Effect of low initial C/N ratio on aerobic composting of swine manure with rice straw

Two pilot composting experiments were conducted to investigate the effect of low initial C/N ratio on the composting of swine manure with rice straw by measuring physical and chemical parameters. The results showed that the thermophilic duration of bin 1 and bin 2 was long enough to satisfy the sanitary standard, and swine manure could reach maturity. Bin 1 containing larger amount of swine manure and less amount of rice straw showed a higher nitrogen loss (8%), shorter thermophilic phase, and longer maturity time (about 2 weeks) than bin 2. However, economical analysis showed a lower initial C/N ratio (20) could reduce 172 kg rice straw per ton fresh swine manure than a higher C/N ratio (25), and more swine manure could also be treated. Therefore, a low initial C/N ratio (20) could be suggested in the composting of swine manure with rice straw.     

葡萄籽对猪粪秸秆高温堆肥中微生物群落与碳氮含量的影响

以猪粪与秸秆(鲜质量10.5∶1)为基础,在自制的强制通风静态堆肥反应箱中进行堆肥化试验,研究添加8%葡萄籽对猪粪秸秆高温堆肥中微生物群落演替和碳氮转化的影响.在堆肥化的30 d里,分7次采集不同时期的堆肥样品,测定堆肥中微生物区系、微生物生理群的数量及堆肥碳氮含量.结果表明：添加葡萄籽使堆肥中细菌数量略高、放线菌数量显著增加、真菌数量明显降低,细菌/放线菌下降;氨化细菌和反硝化细菌数量降低;而硝化细菌、固氮菌和纤维素分解菌数量增多;铵态氮和有机碳含量下降,而硝态氮含量明显提高.堆肥中硝态氮含量与放线菌数量呈极显著正相关关系.添加葡萄籽使堆体升温快且高温期稳定,堆肥含水率波动较小,从而使堆肥高温期放线菌和亚硝化细菌的波动较小,数量较高,有利于堆肥中硝态氮含量的增加.     

Composting of high moisture content swine manure with corncob in a pilot-scale aerated static bin system

Pilot composting experiments of swine manure with corncob were conducted to evaluate the performance of the aerated static bin composting system. Effects of temperature control (60 and 70 degrees C) and moisture content (70% and 80%) were monitored on the composting by measuring physical and chemical indexes. The results showed that (1) the composting system could destroy pathogens, converted nitrogen from unstable ammonia to stable organic forms, and reduced the volume of waste; (2) significant difference of NH(4)(+)-N (P(12) = 0.074), and (NO(3)(-) + NO(2)(-))-N (P(12) = 0.085) was found between the temperature control treatments; (3) anaerobic reaction in the treatment with 80% moisture content resulted in significant difference of pH (P(23) = 0.006), total organic matter (P(23) = 0.003), and germination index (P(23) = 0.040) between 70% and 80%. Therefore, the optimum initial moisture content was less than 80% with the composting of swine manure and corncob by using the composting system.     

Effects of struvite formation and nitratation promotion on nitrogenous emissions such as NH3, N2O and NO during swine manure composting

To reduce nitrogenous emissions from composting, two different countermeasures were applied simultaneously in swine manure composting. One was forming struvite by adding Mg and P at the start of composting, and the other was to promote nitratation (nitrite being oxidized nitrate) by adding nitrite-oxidizing bacteria after the thermophilic phase of composting. In the laboratory- and mid-scale composting experiments, 25-43% of NH3, 52-80% of N2O and 96-99% of NO emissions were reduced. From the nitrogen balance, it was revealed that the struvite formation reduced not only NH3, but also other nitrogenous emissions except N2O. The amount of total nitrogen losses was reduced by 60% by the two combined countermeasures, against 51% by the struvite formation alone. However, the nitratation promotion dissolved struvite crystals due to the pH decline, diminishing the effect of struvite as a slow-release fertilizer.     

Changes in biochemical and microbiological parameters during the period of rapid composting of dairy manure with rice chaff

Various parameters were measured during the period of composting of dairy manure and rice chaff in different ratios (dairy manure/rice chaff=V/V, pile 1: 75/25; pile 2: 80/20; pile 3: 85/15) to evaluate their suitability as indicators for the composting process. The temperature in pile 1 increased rapidly and remained above 60 °C for 30 days, while the temperature in pile 3 increased slowly relative to the other two piles. Furthermore, the degradation of organic substrates, as indicated by the reduction of C/N ratio, was rapid in pile 1 (below 20% 28 days after beginning of the composting). The major fluctuations of various water-soluble fractions in all piles were observed during the first 3 weeks, and the results in general showed that the highest microbial populations and enzymatic activities also appeared in this phase. Various parameters indicated that the rapid composting method was a feasible one for treating agricultural wastes.     

Patterns and quantities of NH(3), N(2)O and CH(4) emissions during swine manure composting without forced aeration--effect of compost pile scale

To evaluate the NH(3), N(2)O, and CH(4) emissions from composting of livestock waste without forced aeration in turned piles, and to investigate the possible relationship between the scale of the compost pile and gas emission rates, we conducted swine manure composting experiments in parallel on small- and large-scale compost piles. Continuous measurements of gas emissions during composting were carried out using a chamber system, and detailed gas emission patterns were obtained. The total amount of each gas emission was computed from the amount of ventilation and gas concentration. NH(3) emission was observed in the early period of composting when the material was at a high temperature. Sharp peaks in CH(4) emission occurred immediately after swine manure was piled up, although a high emissions level continued after the first turning only in the large-scale pile. N(2)O emissions started around the middle stage of the composting period when NH(3) emissions and the temperature of the compost material began to decline. The emission rates of each gas in the small and large piles were 112.8 and 127.4 g NH(3)-N/kg T-N, 37.2 and 46.5 g N(2)O-N/kg T-N, and 1.0 and 1.9 g CH(4)/kg OM, respectively. It was found that changing the piling scale of the compost material was a major factor in gas emission rates.     

Effect of aeration on composting of date palm residues contaminated with Fusarium oxysporum f.sp. albedinis

Composting of date palm (Phoenix dactylifera L.) residues contaminated with Fusarium f.sp oxysporum albedinis, causal agent of the vascular wilt (Bayoud) of the date palm, has been achieved. The effect of the aeration of the piles by manual turning has been studied. The maintenance of an adequate humidity of 60%-70%, necessary to the good progress of the composting process, required the contribution of 11.4 L of water/kg of the dried residues. The evolution of the temperatures in the three piles presents the same phases. A latency phase, followed after 2-3 d of composting by a thermophilic phase, which lasts about 24 d, where the temperature remains elevated between 50 and 70 degrees C. Then a cooling phase that takes about 15 d, during which the temperatures fall to values between 25 and 35 degrees C, near room temperature. Fusarium f.sp oxysporum albedinis is eliminated completely during the thermophilic phase of composting, and increasing frequencies of turning accelerate its disappearance to a certain extent. On the other hand, pH remained steady and relatively basic oscillating between 8.2 and 8.7. Ninety percent (90%) of the the date palm residues are composed exclusively of organic matters. The total nitrogen represents only 0.4%. The contribution of manure decreases the ratio of carbon to nitrogen (C/N) from 115 to 48 in the initial mixture. After 80 d of composting and according to the frequency of return up, there is a reduction of the granulometry of the substratum, the C/N ratio (from 29% to 44%), the organic matter (from 15% to 23%), the total volume (from 25% to 35%), and of the dry weight of the swaths (from 16% to 24%). On the other hand there is an increase in total nitrogen rate (from 20% to 40%) and in the mineral matter (from 23% to 35%).     

Effect of carbon source on compost nitrogen and carbon losses

The effect of C source on N losses by volatilization during composting was measured using four bulking agents, each at three humidity levels and composted in duplicate under passive and active aeration. The bulking agents were pine shavings alone and corrected with soybean, chopped grass hay alone and corrected with urea, long (unchopped) wheat straw and chopped oat straw. The readily available C of each bulking agent was determined by analyzing for BOD5. In 105 l laboratory vessels, the bulking agents were mixed with liquid swine manure and tap water for a C/N of 20 and three humidity levels of 60%, 65% and 70%. While being aerated actively or passively, the mixtures were composted for 21 days. Their initial and final C and N contents were measured to conduct a mass balance analysis and calculate C and N losses. C and N losses were compared to bulking agent BOD5. N losses were compared to C losses. The humidity level and aeration regime had no effect on C and N losses but the N losses were correlated to C losses and only the C losses could be correlated to the BOD5 of the bulking agent. Thus, the N losses are related not only to the availability of C but also to the extent of composting. A relationship established between N and C losses indicated that 85% of the initial total N of the compost was available for microbial degradation and that 70% of the available C was lost as CO2 during the immobilization process.     

蚯蚓堆制处理对农业有机废弃物的化学及生物学影响的主成分分析

在实验室可控条件下,以碳氮比28.7∶1的农业有机废弃物（牛粪和稻秆）为赤子爱胜蚓(Eisenia foetida)的培养基质,研究蚯蚓的堆制作用对有机物料的化学及生物学特性的影响.结果表明： 蚯蚓堆制处理30 d后,基质pH值、碳氮比显著降低,全磷显著升高,而全氮、碱解氮、可溶性碳、速效磷、微生物生物量碳、呼吸速率和微生物熵分别提高8.5%、2.6%、18%、63%、212%、44%和300%,有机质、呼吸熵分别降低5.0%和21.9%.蚯蚓堆制处理后物料具有较高的转化酶、酸性和碱性磷酸酶活性,较低的过氧化氢酶和脲酶活性.多元数据分析结果显示,自然堆制和蚯蚓堆制处理物料的化学和生物学特性均呈现显著的差异性.蚯蚓堆制处理优于自然堆制处理,可以明显改善有机物料的化学、生物学性质,是一种高效率处理农业有机废弃物的技术.     

Ammonia emissions during vermicomposting of sheep manure

The effect of C:N ratio, temperature and water content on ammonia volatilization during two-phase composting of sheep manure was evaluated. The aerobic phase was conducted under field conditions. This was followed by Phase II, vermicomposting, conducted in the laboratory under controlled conditions of water content (70% and 80%) and temperature (15 and 22 °C). The addition of extra straw lead to a 10% reduction in NH3 volatilization compared to sheep manure composted without extra straw. Temperature and water content significantly effected ammonia volatilization at 0 day in Phase II, with a water content of 70% and temperature of 22 °C leading to greater losses of ammonia. Nitrogen loss by ammonia volatilization during vermicomposting ranged from 8% to 15% of the initial N content. The addition of extra straw did not result in significant differences in total carbon content following vermicomposting.     

High yield of poly-gamma-glutamic acid from Bacillus subtilis by solid-state fermentation using swine manure as the basis of a solid substrate

Solid-state fermentations (SSF), using swine manure as the basis of a solid substrate, were carried out for high yield of poly-gamma-glutamic acid (gamma-PGA) by Bacillus subtilis CCTCC202048. Fermentation medium and process parameters were optimized through three orthogonal array designs. The optimal medium consisted of 62.3% (w/w, dry weight basis) swine manure, 25.0% soybean cake, 5.0% wheat bran, 5.0% glutamic acid, 2.5% citric acid and 0.2% MnSO4.H2O. The optimal process parameters were 15.0 g medium with initial moisture content 60% and initial pH 9.0 in 250 ml flask, inoculation at mid-log phase with a 4% inoculum level and cultivation for 48 h at 37 degrees C. The average-PGA yield (6.0%) in triplicate under optimal conditions was obtained on the laboratory scale while it was 4.5% at compost experiment. These would lay a foundation for lessening the pollution of swine manure, increasing fertilizer efficiency and exploring a late-model organic fertilizer that retains water and nutrients.     

Composting of de-inking paper sludge with poultry manure at three nitrogen levels using mechanical turning: behavior of physico-chemical parameters.

De-inking paper sludge (DPS) is rich in carbon (C) but poor in nitrogen (N). Thus, it has a high C:N ratio which limits the composting process. Accordingly, the goal of this study was to investigate the effect of three N treatments on DPS composting. Compost piles of 100 m3 were formed by mixing raw DPS with poultry manure and chicken broiler floor litter, giving on average 0.6%, 0.7% and 0.9% total N. The changes in physico-chemical parameters, total weight and fiber losses, and maturity of composting piles of DPS were monitored during 24 weeks. The compost piles had a neutral to alkaline pH throughout the study. Inorganic N decreased whereas organic N increased over time for all treatments. These changes in magnitude were different among N treatments resulting in a final total N content of 0.9% for the 0.6% N treatment whereas final total N contents of 0.7% and 0.9% N were measured for the 0.7% and 0.9% N treatments. The total weight, cellulose and hemicellulose losses were higher in 0.6% N treatment giving the lowest C:N ratio after 24 weeks of composting. However, none of the 24 week-old composts of DPS were mature based on their final C:N ratio and colorimetric test of maturity. Except for copper, their final total trace element contents meet most known standards or guidelines for organic soil conditioners. Overall, 0.6% N treatment was the best to enhance DPS composting using mechanical turning, but a period of more than 24 weeks was required to reach compost maturity.     

Effect of turning regime and seasonal weather conditions on nitrogen and phosphorus losses during aerobic composting of cattle manure

Cattle manure from stock bedded on straw was aerobically composted under ambient conditions, turning with either a tractor-mounted front-end loader or a rear discharge manure spreader. Three composting experiments, each of approximately four months duration, were conducted to investigate the effect of turning regime and seasonal weather conditions on nitrogen and phosphorus losses during aerobic composting of cattle manure. Manure stacks of 12-15 m(3) initial volume were constructed in separate 5 x 5 m concrete compartments. Experiment 1 (January-April 1999) compared manure heaps turned once (T1) or three times (T3) using a front-end loader with an unturned static (S) control manure stack. Experiment 2 (June-September 1999) compared the same treatments as Experiment 1. Experiment 3 (September-December 1999) compared T1 and T3 turning regimes using a front end loader with turning by a rear-discharge spreader (TR1 and TR1T2) for more effective aeration of the manure. Turning took place at 6 weeks for the one turn treatments, and after 2, 6 and 10 weeks for the three turn treatments. Leachate losses were dominated by NH(4)-N during the first three weeks of composting, after which time NH4-N and NO3-N concentrations in leachates were approximately the same, in the range 0-20 mg N l(-1). The concentrations of both NH4-N and NO3-N in leachate were higher after turning. Molybdate-reactive P concentrations in leachate tended not to be significantly influenced by turning regime. Gaseous losses of NH3 and N2O rose quickly during the initial phases of composting, peaking at 152 g N t(-1) d(-1) for the T3 treatment. Mean NH3 emission rate (25-252 g N t(-1) d(-1)) for the first two weeks of Experiment 2 conducted during the period June-September were an order of magnitude greater (1-10 g N t(-1) d(-1)) than Experiment 3, conducted during the colder, wetter autumn period (September-December). Nitrous oxide emission rates ranged between 1-14 g N t(-1) d(-1) and showed little influence of turning regime. Total N and P concentrations in turned (T) and static (S) manure were elevated at the end of all experiments, due to loss of dry matter. Mean total N losses were 30.4% (T1) and 36.8% (T3) and total P losses 28.2% (T1) and 27.4% (T3).     

耐铅镉菌株的分离鉴定及其吸附能力

堆肥中添加生物钝化剂是当前降低粪便中重金属生物毒性最为有效的方式之一,为了进一步提高其钝化重金属的能力,文中获得了复合重金属高耐性的钝化剂菌株,并探究其生物学特性和吸附特征。采集猪粪堆肥样品并在改良的牛肉膏培养基中分离和筛选耐铅又耐镉的高耐性菌株,通过形态结合分子生物学鉴定该菌株。该菌株分别在不同pH、温度和盐浓度条件下培养获得其最适的生长条件,进而在该条件下分析其对铅镉吸附的特性。结果获得一株耐铅浓度为600 mg/L、镉浓度为120 mg/L的铅镉复合耐性菌株SC19,该菌株为西地西菌属,其最适生长环境为pH值7.0、温度37℃、盐浓度0.5%。培养36 h的稳定期SC19菌株在吸附时间30min时铅的去除率最高,对铅的最大去除率和吸附量分别为60.7%和329.13mg/g;培养8h的对数期在吸附时间30min时镉的去除率最高,对镉的最大去除率和吸附量分别为51.0%和126.19 mg/g。红外光谱分析显示,SC19菌株对铅镉离子的吸附主要是细胞表面的多种活性基团与金属离子发生络合作用。该研究揭示了SC19菌株有较好的二价态铅镉离子吸附能力,可为生物钝化重金属提供重要的微生物种质资源。     

Effect of the raw materials and mixing ratio of composted wastes on the dynamic of organic matter stabilization and nitrogen availability in composts of Sub-Saharan Africa

The effect of raw materials and their proportions in initial mixtures on organic matter (OM) stabilization and nitrogen (N) availability during pit composting in Sub-Saharan Africa was assessed using biochemical fractionation and laboratory incubations to characterize composts sampled throughout the composting process. Stabilization of OM occurred more rapidly in mixtures with slaughter-house wastes, it was progressive in mixture with household refuses while tree leaves compost remained unstable. Carbon mineralization from compost samples was positively correlated to water soluble and hemicellulose-like organic fractions. Mixtures containing large proportions of household refuses reached the highest stability and total N but available N remained weak. Slaughter-house wastes in the initial mixtures made possible to reach good OM stabilization and the largest N availability. The nature of initial mixing influenced composting parameters, OM stabilization and N availability. It is suggested mixing household refuses and slaughter-house wastes with tree leaves to reach better amending and fertilizer qualities of composts.     

Effect of bioaugmentation and nitrogen supplementation on composting of paddy straw

A composting experiment was conducted to evaluate the effect of a hyperlignocellulolytic fungal consortium and different nitrogen amendments on paddy straw composting in terms of changes in physicochemical and biological parameters. A fungal consortium comprising four lignocellulolytic mesophilic fungal cultures was used as inoculum for bioaugmentation of paddy straw in perforated pits. The comparative effect of farmyard manure (FYM), soybean trash, poultry litter and urea on the composting process was evaluated at monthly intervals in terms of physicochemical (pH, EC, available P, C:N ratio and humus content) and biological (enzymatic and microbial activity) parameters. The compost prepared from bioaugmented paddy straw composting mixture, with poultry manure as nitrogen supplement attained desirable C:N ratio in 1 month and displayed least phytotoxicity levels along with higher production of β-1,4-Exoglucanase. The combined activity of the autochthonous composting microbiota as well as the externally applied fungal inoculum accelerated the composting process of paddy straw. Supplementation of paddy straw with poultry manure in 8:1 ratio was identified as the best treatment to hasten the composting process. This study highlights the importance of application of fungal inoculum and an appropriate N-amendment such as poultry manure for preparation of compost using a substrate having high C:N ratio, such as paddy straw.     

Characterization of dairy cattle manure/wallboard paper compost mixture

The aim of this research was to evaluate the use of manufacturing wallboard paper scraps as an alternative bulking agent for dairy cattle manure composting. The characteristics of the composting process were studied based on the changes in physico-chemical parameters and final compost quality. Composting of dairy cattle manure with wallboard paper was performed in a 481-L cylindrical reactor with vacuum-type aeration. Rapid degradation of organic matter was observed during the thermophilic stage of composting due to high microbial activity. High temperature and alkaline pH conditions promoted intense ammonia emission during the early stage of composting. The number of mesophilic and thermophilic microorganisms were found to be affected by changes in temperature at different composting stages. The total nitrogen (N), phosphorus (P), potassium (K), and sodium (Na) concentrations of the mixture did not change significantly after 28days of composting. However, the presence of gypsum in the paper scraps increased the calcium content of the final compost. The wallboard paper had no phyto-inhibitory effects as shown by high germination index of final compost (GI=99%).     

Performance characteristics of three aeration systems in the swine manure composting

Pilot composting of swine manure mixed with rice straw was carried out to evaluate performance characteristics of three aeration systems: forced aeration, passive aeration and natural aeration. It was expected to provide academic basis for farmers to select an advisable aeration system. The results showed that the thermophilic durations were long enough to satisfy the sanitary standard, and swine manure could reach maturity. The indexes of the composting, including physical changes, pH value, TOC, OM, TKN, WSC, WSN, solid C/N ratio, water-soluble C/N ratio, TOM, NH4+-N, (NO3(-) + NO2(-))-N, and GI had no significant difference among the treatments (P > 0.05) except the average temperature profiles (P12 = 0.001, P13 = 0.036). Economic analysis showed that a passive aeration system was suitable for a small-scale swine farm, and forced aeration system should be considered to apply in the middle and large-scale swine farms with a high extent of industrialization. But, in order to avoid too high temperature occurring during composting, an active aeration control system needed to be developed.     

Temporal and spatial distribution of <Emphasis Type="Italic">Bacillus</Emphasis> and <Emphasis Type="Italic">Clostridium histolyticum</Emphasis> in swine manure composting by fluorescent in situ hybridization (FISH)

The temporal and spatial distribution of the genus Bacillus and Clostridium histolyticum group in swine manure composting was determined by fluorescent in situ hybridization using fluorescently labeled 16S rRNA-targeted oligonucleotide probes LGC353b and Chis150, respectively. The temporal distribution of total bacteria, Bacillus and C. histolyticum, detected in each layer of the composting pile was noticeable in that the number of them detected at the high-temperature stage was higher than that of the cooling stage. The number detected at the cooling stage was higher than that of the temperature-rising stage. The number of the total bacteria distributed in three locations achieved balance at the stage of cooling. The spatial distribution of the genus Bacillus cells was that the number and the relative abundance of Bacillus cells detected in the middle layer of composting pile were the lowest at each stage of composting. However, the minimum value of the relative abundance exceeded 8%. Compared with Bacillus spp., the C. histolyticum group displayed higher relative abundance in the same layer at different stages of composting except in the top layer at the stage of high temperature. However, the characteristic of the spatial distribution was not noticeable. The detected limits of the genus Bacillus and C. histolyticum group were both found to be the high cell density of 10⁶ cells g⁻¹ (wet weight). These results indicated that the genus Bacillus and C. histolyticum group were the predominant bacteria in the swine manure composting process and may play important role in this complex environment.     

Co-composting of oil exhausted olive-cake, poultry manure and industrial residues of agro-food activity for soil amendment

The co-composting of exhausted olive-cake with poultry manure and sesame shells was investigated. These organic solid wastes were watered by the confectionary wastewater which is characterized by its high content of residual sugars raising its COD. Four aerated windrows were performed to establish the effects of confectionary by-products on the compost process. Different mixtures of the agro-industrial wastes were used. During the composting process, physico-chemical parameters (temperature, moisture, pH, electrical conductivity, total carbon and total nitrogen) were studied. The stability of the biological system was noticed after 70 days. The final products were characterized by their relatively high organic matter content, and low C/N ratio of 14-17. The humidification of the windrows with the wastewater seemed to have accelerated the composting process in comparison to a windrow humidified with water. In addition, the organic matter degradation was enhanced to reach 55-70%. The application of the obtained composts to soil appeared to significantly improve the soil fertility. Indeed, field experiments showed an increase in potato yield; the production was 30.5-37.5 tons ha(-1), compared to 30.5 tons ha(-1) with farm manure.