conversion of PC to PG (98%–99%) in the first three batch cycles. In the cases of a packed-bed reactor (PBR) and a continuous stirred-tank reactor (CSTR) used for continuous synthesis of PG with the immobilized PLD, the operational stabilities of the immobilized enzyme were almost the same (half life=14 h at 30°C) when purified PC was used, while in the case of partially purified PC in CSTR the half life increased more than five times.Abbreviations used PC phosphatidylcholine - PG phosphatidylglycerol - PA phosphatidic acid - PLD phospholipase D - PBR packed bed reactor - CSTR continuous stirred tank reactor Studies on enzymatic conversion of phospholipids (III)     

Lipase-catalyzed hydrolysis of olive oil in chemically-modified AOT/isooctane reverse micelles in a hollow fiber membrane reactor

The hydrolysis of olive oil catalyzed by Candida rugosa lipase in sodium bis(2-ethylhexyl)sulfosuccinate (AOT)/isooctane and the synthetic sodium bis(2-ethylhexyl polyoxyethylene)sulfosuccinate (MAOT)/isooctane reverse micellar systems was investigated in a polysulfone hollow fiber membrane reactor with recycle of the reaction mixture. Lipase was completely retained by the membrane while olive oil and oleic acid freely passed through. The retention of reverse micelles depended on W ₀ (molar ratio of water to surfactant). At an olive oil concentration of 0.23 mol l^–1 the final substrate conversion in the MAOT micellar system was about 1.4 times of that in the AOT micellar system.     

Effect of solvents on hydrolysis of olive oil by immobilized lipase in reverse phase system

Summary Lipase fromCandida rugosa was immobilized by adsorption on three supports which could contain water available for the hydrolysis of olive oil in a reverse phase system. To select the most suitable solvent for this system, the effect of organic solvents on the stability and catalytic activity of immobilized lipase for the hydrolysis reaction has been examined. The results revealed that isooctane was superior to any other solvents tested in this study for enzymatic fat splitting in a reverse phase system. Also the effect of the solvent polarity on the hydrolysis of olive oil has been examined in detail using various organic solvents mixed with an equivolume of isooctane. It was found that the hydrolysis of olive oil by immobilized lipase was markedly affected by the polarity of reaction solvents.     

A comparative study of immobilized amyloglucosidase in a packed bed reactor and a continuous feed stirred tank reactor

The catalytic activity of amyloglucosidase covalently attached to DEAE-cellulose was studied in a packed bed reactor and a continuous feed stirred tank reactor (CSTR) for the reaction maltose → glucose. At low flow rates mass-transfer limitations in the bed reactor lead to lower conversions for this reactor compared to the CSTR. Simple theoretical expressions for these reactors were compared with the experimental results. There are significant differences between the kinetic parameters and pH profile of the immobilized and free enzyme. The immobilized enzyme also showed greater stability at 50°C than did free amyloglucosidase. The temperature dependence of the reaction rate was the same for immobilized and free enzyme.     

Hydrolysis of olive oil catalyzed by surfactant-coated<Emphasis Type="Italic">Candida rugosa</Emphasis> lipase in a hollow fiber membrane reactor

In this study, we invetigated the hydrolysis of olive oil catalyzed by a surfactant-coatedCandida rugosa lipase in a hydrophilic polyacrylonitrile hollow fiber membrane reactor and then compared the results to those using the native lipase. The organic phase was passed through the hollow inner fibers of the reactor and consisted of either the coated lipase and olive oil dissolved in isooctane or the coated lipase dissolved in pure olive oil. The aqueous phase was pumped through the outer space. After 12 h and with conditions of 30°C, 0.12 mg enzyme/mL and 0.62 M olive oil, the substrate conversion of the coated lipase reached 60%. This was twice the conversion for the same amount of native lipase that was pre-immobilized on the membrane surface. When using pure olive oil, after 12 h the substrate conversion of the coated lipase was 50%. which was 1.4 times higher than that of the native lipase.     

Entrapment of lipase into K-carrageenan beads and its use in hydrolysis of olive oil in biphasic system

The porcine pancrease lipase was immobilized by entrapment in the beads of K-carrageenan and cured by treatment with polyethyleneimine (PEI) in the phosphate buffer. The retention of hydrolytic activity of lipase and compressive strength of the beads were examined. The activity of free and immobilized lipase was assessed by using olive oil as the substrate. The immobilized enzyme exhibited a little shift towards acidic pH for its optimal activity and retained 50% of its activity after 5 cycles. When the enzyme concentration was kept constant and substrate concentration was varied the K_m and V_max were observed to be 0.18 × 10⁻² and 0.10, and 0.10 × 10⁻² and 0.09 respectively, for free and for entrapped enzymes. When the substrate concentration was kept constant and enzyme concentration was varied, the values of K_m and V_max were observed to be 0.19 × 10⁻⁷ and 0.41, and 0.18 × 10⁻⁷ and 0.41 for free and entrapped enzymes. Though this indicates that there is no conformational change during immobilization, it also shows that the reaction velocity depends on the concentration. Immobilized enzyme showed improved thermal and storage stability. Hydrolysis of olive oil in organic–aqueous two-phase system using fixed bed reactor was carried out and conditions were optimized. The enzyme in reactor retained 30% of its initial activity after 480 min (12 cycles).     

Activity and operational stability of immobilized mandelonitrile lyase in methanol/water mixtures

Summary The enzyme mandelonitrile lyase was covalently immobilized on solid support materials using different methods. Immobilization on porous silica using coupling with glutaraldehyde afforded preparations with high enzyme loading (up to 9% (w/w)). The immobilized enzyme was used in a packed bed reactor for the continuous production of d-mandelonitrile from benzaldehyde and cyanide. The influence of the flow rate, pH, substrate concentrations and enzyme loading on the reaction yield and the enantiomeric purity of the product was investigated. In order to suppress the competing spontaneous reaction, the enzymatic reaction must be rapid. A flow rate of 9.5 ml/min (0.1 M benzaldehyde and 0.3 M HCN) through a 3 ml reactor afforded a 86% yield of mandelonitrile with 92% enantiomeric excess. No leakage of enzyme occurred under continuous operation. One column was used continuously for 200 h without any decrease in yield or enantiomeric purity of the product. High concentrations of benzoic acid were shown to decrease the operational stability of the system.     

Purification and characterization of a lipase from Pichia burtonii

An extracellular lipase from Pichia burtonii was purified to homogeneity by a combination of DEAE-Sephadex A-50 ion-exchange chromatography, Sephadex G-100 gel filtration, and isoelectric focusing. The purified enzyme preparation showed a single protein band corresponding to a molecular mass of 51 kDa on sodium dodecyl sulphate/polyacrylamide gel electrophoresis. The molecular mass of the enzyme was estimated to be 47 kDa on Superdex 200 gel filtration, suggesting that the enzyme was a monomeric protein. The pI was about 5.8. The optimum pH and temperature for the hydrolysis of olive oil were about 6.5 and 45°C respectively. Rapid loss of the enzyme activity was observed above 30°C in the absence of olive oil, but the addition of olive oil or trimethylolpropane diallyl ether greatly stabilized the enzyme. At 30°C, the enzyme hydrolysed Spans and Tweens as well as simple triglycerides of short- and middle-chain fatty acids. Although the enzyme cleaved all the ester bonds of triolein, it showed some preference for the outer ester bonds.     

Effect of water on hydrolysis of olive oil by immobilized lipase in reverse phase system

Summary Candida rugosa lipase immobilized by adsorption on the swollen Sephadex LH-20 and Sephadex LH-60 could effectively hydrolyze olive oil at high concentration in a reverse phase system. Initial water content was found to be the most important factor that determines both the hydrolysis rate and the degree of hydrolysis; approximately 54% of water in the gels was readily utilized.     

Enzymatic catalysis in microemulsions: enzyme reuse and product recovery

A technique for enzyme reuse and product recovery from enzymatic catalysis in microemulsions is demonstrated. The enzymatic reaction is performed in a homogeneous isotropic microemulsion; AOT (sodium bis-(2-ethyl- hexyl)sulfosuccinate)/isooctane/buffer or C(12)E(5)(penta ethylene glycol dodecyl ether)/heptane/buffer. By small temperature changes the systems are shifted to two phase regions, where an oil-rich phase, containing the product, coexists with a water-rich phase containing surfactant and enzyme. The oil-rich phase may be replaced by an oil solution containing new substrate. Thus, the reaction may be continued and the enzyme reused. This procedure was repeated nine times in the present study. Data on phase behavior in presence and in absence of protein, partitioning of the components and a radioactive-labelled protein between the phases, and the repeated use of horse liver alcohol dehydrogenase (HLADH) in the microemulsions are presented.     

Immobilization of chitosan-invertase neoglycoconjugate on carboxymethylcellulose-modified chitin

Saccharomyces cerevisiae invertase, chemically modified with chitosan, was immobilized on a carboxymethylcellulose-coated chitin support via polyelectrolyte complex formation. The yield of immobilized protein was determined to be 72% and the enzyme retained 68% of the initial invertase activity. The optimum temperature for invertase was increased by 5 degrees C and its thermostability was enhanced by about 9 degrees C after immobilization. The immobilized enzyme was stable against incubation in high ionic strength solutions and was 12.6-fold more resistant to thermal treatment at 65 degrees C than the native counterpart. The prepared biocatalyst retained 98% and 100% of the original catalytic activity after 10 cycles of reuse and 70 h of continuous operational regime in a packed bed reactor, respectively. The immobilized enzyme retained 95% of its activity after 50 days of storage at 37 degrees C.     

Immobilization of chitosan-modified invertase on alginate-coated chitin support via polyelectrolyte complex formation

Saccharomyces cerevisiae invertase was chemically modified with chitosan and further immobilized on sodium alginate-coated chitin support. The yield of immobilized protein was determined as 85% and the enzyme retained 97% of the initial chitosan-invertase activity. The optimum temperature for invertase was increased by 10 °C and its thermostability was enhanced by about 9 °C after immobilization. The immobilized enzyme was stable against incubation in high ionic strength solutions and was four-fold more resistant to thermal treatment at 65 °C than the native counterpart. The biocatalyst prepared retained 80% of the original catalytic activity after 50 h under continuous operational regime in a packed bed reactor.     

微水——有机溶剂两相体系中消旋萘普生的酶法拆分

研究了微水－有机溶剂两相体系中固定化脂肪酶催化的萘甲酯的立体选择性水解反应,固定化酶活性受载体极性、水含量、有机溶剂的ｌｏｇＰ值,产物抑制的影响,据此构建了一种可以连续拆分产生（Ｓ）－（＋）－萘普生的微水－有机溶剂两相体系。反应在一个具有回路的连续流搅拌反应器中进行,反应器中添加有采用吸附法固定化的脂肪酶,截体为一种弱极性的合成载体,水相连同固定化酶颗粒一起永久保持在反应器中,有机流动相带入底物,