Purification and Characterization of Polyphenol Oxidase From Waste Potato Peel by Aqueous Two-Phase Extraction

Potato peel from food industrial waste is a good source of polyphenol oxidase (PPO). This work illustrates the application of an aqueous two-phase system (ATPS) for the extraction and purification of PPO from potato peel. ATPS was composed of polyethylene glycol (PEG) and potassium phosphate buffer. Effect of different process parameters, namely, PEG, potassium phosphate buffer, NaCl concentration, and pH of the system, on partition coefficient, purification factor, and yield of PPO enzyme were evaluated. Response surface methodology (RSM) was utilized as a statistical tool for the optimization of ATPS. Optimized experimental conditions were found to be PEG1500 17.62% (w/w), potassium phosphate buffer 15.11% (w/w), and NaCl 2.08 mM at pH 7. At optimized condition, maximum partition coefficient, purification factor, and yield were found to be 3.7, 4.5, and 77.8%, respectively. After partial purification of PPO from ATPS, further purification was done by gel chromatography where its purity was increased up to 12.6-fold. The purified PPO enzyme was characterized by sodium dodecyl sulfate polyacrylamide gel electrophoresis (SDS-PAGE), followed by K_m value 3.3 mM, and V_max value 3333 U/mL, and enzyme stable ranges for temperature and pH of PPO were determined. These results revealed that ATPS would be an attractive option for obtaining purified PPO from waste potato peel.     

Optimization of bovine serum albumin partition coefficient in aqueous two-phase systems

Partitioning of proteins in aqueous two-phase systems has been shown to provide a powerful method for separating and purifying mixtures of biomolecules by extraction. These systems are composed of aqueous solutions of either two water-soluble polymers, usually polyethylene glycol (PEG) and dextran (Dx), or a polymer and a salt, usually PEG and phosphate or sulfate. There are many factors which influence the partition coefficient K, the ratio of biomolecule concentration in the top phase to that in the bottom phase, in aqueous two-phase systems. The value of the partition coefficient relies on the physico-chemical properties of the target biomolecule and other molecules and their interactions with those of the chosen system. In this work, the partition behavior of pure bovine serum albumin in aqueous two-phase systems was investigated in order to see the effects of changes in phase properties on the partition coefficient K. The concentration of NaCl and pH were considered to be the factors having influence on K. Optimal conditions of these factors were obtained using the Box-Wilson experimental design. The optimum value of K was found as 0.0126 when NaCl concentration and pH were 0.14 M and 9.8, respectively, for a phase system composed of 8% (w/w) polyethylene glycol 3,350 - 9 (% w/w) dextran 37,500 - 0.05 M phosphate at 20 °C.     

ATPS applied to extraction of small molecules - polycetides - and simultaneous clarification of culture media with filamentous microorganisms

Aqueous two-phase systems (ATPS) were applied for extraction of small molecules (polycetides) - retamycin, an anthracyclin, and two red pigments, rubropunctamin and monascorubramin - from the whole culture media of Streptomyces olindensis and Monascus purpureus. ATPS allows, in one step, the separation of the small hydrophobic molecules in the PEG rich phase, from the filamentous microorganisms, which remains in the salt phase. Through experimental designs, the main variables and their levels were defined, as follows: for retamycin extraction, PEG 6000 (10%, w/w), phosphate at 20% (w/w) and pH 6.0 led to the higher partition coefficient, K(r) = 8.2, and yield = 91.3%; for red pigments, the statistical analysis indicate PEG 6000 (20%, w/w) and phosphate at 15% (w/w), for a high partition coefficient, (K(pig) = 113 and 150).     

AQUEOUS TWO-PHASE EXTRACTION FOR THE PURIFICATION OF ALKALINE AGARASES FROM CULTURE EXTRACTS OF Pseudomonas aeruginosa AG LSL-11

The agarases were purified for the first time an using aqueous two-phase system (ATPS) consisting of polyethylene glycol (PEG) and phosphate salt. The three extracellular, alkaline agarases produced by Pseudomonas aeruginosa AG LSL-11 were efficiently extracted into the top PEG-rich layer. The influencing factors on the partition of agarases—molecular weight of the PEG, system pH, system temperature, and NaCl concentration—were investigated. All the factors were found to have a significant effect on the partition of agarases except NaCl. The optimal ATPS parameters for the partitioning and purification of agarases were found to be 12% PEG 600 and 11.9% (w/w) phosphate salt at pH 8.0 and 4°C. All three agarases were concentrated in the top PEG phase with 6.19-fold purity and 71.21% recovery. The ATPS was found to be more convenient and economical than the conventional ion-exchange chromatography (IEC) method for extraction of three agarases and could be significantly employed for the purification of agarases from fermentation broth.     

Application of a PEG/salt aqueous two-phase partition system for the recovery of monoclonal antibodies from unclarified transgenic tobacco extract

Aqueous two-phase partition systems (ATPS) have been widely used for the separation of a large variety of biomolecules. In the present report, the application of a polyethylene glycol/phosphate (PEG/phosphate) ATPS for the separation of anti-HIV monoclonal antibodies 2G12 (mAb 2G12) and 4E10 (mAb 4E10) from unclarified transgenic tobacco crude extract was investigated. Optimal conditions that favor opposite phase partitioning of plant debris/mAb as well as high recovery and purification were found to be 13.1% w/w (PEG 1500), 12.5% w/w (phosphate) at pH 5 with a phase ratio of 1.3 and 8.25% w/w unclarified tobacco extract load. Under these conditions, mAb 2G12 and mAb 4E10 were partitioned at the bottom phosphate phase with 85 and 84% yield and 2.4- and 2.1-fold purification, respectively. The proposed ATPS was successfully integrated in an affinity-based purification protocol, using Protein A, yielding antibodies of high purity and yield. In this study, ATPS was shown to be suitable for initial protein recovery and partial purification of mAb from unclarified transgenic tobacco crude extract.     

高速逆流双水相色谱法纯化卵白蛋白

生物大分子的液_固色谱纯化过程中固相载体会产生产物吸附、变性等不良影响。高速逆流色谱无需固相载体 ,且具有高分便率和高回收率的优点 ,其中有机相 水相体系在分离天然产物中应用广泛 ,而应用双水相体系分离生物大分子尚处于研究阶段。双水相高速逆流色谱体系的建立与仪器设备及操作工艺条件密切相关 ,因此利用多分离柱高速逆流色谱仪 ,研究了PEG1000-无机盐双水相体系对标准蛋白质混合物以及卵白蛋白的分离。pH值和PEG浓度对不同种类蛋白质的分配系数影响不同 ,实验发现在pH9.2的150% (W/W)PEG1000 170% (W/W)磷酸钾盐体系中 ,细胞色素C、溶菌酶和肌红蛋白的分配系数差异较大 ,且分布合理 ,因而采用该体系在 0 8mL min流速 ,85 0r min转速的条件下 ,成功分离了细胞色素C、溶菌酶和肌红蛋白的混合物。实验也发现在pH9 2的 16 0 % (W/W)PEG10 0 0 17 0 % (W/W)磷酸钾盐体系中 ,鸡蛋清样品中的主要蛋白质成分:卵转铁蛋白、卵白蛋白和溶菌酶的分配系数差异最大 ,因而采用该体系在 1 8mL min流速、85 0r mi转速的条件下,200min内从鸡蛋清样品中成功分离卵白蛋白,其电泳纯度为100%,收率为95%.     

Purification of recombinant cutinase by extraction in an aqueous two-phase system facilitated by a fatty acid substrate

Purification of recombinant wild-type cutinase from the culture supernatant of Saccharomyces cerevisiae by extraction in aqueous two-phase system was investigated. The partition of the enzyme in a polyethylene glycol (PEG)-potassium phosphate system to the top phase was increased with lower molecular weight PEG. Enzyme partition in a 20% PEG/15% phosphate two-phase system was studied in the presence of detergents, fatty acids, and alcohols, respectively. Addition of 0.5% (w/w) butyrate increased the partition coefficient from 17 to 135 and the purification factor from 10 to 23. The effect of butyrate was also confirmed by using the countercurrent mode of extraction. Recovery of cutinase from the top phase was achieved by a secondary extraction into a new salt phase at a lower pH or a lower temperature. A specific interaction of butyrate to the active site of the enzyme was demonstrated by fluorescence spectroscopy. Size exclusion chromatography showed the cutinase-butyrate complex to be over two times the size of the free enzyme.     

牛血清白蛋白在聚乙二醇/葡聚糖双水相体系中分配特性的研究

采用考马斯亮蓝G250染色法测得室温下BSA在PEG/dextran双水相体系中的分配系数。以BSA在PEG/dextran体系的下相富集为目标,研究了PEG的分子量、浓度、dextran浓度以及所加入中性盐的种类与浓度、体系pH诸因素对其分配特性的影响。实验结果表明,在PEG4000/dextran体系中,采用PEG质量分数9%-dextran质量分数9%的浓度组成,同时在pH=7.0,NaC l浓度为0.2 mol.L-1或pH6.0,NaC l浓度为0.34 mol.L-1的工艺条件下萃取BSA均可达最小分配系数,其值为0.014。     

Application of the response surface methodology for optimization of whey protein partitioning in PEG/phosphate aqueous two-phase system

In order to develop a new strategy for β-lactoglobulin (β-lg) removal from whey protein, partitioning of α-lactalbumin (α-la), β-lg and glycomacropeptide (Gmp) was studied using aqueous two phase systems (ATPS). A system composed of 13% (w/w) polyethylene glycol (PEG, average molar mass 2000 g/mol) and 13% (w/w) potassium phosphate was used at 25°C. A central composite rotatable design (CCRD) associated to the response surface methodology (RSM) was applied to investigate the effects of NaCl concentration and pH on the partition of these proteins. It was found that α-la and Gmp partitioned to the top phase rich in PEG, whereas β-lg partitioned to the bottom phase rich in salt. According to the RSM, optimal conditions for β-lg removal where found where pH was equal to 6.7 and salt concentration was 0.35 mol/L. Under these conditions, the partition coefficient K(α) was 0.48 and K(Gmp) was 0.92. On the other hand, the partition coefficient K(β) was only 0.01. In such conditions β-lg preferentially concentrates in the bottom phase, while the top phase exclusively contains the proteins α-la and Gmp. Fractionation of the proteins from fresh whey was performed in a three stage cross-flow extraction system. The extraction yield for β-lg in the bottom phase was 97.3%, while the yields for α-la and Gmp in the top phase were 81.1% and 97.8%, respectively.     

Extraction of protease from Aspergillus tamarii URM 4634 in aqueous two-phase system under continuous and discontinuous process

Abstract

Aqueous two-phase systems have been studied for almost a century to separate biomolecules in harmless conditions. Proteases produced by Aspergillus tamarii URM 4634 were extracted in polyethylene glycol (PEG)/phosphate aqueous two-phase system under discontinuous and continuous (perforated rotative discs column) process. On the discontinuous process, it was evaluated the effect of operational conditions (PEG molar mass and its concentration, phosphate concentration and pH) over the partition coefficient, activity yield and purification factor. Protease partitioned to PEG-phase with partition coefficients up to 55.73. The best process parameters were 17.5% of PEG, with molar mass 8000?g·mol^?1, 15% of phosphate salt at pH 6, with 113.15% of activity yield and purification factor of 2.62. Under continuous extraction, hold up data showed that 57.1% of the discontinuous phase was available for protein extraction. Further, separation achieved 90.0% of efficiency. The yields surpassed 100% in almost all runs, and the best purification factor was 1.84, with both flows of 2?mL·min^?1. Thus, the best operational conditions reached an activity yield of 95.3% and 90.0% of separation efficiency. Hence, aqueous two-phase system PEG/phosphate extraction is an efficient process for separation of proteases produced by Aspergillus tamarii URM 4634, under continuous extraction likewise under discontinuous process.     

Liquid-liquid extraction of a Schistosoma mansoni recombinant protein from an Escherichia coli extract in aqueous two-phase system

This work describes the partition of a Schistosoma mansoni tegumental antigen produced by a recombinant Escherichia coli strain using an aqueous two-phase system composed of polyethylene glycol (PEG) and potassium phosphate. The effects of the polymer molecular weight, tie line length and pH on antigen partitioning were investigated. The detection of the antigen in both phases were determined by ELISA. The system composed of PEG 3550 (19.7% w/w) and potassium phosphate (17.7% w/w) led to a yield of 59% and an antigen purification factor of 3 in the PEG-rich phase. It was observed that the antigen partition in ATPS was strongly affected by the pH value and tie line length. In addition, it was possible in a single step, to remove the cell debris, that precipitated at the interface of the system.     

Correlation for the partition behavior of proteins in aqueous two-phase systems: effect of surface hydrophobicity and charge

Correlations to describe the effect of surface hydrophobicity and charge of proteins with their partition coefficient in aqueous two-phase systems were investigated. Polyethylene glycol (PEG) 4000/phosphate, sulfate, citrate, and dextran systems in the presence of low (0.6% w/w) and high (8.8% w/w) levels of NaCl were selected for a systematic study of 12 proteins. The surface hydrophobicity of the proteins was measured by ammonium sulfate precipitation as the inverse of their solubility. The hydrophobicity values measured correlated well with the partition coefficients, K, obtained in the PEG/salt systems at high concentration of NaCl (r = 0.92-0.93). In PEG/citrate systems the partition coefficient correlated well with protein hydrophobicity at low and high concentrations of NaCl (r = 0.81 and 0.93, respectively). The PEG/citrate system also had a higher hydrophobic resolution than other systems to exploit differences in the protein's hydrophobicity. The surface charge and charge density of the proteins was determined over a range of pH (3-9) by electrophoretic titration curves; PEG/salt systems did not discriminate well between proteins of different charge or charge density. In the absence of NaCl, K decreased slightly with increased positive charge. At high NaCl concentration, K increased as a function of positive charge. This suggested that the PEG-rich top phase became more negative as the concentration of NaCl in the systems increased and, therefore, attracted the positively charged proteins. The effect of charge was more important in PEG/dextran systems at low concentrations of NaCl. In the PEG/dextran systems at lower concentration of NaCl, molecular weight appeared to be the prime determinant of partition, whereas no clear effect of molecular weight could be found in PEG/salt systems.     

Direct purification of Burkholderia Pseudomallei lipase from fermentation broth using aqueous two-phase systems

An aqueous two-phase purification process was employed for the recovery of Burkholderia pseudomallei lipase from fermentation broth. The partition behavior of B. pseudomallei lipase was investigated with various parameters such as phase composition, tie-line length (TLL), volume ratio (V_R), sample loading, system pH, and addition of neutral salts. Optimum conditions for the purification of lipase were obtained in polyethylene glycol (PEG) 6000-potassium phosphate system using TLL of 42.2% (w/w), with VR of 2.70, and 1% (w/w) NaCl addition at pH 7 for 20% (w/w) crude load. Based on this system, the purification factor of lipase was enhanced to 12.42 fold, with a high yield of 93%. Hence, the simplicity and effectiveness of aqueous two-phase systems (ATPS) in the purification of lipase were proven in this study.     

Optimisation of aqueous two-phase extraction of human antibodies

The purification of human antibodies in an aqueous two-phase system (ATPS) composed of polyethylene glycol (PEG) 6000 and phosphate was optimised by surface response methodology. A central composite design was used to evaluate the influence of phosphate, PEG and NaCl concentration and of the pH on the purity and extraction yield of IgG from a simulated serum medium. The conditions that maximise the partition of IgG into the upper phase were determined to be high concentrations of NaCl and PEG, low concentrations of phosphate and low pH values. An ATPS composed of 12% PEG, 10% phosphate, 15% NaCl at pH 6 was further used to purify human monoclonal antibodies from a Chinese Hamster Ovary (CHO) concentrated cell culture supernatant with a recovery yield of 88% in the upper PEG-rich phase and a purification factor of 4.3. This ATPS was also successfully used to purify antibodies from a hybridoma cell culture supernatant with a recovery yield of 90% and a purification factor of 4.1.     

Correlations for the partition behavior of proteins in aqueous two-phase systems: effect of overall protein concentration

The effect of protein concentration in partitioning in PEG/salt aqueous two-phase systems has been investigated. PEG 4000/phosphate systems in the presence of 0% w/w and 8.8% w/w NaCl have been evaluated using amyloglucosidase, subtilisin, and trypsin inhibitor. Also, a PEG 4000/phosphate system with 3% w/w NaCl was used for alpha-amylase. The concentration of the protein in each of the phases affected its partition behavior. The pattern for the individual proteins was dependent on their physicochemical properties. In the top phase, maximum protein concentration was determined mainly by a steric exclusion effect of PEG, and hydrophobic interaction between PEG and proteins. In the bottom phase, maximum concentration was determined mainly by a salting-out effect of the salts present. As the ionic strength was increased in the systems the concentration in the top phase increased for all proteins. In the bottom phase an increase in ionic strength increased the salting-out effect. Amyloglucosidase had a very low maximum concentration in the PEG-rich top phase which was probably due to its large size (steric exclusion) and low hydrophobicity, and a high concentration in the salt-rich bottom phase due to its high hydrophilicity. In the case of subtilisin and trypsin inhibitor, their high concentrations in the top phase were due to their hydrophobic nature (hydrophobic interaction with PEG) and small size (negligible steric exclusion). The maximum concentration in the bottom phase for trypsin inhibitor was lower than that of subtilisin which was probably due to its higher hydrophobicity and, hence, a stronger salting-out effect. The protein concentration in each of the two phases was correlated with a "saturation"-type equation. The partition coefficient could be satisfactorily predicted, as a function of the overall protein concentration, by the ratio between the "saturation" equations of the two individual phases. Better correlations were obtained when an empirical sigmoidal Boltzmann equation was fitted to the data, since in virtually all cases the partition coefficient is constant at low protein concentration (true partitioning) and changes to a different constant value at a high overall protein concentration. (c) 1996 John Wiley & Sons, Inc.     

Aqueous two-phase extraction for the purification of alkaline agarases from culture extracts of Pseudomonas aeruginosa AG LSL-11

The agarases were purified for the first time an using aqueous two-phase system (ATPS) consisting of polyethylene glycol (PEG) and phosphate salt. The three extracellular, alkaline agarases produced by Pseudomonas aeruginosa AG LSL-11 were efficiently extracted into the top PEG-rich layer. The influencing factors on the partition of agarases--molecular weight of the PEG, system pH, system temperature, and NaCl concentration--were investigated. All the factors were found to have a significant effect on the partition of agarases except NaCl. The optimal ATPS parameters for the partitioning and purification of agarases were found to be 12% PEG 600 and 11.9% (w/w) phosphate salt at pH 8.0 and 4°C. All three agarases were concentrated in the top PEG phase with 6.19-fold purity and 71.21% recovery. The ATPS was found to be more convenient and economical than the conventional ion-exchange chromatography (IEC) method for extraction of three agarases and could be significantly employed for the purification of agarases from fermentation broth.     

Recovery of the proteose peptone component 3 from cheese whey in Reppal PES 100/polyethylene glycol aqueous two-phase systems

Recovery of the proteose peptone component 3 from cheese whey was optimal using a 16% (w/w) Reppal PES 100 – 24% (w/w) PEG 600 aqueous two-phase system, at pH 7, giving a mass recovery yield of 99% and a purity of 83% for proteose peptone component 3 in the upper phase. Using the above system a partition coefficient of 30.7 and a purification factor of 6.9 were achieved.     

Coupling purification and in situ immobilization process of monoclonal antibodies to clenbuterol for immunosensor application

Clenbuterol (CL), which promotes the growth of muscular tissue and the reduction of body fat in pigs and cattle, has been confirmed to be a potential hazard to human health. In this study, a monoclonal antibody to clenbuterol (CL mAb) from a hybridoma culture supernatant was purified by an aqueous two-phase system (ATPS) at different polyethylene glycol (PEG) concentrations, PEG molecular weights, pH values, and NaCl concentrations. Then the CL mAb was immobilized in situ by directly adding polystyrene microspheres (PSMSs) into a PEG phase containing CL mAb. Using the immobilized antibody, an immunosensor was constructed to detect the CL residues in pork samples. The results showed that using an ATPS composed of 15% (w/w) PEG6000, 15% (w/w) phosphate, and 15% (w/w) NaCl at pH 8.0, the partition coefficient was 7.24, the activity recovery was 87.86%, and the purification fold was 2.88. The PEG–CL mAb–PSMS retained approximately 98% of its initial activity after 30-ml phosphate buffer (PBS) washings. After 30 days of storage, the CL mAb–PSMS lost nearly 75% of its activity, whereas the PEG–CL mAb–PSMS retained as much as 95% of its initial activity. Furthermore, the constructed immunosensor obtained recoveries of 90.5 to 102.6% when applied to pork samples spiked with CL.     

Evaluation of recombinant phenylalanine dehydrogenase behavior in aqueous two-phase partitioning

Recombinant Bacillus sphaericus phenylalanine dehydrogenase (PheDH) partitioning was studied in polyethylene glycol (PEG) and ammonium sulfate aqueous two-phase systems (ATPS). The objectives of this work were to investigate influences; varying the molecular mass and concentration of PEG, pH, phase volume ratio (V_R), tie-line length (TLL) and concentration of (NH₄)₂SO₄ on the partition behavior of PheDH. It was revealed that the partitioning was not affected by V_R, while PEG molecular mass and concentration and (NH₄)₂SO₄ concentration had significant effects on enzyme partitioning. Longer TLL and higher pH resulted in better partitioning into the top phase. Under the most favorable partition conditions with 8.5% (w/w) PEG-6000, 17.5% (w/w) (NH₄)₂SO₄ and V_R = 0.25 at pH 8.0, partition coefficient (K_E), recovery (R%), yield (Y%) and TLL were achieved 58.7%, 135%, 94.42% and 39.89% (w/w), respectively. Overall, the promising results obtained in this research indicated that the ATPS partitioning can be provided an efficient and powerful tool for recovery and purification of recombinant PheDH.     

Detection of surface charge-related properties in model membrane systems by aqueous two-phase partition

Unilamellar vesicles composed of phosphatidylcholine (PC) and either phosphatidic acid (PA) or phosphatidylglycerol (PG) partition to the upper poly(ethylene glycol) (PEG)-rich phase of a charge-sensitive 5%:5% (w/w) PEG 8000/Dextran T-500 phase system containing 10 mM sodium phosphate at pH 7, consistent with the vesicles bearing a net negative charge. When prepared in the presence of a pH gradient (interior acidic), PC/PA vesicles exhibit an increased partition to the top PEG-rich phase, consistent with a redistribution of the PA from the inner to the outer monolayer of the vesicle bilayer. Conversely, when prepared in the presence of a pH gradient (interior basic), PC/PG vesicles exhibit a decreased top-phase partition, consistent with a redistribution of the PG from the outer to the inner monolayer of the vesicle bilayer. Unilamellar vesicles composed of PC and stearylamine partition to the lower dextran-rich phase of a 5%:5% (w/w) PEG 8000/Dextran T-500 phase system containing 10 mM sodium phosphate at pH 8.5, consistent with the vesicles bearing a net positive charge. When prepared in the presence of a pH gradient (interior acidic), conditions under which the stearylamine is trapped on the inner monolayer of the bilayer, the vesicles now partition predominantly to the interface in a manner similar to vesicles composed of PC alone. These results demonstrate that partitioning in aqueous two-phase polymer systems is a sensitive method for monitoring the asymmetry of charged lipids in model membrane systems and also suggests that partitioning in charge-sensitive systems depends only on the physical nature of the exterior surface of the membrane.