鲁氏酵母3-磷酸甘油脱氢酶基因（ZrGPD1）在粉状毕赤酵母中的表达

为探索在野生型粉状毕赤酵母（Pichia farinosa）中整合表达来源于耐高渗鲁氏酵母（Zygosacharomyces rouxii）的3-磷酸甘油脱氢酶基因（ZrGPD1）以提高产甘油能力的可行性,应用PCR方法从P. farinosa的染色体中扩增出乳清苷酸脱羧酶基因（URA3）片段,以此作为同源整合的靶序列,构建了整合型表达载体pUR-ZG。电击转化粉状毕赤酵母,以抗生素Zeocin为筛选标记,获得转化子pfa-gu,摇瓶发酵结果表明：以P. farinosa作为对照菌株,发酵72h后,转化子pfa-gu的生物量和甘油含量均高于对照菌株,其中甘油含量达到37g/L,比对照提高了30%。结论：在P. farinosa中异源表达ZrGPD1能够提高细胞的产甘油能力和对渗透压的调节能力。     

产1,3-丙二醇菌株丁酸梭菌的诱变育种

甘油由丁酸梭菌转化成1,3-丙二醇的研究是厌氧条件下进行。为了获得1,3-丙二醇的高产突变株,以丁酸梭菌为出发菌株进行诱变处理。经过硫酸二乙酯（DES）化学诱变得到2株高产正突变株C.but2031和C.but2046,再经过紫外线和亚硝基胍（NTG）复合诱变得到突变株C.but3037。经过初筛、复筛和传代实验,表明其是稳定的突变株。C.but3037的1,3-丙二醇产量由出发菌株的2.2g/L提高到15.7g/L,提高了6.13倍,     

产1,3-丙二醇菌株的诱变和筛选

为提高克雷伯氏肺炎杆菌产1,3-丙二醇的能力,以离子束、紫外线和氯化锂为复合诱变法,建立了产酸圈和产物耐受相结合的平板筛选方法,获得可耐受高浓度1,3-丙二醇并且副产物中乙醇含量较少的优良突变菌株2株。与出发菌株相比,两株高产突变菌株Klebsiella pneumoniae LM 03和Klebsiella pneumoniae LM05的1,3-丙二醇产量分别提高了33% 和30% ,达到66.74 g/L和65.12 g/L;乙醇产量分别降低了38% 和24% ,降低为6.59 g/L和8.05 g/L。同时测定了诱变前后还原途径中甘油脱水酶（GDHt）和1,3-丙二醇氧化还原酶（PDOR）的酶活变化,研究表明诱变对GDHt有明显的促进作用,而对PDOR的影响不明显。该诱变和筛选方法目标明确、易操作、效率高,在1,3-PD工业规模的生物法生产中将具有良好的应用价值,而且对于其他具有工业应用价值的菌株筛选工作也具有一定的借鉴意义。     

利用木糖-葡萄糖为原料产乙醇酵母的筛选、鉴定及发酵试验

建立筛选利用木糖为碳源产乙醇酵母模型,获得一株适合利用木质纤维素为原料产乙醇的酵母菌株。样品经麦芽汁培养基培养后,以木糖为唯一碳源的筛选培养基初筛,再以重铬酸钾显色法复筛。通过生理生化和26D1/D2区对筛选得到的菌株进行分析和鉴定,该菌初步鉴定为Pichia caribbica。经过筛选得到的菌株Y2-3以木糖（40g/L）为唯一碳源发酵时：生物量为23.5g/L,木糖利用率为94.7 %,乙醇终产量为4.57 g/L;以混合糖（葡萄糖40 g/L,木糖20 g/L）发酵时：生物量为28.6 g/L,木糖利用率为94.2 %,葡萄糖利用率为95.6%,乙醇终产量为20.6 g/L。Pichia caribbica是可以转化木糖及木糖-葡萄糖混合糖为乙醇的酵母菌株,为利用木质纤维素发酵乙醇的进一步研究奠定了基础。     

一株1,3-丙二醇生产菌的分离鉴定及其发酵特性

从活性污泥中分离筛选得到一株能代谢甘油生产1,3-丙二醇(1,3-PD)的菌株2-1,通过形态学鉴定、生理生化试验、16S rRNA序列分析对菌株分类学地位进行鉴定,用MEGA 4.1软件构建的系统发育树显示菌株2-1与Klebsiella pneumoniae(CP001891)的亲缘关系最近。16S rDNA序列同源性比较发现,菌株2-1与模式菌株同源率为95.4%,疑似为新种。对菌株2-1在5 L发酵罐中进行发酵特性研究,分批补料发酵时得到较高的1,3-PD终浓度,达到63.5 g/L,此时生产强度为2.19 g/(L.h),底物转化率0.64 mol/mol。     

具有差向选择性还原(R)-6-氰基-5-羟基-3-羰基己酸叔丁酯活性的微生物菌株筛选和鉴定

从土样中分离得到一株具有差向选择性还原(R)-6-氰基-5-羟基-3-羰基己酸叔丁酯活性的微生物菌株ZJB-09225,经生理生化特征鉴定和18S rDNA测序后鉴定为卡里比克毕赤酵母(Pichia caribbic ZJB-09225)。研究结果发现,在最适发酵条件下培养32 h,生物量为8.8 g/L,体积酶活达7.2 U/L;P.caribbic ZJB-09225最适作用温度、最适作用pH值分别为35℃和7.5。在最适的催化条件下,P.caribbic ZJB-09225细胞催化50.0 g/L(R)-6-氰基-5-羟基-3-羰基己酸叔丁酯3 h后,产物6-氰基-(3R,5R)-二羟基己酸叔丁酯得率3.4%,产物d.e.值99.5%以上。     

利用重组大肠杆菌产聚-4-羟基丁酸的研究

重组大肠杆菌 E.coli XL-1 Blue（pKSSE5.3）携带Ralstonia　eutropha　H16的 PHA聚合酶基因（phaC）和Clostridium kluyveri的4-羟基丁酸:CoA转移酶基因（orfZ）,可以利用葡萄糖和4-羟基丁酸为碳源合成均聚的聚-4-羟基丁酸[P（4HB）]。优化培养基和培养条件后,进行了补料分批培养。结果表明,经68h左右培养,E.coli XL-1 Blue（pKSSE5.3）的发酵液中菌体干重达13g/L,P（4HB）的密度达5g/L,P（4HB）百分含量为36％。从收获的冻干细胞中提纯得到40g均聚的P（4HB）,为进一步分析检测P（4HB）生物、理化、加工特性及其应用价值成为可能。     

E.aero高产1.3-丙二醇菌株选育及发酵培养基研究(Ⅰ)

以淡水湖泊泥土中分离出的300多株肠杆菌(Enterobacter)为出发菌株,利用常规筛选方法选出2株1．3-丙二醇产生菌(Enterobacter)。经UV、DES、NTG、EMS、LiCl单独及复合诱变,选育出一株(E．aero-N-56)1．3-PD高产突变株。通过单因素实验,确定了E．aero—N-56菌株1．3-PD发酵培养基为：甘油90g/L,NH4CL1．50g/L,Fe^2 0．005％,Co^2 0．004％。微量元素液12mL／L。该突变株1．3-PD产量为36．8g/L。     

产1,3-丙二醇新型重组大肠杆菌的构建

利用PCR技术从大肠杆菌(Escherichia coli )中扩增出1.16 kb的编码1,3-丙二醇氧化还原酶同工酶的基因yqhD,将其连接到表达载体pEtac,得到重组载体pEtac-yqhD,重组载体在大肠杆菌JM109中得到高效表达。SDS_PAGE分析显示融合表达产物的分子量均为43 kD,同核酸序列测定所推导的值相符。对含有yqh-D的基因工程菌进行表达研究表明：37 ℃,以1.0 mmol /L IPTG诱导4 h,1,3-丙二醇氧化还原酶同工酶的酶活力达到120 u/mg蛋白,而对照菌株的酶活力为0.5 u/mg蛋白。再将含甘油脱水酶基因dhaB和含1,3-丙二醇氧化还原酶同工酶基因yqhD的重组质粒共转化大肠杆菌JM109得到重组大肠杆菌JM109（pUCtac-dhaB, pEtac-yqhD）,该菌株在好氧条件下,以1.0mmol/L IPTG诱导可将50 g/L甘油转化为38.0 g/L 1,3-丙二醇。首次发现1,3-丙二醇氧化还原酶同工酶在好氧条件下表现出较高的活性。     

4-氯乙酰乙酸乙酯羰基还原酶产生菌的筛选及产酶条件研究

从实验室保藏的菌株中,筛选到一株立体选择性较高的产4-氯乙酰乙酸乙酯(COBE)羰基还原酶的菌株———出芽短梗霉(Aureobasidiumpullulans)SW0202,菌体产酶条件研究表明,最佳的发酵培养基配方为:麦芽糖30.0g/L,酵母膏20.0g/L,蛋白胨3.0g/L,(NH4)2SO45.0g/L,KH2PO42.0g/L,MgSO4.7H2O0.7g/L,最适发酵温度及初始pH分别为:28°C和pH6.0。该菌在此条件下发酵培养24h,产菌丝体生物量16.78g干菌体/L,COBE羰基还原酶酶活力达到1007U/L。在COBE的转化反应中,产物S-CHBE的浓度达到10.12g/L,光学纯度>97%e.e.。     

Study of two-stage processes for the microbial production of 1,3-propanediol from glucose

The microbial production of 1,3-propanediol (1,3-PD) from glucose was studied in a two-stage fermentation process on a laboratory scale. In the first stage, glucose was converted to glycerol either by the osmotolerant yeast Pichia farinosa or by a recombinant Escherichia coli strain. In the second stage, glycerol in the broth from the first stage was converted to 1,3-PD by Klebsiella pneumoniae. The culture broth from P. farinosa was shown to contain toxic metabolites that strongly impair the growth of K. pneumoniae and the formation of 1,3-PD. Recombinant E. coli is more suitable than P. farinosa for producing glycerol in the first stage. The fermentation pattern from glycerol can be significantly altered by the presence of acetate, leading to a significant reduction of PD yield in the second stage. However, in the recombinant E. coli culture acetate formation can be prevented by fed-batch cultivation under limiting glucose supply, resulting in an effective production of 1,3-PD in the second stage with a productivity of 2.0 g l(-1) h(-1) and a high yield (0.53 g/g) close to that of glycerol fermentation in a synthetic medium. The overall 1,3-PD yield from glucose in the two stage-process with E. coli and K. pneumoniae reached 0.17 g/g.     

Asymmetric reduction of 4-hydroxy-2-butanone to (R)-1,3-butanediol with absolute stereochemical selectivity by a newly isolated strain of Pichia jadinii

In this study, a novel strain of Pichia jadinii, HBY61, capable of the biocatalysis of 4-hydroxy-2-butanone (4H2B) to (R)-1,3-BD was isolated. HBY61 produced (R)-1,3-BD with high activity and absolute stereochemical selectivity (100 % e.e). Glucose and beef extract were found to be the key factors governing the fermentation, and their optimal concentrations were determined to be 84.2 and 43.7 g/L, respectively. The optimal bioconversion conditions of 4H2B catalyzed by HBY61 were pH 7.4, 30 °C, and 250 rpm with 6 % (v/v) glucose as the co-substrate. Accordingly, when 45 g/L of 4H2B was divided into three equal parts and added successively into the system at set time intervals, the maximum (R)-1,3-BD concentration reached 38.3 g/L with high yield (85.1 %) and strict 100 % enantioselectivity. Compared with previously reported yields for the biocatalytic production of (R)-1,3-BD, the use of strain HBY61 provided a high yield with excellent stereoselectivity.     

Mold-inhibitory activity of different yeast species during airtight storage of wheat grain

The yeast Pichia anomala J121 inhibits spoilage by Penicillium roqueforti in laboratory and pilot studies with high-moisture wheat in malfunctioning airtight storage. We tested the biocontrol ability of an additional 57 yeast species in a grain mini silo system. Most yeast species grew to CFU levels comparable to that of P. anomala J121 after 14 days of incubation (>10(6) CFU g(-1)). Of the 58 species, 38 (63 strains) had no mold-inhibitory effects (Pen. roqueforti levels >10(5) CFU g(-1)). Among these were 11 species (18 strains) that did not grow on the wheat grain. Several of the non-inhibiting yeast species have previously been reported as biocontrol agents in other postharvest environments. Weak inhibitory activity, reducing Pen. roqueforti levels to between 10(4) and 10(5) CFU g(-1), was observed with 11 species (12 strains). Candida silvicola and Pichia guillermondii reduced Pen. roqueforti to <10(4) CFU g(-1). Candida fennica, Candida pelliculosa, Candida silvicultrix, P. anomala (29 strains), Pichia burtonii, Pichia farinosa and Pichia membranifaciens strongly inhibited Pen. roqueforti (<10(3) CFU g(-1)) in the mini silos, but none had higher biocontrol activity than P. anomala strain J121. This report is the first of biocontrol activity of C. fennica and C. silvicultrix. The ability of 27 yeast species to grow to high CFU values without inhibiting mold growth suggests that nutrient competition may not be the main mode of action of P. anomala J121.     

Effect of different strains of yeast on stereocontrolled reduction of 5-acetylisoxazolines

The stereocontrolled reduction of 3-aryl-5-acetylisoxazolines (1) to the corresponding alcohols (2 and 3) in the presence of four different yeast strains, recognized as Baker's yeast (commercial), Candida krusei (ATCC 14243), Pichia farinosa (NRRL Y110) and Sacchromyces sp. (soil isolate) have been attempted. The C. krusei was found to be diastereoselective for the (R)-1 while the Sacchromyces sp. led to complete reduction to yield the RS- and SS-alcohol in 1:1 ratio at 10 g/L scale.     

一株高产Monacolin K紫红曲霉菌株筛选、鉴定及发酵条件优化

为从天然发酵红曲米中分离的30株红曲霉菌株中筛选高产MonacolinK的菌株,并对其产MonacolinK的发酵条件进行优化。实验采用高效液相色谱法(HPLC)筛选到9株具有产MonacolinK能力的红曲霉菌株,其中以编号ZX26的菌株产MonacolinK能力最高,发酵液中Monacolin K产量达到107.6mg/L,并且产MonacolinK能力具有良好的稳定性。微生物形态学结合ITS基因同源性分析结果表明,编号ZX26菌株为紫红曲霉。进一步采用单因素试验和正交试验法优化紫红曲霉ZX26产MonacolinK的发酵条件,结果表明在培养基组分为葡萄糖70g/L,牛肉膏15g/L,NaNO32g/L,MgSO4·7H2O0.5g/L,KH2PO41.5g/L时,其最优发酵条件为:发酵初始pH4.0,接种量为7%,培养温度30℃,发酵10天,在此条件下,紫红曲霉ZX26发酵液中MonacolinK产量达到271.36mg/L,相对于培养条件优化前MonacolinK产量提高152.19%,经验证此培养条件下MonacolinK产量最佳。     

Optimization of medium compositions favoring butanol and 1,3-propanediol production from glycerol by Clostridium pasteurianum

Medium compositions favoring butanol and 1,3-propanediol (1,3-PDO) production from glycerol by Clostridium pasteurianum DSM525 were investigated using statistical experimental designs. Medium components affecting butanol and 1,3-PDO production were screened using a fractional factorial experimental design. Among the six tested variables (phosphate buffer, MnSO4·H2O, MgSO4·7H2O, FeSO4·7H2O, (NH4)2SO4, and yeast extract), FeSO4·7H2O, (NH4)2SO4, and yeast extract were found to be significant variables for further optimization of medium using a Box-Behnken design. Optimal butanol (0.98 g/L/h) and 1,3-PDO (1.19 g/L/h) productivities were predicted by the corresponding quadratic model for each product and the models were validated experimentally under optimized conditions. The optimal medium composition for butanol production was significantly different from that for 1,3-PDO production (0.06 vs. 0 g/L for FeSO4·7H2O, 7.35 vs. 0 g/L for (NH4)2SO4, and 5.08 vs. 8.0 g/L for yeast extract), suggesting that the product formation from glycerol by C. pasteurianum DSM525 can be controlled by changing medium compositions.     

Fast conversion of glycerol to 1,3-propanediol by a new strain of Klebsiella pneumoniae

Five bacterial strains screened from a batch of 39 samples could convert glycerol anaerobically to 1,3-propanediol (1,3-PD). One of the strains, XJ-Li, which could synthesize 1,3-PD with a higher concentration, was identified and characterized. Phylogenetic analysis of the strain XJ-Li included the study of morphology, physiological and biochemical characteristics. In addition, 16SrDNA sequences were created. The results indicated that this strain is a member of Klebsiella pneumoniae. The optimal cultivation parameters for pH and temperature were determined as 8.0 and 40 °C, respectively. The optimized nitrogen source and carbon source were 6.0 g/L of (NH₄)₂SO₄ and 20 g/L of glycerol, respectively. After 8 h in batch fermentation, both the 1,3-PD concentration and glycerol consumption reached the maximum, with 12.2 g/L of 1,3-PD and 1.53 g/L h of productivity, and a molar yield of 1,3-PD to glycerol of 0.75. Fed-batch fermentation also indicated a higher molar yield of 0.70, and the concentration of 1,3-PD reached 38.1 g/L after 66.4 g/L of glycerol consumption. The results of batch and fed-batch fermentations demonstrated that K. pneumoniae XJ-Li would be an excellent 1,3-PD producer.     

Isolation, characterization and evaluation of hyper 2-propanol producing bacteria from Singapore environment

Three hyper 2-propanol producing strains were isolated from Singapore environment using an enrichment step and a high through-put screening step. The analysis of the amplified 16S rDNA revealed that the isolates belonged to Clostridium species and they were named as Clostridium sp. BT10-1, Clostridium sp. M10-1 and Clostridium sp. PU31-4. At 1 L scale, the 2-propanol titer of these positive strains was 1.6–2.1 times of that of Clostridium beijerinckii NRRL B593, which is so far the most efficient natural 2-propanol producer. The highest 2-propanol titer was achieved by isolate BT10-6 and it was 5.26 g/L (87.5 mM). These three positive strains BT10-6, M10-1 and PU31-4 consumed glucose almost completely in 40–48 h and gave 2-propanol productivity at 0.132, 0.118 and 0.087 g/L/h, respectively, which is 3.0–4.6 times of 0.029 g/L/h given by C. beijerinckii NRRL B593. Butanol was also produced by these positive strains with a slightly lower butanol titer and higher butanol productivity, compared to butanol control strain C. beijerinckii NCIMB 8052.     

Structure of oligosaccharides on Saccharomyces SUC2 invertase secreted by the methylotrophic yeast Pichia pastoris.

Saccharomyces SUC2 invertase, secreted by the methylotrophic yeast Pichia pastoris and purified to homogeneity from the growth medium by DE-52 chromatography, appeared on sodium dodecyl sulfate-polyacrylamide gel electrophoresis as a diffuse ladder of species at 85-90 kDa, while the secreted Saccharomyces form migrated as a broad band from 100 to 150 kDa. Endo-beta-N-acetylglucosaminidase H released the Pichia invertase carbohydrate generating a 60-kDa protein with residual Asn-linked GlcNAcs and oligosaccharides separated on Bio-Gel P-4 into Man8-11GlcNAc. Nearly 75% of the oligosaccharides were equally distributed between Man8,9GlcNAc, while 17% were Man10GlcNAc and 8% were Man11GlcNAc. Oligosaccharide pools were analyzed for homogeneity by high-pH anion-exchange chromatography, and structures were assigned using 500 MHz one- and two-dimensional 1H NMR spectroscopy. Pichia Man8GlcNAc was the same isomer as found in Saccharomyces, which arises by removing the alpha 1,2-linked terminal mannose from the middle arm of the lipid-oligosaccharide Man9GlcNAc (Byrd, J. C., Tarentino, A. L., Maley, F., Atkinson, P. H., and Trimble, R. B. (1982) J. Biol. Chem. 257, 14657-14666). The Man9GlcNAc pool was 5% lipid-oligosaccharide precursor and 95% Man8GlcNAc isomer with a terminal alpha 1,6-linked mannose on the lower-arm alpha 1,3-core-linked residue (Hernández, L. M., Ballou, L., Alvarado, E., Gillece-Castro, B. L., Burlingame, A. L., and Ballou, C. E. (1989) J. Biol. Chem. 264, 11849-11856). An alpha 1,2-linked mannose on the new alpha 1,6-linked branch in Man9GlcNAc provided 80% of the Man10GlcNAc, which is the structure on Saccharomyces invertase (Trimble, R. B., and Atkinson, P. H. (1986) J. Biol. Chem. 261, 9815-9824). A minor Man10GlcNAc (12%) and the principal Man11GlcNAc (82%) were the major Man9,10GlcNAc with novel alpha 1,2-linked mannoses on the preexisting alpha 1,2-linked termini. Although Pichia glycans did not have terminal alpha 1,3-linked mannoses as found on Saccharomyces core oligosaccharides, over 60% of the structures were isometric configurations unique to lower eukaryotes.