Nutritional characterization of Mucuna pruiriens: 2. In vitro ruminal fluid fermentability of Mucuna pruriens,Mucunal-dopa and soybean meal incubated with or without l-dopa

Three in vitro experiments were conducted to determine the rumen fermentability of Mucuna (M) pruriens (24 g 3,4-dihydroxy-l-phenylalanine (l-dopa)/kg dry matter (DM) and soybean meal treated with (SBD) or without (SB) 138 g l-dopa/kg DM). Additional objectives were to determine if l-dopa inhibits rumen fermentation, and if ruminal microbes can adapt to l-dopa or M. In Experiment 1, ground (1 mm) substrates were incubated in triplicate at 38 °C in 9 ml nutrient media and 1 ml rumen fluid in a series of six, 48 h, consecutive batch cultures. The first culture was inoculated with rumen fluid from two donor cows. Subsequent cultures were inoculated with fluid (1 ml) from the previous culture. The DM digestibility (DMD, 616 g/kg vs. 540 g/kg; P<0.01) and gas production (51.7 ml/g vs. 44.2 ml/g DM; P<0.05) were higher from fermentation of M versus SB but similar for SB and SBD (540 g/kg vs. 554 g/kg and 44.2 ml/g DM vs. 43.5 ml/g DM, respectively). The slopes of the relationships between DMD (g/kg) or gas production (ml/g DM) and fermentation period were not reduced by fermenting M (−0.014 DMD slope; 2.28 gas production slope) or SBD (−0.014 DMD slope; 0.459 gas production slope), instead of SB (−0.002 DMD slope; 1.039 gas production slope), indicating microbial adaptation to M and SBD. Total volatile fatty acid concentration (VFA; 53.7, 54.9 and 54.9 mmol/l) and molar proportions of VFA were similar among substrates. Gas production kinetics of M versus SB (Experiment 2), and SB versus SBD (Experiment 3) were also measured after substrates were incubated in triplicate in buffered rumen fluid for 24 h using a non-linear exponential model to fit the data. Residual l-dopa was measured after separate fermentation of substrates in triplicate for 0, 4, 8, 16 and 24 h. Fermentation of M versus SB produced more (P<0.05) gas (250 ml/g vs. 100 ml/g DM) and total VFA (203 mmol/l vs. 180 mmol/l) and a lower (P<0.05) acetate:propionate ratio (1.35 vs. 1.87; P<0.05). Adding l-dopa to SB increased (P<0.01) gas production (92 ml/g DM vs. 200 ml/g DM), and total VFA concentration (132 mmol/l vs. 188 mmol/l), but reduced (P<0.05) gas production rate (0.08 ml/h vs. 0.05 ml/h). The concentration of l-dopa in fermented M and SBD decreased by 53 and 47%, respectively during fermentation. In conclusion, M was more fermented than SB and degradation of l-dopa during ruminal fermentation and microbial adaptation to l-dopa were confirmed. Adding l-dopa to SB did not impair ruminal fermentation.     

Safflower seeds in corn silage and alfalfa hay based early lactation diets: A practice within an optimum forage choice

Safflower seed (SS), Carthamus tinctorius L., has the highest concentration of linoleic acid among 80 oilseeds. It was hypothesized that an Iranian variety of SS can be effectively fed with cottonseeds (CS) to maintain feed intake, energy metabolism and productivity of early lactation cows under negative energy balance. Our objective was to determine effects of feeding diets containing 100 g whole CS with (1) no SS (SS0), (2) 75 g CS + 25 g SS (SS25), or (3) 50 g CS + 50 g SS (SS50), per kg of dietary DM, on feed intake, rumen fermentation, blood metabolites and milk production of early lactation cows fed diets based on a uniform mixtures of alfalfa hay and corn silage. Nine multiparous early lactation Holstein cows (46 ± 7 d in milk) were used in a replicated 3 × 3 Latin square design study with three 21-d periods. Each period had 14 d of adaptation and 7 d of data collection. Dietary inclusion of SS did not affect (P>0.10) DM intake, rumen pH and concentrations of ammonia and VFA, blood concentrations of insulin, non-esterified fatty acids, urea and triglycerides, and milk production. Adding SS linearly reduced blood glucose (P=0.05) and beta-hydroxybutyric acid (P<0.05), and increased blood total cholesterol (P<0.01) and low-density lipoproteins (P<0.05) concentrations. Results demonstrated that SS as an economical and rich source of essential fatty acids can be included up to 50 g/kg of dietary DM alongside CS for early lactation cows without affecting feed intake while maintaining rumen fermentation, peripheral energy supply and milk production.     

Chemical composition and rumen degradability of three corn hybrids treated with insecticides against the European corn borer (Ostrinia nubilalis)

This experiment determined the chemical composition, rumen degradability (aNDF in stalks and starch in kernels) and in vitro gas production of kernels from three corn hybrids treated (TT) or not treated (control, CTR) with insecticides against the European corn borer (ECB, Ostrinia nubilalis). Two whole-plant silage hybrids belonging to the FAO rating 600 and 700 maturity class (S600 and S700, respectively) and one selected for grain production (G600, FAO rating 600, Dekalb-Monsanto Agricoltura S.p.A., Lodi, Italy) were sown in two main plots (TT and CTR) of an experimental field. Two subsequent treatments of pyrethroids (25 and 1.2 g/ha of cyfluthrin and deltamethrin, respectively) were applied to the TT plots. The insecticide treatment reduced the number of damaged plants (4.5 broken plants/plot versus 0.3 broken plants/plot, P<0.01) and increased the total grain yield by 11% (13.8 t/ha versus 12.4 t/ha), while hybrids did not differ. ECB larvae which bored into the stalk tunnels modified the chemical composition of stalks and kernels. In stalks, total sugars content (i.e. glucose, fructose, sucrose) was about twice that in TT versus CTR plants (123 g/kg versus 60 g/kg DM, P<0.01), while aNDF content was higher in CTR stalks (765 versus 702 g/kg DM, P<0.01). DM degradability after 48 h of incubation of stalks was higher in TT than in CTR, both in vitro (0.360 versus 0.298, P<0.01) and in situ (0.370 versus 0.298, P<0.05), while there were no differences in aNDF degradability. Kernels from TT plots contained less DM (615 g/kg versus 651 g/kg, P<0.01) and more CP (84 g/kg and 78 g/kg DM, P<0.05) than those from CTR plots, while in situ rumen starch disappearance and in vitro gas production were similar. Corn hybrid selected for yield of grain (G600) differed from S600 and S700 due to a higher (P<0.01) content of aNDF, ADF and lignin(sa) in the stalks, and a higher starch content (696 g/kg versus 674 and 671 g/kg DM, P<0.01) and CP (87 g/kg versus 77 and 76 g/kg DM, P<0.05) in grain. The G600 hybrid produced stalks with a lower (P<0.01) aNDF rumen degradability than the S600 and S700.     

Different lactic acid bacteria and their combinations regulated the fermentation process of ensiled alfalfa: ensiling characteristics,dynamics of bacterial community and their functional shifts

The objectives of this study were to investigate the adaptation and competition of Lactobacillus plantarum, Pediococcus pentosaceus and Enterococcus faecalis inoculated in alfalfa silage alone or in combination on the fermentation quality, dynamics of bacterial community, and their functional shifts using single-molecule real-time (SMRT) sequencing technology. Before ensiling, alfalfa was inoculated with L. plantarum (Lp), P. pentosaceus (Pp), E. faecalis (Ef) or their combinations (LpPp, LpEf, LpPpEf) and sampled at 1, 3, 7, 14 and 60 days. After 60-days fermentation, the Lp-, Pp- and LpPp-inoculated silages had lower pH but greater concentrations of lactic acid were observed in Pp, LpEf and LpPpEf-inoculated silages. The inoculants altered the keystone taxa and the bacterial community dynamics in different manners, where L. plantarum, Weissella cibaria and L. pentosaceus dominated the bacterial communities after 14 days-fermentation in all treatments. The silages with better fermentation quality had simplified bacterial correlation structures. Moreover, different inoculants dramatically changed the carbohydrate, amino acid, energy, nucleotide and vitamin metabolism of bacterial communities during ensiling. Results of the current study indicate that effect of different inoculants on alfalfa silage fermentation was implemented by modulating the succession of bacterial community, their interactions and metabolic pathways as well during ensiling.     

Effects of Agave salmiana Otto Ex Salm-Dyck silage as forage on ruminal fermentation and growth in goats

Ensiling of Agave salmiana Otto Ex Salm-Dyck, a widespread plant in Mexico, as a viable preservation method to create a potential animal feed resource for ruminants was investigated. Fresh A. salmiana with 205 g dry matter (DM)/kg and wilted alfalfa with 602 g DM/kg were ensiled in combinations (DM:DM) of 1000:0, 500:500 and 350:650, to evaluate feeding value of agave:alfalfa silages on ruminal fermentation and growth of goats. Chemical composition and in situ ruminal disappearance of three total mixed rations (TMRs), which included 240 g/kg DM of each silage (1000:0, 500:500 and 350:650) were determined. The TMR were used to assess ruminal fermentation and growth of 15 goats (20 ± 2.2 kg body weight (BW)). Silage pH (≤4), lactate (>25 g/kg DM) and ammonia (<50 g/kg total N) concentrations indicate that silage quality was good. Lactic acid was the main acid in all silages, acetic acid concentrations were relatively low, and butyrate was only detected in only the 1000:0 agave:alfalfa silage. Potential DM disappearance of the TMR increased quadratically as the amount of alfalfa included in the silage mixture increased. The BW gain and feed efficiency were not changed by treatment, even though DM intake decreased and aNDF intake increased linearly as the amount of alfalfa included in the silage mixture increased. Ruminal pH and butyrate increased, and ammonia N, lactate and propionate decreased linearly as alfalfa proportion of alfalfa in the silage mixture was increased. The TMR ingredient selectivity by the goats may have limited goat performance when alfalfa was included in agave silage mixtures. Because the agave:alfalfa blend improved nutritional quality, ruminal digestibility and intake of agave silage, alfalfa inclusion may improve nutritional characteristics of agave plants silages for ruminants.     

The bacterial community and metabolome dynamics and their interactions modulate fermentation process of whole crop corn silage prepared with or without inoculants

Multi-omics approach was adopted to investigate the modulation of bacterial microbiota and metabolome as well as their interactions in whole crop corn ensiling systems by inoculating homofermentative Lactobacillus plantarum or heterofermentative Lactobacillus buchneri. Inoculations of the two different inoculants resulted in substantial differences in microbial community and metabolic composition as well as their dynamics in ensiled corn. Inoculants also altered the correlations of microbiota in different manners, and various keystone species were identified in corn silages with different treatments. Many metabolites with biofunctional activities like bacteriostatic, antioxidant, central nervous system inhibitory and anti-inflammatory were found in the present silage. A constitutive difference in microbiota dynamics was found for several pathways, which were upregulated by specific taxa in middle stage of fermentation, and widespread associations between metabolites with biofunctions and the species of lactic acid bacteria dominated in silage were observed. Multiple microbial and metabolic structures and dynamics were correlated and affected the fermentation process of the corn ensiling systems. Results of the current study improve our understanding of the complicated biological process underlying silage fermentation and provide a framework to re-evaluate silages with biofunctions, which may contribute to target-based regulation methods to produce functional silage for animal production.     

Antibacterial activity of lactic acid bacteria included in inoculants for silage and in silages treated with these inoculants

AIMS: To determine antibacterial activity in lactic acid bacteria (LAB) silage inoculants and in wheat and corn silages which were treated with these inoculants. METHODS AND RESULTS: Wheat and two corn silages were prepared in 0.25 l sealed glass jars. Inoculant treatments were prepared for each type of silage with each of 10 LAB silage inoculants at inoculation rate of 10(6) CFU g(-1). Untreated silages served as controls. Antibacterial activity was determined in the inoculants and in their respective silages with Micrococcus luteus and Pseudomonas aeruginosa. Antibacterial activity was detected in nine of the 10 inoculants whereas such activity in the silages varied. Control silages did not have antibacterial activity. CONCLUSIONS: Many LAB silage inoculants have antibacterial activity and in some cases this activity is imparted on inoculated silages. SIGNIFICANCE AND IMPACT OF THE STUDY: This study was conducted as part of a broader research objective, which is to find out how LAB silage inoculants enhance ruminant performance. The results of this study indicate that LAB silage inoculants produce antibacterial activity, and therefore, have a potential to inhibit detrimental micro-organisms in the silage or in the rumen.     

Fate of Escherichia coli O26 in corn silage experimentally contaminated at ensiling, at silo opening, or after aerobic exposure, and protective effect of various bacterial inoculants

Shiga toxin-producing Escherichia coli (STEC) strains are responsible for human illness. Ruminants are recognized as a major reservoir of STEC, and animal feeds, such as silages, have been pointed out as a possible vehicle for the spread of STEC. The present study aimed to monitor the fate of pathogenic E. coli O26 strains in corn material experimentally inoculated (10⁵ CFU/g) during ensiling, just after silo opening, and after several days of aerobic exposure. The addition of 3 bacterial inoculants, Propionibacterium sp., Lactobacillus buchneri, and Leuconostoc mesenteroides (10⁶ CFU/g), was evaluated for their abilities to control these pathogens. The results showed that E. coli O26 could not survive in corn silage 5 days postensiling, and the 3 inoculants tested did not modify the fate of pathogen survival during ensiling. In the case of direct contamination at silo opening, E. coli O26 could be totally eradicated from corn silage previously inoculated with Leuconostoc mesenteroides. The combination of proper ensiling techniques and the utilization of selected bacterial inoculants appears to represent a good strategy to guarantee nutritional qualities of cattle feed while at the same time limiting the entry of pathogenic E. coli into the epidemiological cycle to improve the microbial safety of the food chain.     

Characterization and Identification of Pediococcus Species Isolated from Forage Crops and Their Application for Silage Preparation

Pediococcus species isolated from forage crops were characterized, and their application to silage preparation was studied. Most isolates were distributed on forage crops at low frequency. These isolates could be divided into three (A, B, and C) groups by their sugar fermentation patterns. Strains LA 3, LA 35, and LS 5 are representative isolates from groups A, B, and C, respectively. Strains LA 3 and LA 35 had intragroup DNA homology values above 93.6%, showing that they belong to the species Pediococcus acidilactici. Strain LS 5 belonged to Pediococcus pentosaceus on the basis of DNA-DNA relatedness. All three of these strains and strain SL 1 (Lactobacillus casei, isolated from a commercial inoculant) were used as additives to alfalfa and Italian ryegrass silage preparation at two temperatures (25 and 48°C). When stored at 25°C, all of the inoculated silages were well preserved and exhibited significantly (P < 0.05) reduced fermentation losses compared to that of their control in alfalfa and Italian ryegrass silages. When stored at 48°C, silages inoculated with strains LA 3 and LA 35 were also well preserved, with a significantly (P < 0.05) lower pH, butyric acid and ammonia-nitrogen content, gas production, and dry matter loss and significantly (P < 0.05) higher lactate content than the control, but silages inoculated with LS 5 and SL 1 were of poor quality. P. acidilactici LA 3 and LA 35 are considered suitable as potential silage inoculants.     

Lactobacillus plantarum effects on silage fermentation and in vitro microbial yield

In four parallel experiments, herbage [three harvests of alfalfa (308 to 379 g dry matter (DM)/kg), one of whole-plant corn (331 g DM/kg)] was ensiled with three different treatments: no inoculant (control), Lactobacillus plantarum (LP) or formic acid (FA), in 1-L mini-silos and fermented for 60 d at room temperature (22 °C). Mini-silos were opened and analyzed for fermentation characteristics and soluble N fractions. A subsample of wet silage from each mini-silo was ground to 4 mm and stored at ?20 °C. Silages were thawed and subjected to 9 h ruminal in vitro incubations to measure gas production and volatile fatty acid (VFA) production as well as microbial biomass yield (MBY) and microbial non-ammonia N (MNAN) formation using ¹⁵N as a marker. In all four experiments, silage fermentation products and pH indicated good preservation across all treatments. Analysis of data showed that FA- and LP-treated silages had lower concentrations of ammonia-N and free amino acids N than control. The FA treatment was lower in soluble N, but higher in peptide-N, than control. Silage pH was lowest in FA (4.25), followed by LP (4.28), and control (4.38). Ruminal in vitro gas production and VFA concentrations were not different among treatments (P>0.05). Compared to control, FA- and LP-treated silage yielded greater MNAN and MBY. These findings suggested that L. plantarum preserved more true protein during silage fermentation than control, which in turn increased in vitro ruminal microbial growth.     

Ozone exposure during growth affects the feeding value of rice shoots

Rising tropospheric ozone concentrations have been observed in many Asian countries in recent years. Ozone pollution reduces the yield of agricultural crops but may also affect crop quality. This study aimed at estimating the effect of ozone exposure on feeding quality of rice shoots for ruminant herbivores. Rice plants from two genotypes differing in ozone tolerance were exposed to ozone at a concentration of 120 nl/l for 18 days, and feeding value was determined by chemical analyses and in vitro incubation in rumen fluid. Rice biomass was reduced by an average of 24% in the ozone treatment as compared to the control. Moreover, ozone exposure affected various feed quality parameters. Crude protein content was lower in ozone treated plants (P<0.05). Potential gas production during the in vitro incubation for 96 h also dropped (P<0.01) due to ozone treatment, indicating reduced digestibility of the plant materials. This was explained with an increase in the antinutritive components lignin (P<0.05) and phenolics (P<0.001) due to ozone exposure. An ozone tolerant genotype exhibited a more pronounced increase in phenolics, suggesting that this may constitute a stress defense mechanism. Our results suggest that ozone may affect the feeding value of cereal straws and calls for further research in this direction.     

Temperate forages ensiled with molasses or fresh cheese whey: Effects on conservation quality, effluent losses and ruminal degradation

Effects of ensiling and adding molasses or increasing levels of fresh cheese whey on the conservation and rumen degradability of temperate pasture silages were evaluated. Forage from three paddocks of mixed grass and legume pastures was used to make 45 silages (15 silages per paddock) with 5 treatments, including silage without additives (control), silage with 15 g/kg dehydrated molasses and silage with 20, 50 and 100 g/kg fresh cheese whey. The chemical composition and fermentation quality (i.e., pH, ammonia N, loss of dry matter (DM) and neutral detergent fibre (NDF), effluent production) of the silages were determined. Fresh and ensiled materials were evaluated for in situ rumen degradability. Ensiling reduced DM and NDF rumen degradability (P<0.01). When additives were employed, the reduction of DM degradability of the silages decreased (P≤0.03). Addition of molasses led to the lowest pH (P<0.01) and DM losses (P<0.01), and highest DM degradability (P<0.01). The conservation and DM degradation results of dried molasses silage was superior to those of fresh whey silages. In general, an increase in the level of whey increased DM degradability (P≤0.03), but linearly increased effluent production (P<0.01) and losses (P<0.01).     

Effects of <Emphasis Type="Italic">Lactobacillus buchneri</Emphasis> and <Emphasis Type="Italic">Lactobacillus plantarum</Emphasis> on fermentation,aerobic stability,bacteria diversity and ruminal degradability of alfalfa silage

Silages are important feedstuffs. Homofermentative lactic acid bacterial inoculants are often used to control silage fermentation. However, some research pointed out those homofermentative lactic acid bacteria (LAB) impaired the aerobic stability of wheat, sorghum, and corn silages. Adding heterofermentative LAB can produce more acetic acid, thereby stabilizing silages during aerobic exposure. Alfalfa is difficult to ensile. The present work was to study the effects of L. buchneri (heterofermentative LAB), alone or in combination with L. plantarum (homofermentative LAB) on the fermentation, aerobic stability, bacteria diversity and ruminal degradability of alfalfa silage. After 90 days ensiling, the pH, NH₃-N/TN, butyric acid content and molds counts of control were the highest. The inoculated silages had more lactic acid, acetic acid content and more lactic acid bacteria than the control. Inoculating LAB inhibited harmful microorganisms, such as Enterobacterium and Klebsiella pneumoniae. The L. buchneri + L. plantarum-inoculated silage had more acetic acid and less yeasts than other three treatments (P < 0.05), and lower NH₃-N/TN than control (P < 0.05). The CO₂ production of L. buchneri + L. plantarum-inoculated silage was less than that of L. plantarum-inoculated silage (P < 0.05). Inoculating LAB in alfalfa silages can decrease pH, increase the production of lactic and acetic acids, reduce the number of yeasts and molds, and inhibit Enterobacterium and K. pneumoniae. Inoculating with L. buchneri or L. buchneri + L. plantarum can improve aerobic stability of alfalfa silages. A combination of L. buchneri and L. plantarum is preferable because it enhanced alfalfa silage quality and aerobic stability.     

Use of real time PCR to determine population profiles of individual species of lactic acid bacteria in alfalfa silage and stored corn stover

Real-time polymerase chain reaction (RT-PCR) was used to quantify seven species of lactic acid bacteria (LAB) in alfalfa silage prepared in the presence or absence of four commercial inoculants and in uninoculated corn stover harvested and stored under a variety of field conditions. Species-specific PCR primers were designed based on recA gene sequences. Commercial inoculants improved the quality of alfalfa silage, but species corresponding to those in the inoculants displayed variations in persistence over the next 96 h. Lactobacillus brevis was the most abundant LAB (12 to 32% of total sample DNA) in all of the alfalfa silages by 96 h. Modest populations (up to 10%) of Lactobacillus plantarum were also observed in inoculated silages. Pediococcus pentosaceus populations increased over time but did not exceed 2% of the total. Small populations (0.1 to 1%) of Lactobacillus buchneri and Lactococcus lactis were observed in all silages, while Lactobacillus pentosus and Enterococcus faecium were near or below detection limits. Corn stover generally displayed higher populations of L. plantarum and L. brevis and lower populations of other LAB species. The data illustrate the utility of RT-PCR for quantifying individual species of LAB in conserved forages prepared under a wide variety of conditions.Disclaimer: Mention of products is for informational purposes only and does not imply a recommendation or warranty by USDA over other products that may also be suitable     

Natural populations of lactic acid bacteria associated with silage fermentation as determined by phenotype, 16S ribosomal RNA and recA gene analysis

One hundred and fifty-six strains isolated from corn (Zea mays L.), forage paddy rice (Oryza sativa L.), sorghum (Sorghum bicolor L.) and alfalfa (Medicago sativa L.) silages prepared on dairy farms were screened, of which 110 isolates were considered to be lactic acid bacteria (LAB) according to their Gram-positive and catalase-negative characteristics and, mainly, the lactic acid metabolic products. These isolates were divided into eight groups (A-H) based on the following properties: morphological and biochemical characteristics, γ-aminobutyric acid production capacity, and 16S rRNA gene sequences. They were identified as Weissella cibaria (36.4%), Weissella confusa (9.1%), Leuconostoc citreum (5.3%), Leuconostoc lactis (4.9%), Leuconostoc pseudomesenteroides (8.0%), Lactococcus lactis subsp. lactis (4.5%), Lactobacillus paraplantarum (4.5%) and Lactobacillus plantarum (27.3%). W. cibaria and W. confusa were mainly present in corn silages, and L. plantarum was dominant on sorghum and forage paddy rice silages, while L. pseudomesenteroides, L. plantarum and L. paraplantarum were the dominant species in alfalfa silage. The corn, sorghum and forage paddy rice silages were well preserved with lower pH values and ammonia-N concentrations, but had higher lactic acid content, while the alfalfa silage had relatively poor quality with higher pH values and ammonia-N concentrations, and lower lactic acid content. The present study confirmed the diversity of LAB species inhabiting silages. It showed that the differing natural populations of LAB on these silages might influence fermentation quality. These results will enable future research on the relationship between LAB species and silage fermentation quality, and will enhance the screening of appropriate inoculants aimed at improving such quality.     

Screening and selection of lactic acid bacteria strains suitable for ensiling grass

AIM: Lactic acid bacteria (LAB) strains shown to have broad-spectrum antimicrobial activity were screened for potential as grass silage inoculants. The strains capable of rapidly lowering the pH of the grass matrix and with low proteolytic activity were assessed in laboratory-scale silos in a grass matrix containing natural microbial flora. METHODS AND RESULTS: Screening of nine candidate strains was performed first in a grass extract medium. The four most promising strains were selected on the basis of growth rate in the medium, capacity to reduce pH and ability to limit the formation of ammonia-N. The efficiency of the selected strains was further assessed in a laboratory-scale ensiling experiment. Untreated (no additive) and formic acid served as controls. All tested inoculants improved silage quality compared with untreated. With one exception (Pediococcus parvulus E315) the fermentation losses in the inoculated silages were even lower than in the acid-treated control silage. Pure lactic acid fermentation was obtained in the timothy-meadow fescue silage with all inoculants. The results obtained in the ensiling experiments were consistent with those of the screening procedure, which appeared to predict correctly the potential of LAB as silage inoculants. The strains with a low ammonia production rate in the grass extract medium behaved similarly in the silage. Especially in this respect the strain Lactobacillus plantarum E76 was superior to the other candidates. CONCLUSIONS: The screening method using grass extract proved to be useful in strain selection. SIGNIFICANCE AND IMPACT OF THE STUDY: The rapid screening method developed for the LAB strains provides a useful tool for more systematic product development of commercial inoculant preparations. Time consuming and laborious ensiling experiments can be limited only to the most promising strains.     

Alcoholic fermentation and its prevention by Lactobacillus buchneri in whole crop rice silage

AIMS: To evaluate the fermentation characteristics and the effects of Lactobacillus buchneri inoculation in ensiling whole crop rice. METHODS AND RESULTS: Laboratory-scale silages were prepared from whole crop rice harvested at yellow-ripe stage. The crop was ensiled for 2 months with and without inoculation of L. buchneri at 10(4), 10(5) and 10(6) CFU g(-1). The effect of prolonged ensiling was also studied by using the same crop; the silos were opened at 1, 3, 6 and 12 months, while the inoculation was made at 10(5) CFU g(-1). Enhanced alcoholic fermentation was found in untreated silage; the sum of ethanol and 2,3-butanediol were seven times higher at 2 months than those of lactic and volatile fatty acids, while the differences were diminished at 12 months owing to the reduction of ethanol in the late ensiling period. Inoculation of L. buchneri inhibited the alcohols; however, ethanol yet prevailed over the fermentation until 6 months, after which acetic acid became the main product in the inoculated silage. Regardless of inoculation and ensiling period, yeasts were not found in whole crop rice silage. CONCLUSIONS: Substantial amounts of ethanol and 2,3-butanediol would be produced in silage prepared from whole crop rice. The alcoholic fermentation can be suppressed when inoculated with L. buchneri. SIGNIFICANCE AND IMPACT OF THE STUDY: Inoculation of L. buchneri could be an option to prevent ethanol fermentation in silage.     

Diversity of a stable enrichment culture which is useful for silage inoculant and its succession in alfalfa silage

Alfalfa is a kind of forage that is difficult to ensile for good quality. Therefore, inoculants are always used to enhance the preservation of alfalfa silage. Through continuous restricted subcultivation, a lactic acid bacteria community (Al2) was selected from well-fermented alfalfa silage, which sharply decreased the pH level and produced a large amount of lactic acid. The adding of Al2 to alfalfa at ensiling resulted in a more rapid drop in pH and higher levels of lactic acid, and it also reduced the ammonia-nitrogen content significantly (P < 0.01). Plate isolation, denaturing gradient gel electrophoresis (DGGE) and the construction of a 16S rRNA gene clone library were used to identify the composition diversity of the Al2 community; seven strains were detected in the community, the predominant strain belonging to Lactobacillus plantarum. Samples of alfalfa silages of duration 0, 2, 5, 10, 20 and 30 days were studied with DGGE analysis. The DGGE band patterns of Al2-treated and non inoculated were rather different, and the components of Al2 were the dominant bacteria in Al2-treated silages, especially L. plantarum, while Pediococcus pentosaceaus was predominant in naturally fermented alfalfa silage.     

Degradability characteristics of dry matter and crude protein of forages in ruminants

Twelve corn silages, 22 grass silages and 14 grass hays, obtained from various farms located in the lower Fraser Valley region of British Columbia, and 16 alfalfa hays, grown primarily in the Columbia basin of central Washington State, were evaluated using both the rumen and the mobile nylon bag in situ techniques. Nylon bags containing each forage were incubated in duplicate for 0, 2, 4, 8, 12, 24, 48, 72, or 96 h in two of six non-lactating Holstein cows fitted with rumen and duodenal cannulae. All forage types were evaluated in terms of the following dry matter (DM) and crude protein (CP) digestion characteristics: soluble fraction A, degradable fraction B, degradation rate, lag phase, and effective degradability. The mobile nylon bag technique was used to determine intestinal disappearance of DM and CP from the forages following pre-incubation in the rumen for 12 h. Significant (P < 0.05) differences in degradation characteristics occurred within all forages with regard to the soluble and potentially degradable DM and CP fractions. Soluble CP content in the rumen varied from 44.08 to 75.37% and from 18.74 to 65.38% in the corn and grass silages, respectively, and from 48.27 to 75.43% and from 30.13 to 65.95% in the alfalfa and grass hays, respectively. Significant differences within each forage type were also observed for the degradable CP in fraction B: 10.89 to 45.28% for corn silage, 20.72 to 82.77% for grass silage, 16.67 to 44.88% for grass hay and 25.44 to 62.93% for alfalfa hays. Significant differences (P > 0.05) were observed in fractional rates of ruminal DM degradation of the grass hays and corn silages. Significant differences did exist in the fractional rates of ruminal CP degradation within all forage types with the exception of alfalfa hays. Effective degradabilities of DM and CP were also significantly different between samples of a particular forage type. The mobile nylon bag data indicated that approximately 20% of the original CP in the grass silage, grass hay and alfalfa hay samples disappeared in the intestine and that there was significant variation between individual samples. On average, in the corn silage samples more than 10% of the original nitrogenous material disappeared in the intestine. The results presented in this study clearly demonstrate that the use of tabulated values for describing individual batches of forages in terms of their degradability characteristics is inaccurate since they may not reflect the particular forage being used in the ration and thus may lead to errors in diet formulation.     

Effects of Bacillus subtilis and its metabolites on corn silage quality

Cellulolytic micro-organisms are potent silage inoculants that decrease the fibrous content in silage and increase the fibre digestibility and nutritional value of silage. This study aimed to evaluate the effects of Bacillus subtilis CCMA 0087 and its enzyme β-glucosidase on the nutritional value and aerobic stability of corn silage after 30 and 60 days of storage. We compared the results among silage without inoculant (SC) and silages inoculated with B. subtilis 8 log₁₀ CFU per kg forage (SB8), 9 log₁₀ CFU per kg forage (SB9) and 9·84 log₁₀ CFU per kg forage + β-glucosidase enzyme (SBE). No differences were observed in the levels of dry matter, crude protein and neutral detergent fibre due to the different treatments or storage times of the silos. Notably, the population of spore-forming bacteria increased in the SB9-treated silage. At 60 days of ensiling, the largest populations of lactic acid bacteria were found in silages treated with SB8 and SBE. Yeast populations were low for all silages, irrespective of the different treatments, and the presence of filamentous fungi was observed only in the SBE-treated silage. Among all silage treatments, SB9 treatment resulted in the highest aerobic stability.